2004 FORD F-250 SD Suspension Problems

FRONT END SHAKES VIOLENTLY AFTER HITTING A ROUGH SPOT ON PAVEMENT AT HIGHWAY SPEED. CONTINUES UNTIL SPEED IS REDUCED TO LESS THAN 50 MPH. THERE ARE SEVERAL OTHER COMPLAINTS ON YOUR DATABASE FOR THE SAME PROBLEM, SO WHY ISN'T SOMETHING BEING DONE ABOUT IT? THIS IS A VERY SERIOUS ISSUE. MY WIFE WOULD NOT HAVE BEEN ABLE TO HANDLE THIS HAPPENING TO HER. THIS HAPPENED ONCE BEFORE ABOUT A YEAR AGO AND I HAD THE TRUCK CHECKED, BUT NOTHING COULD BE FOUND. EVEN THOUGH IT'S TEN YEARS OLD, TRUCK ONLY HAS A LITTLE OVER 24,000 MILES. *TR

TL* THE CONTACT OWNS A 2004 FORD F-250 SD. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STARTING BOUNCING ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAILURE WAS UNABLE TO BE DUPLICATED. THE CONTACT MENTIONED THAT THE VEHICLE WAS TAKEN FOR DIAGNOSTIC TESTING ON SEVERAL OCCASIONS FOR THE SAME FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 180,000. *TR

TRAVELING AT REGULAR MOTORWAY SPEEDS (55 - 70) THE TRUCK VIBRATES VIOLENTLY AND CONSTANTLY. IT STOPS ONCE THE VEHICLE SLOWS TO BELOW 30MPH. I HAVE CHECKED OTHER COMPLAINTS AND WILL BE CHECKING TIRE PRESSURE AND SEEING IT A STEERING DAMPENER CAN BE ADDED. THIS VEHICLE WAS UNLOADED AT THE TIME OF THE INCIDENT AND HAD ABOUT 1/2 A TANK OF FUEL ON BOARD. *TR

VEHICLE SHIMMY AND SHAKE, STEERING WHEEL OSCILLATION STARTS AT APPROX. 50 MPH AFTER GOING OVER SLIGHT BUMP IN ROADWAY. CONTINUES UNTIL BRAKES ARE APPLIED AND SPEED IS REDUCED TO UNDER 45 MPH. *TR

MY 2004 F250 2WD SUPERDUTY PICKUP SHAKES VIOLENTLY WHENEVER I HIT THE SMALLEST POTHOLE OR DRIVE OVER RAILROAD TRACKS. THIS CAUSED MY RIGHT TIE ROD TO SEPARATE AND RUN THREE PEOPLE OFF THE ROAD. AFTER NEW TIE RODS THE PROBLEM STILL EXIST. THIS TRUCK ONLY HAS 81,000 MILES ON IT .NO ONE HAS ANY EXPLANATION AS TO WHAT TO DO TO FIX THIS OTHER THAN AN AFTER MARKET STEERING STABILIZER. SHOULDN'T FORD BE RESPONSIBLE FOR THIS FIX BEFORE SOMEONE GETS KILLED? *TR

DT*: THE CONTACT STATED WHILE TRAVELING 65 MPH, A VIBRATION WAS FELT FROM THE STEERING WHEEL ALONG WITH THE FRONT AND REAR OF THE VEHICLE. THE SERVICE DEALER AND MANUFACTURER REPLACED THE ENTIRE FRONT END, ALL AXLES, ROTORS, RING AND PINION AND WHEEL HUBS, BUT THE VIBRATION CONTINUED. THE MANUFACTURER HAD AN ENGINEER TEST THE VEHICLE AND FOUND THE VIBRATION TO BE WITHIN OPERATING STANDARDS.*AK THE FUEL LIGHT ILLUMINATED, THE CENTER CONSOLE SQUEAKED, THE LOWER BALL JOINTS WERE REPLACED. UPDATED 11/21/06. *JB