2018 FORD F-150 Structurebody Problems

Tried to open door to put my 2 year old in her car seat and it wouldn't open, assume this was due to the extreme cold. So I took our other vehicle, few days later when it warmed up I again went to leave with my daughter and this time the door opened but will no longer latch shut. Tried toggling child lock messing with lock mechanism on top of the door Tried both interior and exterior handles but it will not latch no matter what I do. Now all my lights are staying on and door ajar light and icon are on and won't go off. I currently have the door ratchet strapped inside the vehicle to hold it close and I cannot drive it due to the safety concerns if the strap let's loose and the door flings open... There is a recall for frozen door mechanism my...

Tailgate opened

In cold weather all four vehicle doors would open randomly when driving, forcing occupants to manually hold them shut. Owner found recall 18N03 was active for vehicle and took the vehicle to Ford dealership for service of recall. The issue continued after service and the owner inspected vehicle following the recall procedure distribution from NHTSA to discover the dealership partially and incorrectly completed the work listed. Additionally, recall 18N03 refers to recall 17S33 for the rear doors in super cab models. This vehicle has water shields from 17S33 installed but the rear door latches are still unreliable in cold weather.

Door latches freeze, and door won’t stay closed. Operator must drive while holding the door shut. Super-unsafe.

Tailgate latch fails and the gate opens while driving. This happened to me and I lost part of my load on the road causing a dangerous situation to other vehicles I can also lose valuable items or they could get damaged. I notified the dealership about this on two occasions and was told that there was no recall on the 2018 but other years were covered .

Door Latch Freezing during cold winter months(every year) where temperatures drop below 32°F even after Ford Recall done on both front door latches. Inability to open door, then after door opened there is an Inability for door to latch until it warmed up.

Pant is flaking off roof and tail gate in 1/8 to 1/4 inch pieces. Offord white paint. Clearly a manufacturing defect . 2018 F150 has approx. 27,000 miles on it, Filed a claim with ford dealer Gosch in Murrieta Ca 92563.

The doors do not close when cold i have to use the seatbelt to rap around doors to keep them shut. I have brought to ford multiple times no fix. The transmission erratically shifts through multiple gears and downshifts into low gears when at high rate of speed. Which i have been told is due to a faulty cdf drum in transmission that ford wont take responsibility for. It is a very dangerous vehicle

Door latching system is often inoperable when temperatures are below freezing. The door will not latch and must be held close while driving. Vehicle has been repaired once by dealer per bulletin 18N03 but the problem persists.

The doors do not properly latch in cold weather. Yes available for inspection. The door came open while we driving down the road. The dash light came on indicating door was ajar. Door was not able to be closed after repeated attempts of closing. Passenger has to hold the door closed. Same occurrence happened to the driver side door and it would not latch so the vehicle couldn’t be used that day otherwise driver would have to hold door closed.

Doors will not latch in temps below 30degrees F.

Rear doors get frozen and will not latch to stay shut. My daughter almost flew out of the vehicle when we went around a corner. I literally had to turn the heat on high hood the door closed for 30 minutes to get it warm enough to latch and stay shut. This is usually following a car wash within a 7 day span. I am not sure how there cannot be a recall for this. Everyone that I know with an F150 has had the same issues.

At cold temperatures driver side door will not latch.

Driver door cable sticking open when low temps occur. Driver door does not latch until vehicle is locked or key is inserted into door and manually positioned or key fob is used to lock the vehicle.

tailgate latch does not work all the time . sometimes just drops open when driving.

THE PASSENGER BACK DOOR LATCH, SOMETIMES WHEN THE DOOR CLOSES IT SAYS REAR RIGHT DOOR AJAR. IT TAKES A FEW TIMES TO OPEN AND CLOSE IT FOR THE LIGHT TO GO OFF.. NOONE'S SAFETY HAS BEEN PUT AT RISK YET DOOR STILL LOCKS BUT COULD BECOME UNSAFE OVER TIME. THE VEHICLES HAS NOT BEEN INSPECTED BY MANUFACTURER OR INSURANCE OR OTHERS YET. THE DOOR LIGHT COMES ON IF DOOR IS NOT CLOSED PROPERLY AND WILL STAY ON SOMETIMES.

The door latches was not latching in cold weather until they are warmed up and then they latch. It is a safety thing for me and my kids and wife.

Took my vehicle to ford dealership to have leaking sunroof checked, had it repaired for broken track, but the amazing things was the price that ford charge me for the repair of the sunroof track which was $5507.49, wasn’t really told why it cost me so much being that it’s a 2018. I do have the receipt, and has been trying to find a lawyer to try and recover some of my losses. Please let me know what I should do about this repair

Tailgate keeps falling down while traveling down the road. This has happened several times. This time after it hit the trailer after backing it up at the end of the trip.

The tailgate on my truck has opened while driving down the road. This has happened several times since I have owned the truck. There are several recalls for 2018 F 150 tailgate issues. I have taken it to the Ford dealer, but was told there is no recall on trucks in my VIN range.

Door lock freezing recall, still freezes. After performing this recall for my door latches freezing, they still freeze. Once I get them open, the door will not latch shut and I would have to drive while holding the door shut until it unfreezes. Forums verify that I am not the only one with doors still freezing after recall. I am confident the recall was performed correctly, but fords fix is not a proper fix and I am still left with frozen door latches in an unsafe vehicle.

The hood latch has failed on my ford F-150. My security system alarms when it happens. It has happened while I have driven and during times when there are changes in temperature. When searching for this, I came across a number of others that have had similar issues with their ford F150/ F250s and Expeditions. I am surprised ford has not recalled it due safety hazard of a failing hood latch. Additionally the main horn has failed. Again searching has found that other people with similar models and years from ford have the same issue with the horn. Both are safety concerns.

when the temp outside is below freezing the driver-side door will not latch shut and the doors will not lock.

Passenger door actuator would not reingange the door after opening. Temperature was around 15 Farenheit for awhile. Door opened with some effort, but would not latch back. If vehicle was in motion door would need to be held to prevent opening. The vehicle could be locked for the door to stay in place, but it would not sit flush with the body of the vehicle.

Tailgate actuator sometimes does not open completely. Pressin the button engages the operation, I can hear it trying to unlatch, but the tailgate does not completely release. If the tailgate is not in use for awhile, opens as intended for few times.

Doors keep freezing and they won't stay shut when you drive if it gets below 25 degrees

This is the 6th winter I have had my truck. Every winter, the door locks freeze to the point the doors won't close. I have called ford, they have replaced the door locks. The problem still persists. I went to warm them up with a torch today to get them working again. I left and once again the door flew open under braking. I have called ford on this, they need to fix it before something really bad happens. This has happened at least once every winter. I am afraid to drive the thing when it freezes for fear of the doors flying open. the only warning lamp happens once the door is open. It won't go into gear. That's great and all but it doesn't let me know when the door may be compromised due to freezing. The dealer and ford have both confirmed this a known problem. I...

Frozen door latches. When its cold and you open the door, then close the door it does not latch.

The vehicle as of 12/9/2023 at 3:19pm CST is at a mileage of 79,523. Around the time we bought out the lease on our truck in April 2021, we reported to the dealership that the tailgate latch on occasion would not latch. They did a repair for it, but it has happened a few times since. We saw a recall notice for other Ford F-150 models from 2018 that had issues with latches/linkages/locks on the tailgate where the tailgate would become unlatched like ours.

The vehicle as of 12/9/2023 at 3:27pm CST is at a mileage of 79,528. We reported to the dealership in April 2021 and services prior to April 2021 that the sunroof would randomly become misaligned with the sunroof track when opening. There will be excessive noise coming from the sunroof when it’s misaligned. We are concerned that there might be a larger problem with potential exposed areas/leaks when that is misaligned. We feel strongly that it is either the alignment (misalignment) of the panels, an issue with the track, or an issue with the brackets. It was brought into the dealership, and they said they fixed it, but it continues to happen.

Once the temperature drops below freezing, the door latches will quit working. If I open the door then it will not latch when I try to close the door. This has happened every winter since i have owned the truck. I have taken it into the dealer multiple times for this issue. I believe they even replaced the door latches on one of the occasions but now that it is winter again this year they are not latching when I close the door. This has happened on the front and rear door latches. There must be an issue inherent with the design if they did replace the latches and I'm still having trouble. I believe they need to look at a redesign.

The twin panel sunroof has water leaks threw the factory installed rivets on the rail causing electrical shortages and which can lead to a fire hazard water and electrical do not mix ford needs to redesign these sunroof rails to prevent water from seeping threw the cracks of the factory installed rivets

Any time that temps fall below freezing one or multiple doors may fail to re latch shut after opening. I am worried that if that is the case then if they do latch shut could they fail and the door re open mid drive anyways? Seems to me this is a very common ford issue starting back in 2015 but a recall has not been issued, only a customer service thing where they "fix" the issue with more people then not stating that the "fix" does not fix it at all

All doors have this issue during cold weather. The doors fail to latch or the doors fail to open. When the doors fail to latch I close the door thinking it is safely closed; however, the door latch fails to engage allowing the door to open while driving. This happened while a child was in the back seat and caused a very distressing hazard. I had to tie the door shut with a bungee cord. Other time the door latch will fail to disengage when operating the door handle both interior and exterior door handles. This is also very dangerous because it effectively lock a person in the vehicle preventing escape for any peril. I have learned that NHTSA already recalled this issue for 2015 to 2017 models and it appears that Ford has stuck their middle finger at NHTSA because they continue to use the faulty equipment. Much of...

3 out of 4 doors locks do not work. If you search recalls for 2015 - 2017 Ford F150's, it is doing the same thing.

Driver door swung open while driving and then would not stay latched. Door frequently will not latch.

Drivers side door will not latch closed AND OPEN WHILE DRIVING

In freezing weather, the door latches freeze and the door cannot be closed. There is a recall for this issue, #19N06 however it does not work. I had the recall performed then a week later when the weather changed, I am unable to close my door. This is a major safety issue because the driver has to hold the door or strap the door shut while driving and there is also the risk of it not being truly latched and swinging open while moving. Ford provides the one time recall however, in my case this seems to do nothing. I have had the vehicle in to Ford and they claim this is all the recall does to fix it and the rest of the time/labor they spend will be out of my pocket. There are no indicator lights prior to failure, it is strictly due to below freezing weather.

The rear passenger side door did not latch. My 6 month old son could have fell out because his car seat is on that side. Luckily I noticed it when I was backing out of the driveway and not on the expressway. I pulled back into the drive way and tried to shut the door about 30 times. It would not shut. All the other doors worked fine. The only way to keep the door shut was to hold the door shut and lock the truck. After I did that my door would not unlock. It tried doing it manually but it was stuck in the lock position. It seems something is wrong with the door latch and I am glad that I caught it or my baby could have gotten hurt. The door latches in the truck have to be looked at. I just bought this truck from a...

Frozen door latch,unable to close or lock,must hold door closed with one hand while steering with the other hand,extremly unsafe!!!

After loading groceries into the rear seats, I shut the passenger door and thought it was latched. I started to drive off and the door came open. I spent 20 mins trying to get it to latch and although I could move the door latch mechanism with my fingers, the door would not latch and remain shut. I ended up tying the door shut in order to drive home 7 miles.

We were driving and another car told us our tailgate was down. We did not put anything into the truck before we started our drive and no buttons were pushed. The tailgate went back up without incident, however there was also no indication from inside the truck that the tailgate was down.

The truck was sitting in the driveway and out of nowhere the alarm went off. Go out to inspect and the vehicle is showing that the driver and left back door are not closed. The driver side door will not latch it opened up out of nowhere and will not latch. Apparently this issue is know with Ford trucks when it gets too cold. This is a safety issue because the door will just open while driving.

Drivers door fails to latch, appears to be similar to Freezing issue on NHTSA Recall ID: 17V652000.

Vehicle had electrical issues - Diagnosis by dealership was water damage to the Body Control Module. This module is inside the cabin on the front passenger area by their feet/legs. The issues included - flashers goin off, horn going off, truck bed gate dropping open - while parked and while driving down highway, and entire vehicle just shutting down while ALL of the issues happened at once. People have been put at risk by the gate dropping and the immediate shut down of an operating vehicle. The dealer was able to reproduce the problem. I had it happen twice. I have since identified that it is something that is a known issue on F150 forums. So much so that the likely cause of the water damage has been identified, and forwarded to the manufacturer. They are not fixing the issue. Manufacturer's dealership technician identified the water damage as the root...

The driver's door freezes, so once the door is opened it will not latch closed until the door is warmed up. Additionally, the door can catch when closed, but if any pressure is put on the door, it pops open because the latch or mechanism is frozen and will not function properly. This has happened multiple times now, and Ford has stated that we don't live in a 'cold' climate region, so the can not get the cold weather 'repair' to fix this issue. I believe this is a significant safety issue, I can't drive the vehicle until the weather warms up so the door latch will work again.

Tailgate opens while driving and has occurred many times.

This F150 developed an annoying whistling wind noise at around 50MPH and higher. I cannot be sure but I think it's originating from the windshield area. Owned this vehicle since new and now has 22,000 miles.

Condensation from evaporator drain is leaking into cab, which has created mold, exposing myself and any passengers riding in my vehicle including my kids. Ford issued TSB 19-2345 to fix this issue but it does not work and they are not willing to replace the molded carpet under a field service action. This is a known design flaw that should be fixed as soon as possible to prevent mold growth. If mold is found, carpet should be replaced immediately due to the health hazards associated with mold in an enclosed vehicle. Ford should be held liable to fix these issues without any charge to the customer.

In freezing/wintertime conditions drive side door latch freezes open and the door will not remain closed while driving. Problem remains until the truck warms up. Previous recall to fix issue did not resolve the problem. Dealer has no current fix for the problem other than to tell me it’s a known issue.