2004 FORD F-250 SD Engine And Engine Coolingexhaust System Problems

MY 2004 F-250 DIESEL, 79,292 MILES, HAS BEEN AT THE LOCAL FORD DEALERSHIP SINCE SEPT. 7TH. THERE ARE SO MANY DIESELS BROKEN DOWN, MINE DID NOT GET PULLED INTO THE BAY FOR WORK UNTIL THE LAST WEEK IN OCT. IT IS STILL IN THE BAY WAITING AN ENGINE AS OF NOV. 11TH. OVER 2 MONTHS IN THE SHOP. THEY CHANGED THE OIL PRIOR TO DIAGNOSING BLOWN HEAD GASKETS AND OVER BOOSTING TURBO, SO THEY COULD NOT CONFIRM IF WATER WAS IN THE OIL PAN. DIAGNOSES WAS TO REPLACE THE HEAD BOLTS, GASKETS, EGR COOLER, REBUILD AN OVER BOOSTING TURBO, AT A COST OF ABOUT $3,000.00. AFTER THE HEADS WERE DEEMED UNUSABLE, MUCH PITTING, CORROSION OF THE HEAD WHERE THE CYLINDER IMPRINT IS LOCATED, THE COST WENT TO $7,5000. SINCE THEY FAILED TO INSPECT THE OIL FOR COOLANT, I HAD LITTLE ALTERNATIVE THAN TO REQUEST AN ENTIRE ENGINE, AT A COST...

TL*THE CONTACT OWNS A 2004 FORD F250 SUPERDUTY. WHILE DRIVING UPHILL AT 35 MPH, THE VEHICLE SUDDENLY LOST POWER. AFTER SHIFTING IN AND OUT OF GEAR, THE VEHICLE STALLED TWO TO THREE TIMES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE EGC COOLER WAS REPROGRAMMED BECAUSE IT OVERHEATED AFTER PULLING A LOAD UPHILL. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY WOULD DECIDE WHETHER THEY WOULD COVER THE REPAIR COSTS AND GET BACK WITH HIM. THE FAILURE MILEAGE WAS APPROXIMATELY 10,000. THE CURRENT MILEAGE WAS APPROXIMATELY 60,000.

FICM ON MY 6.0 SUPER DUTY IS CAUSING RUNNING PROBLEMS THIS IS JUST ANOTHER IN A LONG LIST OF ISSUES FORD IS AWARE OF, IF THE TRUCK WAS TO STOP RUNNING DURING FREEWAY SPEEDS THIS MAY CAUSE SERIOUS INJURY TO MY FAMILY DUE TO LOSS OF BRAKING AND STEERING. I USE THIS TRUCK TO TOW A TRAVEL TRAILER AND AT THIS TIME I DO NOT FEEL THIS TRUCK IS SAFE ENOUGH TO DO THIS. THE LOCAL DEALER WANTS $1200.00+ TO REPAIR THIS WELL KNOWN PROBLEM. I AM NOT IN THE POSITION TO REPLACE THIS VEHICLE. OTHER PROBLEMS REPLACED 4 EGR IN 50,000 MILES. *TR

I HAVE A 2004 FORD F250 SUPER DUTY WITH A 6.0 DIESEL. THE EGR COOLER WAS REPLACE TWICE UNDER WARRANTY AND WITH THE TRUCK NOW OUT OF WARRANTY WITH 111,000 MILES ON IT, THE EGR COOLER WENT OUT ONCE MORE AND FORD WOULD NOT HELP ME OUT ON THE REPAIR SO I HAD TO PAY FOR IT MYSELF. THERE IS A HUGE PROBLEM WITH THE 2003 THROUGH 2005 6.0 DIESEL. IT HAS HAPPENED TO THOUSANDS OF OWNER. OWNERS OF THESE VEHICLES ARE BEING FORCED TO BYPASS THE EGR COOLER, THERE BY MAKING IT INOPERABLE. THIS IS IN VIOLATION OF EPA STANDARDS AND FORD SHOULD BE FORCED BY THE GOVERNMENT TO RECALL THESE VEHICLES AND REPAIR THEM RIGHT. THIS IS NOT ONLY A FAIRNESS ISSUE; IT IS A CLEAN AIR SAFETY ISSUE. *TR

2004 F250 SUPER DUTY / ENGINE CHOKES DOWN AND SOMETIMES STALLS. HAPPENS OFTEN, MOSTLY IN CITY TRAFFIC. THEY CLAIM TO HAVE REPLACED SENSORS AND VALVES; BUT, THE TRUCK HAS PROGRESSIVELY GOT WORSE (2-3 TIMES A WEEK). *TR