2011 FORD EXPLORER Engine Problems

CAR WAS FINE THEN ALL OF A SUDDEN OVER HEATING SIGN WENT ON IN THE CAR . I PULLED OVER ON THE FREEWAY CALLED A TOW TRUCK BECAUSE I WAS TOLD NOT TO DRIVE THE CAR. I HAD IT TOWED TO MY HOUSE HAD A PROFESSIONAL MECHANIC LOOK AT IT AT MY HOUSE I WAS THEN TOLD THAT THERE WAS A LEAK AND THE WATER TANK WAS NOT HOLDING WATER BECAUSE OF IT. THE NEXT DAY I WENT TO MY CAR I TURNED IT ON AND CHECK ENGINE LIGHT WAS ON. I THEN TURNED OFF THE CAR CAUSE I DID NOT WANT TO CAUSE ANYMORE DAMAGE. THE MECHANIC CAME BACK TO MY HOUSE AND TOLD ME IT WAS NOW LEAKING WATER AND OIL TO TAKE IT IN RIGHT AWAY. I HAD NO PREVIOUS PROBLEMS WITH MY CAR UNTIL THAT POINT. I TAKE IT TO THE DEALER THEY TELL ME THAT...

I PURCHASED MY VEHICLE IN MARCH OF 2016. I FIRST HAD ISSUES WITH THE BRAKING SYSTEM. I HEARD SCREECHING AND WHIRRING AS I DROVE THE VEHICLE. NEXT, I HAD ISSUES WITH THE BATTERY, BATTERY ACID LEAKED ALL OVER THE BATTERY, CORROSION BUILT UP ON THE BATTERY. MOST RECENTLY, AFTER SERVICING MY VEHICLE, THE POWER STEERING LOCKED UP. THE COMPUTER READ THAT THERE WAS POWER STEERING FAULT. I DON'T UNDERSTAND HOW I WAS ABLE TO PURCHASE A VEHICLE OFF THE DEALERSHIP LOT WITH ALL OF THE ISSUES THAT THE VEHICLE HAD.

I FIRST BEGAN EXPERIENCING BRAKING AND BATTERY ISSUES 3 TO 4 WEEKS AFTER THE PURCHASE OF MY VEHICLE. I TOOK THE VEHICLE IN FOR SERVICING OF THE BRAKING AND BATTERY ISSUES. I WAS INFORMED BY THE SERVICE ADVISOR THAT I SHOULD RETURN THE VEHICLE TO DEALERSHIP FOR REPAIRS DUE TO THE MULTIPLE ISSUES WITH VEHICLE. AT THAT TIME, I LEARNED THAT THERE WAS LEAKAGE FROM THE UPPER PORTION OF THE ENGINE. THE DEALERSHIP ADDRESSES SOME BUT NOT ALL ISSUES RELATED TO THE VEHICLE. NEXT, I RECEIVED AN EMAIL FROM THE DEALERSHIP STATING THE VEHICLE WAS DUE FOR FACTORY RECOMMENDED SERVICING. I MADE AN APPT. THE NEXT DAY, THE LOW BATTERY LIGHT CAME ON. CALLED DEALERSHIP, NO RESPONSE. ONE AND A HALF WEEKS LATER, THE BATTERY WAS DEAD. CALLED TRIPLE A. BATTERY HAD BATTERY ACID AND CORROSION EVERYWHERE. A RED SOLUTION WAS SPRAYED ON THE BATTERY TO PREVENT LEAKAGE. BUT IT...

WENT TO GO DRIVE THE SUV WHILE DOING ONLY 25 MPH & IT WAS RAVING OUR 3-5 RPM. WHILE DRUG IN THE CITY

WE HAVE EXHAUST IN THE PASSENGER COMPARTMENT WHEN CLIMBING A HILL OR AT A TRAFFIC STOP WHEN THE ENGINE IS RUNNING, WE NOTICE THE PROBLEM WHEN UNDER ACCELARATION AND WHILE USING THE HEATER/AC. WILL OPEN THE WINDOW WHEN STOPPED WITH THE CAR IDELING TO LESSEN THE SMELL. HAVE COMPLAINED TO FORD BUT HAVE HAD NOTHING DONE. THERE IS A TECHNICAL BULLITEN ON THE VALVE COVER WITH A REPLACEMENT PART BUT FORD HAS NOT RECALLED IT AND WILL NOT FIX THE PROBLEM.

WHEN DRIVING THE VEHICLE ON THE HIGHWAY OR WHEN ACCELERATING THE INSIDE OF THE VEHICLE SMELLS OF ROTTING EGGS. FROM TIME TO TIME IT IS SMELT WHEN SITTING AT AND IDLING. THIS HAS BEEN AN ONGOING PROBLEM WITH OUR 2011 FORD EXPLORER.

STRONG ENGINE EXHAUST SMELL IN VEHICLE CABIN WHILE DRIVING, DURING ENGINE OPERATION ABOVE 3000-3500 RPM WITH WINDOWS CLOSED AND CLIMATE CONTROL ON. OUTSIDE AIR ON OR OFF SEEMS TO MAKE NO DIFFERENCE.

WHILE DRIVING AND ESPECIALLY AFTER, THERE IS A BURNING HAIR SMELL THAT IS IN THE CAR AND WHEN YOU STEP OUTSIDE THE CAR IT IS VERY STRONG IN THE ENGINE. UPON LEARNING OF THE CLASS ACTION LAWSUIT TOO LATE, IT HELPED MAKE SENSE WHY I WAS SMELLING THE "BURNT HAIR" SMELL WHEN I RAN THE HEATER AND/OR AC. THIS WAS ANYTIME I DROVE THE CAR WHETHER HIGHWAY DRIVING OR AROUND TOWN.

HAVE EXTENSIVE ENGINE DAMAGE DUE TO WATER PUMP FAILURE WITH NO WARNING! I WAS DRIVING MY VEHICLE DOWN A MAIN HIGHWAY AND ALL OF A SUDDEN THE "ENGINE COOLANT OVERTEMP" CAME ON THEN "LOW OIL PRESSURE" AND MY VEHICLE SHUT DOWN! I COULDN'T DRIVE THE VEHICLE. LUCKILY I DRIFTED TO SIDE OF THE ROAD SO THAT MY CAR COULD BE TOWED WITHOUT HAVING AN ACCIDENT! SHOP DETERMINED WATER PUMP FAILURE AND WATER LEAKED INTO MY ENGINE POOR ENGINE DESIGN ON FORDS PART) AND DESTROYED THE ENGINE WITH NO WARNING! NO ENGINE LIGHT CAME ON OR ANYTHING. PLEASE INVESTIGATE THIS. THERE ARE NUMEROUS COMPLAINTS ABOUT THIS SAME SITUATION. I CALLED FORD TO COMPLAIN BUT ALL THEY DID WAS TAKE DOWN MY COMPLIANT. THIS IS A SAFETY ISSUE BECAUSE I WAS DRIVING IN TRAFFIC AND THIS COULD HAVE CAUSED AN ACCIDENT. THE WHOLE CAR JUST SHUT DOWN! *TR

UPON HEAVY ACCELERATION SUCH AS WHEN PULLING ONTO A HIGHWAY, OR PASSING ANOTHER VEHICLE ON THE ROAD, AN EXHAUST/FUEL SMELL WILL ENTER THE VEHICLE AND BE VERY NOTICEABLE TO EVERYONE IN THE VEHICLE. THIS OCCURS MOSTLY WHEN THE AIR CONDITIONER IS ON, ON RECIRCULATION. MY WIFE (PRIMARY DRIVER OF THIS 2011 FORD EXPLORER) COMPLAINS OF A LOT OF HEADACHES AND I AM BEGINNING TO WONDER IF SHE IS GETTING CARBON MONOXIDE POISONING FROM DRIVING THIS VEHICLE DAILY. WE ARE GOING TO BUY A CO2 DETECTOR TO SEE IF THIS IS IN FACT TRUE.

MY 2011 FORD EXPLORER LOST POWER EVEN THOUGH THE ENGINE DID NOT DIE THERE WAS NO POWER WHEN PRESSING ON GAS PEDAL. THE YELLOW WRENCH LIGHT CAME ON THE PANEL. I TURNED THE IGNITION OFF AND WAITED A FEW MINUTES AND IT RESTARTED. I TOOK IT TO A DEALER AND THEY COULDN'T GET ANYTHING TO REGISTER. I PICKED THE CAR UP ANYD BEFORE I MADE IT HOME IT LOST POWER AGAIN. I TOOK IT BACK IN AND THEY STILL COULDN'T GET ANYTHING TO REGISTER. THEY REPLACED THE BA SENSOR FIR $500 SINCE MY AIR FILTER WAS DIRTY AND COULD BE THE CAUSE OF PROBLEM. A WEEK LATER THE CAR STOPPED AGAIN. IT HAPPENED AGAIN A FEW DAYS LATER AND THEN IT STALLED 4 TIMES IN ONE DAY AND THE ENGINE LIGHT CAME ON AND STAYED. I BORROWED A CODE READER AND THE CODE P2111 APPEARED. I GOOGLED THIS AND IT...

EXHAUST FUMES ENTER THE PASSENGER COMPARTMENT WHEN THE AC IS RUNNING AT HIGHWAY SPEEDS AND AT ANY SPEED WHEN THE ENGINE IS TAXING IE GOING UP A STEEP GRADE.

BAD BURNING SMELL UNDER ACCELERATION TO HIGHWAY SPEED COMING FROM AIR VENTS. OIL WAS FOUND IN THE AIR FILTER HOUSING AND PIPING NEAR MASS AIR FLOW SENSOR.

LONG STORY SHORT, I PULLED OUT OF MY NEIGHBORHOOD GOT ABOUT A QUARTER OF A MILE DOWN THE ROAD. HEARD THE DRIVE BELT SQUEAL FOR ABOUT 15 SECONDS, FOLLOWED BY CHECK ENGINE LIGHT, AND EXTREME ENGINE KNOCK. THE VEHICLE WAS SHUT OFF IMMEDIATELY. THE CODES READ, CRANKSHAFT/CAMSHAFT CORRELATION BANK A SENSOR 1, THE SECOND CODE WAS ENGINE KNOCK. VEHICLE TOWED TO THE DEALER WERE THEY HAD 2 OF THEIR TOP TECHNICIANS LOOK AT THE VEHICLE AND THE BOTH REPORTED THE WATER PUMP HAD FAILED AND FILLED THE ENGINE UP WITH COOLANT WHICH CAUSE THE ENGINE TO EXPIRE. MY WIFE ONLY HAD THE TRUCK FOR 2 YEARS AND SHE'S VERY CAREFUL DRIVER. NO WOARNING SIGNS OF A FAILING WATER PUMP. JUST GOT BACK FROM A 7HR ROAD TRIP A WEEK BEFORE THE WATER PUMP FAILED AND THE ENGINE EXPIRED.

I WANT TO STATE THAT MY TRUCK DOES THE SAME THING AS REPORTED IN THIS PROBLEM. THE SMELLS GETS REAL BAD IN THE CABIN WHEN ENTERING HIGHWAY OR CROSSING VEHICLES NHTSA ACTION NUMBER: PE16008 COMPONENT(S): ENGINE AND ENGINE COOLING , STRUCTURE

I WAS LEAVING MY HOUSE PULLING A KAYAK TRAILER WITH ONE KAYAK ON IT, WENT ABOUT A HALF BLOCK AND THE ENGINE SLOWED DOWN AND THE FORD EXPLORER WOULD HARDLY MOVE. WAS ABLE TO GO AROUND THE BLOCK AND MAKE IT BACK TO MY DRIVEWAY. AFTER STOPPING AND RESTARTING THE PROBLEM WAS GONE. I HAD THE FORD EXPLORER TOWED TO THE DEALER WERE I BOUGHT IT, THEY CHECKED IT AND SAID IT DIDN'T SHOW A ERROR CODE ON THE COMPUTER AND DROVE IT TWICE AND COULD NOT MAKE IT HAPPEN SO THERE WAS NOTHING THEY COULD DO. I RESEARCHED THE PROBLEM AND FOUND OUT IT IS THE ELECTRONIC THROTTLE BODY AND THEY HAVE CHANGED OVER ONE MILLION OF THEM. BOTH YOU AND FORD ARE AWARE OF THE PROBLEM BUT A RECALL WAS NEVER ISSUED. ALSO ONCE THIS HAPPENS IT WILL HAPPEN AGAIN UNTIL THE PROBLEM IS FIXED. I HAVE A...

AFTER HARD ACCELERATION AND LET UP EXHAUST SMELL GETS IN THE COMPARTMENT TO THE POINT YOU HAVE ROLL THE WINDOWS DOWN TO CLEAR IT OUT FORD HAS TRIED TO FIX IT THEY HAVE A SERVICE.

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING WHILE THE CRUISE CONTROL WAS SET AT 58 MPH. THE CONTACT WAS ABLE TO COAST THE VEHICLE ONTO THE ROAD SHOULDER. ONCE THE VEHICLE WAS RESTARTED, IT RESUMED NORMAL OPERATION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 83,000.

UNDER HARD ACCELERATION I GET A STING ODOR IN THE CABIN. IT IS LIKE AN EXHAUST SMELL INSIDE THE CAR. IT ALWAYS DOES IT ABOVE 3500 RPM.

SINCE PURCHASING MY 2011 EXPLORER, I HAVE JUST REPLACE THE COOLANT FAN ON JUNE 20,2015. THIS IS THE SECOND TIME THE FAN HAS QUIT WORKING ENTIRELY AND CAUSED THE VEHICLE TO OVERHEAT AND REQUIRED IMMEDIATE REPLACEMENT. REQUESTED FORD TO REIMBURSE COST OF MOST RECENT REPAIR.

I SENT MY VEHICLE IN TWO MONTHS FOR TO BE FIX AT DREW FORD DEALERSHIP. THEY ALSO CORRECTED A RECALL ON THE POWERSTEERING FAULT. NOW THE FAULT IS BACK AND THE STEERING WHEEL IS IMMOVABLE OR EXTREMELY HARD TO MOVE. THEY ALSO CLAIM THIS WILL NOT FALL UNDER THE RECALL, BECAUSE IT HAS BEEN REMEDY THE FIRST TIME. I AM VERY UPSET WITH FORD, BECAUSE THIS CAN BE A 600-2000 DOLLAR REPAIR. POWER STEERING SHOULD NOT GO THIS FAST, MY CAR IS BARELY 4 YEARS OLD. I MAY HAVE TO TRADE IT IN FOR MORE RELIABLE VEHICLE LIKE A HONDA OR TOYOTA. I WANT TO SUPPORT AMERICAN COMPANIES. THIS EXPERIENCE LEFT ME WITH A BAD TASTE IN MY MOUTH. *TR

TL* THE CONTACT OWNS A 2011 FORD EXPLORER. WHILE DRIVING AT ANY SPEED, THE POWER STEERING AND COMPUTER FAILED. IN ADDITION, THE ENGINE, ABS, TRACTION CONTROL, AIR BAG, AND SECURITY SENSORS ILLUMINATED. THE DEALER ADVISED THE CONTACT TO RESET THE MASTER CONTROLS. THE VEHICLE ALSO EXHIBITED COMPUTER FAILURE. THE FIRMWARE WAS UPDATED MULTIPLE TIMES, HOWEVER THE FAILURE RECURRED MONTHS LATER AND INCLUDED VARIOUS ELECTRICAL SHORTS. WHILE DRIVING AT AN UNKNOWN SPEED, THE POWER STEERING FAILED. THE VEHICLE WAS TOWED TO THE AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE CONTACT WAITED FOR MONTHS TO DETERMINE IF THE DEALER WAS ABLE TO PROVIDE A REMEDY TO THE FIRMWARE FAILURE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 14V286000 (STEERING) AND 14E001000 (STEERING). THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

THIS IS A MAJOR SAFETY CONCERN. WHILE DRIVING AN INDICATION OF A MALFUNCTION IN THE AWD SYSTEM SHOWS ON THE DASHBOARD & SYNC COMPUTER. THE ENGINE LOSES COMPLETE POWER AND YOU MUST PULL OVER AND RESTART THE VEHICLE TO RESET THE ON-BOARD COMPUTER. THIS LOSS OF POWER HAPPENS ON THE HIGHWAY AND IS AT GREAT RISK OF CAUSING SERIOUS ISSUES TO OTHER TRAFFIC. NOT TO MENTION WHEN I HAVE MY CHILD IN THE VEHICLE. I HAVE TAKEN IT TO ROSNER FORD DEALERSHIP IN KING GEORGE VA (THEY COULDN'T FIND A ISSUE 4 FOUR TIMES NOW). IT HAPPENS WITH FREQUENT AND UNREGULAR INTERVALS. I HAVE REPEATEDLY WENT BACK TO THE DEALERSHIP TO FIX. THE FORD MOTOR COMPANY (THROUGH MY EXPERIENCE WITH THE SERVICE DEPT) SEEMS AS IF THEY DON'T CARE EVEN WHEN I EXPRESSED THE SAFETY CONCERN. I BELIEVE THE COMPUTER PROBLEM IS A BIGGER THING THAN REALIZED. HOPEFULLY THIS WILL...

AS I WAS MERGING ON TO THE HIGHWAY, I ACCELERATED TO REACH THE SAME SPEED OF THE TRAFFIC. THE ENGINE REVVED OVER 3500 RPM. MY AIR CONDITIONER WAS ON AND SET TO RECIRCULATE THE AIR. SHORTLY AFTER MERGING ONTO THE HIGHWAY, I SMELLED EXHAUST FUMES IN THE CABIN OF MY CAR. *TR

DRIVING DOWN THE INTERSTATE AT 70MPH, WARNING COMES ON THE CONSOLE "AWD IS OFF" AND THE ENGINE IS DOWN TO IDLE SPEED (~800 RPM). PRESSING THE ACCELERATOR RESULTS IN NO SPEED INCREASE, FORCING ME TO MOVE ACROSS 4 LANES OF TRAFFIC TO THE EMERGENCY LANE WITH ONLY THE BRAKES WORKING (NO CONTROL OVER MY SPEED, OTHERWISE). PULLED OVER, STOPPED THE ENGINE, LOOKED AROUND AND COULD SEE NO EXTERNALLY VISIBLE PROBLEMS (FLUID LEAKS, ETC.). START THE CAR AND THERE ARE NO WARNINGS, SO I CONTINUE DOWN THE ROAD, BUT THIS TIME STAY IN THE RIGHT LANE AND KEEP THE SPEED TO AROUND 60. LESS THAN 1 MILE DOWN THE ROAD, THE EXACT SAME THING HAPPENS. AT THIS POINT WE CALL FORD TO GET US A TOW. THIS WAS A VERY DANGEROUS EVENT TO HAPPEN, ESPECIALLY WHEN I HAD THE EXPLORER FULL WITH MY FAMILY! TODAY THE SERVICING DEALER CALLED AND SAID...

WHEN MERGING INTO LANE AND PASSING A CAR ABOUT 3500 RPM EXHAUST GAS ENTERS PASSENGERS CABIN AND EVERYONE INSIDE WILL COMPLAIN OF VERY STRONG ODOR, BREATHING PROBLEM AND HEADACHE. HAD THIS PROBLEM SINCE CAR WAS NEW AND DEALING WITH UNCOMFORTABLE SMELL WITH THE REST OF THE FAMILY. WIFE HAD NUMEROUS TIMES HAVING PROBLEM CONCENTRATING DRIVING BECAUSE THE EXHAUST FUMES OR ODOR IS CAUSING HER TO HAVE HEADACHES AND ALMOST PASSING OUT ON LONG TRIPS. IT IS A HAZARDOUS/DANGEROUS ISSUE. IF FORD CAN HAVE A FIX ON THIS AND IT HAS TO BE SOON. I THINK IT IS THOUSAND OR HUNDRED OF THOUSAND OF FORD VEHICLES OUT THERE THAT HAS THIS PROBLEM. PLS. DON'T WAIT FOR SOMETHING LIKE GM DID. *TR

AFTER A RAPID ACCELERATION IN ORDER TO GET TO TOLL SPEEDS (65MPH) THE VEHICLE STARTED TO PRODUCE A BURNT SMELL. THOUGHT IT COULD BE NEW VEHICLE STUFF BUT RIGHT KNOW ITS 30,000 MILES AND EVERY TIME I GO OVER 4000 RPM ON A RAPID ACCELERATION IT GIVES ME THE ODOR, PLUS THE VEHICLE LOSSES POWER ON THE HILLS. DISAPPOINTING WHEN YOU PAY OVER 40,000 FOR A NEW LUXURY SUV. *TR

WHILE DRIVING THE CAR DIES AND THE YELLOW WRENCH LIGHT APPEARS. THIS OCCURRED TWICE IN ONE DAY. THE FIRST TIME IT OCCURRED I WAS JUST BEGINNING TO ACCELERATE. I WAS ABLE TO PULL OVER AND RESTART THE CAR. THE SECOND INCIDENT OCCURRED WHILE DRIVING DOWN THE HIGHWAY. I WAS ABLE TO PULL OVER AND RESTART THE CAR. I IMMEDIATELY BROUGHT IT TO A FORD DEALER WHO HAS HAD THE CAR FOR THREE DAYS AND CANNOT FIND OUT WHAT IS WRONG. *JS

DURING HARD ACCELERATION ONTO A HIGHWAY OR FROM A STOP, THE INTERIOR OF THE VEHICLE FILLS WITH THE ODOR OF EXHAUST FUMES. THIS OCCURS EVERY TIME AND IS NOT RANDOM. *TR

ENGINE OVERHEATS WHEN IDLE, OR IN SLOW STOP AND GO TRAFFIC. I HAD THIS ADDRESSED ONCE BY FORD DUE TO A BULLETIN, BUT IT SEEMS TO BE DOING IT AGAIN. *TR

UPON MEDIUM TO HEAVY ACCELERATION, SUCH AS ACCELERATING ONTO A FREEWAY, THE VEHICLE CABIN IS FILLED WITH EXHAUST FUMES FROM THE ENGINE. THIS INJURES THE RESPIRATORY SYSTEM OF THE PASSENGERS. FORD HAS FINALLY ADMITTED THAT THERE IS A PROBLEM, AND THEY ARE WORKING ON A FIX (AFTER MY FAMILY HAS BEEN BREATHING POLLUTED AIR FOR ALMOST 1.5 YEARS). *TR

PURCHASED THIS VEHICLE FOR MY WIFE A LITTLE OVER A YEAR AGO. AT FIRST EVERYTHING WAS FINE BUT THEN AT ABOUT FOUR MONTHS WE STARTED HAVING ISSUES WITH THE WINDOW NOT ROLLING UP. THE DEALER TOOK CARE OF THAT ISSUE WITH NO PROBLEMS. THEN WE TAKE IT IN FOR THE SCHEDULED MAINTENANCE (OIL CHANGE/TIRE ROTATION) & OUR TIRES HAD INSIDE CUPPING IN WHICH THE DEALER DOES NOTHING ABOUT & STILL HAVE NOT. AT AROUND 22K MILES MY WIFE NOTICES THE VEHICLE STARTING TO JERK WHEN STOPPED OR MOVING. OVER THE PAST 8K MILES THIS GETS WORSE & GETS TO WHERE THE VEHICLE HAS STALLED OUT NUMEROUS TIMES (STILL OR MOVING). I HAVE MADE AN APPOINTMENT WITH THE DEALER TO RESOLVE THIS ISSUE. NOT SURE THE CAUSE YET. *TR