2016 KIA SOUL Engine Problems

SUBJECT: Engine → Stall → Loss of power while driving: While driving normally, the vehicle began losing power and could not accelerate properly. The engine warning light illuminated and the vehicle repeatedly entered a reduced-power condition where it could barely maintain speed. The vehicle would stall while driving and then restart after sitting. This occurred multiple times over a period of time and progressively worsened. The engine also began consuming large amounts of oil between oil changes. Eventually the engine suffered catastrophic failure and would no longer run. A dealership later stated internal engine damage was present, including a failed valve and spark plug damage. The vehicle is currently at a dealership and available for inspection. The loss of power and stalling created a safety hazard because the vehicle could not maintain normal traffic speed and could have been struck by other vehicles. The problem was confirmed by a dealership...

I have put my 3rd Catalytic Convertor on this car. It looses power going uphill. Which is not safe. Just had 3rd on replaced yesterday Feb. 9, 2026. The mechanic said there is too much oil going to the engine. Mechanic said next thing would be replacing the engine. Why does my 2016 not have a recall on the engine.

The vehicle is suffering from excessive oil consumption (over 1 quart per 1,000 miles) and a recurring P0420 (Catalyst Efficiency) code. This is a documented precursor to catastrophic engine failure and engine compartment fire in the 2.oL Nu GDI engine. The engine's oil consumption is poisoning the catalytic converter, causing it to clog. This creates extreme exhaust backpressure, leading to sudden loss of motive power (stalling) while driving. This defect poses an unreasonable risk of a high-speed collision and fire if oil comes into contact with the hot exhaust manifold. Due to current extreme winter conditions (-20F with wind chill), a sudden engine stall or seizure creates a life-threatening emergency. I no longer feel safe operating this vehicle, as an engine failure in these temperatures could leave me stranded without heat in sub-zero weather.

While driving on a road trip from Charleston, South Carolina to Florida in January of 2023 the factory installed catalytic converter failed (front facing) clogging the exhaust system and damaging the engine (engine now experiences blow by and pistons rings have been damaged). A recall for the overheating of the catalytic converter was marked as repaired before I bought the car. However, I believe that either the update was not done to the on-board computer or that a damaged catalytic converter was not replaced. This directly led to the subsequent failure in question and has since damaged my engine. At the time of the incident, an investigation of both catalytic converters revealed heavy sediment deposits and the core of the filtering component of the front facing unit had become so corroded that a chunck of it had broken loose and become lodged in the connecting hose that linked it to...

Engine knock engine failure

They have a recall on the catalytic converters for the 1.6 engines but not the 2.0. I have had to have mine replaced two times in a year. There is definitely a problem. The second time it almost caught fire due to glowing red cause it got so hot. The same problem is happening to the 2.0 engines just like the 1.6 engines, but nothing is being done.

Greetings, I have a base 2016 kia soul manual transmission that I thought was under safety recall for its engine, but when I search it says 0 unrepaired recalls, when I look this up it does claim my vehicle had this problem, but I never had a dealer fix it, I did contact the one I got it from a couple of years ago and asked if my vehicle qualified for the recall since it already has 200,000 miles on it but they never got back to me, did they just claim to fix it, because it has not been worked on. Still runs great at 300,000 miles but if the engine has a safety issue that might catch on fire then I want to get it addressed regardless of its high mileage

A. Safety Defect and Failure Sequence I am filing this complaint because my Kia Soul, which is subject to the widespread engine defect and extended warranty under the Hyundai/Kia Class Action Settlement, suffered a catastrophic failure immediately following dealership intervention. Responsible Action: I brought the vehicle to the authorized Kia dealership on September 25th the instant the Check Engine Light illuminated for the very first time. The vehicle was driven to the dealership under its own power. Triggering Event: The dealership performed the required engine-related software update (Knock Sensor Detection System, KSDS) and routine service. Immediately following this service, the engine went into limp mode and ceased functioning, requiring a complete engine replacement. This sequence strongly suggests the failure was either caused by the known defect covered by the recall or was triggered by the software update itself. Manufacturer Denial: Kia is denying the claim under the Class Action Extended...

The contact owns a 2016 Kia Soul. The contact stated that while driving at various speeds or while shifted into park(P), there was an abnormal knocking sound coming from the engine. The check engine warning light was illuminated. The vehicle had been taken to the local dealer, where it was diagnosed as needing a Product Improvement Code before the failure. The vehicle was not repaired due to the cost. The contact stated that a rental vehicle was paid for out of pocket. The contact related the failure to NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling); and the contact was informed that the vehicle was repaired prior to ownership in 2020. The manufacturer was made aware of the failure. The failure mileage was approximately 117,000.

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact became aware that there was oil leaking from the engine near the spark plugs while checking prior to the warning light being illuminated. The vehicle was taken to a local dealer who diagnosed the vehicle and determined that the head gasket needed to be replaced. The vehicle was repaired; however, the vehicle was still leaking oil, and the check engine warning light was illuminated. The contact was constantly adding oil to the engine. The contact had taken the vehicle back to the same dealer and was advised that the catalytic converter needed to be replaced, and a tune-up was needed. The catalytic converter was not replaced, and the contact stated that the engine was still leaking oil. The vehicle was not repaired. The contact had...

While driving my 2016 Kia Soul on the highway, the vehicle suddenly began shaking and immediately lost power. The check engine light came on and the car would not accelerate, even when pressing the gas pedal. This happened with no prior warning. I had to coast to the shoulder in moving traffic, which created a safety concern. The engine then stalled completely and would not restart. The vehicle was towed to Findlay Kia in Las Vegas. Their technicians diagnosed a major internal engine failure. The repair report shows zero compression in cylinder 2, a cracked intake valve, oil contamination, and extensive internal engine damage requiring a full engine replacement. Diagnostic trouble codes included P0300, P0302, P0303, and P0326. There were no earlier symptoms, no overheating, and the vehicle has been properly maintained. The failure was sudden and left the car completely inoperable. I opened Case #[XXX] with Kia Corporate. They...

I was driving in the carpool line to Anaheim with my daughter, the car starts pulling and make a noise in the front part and start loosing speed, from 75 miles per hour to 40 miles per hours in 2 minutes. I drove to the safety zone but in high risk to a crash. All the sensor lights on in the front part. And the steering feels hard, no movement. We feel so stressed and unsafe. The police officer help us and The 511 towing help this was on October 16th. We pay $830 dlls to the AAA to bring the car to San Diego.

The contact owns a 2016 Kia Soul. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact heard an abnormal clunking sound coming from underneath the vehicle. In addition, the RPMs increased to 3,000 and the vehicle lost motive power. No warning lights were illuminated. The vehicle was driven to the shoulder of the road. The contact turned the vehicle off. The contact stated that while attempting to start the vehicle, the vehicle started. However, the accelerator pedal was depressed, and the RPMs increased to 3,000 again. In addition, the contact stated that the vehicle failed to accelerate above 20 MPH. The vehicle was towed to the dealer, where it was diagnosed with catalytic converter failure. The contact was informed that the catalytic converter needed to be replaced. The vehicle was not repaired. The contact...

Had 3 oil consumption test 2 oil leak repairs, low to no oil each time, now car is stalling , Catalytitic Converter problem, yellow engine light is blinking, Kia of Newton New Jersey need to fix my car.

Car was purchased from dealership August 25, 2025 on September 19, 2025 at about 9:38 PM. Car experienced catastrophic engine failure due to an active recall/campaign that was not disclosed to buyer for an ECU problem. This problem caused total brake failure in the power brake system, forcing buyer to swerve across three lanes of traffic into breakdown lane.

Rcall SC176 I have tried multiple times to schedule the required recall repair for my Kia, but my local dealer has not responded to phone calls or emails. I cannot travel to another state to complete this recall. Kia has not provided a reasonable option to complete the safety repair. I am requesting assistance to get this recall completed safely and locally, and at no cost.

The engine makes a noise like a knock, when the car is running or the speed increases the noise becomes louder and it feels like a strong blow coming from the engine.

I was on my way home from work and the car just cut off .it wont move forward or backwords..the lights,radio all was on the car just wouldnt move ..i turned the key off and tried to start it up..it did nothing ..waited bout 10 minutes it started back up ..i looked up the recalls .SC176 sounds like what happen to it

My 2016 Kia Soul is now consuming oil excessively and emitting smoke from the exhaust. These symptoms only began after a dealership performed recall-related work (knock sensor replacement and KSDS software update). The vehicle is covered under Kia’s Technical Service Bulletin ENG222 (Rev. 7, Feb. 2025), which lists the Kia Soul (2012–2024) as eligible for evaluation and repair of oil consumption due to piston oil ring failure. This bulletin requires that a sealed oil consumption test be performed when customer complaints of oil consumption or smoke are verified. Despite this, Kia America has denied warranty coverage, stating the vehicle passed the rod bearing clearance test (BCT) and therefore does not qualify for an engine replacement under the class action settlement. This is misleading and incomplete because: The oil consumption issue is a separate covered defect under TSB ENG222. My vehicle is within the mileage (94k) and time limit (15 years/150k...

The check engine light has come on multiple times, indicating an engine failure defect, a known and recurring issue among this vehicle’s model. The problem first occurred on [XXX], again on [XXX], and is ongoing since [XXX]. The vehicle has been inoperable since [XXX], and remains at the dealership. The defect puts the safety of the driver and others at risk because the vehicle can become inoperable without warning while driving. The issue has been inspected and documented by the dealership each time it occurred, but repairs under warranty have failed to resolve the defect. Prior to the failures, the check engine light illuminated as a warning. The recurring nature of the problem and its continued presence despite recommended maintenance indicate a systemic engine defect that has not been adequately repaired or addressed by the manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

2016 KIA SOUL- While driving, vehicle lost power, check eng light came on and vehicle would not accelerate, engine started making noise- pulled over and shut car off. Had vehicle towed to independent shop and was diagnosed with bad catalytic (manifold) convertor- they changed oil and filter and also found metal in oil, which I never experienced till this incident- upon research i found that there was a recall on that convertor, i called dealer, had towed there- diagnosed as convertor, was told covered one day, then called next and told it was not. Evidently, looking at reviews and complaints, there are many people driving 2016 kia souls that were not covered under this catalytic recall. Seems that Kia never fixed the original issue. Warning DON'T BUY A KIA- I have contacted Kia customer care, case [XXX] and they have said car did not have recall and are not giving...

Check engine light came on. 4 new engine coils and spark plugs. Carb cleaner in gas. Check engine light on again then while driving car jerked and check engine light blinking. Code 420 catalytic converter. This vehicle was under recall for same issue but was ok at time of recall. Was checked at Kia dealership u see recall time.

My 2016 Kia Soul is experiencing severe oil consumption, piston ring failure, and smoke from the exhaust. The vehicle is covered under Kia’s engine warranty extension (Product Improvement Campaign PI2002B and subsequent updates), which extends coverage to 15 years/150,000 miles on the engine short block/long block assembly. The dealership confirmed the failure is due to piston oil rings, but Kia America has denied warranty coverage, stating that because the rod bearing clearance test passed, the repair is not covered. This denial contradicts Kia’s own documentation, which defines the covered “short block assembly” as including pistons and piston rings, in addition to bearings and connecting rods. By refusing coverage, Kia is effectively narrowing the warranty in a way that leaves consumers unprotected, despite the campaign language. This issue raises a safety concern because excessive oil consumption and piston ring failure can lead to: Engine smoke and emissions problems, Sudden power loss,...

The vehicle when coming to a stop to park I press the engine off button and a car with a key symbol stays on and won’t go off and there is a beeping with screen not turning off. Have to turn car on and off numerous times to get it to turn off

While driving my 2016 Kia Soul Plus on the highway, smoke began coming from the rear of the vehicle. Within seconds, flames were visible. Other drivers flagged me down, and I was able to pull over. I evacuated three dogs from the car, but the vehicle quickly became engulfed in flames and was a total loss. The fire department responded and extinguished the fire. There were no warning lights or unusual performance issues immediately before the fire started. The vehicle had not been modified and was in regular use. This incident posed a severe risk to my safety, the safety of my pets, and others on the road. My VIN currently shows no active recalls, but Kia has issued recalls for engine and electrical fire risks in other Soul models. The fire appears related to engine, electrical, or fuel system malfunction. I strongly believe this defect should be investigated for...

Kia 2016 died in mid traffic, would not switch out of 1st gear as an automatic, on a major road in Texas, no warning lights etc. Could be Transmission or Catalytic convertor.

Unknown

The vehicle started losing power and then stalled just as we pulled onto our road to our home, no light indicators were on and it started back up, but the traffic behind us causing slowing and potential risk to us and others. When restarted it would not accelerate appropriately and at that time we were able to put it in neutral and push it the remaining way, again causing a VERY dangerous situation. Upon inspection it was noticed that the oil was barely readable. We added 4 quarts (the vehicle has routine oil changes and is not due for another month or 1,000 miles) and let it sit for about 20 minutes. Upon restarting, the engine started making a loud pinging sound and oil was noticed coming out around the butterfly valve. At that time the cabin air filter and engine air filter was changed, butterfly valve cleaned and another...

4 29 23 at 101091 miles the catalytic converter was replaced. The car sucks up oil before even the 3000 .mark..kia performed. Then on7/8/25 wg baker replaced catalytic converter again. Also coding of abs brakes now and why would catalytic converter need replacing? Because car is eating off oil. Yes my car stopped on the interstate and I had to pull over. I've already done two tune ups.

Engine has lower end knocking noise,internal failure

On our way to Florida, our car broke down on the highway. When we were able to get our car towed to a mechanic, the mechanic stated that the issue was a rod bearing went out which matches the kia recall reasons for the same vehicle as ours. We took the car to Kia and they tested it and the rod bearing was the issue. We had no warning lights prior to our car breaking down and it was taken for an oil change just 5 days before. See below for more info on the recall: The 2016 Kia Soul, specifically models with the 1.6L GDI engine, was included in a Kia product improvement campaign related to connecting rod bearing wear. This campaign involved a software update for the Engine Control Unit (ECU) to implement a Knock Sensor Detection System (KSDS). The KSDS is designed to detect early signs of...

Component/system failed: Engine and Power Train. Available for inspection: Yes, the vehicle is currently at the dealership. After a loud ticking/knocking noise from the engine began, the car lost power while driving. It matches symptoms associated with Kia’s known connecting rod bearing failure issue (covered under Recall SC176 and Campaign PI2002A). There were no warning lamps at first, but later the oil pressure warning light began to flash intermittently. A Kia dealership confirmed the issue and completed the PI2002A ECU update. However, they denied the extended engine warranty coverage under the campaign, saying that the vehicle was purchased at an auction, even though this issue stems from a known manufacturing defect and recall that should apply to the vehicle, regardless of ownership history. This creates a serious safety concern, as the engine could seize while driving. This issue has been reproduced and confirmed by the dealership and documented under Kia...

Check engine light came on 6months ago the code was P0420 I took it to a Kia dealership they said my catalytic converter was worn out and it would be $1500 to replace it I brought up how there was a recall he told me the vehicle already had the recall taken care of from the previous owner of the vehicle and would not fix it again i have no proof they fixed the recall and if they did it obviously didn’t work now that car don’t drive at all the catalytic converter is clogged I’m still making payments on the car this hell for me having hard time getting to work now with no transportation I need some guidance it’s not fair they can just tell me the previous owner got it fixed and even if they did it didn’t work or they didn’t do it right is there...

The contact owns a 2016 Kia Soul. The contact stated while driving in a parking lot at approximately 10 MPH, the engine seized. The contact was able to coast to a nearby parking space, where the vehicle lost power and shut off. The contact attempted to restart the vehicle and the check engine warning light illuminated. The vehicle was unable to start the vehicle. The vehicle was towed to the residence. The vehicle was inspected by a certified mechanic who diagnosed the vehicle with engine failure. The mechanic suggested that the engine be replaced. The contact became aware of a Software Update Program with an extension for an engine replacement. The vehicle was towed to the dealer and confirmed the diagnostic result. The dealer informed the contact that the engine would not be covered by Kia because the Software Update Program update was not being completed. The manufacturer was informed...

I own a 2016 Kia Soul, VIN [XXX] . The vehicle suffered engine failure and is currently at Kia of Bradley in Illinois. My vehicle is covered under Recall SC176 (NHTSA #19V120) for a known defect that can cause engine damage and fire risk. Kia has denied my recall claim, stating that I did not receive the ECU update and that there is “sludge” under the oil cap. I was never properly notified that failure to receive the update would void my recall protection. Sludge presence is not proven to be the cause of the failure, and no oil analysis or inspection has been performed. The recall mandates free repair or replacement of the engine if damage is present, and this has not been honored. Kia is attempting to charge $600 just for diagnostics and has refused to repair the safety issue despite the engine failing. I am asking NHTSA...

Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire. I have replaced my catalytic converter twice in the last year due to this issue. Engine is dumping oil into catalytic converter causing it to stop up. There was a recall for the 1.6 engine, mine is 2.0 and the issue is exactly the same. 19V-120 / SC176 Recall Summary#19V120000

My 2016 Kia Soul Plus (VIN: [XXX] ) showed a blinking check engine light and entered limp mode while driving. I had the code read and received P1326, which is a known issue in Kia vehicles related to the Knock Sensor Detection System (KSDS). This code indicates possible engine bearing wear or impending engine failure, which could result in engine stall or fire, creating a serious safety risk while driving. My car has under 115,000 miles, but I purchased it used from a non-Kia dealer and was told by Kia that it's not covered under warranty or recall. However, many vehicles with this issue received engine replacements or software updates under TSB PI2002 and other campaigns. I am requesting that NHTSA investigate this issue for the 2016 Kia Soul, as it appears to be part of the larger engine defect trend affecting many Kia models. This vehicle should be included...

2016 Kia Soul engine burns excessive amounts of oil leading to constantly needing to top off oil and/or oil changes. When car accelerate white smoke comes from engines; mechanic has pictures of white ash on engine components. We have taken it to the dealership after it was purchased by Carmax in June 2024 the check engine light was displayed, but were told no codes came up. We have taken the car to multiple private mechanics and were told this is a common problem and there is a recall on these engines. Finally 2 weeks ago auto repair shop confirmed engine faulty took pictures of white ash on engine components and advised to tow car to dealership re: extended recall on these engines. Dealership states the car now needs a catalytic converter; however this is a direct result of oil deposits in the exhaust that damage the catalytic converter. We have...

CATALYIC CONVERTER IS DAMAGE

I had my crankshaft sensor replaced and it is still stalling on me. Engine has stalled while I was driving and this has put my life at risk and my job at risk.

I was never informed about the issues with my 1.6 GI engine YEARS AGO. And now my engine went bad in my 2016 Kia soul and kia screwed me and won’t cover fixing my car. I’m so disgusted with kia and their customer service for not helping me or ever informing me.

On May 17, 2025, the engine in our 2016 Kia Soul seized up and was destroyed. It is within Kia’s 10 year/100,000 mile drivetrain warranty. They are refusing to honor the warrant stating there was a recall on the vehicle that we never got fixed. The only unrepaired recall on this vehicle involves the steering, nothing to do with the motor. They are trying to escape the responsibility that they have promised to the American consumer.

My 2016 Kia soul had the engine white come on. I took it to have the computer read what the problem was. It came back engine knock sensor. I was told there was a recall on this and I needed to take it to an authorized Kia dealer. I took this to an authorized Kia dealer who told me that that was a faulty check engine light there was nothing wrong with the sensor, but my pistons were bad and I needed a new engine. Well, when I read further into the recall, it specifically said that this check engine sensor issue could affect the engine. My car just hit 100,000 miles. I had regular service. I now have a Kia who is sitting in front of my house not being able to be run. I truly feel that there is an issue that was not addressed when it was...

Car started rapidly slowing while on the highway and would not accelerate. After taking it to the dealership they said the catalytic converter is clogged and will need replaced. Seems to be a common issue with this vehicle that is not always covered by recall for whatever reason.

My vehicle has stranded me twice due to the same issue—error code P1326, which I am regrettably too familiar with. It is apparently associated with the Knock Sensor Detection System and the possibility of defective piston oil rings

My engine failed in a2016 Kia Soul.It is available upon inspection. My safety was at risk because the engine went bad all of a sudden. The vehicle has been inspected by a repair facility.Yes I went to a dealership and ask about knocking noise they didn’t say anything about ksds and made me an appointment a week later.

Car is making a knocking sound. Car is going thru more oil than normal. Causing the motor to get hot.

About a year ago I got my car serviced for the recall that was due to a potential issue with the catalytic converter overheating. High exhaust gas temperatures could damage the catalytic converter, potentially leading to abnormal engine combustion, piston damage, and even a fire. As of today 4/22/2025 I was told my catalytic converter needs to be replaced. I first noticed a check engine light 12/20/2024 and I got the code read from my local AutoZone. The code came back my catalytic converter. After doing some research I seen an active recall which I described as above. I scheduled an appointment at my local Kia Dealership which is also where I go the car. They got me in 01/2025 to service the recall. Here i am just a year past the recall and I've been told I need a whole new catalytic converter which is going to run me...

In order to complete the Recall SC176 on my vehicle, I am required to submit comprehensive maintenance records. Since purchasing the car used in 2019, all routine maintenance—excluding tires and brakes—has been performed by the original selling dealership. However, that dealership is unable to provide the necessary documentation. As a result, the Kia dealership handling the recall is refusing to perform the required repairs, citing court-ordered terms that mandate maintenance record verification. Despite extensive discussions with Kia, there appears to be no alternative path forward without these records. This situation leaves me with two unacceptable options: continue driving a vehicle with a potentially hazardous, unrepaired engine, or reduce my household to a single vehicle—an outcome that would create significant hardship for my family. Additionally, because we are currently enrolled in a debt consolidation program, taking out any form of loan to replace this vehicle is not permitted. The lack of...

Cadillac converter melted