2004 MERCURY MONTEREY Power Trainautomatic Transmission Problems

MY 2004 MERCURY MONTEREY HAD A RECALL JOB DONE ON THE TRANSMISSION REPLACING THE TORQUE CONVERTER APPROXIMATELY TWO MONTHS AGO. I WAS DRIVING HOME FROM CHURCH TODAY, AND THE TRANSMISSION STOPPED WORKING. MY FAMILY ENDED UP STRANDED. IT WAS LUCKY FOR US THAT THE STREET WASN'T BUSY SO THAT WE DIDN'T HAVE AN ACCIDENT. *TR THE CONSUMER WAS INFORMED THE PROBLEM WAS COMPLETELY UNRELATED FROM THE PREVIOUS TRANSMISSION REPAIR. UPDATED 04/01/13

2004 MERCURY MONTEREY. CONSUMER WRITES IN REGARDS TO A DEFECTIVE TRANSMISSION *TGW THE CONSUMER STATED HE NOTICED THE TRANSMISSION WAS STARTING TO SLIP. IN MAY OF 2008 THE VEHICLE WOULD NOT GO FORWARD OR BACKWARD. THE VEHICLE WAS TOWED TO A REPAIR SHOP WHERE THE TRANSMISSION WAS REPLACED AT A COST OF $ 1985.00. THE CONSUMER RECEIVED A RECALL NOTICE IN THE MAIL REGARDING THE DEFECTIVE TRANSMISSION. THE NOTICE ALSO STATED IF THE TORQUE CONVERTER HAD ALREADY BEEN REPLACED, THAT ADDRESSED THE SPECIFIC ISSUE, HE MAY BE ELIGIBLE FOR REIMBURSEMENT. *JB

ACCELERATING AWAY FROM TRAFFIC SIGNAL, VEHICLE ACCELERATED NORMALLY UP TO 20-25MPH AND THEN TRANSMISSION TOTALLY FAILED. NO WARNING, NO SYMPTOMS. *KB

TL* THE CONTACT OWNS A 2004 MERCURY MONTEREY. THE CONTACT STATED WHILE DRIVING 40 MPH THE VEHICLE STOPPED MOVING WITHOUT ANY WARNING. THE CONTACT MENTIONED THAT THE ENGINE WAS RUNNING. THE FAILURE AND CURRENT MILEAGE WAS 40,000. THE CONSUMER STATED THE VEHICLE WOULD NOT MOVED, EVEN THOUGH THE ENGINE WAS STILL RUNNING. THE VEHICLE WAS TOWED TO A REPAIR SHOP, WHERE THE CONSUMER WAS INFORMED THE VEHICLE NEEDED A TRANSMISSION. ACCORDING TO THE DEALER INVOICE, THERE WERE METAL SHAVING IN THE PAN, AND THE OIL PUMP/TORQUE CONVERTER FAILED. UPDATED 11/04/11

WITHOUT WARNING (LIGHTS, NOISES, MESSAGES) OUR 2004 MERCURY MONTEREY, WITH ONLY 67K MILES, WOULD NOT GO INTO REVERSE. WHEN WE THEN TRIED TO PUT IT INTO DRIVE, IT WOULD NOT GO FORWARD. WHEN SWITCHED BACK TO REVERSE, IT THEN WENT FORWARD! LUCKILY OUR SERVICE GARAGE IS ONLY A FEW BLOCKS AWAY. ...SO IT ONLY TOOK US A COUPLE OF HOURS TO GET IT THERE. MECHANIC FOUND MAGNET IN TRAY COVERED WITH NOT ONLY METAL SHAVINGS, BUT ALSO LARGER CHUNKS OF METAL. LUCKILY THIS HAPPENED IN OUR ALLEY, SO THERE WERE NO TRAFFIC ISSUES TO DEAL WITH AND NO ONE GOT HURT. *TT

TRANSMISSION FAILED AT 101,000 MILES ON 2004 MERCURY MONTEREY MINI-VAN. THE TRANSMISSION FAILED WITH NO PRIOR WARNING OR OCCURRENCES - ALL FLUIDS AND FILTERS HAVE BEEN CHANGED EVERY 30,000 MILES SINCE VAN WAS PURCHASED AT 40,000 MILES ON ODOMETER. THIS SUBSEQUENT FAILURE INCLUDED THE VEHICLES IMMOBILITY/LOSS OF POWER TO TRANSMISSION EVEN WHEN IN GEAR. THIS FAILURE REQUIRES THAT THE TRANSMISSION BE COMPLETELY REBUILT AT A EXPENSE OF $2500 - ASSUMED THAT THE CAUSE OF FAILURE IS DUE TO EXCESSIVE METAL IN FLUID FROM FAILURE OF TORQUE CONVERTER. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MONTEREY. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE TRANSMISSION MALFUNCTIONED. THE CONTACT STATED THAT ALTHOUGH HE ATTEMPTED TO SHIFT GEARS, THE TRANSMISSION FAILED TO ENGAGE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE TORQUE CONVERTER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 85,890 AND THE CURRENT MILEAGE WAS 86,150.

ON SATURDAY JULY 2, 2011 WE WERE DRIVING OUR 2004 MERCURY MONTEREY FROM THE UPPER PENINSULA OF MICHIGAN TO OUR HOME IN OHIO. MY WIFE, THREE CHILDREN, AND I THOUGHT WE HAD A DAY OF DRIVING AHEAD OF US AND THEN THE VACATION WOULD BE OVER. SUDDENLY, WITHOUT ANY WARNING, ON THE HIGHWAY NEAR GAYLORD MICHIGAN THE ENGINE CONTINUED TO RUN BUT THE CAR WAS NOT BEING PULLED FORWARD. ALL WE COULD DO WAS COAST TO THE SIDE OF THE ROAD. OUR VAN HAS ONLY 67,000 MILES ON IT AND HAS NEVER HAD ANY KIND OF TRANSMISSION PROBLEM. THERE WERE NO CHECK ENGINE OR ANY OTHER WARNING LIGHTS. WE HAD THE VAN TOWED TO A REPAIR SHOP, AND THEY TOLD US THE TRANSMISSION WAS BAD AND THAT THIS IS A KNOWN PROBLEM WITH THIS FORD MERCURY MONTEREY. SINCE IT WAS SATURDAY JULY 2 WE HAD TO WAIT THREE DAYS (SINCE...

ON 7/25/11 I WAS ON MY WAY TO WORK AND WITHOUT ANY PROBLEMS, MY 2004 MERCURY MONTEREY JUST WOULDN'T GO INTO GEAR. I HAD TO TOW MY VEHICLE TO THE REPAIR SHOP WHICH NOTIFIED ME THAT THE TORQUE CONVERTER HAD TO BE REPLACED. *KB

WE WERE DRIVING OUR 2004 MERCURY MONTEREY WITH ONLY 50,000 MILES ON IT, DOING ABOUT 40 MPH WHEN ALL OF A SUDDEN, WITHOUT ANY WARNING SIGNS, THE RPMS INCREASED AND THE VEHICLE STOPPED ACCELERATING. IT ACTED LIKE IT WAS IN NEUTRAL. WE WERE ABLE TO DRIFT OFF THE ROAD ONTO THE SHOULDER AND DISCOVERED WE HAD LOST ALL THE GEARS IN OUR VAN. THANK GOD NO ONE WAS HURT, BUT THE 4 ADULTS AND 3 CHILDREN UNDER 2 WERE STRANDED ON THE SIDE OF A ROAD IN THE MIDDLE OF NOWHERE 3 1/2 HOURS FROM HOME. *KB

WAS DRIVING VEHICLE ON U.S. 10 IN MICHIGAN ON SATURDAY JULY 2, AT 77MPH. PULLED INTO LEFT LANE TO PASS SLOWER TRAFFIC & TACHOMETER SPUN BUT THERE WAS NO POWER - VEHICLE WAS COASTING WITH WHAT APPEARED TO BE NO CONNECTION BETWEEN THE ENGINE & THE TRANSMISSION. COASTED SAFELY TO THE SHOULDER & CALLED A TOW TRUCK. VEHICLE WAS SERVICED IN MT. PLEASANT, MI. DEALER INFORMED ME THAT THE TORQUE CONVERTER SPLINES HAD WORN OFF. REPAIR INCLUDING DROPPING TRANS, FLUSHING VALVE BODY, FLUSHING COOLER LINES, REPLACEMENT OF SCREEN & SEVERAL GASKETS & SEALS COST $1682. TORQUE CONVERTER SPLINES SHOULD NEVER WEAR OFF UNDER NORMAL USE - MAKES ME THINK THAT COMPONENT WAS NOT PROPERLY HEAT TREATED. VEHICLE HAD 78,077 MILES AT TIME OF FAILURE. HAS BEEN MAINTAINED REGULARLY AT RECOMMENDED INTERVALS AT SELLING DEALER. *INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)TT

ON SEPT 27, 2010 I WAS DRIVING HOME FROM MY JOB AND MY 2004 MERCURY MONTEREY JUST STOPPED ACCELERATING. THERE WERE NOT SOUNDS, LIGHT OR WARNINGS ON THE DASH AND THERE HAD NEVER BEEN ANY. I WAS ABLE TO COAST UP ONTO THE GRASS AREA ON THE SIDE OF THE 2 LANE ROAD AND OUT OF TRAFFIC BEFORE THE CAR CAME TO A COMPLETE STOP. MY CAR WOULD NOT RESTART. MY CAR HAD 50180 MILES ON IT AT THE TIME THIS HAPPENED. I HAD MY CAR TOWED TO A REPAIR SHOP WHERE A REPAIR WAS MADE. I HAVE ALL THE PAPERS REGARDING THE REPAIRS WHICH INCLUDED A REBUILT TORQUE CONVERTER, THE REMOVAL METAL CONTAMINATION THROUGHOUT THE UNIT, AND THE REMOVAL AND REPLACEMENT OF THE TRANSAXLE ASSEMBLY. *TR

TRANSAXLE WARNING LIGHT CAME ON. HAS MECHANIC CHECK CODES "TORQUE CONVERTER LOCKED UP." VAN IS IN THE TRANSMISSION SHOP NOW BECAUSE IT IS NOT SAFE TO DRIVE. I SEE A CLASS ACTION LAWSUIT IS ALREADY FILED ABOUT THIS ISSUE BUT I DON'T SEE ANY RESOLUTION OF IT AS OF YET. HTTP://CLASSACTIONLAWSUITSINTHENEWS.COM/CLASS-ACTION-LAWSUIT-COMPLAINTS/FORD-CLASS-ACTION-LAWSUIT-COMPLAINT-FILED-OVER-ALLEGED-DEFECT-IN-2004-2005-MODEL-YEAR-FORD-FREESTAR-AND-MERCURY-MONTEREY-TRANSMISSIONS-TORQUE-CONVERTERS/ *TR

WE ARE THE OWNERS OF A 2004 MERCURY MONTEREY WITH JUST OVER 64,000 MILES ON IT. I WAS SHOCKED WHEN MY WIFE CALLED ME ON THE EVENING OF JUNE 3RD, 2011 AND TOLD ME THAT SHE HAD GOTTEN INTO THE VAN, STARTED IT AND TRIED TO GO IN REVERSE AND THE VAN WOULDN'T MOVE. SHE THEN PUT IT INTO "DRIVE" AND IT SEEMED TO WORK FINE FOR A FEW MINUTES AND THEN IT MADE AN AWFUL CLUNKING SOUND A FEW TIMES AND LOST POWER AS SHE WAS DRIVING NEAR OUR HOME HEADING TOWARD THE FREEWAY. I IMMEDIATELY KNEW IT WAS A PROBLEM WITH THE COMPONENTS OF THE TRANSMISSION. THANKFULLY NO ONE WAS INJURED AS SHE WAS TRAVELING AT SLOW SPEEDS ON SURFACE STREETS JUST BEFORE MAKING IT ONTO THE FREEWAY. IT SCARES ME TO THINK WHAT COULD HAVE HAPPENED HAD THE PROBLEM NOT OCCURRED UNTIL 5 MINUTES LATER WHEN SHE...

DRIVING ON HIGHWAY. SUDDEN LOSS OF ALL FORWARD MOTION. THE ENGINE DID NOT TURN OFF, JUST SOUNDED LIKE IT WAS IN NEUTRAL. CHANGING OF GEARS HAD NO RESPONSE. SINCE THE, ALL PARTS HAVE BEEN REPLACED AND STILL NO RESPONSE. *TR

2004 MERCURY MONTEREY TRANSMISSION FAILED AT 69,000 MILES WITH MINOR WEAR AND TEAR. WE HAVE HAD THE VEHICLE FOR 5 YEARS AND 4 MONTHS AND VEHICLE HAD 16,000 MILES WHEN WE PURCHASED IT. TRANSMISSIONS ARE TO LAST LONGER THAN 69,000 MILES. THAT BRAKES DOWN LESS THAN 900 MILES PER MONTH WHICH IS WELL BELOW THE NATIONAL AVERAGE. IN FACT TO FURTHER PROVE THE POINT FOR 2 OF THE 5 YEARS IS WAS OUR SOLE VEHICLE FOR A FAMILY OF 7 WITH 2 WORKING ADULTS. WE CONTACTED FORD BUT WE WERE "WITHIN OUR MILES OF THE EXTENDED WARRANTY BUT UNFORTUNATELY THE TIME EXPIRATION WAS SEPTEMBER OF 2010". WE PAID $1800 TO HAVE IT REPLACED YESTERDAY HOWEVER IT BROKE DOWN AGAIN YESTERDAY AND WE ARE WAITING TO HEAR FROM THE SHOP AGAIN NOW. IF ANYONE GOOGLE'S 2004 MERCURY MONTEREY TRANSMISSION ISSUES THERE IS A PLETHORA OF RESULTS INCLUDING CLASS ACTION LAWSUITS. *TR

TRANSMISSION PROBLEMS: I OWN A MERCURY MONTEREY 2004 VAN. I PURCHASED IT USED IN JULY 2008 AND IN DECEMBER THE TRANSMISSION STOPPED WORKING. I DID HAVE AN EXTENDED WARRANTY SO IT WAS REPAIRED BUT NOT REPLACED OR REBUILT. I DON'T KNOW WHY THEY DID NOT REPLACE THE TRANSMISSION SINCE THERE WERE SO MANY COMPLAINTS. IN FEBRUARY 2011 I HADTHE SAME PROBLEM HAPPEN AGAIN WHILE TRAVELING ON THE HIGHWAY. IT JUST STOPPED AND I VEERED OFF THE HIGHWAY, HAD IT TOWED. WELL THIS TIME I HAD THE OPTION OF GETTING THE SAME THING DONE OR REBUILD IT. THE ONLY PROBLEM IS THE EXTENDED WARRANTY HAS EXPIRED SO I HAD TO CHOOSE TO HAVE IT REPAIRED. THAT REPAIR COST ME 1700.00. THE JOB AS BEFORE IS ONLY GOOD FOR 12,000 MILES. I DO QUITE A BIT OF TRAVELING. HAS THERE BEEN ANY RESOLUTION TO ALL THE COMPLAINTS THAT HAVE BEEN MADE. PLEASE...

I WAS TRAVELING DOWN THE HIGHWAY WHEN I LOST ALL FORWARD POWER TO THE VAN. HAD THE VAN TOWED AND WAS TOLD THE TORQUE COVERER HAD FAILED AND WOULD NEED TO REPLACE THE TRANSMISSION. *TR

2004 MERCURY MONTEREY DRIVING ON HIGHWAY ON CRUISE CONTROL AT 67MPH WHEN VEHICLE LOST POWER DRIFTED TO LANE THAT WAS CLOSED TO TRAFFIC DUE TO HIGHWAY CONSTRUCTION AND AVOIDED BEING HIT BY TRAFFIC TRAVELING BEHIND ME HAD TO BE TOWED TO A FORD/MERCURY DEALERSHIP. WAS INFORMED THAT IT WAS THE TRANSMISSION AND NEEDED TO BE REPLACED AT A COST OF $3500.00 I AM AN 80YR. OLD WOMEN WITH NO OTHER DRIVER AND HAVE LESS THAN 40,000 MILES ON THIS VAN AND FEEL THAT THIS SHOULD NOT HAVE HAPPENED. ALSO FEEL THAT THERE SHOULD BE SOME WARRANTY BUT WAS TOLD THAT THERE IS NOT ST.LOUIS,MISSOURI. *TR

TL* THE CONTACT OWNS A 2004 MERCURY MONTEREY. THE CONTACT WAS DRIVING APPROXIMATELY 40-45 MPH WHEN THE TRANSMISSION EXHIBITED SEVERE HESITATION AND WOULD NOT RESPOND NORMALLY. THE CONTACT WAS ABLE TO MANEUVER TO A SAFE LOCATION WHERE THE TRANSMISSION COMPLETELY FAILED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY INFORMED THE CONTACT THAT THE TRANSMISSION WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 60,000.

TRANSMISSION FAILURE IN 2004 MERCURY MONTEREY VAN. NO WARNING OF THE IMPENDING FAILURE. NO RESPONSE FROM THE TRANSMISSION IN ANY GEAR. IT OCCURRED WHILE ON AN ENTRANCE RAMP TO A MAJOR HIGHWAY. TOWED TO FORD DEALER WHERE IT WAS DETERMINED THAT "TRANSMISSION FAILURE" HAD OCCURRED. FORD REBUILT TRANSMISSION INSTALLED AT A COST OF $3,455. I AM CONCERNED THAT THIS TRANSMISSION CAN FAIL AGAIN WHEN FIVE KIDS ARE BEING TRANSPORTED TO SCHOOL IN THIS VAN ON THAT SAME HIGHWAY DURING RUSH HOUR. *TR

WAS DRIVING MY 2004 MERCURY MONTEREY AND ALL THE SUDDEN MY TRANSMISSION QUITE LETTING THE CAR GO FORWARD OR IN REVERSE. TOOK IT TO A REPAIR SHOP AND IT WAS THE TORQUE CONVERTER WHICH COST ME $2300 TO REPAIR. *TR

I AM THE OWNER OF A 2004 MERCURY MONTEREY MINIVAN WHICH I PURCHASED NEW. ABOUT A MONTH AGO AND LITERALLY WITHOUT ANY SIGN OF PROBLEMS, I CAME OUT OF WORK AND DISCOVERED THAT MY VAN WOULD START UP FINE BUT WOULD NOT GO INTO GEAR (FORWARD, REVERSE ETC.) I HAD THE VAN TOWED TO THE NEAREST FORD DEALERSHIP AND WAS TOLD THAT THE TORQUE CONVERTER HAD WENT OUT AND THAT IT WOULD COST ME $1600 TO REPAIR. AFTER THREATENING TO TOW THE VEHICLE TO ANOTHER SHOP I EVENTUALLY GOT THEM TO AGREE TO DROP THE COST TO $1000. I WAS SHOCKED THAT THE TRANSMISSION WOULD HAVE SUCH A MAJOR BREAK DOWN WITH LESS THAN 50,000 MILES. AFTER RESEARCHING THE INTERNET I DISCOVERED THAT THERE ARE MANY COMPLAINTS ABOUT THE SAME PROBLEM AND THAT IT ALWAYS SEEMS TO OCCUR AROUND THE 50K MILEAGE MARK. IN FACT, I DISCOVERED THAT A CLASS...

WHILE DRIVING IN TRAFFIC WITH MY SISTER & MY YOUNG SON, WITHOUT ANY WARNING SIGNS, OUR MERCURY MONTEREY JUST QUIT. BY THE GOOD GRACE OF GOD, DIVINE INTERVENTION, ANGELS OR WHATEVER ELSE MAY HAVE INTERVENED, IT SO HAPPENED THAT WE HAD MISSED THE EXIT TO ENTER INTERSTATE 695 SO THE INCIDENT OCCURRED ON A BUSY CITY STREET INSTEAD OF THE HIGHWAY. THAT BEING SAID, WE EASILY COULD HAVE LOST OUR LIVES IN EITHER PLACE, HOWEVER IT WOULD HAVE BEEN A SURE BET AT 60 MPH ON THE HIGHWAY! THE VEHICLE WAS TOWED TO A GARAGE AND THE PROBLEM WAS DIAGNOSED AS A FAILED TRANSMISSION, MORE SPECIFICALLY, THE AUTOMATIC TRANSMISSION TORQUE CONVERTER. THE TRANSMISSION HAD TO BE REPLACED. *TR

MY WIFE WAS DRIVING MY 2004 MERCURY MONTEREY AROUND THE PERIMETER OF OUR LOCAL MALL. SUDDENLY THE VAN SLOWED, AND SHE NOTICED THE TACHOMETER SHOWED THE RPMS INCREASING AS THE PRESSED THE ACCELERATOR. THE VAN STOPPED DEAD. SHE HAD TO CALL ME TO PUSH THE VAN INTO A PARKING SPACE UNTIL WE COULD HAVE IT TOWED THE FOLLOWING DAY. THE COULD HAVE BEEN EXTREMELY DANGEROUS IN TRAFFIC. I HAVE A HANDICAPPED 19 YEAR OLD DAUGHTER, AND RELY ON THIS VAN FOR HER TRANSPORTATION, SO ON TOP OF THE SAFETY ISSUE, THIS IS A TREMENDOUS INCONVENIENCE FOR US. *TR

I HAVE A 2004 MERCURY MONTEREY WAS DRIVING AND ALL THE SUDDEN TRANSMISSION WENT OUT WITHOUT WARNING. NO WARNING LIGHTS OR OTHER SHIFTING PROBLEMS. VERY HAZARDOUS. THEY WANT 4 TO 6000.00 TO REPAIR THIS IS DEFINITELY A FORD PROBLEM AND SHOULD BE REPAIRED BY THEM. I COULD HAVE BEEN KILLED AND MY PASSENGERS ONLY BY THE GRACE OF GOD WE WEREN'T. *TR

I WAS ON MY WAY HOME AFTER PICKING UP MY 2 GRANDDAUGHTERS AND MY CAR JUST LOST ALL MOVEMENT. THE MOTOR WAS RUNNING BUT WHEN I TRIED TO ACCELERATE IT WOULD NOT MOVE FORWARD. I WAS ABLE TO COAST TO THE BOTTOM OF THE HILL, WHERE LUCKILY THERE WAS TURNOFF LANE. I CALLED FOR ASSISTANCE AND THEN HAD TO BE TOWED. THE GIRLS WERE SCARED TO DEATH, I GUESS JUST KNOWING THAT WE WEREN'T ABLE TO GO, IT WAS DARK AND WE WERE ON A BUSY HIGHWAY. THE MECHANIC HAS INFORMED ME THAT IT IS THE TRANSMISSION. MY CAR IS A 2004 MERCURY MONTEREY, ONLY 77,000 MILES. IT HAS NEVER GIVEN ME ANY TROUBLE. THIS HAS BEEN QUITE AN INCONVENIENCE, ESPECIALLY SINCE I WORK EVERYDAY AND IT IS GOING TO BE QUITE AN EXPENSE TO REPLACE, LAST QUOTE WAS 2600.00, WHICH IS NOT EASY TO COME BY GIVEN THE ECONOMY....

I HAVE A 2004 MERCURY MONTEREY WITH APPROXIMATELY 70,000 MILES. THE TORQUE CONVERTER WAS REPLACED UNDER AN EXTENDED WARRANTY AT APPROXIMATELY 37,000 MILES. I JUST TOOK THE VAN BACK TO THE DEALERSHIP BECAUSE OF A NOISE FROM THE ENGINE, AND I AM TOLD BY THE MERCURY TECH THE TORQUE CONVERTER IS GOING BAD AGAIN, AND THEY WANT $1700 TO REPLACE IT AGAIN. IN RESEARCHING THIS PROBLEM I FOUND A LARGE NUMBER OF COMPLAINTS ALSO FILED FOR THE SAME PROBLEM, THIS NEEDS TO BE ADDRESSED. *TR

THE VAN IS A 2004 MERCURY MONTEREY. I WAS DRIVING HOME FROM DROPPING A FRIEND OFF TO GET HIS SUV FROM THE SHOP. I WAS DRIVING HOME, AND HAD TO SLOW DOWN TO MAKE A LEFT TURN AT THE LIGHT. I TURNED AND WENT TO STEP ON THE GAS AND THERE WAS NOTHING. I THOUGHT AT FIRST I HAD SOMEHOW BUMPED IT INTO NEUTRAL. WHEN I LOOKED DOWN IT WAS IN DRIVE. I JUST MADE IT OVER THE TRAIN TRACKS WHEN IT CAME TO A STOP. I TRIED EVERYTHING I COULD THINK OF. I TURNED THE VAN OFF THEN ON WENT THROUGH ALL OF THE GEARS, AND NOTHING HAPPENED. MY WIFE CALLED AAA, AND HAD THE VAN TOWED TO A REPAIR SHOP WHERE WE WERE TOLD IT WOULD COST BETWEEN $2,500 TO $3,000 TO REPLACE THE TRANSMISSION BECAUSE THE TORQUE CONVERTER SENT METAL SHAVINGS THROUGH THE TRANSMISSION. THE MOST FRUSTRATING...

I OWN A 2004 MERCURY MONTEREY THAT APPARENTLY HAS A TRANSMISSION/TORQUE CONVERTER ISSUE WITH IT. ON THE 5TH OF DECEMBER ME AND MY FAMILY WERE DRIVING HOME FROM THE BASE THAT WE ARE STATIONED AT OVERSEAS WHEN ALL OF A SUDDEN I LOST POWER IN THE VEHICLE. THE RPM'S SHOT UP BUT NEVER ACCELERATED. LUCKILY I WAS ABLE TO PULL OFF THE RD SAFELY. I SHUT OFF THE VEHICLE, RESTARTED IT PUT IT INTO GEAR AND NOTHING... WE HAD IT TOWED TO A LOCAL GARAGE OUT HERE AND THE MECHANIC SAID THAT MY TRANSMISSION IS JUNK... WE HAVE NOT HAD ANY OTHER PROBLEMS WITH THIS VEHICLE EXCEPT FOR THIS... NO WARNING LIGHTS OR ANYTHING CAME ON TO WARN US OF A POSSIBLE PROBLEM WITH THE VEHICLE.. WE DO NOT HAVE THE MONEY TO GET THIS FIXED AND STILL OWE ABOUT $9000.00 ON THIS VEHICLE. WHAT IS FORD GONNA DO ABOUT...

TRANSMISSION FAILURE - CAUSED BY FAULTY TORQUE CONVERTER. *TR

MY FAMILY AND I WERE TRAVELING DOWN A RURAL ROAD WHEN OUR 2004 MERCURY MONTEREY JUST LOST ITS POWER TO MOVE. THE ENGINE WAS STILL RUNNING BUT WHEN I PUSHED ON THE GAS WE DIDN'T HAVE ANY RESPONSE AND WE COASTED TO THE SIDE OF THE ROAD OUT IN THE COUNTRY AWAY FROM EVERYTHING AND EVERYONE. OUR CELL PHONE HAD NO SIGNAL SO I HAD TO WALK THREE MILES TO GET MY SIGNAL ON THE CELL PHONE TO BE ABLE TO CALL FOR HELP WHILE MY WIFE AND GRANDSON WAITED IN THE VAN UNTIL I RETURNED. I HAD TO GET THE VAN PULLED 35 MILES BACK HOME AND IT IS STILL SETTING BECAUSE NO ONE KNOWS WHY IT QUIT MOVING AND WHAT TO DO ABOUT IT. I TRIED ALL GEARS AND NONE OF THEM WORK. *TR

I OWN A 1994 MERCURY MONTEREY MINIVAN AND THE TRANSMISSION WENT OUT WITH NO WARNING WHILE DRIVING ON A NARROW ROAD WITH NO SHOULDER. I HAD NOWHERE TO GO EXCEPT THE DITCH. MY VAN HAS UNDER 73000 MILES ON IT AND THIS IS THE SECOND MAJOR REPAIR TO THE TRANSMISSION IN LESS THAN 5 MONTHS. SOMETHING IS VERY WRONG WITH THE MERCURY MONTEREY TRANSMISSIONS AS EVIDENCED BY THE LARGE NUMBER OF REPORTS OF FAILURE AND THE FACT THAT A CLASS ACTION LAWSUIT WAS APPROVED AGAINST FORD FOR THIS EXACT PROBLEM>

SUDDEN (AND SILENT) AUTOMATIC TRANSMISSION FAILURE ON 2004 MERCURY MONTEREY WITH 59876 MILES. STOPPED AT A SIGNAL LIGHT, PROCEEDED ON GREEN LIGHT AND ACCELERATED TO 30 MPH, NO PROBLEMS, NORMAL ACCELERATION. PROCEEDED 500 FEET AND STOPPED AT RAIL ROAD CROSSING. VAN LOST MOTIVE POWER AND STOPPED. THE ENGINE REVVED BUT VAN DID NOT MOVE. NO WARNING, NO LIGHTS,NO SOUND, VAN WILL NOT MOVE. BLOCKED RAILROAD CROSSING, PUSHED VAN TO THE SIDE OF THE ROAD AND THEN GOT VEHICLE TOWED HOME. ALL MAINTENANCE PERFORMED AT MERCURY RECOMMENDED MILEAGE AND TIME. LOST TWO TRANSMISSIONS ON 2002 CHEVY VENTURE, AND BOUGHT THE VAN BASED ON FORD/MERCURY REPUTATION. *TR

2004 MERCURY MONTEREY 59,700 MILES AND THE TORQUE CONVERTER WENT OUT. THANKFULLY THE VEHICLE BROKE DOWN IN FRONT OF THE HOUSE. AFTER REVIEWING A BUNCH OF WEBSITES, THERE SHOULD BE A RECALL ON THIS VEHICLE FOR THIS PROBLEM. THIS IS A FAMILY VEHICLE SOLD TO THE CONSUMERS AS SAFE. HARDLY, THE CASE! *TR

WITHOUT ANY WARNING OUR 2004 MERCURY MONTEREY HAD DRIVETRAIN ISSUES. WE WERE AT A RED LIGHT AND WHEN WE WENT TO ACCELERATE THE VAN DID NOT MOVE. WE TURNED IT OFF AND WAITED A FEW MINUTES THE STARTED IT BACK UP. WE WERE THEN ABLE TO PARK IT ALONG THE ROAD BEFORE THE TRANSMISSION STARTED TO NOT WORK AGAIN. WE NOW ARE NOT SURE AS WHAT TO DO ABOUT IT. WE CAN NOT AFFORD TO PUT MONEY NOT IT TO HAVE IT REPAIRED. AFTER READING HERE AND ON LINE THIS SEEMS TO BE A ISSUE WITH FORD. WE CALLED FORD AND THEY SAID TO TAKE IT TO A DEALER AND HAVE IT LOOKED AT. I FIRST WENT TO THE DEALERSHIP AND THEY SAID IT WOULD BE $75.00 PER HOUR TO LOOK AT IT WITH A WINDOW OF 1 TO 3 HOUR COST. AND 1 HOUR MINIMUM FEE. *TR

HAD TRANSAXLE REPAIRED IN 2009 FOR $2,500. TRANSAXEL WAS REPLACED. DRIVING HOME FROM NASHVILLE TO KNOXVILLE LAST NIGHT TRANSAXEL WENT OUT AT 70 MPH. HAD TO COAST TO A STOP. WAS SMOKING WHEN PULLED OVER. *TR

ON JUNE 27, 2010 THE VEHICLE LOST POWER TO THE DRIVE WHEELS WITHOUT ANY WARNING NOISES OR OTHER PHYSICAL INDICATORS AND WITHOUT ANY DASHBOARD INDICATOR LIGHTS. APPROXIMATE MILEAGE - 105,000. QUALIFIED MECHANIC ADVISED TO REPLACE TRANSMISSION. A USED TRANSMISSION WAS OBTAINED AND INSTALLED BY QUALIFIED MECHANIC WITH THE SAME RESULTS ON OCTOBER 8, 2010. *TR

DRIVING ON THE HIGHWAY IN OUR 2004 MERCURY MONTEREY, THE CAR ACTED LIKE IT WENT INTO NEUTRAL AND HAD TO BE COASTED ONTO THE SHOULDER. THERE WAS NO WARNING LIGHT OR INDICATION OF ANY MECHANICAL PROBLEM BEFOREHAND. AFTER TAKING IT TO THE DEALERSHIP, THEY DECLARED IT WAS A PROBLEM WITH THE TRANSMISSION. ALL REQUIRED MAINTENANCE HAD BEEN DONE ON THE VEHICLE. THE VEHICLE IS CURRENTLY AT THE DEALERSHIP. *TR

2004 MERCURY MONTEREY WITH 120,000, WOULDN'T MOVE IN THE MIDDLE OF LONG TRIP. TORQUE CONVERTER STRIPPED OUT. STARTED JUMPING IN AND OUT OVERDRIVE WHEN FINALLY DID MOVE, BUT BLEW OUT SEAL. *TR

2004 MERCURY MONTEREY - WIFE DRIVING DOWN THE HIGHWAY (WITH ONE CHILD AS A PASSENGER) AT 65 MPH. VEHICLE LOST ALL ABILITY TO ACCELERATE. NO GEAR. HAD TO COAST TO THE SIDE OF THE HIGHWAY (DURING RUSH HOUR) WHERE THERE WAS LITTLE TO NO ROOM TO EVEN EXIT THE VEHICLE SAFELY. SHE WAS STUCK IN THE VEHICLE WHILE CARS AND TRUCKS SPED BY RAPIDLY OFTEN COMING CLOSE TO HITTING HER. POLICE WERE CALLED AND ALSO A TOW TRUCK. THE VAN HAD NO MOVEMENT IN ANY GEAR. ONLY HAD PARK AND NEUTRAL. VAN WAS TOWED AND THE PROBLEM WAS DETERMINED TO BE A FAILED TORQUE CONVERTER. SPECIFICALLY THE SPLINES INSIDE THE CONVERTER WHERE THE SHAFT COMING OUT OF THE TRANSMISSION ENGAGES. REPAIR COST PLUS TOW IS $2000. LUCKILY NO ONE WAS HURT BUT IT WAS A VERY DANGEROUS SITUATION. AFTER SOME RESEARCH THERE IS APPARENTLY A CLASS ACTION SUIT AGAINST FORD...

TL* THE CONTACT OWNS A 2004 MERCURY MONTEREY. THE CONTACT WAS DRIVING 35 MPH WHEN THE TRANSMISSION SLIPPED OUT OF GEAR AND WOULD NOT RETURN TO THE APPROPRIATE GEAR. THE CONTACT WAS UNABLE TO DRIVE THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. NEITHER THE DEALER NOR MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS 99,500.

WE BOUGHT A 2004 MERCURY MONTEREY WITH 97K MILES ON IT IN JUNE 24, 2010...EVERYTHING WAS FINE UNTIL AUGUST 11, 2010. I WAS DRIVING AND ALL OF A SUDDEN THE CAR WILL NOT ACCELERATE...SO I DRIFT TO THE SIDE OF THE ROAD AND TRY TO GET THE VAN TO ACCELERATE BUT NOTHING HAPPENED. I HAD TO GET IT TOWED AND THE TRANSMISSION GUY TOOK IT APART AND SAID THE TORQUE CONVERTER NEEDS REPLACED IT WENT OUT...WE ARE STILL WAITING TO SEE IF OUR EXTENDED WARRANTY COVERS IT IF NOT IT WILL BE 1400-1600 BUCKS TO GET IT FIXED. I MEAN WE HAD NOT EVEN HAD IT FOR TWO MONTHS YET. I STARTED RESEARCHING AND FOUND ALOT OF COMPLAINTS ON IT AND STILL NOTHING HAS BEEN DONE. THANKS GOODNESS NO ONE IN MY FAMILY GOT HURT, WHAT WILL IT TAKE TO GET THEM TO RECALL THIS PROBLEM AND TO KEEP PEOPLE...

DRIVING HOME FROM WEST SIDE OF STATE TO EAST SIDEOF STATE AND HAD CRUISE CONTROL ON. HAD MY 2 YEAR OLD, 4 YEAR OLD AND 5 YEAR OLD AND WIFE IN CAR. ENGINE WAS AT 2300RPM AND AROUND 65MPH. CRUISE CONTROL WAS ENGAGING POWER TO MAINTAIN 65MPH AND THEN RPM FLARED UP TO 4000RPM AND ALL LOSS OF POWER. I WAS ON FREEWAY AND BARELY WAS ABLE TO PULL OVER. WAS HALF ON SHOULDER AND PART ON WHITE LANE MARKER. COULD NOT GET CAR TO DRIVE OFF LANE. PEOPLE WERE HONKING AND WAS WORRIED THAT WE WOULD GET HIT. COULD NOT GET KIDS OUT OF CAR BECAUSE OF DANGEROUS OBJECTS FROM MOVING CAR TIRES PASSING BY. I HAVE NO POWER IN REVERSE DRIVE, SECOND OR 1ST. ITS LIKE BEING IN NEUTRAL WITH ENGINE REVVING AND NO MOVEMENT. PLEASE ADVISE. *TR

2004 MERCURY MONTEREY HAS HAD POWER TRAIN AUTOMATIC TRANSMISSION REPLACED TWICE AND ONLY HAS ABOUT 67,000 MILES ON IT. *TR

INCIDENT FIRST OCCURRED ON 6/20/2010, ON I-64. I WAS DRIVING OUR 2004 MERCURY MONTEREY WHEN I REALIZED THAT THE TRANSMISSION HAD SLIPPED FROM D3 TO D2. I STOPPED VAN AND IT WORKED FINE AFTER RESTARTING, BUT WAS AFRAID TO USE IT; ONLY USED SEVERAL TIMES FOR SHORT TRIPS IN THE INTERIM - NO PROBLEMS, HOWEVER, WITH THE TRANSMISSION. TOOK TO DEALER ON 7/30 - 41,779 MILES - EXTENDED WARRANTY (ESP) EXPIRED 2/5/10. DEALER REPLACED TRANSMISSION RANGE SENSOR AND BRAKE PRESSURE SWITCH AT A COST OF $325.22, INCLUDING DIAGNOSTIC CHECK. DEALER ALSO FLUSHED AND FILLED TRANSMISSION - TWICE TO REMOVE WATER - COST: $184.87. I ASKED FOR THE OLD PARTS - DEALER DID NOT RETURN THEM. PICKED UP VEHICLE ON 8/1/10; TRANSMISSION WORKED FINE, BUT THE TRACTION CONTROL SYSTEM (TCS) LIGHT TURNED ON AND STAYED ON. DID NOT DRIVE UNTIL 8/6 WHEN I TOOK IT TIRE SHOP TO HAVE TIRES REPLACED...

WHILE ON THE HIGHWAY AND ACCELERATING TO PASS A CAR, ABOUT 65 MPH, TRANSMISSION FAILED, AND HAD TO COAST VEHICLE OVER TO THE SIDE OF ROAD AND STOPPED. IN PARK, REVVED ENGINE AND NO ENGAGEMENT OF TRANSMISSION WAS REALIZED. HAD TO TOW CAR TO FORD_MERCURY DEALER. DEALER REPLACED TRANSMISSION-DO NOT KNOW IF OLD TRANSMISSION IS AVAILABLE. *TR

TL*THE CONTACT OWNS A 2004 MERCURY MONTEREY. THE CONTACT STATED THAT WHILE DRIVING 70 MPH THE VEHICLE SUDDENLY STOP ACCELERATING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE ONTO THE EMERGENCY LANE AND CALL A TOW TRUCK. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC WHO STATED THAT THE TRANSMISSION WAS DESTROYED. THE MANUFACTURER STATED THAT SINCE THERE WERE NO RECALLS, OR RELATED WARRANTIES THAT THERE WAS NOTHING THAT THEY COULD DO. THE CONTACT WAS CONCERNED ABOUT THE SAFETY RISK AS WELL AS THE POSSIBILITY THAT A CRASH COULD OCCUR. THE FAILURE MILEAGE WAS 40,000.

5 DAYS AFTER A WONDERFUL VACATION (IN WHICH I USED MY 2004 MERCURY MONTEREY VAN), I WAS DRIVING TO WORK WHEN I FELT A SHIFTING IN THE FRONT OF THE VEHICLE AS I WAS TURNING A CORNER. I KNEW SOMETHING WAS WRONG RIGHT AWAY AND PULLED (COASTED) INTO A PARKING SPACE. LUCKILY, I WAS ON A SIDE STREET AND NOT A HIGHWAY. I PUT CAR IN PARK AND LISTENED AND WAITED FOR A MOMENT. WHEN I SHIFTED INTO REVERSE TO LEAVE THE PARKING SPACE, NOTHING HAPPENED. I TRIED FORWARD AND REVERSE A FEW MORE TIMES, I TURNED OFF THE AIR CONDITIONING AND MADE SURE THE RADIO WAS STILL WORKING. THE CAR WOULD STILL NOT CHANGE GEARS. HAD THE CAR TOWED ($75) AND NEEDED A NEW (REBUILT) TRANSMISSION - $2,300. WARRANTY EXPIRED A FEW MONTHS AGO, SO IT WAS ALL OUT OF POCKET. IT TOOK A WEEK TO FIX THE VEHICLE,...

OWN A 2004 MERCURY MONTEREY WITH A REBUILT TRANNY WHEN BOUGHT. 3 YOUNG KIDS UNDER AGE 3. TRANSMISSION JUST WENT WHILE DRIVING WITH ALL 3 KIDS. THANK GOD NO-ONE WAS HURT! THIS IS A KNOWN PROBLEM. WHY IS THERE NO RECALL???? *TR