2020 FORD EXPLORER Electrical System Problems

STARTING ABOUT THE BEGINNING OF JULY MY NEW 2020 EXPLORER ST STARTED SLAMMING ON THE BRAKES IN REVERSE, WITH NO OBJECTS NEAR BY. THEN IT STARTED THROWING A FAULT FOR THE REVERSE BRAKING SYSTEM. I HAVE HAD THE VEHICLE BACK TO THE DEALER 3 TIMES FOR THE SAME ISSUE. AFTER THE SECOND TIME IT HAD MORE FAULT CODES FOR HILL ASSIST, FORWARD COLLISION, AND ADVANCED TRAC. AFTER THE THIRD TIME AT DEALER THEY ASSURED ME THE ISSUE WAS FIXED. NEEDLESS TO SAY IT IS HAVING THE ISSUES AGAIN. I HAVE ALSO HAD THE CHECK ENGINE LIGHT COME ON AND THEY DETERMINED THE TEMP SENSOR NEEDED TO BE REPLACED. THE FLEX PIPE IS MAKING A HORRIBLE NOISE AS WELL AND THE SOLUTION WAS TO PUT A CLAMP ON IT AND THE SOUND IS MUCH BETTER BUT STILL THERE! THIS VEHICLE SEEMS TO BE A LEMON.

I HAVE HAD THIS VEHICLE SINCE FEBRUARY AND IT HAS BEEN IN THE SHOP 5 TIMES FOR VARIOUS THINGS! THERE IS A JOLT WHEN IT CHANGES GEARS AND WHEN HITTING BRAKES. I HAVE A DELAY WHEN I PUT THE CAR IN REVERSE WHICH HAS ALMOST CAUSED ACCIDENTS. IT ROLLS FORWARD, EVEN WITH MY FOOT ON THE BRAKE AND THE JERKS HARD WHEN IT FINALLY CATCHES UP AND GOES IN REVERSE. CORPORATE WILL NOT GET ME OUT OF THIS VEHICLE, EVEN AFTER IT BROKE DOWN AND HAD TO BE TOWED WHILE I WAS OUT OF STATE ON VACATION!

TL* THE CONTACT OWNS A 2020 FORD EXPLORER. THE CONTACT STATED WHILE THE VEHICLE WAS AT A STAND STILL AND ATTEMPTING TO START THE VEHICLE, THE FRONT PASSENGER'S SIDE MIRROR FAILED TO OPEN. THE CLIMATE CONTROL FAILED TO OPERATE CORRECTLY, WHICH CREATED A VISIBILITY HAZARD FOR THE DRIVER. THE CONTACT STATED THAT THE BLIND SPOT DETECTION, CROSS TRACK, SIDE OBSTACLE DETECTION, PRE-COLLISION ASSIST NOT AVAILABLE WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO EMPIRE FORD OF HUNTINGTON LOCATED AT 333 W JERICHO TURNPIKE, HUNTINGTON, NY 11743, WHERE IT WAS DIAGNOSED WITH NEEDING TO UPDATE AN UNKNOWN SOFTWARE AND TO REPLACE AN UNKNOWN MODULE. THE VEHICLE WAS REPAIRED, HOWEVER THE FAILURE RECURRED. THE VEHICLE HAD NOT BEEN DIAGNOSED NOR REPAIRED AS OF YET. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OPENED A CASE WHICH WAS RECENTLY CLOSED. THE FAILURE MILEAGE WAS APPROXIMATELY 8,000.

THE VEHICLE EXPERIENCES VARIOUS FAULT CODES: BLIND SPOT SYSTEM FAULT; CROSS TRAFFIC SYSTEM FAIL; AND REVERSE BRAKE ASSIST NOT AVAILABLE. IN ADDITION, AIR CONDITIONING DOES NOT WORK, INCLUDING RIGHT SIDE PASSENGER WINDOW AND RIGHT SIDE MIRRORS. FAULTS MAINLY OCCUR AFTER STARING VEHICLE, BUT THEY HAVE ALSO OCCURRED WHILE DRIVING. THE AC FAILURE OCCURS WHEN STARTING VEHICLE AND HAVE OCCURRED AFTER FIRST START IN MORNING AND AT THE END OF THE DAY AFTER MULTIPLE STARTS. THERE IS NO IDENTIFIABLE PATTERN TO FAILURES. THE VEHICLE WAS PURCHASED IN JANUARY AND HAS 3254 MILES. THIS IS THE THIRD TIME THE ISSUE HAS OCCURRED AND FORD CAN NOT IDENTIFY THE ISSUE. THE SYSTEM PROVIDES DAILY CODES AND THE DEALERSHIP AND FOCUSED ON THE SENSORS, INCLUDING REPLACING ON, BUT THE ISSUE IS NOT RESOLVED. INCIDENTS OCCURRED ON MARCH 16, 2020, MARCH 26, 2020, APRIL 14, 2020, JULY 4, 2020, JULY 14 AND JULY 17 2020.

VEHICLE WAS PARKED. VEHICLE LOCKED INTO PARK AND WOULD NOT SHIFT OUT OF PARK OR START, BRAKE PEDAL WAS DEPRESSED FULLY. DASHBOARD MESSAGE: DRIVE MODE NOT AVAILABLE PLUS SCROLLED THROUGH EVERY OTHER MODE OR FEATURE AND INDICATED 'NOT AVAILABLE.' BUT LCD SCREEN SHOWED MESSAGE 'TURN OFF IGNITION.' IGNITION WAS OFF. VEHICLE THOUGHT IGNITION STILL ON. WOULD NOT START. I DISCONNECTED NEGATIVE TERMINAL OF BATTERY AND RECONNECTED AND CAR THEN STARTED WITH NO ERROR OR CODE MESSAGES.

ON OCCASION WHEN STARTING OUR 2020 EXPLORER ST, THE BRAKES DO NOT WORK... RESULTING IN THE VEHICLE DRIVING AWAY. THE ONLY WAY TO STOP THE VEHICLE, IS TO THROW IT BACK INTO PARK OR NEUTRAL. THIS HAS OCCURRED 1-2 TIMES A MONTH, AND FORD HAS BEEN RELUCTANT TO FIX THE ISSUE. THE VEHICLE WAS ALMOST INVOLVED IN A LOW-SPEED CRASH, DUE TO FORDS INABILITY TO FIX THE PROBLEM. WE HAVE ATTEMPTED TO GET A BUYBACK, BUT THEY HAVE NOT RESOLVED IT AS OF NOW.

I HAVE NUMEROUS FAULT MESSAGES, PRE COLLISION ASSIST FAULT, 4WD TEMP DISABLED, 4WD SYSTEM FAULT SERVICE REQUIRED, SERVICE REQUIRED, DRIVE MODE UNAVAILABLE FAULT,AUTO HOLD SYSTEM FAULT,SERVICE ADVANCETRAC, VEHICLE WILL NOT SWTICH INTO PARK OR NEUTRAL. I WAS IN MOTION AT THE STATE SPEED LIMIT OF 70 ON THE OHIO TURNPIKE WHEN OUT OF THE BULE THE WARNING CLUSTER LIT UP LIKE A CHRISTMAS TREE WITH MUTIPLE FAULTS AND SYSTEM ERRORS. VEHICLE HAS LIMITED BRAKING.

SEVERAL TIMES THE REVERSE CAMERA AND SENSOR HAVE NOT WORKED (BLUE SCREEN) ONE OF THE TIMES ALMOST HITTING A CAR BEHIND ME, ONCE THE CENTER SCREEN WENT BLACK WHILE DRIVING WHILE USING THE NAVIGATION SYSTEM, THIS MORNING, PUT THE TRANSMISSION IN REVERSE AND THE BRAKE PEDAL BECAME REALLY HARD WHEN STEPPING ON IT AND AGAIN ALMOST HIT A CAR BEHIND ME, SUDDENLY IT WENT TO THE FLOOR CAUSING THE CAR TO STOP SUDDENLY ALL THIS WHILE GETTING OUT OF A PARKING SPACE

I JUST PULLED OUT FROM A PARKING LOT INTO TRAFFIC AND THERE WAS A LOUD CLUNK AND WARNING LIGHTS APPEARED ON THE DASH. ONE SAID "SERVICE ADVANCETRAC" AND THE OTHER SAID "4WD FAULT SERVICE REQUIRED." THE VEHICLE WOULD NOT SHIFT OUT OF LOW GEAR AND WOULD NOT ACCELERATE OVER 25MPH. THEN, SEVERAL OTHER WARNING LIGHTS CAME ON, SUCH AS "PRE-COLLISION ASSIST NOT AVAILABLE." I TOOK THE VEHICLE TO THE DEALERSHIP THE NEXT DAY AND THEY WERE UNABLE TO REPAIR/RESOLVE THE ISSUE.

THE VEHICLE WAS DRIVING ON A LOCAL HIGHWAY WHEN THE MESSAGE 'SERVICE CHARGE SYSTEM NOW'. THE BATTERY ICON APPEARED BRIEFLY ON THE DASHBOARD. I CONTINUED DRIVING AND THE SAME MESSAGE REAPPEARED EVERY 5 MINUTES. THE DEALER TOLD ME THEY DID NOT RECOGNIZE THE MESSAGE, AND TO BRING THE VEHICLE IN FOR SERVICE SOON. THEY RAN A 'DIAGNOSTIC ' AND DETERMINED IT NEEDED A NEW ALTERNATOR. THE VEHICLE IS SEVEN MONTHS OLD AND HAS LESS THAN 15,000 MILES. IT IS STILL IN FOR SERVICE AS THE DEALER DID NOT HAVE A REPLACEMENT ALTERNATOR IN STOCK. *TR

TL* THE CONTACT OWNS A 2020 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE INSTRUMENT PANEL STATED THAT THE VEHICLE WAS DRIVING AT 85 MPH. THE SERVICE ENGINE SOON WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO GEWEKE FORD LOCATED AT 871 E. ONSTOTT RD, YUBA CITY, CA 95991, (530) 821-2121, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT AN UNKNOWN ELECTRONIC COMPONENT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 12,000.

SINCE WE HAVE PURCHASED THE SUV IT HAS ON MULTIPLE OCCASIONS FLASHED CROSS TRAFFIC SYSTEM FAULT, BLIND SPOT SYSTEM FAULT, AC SHUTS OFF, AND THE WINDOWS WILL NOT ROLL DOWN. HAVE TAKEN TO THE DEALERSHIP TWICE, ONCE THEY CHARGED THE BATTERY, THE LAST TIME THEY RESET A MODULE. IT DID IT AGAIN TODAY SO WE WILL HAVE TO TAKE IT BACK. WE HAVE HAD THE PROBLEM HAPPEN WHILE MOVING BUT TODAY WE WERE STATIONARY WHEN IT HAPPENED. *TR

CAR GOES INTO DEEP SLEEP AFTER TWO DAYS OF BEING PARKED AND HAS TO BE JUMPED TO START. HAPPENS ON REGULAR BASIS. DEALER UNABLE TO CORRECT PROBLEM AFTER NUMEROUS ATTEMPTS TO REPAIR THE CAR SINCE IT WAS PURCHASED.

FALSE ENGINE COOLANT TEMPERATURE ALARM ISSUE - VEHICLE BELIEVES IT IS OVERHEATING WHEN IT ISN'T. THIS RESULTS IN THE LOSS OF ENGINE POWER, WHERE THE VEHICLE IS UNABLE TO DRIVE FASTER THAN 50MPH AND IS EXTREMELY SLOW TO ACCELERATE CAUSING A MAJOR SAFETY HAZARD. THIS HAS OCCURRED ON MY EXPLORER ST MODEL 3 DIFFERENT TIMES ALL WHILE TRAVELING AT HIGHWAY SPEEDS. THE SECOND TIME WHILE I WAS TRYING TO MERGE ONTO THE FREEWAY AND NEARLY COLLIDED WITH A SEMI TRUCK SINCE I LOST ALL ABILITY TO ACCELERATE. ALL TIMES THE VEHICLE WAS TAKEN TO FORD DEALERSHIP FOR REPAIR. MY VEHICLE HAS CURRENTLY BEEN WAITING FOR REPAIR FOR OVER 30 DAYS & ONLY HAS 13,000 MILES ON IT.

WHEN TRYING TO MOVE THE VEHICLE OUT OF PARK, EITHER REVERSE OR DRIVE THE VEHICLE JERKS INTO GEAR HARD AND THEN STALLS. TRIED MULTIPLE TIMES TO GET THE VEHICLE OUT OF THE DRIVE WAY STARTS UP NO ISSUE, NO CHECK ENGINE LIGHT YET KEEPS STALLING. THIS IS NEW OWNED FOR 3 DAYS WITH LESS THAN 200 MILES ON IT.

THE VEHICLE IS RANDOMLY BRAKING FOR NO UNKNOWN REASON. ALMOST LIKE IF I WAS DRIVING AND PUT ON EMERGENCY BRAKE. IT MOSTLY DOES IT WHILE IN REVERSE WHEN THERE IS LITERALLY NOTHING AROUND ME. THERE IS AN OPTION AND IT HAS STILL DOES IT WITH OPTION OFF. IT HAS NEARLY CAUSED 1 ACCIDENT WHEN I WAS IN MY SONS CAR POOL LINE AT SCHOOL. OTHERWISE IT HAS CAUSED EXTREME ANXIETY BECAUSE I DON'T KNOW WHEN IT WILL HAPPEN. THE BRAKE ASSIST FAULT IS ALSO ON, AND DEALER CANNOT FIND FIX TO THAT EITHER. THE DEALER (CAPITAL FORD RALEIGH) WAS AWARE OF SENSOR ISSUES, AS WELL AS FAULTS THE DAY I TOOK DELIVERY ON VEHICLE. THEY KNOWINGLY SOLD IT TO US ANYWAYS. I TOOK VEHICLE TO SERVICE DEPT THE VERY DAY AFTER WE TOOK DELIVERY. THERE IS NO FIX FOR THESE DANGEROUS ISSUES, AND I AM FORCED TO KEEP DRIVING WITH...

DEEP SLEEP MODE ACTIVATES AFTER 2 DAYS. MOST RECENT EXPERIENCE INVOLVED HAVING TO JUMP START THE CAR AFTER SETTING 3 DAYS.

TL* THE CONTACT OWNS A 2020 FORD EXPLORER. WHILE THE VEHICLE WAS PARKED, THE ENGINE SUDDENLY BEGAN TO REV VERY HIGHLY AND THE VEHICLE ATTEMPTED TO ACCELERATE FORWARD. THE DRIVER DEPRESSED THE BRAKE PEDAL TO PREVENT THE VEHICLE FROM MOVING. THE TRANSMISSION WAS SWITCHED INTO NEUTRAL, BUT THE FAILURE CONTINUED. AFTER TURNING THE VEHICLE OFF AND BACK ON, IT RESUMED NORMAL OPERATION. THE MANUFACTURER AND LEVITOWN FORD (3195 HEMPSTEAD TPKE, LEVITOWN, NY) WERE NOTIFIED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 2,000. *DT*JB