2019 FORD ECOSPORT Engine Problems

Car went in for recall. Ford replaced engine because they claim a bolt broke. I have taken the car about 300 miles since I received it back and the engine light appeared. I let them know. Light went off and I had another important meeting to make in DFW . This time wrench and engine light came on . It sat at airport for 2 days. Then I got back in , no warning lights on but I got home with more warnings then. Engine was super hot and making humming noise. The next day warning light again. I took videos and called Ford . They have refused to help me. I just had a new engine installed because of a recall.

Complaint Summary: My 2019 Ford EcoSport has experienced repeated failures of a known recall‑related engine defect. The engine was replaced once due to the recall, and less than a year later the same defect occurred again. The vehicle stalled on the highway, creating a serious safety hazard. Despite multiple recall repairs, the defect persists. Ford denied my buyback request without proper review. I am requesting NHTSA investigation into the effectiveness of this recall remedy. Have had two failed attempts under this recall to correct the situation, which is putting me and my family at risk. This is especially concerning because my special-needs son travels with me in the vehicle.

I bought a used 2019 Ford Ecosport SE in January 2022. I received a recall notice (#23S64: “ENGINE OIL PUMP BELT AND TENSIONER REPLACEMENT FINAL REPAIR”). A paper notice I received from Ford dated June 2024 mentioned a remedy expected in Q1 2025. The estimation was pushed back, and parts were eventually ready in Q3, some time in August. Before I could take my vehicle to a dealership, on [XXX], while driving my vehicle it stalled, smoked, and smoldered. I made no collisions with any other object, person, or vehicle. I called my insurance and the fire department (incident number: [XXX]). I believe the damage was related to the recall. It was described to me that there was even damage to some wiring, as a result of the fire. I called my insurance, and they towed my vehicle to Larry H. Miller Ford Dealership on September 30, 2025. It was...

my ford EcoSport had to get a new motor due to teh recall issue but since they put a new motor my ac and heater had to be replaced. my battery. my sensors pop on and off. My car won't go over 65 and when it does it jerks. Ford did replace the motor but ive asked for them to buy the car back and they have refused my car has completely shut off and ive taken to ford and they don't know. i have the poofe code and my gas could be full and driving it 5 minutes im on e. they dont know if its the sensor or the tank. i always smell something burning. ive asked they said thats normal, but the smell gets stronger and stronger.

Our engine seized due to a safety recall while traveling on a major interstate. We received notice of the safety recall from Ford and asked to have it fixed by our local dealership. This was August 20, 2025. We were told by the dealership’s service manager that there were 2 or 3 cars ahead of us and call back the first of September. We again asked to get scheduled and were told there were cars ahead of us. We once again asked about the recall and having it repaired on Oct. 21, 2025. We was told it couldn’t be scheduled at the time and it should be okay for us to go on our scheduled 8 hour trip. The car seized on Oct. 26, 2025 and we were 4 hours away from home. At that time, we had to have it towed to local dealership there and were stranded. The...

I contacted the local Ford dealer, Confidence of Norman in Oklahoma, twice regarding correspondence from Ford about the ongoing recall. I had made appointments on both occasions. During my first visit, the dealership representative stated that they would only address the issue if my vehicle had an actual malfunction and would take no action in the meantime. Last week, I scheduled a follow-up appointment after receiving another letter from Ford. This appointment took place today; however, I was again refused service. The dealership claimed that, despite my scheduled appointment, they lacked the necessary tools to perform the repairs. They did not offer an alternative appointment or provide an estimated timeline for when the issue might be fixed. Ultimately, their response indicated that my visit was unproductive. Besides this complaint, I don’t know what else I can do to fix this problem.

My vehicle falls under a recall due to the oil tensioner belt. I experienced a problem where the engine wasn’t allowing me to accelerate over certain speeds. The car has been experiencing the same issue even after multiple attempts to fix the car. I had the engine replaced once & four days later the engine blew while I was traveling down a hill. I had no control over the vehicle and as it continued to glide down the hill, I anxiously turned on my hazards afraid of what I was about to face. The dealership determined that the engine had blown again & that they would rectify the situation yet again. I received notice that after yet another replacement engine, the car was test driven and is chattering. My car has been in the shop for over two months and after multiple attempts of trying to fix the recall, I...

I was driving and all of a sudden I received a low oil pressure alert on my care and within a min my car lost all power and was completely unable to accelerate. It is currently in the shop and they said it will be months before it is repaired.

I received a recall on my vehicle February 2024 and still the parts are not available. Now I am having issues with my vehicle making it unsafe for me and my son to get to and from school and work etc. This is my only vehicle I have! I need my car repaired ASAP and I need another vehicle until mine gets fixed.

I own a 2019 Ford EcoSport, VIN [XXX] , which is subject to recall 23S64 / 23V905 (Engine Oil Pump Belt and Tensioner Replacement - Final Repair). I was informed of this recall in June 2024, yet Ford has advised there is currently no available remedy. This is a serious safety concern. Under 49 U.S.C. Chapter 301 and the National Traffic and Motor Vehicle Safety Act, manufacturers must correct safety defects within a reasonable time and at no cost. Ford's failure to provide a repair, replacement, or refund is a violation of these obligations. I request NHTSA's urgent attention to compel Ford to resolve this recall promptly. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Recall anounced for vehicle early 2024. Remedy still not available. Check Engine light comes on, noticeable loss of fuel pressure at times.

Engine oil pump belt tension

I have had the same issue with my Ecosport since 04/2022 and have taken it to the ford dealership and been in contact with ford corporate multiple times. In March 2023 I had to replace the engine because it finally completely froze up and was told it was do to the oil pump tensioner. This was the fifth time I had taken it in. The check engine light came back on as soon as I left the dealership, I was told it just needed to reset. It started having issues again in August 2023 and every time I took it in it has been dismissed. I have spent thousands of dollars on repairs for this SUV. Today the check engine light came back on and it smells like smoke if you try to drive it, along with it being very slow to pick up speed and making the same odd...

Was driving down highway when I lost power and it started whistling and a warning sounded said low oil pressure so I pulled over and had to be towed home. When I received my recall letter I took it to my local ford dealer In Covington indiana and they told me they couldn't get the parts but would contact me when they came and they neverdid. So I called them back after this happened and they said they couldn't get these parts sent to them that I would have to find a bigger dealership. Now I have to pay for a tow to Lebanon Indiana they can't get it in until July 23rd for diagnosis and no loaner. So I am without answers or a vehicle for almost a month...

I am filing a complaint regarding Ford Recall 23S64 on my 2019 Ford EcoSport. My vehicle is showing a solid red low oil pressure warning, which Ford’s own documents state can result in engine failure while driving. I contacted my Ford dealership, and they confirmed I am part of the recall but told me to keep driving the vehicle until the engine fails, even though this clearly poses a serious safety risk to myself and others on the road. They also said it would be 3 weeks before I can receive a loaner vehicle. I then called Ford’s official customer service number (800‑392‑3673) and was met with dismissive and rude behavior. My concerns about the safety of operating a vehicle with an active engine defect were not taken seriously. I explained that I rely on this car for income and have no safe alternative right now. I’m being told to...

What component or system failed or malfunctioned, and is it available for inspection upon request? The issue appears to be related to the powertrain system, specifically the belt tension or transmission shifting components. A “Powertrain Malfunction / Reduced Power” warning message appeared through the FordPass app, and I have also been experiencing jerking or hesitation when applying pressure to the gas pedal, particularly during gear shifts. The vehicle is available for inspection upon request. ⸻ How was your safety or the safety of others put at risk? The unexpected jerking and reduction in power while driving could pose a serious safety risk, especially when merging onto highways or changing lanes, where smooth acceleration is critical. This behavior could result in a loss of control or increase the likelihood of a rear-end collision in traffic. ⸻ Has the problem been reproduced or confirmed by a dealer or independent service center? An...

Engine failed one me [XXX] it sat in my drive until it made its way to Sarasota Ford on July 9, 2024. I have no been able to drive this car at all for about 2 years now. (July 9th, 2024 - 5/2025) When driving the car it goes from 40mph to 9mph in the middle of traffic putting not only mi life in danger but others. I have compiled to the motor company about how dangerous this car is. My car has had about 3 engines and still has the same problem the recall was put out for. I was told that after so many times of them trying to fix the car and it’s still Not working they have to replace are car by putting us in the same year or newer year make and model but ford doesn’t want to do so they just want to keep...

My car went more than 30 days ago for service due to a serious call Recall# 23s64-23v9085, where I have been patiently waiting due to the parts being unavailable due to the parts not being in, and I stayed stranded with my autistic child in the middle of the turnpike without any power whatsoever to the vehicle putting my life iand my family in danger, the car I towed to the dealer and the engine had to be changed as a result of the recall, however the dealer is now telling me they need to charge me for a throtle manifold part wihich works with the engine to make the car function. They want me to pay for the part that should be covered through the recall, because this is a vital part of the engine functionality. I am very disappointed with the Gus Machado ford dealer, because they have...

It has been one year from the first recall and they keep putting the repair off I think they have had plenty of time to make these parts I think they don't want to fix these cars in hopes that we will forget or they can blame us for this mistake that they made . At any rate this will be the last Ford I buy . [XXX] Cincinnati Ohio INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Powertrain Malfunction/ reduced power Vehicles emission control system The service light has been 3 months after car was purchased in 2023. Dealer claim to fix recall but a week later same light same issues. They fixed car with recalled parts.

Car is real sluggish, hard to shift, stalls out, hard to crank up after fueling

The contact owns a 2019 Ford EcoSport. The contact stated that while at a stop light and depressing the accelerator pedal, the vehicle failed to respond as needed. There was an abnormal ticking sound coming from the engine. The contact stated that several unknown warning lights were illuminated. The dealer was contacted, and the vehicle was taken to be diagnosed; however, the technician was unable to determine the cause of the failure. The contact stated that the engine was replaced; however, the contact was informed that the repair was temporary. The contact stated that after the engine was replaced, the vehicle was retrieved; however, three weeks later the failure reoccurred. The manufacturer was notified of the failure but offered no assistance. The approximate failure mileage was 49,000.

My car went to the dealership service department to be fixed because the recall piece broke in December. Middle of February they told me it was all fixed I picked it up and within 8 hours it wasn’t driving right and had a bunch of alerts. I tried to drive it home it broke down in 2 degrees weather, I was stranded for 35 minutes with no heat. The dealership got the car back had it for a few more weeks. Today they called saying they think it will be fixed. They called this afternoon saying they took it for the test drive and it wouldn’t work.

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000(Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated while driving 40-50 MPH, the suddenly decelerated to 9 MPH unintendedly and stalled in the middle of the road. The contact activated the hazard lights. The vehicle failed to restart and was pushed to the side of the road with assistance. The contact stated that the failure recurred several times while driving. The check engine warning light was illuminated. The message "engine coolant overheating" was displayed. The vehicle was towed to the dealer, where unknown engine parts were replaced several times; however, the failure persisted. The dealer informed the contact that they were waiting for an unknown part for the engine replacement. The vehicle was not repaired. The contact stated that vehicle rental assistance was provided....

Component that failed was engine oil belt and tensioner. Car almost died right on highway. Dealer has confirmed. Dealer has inspected it.

I realize there is an open recall of 23V905. As well, my vehicle did experience a loss of oil pressure which caused the engine to fail. My local Ford Dealership DID replace the engine. However, the recall is still open given the fact the oil pump is still part of the original recall. My frustration is that this recall has been opened since February 2024 and there is no time frame of the repair and closing of the recall and Ford Motor Company refuses to take a complaint on it and has not communicated to their dealerships as to the time frame.

My car is at risk it has a powertrain and a w d failure when I am driving in the middle of the street or the expressway it stops in the middle of the expressway and loses power loses everything where me and my family could be at risk for a very serious accident leading to death in the middle of the highway or in the middle of the road as I am driving the car loses power and stops in the middle of the road. The manufacturer should be responsible for this because this is obviously something that needs to be fixed where it could be causing my death or my family's death while on the road. My car stops more than six times from the moment that I leave my house even as I am on the road it will literally stop 5 to 6 times losing power...

Manufacturer Recall Number23S64 NHTSA Recall Number23V905 THE ENGINE OIL PUMP DRIVE BELT TENSIONER ARM FRACTURED, SEPARATED FROM THE TENSIONER BACKING PLATE, RESULTING IN A LOSS OF ENGINE OIL PRESSURE. THE FORD DEALERSHIP HAS CONFIRMED AND DOES NOT HAVE PARTS FOR REPAIR UNTIL 2025. FORD WILL NOT PROVIDE A RENTAL AND THIS VEHICLE IS NEEDED FOR WORK. FORD STATES THIS ISSUE DOES NOT QUALIFY FOR A RENTAL CAR. WHAT ARE WE SUPPOSED TO DO?

Oil pump has failed due to recall. There is supposed to be an interim fix if your oil pump fails but Ford is telling me there is nothing they can do until Spring of next year. Oil Pressure Low light has came on so I stopped driving the vehicle. I do not want to cause further damage. My safety is at risk because I am expected to operate a vehicle with the Low Oil Pressure light on. This is not safe

See attached document for complaint

The oil pump failed in May. Resulting in blowing my motor. Broke down at a red light which I would say is unsafe !!! My car has been at the ford dealership in Athens since May. I need a car!! I haven’t had a car since may . I’m not paying for a rental weekly when I wouldn’t even be without a car if not for this recall. I need something done to get me a working drivable car!

On [XXX] a low engine oil pressure light came on. I checked my oil and it was fine. I contacted ford and they told me there was a recall but my car was still safe to drive. On [XXX] the engine light came on as well as the same warning. Upon leaving work my car lost acceleration and all power to the car including the brakes. I had it towed to ciocca ford of york pa. I am now without a car and keep getting the run around about approval for a loaner car. I am unable to trade the car in since it will be at the dealership for a lengthy time which is affecting my chances of getting financing for another vehicle since I still have an auto loan. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

How long is Ford going to get away with no remedy for this? They have been aware of this issue for years. They definitely knew about it when they sold vehicle to me. Of course I wasn't informed by dealer. Now I've had to limit driving for fear mine will succumb to this problem. Vehicle is coming up on 60,000 miles, which is when problem arises in many cases. What is my recourse.? Just stuck paying $35,000 for a vehicle I was misled into purchasing? Got three more years paying $500 a month for car I'm afraid to drive. Check engine light is on more than off. Ford should be accountable. For amount they make, to be knowingly selling a defective product is shameful. Please give this recall the attention it deserves.Stop allowing Ford to ignore whatever fix it is going to take. Which seems is going to be replacing...

See attached document for complaint

Unknown While i was driving on the highway my car stopped in the middle and a load noise was coming low engine oil pressure i got the car home safe since it was Saturday the dealership was closed i Was with my elderly mom in the car at the time i had to wait Monday morning i called ford and was told to Tow it or bring it in couldn’t drive it so i had it towed I towed the car to a ford dealership and paid out of pocket for the tow the service rep at ford service rep Santiago try to assist me i was advise to contact Ford Customer service program which i did and spoke to 4 different reps and a supervisor requested a manager i was hung up 3 times i don’t mind my car takes time to be worked on but i don’t have...

system failure do to recall. part not available I'm out of a car that I pay a note but can't drive at all

Almost 6 months ago, my car began to malfunction. It would not start at all. I paid $500 to have a mechanic diagnose the issue and replace the battery, but nothin worked. I had to have the car towed to the Ford dealership, and they advised me that my engine had failed due to a defect in the fuel pump tensioner, which was an issue that was under recall. They told that they could not do anything to repair the issue, however, because the recall had not been officially published. It has now been nearly six months with my vehicle sitting at the dealership, unusable, because Ford refuses to repair it until the recall comes out. They have also refused to provide a rental or loaner car so I have been out of a vehicle.

Engine light came on, saying low oil pressure and no ABLS

My cars engine seized up and almost crashed into someone

My car can no longer accelerate and multiple lights came on, this all happened while i was driving and there was no warning signs that my car was about to do that it just happened out of nowhere while I was driving it.Now I can’t drive my vehicle until it is repaired but the recall parts are still not available so I don’t know what to do to fix my car.

The vehicle experiences a sudden loss of power/acceleration randomly. Sometimes this happens while driving on the freeway and I cannot accelerate to move to the shoulder. Other times, I can accelerate but very slowly. When this happens, the check engine light will come on and I also receive a powertrain malfunction alert on my Ford app. This issue first occurred on [XXX] - I had to have it towed to Ford. They stated it was the battery then, so I purchased a new one. I brought the vehicle back to Ford for the same issue on [XXX], and then on [XXX] I was driving on the beltway and lost complete acceleration of the car. The check engine light and powertrain light came on. The vehicle would not drive. I had it towed to Ford and they had replaced the engine under the original manufacturing warranty. I got the vehicle back...

I believe the component that failed is engine oil pump belt tensioner this is a recalled item. It is available for inspection however it cannot be checked out by Ford itself. I have notified 3 dealerships and they all stated that the part will be available in the second quarter and that's it. My car cannot run properly the brakes don't work the engine is making noises and I have a low oil pressure light on. My safety and the safety of others was put at risk when my brakes stopped working while I was driving it. The problem has not been confirmed because they won't let me drop it off until later on this month. My car isn't working and it's the only car I have. There was an low oil pressure light as well as my check engine light. My car engine was making rattling noises and my...

I have a 2019 ford ecosport se that is affected with the Engine oil pump belt tensioner replacement ford has done absolutely nothing to help the problem I have been without a vehicle since Jan. In January me and my wife were driving and all of a sudden the low engine pressure light came on and the vehicle slowly started getting slow and we pulled off to the side of the road and had it towed to the CASA ford dealership in Las Cruces NM 470 W Boutz Rd, Las Cruces, NM 88005 575-525-4500 and the diagnostic the vehicle letting me know the vehicle is affected due to this recall and they have submitted documents to ford but nothing has been told to me other then there waiting on ford because the recall still says remedy incomplete. I have been paying on the vehicle and have told the dealership and...

In 2022 of July-August. No lights came on to warn me or anything and my engine went completely out. I took it in and it was the oil pressure that caused my engine to fail. I had to get a new engine, transmission, and a whole bunch of other new things done to my car. AFTER repairs covered by warranty I continue driving and right away I noticed my car making weird noises (like whirring and purring). I took it into ANOTHER ford dealership. This dealership told me that the OTHER dealership did the repairs all wrong and that my car was a mess under the hood…and BOTH dealerships argued who was going to pay for the repairs . To this day I still hear the whirring even though they claim it’s fixed . Surprise ford of Arizona was the dealership that did repairs, and the Milford Ford was the...

My dad has the 2019 ford ecosport and I truly believe because of the bad part that is on recall, his car will not start anymore he is [XXX] and it's his only ride, it has been not working since February 2024 just wondering how long it was gonna get the part to get fixed INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

low oil engine, light on...big valley ford lincoln stockton wont do something until the second letter re-call is serve.

In June 2023, I had to replace the engine on the 2018 Ecosport at the cost of approximately $6000.00. The explanation on the bill was due to problems with the "oil pump" I received a letter from Form recalling the car for repairs Jan 1, 2024 for exactly the same problem that I haad to spend 6000.00 dollars to repair and they still have not repaired the issue on the recall notice. If the car's engine fails AGAIN...because they still have not fixed the issue who will be responsible for the second engine that would have to be replaced in the vehicle?

The contact owns a 2019 Ford EcoSport. The contact received notification of NHTSA Campaign Number: 23V905000 (Engine and Engine Cooling) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at an undisclosed speed the oil pressure warning light illuminated. The contact stated while attempting to start the vehicle, the vehicle failed to start. The vehicle was towed to an independent mechanic where it was diagnosed with a disconnected tensioner belt which caused engine failure. The dealer was not made aware of the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 72,000. VIN tool confirms parts not available.

Due the oil drive belt breaking caused the motor to be bad per the ford dealership so they saying it needs a new motor

My newly purchased 2019 Ford eco-sport with under 40000 miles started having engine malfunctions, and would not accelerate at all. I had it towed to joey Meyers and was told they needed to replace the engine. I had it replaced in October 2023, Which took two months, and now I am Having the same exact engine light come on and my car is slow to accelerate even after replacing the engine. 4 weeks ago I brought the vehicle back to Joe Meyers ford and was told that “ this is a new issue and the parts that need to be replaced are technically “outside” of the engine so not covered under warranty “ the repair invoice total that was quoted to me is $2400. I refused to pay this because I don’t understand how the engine is replaced and three months later I have the same issue but ford is...