2020 FORD EDGE — Problems, Recalls & Safety Data

My vehicle is a 2020 Ford Edge SEL. I am experiencing ongoing transmission shuddering, jerking, and RPM fluctuations during normal driving. At slow speeds, the vehicle jerks and shudders, making it very difficult to drive smoothly in traffic and when accelerating from a stop. At higher speeds, the RPM gauge jumps while driving, and the vehicle feels like it is slipping or shifting unpredictably. The condition has been getting worse over time. This problem matches the known defect described in Ford Technical Service Bulletin (TSB) 20-2081 related to transmission shudder. My vehicle’s year, make, and model match those affected by this known issue; however, my VIN is not included in any recall. The unpredictable jerking, shuddering, and RPM fluctuations create unsafe driving conditions, especially when merging into traffic, turning, or maintaining speed. I believe this is a widespread defect affecting the safe operation of the vehicle and should be investigated by NHTSA for a potential recall. I am submitting this complaint to request that this defect be reviewed for investigation and corrective action.

My 2020 Ford Edge Titanium experienced a complete transmission failure at just 65,898 miles—less than 6,000 miles beyond the factory warranty. Fortunately, I had purchased a Lifetime Limited Warranty through a third-party provider, American Colonial Administration, LLC. During my research on the 8F35 transmission, I discovered numerous consumer complaints, particularly affecting the 2019–2021 model years. I also reviewed estimated replacement costs, which typically ranged from $5,500 to $9,000. However, the Ford dealership charged $11,596.27 for the replacement. The warranty company covered $9,791.29, leaving me responsible for $1,804.98 out of pocket, in addition to $408 for towing and $421 for a one-week rental car. My vehicle remained in the shop for a total of 33 days, leaving me without transportation for 26 days. I contacted Ford Motor Company in Dearborn, Michigan to request cost assistance, given the documented issues with the 8F35 transmission. I was informed that no Customer Satisfaction Program (CSP) applied to my situation. I was also told that dealerships are independently owned and operated, which ultimately meant Ford would not offer any help—even though the failure resulted from a known problem with their own product.

my 2020 ford edge suddenly started failing to catch the gear when driving, the rpms would rev but the car would not speed up, when it would finally catch, the car would jerk forward. No warning, no heads up, I just got in my car one day and the problem existed. I bought this car new, I am the sole owner and I routinely take it in for upkeep. It has 62,000 miles on it so JUST over the 60k warranty. I took the car to the local Ford dealership who informed me that the torque converter was going out. After looking the issue up online, its was apparent that this is a known issue very common the this year. This is a faulty part that has yet to be recalled. I asked the Ford dealership about this issue and they confirmed that it was a very common problem and they had 2 vehicles currently in their shop for the same problem. The quote to correct this issue is thousands of dollars.

Safety Defects and Mechanical Failures My 2020 Ford Edge (VIN: [XXX] ) is plagued by systemic safety defects that render it unroadworthy under Pennsylvania law (37 Pa. Code § 301.2).[1, 2] The 8F35 transmission suffers from a documented "shudder" and loss of motive power (TSB 21-2389), creating a high risk of collisions in traffic.[3, 4, 5] Additionally, the vehicle is subject to critical federal recalls: Recall 21S02 (21V-011) regarding sudden rear axle seizure [6, 7, 8] and Recall 20S49 (20V-550) regarding a lethal fire hazard from leaking transmission fluid.[9, 10, 11] The engine also exhibits a design flaw known as "coolant intrusion" (TSB 19-2346), which leads to catastrophic engine failure and hydro-lock.[12, 13, 14] ​Deceptive Trade Practices and Lender Liability CarMax sold this vehicle as "Quality Certified" without fulfilling the disclosure requirements mandated by the 2022 Multistate Attorney General Settlement.[15, 16] Specifically, CarMax failed to provide the required standalone, signed disclosure form for open safety recalls prior to the sale.[17, 18, 15] Because this transaction was financed through Santander Consumer USA, the lender is derivatively liable for CarMax’s deceptive acts under the FTC Holder Rule (16 C.F.R. § 433).[19, 2] This federal rule allows me to assert all legal claims and defenses against Santander that I have against CarMax, including breach of the implied warranty of merchantability, which overrides any "As-Is" disclaimer when a vehicle is sold in a non-roadworthy condition INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Safety Defects and Mechanical Failures My 2020 Ford Edge (VIN: [XXX] ) is plagued by systemic safety defects that render it unroadworthy under Pennsylvania law (37 Pa. Code § 301.2).[1, 2] The 8F35 transmission suffers from a documented "shudder" and loss of motive power (TSB 21-2389), creating a high risk of collisions in traffic.[3, 4, 5] Additionally, the vehicle is subject to critical federal recalls: Recall 21S02 (21V-011) regarding sudden rear axle seizure [6, 7, 8] and Recall 20S49 (20V-550) regarding a lethal fire hazard from leaking transmission fluid.[9, 10, 11] The engine also exhibits a design flaw known as "coolant intrusion" (TSB 19-2346), which leads to catastrophic engine failure and hydro-lock.[12, 13, 14] ​Deceptive Trade Practices and Lender Liability CarMax sold this vehicle as "Quality Certified" without fulfilling the disclosure requirements mandated by the 2022 Multistate Attorney General Settlement.[15, 16] Specifically, CarMax failed to provide the required standalone, signed disclosure form for open safety recalls prior to the sale.[17, 18, 15] Because this transaction was financed through Santander Consumer USA, the lender is derivatively liable for CarMax’s deceptive acts under the FTC Holder Rule (16 C.F.R. § 433).[19, 2] This federal rule allows me to assert all legal claims and defenses against Santander that I have against CarMax, including breach of the implied warranty of merchantability, which overrides any "As-Is" disclaimer when a vehicle is sold in a non-roadworthy condition INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)