2016 FORD EXPLORER Fuelpropulsion System Problems

CARBON MONOXIDE AND GASOLINE SMELL IN CABIN

MY STOCK (UNALTERED) 2016 FORD EXPLORER SPORT WITH ECOBOOST ENGINE EMITS A ROTTEN EGG, SULFUR-LIKE ODOR INTO THE PASSENGER CABIN UPON FULL THROTTLE ACCELERATION. THIS CONDITION DOES NOT OCCUR DURING NORMAL (LESS THAN FULL THROTTLE ACCELERATION) DRIVING. THIS CONDITION OCCURS ONLY DURING FULL THROTTLE ACCELERATION AND IS REPLICABLE. THIS CONDITION HAS OCCURRED SINCE ORIGINAL PURCHASE IN 04/2016 AND CONTINUES TODAY.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, A STRONG FUEL ODOR BECAME PRESENT INSIDE THE CABIN. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND HAD TO OPEN ALL THE WINDOWS. THE CONTACT EXITED THE VEHICLE, CHECKED INSIDE THE ENGINE COMPARTMENT AND OUTSIDE THE VEHICLE BUT THERE WERE NO NOTICEABLE LEAKS. THE CONTACT WAITED FOR APPROXIMATELY TEN MINUTES AND GOT INSIDE THE VEHICLE AND STARTED DRIVING BUT THE ODOR BECAME STRONGER ALSO NOTICED THAT THE ODOR WAS EMERGING FROM THE AIR VENTS. THE CONTACT TURNED OFF THE AIR CONDITIONING AND DROVE TO THE DEALER BRADLEY FORD OF LAKE HAVASU, ARIZONA. THE DEALER KEPT THE VEHICLE FOR EVALUATION AND THEY HAD NOT DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE NUMBER: CAS-12708860 WAS OPENED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE...

EVERY TIME I STEP ON THE GAS TO ACCELERATE QUICKLY, THE INSIDE OF MY CAR STARTS TO SMELL LIKE SMOKE OR SOMETHING IS BURNING. I HAVE TO LOWER MY WINDOWS FOR ABOUT A MINUTE TO CLEAR THE AIR OUT. IT HAS BEEN GOING ON FOR MONTHS.

I AM AN OWNER OF A 2016 FORD EXPLORER THAT WAS PURCHASED BRAND NEW AT A DEALERSHIP HERE IN AZ LAST YEAR IN JANUARY. IMMEDIATELY AFTER PURCHASE, I STARTED NOTICING FUEL LEAKAGE FROM THE VEHICLE AND VEHICLE USING A LOT OF GAS EVERYDAY. I TOOK MY TRUCK BACK TO THE DEALERSHIP AND WAS TOLD EVERYTHING IS OK. AS TIME WENT ON, I NOTICED THAT EVERY TIME I ACCELERATED ON THE GAS, THE TRUCK SLOWED DOWN. TOOK TRUCK TO DEALERSHIP AND WAS TOLD ONCE AGAIN NOTHING IS WRONG. A COUPLE OF MONTHS AGO, THE BATTERY DIED. I HAVE THE TRUCK TOOWED TO THE DEALERSHIP AND THEY REPLACED THE BATTERY. TWO WEEKS LATER, THE BATTERY DIES AGAIN. I HAD IT TOWED TO THE DEALERSHIP AGAIN. THEY REPLACED THE BATTERY AGAIN AND NOTICED A RECALL ON THE TRUCK. A WEEK LATER I'M DRIVING MY KIDS TO SCHOOL WHEN THE DASHBOARD GOES BLACK AND...

WHILE IN MOTION AND ACCELERATING ABOVE 2500 RPM, EXHAUST FUMES FILL THE CABIN. WE TOOK IT INTO A DEALERSHIP WHERE THEY TRIED TO FIX THE ISSUE USING A TECHNICAL BULLETIN FORD ISSUED. THE PROBLEM PERSISTS.

I HAVE BEEN TAKING THIS VEHICLE INTO THE DEALERSHIP MANY TIMES SINCE JULY 2016 FOR AN EXHAUST SMELL IN THE CABIN WHEN ACCELERATING AND AT HIGH SPEEDS AND CONSTANTLY FEEL DIZZY AND NAUSEOUS WHEN DRIVING THE VEHICLE. I HAVE TRIED MULTIPLE DEALERSHIPS TO FIX AND THEY HAVE TRIED ALL THE TSB'S THAT APPLY TO THE 2011-15'S, BUT SEEM TO NOT WORK ON THE 2016. THEY HAVE RESEALED THE VEHICLE AT LEAST 3 TIMES, REPLACED THE EXHAUST SYSTEM, AND OTHER PARTS, AND WHO KNOWS WHAT ELSE THEY'VE TRIED, BUT STILL WITH NO RESOLUTION. I'M TAKING IT BACK TO THE DEALERSHIP YET AGAIN TOMORROW, BUT REFUSE TO TAKE THIS VEHICLE BACK HOME UNTIL THE SMELL IS COMPLETELY GONE, WHICH SEEMS TO BE AN IMPOSSIBLE FEAT AT THIS POINT. I HAVE A CASE OPEN WITH FORD, BUT HAVE NOT NOT MADE ANY PROGRESS WITH THEM EITHER (OVER 6 WEEKS). PLEASE DO WHAT YOU...

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THERE HAD BEEN EXTREMELY STRONG EXHAUST FUMES EMITTING ON THE INSIDE AND OUTSIDE OF THE VEHICLE THAT HAD PROGRESSED. THE DEALER HAD REPLACED THE MUFFLER, PRESSURIZED THE CABIN, INSPECTED THE SEALS AROUND THE REAR OF THE EXHAUST BUT HAD BEEN UNABLE TO DETERMINE IF THE REPAIRS MAY PROVIDE A PERMANENT SOLUTION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS WAITING TO DETERMINE THEIR SOLUTION TO REPAIR THE VEHICLE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

EXHAUST FUMES IN CABIN- I AM EXPERIENCING A STRONG SULFURIC SMELL IN THE CABIN AFTER HARD ACCELERATION. THIS OCCURS WHEN THE CAR IS RUNNING AND HAS OCCURRED ON BOTH THE HIGHWAY AND ON CITY STREETS.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE CONTACT NOTICED A ROTTEN EGG ODOR WITHOUT WARNING. THE MANUFACTURER ADVISED NOT TO TOUCH THE FAILURE DUE TO A LACK OF REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE WAS NEITHER DIAGNOSED NOR REMEDIED. THE FAILURE MILEAGE WAS APPROXIMATELY 500.

NOTICED A MONTH AFTER PURCHASE OF NEW CAR, CABIN FILLED UP WITH GAS SMELL ENTERING FREEWAY. SPOKE TO CAR SALESMAN.(HAD JUST FILLED CAR WITH GAS & W/CAPLESS SYSTEM I CONNECTED THE DOTS, THOUGHT THAT'S WHY IT HAPPENED & SPOKE TO SALESMAN. THEN NEXT TIME I HAD TO REV THE ENGINE TO ACCELERATE/PASS, IT HAPPENED WITH 1/4 TANK GAS. SENT A PS TO SALESMAN 11/29/16 THRU EMAIL. HE SAID IT TAKES THE CAR 3K-5K MI. TO BREAK IN. I JUST TRIED NOT TO GET ON FREEWAY, ONLY DROVE IT AROUND TOWN. WE USED MY HUBBY'S TRUCK FOR FREEWAY. THIS WEEKEND, WENT TO NEPHEW'S BB GAME ON 2 LANE 42 MILE RD. HAD TO PASS SLOW CAR IN FRONT OF ME--CAR HAD SUCH A GAS SMELL, I GOT A SORE THROAT FROM IT AND HAD TO ROLL DOWN WINDOWS TO BREATHE. I WAS SHOCKED IT HAPPENED AGAIN. LOOKED UP ON INTERNET WHAT...

FUME. CARBON MONOXIDE LEAKING. I'VE BEEN VERY ILL SINCE DRIVING THIS VEHICLE. I'VE BEEN DIZZY, WITH BLURRED VISION AND NAUSEATED SINCE THE PURCHASED OF THIS VEHICLE.

WHEN ACCELERATING, MY CABIN FILLS UP WITH EXHAUST FUMES. IT DOESN'T DO IT AS BAD WHEN IT IS COLD OUTSIDE BUT WHEN IT IS HOT, IT IS REALLY BAD. IT HAS BEEN TO FORD SEVERAL TIMES AND THEY PERFORMED THE TECHNICAL BULLETINS ON THE CAR. IT DIDN'T HELP.

WHILE DRIVING OUT OF THE SUBDIVISION THE CAR STALLED. THE WRENCH LIGHT CAME ON. WE PARKED IT AND TOOK ANOTHER CAR WE HAD AT THE TIME. WE WILL MAKE MENTION OF IT TOMORROW WHEN I CALL THE DEALER AND ADD IT THE SERVICE TICKET REGARDING THE EXHAUST PROBLEM.

WE PURCHASED A CERTIFIED USED 2016 EXPLORER FROM LITHIA FORD DECEMBER 2016. UPON DRIVING HOME THERE WAS AN EXHAUST SMELL AND WE THOUGHT IT MAY HAVE BEEN A VEHICLE IN FRONT OF US. BUT THAT PROVED FALSE, AND IT IS A SERIOUS DISTRACTION AND I NOW AM GETTING HEADACHES WHEN I RIDE IN MY NEW CAR. TODAY I STARTED THE CAR AND A VERY STRONG EXHAUST SMELL FILLED THE CABIN. MUCH LIKE A VERY OLD CAR. THE EXHAUST SMELL LINGERED IN THE CABIN FOR A LONG TIME. WE FEEL THE CARBON MONOXIDE INFILTRATION THREAT IS VERY WORRISOME AND NEED IMMEDIATE ATTENTION. AND SINCE OUR TERRIBLE WINTER WEATHER I HAVEN'T BEEN ABLE PUT VERY MANY MILES ON IT. WE ARE GOING TO TRY TO GET IN ON A CLASS ACTION SUIT SINCE WE ARE READING MANY SIMILAR COMPLAINTS WITH THIS 2016 MODEL JUST LIKE THE PREVIOUS MODEL YEARS 2011 - 2015...

THE FUEL LINE ATTRACTED A CRITTER MOST LIKELY A SQUIRREL WHICH CHEWED THROUGH THE RUBBER HOSE AND CAUSE A SEVERE FUEL LEAK THAT COVERED THE ENTIRE ENGINE COMPARTMENT. WE HAD TO IMMEDIATELY PULL OVER AND SHUT OFF THE VEHICLE TO PREVENT A FIRE. ACCORDING TO THE FORD TECHNICIAN, THE HOSES NOW CONTAIN SOY AND THEY HAVE SEEN SEVERAL CASES IN WHICH CRITTERS HAVE CHEWED THROUGH VARIOUS HOSES IN THE ENGINE COMPARTMENTS OF VEHICLES.

WHEN ACCELERATING OVER 3500 RPM SMOKE GASES COME INSIDE THE CABIN IT STARTED WHEN I ACQUIRED THE VEHICLE AND HASN'T STOPPED EVER SINCE

2016 FORD EXPLORER [XXX] LOST POWER AND WOULD NOT MOVE IN MIDDLE OF BUSY HIGHWAY. VEHICLE WAS NOTED TO HAVE A SPUTTERING SOUND AND APPEARED TO BE FIRING ON ONLY A FEW CYLINDERS. TURNED VEHICLE ENGINE OFF AND RESTARTED NO HELP VEHICLE WOULD NOT MOVE WITH ACCELERATOR PEDAL IN FULL OPEN (FLOORED) POSITION. AFTER OPENING HOOD AND DISCONNECTING NEG TERMINAL OF BATTERY VEHICLE OPERATED FINE FOR APPROX 10 MILES AND THEN SAME OCCURENCE. AGAIN FAULT CLEARED AND RAN FINE TO NEAREST FORD DEALER. INITIAL DIAGNOSIS BY DEALER WAS CODES P2111 AND P2112. DEALER STATED FOUND RECALL 16B32 FOLLOWED INSTRUCTIONS AND REPROGRAMMED PCM AND CLEAR CODES. CUSTOMER DEPARTED DEALERSHIP SERVICE BAY AND REPEAT ABOVE MENTIONED MALFUNCTION BEFORE OFF THE DEALER LOT. RETURNED TO SERVICE BAY AND DEALER STATED THAT THROTTLE BODY WAS CHANGED. VEHICLE APPEARS TO BE OPERATING NORMAL AT THIS TIME. THIS IS A SAFETY ISSUE THAT SHOULD BE INVESTIGATED....

I WAS DRIVING ON 675 IN DAYTON OHIO AT 65-70 MILES AN HOUR WHEN MY FORD EXPLORER XLT LOST ALL ACCELERATION AND I WAS FORCED TO COAST TO A STOP ON THE LEFT SHOULDER OF THE HIGHWAY. I WAS ABLE TO TURN THE CAR OFF AND RESTART IT, AND DRIVE IT HOME WITHOUT INCIDENT. I HAD IT TOWED TO A FORD DEALER AND HOPEFULLY WILL HAVE AN ANSWER TOMORROW. THIS VEHICLE IS A 2016 XLT WITH JUST OVER 8,000 MILES. I NO LONGER TRUST THIS VEHICLE AND WILL BE RESEARCHING MORE RELIABLE VEHICLES.

THE VEHICLE KEEPS LOSING FUEL AND FUEL HAS TO BE REPLACED EVERY OTHER DAY. TOOK VEHICLE INTO FORD DEALERSHIP TO BE CHECKED OUT AND WAS TOLD VEHICLE IS SAFE TO DRIVE. GAS CAN BE SMELT AND VISIBLY GUSHES AFTER FUELING IN STATIONARY POSITION. WHEN VEHICLE IS IN DRIVE MOTION, GAS LEAKS SLOWLY. ALSO, WHILE DRIVING THE VEHICLE JERKS AND WILL SLOW DOWN ACCELERATION.

I PREVIOUSLY OWNED AND 2013 FORD EXPLORER XLT AND TOOK IT 3 TIMES T DEALERSHIP FOR HAVING IT CHECK FOR FUMES COMING INTO THE CABIN WHEN SUDDENLY ACCELERATING THE VEHICLE. THE ISSUE WAS NEVER CORRECTED. I PURCHASED AND 2016 XLT HOPING TO HAVE THIS ISSUE NOT LONGER BOTHERING, SADLY I AM EXPERIENCING THE SAME ISSUE WITH MY NEW EXPLORER. I DISCUSSED THIS WITH THE DEALER'S MANAGER AND HE HAD NOT A SOLUTION FOR MY ISSUE.

VEHICLE LOST POWER IN THE CITY GOING ABOUT 35MPH, HAD TO COAST TO SIDE OF THE ROAD, BAD THROTTLE BODY...... 6600 MILES ON THE CAR SERVICE LIGHT CAME ON ZERO THROTTLE RESPONSE.

VEHICLE LOST POWER WHILE DRIVING DOWN A BUSY HIGHWAY AT 65+ MPH. ENGINE WAS RUNNING ROUGH (SOUNDED LIKE A TRACTOR) AND COULD NOT ACCELERATE. DASH LIGHTS CAME ON. VEHICLE WAS ABLE TO COAST TO AN EXIT RAMP WHERE IT WAS TOWED TO THE DEALERSHIP TO HAVE THE THROTTLE BODY REPLACED. MILEAGE WAS JUST OVER 7,000. IT IS SAD THAT I HAD TO RESCUE MY FAMILY (WIFE, 4 MONTH OLD BABY, 3 YEAR OLD AND 6 YEAR OLD) OFF A BUSY HIGHWAY EXIT RAMP WHEN THE VEHICLE IS LESS THAN 6 MONTHS OLD. THE TOW TRUCK DRIVER SAID HE GETS ABOUT 3 OR 4 OF THE SAME ISSUE WITH NEW EXPLORERS A WEEK. HOW CAN THIS NOT BE A RECALL? NOW WE WILL DRIVE IN FEAR OF THIS PROBLEM OCCURRING AGAIN SINCE, FROM WHAT THE DEALER SAID, THE THROTTLE BODY WAS REPLACED WITH THE EXACT SAME PART. I GUESS WE JUST...

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE HAD AN ABNORMAL CARBON MONOXIDE ODOR WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE WAS NEW AND JUST BURNING OFF OIL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 10.

I'M A VICTIM OF THE WIDE SPREAD ELECTRONIC THROTTLE BODY ISSUE ON THE 2016 FORD EXPLORER, LIMITED, FWD, 3.5V6. IT ONLY CLOCKED 7000 MILES AND IT HAPPENED WHEN I WAS AT AROUND 40MPH IN THE TRAFFIC, AND ALL OF SUDDEN, BOTH THE CHECK ENGINE AND AIRBAG LIGHT TURNED ON, STEERING WHEEL BECAME HEAVY, AND LOST ALL THE POWER, PRESSING THE GAS PADDLE COULDN'T ACCELERATE THE VEHICLE. I MANAGED TO COAST TO THE ROAD SIDE, CALLED THE TOW TRUCK, AND SENT THE CAR IN NEARBY FORD SERVICE. ON THE NEXT DAY, I WAS INFORMED OF THE THROTTLE BODY FAILURE AND FAULTY PART WAS REPLACED. AS ECHOED BY SO MANY OTHER OWNERS, THIS IS A KNOWN DEFECT IN AN IMPORTANT PART ON THIS BRAND NEW CAR, IT'S EXTREMELY DANGEROUS TO LOSE ALL POWER ALL OF SUDDEN IN THE MIDDLE OF THE TRAFFIC, WHAT IF IT'S ON A SPEEDY HIGHWAY? HUSBAND, WIFE, OR...

THE VEHICLE WAS BEING DRIVEN AT APPROXIMATELY 40 MPH WHEN THE ENGINE WENT TO IDLE. A WRENCH ICON SHOWED ON THE DASH AND THE ENGINE WOULD IDLE, BUT WHEN THE GAS PEDAL WAS DEPRESSED, THE CAR WOULD NOT ACCELERATE WHATSOEVER. THE PROBLEM IS A DEFECTIVE THROTTLE BODY AND THE ISSUE IS WIDELY REPORTED AS A COMMON OCCURRENCE. BECAUSE THE THROTTLE BODY FAILED ON A MAJOR INTERSTATE HIGHWAY AT RUSH HOUR MADE FOR A VERY DANGEROUS SITUATION. FORD SEEMS TO HAVE NO RESOLUTION FOR THIS ISSUE.

VEHICLE WAS PROCEEDING AND ALL POWER TO THROTTLE STOPPED. POWER STEERING WENT OUT. VEHICLE COASTED TO STOP IN TRAFFIC TURN LANE. FORD STATED THIS IS A PROBLEM WITH VEHICLES THROTTLE BODY

WHILE DRIVING ON A BUSY HIGHWAY WITH MY THREE CHILDREN I LOST ALL POWER TO MY VEHICLE JUST BARELY MAKING IT OUT THE WAY OF A SENI TRUCK. THE EXPLORER WAS PURCHASED IN MARCH OF THIS YEAR BRAND NEW TO AVOID PROBLEMS LIKE THIS. DOES SOMEONE HAVE TO BE KILLED BEFORE A RECALL IS ISSUED?!?!?!?!!!

I LEASED MY 2016 FORD EXPLORER XLT IN AUGUST ON 2015. ON SATURDAY, JULY 9, 2016, WITH ONLY AROUND 8,400 MILES ON THE VEHICLE, WHILE DRIVING, IT SHIMMIED, STOPPED, HAD NO ACCELERATION/POWER, AND THE WRENCH LIGHT CAME ON WHILE I WAS ON A BUSY STREET IN MY CITY. (50 MPH SPEED LIMIT). I "LIMPED" HOME AND CALLED A TOW TRUCK TO HAVE IT TOWED TO MY LOCAL FORD DEALERSHIP. I WAS TOLD BY THE SERVICE TECHNICIAN BASED ON THE "SYMPTOMS" I TOLD HIM THAT IT WAS THE ELECTRONIC THROTTLE BODY AND THAT THEY'VE HAVE A LOT OF 2016 EXPLORERS COME IN WITH THE SAME EXACT PROBLEM AND THAT FORD IS AWARE OF THE PROBLEM. REALLY? FORD IS AWARE OF THE PROBLEM BUT REFUSES TO ISSUE A RECALL!!! GUESS IT'S ALL ABOUT THE ALMIGHTY DOLLAR TO THEM. I THANK GOD THIS HAPPENED TO ME ON A SATURDAY AFTERNOON AND NOT DURING...

PURCHASED VEHICLE NEW ON 06/24/16. ON 06/28/16 WAS DRIVING ON A NEIGHBORHOOD STREET TRAVELING AROUND 20 MPH AND VEHICLE LOST POWER. VEHICLE FLASHED ERROR CODE FULL ACCESSORY POWER ACTIVE, NO WRENCH SYMBOL AND ENGINE WAS STILL ON JUST NO RESPONSE FROM ACCELERATOR. VEHICLE DRIFTED TO SIDE OF ROAD AND WAS PUT IN PARK AND BACK INTO DRIVE AND THE VEHICLE WORKED FINE. ON 06/29/2016 WAS IN A PARKING LOT GOING 10 MPH WHEN THE SAME ISSUE OCCURRED. AGAIN PUT IT IN PARK AND BACK INTO DRIVE AND THE VEHICLE WORKED FINE. DROVE 6 MILES DOWN THE ROAD AND THE SAME ISSUE OCCURRED, AROUND 25 MPH. AGAIN VEHICLE DRIFTED OFF OF THE ROAD AND THIS TIME THE VEHICLE HAD TO BE TURNED OFF AND TURNED BACK ON TO GET THE VEHICLE TO WORK. WITH ALL THREE INSTANCES THE ENGINE WAS ON JUST NO RESPONSE FROM THE ACCELERATOR AND THERE WAS NO...

ACCELERATOR ISSUE - FORD EXPLORER LIMITED 2016: UPON INITIAL ACCELERATION THROUGH AN INTERSECTION (MAN-O-WAR/TODD'S RD. LEXINGTON, KY) AND REACHING APPROXIMATELY 10MPH THE VEHICLE FAILED TO ACCELERATE THEN BEGAN COASTING. AFTER FOUR OR FIVE ATTEMPTS TO PUSH THE ACCELERATOR, THE ENGINE (2.4L) REVVED AND THE VEHICLE BEGAN GAINING SPEED WITH NO FURTHER PROBLEMS. THE VEHICLE WAS CLEARLY IN DRIVE, HAD A FULL TANK OF GAS AND HAS ONLY 3500 MILES ON ODOMETER. UPON NOTIFYING ROADSIDE ASSISTANCE THIS DATE, THE INDIVIDUAL ANSWERING THE CALL STATED THIS IS A COMMON PROBLEM WITH NEW FORD EXPLORERS.

MY WIFE, AND 2 FRIENDS, WERE ATTEMPTING TO MERGE ONTO A MAJOR HIGHWAY WHEN THE VEHICLE LOST ALL POWER WITHOUT WARNING AND WAS ALMOST STRUCK BY A PASSING SEMI. THE WRENCH SYMBOL CAME ON. VEHICLE DRIFTED TO THE SHOULDER OF THE ROAD. HER FRIEND CALLED HER HUSBAND WHO KNEW IMMEDIATELY WHAT THE PROBLEM WAS. HE TOLD MY WIFE TO LET IT SIT A FEW MINUTES THEN TRY TO RESTART IT. IT DID START AND DROVE IT HOME WITH THE WRENCH SYMBOL ON. DID A QUICK INTERNET SEARCH AND FOUND OUT THIS IS A WELL KNOWN PROBLEM BY FORD. THE THROTTLE BODY NEEDS TO BE REPLACED. THIS VEHICLE ONLY HAS 8,000 PLUS MILES. TONIGHT WE ARE GOING TO ATTEMPT TO DRIVE IT TO THE DEALER AFTER ALL THE TRAFFIC DIES DOWN. SOMEONE IS GOING TO END UP DEAD OR BADLY INJURED. WHY HASN'T FORD DONE A RECALL?

I HAVE RECENTLY HAD PROBLEMS WITH THE THROTTLE BODY IN MY 2016 EXPLORER, TO THE POINT THAT THE TRUCK WOULD NOT MOVE WHEN THE GAS PEDAL WAS PRESSED. I WAS STOPPED AT A LIGHT AND WHEN IT TURNED GREEN I STEPPED ON THE GAS PEDAL AND THE CAR STARTED TO BUCK AND THEN WOULD NOT ACCELERATE. I COASTED TO THE SIDE OF THE ROAD BEFORE STOPPED AND PUT ON MY HAZARDS. I CALLED FORD ROADSIDE ASSISTANCE AND WAS STUCK IN THE SIDE OF THE ROAD WITH MY 2 KIDS WHILE IT TOOK MORE THEN 3 HRS BEFORE I CANCELLED AND LEFT THE CAR UNTIL THE FOLLOWING MORNING FOR AAA. IT WAS SENT TO FREEHOLD FORD WHERE THEY TOLD ME IT WAS A THROTTLE BODY DEFECT AND THAT IT NEEDS TO BE REPLACED. TODAY, 7-23-16 THE SAME ISSUE OCCURRED WHILE I WAS TRYING TO LEAVE THE PARKING LOT OF A RESTAURANT...

BRAND NEW 2016 FORD EXPLORER WITH ONLY 6779 MILES. UNABLE TO ACCELERATE FROM A STOP THROUGH A BUSY INTERSECTION. NO INDICATION THAT ANYTHING WAS WRONG PRIOR TO THIS. SEVERAL DASH LIGHTS CAME ON. CAR WENT INTO LIMP MODE NOT ALLOWING ME TO ACCELERATE ABOVE 15 MPH. CHECK ENGINE LIGHT, POWER TRAIN LIGHT AND AIRBAG LIGHT ALL ILLUMINATED. HAD CAR TOWED TO DEALERSHIP. THROTTLE BODY FAILURE INDICATED AS THE ISSUE. PART WAS BACK ORDERED FOR TWO WEEKS. VERIFIED ONLINE THAT MANY OTHER NEW EXPLORER OWNERS HAVE HAD THIS SAME ISSUE AROUND THE SAME MILEAGE. FORTUNATELY I WAS NOT ON A BUSY HIGHWAY LIKE SOME.

THE INSIDE OF THE SUV SMELLS EXHAUST GAS WHEN YOU ARE MERGING INTO FREEWAY ON RAMPS AND/OR PASSING SOMEONE. ESPECIALLY WITH THE SUNROOF OPEN.

MY WIFE WAS DRIVING OUR 2016 FORD EXPLORER THAT HAS 4900 MILES ON IT. AFTER MAKING A RIGHT HAND TURN THE CAR LOST POWER, WENT INTO (LIMP MODE) WRENCHES AND CHECK ENGINE LIGHT CAME ON. SHE MADE IT TO A PARKING LOT AND RESTARTED THE CAR WHICH RAN OK FOR ANOTHER MILE BEFORE IT LOST POWER AGAIN, RESTARTED AGAIN WITH THE SAME RESULT. DECIDED TO HAVE IT TOWED TO DEALER. WAS DIAGNOSED WITH AN INTERNAL THROTTLE BODY FAILURE. WAS TOLD BY THE DEALER THAT THE REPLACED THROTTLE BODY WAS THE SAME PART NUMBER AS THE FAILED ONE. HE WAS NOT SURE IF FORD HAD MODIFIED THE REPLACEMENT PART OR NOT. YOU SPEND ALL THIS MONEY ON A NEW CAR AND CAN'T BE SURE IF IT WILL MAINTAIN POWER AT HIGHWAY SPEED. IF FORD HAS MODIFIED THIS PART THEY SHOULD AT LEAST NOTIFY THEIR CUSTOMERS AND DEALERS TO ASSURE US DRIVERS...

2016 FORD EXPLORER LIMITED W/ABOUT 7K MILES ON IT. RENTED THIS VEHICLE FROM A NATIONAL RENTAL CAR AGENCY. ON 7/8/2016 WHILE TRAVELING ON A STATE RD IN THE MIDDLE OF A MAJOR INTERSECTION THE GAS PEDAL STOPPED WORKING COMPLETELY AND I WAS SO LUCKY THAT I DID NOT GET REAR ENDED OR HIT BY OTHER CARS GOING BY AT 45MPH OR MORE. I WAS COMPLETELY SHAKEN UP. WHEN THE TRAFFIC SLOWED I MANAGED TO RESTART THE CAR AND THE GAS PEDAL STARTED TO WORK AGAIN AND THEN I WAS ABLE TO PULL TO SIDE OF THE ROAD AND CALL THE RENTAL COMPANY. THIS WAS THE SECOND FORD EXPLORER THAT WAS GIVEN TO US BY THE RENTAL COMPANY AFTER THE FIRST FORD EXPLORER 2016 ALSO WITH LOW MILEAGE GAVE US THE SAME PROBLEM FEW DAYS EARLIER. LUCKILY THE FIRST TIME WE WERE DRIVING ABOUT 45MPH ON THE OUTSIDE LANE OF A...

WHILE DRIVING AT 60 MPH ON A 4 LANE HIGHWAY, THE CAR SUDDENLY SHUT DOWN WITH NO WARNING. THE WENCH LIGHT CAME ON AND THE ENGINE WOULD ONLY ROUGH IDLE - PRESSING THE ACCELERATOR DID NOTHING. WE HAD TO COAST TO THE SIDE OF THE ROAD; FORTUNATELY THERE WAS VERY LITTLE TRAFFIC AT THE TIME, HAD TRAFFIC BEEN HEAVY WE COULD HAVE BEEN IN A VERY SERIOUS WRECK. AFTER HAVING THE VEHICLE TOWED TO A DEALERSHIP, WE LEARNED THAT THE THROTTLE BODY WAS FAULTY AND THIS HAS APPARENTLY BEEN A KNOW ISSUE WITH FORD FOR SEVERAL YEARS! THIS WAS A BRAND NEW VEHICLE THAT I HAVE OWNED LESS THAN 5 MONTHS. I STRONGLY BELIEVE FORD KNOWS ABOUT THIS PROBLEM BUT HAS REFUSED TO TAKE STEPS NEEDED TO RECTIFY THE SITUATION. EVEN THOUGH THE PART WAS ORDERED ON AN "EMERGENCY" BASIS, IT WAS OVER A WEEK BEFORE THE PART WAS DELIVERED;...

THIS PARTICULAR PROBLEM OCCURRED THREE TIMES OVER TWO DAYS. THE FIRST TIME I WAS DRIVING APPROXIMATELY 45MPH ON A CITY STREET WHEN A WRENCH LIGHT AND AIRBAG LIGHT CAME ON AND THE VEHICLE'S THROTTLE STOPPED RESPONDING. IF I LET OFF THE BREAK THE VEHICLE WOULD CONTINUE TO MOVE AT APPROXIMATELY 5MPH SO I WAS ABLE TO GET IT OFF THE ROADWAY. I TURNED THE VEHICLE OFF AND BACK ON AND IT SEEMED TO BE FUNCTIONING NORMALLY WITH THE CHECK ENGINE LIGHT ILLUMINATED. I WAS ABLE TO MAKE IT TO MY OFFICE WHERE I LEFT IT PARKED UNTIL AFTER LUNCH. WHEN I CRANKED UP THE VEHICLE AFTER LUNCH THE CHECK ENGINE LIGHT WAS NO LONGER ON. AFTER DRIVING APPROXIMATELY TEN MORE MILES I ATTEMPTED TO MAKE A LEFT TURN INTO A PARKING LOT WHEN THE SAME THING HAPPENED AND I WAS ALMOST HIT BY AN ONCOMING TRUCK. AFTER TURNING THE VEHICLE...

MY VEHICLE EMITS EXHAUST IN THE CABIN WHILE DRIVING. UPON ACCELERATION AND DECELERATION, THE EXHAUST SMELL IS SO POTENT, ME AND MY PASSENGERS HAVE TO ROLL DOWN THE WINDOWS. I RETURNED THE VEHICLE THE DAY AFTER PURCHASING TO THE FORD DEALERSHIP FOR REPAIRS AND HAVE RETURNED IT FOR REPAIRS MANY TIMES SINCE. THEY HAVE SEALED ALL OPENINGS UNDER THE VEHICLE, REPLACED THE EXHAUST SYSTEM, AND REPLACED THE VENTS IN THE BUMPER. FORD HAS ACKNOWLEDGED THERE IS AN ISSUE WITH MY EXPLORER, HOWEVER, THEY ARE UNABLE TO FIX IT. MY LAST REPAIR VISIT IN JUNE 2016, I WAS NOTIFIED THAT I NEED TO COME PICK UP MY VEHICLE BECAUSE THEY COULD DO NOTHING ELSE FOR IT. THEY HAVE TRIED TO REPAIR IT AND THEY ARE UNABLE TO REPAIR THE ISSUE. THIS HAS CAUSED VARIOUS HEALTH ISSUES FOR ME, WHICH INCLUDE, HEADACHES AND NAUSEA. FORD HAS IGNORED ALL OF MY REQUEST TO...

THROTTLE BODY - HAS FAILED. ORANGE WRENCH LIGHT CAME ON , RIGHT AFTER MAKING A RIGHT TURN AND CAR WENT INTO WHAT IS CALLED "LIMP MODE". THIS HAPPENED WHILE I WAS AT LEAST 200 MILES AWAY FROM HOME, IN MID SIZE CITY.

2016 POLICE UTILITY: WAS DRIVING THE VEHICLE DOWN THE HIGHWAY WHILE TRANSPORTING A PRISONER. VEHICLE IMMEDIATELY LOST POWER. VEHICLE WOULDN'T ACCELERATE. VEHICLE HAD STEERING AND BRAKE ONLY. VEHICLE MOTOR BEGAN TO SHAKE AND MISFIRE. VEHICLE TOWED TO FORD DEALERSHIP.

I WAS DRIVING HOME AT 10:00 AM AFTER VISITING A DOCTOR'S OFFICE ON A BUSY HIGHWAY AT 57 MPH WHEN ALL OF A SUDDEN THE CAR GAS PEDDLE IS NOT WORKING. THE CAR IS IN COMPLETE SHUT DOWN MODE. I ROLLED THROUGH AN INTERSECTION TO GET TO SAFE PLACE OUT OF TRAFFIC. THE CAR DASH BOARD SHOWED A WRENCH AND ENGINE LIGHT AND ON THE DASHBOARD A MESSAGE STATED "SEE MANUAL". THE CAR HAD COMPLETELY SHUT DOWN. SCARED TO DEATH AT WHAT JUST HAPPENED, I CALLED FORD WARRANTY NUMBER FOR A TOW TRUCK AND WAITED FOR 2 1/2 HOURS TILL FINALLY THE TOW TRUCK SHOWED UP. WHEN I GOT TO THE DEALERSHIP WHERE I PURCHASED THE CAR, I WAS SERIOUSLY DEVASTATED. TWO MANAGERS TOLD ME THEY DIDN'T KNOW WHAT WAS WRONG WITH THE CAR, BUT THEY WOULD WORK TO FIND OUT. THEY KNEW WHAT THE PROBLEM WAS AND HOW SERIOUS...

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THE THERE WAS A FUEL ODOR BEING RELEASED INTO THE VEHICLE. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED, THE ODOR WAS PRESENT AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT NO REMEDY WAS PROVIDED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 4,000. THE VIN WAS NOT PROVIDED.

ON 06/24/2016 I WAS DRIVING MY FAMILY NORTH ON I95 THE BELT WAY / MARYLAND 5 LANES OF TRAVEL IN HEAVY TRAFFIC. WITHOUT WARNING OUR 2016 FORD EXPLORER COMPLETELY LOST POWER AND A WRENCH INDICATOR LIGHT CAME ON THE DISPLAY. THIS WAS IN THE APPROACH OF THE FT.MC HENERY TUNNEL WE HAD NO PLACE TO GO WITH A TRACTOR TRAILER ALMOST STRIKING US,MY FAMILY WAS TERRIFIED . THE VEHICLE DID START AGAIN 3 MINUTES LATER WITH NORMAL RPMS WE ATTEMPTED TO DRIVE ON WITH THIS HAPPENING 4 MORE TIMES CAUSING US TO GO TO THE SHOULDER. I AM A POLICE OFFICER AND A TRAFFIC INVESTIGATOR I AM IN FEAR BECAUSE THIS IS A WELL KNOWN PROBLEM AND WE WERE NOT CONTACTED BY FORD ABOUT THIS PROBLEM MY FAMILIES SAFETY AND THE PUBLICS IS AT AN EXTREME RISK, THIS MUST BE ADDRESSED BEFORE A TRAGEDY HAPPENS. I HAVE SINCE CALLED MY...

4 MONTHS AFTER PURCHASING A NEW EXPLORER, IT BEGAN TO LURCH WHILE WAITING AT RED LIGHTS. THAT SAME WEEK, WHILE DRIVING ON THE DALLAS NORTH TOLLWAY (70 MPH), THE DASHBOARD LIT UP AND THE CAR BEGAN TO DECELERATE (GAS PEDAL DID NOT WORK). AFTER DODGING CARS, I MADE IT OVER 3 LANES WITH THE HAZARD LIGHTS ON AND PROCEEDED TO THE EXIT RAMP. I WAS ABLE TO SLOWLY PULL OFF THE RAMP ACROSS 3 LANES (ROLLING) TO A PARKING LOT. THE EXPLORER HAD TO BE TOWED (FLATBED) TO THE DEALERSHIP.

I WAS DRIVING IN THE LEFT LANE OF AN INTERSTATE HIGHWAY AT ~65 MPH WHEN MY VEHICLE DECELERATED DOWN TO 15 MPH. THE VEHICLE WAS STILL RUNNING BUT IT WAS ESSENTIALLY 'DEAD' IN THAT NOTHING HAPPENED WHEN YOU STEP ON THE GAS PEDAL. I WAS LOSING SPEED BY THE SECOND AND COULD NOT MAKE IT OVER TO THE RIGHT LANE DUE TO HEAVY TRAFFIC, SO I WAS LUCKY AND FOUND A SMALL LEFT SHOULD TO PULL OVER ON. IF THERE WAS NO LEFT SHOULDER, I DON'T KNOW WHAT THE OUTCOME WOULD HAVE BEEN. AFTER BEING TOWED TO THE LOCAL FORD DEALER/SERVICE SHOP, IT WAS DETERMINED TO BE AN ELECTRONIC THROTTLE BODY(ETB) WHICH FAILED. FORD REPLACED THE ETB, BUT STATED THE REPLACEMENT ETB WAS THE SAME AS THE ONE WHICH FAILED. THERE WAS NO REASSURANCE THAT THE PROBLEMATIC ETB WAS BEING REPLACED WITH A MORE DURABLE SOLUTION. THE FORD SERVICE SHOP...

HI I NEED HELP WE ARE HAVING ISSUE WITH OUR 2016 FORD EXPLORER SPORT WE ONLY HAVE IT FOR 3 MONTHS 2K MILEAGE, WE NOTICED THE HOOD VIBRATE AT 65MPH OR OVER ON FREEWAY, I BROUGHT IT TO MY NEAREST FORD DEALER, "FORD SERRAMONTE" ON 05/16/16 THE SERVICE MANAGER NAME HENRY SAID THEY ARE AWARE OF IT BUT COULDN'T DO ANYTHING & THEY ARE WAITING FOR FORD TO FIND THE SOLUTION TO FIX IT, BUT THEY DIDN'T EVEN CHECK THE HOOD. I CONTACTED FORD CUSTOMER CARE TEAM ON 05/18/16 & THEY OPEN A CASE, CASE NUMBER: CAS-9514452-P1Y5C2 TARA MELVIN COSTUMER CARE MANGER HANDLING THE CASE. WE ARE PROSTRATED BECAUSE IT'S BRAND NEW CAR & ALREADY HAS A LOT OF PROBLEMS, IT WAS DISTRACTIVE DRIVING THE VEHICLE SO I'M SCARED SPECIALLY I'M ALWAYS WITH MY 1YR & 4YRS OLD SON, THEY JUST TOLD ME TO WAIT & IT'S BEEN MORE THAN...

THE VEHICLE WENT INTO LIMP MODE RPM AND SPEED WHERE REDUCED TO 1000 RPM (MAX) AND 5-10 MPH WHILE RESPONDING TO A POLICE MATTER AS THE VEHICLE IS THE POLICE MODEL AND PURCHASED AS A POLICE CAR. UPON RESEARCH, THE ELECTRIC THROTTLE BODY HAS BEEN A PROBLEM FOR A NUMBER OF YEARS AND HAS NOT BEEN ADDRESSED. THIS IS A POLICE VEHICLE AND NOT RELIABLE AT ALL. THE VEHICLE HAS 3960 MILES ON IT AND DEPT IS BEING TOLD IT WILL BE 2-3 MONTHS BEFORE BACK IN SERVICE. RESEARCH DONE ON INTER NET FINDS THIS HAS BEEN AN ON GOING ISSUE WITH FORD FOR A NUMBER OF YEARS AND BEING OVER LOOKED BY THE REGULATING AGENCIES.

I WAS TRAVELING IN THE NUMBER ONE LANE AT 65MPH IN HOLIDAY TRAFFIC AND I SUDDENLY LOST ALL THROTTLE RESPONSE. RPM DROPPED TO 1,500 AND SPEED DROPPED TO 10MPH THIS ALMOST CAUSED A REAR ENDER SINCE NO BRAKE LIGHTS CAME ON. THIS IS A LIFE AND DEATH ISSUE!