2011 FORD EXPLORER Fuel System Gasoline Problems

The contact owns a 2011 Ford Explorer. The contact stated that while driving at an undisclosed speed, the contact detected an abnormal fuel odor. The vehicle was taken to an independent mechanic, who diagnosed that there was a vapor leak coming from the top of the fuel tank. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 102,000.

WHEN MERGING INTO LANE AND PASSING A CAR ABOUT 3500 RPM EXHAUST GAS ENTERS PASSENGERS CABIN AND EVERYONE INSIDE WILL COMPLAIN OF VERY STRONG ODOR, BREATHING PROBLEM AND HEADACHE. HAD THIS PROBLEM SINCE CAR WAS NEW AND DEALING WITH UNCOMFORTABLE SMELL WITH THE REST OF THE FAMILY. WIFE HAD NUMEROUS TIMES HAVING PROBLEM CONCENTRATING DRIVING BECAUSE THE EXHAUST FUMES OR ODOR IS CAUSING HER TO HAVE HEADACHES AND ALMOST PASSING OUT ON LONG TRIPS. IT IS A HAZARDOUS/DANGEROUS ISSUE. IF FORD CAN HAVE A FIX ON THIS AND IT HAS TO BE SOON. I THINK IT IS THOUSAND OR HUNDRED OF THOUSAND OF FORD VEHICLES OUT THERE THAT HAS THIS PROBLEM. PLS. DON'T WAIT FOR SOMETHING LIKE GM DID. *TR

UPON MEDIUM TO HEAVY ACCELERATION, SUCH AS ACCELERATING ONTO A FREEWAY, THE VEHICLE CABIN IS FILLED WITH EXHAUST FUMES FROM THE ENGINE. THIS INJURES THE RESPIRATORY SYSTEM OF THE PASSENGERS. THEY ARE WORKING ON A FIX (AFTER MY FAMILY HAS BEEN BREATHING POLLUTED AIR FOR ALMOST TWO AND A HALF YEARS). FORD HAS FINALLY ADMITTED THAT THERE IS A PROBLEM, AND SEND ME A LETTER THAT SAID. [XXX] FORD CUSTOMER SERVICE DIVISION MARCH 7, 2014 [XXX] [XXX] SUBJECT: CUSTOMER CONCERN - EXHAUST ODOR ON 2011-2014 EXPLORER, EDGE OR MKX WE THANK YOU FOR TAKING THE TIME TO DISCUSS THE CONCERN OF EXHAUST ODOR IN YOUR VEHICLE. TO ADDRESS YOUR CONCERN ABOUT EXHAUST ODOR, WE HAVE PERFORMED SEVERAL INSPECTIONS AND SEALING ACTIONS WHERE APPLICABLE ON YOUR VEHICLE TO HELP MINIMIZE THE AMOUNT OF ODOR COMING INTO THE PASSENGER COMPARTMENT. WITH THESE CHANGES YOU MAY STILL EXPERIENCE ODOR UNDER CERTAIN DRIVING CONDITIONS...

THE CHECK ENGINE LIGHT WENT ON MY 2011 FORD EXPLORER ON 11/21/11 AND TOOK IT TO THE DEALER AT WHICH TIME I WAS TOLD IT WAS A LEAK IN THE GAS CAP (BUT THIS CAR HAS A CAP-LESS GAS TANK) CHECK ENGINE LIGHT WENT OFF AND BACK ON WITHIN 1 WEEK, TOOK IT BACK ON 11/26/11 AND AT THAT TIME THEY SAID THEY GOT THE SAME READING WITH THE GAS CAP ISSUE AND THEY CHANGED A SOLENOID. CHECK ENGINE LIGHT WENT OFF ONLY TO GO BACK ON 3 DAYS LATER. DROPPED MY CAR OFF AT DEALER ON 12/3/11 FOR 3RD TIME AND NOW THEY TOLD ME THEY KEEP GETTING SAME ERROR CODE AND THEY SENT ISSUE TO TECH'S IN DETROIT FOR ASSISTANCE. I WILL BE DROPPING MY CAR OFF TODAY (12/7/11) AGAIN TO SEE IF THEY CAN FIX IT. CHECK ENGINE LIGHT REMAINS ON. *TR