2018 FORD F-150 Electrical System Problems

According to repairman, water made it into the rear tail light, shorting out a module that controls all lights, windows, a/c and heating controls.

Sync screen, music, and charging are all dead. I think it’s the apid

Backup camera shows blue screen. Appears to be faulty wiring harness or connection. Impacted driver safety when backing up. Previously replaced camera due to suspected camera failure. Fix lasted less than a year before blue screen returned. No other warnings or indications.

This vehicle has the 10R80 10 speed transmission, the same transmission that is in the Mustang that is under recall now. That was reset at a Ford dealership in 2023 I believe. It was not acting up at that time, they "fixed" it then while it was in. Now a few years later this problem is VERY PERSISTANT now, constantly missing, skipping, and losing power trying to accelerate trying to get on to busy roads and highways, it loses power and skips through all the gears from 1st to 10th back down to 4, then 6 then 2 then back to 9 and 10. I have almost been hit numerous times from this action. It is also causing the dash lights to turn off and come back on. Also effecting my 4 wheel drive, it will not engage. This should be a SAFTEY RECALL and Ford needs to take of...

I was not in an accident. I have a 2018 ford f150 xlt and it has a 3.5 eco boost. My truck is leaking some type of oil from the top and has very bad fuel injectors which is why my truck cant accelerate and shakes extremely bad. When I sit at a red light my truck dies and I think i have a leaking exhaust. I bought a new battery but it still dies. I know they used to do a recall for a new engine from what i’ve searched but they don’t do it anymore and I don't think its safe for me driving while I have all those problems. I have not been in an accident but with all these problems my truck could possibly die or go out while i’m on the highway and just makes me nervous driving something like that when the 3.5 eco...

Taillight leaks water causing the blindspot sensor to burn up. Once the sensor is burned up the airbags, power door locks, power windows, heat/defrost, and the radio don't work. This is a known problem and Ford has no fix for it. It is several weeks wait to get it into Ford and costs several thousand dollars for a known problem that they are not addressing. Having no heat or defrosters in the winter make this a safety issue for everyone on the road not just the operator. Door locks and windows not working is a safety issue for the vehicle passengers.

The vehicle experienced repeated failures involving multiple systems, including the transmission system (transmission replacement), powertrain/engine system (cylinder-related repairs), electronic control systems (vehicle computer/control module replaced multiple times), electrical system (ongoing electrical faults), and rear safety systems (backup camera failure). The vehicle is available for inspection upon request. These failures created ongoing safety concerns due to loss of vehicle reliability and malfunction of safety-related electrical systems, raising concern about unexpected mechanical or electrical failure during operation. The issues were confirmed and documented by Ford-authorized dealerships and independent service centers. Despite repeated repairs, the same or related problems continued to occur. The vehicle was inspected and repaired by Ford dealerships; however, one servicing dealership (Ford of Ventura) later closed, leaving unresolved issues without continuity of service. Warning lights and system alerts occurred prior to failures along with ongoing electrical malfunctions. Exact dates of first warning indicators are UNKNOWN, but symptoms recurred over...

Water intrusion into the Body Control Module (BCM) caused multiple safety-related electrical failures. The horn no longer functions, traction control activates and deactivates while driving, exterior lights remain on after vehicle shutdown, and the battery must be disconnected to turn off headlights. The issue presents a safety concern while operating the vehicle. Ford Motor Company was notified and documented the concern but declined assistance due to no active recall or program.

The day running lights don’t work at all and researching online there are hundreds if not thousands of people with similar issues. F150’s 2015-2020 having the same problem. This is not caused by misuse or neglect but factory defective components. These headlight are almost $1400

-Auto stop/start system failed and is available for inspection. I was driving down the road and braked for a vehicle about to pull in front of me, when I let off the brake and pushed the gas I noticed the vehicle had shut off there was an error message on the information center, Error message: "Auto startstop shift to P, then restart engine" -I could've been in an accident due to immobilized vehicle -Vehicle taken to dealer. Was told the failure was unlikely to be duplicated. Was told to unplug(deactivate) auto stop/start system to hopefully avoid recurrence. -No -No messages or symptoms prior to failure.

Was listening to my radio in my 2018 f150 1min and the next the music stopped my phone stopped charging touch screen went black tried the soft reset nothing checked fuses nothing . Found out it’s my apim Ive also seen where a lot of people are saying they have had the same issue with this and it’s not a cheap fix one guy said he works at ford and done 15 in one day . Ford is suppose to be the best why isn’t there a recall on these . 98k miles and I have to spend $500-$1000 to be able to use my touch screen this is not right for anyone and this should be on ford . Believe I might be switching over to dodge now.

Back up camera stopped working on 2018 F150 XLT 2.7 v6. Screen only shows blank screen or blue screen with the words, cameral not available.

My back up camera just shows blue or static. It just randomly happened but everything else works and the screen shows fine when not in reverse.

Auto start stop. This has happened on several occasions where I will be traveling at highway speeds and my 2018 F-150 10 speed 10R80 Transmisson with a 5.0-liter motor has died while traveling. I have talked to Ford Engineering reps, and they say they have never heard of this. I have done research into the subject and there have been hundreds of reports of the same issue. I have an appointment scheduled for Ford to look into the issue.

Loss of power to dashboard and all accessories while driving. The engine and transmission continued to operate until the vehicle could be parked in a safe location, and the vehicle could not be started again. The issue was reproduced by a dealership and repaired by changing a faulty APIM module. No other inspections have been performed. After the repairs, the security alarm randomly engages and sounds the horn.

The contact owns a 2018 Ford F-150. The contact stated that while driving at various speeds, the transmission shifted to neutral(N) unintendedly, and the vehicle lost motive power. The power train warning light was illuminated. No further information was available. Additionally, the contact stated that electronic system and lights failed to turn off. The contact confirmed that the VIN was not included in a recall and that the warranty had expired. The contact stated that there were complaints and lawsuits related to the failure. The contact stated that the body control module (BCM) was previously repaired. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 84,019.

The contact owns a 2018 Ford F-150. The contact stated while depressing the accelerator pedal, the gear shifter shifted independently, and the message "Vehicle Heisted Gear Ten Error" was displayed. The vehicle was not diagnosed or repaired by the dealer or an independent mechanic. The manufacturer was notified of the failure and referred the contact to the NHTSA to file a vehicle safety complaint. The approximate failure mileage was 52,742.

When backing up, my camera will either not work or be extremely slow. Then once it works the backup image or blank screen will show up when not in reverse. My screen will be blank, be extremely slow, or freeze when I turn the vehicle on or when driving. Unable to get CarPlay to work at all. When pushing buttons the lag time is so bad that it will take minutes for it to catch up. Unable to update the software.

I had a rear view camera problem where the screen went blue on my f150. No picture or beeps. I paid over $800 for software and hardware repairs and now there is a recall. Conveniently my vin is not included even though I have the same repairs I had to pay for. Reciepts from Ford Dealership available.

SYNC seems to return to factory setting at every start and I need to answer the same series of initial questions to access it. It dumps all of my saved preferences when I turn the truck off. It freezes, particularly when I try a manual soft reboot. Back up camera comes on while I'm driving. I don't have access to audio, navigation, or hands free support.

The radio goes black giving no indication to why and no way to adjust the heated steering wheel or the climate controls.

The button on the steering wheel get hot then fail to work this has happened several times i have complained to ford. The cruise control quits working and all the buttons for the dash menu quit working. I will be driving down the road with the cruise control on and all of a sudden it will quit working. Then it will just come back on like you never shut it off and when you least expect it. when this happens you can not shut the thing off its gonna cause an accident.

My back up camera barely works now. Most of the times that I back up the screen is blue or black. Very rarely it will work. I brought it into my local for dealer and they said moisture somehow got into the sealed connector and started corroding the metal in there making it a bad connection. They told me I needed a new wire harness for over $500 and I don’t have the money to fix it. So now my back up camera is just broke.

The engine system on this vehicle experienced multiple failures, including severe knocking, power loss, and potential oil-related malfunctions. Despite repeated service visits to the authorized Ford dealership, the problem persisted. The dealership performed multiple repairs, but the issue was never fully resolved. The vehicle has been undrivable for over a year, during which I have had to rely on rental cars, borrowed vehicles, and eventually purchased cash vehicles to commute — all while continuing to pay for the truck. This is a severe financial and safety burden for a vehicle sold as reliable. To this day, no clear resolution has been offered, and Ford’s internal support has repeatedly deflected responsibility or referred me to scripted call center processes. The vehicle remains parked, unable to be driven due to fear of catastrophic failure or causing harm to myself or others on the road. The engine should be fully inspected, and the...

The contact owns a 2018 Ford F-150. The contact stated while the vehicle was parked, the radio and the rearview camera was inoperative. No warning lights were illuminated. The vehicle was taken to a dealer to be diagnosed. The diagnostic result was unavailable. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 120,000.

See attached document for complaint.

I had repeated issues with sudden downshifts while driving starting around 80,000 miles. By 83,000 miles it was doing it weekly or more frequently. It would shift down to first gear no matter what gear it was in. I would have trouble getting it to shift back even if I stopped and turned it off or tried the manual’s “fix” of pressing the brake and accelerator pedals at the same time for at least 30 seconds. I paid $2300 to fix a transmission barely past 80,000 miles. Besides the safety issue, the impact on daily life in general is a mess. Ford should have to recall all recent years and fix or repay the customers like me who had to pay Ford to fix their defects.

The contact owns a 2018 Ford F-150. The contact stated that after stopping the vehicle, the vehicle would not immediately restart. Also, while at a stoplight with the Auto START/STOP feature activated, the vehicle did not immediately restart after depressing the brake pedal, and the vehicle had to be jump-started. The vehicle was taken to the local dealer, who indicated that there was no issue with the battery and was unable to determine the cause of the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 102,602.

While driving in manual mode on the road vehicle seemingly came out of gear and then slammed into a lower gear causing me to be slammed forward in my seat and nearly wrecked my vehicle, it then unprotected went to 1st then to 9the gear all while still in manual shift mode. Vehicle also dose not always fully engage park when P is illuminated.

The same problem that is highlighted with the 1.3 million Ford F-150 truck investigation for the 2015 - 2017 models has happened to me. In 2024 my Ford F-150 would switch from 10th to 3rd gear without warning. This has lead to the transmission completely failing. I had to personally replace the transmission myself. I had just went over the warranty mileage. The incident was reported to Ford but nothing was done about it. At the machenic repair shop there were 2 other Ford F-150 that had the same problem.

When I tow my boat the starter overheats and when I stop to get gas I have trouble starting the engine or it won't start at all until the engine cools completely.

Radio went out not long after I bought it. Nothing on that end works. No back up camera, nothing. Bad apim module. 1400 to replace. It’s such a common issue and should be a recall.

Powertrain control module software is faulty, causing improper diagnosis of catalytic converters efficiency. Prompting a check engine light and P0430/P0420 code. I could not pass emissions testing with this code. The Ford dealer made me pay out of pocket to replace catalytic converters ~6 months ago, total cost of $2975.12. The have now addressed that it is unlikely the catalytic converters were faulty, and are offering no reimbursement.

THE PASSENGER BACK DOOR LATCH, SOMETIMES WHEN THE DOOR CLOSES IT SAYS REAR RIGHT DOOR AJAR. IT TAKES A FEW TIMES TO OPEN AND CLOSE IT FOR THE LIGHT TO GO OFF.. NOONE'S SAFETY HAS BEEN PUT AT RISK YET DOOR STILL LOCKS BUT COULD BECOME UNSAFE OVER TIME. THE VEHICLES HAS NOT BEEN INSPECTED BY MANUFACTURER OR INSURANCE OR OTHERS YET. THE DOOR LIGHT COMES ON IF DOOR IS NOT CLOSED PROPERLY AND WILL STAY ON SOMETIMES.

Accessory protocol image module (APIM) failed, resulting in frequent loss of power to radio, display, and climate controls.

The Starter on my 2018 Ford F150 XTR (XLT trim to be sold new in Canada) with the 5.0L Coyote V8 engine failed @ only 46,000 miles. I have done my own auto repair for years, and have replaced a few failed or failing starters, none of which were @ less than 100,000 miles. After a little research, I found out that Ford "created" their Coyote engine with the Auto Stop/Start feature as a fuel economy measure to satisfy USEPA. However, this resulted in a several orders of magnitude increase in the number of starts within any given time frame (say, over the course of a year) and, since Ford did not re-design the starter to account for this radical increase in the sheer number of starts, starters are failing early. Mine failed @ 46,000 miles, and I've read multiple online posts from owners of this engine that had to...

I was driving, I looked down because my truck was unresponsive, my truck had died, a warning light had come on stating the following: "Auto Start/Stop Shift to P, then Restart Engine". I was on the interstate, in a two lane construction zone, I had to pull over into the construction area, stop my truck, and try and restart. After a minute or two, I was able to restart my truck and re-enter the road way. A very dangerous situation, luckily I did not have my children in the vehicle at the time. I scheduled a service appointment after this and was told it was the fuel pump control module. Unfortunately, it has happened twice since my service appointment... something needs to me done!

The vehicle was stopped, preparing to make a left-hand turn at a four-way intersection, in Drive with my foot on the brake. I had manually pressed the button to disable the "Auto Start-Stop" feature earlier in this trip, and the light was on indicating that feature was still disabled. While stopped, the vehicle's engine suddenly shut off. On the dashboard, the informational cluster indicated "Auto StartStop Shift to P, then Restart Engine" with the logo for that feature (An "A" in a looped arrow icon) showing below. I shifted to Neutral and restarted the vehicle with no issue - at which time the warning messages went away - and continued the drive without further incident. I have not been able to reproduce the issue, yet. I was in the vehicle with my 1-year-old son in his car seat, preparing to make a left turn across oncoming traffic when the vehicle...

10 Speen Auto Transmission is shifting very hard from 1-2 or just skips 2 and goes 1-3. It shifted so hard this morning it chirped the tires. Other times it jolts me forward. When trying to accelerate it will not and almost feels like its going to stall. Almost got rear-ended one morning with my son in the truck. It is scheduled to go to dealership in 2 weeks (next opening). No warnings lights yet. Started about a week ago. Only getting worst each morning.

The alarm system and hazards will randomly go on and will not turn off until you start vehicle and hit the hazard light button. If you hit the hazard button while the vehicle is off, it does not turn the hazards off. They will often remain flashing even if the horn/alarm system isn't blaring. At times hitting the hazard button has made the horn go off. The truck has started locking itself and keypad will not work to unlock only the key fob. Truck has not been driven at night since this has occurred to notice if its affecting the headlights. We have noticed that it is also affecting the cabin climate controls (air conditioning/heat). The source of the problem appears to be a malfunction with the Body Control Module (BCM). Prior to these issues arising, there were no warning or messages that appeared on the dash. The truck has...

When the auto stop/start feature is engaged at a stop and I am the first vehicle at the light or stop sign, the steering is unresponsive when making a turn into or through the intersection after the auto start re-engages and has posed a safety issue steering/turning because of the delay that occurs in powering the power steering pump. On repeated instances, I have entered an intersection making a turn expecting the steering to be powered, only to find I have to struggle with the steering manually until the pump engages. The first time I asked the dealer to check the issue, I was told that my battery was dead and I had to buy a new one. I was told that would take care of the problem. The problem returned, however, and I took the truck back to the dealer. During the second dealer visit, I was told that...

I was driving on a congested thoroughfare during rush hour on a Friday night. My truck became unresponsive and the steering wheel locked up. The truck made a screeching stop. With over 100 cars behind me honking. I was unable to drive car off the road shoulder in a safe location. The cars electrical system when dead. With very limited battery life on my phone, I worked to to solve this problem. Luckily I had a few tools in the truck and was able to dismantle the all of the underdash plastic and metal components in about 1 hr with cachophany of honking and yelling with ever car. No stopped to help. I had to push the vehicle approx a quarter of a mile on a moderate incline and jump in the cab without power steering and coast down a side street. I had to learn how to put the...

Since purchasing the vehicle the infotainment system has and always been substandard. Which is very frustration when your purchasing a new truck. There seem to be many glitches to the system and never reacted the same way twice when I had to reprogram it every time I got into the vehicle. It became an unreliable way to communicate and very unsafe. I felt very insecure using the system knowing that I would have to readjust or touch the infotainment to make it work had to pull over on the side of the road a lot. I believe that this product is completely faulty and could have been a fatal flaw for Many f150 drivers.

While driving my truck along the highway on April 29, 2024, it spontaneously burst into flames. I pulled it over, and it was completely engulfed in flames and melted into a puddle of molten aluminum. In the last 18 month, this truck has spent over 45 days at the dealership with 10 separate repairs including transmission replacement, cylinder heads, oil leaks, all under 75,000 miles. The smoke and smell began under the back seat passenger floorboards, and within 45 seconds, was burning. I have pictures, video, witnesses, and police reports for corroboration. There was no accident, no impact, no nothing. It simply lit itself on fire.

I was riding down the road the truck started to run hot then it slammed on brakes the power steering went out the panel the instrument panel was black I couldn't roll my windows down the truck was in drive but it wouldn't go and the motor was still running though and then it came all came back up and then it did this all the way home it would slam on break it didn't matter if I was going 30 or 60 and then it shut off before it got home and then the only way to get it going again was to jump it off

#9 - [Recall] Power Train:Automatic Transmission:Gear Position Indication (Prndl) Reported 8 months, 2 weeks ago by FORD SUNRISE Ford will notify owners, and dealers will inspect the shift cable locking clip and properly seat it, if necessary, free of charge. The recall began on april 13, 2018. Owners may contact ford customer service at 1-866-436-7332. Ford's number for the recall is 18s10. Owners may also contact the national highway traffic safety administration vehicle safety hotline at 1-888-327-4236 (tty 1-800-424-9153), or go to www.safercar.gov.

03/11/2022Ford motor company (ford) is recalling certain 201… Needs Action 22S1122V150000 03/11/2022Ford motor company (ford) is recalling certain 201… Needs Action 22S1122V150000 12/16/2021Ford motor company (ford) is recalling certain 201… Needs Action 21S5321V983000 04/12/2021Tenneco automotive (driv) is recalling certain moo… Needs Action 21E027000 03/10/2021Ford motor company (ford) is recalling certain 201… Needs Action 21S1021V155000 02/21/2020Ford motor company (ford) is recalling certain 201… Needs Action 20C0320V097000 08/28/2019Ford motor company (ford) is recalling certain 201… Needs Action 19C0719V633000 08/28/2019Ford motor company (ford) is recalling certain 201… Needs Action 19C0719V633000 04/08/2019Ford motor company (ford) is recalling certain 201… Needs Action 19S1119V278000 04/08/2019Ford motor company (ford) is recalling certain 201… Needs Action 19S1119V278000 12/18/2018Ford motor company (ford) is recalling certain 201… Needs Action 18S4518V894000 08/31/2018Ford motor company (ford) is recalling certain 201… Needs Action 18S2718V568000 08/31/2018Ford motor company (ford) is recalling certain 201… Needs Action 18S2718V568000 06/12/2018Ford motor company (ford) is recalling certain 201…...

Vehicle did not have tires pressure sensors at the moment of the purchased

Lights independently flicker on and off continuously until the battery is completely drained and died. No capability to stop this from occurring.

The contact owns a 2018 Ford F-150. The contact stated that the START/STOP feature intermittently failed to operate as needed. There was no warning light illuminated. The contact stated that while pulling out of a parking lot and entering traffic, another vehicle attempted to run a red light. The contact stated that the vehicle was unable to accelerate due to the failure with the START/STOP feature, and the other vehicle crashed into the contact's vehicle. The air bags deployed upon impact. No injuries were reported. A Police report was filed. The vehicle was towed to the residence after the crash. The dealer and the manufacturer were notified of the failure. The vehicle was not repaired. The failure mileage was unknown.