2018 FORD F-150 Fuelpropulsion System Problems

I own a 2018 Ford F-150, with the Cougar V-8 and a turbocharger. A few years ago, while on the expressway, I had to accelerate to clear a dangerous situation. A message came up on the instrument cluster saying that I was seriously low on oil. I pulled off on the shoulder and shut the engine off. I checked the oil level and it was almost empty. The truck only had about 10,000 miles on it at the time. I had checked the level prior to leaving and it was full. Luckily, I carry extra oil on long trips, a habit I got into back when I used to drive beaters. I had enough oil to fill the engine back up with oil and proceed on my way. I have not had any oil loss since then, although I rarely drive the truck, except to pick up lumber or other...

I was not in an accident. I have a 2018 ford f150 xlt and it has a 3.5 eco boost. My truck is leaking some type of oil from the top and has very bad fuel injectors which is why my truck cant accelerate and shakes extremely bad. When I sit at a red light my truck dies and I think i have a leaking exhaust. I bought a new battery but it still dies. I know they used to do a recall for a new engine from what i’ve searched but they don’t do it anymore and I don't think its safe for me driving while I have all those problems. I have not been in an accident but with all these problems my truck could possibly die or go out while i’m on the highway and just makes me nervous driving something like that when the 3.5 eco...

The vehicle experienced repeated failures involving multiple systems, including the transmission system (transmission replacement), powertrain/engine system (cylinder-related repairs), electronic control systems (vehicle computer/control module replaced multiple times), electrical system (ongoing electrical faults), and rear safety systems (backup camera failure). The vehicle is available for inspection upon request. These failures created ongoing safety concerns due to loss of vehicle reliability and malfunction of safety-related electrical systems, raising concern about unexpected mechanical or electrical failure during operation. The issues were confirmed and documented by Ford-authorized dealerships and independent service centers. Despite repeated repairs, the same or related problems continued to occur. The vehicle was inspected and repaired by Ford dealerships; however, one servicing dealership (Ford of Ventura) later closed, leaving unresolved issues without continuity of service. Warning lights and system alerts occurred prior to failures along with ongoing electrical malfunctions. Exact dates of first warning indicators are UNKNOWN, but symptoms recurred over...

Ford F150 2.7L Ecoboost was running fine. Went to dealer for PCM recall and 3 days later check engine light came on. Went back to the dealer and they say I have a PO430 code now and that I need a catalytic converter at the tune of $3000. Of course I am 8000 miles over the factory warranty of 80000 miles and the extended warranty I bought does not cover it. Seems not right. Is the any help with this issue? Shouldn't Ford be responsible?

When cold starting the engine, a rattling sound occurs caused by the cam phasers not aligning properly. My research shows that Ford claims this is not an issue, and has never issued a recall for this, however, I am worried that continued use might damage the engine further.

After Ford performed a PCM (Powertrain Control Module) reprogramming recall on 16 July 2025, the vehicle began experiencing repeated engine misfires, loss of power, and engine warning lights. The condition progressively worsened, leading to a leaking fuel injector, an EGR valve that stuck open, and eventual internal engine damage requiring full engine replacement. These failures involve PCM-controlled systems (ignition timing, fuel injection, and exhaust gas recirculation) and occurred shortly after the recall calibration. The issue has been confirmed and documented by an authorized Ford dealer. The truck has become unsafe to drive due to stalling and shuddering at highway speeds, which could pose a risk of loss of vehicle control. Warning lamps and a wrench icon appeared intermittently before the engine shuttering and loss of power. The vehicle and all repair documentation are available for inspection upon request.

The brake system on my 2018 Ford F-150 2.7L EcoBoost began failing around early 2025 with a brake warning light illuminating and the pedal feeling soft, signaling a problem. The brake fluid reservoir dropped low repeatedly despite topping it off multiple times with DOT 3 fluid, indicating a persistent leak. By 09:52 AM CDT today, September 10, 2025, the brake pedal lost all pressure, making the vehicle completely undrivable and posing a severe safety risk due to significantly increased stopping distances and potential brake failure. At 10:37 AM CDT, thick white smoke started billowing from the exhaust each time the vehicle was started, likely from brake fluid leaking into the engine via the brake booster, a symptom matching Ford recall 25S37 (NHTSA 25V236) for a defective brake master cylinder seal. This failure endangers the driver, passengers, and other road users, as the truck is a primary vehicle, with the smoke...

My vehicle (2018 Ford F150) is presenting with the same issues the 2021- 2023 ford an Lincoln models regarding the fuel system with my truck sputtering in 7th and 8th gears and stalling. It has stalled a few times in the past few months. The spark plugs have been changed, purple fuel styrene cleaner has been used regularly, filters changed, basically all trouble shooting has been done with no significant change. Maybe there are others who are experiencing the same out there. My vehicle is well maintained, in fact I just put upwards to $8k into it this year.

While driving to Sam’s Club (approximately 20 miles from home), my 2018 Ford F-150 3.5L EcoBoost began running very rough, and the check engine light came on. I had the vehicle scanned, and diagnostics confirmed that the cam phasers are failing — the exact issue I had replaced under warranty at approximately 59,000 miles. The vehicle now has just 88,000 miles, and this failure occurred in under 30,000 miles since the original repair. I have maintained this truck with extreme care. I only use Motorcraft parts and fluids, change the oil every 3,000 miles or sooner, and always use premium fuel. This is not a maintenance issue. This is a design or part failure that Ford has not properly resolved. When the phasers were replaced the first time, I was told there was no warranty on the replacement parts. That is unacceptable. A known failure being replaced with an equally...

In November of 2024, my truck was shaking, accelerating erratically, and felt like the transmission was slipping. The check engine light came on as well. I took it to the shop and after diagnosing that it was a misfire issue in cylinder 6, they replaced spark plugs, fuel injectors, and tried to switch out new coils. They found gasoline inside cylinder 6, and upon doing a compression test, it was well below 100%. The truck continued to have misfires in cylinder 6, ultimately leading to 0% compression in that cylinder after taking it back to the same authorship to diagnose. After researching online forums and technical bulletins, it’s clear this issue is not uncommon among 2.7L EcoBoost engines from this model year, suggesting a manufacturer defect. The cost to replace the engine (as now recommended) has been estimated at nearly $10,000. With the history of regular oil and maintenance by...

I just had to replace my fuel pump due to sudden failure. It was repaired this month at Crossroads Ford of Wake Forest NC. I as well the dealer have the receipts for the repair cost. I believe it should be included in the current recall just issued by Ford and be reimbursed.

Vehicle is shuddering as acceleration starts, took to dealership before warranty ended and they dismissed concerns. Issue has intermittently persisted since then with no resolution available from dealership. The acceleration issues causes the vehicle to slow down and halt before jerking into motion again. Additionally the engine eco boost is occasionally shutting the vehicle off in traffic, if the brake is released too quickly with the boost feature on the engine shuts off, you have to put it back in park and then start the engine again. I've almost been rear ended twice when a light turns green and my engine turns off unexpectedly.

In December 2024 I had a massive fuel leak in my system. I drove into my driveway and my neighbor said they could smell gasoline. I look and fuel was leaking onto the ground. If there was a spark It would have explodes into flames. I took it to my dealer and the diagnostic was a squirrel has chewed a hole in the fuel line because it is coated or made from a soy-based product, and it drawls rodents by its sweet smell and taste. I have spent over $3000 to replace the line because they didn't get it corrected the first time and had to replace the whole system again. I am eliminating the squirrel problem to prevent this happening again but it's not a guarantee and this fuel line material should not be make with a soy-based product.

Hello, I hope this message finds you well. I am writing to follow up on an ongoing issue with my vehicle related to the recall 21B10. I recently purchased a 2018 F150 in November 2024, and I’ve encountered significant problems with the vehicle that I believe are tied to the recall. Specifically, the vehicle is experiencing issues with acceleration, which has made it unsafe to drive, especially on the interstate. When I took my vehicle to Ford in Mooresville, NC, they diagnosed the problem as an error code 21B10. Upon contacting Ford on March 28, 2025, I was informed that the recall had been addressed in February 2022. However, I was advised that the case cannot be reopened, and that it would need to go for review. Given the critical nature of the issue I am experiencing, I am concerned about my safety while driving the vehicle. The acceleration problems...

This has now happened 8+ times. While traveling on the highway towing either a boat or trailer, my engine shuts down. This has happened at 75 mph. The error code :Auto StartStop Shift to P, then Restart Engine" displays on the instrument panel. Power steering does not work, steering becomes quite difficult. I have found several other instances of this same issue in Ford forums. So... at 75mph, on a highway, I lost all power 3-5 times in one trip. Each time I coasted to the safety strip, put the truck in park, and restarted. Several times the vehicle would not restart immediately. I pulled off the highway and did some research and disables the Auto Start/Stop feature, which seemed to alleviate the issue. Unfortunately I cannot permanently disable the feature. I did stop at a Ford dealership and showed them a picture of the error code. The dealership did...

The cam phasers on my 2018 Ford F-150 Raptor are failing now as I hear rattles on a cold start from the engine, which has then been proved out by technicians at the Autonation dealership here in Frisco, Texas. They are suggesting full replacement for all the phasers which causes major safety concerns. I use my car to drop my [XXX] son at daycare every day and drive 30 miles each way to work. I know that Ford offered customer satisfaction program for 2018 manufactured F-150s but somehow the recall doesn't apply to my vehicle. The repair costs are $6k quoted by the dealership I mentioned and it is simply too expensive for us to be able to afford. Therefore, I was wondering if you could please add this recall to my VIN which will allow me to get this safety concern resolved at a Ford dealership. I would really...

We received a recall letter for Emission recall dealing with the system reading that the catalytic converter is bad. We had this happen a year ago, and had to have the catalytic converter replaced because it was showing it was bad. This recall letter says that it will show it’s bad, but may not be bad. We spent almost $3000 because we live in a state with inspections. This letter shows that it was the computer that messed up. We are trying to deal with Ford to see if we can get reimbursed since there’s a recall on the chip. The recall is emission recall 24E12. The work wouldn’t have needed done if the chip wouldn’t had shown the catalytic converter was bad.

Powertrain control module software is faulty, causing improper diagnosis of catalytic converters efficiency. Prompting a check engine light and P0430/P0420 code. I could not pass emissions testing with this code. The Ford dealer made me pay out of pocket to replace catalytic converters ~6 months ago, total cost of $2975.12. The have now addressed that it is unlikely the catalytic converters were faulty, and are offering no reimbursement.

The Cam phasers on this vehicle are defective. This will be my third cam phasers in less than 3 years. The Cam Phasers cause the emissions to fail and can also cause unsafe driving such as the first time they failed while driving on the highway. I have brought this to the attention of the dealership numerous times and they say they can't duplicate it, even though it makes the noise when turning on the car or idling every time. They finally admitted this past visit to the Mall of Georgia Ford that it is an issue and a known recurring issue with this vehicle. I see the issue reported online, Ford Facebook pages, blogs, etc with thousands of people experiencing the same unsafe issue with both emissions and driving safety. Please advise.

My truck stopped in the middle of an intersection and would not crank again. The fuel pump had exploded on the inside and metal shavings were found all throughout my fuel system. The cost to repair my truck was $ 11,867.60 plus tax. From what I have been told, this is an ongoing problem that occurs with this specific fuel pump. I was told from the service manager at the dealership that he sees this problem all the time. I was told from the claim adjuster that this is a problem with all Ford and Chevrolet trucks with diesel engines that use this specific fuel pump. I believe this should be a recall since it is a problem with any diesel that not only Ford but Chevrolet makes. I did file this with my insurance company but it was not covered. My claim # with Farm Bureau is 10000600403. My...

My truck started having issue(s) accelerating properly on-time over the past few months. The issue was only intermittent and occurred sometimes when needing to accelerate quickly in certain scenarios such as turning onto a busy road or merging in high traffic. It would also sometimes downshift very hard when driving at moderate speeds ~40 - 50 mph, and jarred the vehicle so hard it felt like the engine was going to drop out of the truck. The acceleration issue resulted in several incidents in which I was in danger of being struck by other drivers for being momentarily "dead in the water", but the worst incident occurred when I was attempting to merge into a left lane (9/11/2024) during rush hour in front of an on-coming dump truck; my truck did not accelerate AT ALL and the dump truck had to slam on his breaks and swerve out of the...

I was driving, I looked down because my truck was unresponsive, my truck had died, a warning light had come on stating the following: "Auto Start/Stop Shift to P, then Restart Engine". I was on the interstate, in a two lane construction zone, I had to pull over into the construction area, stop my truck, and try and restart. After a minute or two, I was able to restart my truck and re-enter the road way. A very dangerous situation, luckily I did not have my children in the vehicle at the time. I scheduled a service appointment after this and was told it was the fuel pump control module. Unfortunately, it has happened twice since my service appointment... something needs to me done!

Unknown my truck was running rough so took it to shoo they ran the codes told me CPS camshaft position sensor bank 2 was coding so replaced all 4 sensors but was still having issues and then truck started having a rattle but not all the time it would come and go then the shop said replace spark plugs so I did then rattle got worse but would go away when came to stop sign. During all of this I was using alot of oil 1 qt about every 3000 to 5000 miles then the truck started having noisy start up that went away after couple seconds loss of power poor fuel economy and the rattle was more constant oil levels checked daily and were good but yesterday the day after an oil.change and my truck lost power when depressed the gas pedal I continued to lose speed and then...

I on a trip [XXX] round trip is about 332 miles. I had approximately 42 miles to go and the truck speed was reduced and it started to jerk. This is the second trip over two hundred miles and the same thing happened. have extended warranty insurance but I can’t get any one to accept it here in Cleveland, Mississippi. I really think this truck is a lemon. I purchased it last year in November and it’s been giving me problems ever since then. I don’t have money to just give away on something that is not worth it. I even went to the dealer where I bought the truck and asked him if I could swap out for another truck and he told me he couldn’t do it. When I checked on car fax it just shows that this truck had 126 ,000miles on it. But at the dealership...

Been having this issue for months. Go to hit the gas to go from a stop truck shutters and hastates to move. No check engine light has come on. Thought it was the fuel we put in it but no matter what fuel it still does it. Almost have been hit a dozen times with my children in the truck with me due to truck will not Accelerate and shutters when you go to take off from a stop. Even when putting the vehicle into sports mode and hit the gas, the truck hesitates and shutters as well. Been to repair shops and they stated they can't find anything wrong with it due to no check engine light being on.

The 2018 Ford F150 truck came with a cap less fuel fill. What seals the fuel refill area is the gas cap door. The door is equipped with a seal on the gas cap door for when the door is closed, it keeps the weather elements from entering into the gas fill area that is equipped with a cap less mechanism for the gas tank filling. The hinge spring on the door is of poor quality and design and the swivel pin that holds the gas cap door in place fails by the pin working out of place. This now causes the gas cap door to not fully close allowing weather elements to make their way into the cap less gas fill tube. From internet research, this is a common problem with the 2018 F150, as well as other years with this type of cap less gas door. I had...

see NTSHA report of technical service bulletin. This describes exactly the issue. As a result, the timing chain has been diagnosed as stretched due to the cam phaser issue. From what I understand, the safety concern is that the timing chain, if left undiagnosed/unrepaired can cause engine failure, loss of control etc. Ford has attempted to fix the VCT (Variable camshaft timing. [XXX] . the below is Ford's TSB issued 04May2023 TECHNICAL SERVICE BULLETIN 3.5L EcoBoost - Cold Start Ticking/Tapping/Rattle With Possible No Restart During Auto-Start-Stop Operation 23-2143 04 May 2023 This bulletin supersedes 22-2200. Model: Ford 2018-2020 Expedition Built on or before 30-Nov-2019 2017-2020 F-150 Engine: 3.5L EcoBoost Built on or before 30-Nov-2019 Lincoln 2018-2020 Navigator Built on or before 30-Nov-2019 Summary This article supersedes TSB 22-2200 to update the production fix date, Action statement and customer symptom. NOTE: Certain parts may now be reused for this repair. Refer...

While driving my truck along the highway on April 29, 2024, it spontaneously burst into flames. I pulled it over, and it was completely engulfed in flames and melted into a puddle of molten aluminum. In the last 18 month, this truck has spent over 45 days at the dealership with 10 separate repairs including transmission replacement, cylinder heads, oil leaks, all under 75,000 miles. The smoke and smell began under the back seat passenger floorboards, and within 45 seconds, was burning. I have pictures, video, witnesses, and police reports for corroboration. There was no accident, no impact, no nothing. It simply lit itself on fire.

Mechanical fuel pump exploding

Plastic connector that connects the stainless steel fuel line to a plastic fuel line failed while I was driving. Fuel was sprayed over the undercarriage and exhaust system. The truck came to a stop on the road when I slowed down but continued to leak fuel. Approximately 15 gallons of fuel was lost. There were no warnings other than the smell of gasoline. I will be taking the vehicle along with the failed connector which I removed to the dealership on Tuesday,

Fuel injector failure

I was pulling out into 4 lanes of traffic and the truck shut off. Dash had message "Auto StartStop Shift to P, then Restart Engine". I am stuck blocking 4 lanes of traffic on a busy street with cars coming fast. I put in park and restarted the engine. It died and gave the same message 4 more times. Finally revved the engine way up and was able to move the truck. It died twice while approaching the next stop sign even though Auto Start/Stop was disabled. Revved engine and was able to make it to the Ford dealer who had no one available to assess the problem. Several people suggested replacing the battery. I put in a new battery and reset the battery monitoring system. The problem still persists. Slamming a dead pickup into park in the middle of 4 lanes of oncoming traffic is most definitely a safety...

This 2018 F150 developed a cranking noise when starting the engine. Dealership tried two software upgrades per manufacturer notices to solve the issue. The issue was not solved and was said to be Cam Phasers need to be replaced. Manufacturer internal document to dealer stated that driving the vehicle with this problem would not cause any problems and is safe to drive. Dealership had been waiting months for parts. Set-up for an appointment was for later this month, but last month while driving on the Interstate the engine light which was on from the engine issue but a new light, the wrench light came on with the engine light flashing. All power was being lost and had to dodge other vehicles to move over to emergency lane as I had no control of the vehicle. While waiting 12 hours for a tow, I had researched this issue online and found...

I put the truck in park and left it idle with the air conditioning on for a passenger got out to go do something for a few minutes and the truck just started have flames come out of it from the middle of the truck until the truck completely burned the fire started with the truck running and idling and the the truck was parked on gravel

TRUCK WILL STALL WHILE TOWING WHEN COMING TO A STOP AT EXIT. WILL NOT RESTART EASILY. PUT TRUCK IN PARK, CRANK TILL STARTS, REV ENGINE AND SHIFT INTO DRIVE AND KEEP RPMS UP TO DRIVE AWAY. WILL HAPPEN AGAIN AFTER STOPPING FOR GAS. WHILE TOWING , I WILL FUEL AT THE HALF TANK LEVEL. IT HAPPENS A LOT ON HOT DAYS. USUALLY AFTER ABOUT 2 HOURS + OF DRIVING . NO CODES THROWN AT ANY TIME. DEALER CAN NOT FIND ISSUE. THIS HAS HAPPENED FOR 2 YEARS.

AFTER TOWING FOR AN HOUR OR MORE, PULLING INTO GAS STATION, LOW RPM, ENGINE STOPS, AUTO START.STOP WARNING COMES ON, ASKED TO PUT IN PARK AND RESTART ---I HAVE TO REV GAS TO KEEP STARTED--ONLY WHEN TOWING FOR AWHILE

SMELL OF GASOLINE IN PASSENGER CABIN AFTER DRIVING AND HEATER ON (STATIONARY). STARTED IN MARCH. DEALER ATTEMPTED A REPAIR WHICH HELPED. NOW WITH COLD WEATHER AND HEATER ON AGAIN THE PROBLEM HAS RETURNED VERY BADLY.

I WAS DRIVING OUT OF A GAS STATION AND THE AUTO STOP START WARNING CAME ON AS I WAS ACCELERATING AND LOST ALL POWER STEERING AND I WAS ABLE TO COAST AWAY FROM TRAFFIC. I HAD TO PUT IT IN PARK AND RESTART THE ENGINE. I HAVE NO IDEA WHAT CAUSED THIS ISSUE AS I PUT WELL OVER 400 MILES A WEEK ON MY TRUCK AND THIS WAS THE FIRST ACURRANCE.

I KEEP GETTING THE CHECK ENGINE LIGHT P2450 WHICH IS AN EMISSION VALVE IN THE FUEL TANK. I TAKE IT IN AN ALL THEY DO IS RESET THE CHECK ENGINE LIGHT!

TRANSMISSION IS NOT SMOOTH WHEN SHIFTING. MAKES LOUD CLUNKING SOUNDS AND SHUDDERS.

STALLS WHILE MERGING WITH TRAFFIC. THEN RPMS RAISE AND TRUCK SLAMS VIOLENTLY INTO GEAR. EXTREMELY UNSAFE! NUMEROUS COMPLAINTS TO FORD. TO NO AVAIL. PLEASE HELP!

WHEN FUELING THE FUEL NOZZLE BECAME STUCK IN THE CAPLESS FUEL SYSTEM. WHEN WE FINALLY GOT THE NOZZLE OUT (AFTER 15 MINUTES) THE FLAP WAS BROKEN. WE TOOK IT TO FORD DEALERSHIP AND THEY SAID IT WAS NOT COVERED UNDER WARRANTY DUE TO PEOPLE SHOVING THE BIGGER DIESEL NOZZLES IN, THIS WAS A REGULAR AUTO DIESEL NOZZLE THAT WAS USED.

IN PARK AND TRUCK ROLLS,AND THE TRANSMISSION IS SEVERLY SLIPPING,AND SMELLS LIKE GAS

ON INITIAL STARTUP, FUEL LINE BURST DIRECTLY UNDER DRIVERS SIDE, SPRAYED FUEL ALL OVER TRANSFER CASE/POWERTRAIN ELECTRONICS. FIRE DEPT CAME TO ENSURE SAFETY, VEHICLE WAS TOWED TO LOCAL FORD DEALER. VEHICLE CURRENTLY HAS ~11K MI

MY TRUCK HAS 15,000 MILES ON IT. THE ACCELERATION WILL RUN AWAY FREQUENTLY (PRESS THE PEDAL AND THERE IS A SEVERE LAG AND LACK OF POWER). THERE WILL BE RANDOM ENGINE NOISE WHEN DECELERATING AROUND 45 MILES PER HOUR. ALSO, ACCELERATION WILL BE ROUGH WHEN GOING FROM 20-30 MILES PER HOUR JUST BEFORE THE IT SHIFTS INTO A HIGHER GEAR. I TOOK THIS TO THE FORD DEALER AND THEY SAID THERE ARE NO ERROR CODES ON THE TRUCKS COMPUTER SYSTEM. ALSO, THE STEERING WILL BE STIFF OR UNALIGNED AT RANDOM TIMES. PLEASE ASSIST IN GETTING THESE ISSUES CORRECTED.

NO POWER WHEN ACCELERATING FROM A STOPPED POSITION AND IN MOTION. HIGH PRESSURE FUEL PUMP CRACKED AND BOLT SECURING THE PUMP WAS SHEARED.

THE ENGINE SOMETIMES STUMBLES ON LIGHT ACCELERATION LIKE IT IS STARVING FOR FUEL. I HIT THE GAS, THE ENGINE STARTS TO RESPOND, THEN ACTS LIKE IT IS GOING TO STALL. I LET OFF THE GAS AND HIT IT AGAIN, SAME THING. I HAVE TRAVELED AS MUCH AS 500 FT. BEFORE THE ENGINE RESPONDS PROPERLY. DEALER CAN'T FIND ANYTHING, AS IT IS RANDOM AND DOESN'T PRODUCE A FAULT CODE. DOESN'T MATTER IF THE ENGINE IS HOT OR COLD. HAPPENED NUMEROUS TIMES. DANGEROUS SITUATION. IT HAS HAPPENED IN HEAVY TRAFFIC AND WHEN I JUST PULLED OUT OF THE GARAGE.

VEHICLE STALLS WHENEVER COMING TO A STOP AFTER TOWING FOR MORE THAN AN HOUR. REQUIRES THE VEHICLE TO BE PLACED IN PARK TO RESTART, BUT WILL CONTINUE TO STALL OUT IMMEDIATELY. DANGEROUS AT INTERSECTIONS AND STOP-AND-GO TRAFFIC. ALSO STALLS (WHEN TOWING) WHEN ATTEMPTING TO RESTART AFTER REFUELLING. ONLY WAY TO GET THE VEHICLE TO START WITHOUT STALLING IT TO KEEP THE GAS PEDAL PRESSED TO KEEP THE RPM ABOVE 1500; OR WAIT 10-15 MINS FOR ENGINE TO COOL. NO CHECK ENGINE/COMPUTER SYSTEM ERROR GIVEN AT ALL. ONLY STALLS WHEN VEHICLE HAS BEEN TOWING OVER A LONG DISTANCE. OCCURRED 20+ TIMES A DAY OVER THE COURSE OF TRAVELING ACROSS THE US AND CANADA IN JULY/AUGUST 2018. TOOK THE VEHICLE INTO FORD SERVICE CENTER IN LONGMONT, CO, BUT WERE UNABLE TO DIAGNOSE WITH NO CODE. I AM SEEING MORE AND MORE REPORTS OF THE SAME PROBLEM OCCURRING WITH 2018 FORD F-150 2.7L...

I HAVE HAD TWO RUN AWAY FULL ACCELERATIONS IN THIS NEW TRUCK. I ACCELERATED FIRMLY AND THE ACCELERATOR REFUSED TO DISENGAGE. AT OVER 90 MPHM I PUT THE CAR IN NEUTRAL, THE RPM INCREASED AND I SHUT OFF THE KEY. NEXT TIME IN THE SAME DRIVE IT HAPPENED AGAIN AND I IMMEDIATELY SHUT OFF THE KEY. I WILL NOTIFY MY DEALER TOMORROW. I WILL NOT DRIVE IN THIS VEHICLE AGAIN. AS AN EXPERIENCED COMMERCIAL PILOT I HAVE BEEN TRAINED HOW TO DEAL WITH THIS ISSUE BUT THE PUBLIC HAS NO CLUE WHAT TO DO.

SAME ISSUES I'M READING HERE. VEHICLE FREQUENTLY MAKES A LOUD BANG WHEN STARTED. SHIFTS GEARS EXTREMELY ROUGH TO THE POINT WHERE YOU'RE JERKED AROUND. NO POWER WHEN TRYING TO ACCELERATE FROM A STOP WHICH IS EXTREMELY DANGEROUS WHEN CARS ARE BEHIND YOU OR TRYING TO ACCELERATE MERGING ONTO THE FREEWAY. MY TRUCK HAS BEEN TO DEALER TWICE NOW. THE FIRST TIME IT WAS BECAUSE MY FUEL INJECTOR WENT OUT AT 4,500 MILES! IT DOESN'T RUN MUCH BETTER NOW. WHEN I TOOK IT IN THEY JUST BLEW ME OFF AND SAID IT WAS 'NORMAL BEHAVIOR FOR THE VEHICLE'. READING ALL THESE ISSUES HERE, FORD REALLY NEEDS TO TAKE ACTION! EXTREMELY DANGEROUS!!