2002 FORD FOCUS Fuel System Gasoline Problems

TL* THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE APPROXIMATE FAILURE MILEAGE WAS 47,000 AND THE CURRENT MILEAGE WAS 48,804. *TR

BLEW THE FUSE FROM MY FUEL PUMP UPON START UP OF CAR, NEEDED FUSE REPLACED AND GOT THE CAR TO START. HOWEVER, THE FUSE WOULD CONTINUE TO BLOW, THEREFORE NEED NEW FUEL PUMP AND FILTER. TRIED TO REPLACE THE PUMP WITH AN AFTER MARKET PART AND IT WOULDN'T FIT PROPERLY, MEANING I NEED A NEW EXPENSIVE PUMP. *KB

WHILE IDLING, MY CAR IS TURNING OFF. IT ALSO DOES SO WHEN ATTEMPTING TO ACCELERATE AFTER SHIFTING THE CAR FROM P TO D. INITIALLY THE GAS CAP LIGHT ON THE DASHBOARD SIGNALED. I REPLACED THE CAP, AND THE CHECK ENGINE LIGHT WAS ILLUMINATED AFTERWARDS. NOW, THE CAR IS TURNING OFF COMPLETELY WHILE IDLING AND ONLY THE CHECK ENGINE LIGHT IS LIT. *TR

FUEL PUMP STARTED TO CAUSE CAR TO STUTTER, STALL, COMPLETELY DIE. HAS STALLED OUT ON INTERSTATE IN HEAVY TRAFFIC, IN THE MIDDLE OF BUSY AFTERNOON 4-LANE TRAFFIC; BOTH TIMES BARELY MAKING IT OF TRAFFIC AND BEING HIT BY ONCOMING TRAFFIC W/CHILDREN IN THE CAR! CAR MANUFACTURE DATE IS 09/01 IN MEXICO. HAD FUEL PUMP REPLACE AND HAS FAILED BOTH TIMES, COST IS TOO EXPENSIVE FOR ME! ALREADY PAID OVER$1000 FOR PARTS AND LABOR! NO RECALLS ON THIS CAR REGARDING THE FUEL SYSTEM OR THE IGNITION SWITCH LOCKING UP!!! I HAVE SEEN MORE AND MORE OF THESE 2 PROBLEMS WITH THE EARLY FORD FOCUS, WHY HASN'T SOMETHING BEEN DONE YET??????? *TR

CAR WAS RUNNING FUNNY FOR ABOUT A WEEK. LEAVING A STORE PARKING LOT. I PULLED OUT ON THE HIGHWAY AND CAR STARTED MISSING REAL BAD AND STALLED. WOULD NOT START BACK UP. I HAD IT TOWED TO THE GARAGE AND WAS TOLD AFTER THEY LOOKED AT IT THAT IT NEEDED A NEW FUEL DELIVERY SYSTEM OR FUEL PUMP AND STUFF. ANOTHER KNOWN ISSUE BY FORD MOTOR COMPANY,BUT NOT FOR MY FORD FOCUS. THE GUY I PULLED OUT ON PROBABLY THOUGHT IDIOT. *TR

TL* THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO AN INDEPENDENT WHERE THE ENGINE RESTARTED. THE TECHNICIAN WAS UNABLE TO DUPLICATE THE PROBLEM. THE SIMILAR FAILURE RECURRED; ALTHOUGH THE ENGINE RESTARTED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE FUEL PUMP WOULD NEED TO BE REPLACED. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 03V482000 (FUEL SYSTEM, GASOLINE). THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 49,728.

TL*THE CONTACT OWNS A 2002 FORD FOCUS. THE CONTACT STATED THAT THE WIRES ON TOP OF THE FUEL PUMP STARTED TO MELT. AS A RESULT, THE VEHICLE WOULD INTERMITTENTLY SURGE FORWARD AND STALL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE MELTING WIRES WERE CAUSING THE FAILURE. THE FAILURE MILEAGE WAS 132,000 AND THE CURRENT MILEAGE WAS 154,000.

ON MARCH 17, 2011, MY 2002 FORD FOCUS SUDDENLY STALLED OUT AS I WAS ACCELERATING UPHILL, TURNING RIGHT ON A RAMP TO ENTER A BUSY HIGHWAY. FUEL TANK WAS ABOUT . I RESTARTED THE ENGINE A COUPLE TIMES, BUT IT STALLED OUT AGAIN AFTER A FEW SECONDS. IT WAS POTENTIALLY A DANGEROUS SITUATION, BUT LUCKILY I WAS ABLE TO ROLL THE CAR BACK DOWNHILL TO A SAFER LOCATION. (LATER I LEARNED THAT AN IDENTICAL SCENARIO IS DESCRIBED IN FORD DEALER LETTER 03N01, IN WHICH FORD AGREES TO REPLACE FUEL DELIVERY MODULES FOR 2000 AND 2001 MODELS, BUT NOT 2002.) I HAD THE CAR TOWED TO A FORD DEALER, BUT THEY WERE NOT ABLE TO LOOK AT IT TILL THE NEXT MORNING, AT WHICH TIME THE CAR STARTED FINE. FORD RAN MANY TESTS, INCLUDING ELECTRICAL AND MECHANICAL, TOOK IT OUT FOR 3 ' 4 TEST DRIVES AND COULD NOT FIND A...

2002 FORD FOCUS. CONSUMER REQUESTS REIMBURSEMENT FOR TOWING AND REPAIR EXPENSES RELATED TO PROBLEM THAT SHOULD HAVE BEEN TAKEN CARE OF UNDER RECALL. *TGW THE CONSUMER MENTIONED RECALL #03V482000 THE FUEL PUMP WAS REPLACED.

FUEL PUMP IN MY 2002 FORD FOCUS FAILED SUDDENLY AS I WAS MERGING ONTO A 50MPH HIGHWAY IN JANUARY 2010. THE CAR JUST LITERALLY DIED, WITHOUT WARNING. FUEL INTAKE STOPPED AND SO DID THE CAR. I WAS LUCKY IT WAS EARLY ON A SUNDAY MORNING AND TRAFFIC WAS LIGHT. IF I HAD BEEN IN HEAVY TRAFFIC, THIS SUDDEN FAILURE WOULD HAVE POSED A GRAVE SAFETY RISK. THE REPAIR COST $700. FORD REFUSED TO COVER ANY OF IT. IN A SEARCH OF INTERNET ARTICLES AND YOUR WEB SITE, I FOUND THIS FUEL PUMP FAILURE TO BE A WELL-DOCUMENTED PROBLEM IN 2000 - 2002 FORD FOCUS'. I AM CONCERNED THAT THEY REPLACED THE ORIGINAL DEFECTIVE PUMP WITH AN EXACT REPLICA OF THE ORIGINAL PUMP, EXPOSING ME TO CONTINUED DANGER. *TR

THE CAR STARTED TO PUTT PUTT AND THEN IT STALLED OUT I HAD A HAFL OF TANK OF GAS WHEN I HAD TO GET THIS TOWED COME TO FINE OUT THE FUEL PUMP AND FILTER WAS CLOGGED. *TR

2002 FORD FOCUS EXHIBITS ENGINE HESITATION WHEN THE FUEL TANK IS BELOW 1/4 FULL. THERE ARE ACCELERATION PROBLEMS AND THE CAR HAS COMPLETELY LOST POWER ON AT LEAST ONE OCCASION WHILE DRIVING ON THE HIGHWAY. THIS BEGAN TO HAPPEN WITH 80,000KM ON THE CAR AND NOW ALWAYS HAPPENS WHEN DRIVING AT HIGHWAY SPEEDS WITH ONLY 1/4 TANK OF GAS. COMPLAINTS TO FORD ABOUT HOW THIS IS THE EXACT SAME CONDITION THAT CAUSED THEM TO ISSUE A RECALL ON 2000 AND 2001 FOCUSES (03N01) HAVE NOT RESULTED IN ANY OFFER TO REPLACE THE FUEL PUMP FOR FREE. *TR

2002 FORD FOCUS BOUGHT THE END OF MARCH 2009, NOW SITS IN DRIVEWAY, BECAUSE FORD WILL NOT FIX FUEL DELIVERY MODULE FAILURE, BECAUSE OF VIN# NOT ON LIST AS BEING ONE OF THE 671000 UNITS AFFECTED. THE CAR IS DOING THE SAME THING AS ALL THE OTHER 671000 THAT WERE AFFECTED, SURGING, LOSS OF POWER, STALLING, HESITATION. WE WERE GOING DOWN THE ROAD, CHANGED LANES AND IT STARTED DOING THIS, NOW I HAVE HAD 3 MECHANICS WORK ON THIS CAR, NO HELP REPLACED FUEL PUMP, BATTERY, FUEL FILTER ETC, NO LUCK. IT STARTS WHEN IT WANTS WILL RUN THEN IT STARTS LOSING POWER, STALLS. WE DID EXPECT PROBLEMS WITH USED CAR, BUT NOT ONE THAT SHOULD HAVE BEEN INCLUDED IN A RECALL AND FIXED. IF ACCIDENT HAPPENS BECAUSE OF THIS PROBLEM FORD WILL BE AT FAULT. *TR

MY 2002 FORD FOCUS ZTS SUDDENLY STALLED IN HEAVY, FAST MOVING TRAFFIC. I HAD TO WRESTLE THE CAR TO THE CURB WITHOUT POWER STEERING OR POWER BRAKES WHILE AT THE SAME TIME AVOIDING TRAFFIC. I TOOK IT TO THE SHOP AND THEY SAID THE FUEL PUMP HAS FAILED AND NEEDED REPLACEMENT. TOTAL COST ESTIMATE IS NEARLY $800. THIS IS A COMMON PROBLEM IN 2001 AND 2000 MODELS AND THIS PART IS EVEN COVERED IN AN EXTENDED WARRANTY FOR THOSE YEARS. HOWEVER, THE 2002 IS NOT COVERED. I THINK THAT THIS SHOULD BE A SAFELY CONCERN FOR FORD BUT I THINK THEY ARE DOING THE BARE MINIMUM. I WILL NEVER BUY ANOTHER FORD AGAIN. NO WONDER THEY ARE HAVING SUCH DIFFICULT TIMES AT FORD! *TR

FAULTY IGNITION CYLINDER LOCK, FAILS WITHOUT WARNING. I HAD IT REPLACED 12/15/07 AND IT IS NOW DEFECTIVE AGAIN ON 4/6/09. I HAD IT FIXED LAST TIME FOR $200, BUT IT CAN COST UP TO $400. HOW THIS ISN'T A SAFETY ISSUE IS BEYOND ME. THEN AGAIN THE PINTO'S EXPLODING GAS TANK WASN'T DEEMED A "SAFETY ISSUE" BY FORD, EITHER. *TR

I PURCHASED A USED 2002 FORD FOCUS IN FL. WHILE DRIVING IT TO MY HOME IN TN, I EXPERIENCED STALLING AT HWY SPEEDS. I CHANGED THE FUEL FILTER AND CONTINUED ON MY TRIP. IT STALLED AGAIN AND WOULDN'T RESTART. I HAD IT TOWED TO A FORD DEALER THAT DIAGNOSED THE PROBLEM AS THE ALTERNATOR AND BATTERY. I REPLACED THEM BOTH. THE CAR STARTED AND I BEGAN MY TRAVEL BACK HOME. UPON MY RETURN HOME, WHEN I WOULD UTILIZE THE CAR, I WOULD EXPERIENCE STALLING UNDER VARYING CONDITIONS. I TOOK IT TO A MECHANIC WHO COULD NOT FIND THAT PROBLEM, BUT DID REPLACE THE THERMOSTAT. TYPICALLY THE CAR WOULD RUN FOR SEVERAL HOURS BEFORE THE STALLING WOULD BEGIN. I COULD USUALLY ALLOW THE ENGINE TO COOL FOR APPROXIMATELY 20-30 MINUTES AND THE CAR WOULD START. I COULD DRIVE FOR APPROXIMATELY 15 MINUTES BEFORE IT WOULD STALL AGAIN. MY LATEST EXPERIENCE HAPPENED...

I DRIVE A 2002 FORD FOCUS WAGON, MILEAGE 85,578. TWO DAYS AGO I HAD TROUBLE STARTING IT. I DID GET IT STARTED BUT EVERYTIME I TOOK MY FOOT OFF THE ACCELERATOR THE ENGINE STALL. THERE WAS NO CHECK ENGINE LIGHT WARNING PRIOR TO THIS OR DURING THE EVENT. I WAS ABLE TO DRIVE MY CAR HOME, BUT HAD TO RESTART IT EACH TIME I HAD TO STOP. THE NEXT MORNING IT DROVE FINE BUT I TOOK IT TO A FORD DEALER FOR DIAGNOSIS AND REPAIR. I WAS TOLD IT WAS A FUEL PUMP FAILURE AND IT COST ME OVER A $1000 FOR REPAIR. (PARTS LISTER WERE SENDER, GASKET, KIT, TUBE, GASKET, FILTER). IN RESEARCHING RECALLS I FOUND THAT MODEL YEARS 2000-2001 WERE HAVING THIS EXACT SAME PROBLEMS AND A RECALL WAS DETERMINED FOR THIS. I DO NORMAL DRIVING - 70% HIGHWAY, 30% IN TOWN. MY CAR IS JUST OVER 5...

DRIVING MY 2002 ZX5 FORD FOCUS AROUND PITTSBURGH, WITH LESS THAN A 1/4 TANK THE ENGINE STARTED STUTTERING. THEN THE CAR STALLED. I TURNED IT BACK ON AND DROVE ABOUT A 1/4 MILE WHEN IT STARTED STUTTERING AND SHAKING PRETTY BAD AGAIN. WHEN I TRIED TO ACCELERATE, THERE WAS NO POWER AND THE ENGINE STALLED AGAIN. I WAITED A LITTLE BEFORE TURNING IT BACK ON. IT DID THE SAME THING TWICE MORE; ONCE IT STALLED WHEN I WAS DOING A LEFT TURN AT A BUSY TRAFFIC INTERSECTION AND THE OTHER WHILE DRIVING DOWN A CROWDED AVENUE. FORTUNATELY I WAS ABLE TO MAKE THE 2-HOUR TRIP BACK HOME WITHOUT ANY INCIDENTS. I TOOK IT TO THE FORD DEALERSHIP IN MY TOWN AND THEY TOLD ME THEY NEEDED TO REPLACE THE FUEL PUMP, FUEL FILTER AND ALSO PERFORM A FUEL FLUSH. THE TOTAL COST IS ROUGHLY $600.00. I HAVE BEEN LOOKING IN...

I HAVE 2002 FORD FOCUS SE THAT CUTS OUT AND STALLS WHILE MAKING RIGHT HAND TURNS. I TOOK TO THE DEALER 18 MONTHS AGO AND THEY COULDN'T FIND ANYTHING WRONG. NOW IT IS DOING IT 5 TIMES A DAY AND OTHER FOCUS OWNERS ARE SAYING THAT THEIRS CUTS OUT AS WELL. FORD HAS NO TSB THAT I COULD FIND FOR IT BUT IT IS VERY. *NM

OUR 2002 FORD FOCUS STALLS, HESITATES AROUND 1/4 OF A TANK. SYMPTOMS SIMILAR TO FUEL DELIVERY MODULE COMPLAINT OF PREVIOUS YEAR MODELS. *NM

CAR IS STALLING AND DYING WHEN STOPPED. WILL NOT IDLE PROPERLY. HAVE REPLACE BOTH SPARK PLUGS AND PLUG WIRES EVEN THOUGH ONLY HAVE 36K MILES ON THE CAR. ONLY THING DIAGNOSTIC TEST SHOW IS THE FUEL IS TOO LEAN. I AM ASSUMING THAT I WILL HAVE TO REPLACE THE FUEL FILTER SINCE FORD WILL NOT INCLUDE THE 2002 MODELS EVEN THOUGH THEY ARE HAVING THE SAME PROBLEMS AS EARLIER MODELS. *JB

TRANSMISSION WENT OUT 2 TIMES IN 1 YEAR. DRIVER AIRBAG SHIFTED ON ITS OWN. REAR PASSENGER DOOR DOES NOT UNLOCK/OPEN. FRONT BALL JOINT CRACKED. GAS COVER/DOOR FELL OFF. THE SMELL OF GAS INSIDE CAR AT ALL TIMES. BLINKER WOULD NOT TURN OFF BY ITSELF. KEY CHIME GOES OFF WHEN THE KEY IS OUT. *JB

FUEL PUMP WAS REPLACED TWICE FROM JANUARY TO JUNE STERRING WHEEL AND CAR SHAKE WHILE STOPPING AND DRIVING AT 50 MPH OR ABOVE BRAKES HAVE BEEN CHECKED 3 TIMES FINALLY HAD REPLACED AND ROTORS, NO CHANGE IN PERFORMANCE

THERE IS A LINE THAT WENT STRAIGHT INTO THE ENGINE'S INTAKE THAT HAS BEEN LEAKING FLUID SINCE 2,000 MILES AND WAS INSPECTED BY DELER WHO TOLD TO ME THAT IT WAS NOTHING. BUT THE ENGINE CASE SHOULD NOT HAVE A LARGE LEAK OF FLUID THAT SOON. FINALLY NOW, THEY HAVE DONE SOMETHING ON THIS AND REPLACED THE HOSE, AS IT WAS SEEN ONCE MORE AND KNOWS OF ALL THE TIMES REPORTED. I HOPE THIS IS JUST NOT A EASY FIX OR THIS NOW HASN'T CAUSED ANY DAMANGE TO THE INSIDE OF THE ENGINE ITSELF, AS THE ENGINE HAS BEEN IN THE SHOP FOR RIDING ROUGH. THEY TOLD ME LAST TIME THAT THE PART OF THE TRANSMISSION THAT WAS FIXED WOULD FIX THIS. I THINK IT IS DUE TO THE OIL LEAK ON THE TOP OF THE ENGINE CASE SINCE IT WAS NEW. A NEW CAR SHOULD NEVER HAVE A OIL...

I PURCHASED A 2002 FORD FOCUS SE. AT 10,956 MILES I HAD TO REPLACE THE FRONT BRAKES. I WAS BILLED 256.06 FOR THIS REPAIR. I ALSO HAD A WATER LEAK THAT OCCURRED ON THE FRONT PASSENGER SIDE. THE LEAK WAS FIXED. THE PROBLEM WAS SAID TO BE THE POLLEN FILTER. THE CENTER CONSOLE WAS LOOSE, THAT WAS ALSO FIXED ASAP. AND LASTLY THE FUEL ECONOMY IS FAR FROM WHAT FORD CLAIMS IT TO BE. PLEASE VISIT WWW.FORDFOCUSBRAKEPROBLEMS.COM FOR MORE INFO. *JB

VEHICLE SMELLS LIKE GAS. DEALER NOTIFIED. PH

OWNERS MANUAL STATES THAT VEHICLE SHOULD GET 26 GALLONS IN CITY AND 32 ON HIGHWAY. HOWEVER,VEHICLE GETS 18 GALLONS IN CITY. CONSUMER FEELS THE INFORMATION IS INCORRECT IN OWNERS MANUAL. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK