2010 FORD FUSION Engine Problems

TL* THE CONTACT OWNS A 2010 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THERE WAS A COMPLETE LOSS OF ENGINE POWER WITHOUT WARNING. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD WHERE THE ENGINE WAS TURNED OFF. THE ENGINE WAS RESTARTED AFTER SEVERAL ATTEMPTS AND THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED SEVEN TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. IN ADDITION, THE RACK AND PINION FAILED. THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.

WHILE TRAVELING ON OHIO ROUTE 306, THE CAR LOST ALL THROTTLE POWER ABRUPTLY, IN HEAVY TRAFFIC. DUE TO THE FAILURE OF THE THROTTLE BODY, I WENT FROM 45 TO ZERO ON AN INCLINE WITH MANY CARS BEHIND ME HONKING. I RESTARTED THE CAR BUT WHILE THE ENGINE WAS RUNNING I HAD NO THROTTLE POWER AT ALL. FORD DOES NOT SEE A PROBLEM HERE AND SAID IT IS NOT A MAJOR ISSUE. HAD MY DAUGHTER BEEN DRIVING AND THIS HAPPENED TO HER, I WOULD HAVE BEEN CONCERNED FOR HER SAFETY WITH THE HEAVY TRAFFIC AND DANGEROUS CONDITIONS GETTING OUT OF THE VEHICLE. THOUGH I WAS NOT AS CONCERNED FOR MYSELF, THE FAILURE PUT ME IN AN EXTREMELY VULNERABLE AND DANGEROUS STATE. *TR

I WAS DRIVING HOME FROM WORK WHEN MY CAR STALLED AND A WRENCH LIGHT CAME ON. I IMMEDIATELY PULLED OVER TO THE SIDE OF THE ROAD, TURNED THE CAR OFF AND ON, AND DROVE TO MY MECHANIC. HE DROVE AROUND TO TRY AND RE CREATE THE PROBLEM. AFTER 100 OR SO MILES IT HAPPENED AGAIN AND IT TURNED OUT TO BE CODES P2111 AND P2112 WHICH TURNED OUT TO BE THROTTLE BODY CODES. I HAD TO PAY TO GET THE THROTTLE BODY REPLACED BECAUSE IT IS NOT COVERED UNDER ANY WARRANTY AND IS NOT A RECALLED PART. *TR

DRIVING VEHICLE AND THE ENGINE STARTS SURGING AND FAILS TO RESPONSE TO GAS PEDAL MOVEMENT. THE DTC CODE DISPLAYED TWO DAYS LATER WITH CODE READER CONNECT PRE-FAILURE WAS P2111. *TR

WHILE TRAVELING ON I64 SUNDAY SEPTEMBER 8TH ON THE WAY HOME FROM WILLIAMSBURG , MY CAR , WHILE IN A LOT OF HEAVY TRAFFIC ON THE INTERSTATE , STALLED AND THE " WRENCH " LIGHT CAME ON . LUCKILY I HAD GOOD CONTROL OF THE CAR TO PULL OFF THE INTERSTATE . THE CAR LOST ALL POWER AND WOULDN'T RESPONSE TO THROTTLE INPUT. THE CAR WAS SHUT OFF AND AFTER 10 MINUTES, ATTEMPT TO RESTART CAR WHICH WAS SUCCESSFUL. CAR RUN NORMALLY FOR ABOUT 140 ADDITIONAL MILES, THEN STALLED TO LOW POWER AND LACK OF THROTTLE RESPONSE YET AGAIN. TURNING OFF AND THEN TURNING BACK ON WAS UNSUCCESSFUL IN GETTING THE VEHICLE TO RUN NORMAL AGAIN. TOW TRUCK WAS CALLED AND VEHICLE TOWED TO LOCAL FORD DEALERSHIP. WAS INFORMED THAT THE THROTTLE BODY WAS THE CULPRIT AND WAS ON BACKORDER. IF THIS IS A KNOWN PROBLEM, WHY ARE PEOPLE BEING...

WAS DRIVING ON A STATE ROAD GOING APPROXIMATELY 40-45 MPH. BEGAN TO ACCELERATE TO GO UP AN INCLINE AND THEN ENGINE SPUTTERED AND THEN SHUT OFF. SAME THING HAPPENED A WEEK LATER GOING ABOUT 5-10 MPH WHILE ACCELERATING FROM A STOP SIGN ON A RESIDENTIAL STREET. TOOK THE CAR TO THE DEALERSHIP AND THE PROBLEM WAS A BAD THROTTLE BODY WHICH WAS REPLACED. *TR

WHILE DRIVING ON THE HIGHWAY, VEHICLE EXPERIENCED IMMEDIATE, SUDDEN AND COMPLETE LOSS OF ENGINE POWER (ENGINE WOULD NOT RESPOND TO THROTTLE DEPRESSION AND REMAINED AT IDLE) WITH ASSOCIATED YELLOW MAINTENANCE WRENCH ILLUMINATED ON INSTRUMENT CLUSTER. DRIVER HAD TO EXECUTE A DANGEROUS DECELERATING 4 LANE CHANGE TO STOP VEHICLE ON A LIMITED AND NARROW SHOULDER. AFTER RESTARTING VEHICLE, THE LIGHT DISAPPEARED, AND THE VEHICLE WAS ABLE TO BE DRIVEN BEFORE SAME MECHANICAL FAILURE OCCURRED AFTER 1 MILE. VEHICLE WAS DRIVEN 10 MILES TO NEAREST FORD DEALER AT SLOW SPEEDS AND BACK ROADS. POWER LOSS OCCURRED APPROXIMATELY 8 MORE TIMES WHILE ENROUTE TO DEALER. EXTREMELY DANGEROUS AND INSIDIOUS MODE OF FAILURE WITHOUT WARNING. COULD HAVE EASILY RESULTED IN A FATAL CRASH IF IT HAD OCCURRED DURING A HIGHWAY MERGE OR CROSSING TRAFFIC SITUATION. CONSPICUOUSLY CONVENIENT TIMING OF FAILURE 2 MONTHS AND 1000 MILES AFTER WARRANTY EXPIRATION. AFTER DIALOGUE WITH FORD CUSTOMER SERVICE,...

SECOND ENGINE/POWER TRAIN FAILURE WITHIN 4,000 MILES OF VEHICLE 36 MONTH, 36,000 MILE WARRANTY EXPIRATION (FIRST FAILURE WAS A TOTAL POWER LOSS AT HIGH WAY SPEEDS WITHIN 1,000 MILES OF WARRANTY EXPIRATION). VEHICLE SUDDENLY BEGAN JERKING, SHUTTERING AND HESITATING UPON FIRST ACCELERATION. FORD EVALUATED MASS FLOW SENSOR TO BE FAULTY AND REPLACED AT $425 COST IN ADDITION TO $50 RENTAL CAR. UPON CONSULTATION WITH FORD CUSTOMER SERVICE, NO COSTS WERE COVERED OR REIMBURSED. MY WIFE OFTEN TRAVELS ALONE WITH MY CHILDREN, SO WE PURCHASE NEW CARS SPECIFICALLY TO AVOID SUCH BREAK DOWNS AND MAINTENANCE PROBLEMS. WE PAID CASH FOR THIS VEHICLE, AND COULD BUY A NEW BMW 760IL TOMORROW FREE AND CLEAR. INSTEAD, WE BOUGHT A FORD FUSION TO SHOW SUPPORT FOR THE AMERICAN AUTO INDUSTRY. UNDERSTAND THAT MECHANICAL FAILURES HAPPEN, BUT VERY DISAPPOINTED WITH FORD CUSTOMER SERVICE FOR NOT REIMBURSING OR ISSUING RECALLS FOR THESE KNOWN MANUFACTURER DEFECTS OCCURRING...

DROVE OFF FROM WORK AND SHORTLY AFTER I NOTICED THE CAR SLOWED DOWN AND STARTED TO VIBRATE AND FINALLY LOST POWER. I WAS ABLE TO PULL OVER, I TURNED OFF CAR THEN TRIED TO RESTART BUT IT DID THE SAME THING. I THEN DECIDED TO SHUT IT OFF AGAIN AND GIVE IT MORE TIME SURELY AFTER A FEW MINUTES IT SEEMED TO BE FINE BUT RIGHT BEFORE GETTING HOME IT HAPPENED AGAIN. HUSBAND DROVE TO AUTOZONE AND HAD A DIAGNOSTIC CHECK AND RESULTS WERE..."TROUBLE SHOOTING PROBLEM FROM AUTO ZONE CODE P2111 THE THROTTLE ACTUATOR CONTROL SYSTEM". *TR

TL* THE CONTACT OWNS A 2010 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 50,000.

IT FIRST HAPPENED ON TUESDAY SEPTEMBER 3, 2013 WHILE DRIVING ON A MAIN ROAD RETURNING TO MY HOME. THE SPEED WAS 50 MILES PER HOUR AND ALL OF A SUDDEN A WRENCH TOOL LIGHT SHINES AND MY CAR JUST SLOWS DOWN TO 5 MILES AND THEN STOPS. LUCKILY IT WAS LATE AT NIGHT AND I WAS IN THE RIGHT HAND LANE AND COULD TURN INTO A DRIVEWAY OF A CAR WASH. IT WAS A SCARY THING AND I WAS ALL ALONE. I TURNED OFF THE CAR AND SAT FOR A MINUTE AND THEN TURNED IT BACK ON. I WAS ABLE TO GO 1 MILE TO MY HOME AND PARK THE CAR. I THOUGHT IT MIGHT BE A FLUKE. I DIDN'T DRIVE IT AGAIN UNTIL THURSDAY WHEN IT OCCURRED ON THE SAME STREET CLOSE TO THE SAME PLACE. I WAS ALMOST REAR-ENDED BY A CAR BEHIND ME. ON SATURDAY, I WAS...

WRENCH LIGHT CAME ON THE CAR SLOWED DOWN SHAKE BAD AND NO THROTTLE RESPONSE AT ALL, HAD IT TOWED IN FOR SERVICE AND WAS TOLD IT WAS A THROTTLE BODY ASSEMBLY FAILURE, NOT COVERED UNDER POWER TRAIN WARRANTY. *TR

I WAS TRAVELLING ON AN INTERSTATE DOING 70 MILES AN HOUR WHEN MY CAR MADE A BANG AND I LOST ALL THROTTLE RESPONSE. THE CAR WAS RUNNING, SEEMED TO GO INTO NEUTRAL BUT PRESSING THE GAS PEDAL DID NOTHING. I WAS ABLE TO COST OVER 4 LANES DODGING TRAFFIC TO GET TO A SPOT WHERE I COULD COME TO STOP. AFTER TURNING OFF THE ENGINE AND RESTARTING EVERYTHING WENT BACK TO NORMAL. NOW JUST OVER A WEEK LATER IT HAPPENED 3 MORE TIMES IN 1 DAY. DOING RESEARCH IT SEEMS THIS IS A COMMON COMPLAINT FROM FUSION AND ESCAPE OWNERS. IT ALSO SEEMS THERE MAY BE AN INVESTIGATION UNDER WAY AS TO WHETHER THIS SHOULD BE A RECALL ISSUE. NOW IF FORD WAS TO FIX THIS IT WOULD BE 1 THING, BUT AFTER ALMOST KILLING ME ON THE INTERSTATE I NOW HAVE TO FORK OVER $400 TO THE DEALERSHIP BECAUSE...

WHILE ACCELERATING HEARD A CLUNK AND LOST ALL POWER TO THE TRANSMISSION AND THROTTLE. THROTTLE LIGHT CAME ON, CAR RAN ROUGH. HAD TO COAST TO THE SIDE OF THE ROAD. TURNED CAR OFF AND BACK ON. CAR RAN FINE, LIGHT WENT OFF AND I CONTINUED HOME. NOW IT HAPPENED AGAIN LAST WEEK WHILE GOING 65 ON THE INTERSTATE. SAME SCENARIO. IT HAPPENED AGAIN YESTERDAY AND TWICE THIS MORNING. CRUISE WAS SET THE LAST 3 TIMES, GOING 68 ON THE INTERSTATE. LAST TIME IN ADDITION TO THE THROTTLE WARNING LIGHT THE CHECK ENGINE LIGHT CAME ON AND STAYED ON EVEN AFTER RESTARTING. THIS COULD HAVE BEEN BAD ON THE INTERSTATE, BUT THERE WASN'T MUCH TRAFFIC. IT IS NOW AT THE SHOP WAITING ON THE VERDICT.

UPON ACCELERATING FROM STOP AT CITY INTERSECTION TO 30 MPH, CAR SUDDENLY LOST ALL ACCELERATION. COASTED INTO NEARBY LOT. "WRENCH" LIGHT ON. TURNED CAR OFF. LUCKILY, NO CAR HAD BEEN APPROACHING FROM REAR, AND THIS WAS BEFORE ENTERING RAMP TO BUSY 60 MPH HIGHWAY. CAR RAN, AS IF NORMAL AFTER RE-STARTING, WRENCH LIGHT OUT. DROVE 15 MILES TO DEALER SERVICE SHOP. SHOP PERFORMED FORD'S THROTTLE BODY TEST PROCEDURE AND VERIFIED THROTTLE BODY HAD FAILED. SHOP REPLACED ELECTRONIC THROTTLE BODY ASSEMBLY; CAR AT 54,000 MILES. FROM RESEARCHING, SEE THAT THIS A PREVALENT ISSUE WITH INCREASING RATE OF OCCURRENCE (A TOP 5 CAR COMPLAINT OVER PAST 90 DAYS). GIVEN THE APPARENT INCIDENT RATE, INTERMITTENT NATURE, AND ODDS OF OCCURRING WITH SUDDEN SURPRISE IN TRAFFIC MOVING AT SPEED, CLEARLY PRESENTS A HAZARDOUS CONDITION AND COMPROMISES SAFETY IN OTHERWISE NORMAL DRIVING CIRCUMSTANCES. EVIDENTLY PROBLEM OCCURS WITHIN PREDICTABLE RANGE ON ODOMETER, WHICH PROBABLY INDICATES SOME...

THE VEHICLE WAS COMING TO A STOP AND THE ENGINE LOST POWER AND STALLED. THIS HAS OCCURRED TWO TIME IN THE PAST 4 WEEKS. THE VEHICLE HAD BEEN DRIVEN AT LEAST A FEW MILES BEFORE THIS OCCURRED BOTH TIMES. PUT THE VEHICLE IN PARK AND IT STARTED IMMEDIATELY AND I WAS ABLE TO DRIVE AWAY. THE VEHICLE APPEARS TO NOT BE IDLING TO SLOW. *JB

TL* THE CONTACT OWNS A 2010 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED AS THE WRENCH WARNING LAMP ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 71,000.

CAR ENGINE SHUT OFF AT 40 MPH , STEP ON GAS NOTHING HAPPENS. CAR JERKS AND SPUTTERS. MUST PULL TO SIDE OF ROAD AND SHUT OFF ENGINE. WAIT 2 MINUTES AND TRY TO RESTART. RETURNED TO DEALER WITHOUT SUCCESS 3 TIMES. CAR HAS SHUT OFF 6 TIMES SINCE AT DIFFERENT SPEEDS AND HEAVY TRAFFIC. A REAL SAFETY HAZARD! *JB

DRIVING ALONG AND VEHICLE LOST POWER. PULLED OVER AND TURNED OF VEHICLE. WAITED 1 MINUTE AND STARTED VEHICLE UP AND WAS ABLE TO DRIVE AGAIN. THIS HAS OCCURRED AT LEAST 15 TIMES SINCE THE FIRST TIME AND MOST OF THEM OCCURRED WHILE I WAS DRIVING ON THE INTERSTATE. ALWAYS HAD TO PULL TO THE SIDE AND SHUT THE VEHICLE OFF, WAIT A MINUTE AND START THE VEHICLE BACK UP AND CAN CONTINUE ON. NO PATTERN EXCEPT OUTSIDE TEMPERATURE WAS ABOVE 80 DEGREES. *JB

WHILE ON THE FREEWAY DOING APPROXIMATELY 65-75 MPH, MY VEHICLE LOST POWER, THE WRENCH LIGHT CAME ON THE DASH, AND THE VEHICLE BEGAN TO STALL. I PULLED OVER TO THE SIDE OF THE FREEWAY, TURNED THE CAR OFF, AND RESTARTED. IT WAS FINE AFTER RESTARTING. A COUPLE DAYS LATER THE INCIDENT OCCURRED AGAIN. WITHIN 4 DAYS, MY VEHICLE BEGAN TO HAVE 4 EPISODES ON MY 11 MILE COMMUTE. THESE ISSUES DURING RUSH HOUR TRAFFIC PROMPTED ME TO BRING IT IN TO THE DEALERSHIP ASAP AS I DID NOT FEEL SAFE DRIVING IT ANY LONGER. MY VEHICLE IS CURRENTLY AT THE DEALERSHIP AWAITING DIAGNOSIS AND REPAIR. AFTER A GOOGLE SEARCH, I AM FAIRLY CERTAIN THAT THE DIAGNOSIS WILL INVOLVE THE THROTTLE BODY.*JB

DRIVING ON HIGHWAY, TRAVELING AT APPX 65-70 MILES PER HOUR - CAR STARTED RATTLING AND THEN SLOWED DOWN CONSIDERABLY - CAR DID NOT STALL, BUT PRESSING ON THE GAS PEDAL AND THE CAR DID NOT ACCELERATE. WAS ABLE TO SAFELY PULL OVER, TURNED THE CAR OFF, TRIED TO DRIVE, BUT THE CAR WOULDN'T DRIVE - ENGINE WORKED FINE, BUT CAR WOULD NOT MOVE FORWARD OR BACKWARD. YELLOW WRENCH LIGHT CAME ON. HAD CAR TOWED TO DEALERSHIP. WAS TOLD IT NEEDS A NEW THROTTLE BODY ASSEMBLY. *JB

TL* THE CONTACT OWNS A 2010 FORD FUSION. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AS THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE ELECTRONIC THROTTLE BODY WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 81,000. THE CONSUMER STATED THE VEHICLE STALLED MULTIPLE TIMES, BEFORE IT STOPPED COMPLETELY. UPDATED 10/22/13

JUST FOUR MONTHS AFTER PURCHASING MY SO CALLED "CERTIFIED PRE-OWNED 172 POINT PASS INSPECTED 2010 FORD FUSION" THE CAR STARTS ACTING UP WHILE DRIVING DOWN A MAIN STREET IN THE MIDDLE OF TOWN, THE CAR LOST ALL ACCELERATION RIGHT AFTER I STARTED TAKING OFF FROM A STOP LIGHT. THE WRENCH LIGHT THEN CAME ON AND THE CAR STARTED TO STALL OUT AS THIS WAS GOING ON I'M ALSO TRYING TO TURN LEFT, WHICH WAS A LITTLE SCARY BECAUSE I BASICALLY CUT SOMEONE OFF WHILE TURNING BECAUSE, I HAD NO ACCELERATION WHATSOEVER TO AVOID THEM. THIS IS A SERIOUS PROBLEM AND I'M NOT THE ONLY ONE WHOSE HAD TO GO THROUGH IT FROM ALL THE SAME COMPLAINTS I SEE ON THE INTERNET. THIS MALFUNCTIONING THROTTLE BODY NEEDS TO BE RECALLED BEFORE SOMEONE GETS SERIOUSLY HURT! *JB

ENGINE DROPPED TO 900 RPM. COASTED TO STOP. VEHICLE WOULD NOT RESPOND TO ACCELERATION. TURNED ENGINE OFF AND RESTARTED MADE IT TO TOWN. DIAGNOSED BY DEALERSHIP AS THROTTLE BODY. PARTS NOT AVAILABLE TILL OCTOBER. THEY HAVE CAR WE HAVE RENTAL BECAUSE WE HAD EXTENDED WARRANTY. IF WE DIDN'T HAVE THAT WE WOULD BE IN TROUBLE. *JB

CAR LOSES POWER AT HIGHWAY SPEED, RPMS DROP TO IDLE, ENGINE IDLES ROUGH AS IF IT IS NOT GETTING SUFFICIENT AIR OR FUEL, AFTER TURNING ENGINE OFF AND RESTARTING, ENGINE OPERATION RETURNS TO NORMAL. INCIDENT HAS RECURRED ONCE. *JB

VEHICLE STALLED IN MOTION. IT HAPPENED SEVERAL TIMES, WITHOUT ANY WARNING OR ANY SIGN OF MALFUNCTION.

DRIVING ON A BUSY INTERSTATE HIGHWAY WHEN SUDDENLY MY CAR LOOSES POWER AND GOES INTO LIMP MODE. ABSOLUTELY NO THROTTLE RESPONSE. WRENCH LIGHT INDICATOR CAME ON. I PULLED OVER TO THE SIDE OF THE ROAD AND MY CAR SHUTTERED A BIT AS I SLOWED DOWN. TURNED THE CAR OFF AND WAITED A MINUTE BEFORE RESTARTING. RESTARTED SLUGGISHLY. BEGAN DRIVING AGAIN AND NO MORE THAN 5 MINUTES LATER, THE SAME THING HAPPENED. THIS TIME THE CHECK ENGINE LIGHT CAME ON. ONCE AGAIN, TURNED CAR OFF, RESTARTED AND BEGAN DRIVING AGAIN. MADE IT INTO A LOCAL BRAKE/MUFFLER SHOP WHERE THEY WERE KIND ENOUGH TO DIAGNOSE THE PROBLEM FOR ME. ERROR CODE P2112 CAME OVER WITH A DESCRIPTION ABOUT THE THROTTLE BODY ACTUATOR BEING STUCK CLOSED. THEY INFORMED ME THEY'VE SEEN THIS PROBLEM MANY TIMES AND IT SEEMS TO BE A COMMON ISSUE. IT MADE SENSE TO ME BECAUSE, LEADING UP TO THIS...

AT HIGHWAY SPEED, THERE WAS A CONTROLLED LOSS OF POWER TO THE ENGINE. UPON SHUTTING DOWN AND RESTARTING, THE PROBLEM CLEARED BUT RECURRED. THE VEHICLE WAS SERVICED AND THE ELECTRONIC THROTTLE BODY WAS REPLACED. *JB

IN THE PAST WEEK, MY VEHICLE HAS "STALLED," FOR LACK OF A BETTER WORD, AT MODERATE TO HIGH SPEEDS ON THREE SEPARATE OCCASIONS. THE THIRD TIME THIS OCCURRED, I WAS DRIVING UPHILL DURING RUSH HOUR ON "THE CUT IN THE HILL," A STRETCH OF HIGHWAY IN NORTHERN KENTUCKY NEAR CINCINNATI KNOWN FOR ITS DISPROPORTIONATELY HIGH NUMBER OF AUTO ACCIDENTS. IT'S A VERY DANGEROUS PLACE FOR A VEHICLE TO SIMPLY STOP AT THE BUSIEST TIME OF DAY. BECAUSE IT WAS GOING UPHILL, THE VEHICLE DID NOT COAST TO A SAFER LOCATION (OR EVEN COAST AT ALL) AS IT HAD DONE DURING PREVIOUS EPISODES AND I WAS UNABLE TO PULL OVER TO THE SHOULDER. I WAS STUCK, BROKEN DOWN, IN THE MIDDLE LEFT LANE. I HAVE BROUGHT MY CAR INTO THE DEALERSHIP FOR THIS EXACT ISSUE TWICE IN THE PAST WHILE IT WAS COVERED UNDER THE BUMPER-TO-BUMPER WARRANTY. THEY CLAIMED THEY COULD...

I ACCELERATED AFTER A RED LIGHT AND WAS TRAVELING UP AN INCLINE AND SUDDENLY I HAD NO ENGINE POWER. I THOUGHT CAR HAD STALLED BUT ALL LIGHTS WERE ON IN THE DASHBOARD AND I STILL HAD STEERING CAPABILITY. I COASTED DOWN THE BRIDGE AND PULLED OFF INTO THE FIRST PUBLIC PARKING I COULD FIND. THE CAR WAS IDLING VERY ROUGH. I SHUT IT OFF, WAITED A FEW MINUTES AND RESTARTED. IT STARTED FINE AND TRAVELED OK ON THE WAY HOME. IT SEEMED A LITTLE HESITANT A COUPLE TIMES BUT IT DIDN'T REPEAT THE "LIMP-MODE" THAT IT WAS IN PREVIOUSLY. *JB

ON 8/17/13 WHILE DRIVING DOWN THE HIGHWAY AT 65 MPH, MY CAR WENT INTO (LIMP MODE) WOULD NO LONG ACCELERATE, WE SAFELY PULLED TO THE SIDE OF THE ROAD AND THE CAR BEGAN TO SHAKE VIOLENTLY. WE PUT THE CAR IN PARK AND SHUT IT OFF, WE RESTARTED THE CAR AND IT WORKED FINE, THE NEXT OCCURRENCE OCCURRED 9/1/13, WHILE ACCELERATING UP A FREEWAY RAMP, ALL THE SAME SYMPTOMS, AGAIN THE CAR RESTARTED FINE. THIRD OCCURRENCE 9/2/13 WHILE DRIVING 35 MPH ON THE STREET. IT SEEMS IT IS THE THROTTLE BODY. MY CAR IS NO LONGER UNDER WARRANTY, I CALLED THE FORD DEALERSHIP AND THEY ARE ON "BACK ORDER FOR THE PART," I WAS ALSO TOLD THIS PART "GOES OUT ALL THE TIME." I AM TOLD IT CAN BE UP TO 1 MONTH FOR THE PART TO COME IN! MY CAR IS NOT DRIVABLE AND IS A SAFETY HAZARD. LUCKILY,...

WE WERE GOING DOWN THE INTERSTATE AND MY CAR STARTED SHAKING AND DIED OUT. THIS CONTINUED 6 MORE TIMES BEFORE WE FOUND A VALVOLINE AND HAD THEM TEST IT ON THEIR COMPUTER. IT GAVE THE CODE P2111 TAC SYSTEM OPEN. NOW THE CODE IS GONE AND THE DEALER CAN NOT FIX IT UNLESS IT DISPLAYS THIS CODE SO WE HAVE TO CONTINUE TO DRIVE IT UNTIL THE ERROR MESSAGE SHOWS UP AGAIN.*JB

I WAS TRAVELING DOWN A 2 LANE HIGHWAY (STATE ROAD, PA) WHEN THE CAR BEGAN TO RAPIDLY LOSE ACCELERATION AND SEEMED TO STALL. THE ENGINE JERKED EXCESSIVELY, BUT NEVER TURNED OFF. NO AMOUNT OF PRESSING THE ACCELERATOR MADE ANY DIFFERENCE. I COASTED TO THE SIDE OF THE ROAD SAFELY. LUCKILY, NO ONE HIT ME. TURNED ENGINE OFF AND CALLED FOR ROADSIDE ASSISTANCE. TURNED THE VEHICLE ON A FEW MINUTES LATER AND EVERYTHING WAS FINE. THE YELLOW WRENCH LIGHT CAME ON WHEN ACCELERATOR LOST CONTROL. NEXT DAY, WHILE DRIVING TO WORK , IT HAPPENED ON RT13N DE AND AGAIN I WAS LUCKY TO BE ABLE TO QUICKLY GET TO THE EMERGENCY LANE. YELLOW WRENCH LIGHT AND NO CONTROL ON ACCELERATOR WITH ENGINE VIBRATING HEAVILY BUT DOES NOT TURN OFF. SWITCHED OFF AND TURNED ON - EVERYTHING IS FINE. SAME DAY EVENING - RETURNING FROM WORK - IT HAPPENS AS I GET...

THE CAR UNEXPECTEDLY LOSSES POWER. IT HAS OCCURRED ON TWO OCCASIONS. YOU CAN CONTINUE TO PRESS ON THE GAS PETAL BUT THE CAR WILL NOT INCREASE IN SPEED.YOU MUST PULL OVER TO THE SIDE OF THE ROAD. TURN THE ENGINE OFF. WAIT A FEW MINUTES AND RESTART THE CAR IN ORDER TO GAIN CONTROL OF THE THROTTLE AGAIN. IT HAS A DEFECTIVE THROTTLE BODY. THIS IS A KNOWN ISSUE TO FORD. THEY HAVE RECALLED THE 2010 ESCAPE FOR THIS SAME ISSUE. FORD NEEDS TO RECALL THE 2010 FORD FUSION FOR THIS ISSUE BEFORE SOMEONE IS KILLED OR INJURED.*JS

MY 2010 FORD FUSION BEGINS TO SHAKE, VIBRATE AND THEN THE ENGINE STALLS WITHOUT WARNING, WHILE DRIVING IN TRAFFIC. THIS HAPPENS WHILE DRIVING AT EITHER INTERSTATE SPEEDS OR CITY DRIVING SPEEDS. I HAVE TO STOP, PLACE MY CAR IN PARK AND RESTART THE ENGINE. I HAVE COME CLOSE TO BEING REAR ENDED BY A CAR BEHIND ME, BOTH ON THE INTERSATE AND ON CITY STREETS. *JS

DRIVING DOWN HIGHWAY WHEN WRENCH LIGHTS UP AND CHECK ENGINE LIGHT WITH NO ACCELERATION. SHUT CAR OFF AND WAS ALLOWED TO MAKE IT UP TO 45MPH AND UNDER 2K RPMS. RECALL FORD FUSION THROTTLE BODIES!!

MOTOR POWER SURGE A FEW TIMES THEN DIED WITH 4 LANES OF TRAFFIC ALL TRAVELING ABOUT 65MLH. WAS ABLE TO TURN KEY OFF AND RESTART MOTOR AND RAN FINE THE REST OF THE WAY HOME. TODAY SURGE A FEW TIMES BUT NOT AS OFTEN AS YESTERDAY. *TT

RAPID DECELERATION WHILE ON THE FREEWAY, WRENCH SIGN CAME ON. PULLED ON THE SIDE OF THE FREEWAY AND CAR STARTED SPUTTERING AND JERKING, TURNED CAR OFF TURNED BACK ON AND DRIVE FINE. BACK ON THE FREEWAY THE NEXT DAY DURING RUSH HOUR TRAFFIC AND RAPID DECELERATION HAPPENED AGAIN. PULLED OVER IN RUSH HOUR TRAFFIC (VERY DANGEROUS BY THE WAY) TURNED CAR OFF AND BACK ON AND RAN FINE. FORD SAYS IT WILL COST ME $565.00 FOR A NEW THROTTLE BODY AND CAM ON A 3 YEAR OLD VEHICLE THAT HAS HAD REGULAR MAINTENANCE. *TT

DRIVER WAS DRIVING WHEN THE VEHICLE STARTED TO LOSE POWER AND WAS GETTING SLOWER AND SLOWER. WHEN THE DRIVER PULLED OVER THE VEHICLE WAS IDLING AND RUNNING ROUGH. THE VEHICLE STALLED AND THE DRIVER TRIED TO RESTART IT AFTER LETTING IT SIT FOR A FEW MINUTES. SHE WAS ABLE TO GET THE VEHICLE TO STATE BACK UP, BUT IT KEPT STALLING. VEHICLE HAD TO BE TOWED TO A FORD DEALERSHIP WHERE IT WAS DETERMINED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. *TT

DRIVER WAS COMPLAINING THAT THE VEHICLE WAS RUNNING ROUGH WHILE DRIVING. THE VEHICLE STALLED A COUPLE OF TIMES AND THE DRIVER WAS ABLE TO GET IT RESTARTED AND DRIVE IT INTO THE NEAREST FORD DEALERSHIP. IT WAS DETERMINED AFTER DIAGNOSTIC THAT IT WAS THE THROTTLE BODY THAT HAD GONE OUT AND NEEDED TO BE REPAIRED. THE SHOP TOLD US IT WOULD BE A MINIMUM OF 3-4 DAYS BEFORE THEY RECEIVED THE THROTTLE BODY ASSEMBLY BEFORE THEY WOULD EVEN BE ABLE TO START THE REPAIRS. *TT

DRIVER STATED THAT THE VEHICLE WAS SHAKING WHILE SHE WAS DRIVING IT AND SHE WAS UNABLE TO ACCELERATE. SHE WAS ABLE TO GET THE VEHICLE PULLED OVER AND TURN IT OFF FOR A FEW MINUTES AND GET IT RESTARTED. SHE TOOK THE VEHICLE TO THE NEAREST FORD DEALERSHIP WHERE IT WAS DETERMINED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. *TT

VEHICLE STALLED AND DRIVER WAS UNABLE TO GET THE VEHICLE RESTARTED ONCE IT WAS PULLED OFF THE ROAD. VEHICLE HAD TO BE TOWED INTO THE NEAREST FORD DEALERSHIP WHERE IT WAS DETERMINED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. *TT

LIKE MANY OTHERS, I'M EXPERIENCING INCREASINGLY FREQUENT ACCELERATION FAILURES (NO ACCELERATION WITH VISUAL CUE AS WELL AS ACCELERATION SURGES) CONSISTENT WITH (AND IDENTIFIED BY DEALER AS) A MALFUNCTIONING ETB. ADDITIONALLY, IT SEEMS THAT THE THROTTLE BODY MAY BE AFFECTED BY BOTH PROXIMITY AND STRESS SENSORS, AS THE FAILURES (AND GENERALLY FAIRLY DRAMATIC DROPS IN SPEED) TEND TO OCCUR MOST FREQUENTLY AT HIGH SPEEDS IN HEAVY TRAFFIC. PER FORD'S RESPONSE TO THE SAFETY INVESTIGATION (INRL-PE13003-57050P), THE MANUFACTURER SUBMITS THAT THE RESULTING FMEM MODE (ALWAYS THE MOST SEVERE OF "GOOD LUCK WITH THAT" IN MY VEHICLE'S CASE) ALLOWS FOR SAFE MANEUVERING. WHILE THIS MAY BE TRUE ON THE TEST COURSES IN DEARBORN, I'D GLADLY VOLUNTEER MY VEHICLE TO ALLOW MY NEIGHBORS TO RE-EVALUATE THIS CLAIM IN ACTUAL LANSING TRAFFIC. *TT

GOING ON THE HIGHWAY AT 70 MPH, ENGINE JUST DIES ON ME, FORCING ME TO PULL OVER, IT LOOSES ALL POWER BUT IT GOES TO A VERY LOW RPM'S FOR A WHILE, ENGINE SHAKES AND AFTER A COUPLE OF MINUTES JUST TURN OFF, I TURN IT BACK ON AND IT RUNS LIKE NOTHING HAPPENED. I WAS OUT OF TIME APPROXIMATELY 200 MILES AWAY FROM HOME, THIS CONDITION HAPPENED TO ME FOR ABOUT 15 TIMES IN A 100 MILES RANGE. SOME TIMES IT TAKES PLACE JUST AFTER LEAVING A PARKING LOT, SOME OTHER TIMES AT 20 MPH SO IT IS VERY UNPREDICTIBLE BUT AT THE SAME TIME PRETTY DANGEROUS. EVERY ONCE ON A WHILE CHECK ENGINE LIGHT GOES OFF, THEN IT IS NOT THERE. *TT

BASICALLY THE CAR SHUT DOWN DRIVING DOWN THE PENNSYLVANIA TURNPIKE ON FRIDAY MORNING AT 65 MPH, THE CAR TOTALLY SHUT DOWN. THIS HAPPENED 2 TIMES AT 65 MPH AND ONE TIME AT ABOUT 25 MPH WHILE ENTERING THE TURNPIKE. I WAS VERY LUCKY THAT THE TRACTOR TRAILER BEHIND ME GOING ABOUT 70 MPH, SAW SOMETHING WAS WRONG WITH MY CAR AND HAD TIME MOVED OVER INTO THE PASSING OR HE WOULD HAVE HIT MY CAR AND KILLED ME. THIS HAPPEN ONE MORE TIME DURING MY MORNING COMMUTE AT THAT SPEED. I TOOK MY CAR YESTERDAY TO THE FORD DEALER AND HE REPAIRED THE THROTTLE BODY MOTOR ASSEMBLY. I HAVE NOTIFIED FORD CUSTOMER SERVICE CASE # CAS-#[XXX], BUT I BELIEVE THIS IS AN IMMEDIATE LIFE & HEALTH SAFETY RECALL ISSUE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I WAS DRIVING AND A WRENCH CAME ON MY DASH, THE CAR STALLED AND LOST ALL THROTTLE. ITS HAPPENED TO ME BEFORE BUT NOW ITS DOING IT ALOT MORE. I AM AFRAID I WILL GET HURT. *TR

I WAS DRIVING MY CAR ON THE EXPRESSWAY AND SUDDENLY MY ENGINE DIED WITH NO WARNING AND THE RPMS DROPPED. I CAME VERY CLOSE TO AN ACCIDENT AND LUCKILY WAS ABLE TO GET IT OFF THE ROAD. PEOPLE DRIVE VERY FAST AND I FEEL LUCKY TO BE UNHURT. I HAVE A DEFECTIVE THROTTLE BODY AND I CAN NO LONGER DRIVE MY CAR TILL IT IS FIXED. THIS IS VERY DANGEROUS AND SHOULD BE RECALLED. THEY SAY THE CIRCUIT BOARD IS FAULTY AND IS SENDING THE ENGINE THE WRONG SIGNAL. SOMEONE IS GOING TO GET SERIOUSLY HURT OR KILLED . PLEASE ADD THIS TO YOUR LIST OF OTHER COMPLAINTS. I BOUGHT MY CAR ON JULY 11, 2009 THANK U *TR

I WAS DRIVING HOME DOING ABOUT 50 MPH, AND ALL OF A SUDDEN THE CAR LOST POWER AND I WAS UNABLE TO ACCELERATE. THE CAR STARTED SHAKING VIOLENTLY AND IT FINALLY STOPPED DOWN TO ABOUT 2-3 MPH. I TOOK IT TO THE FORD DEALERSHIP AND HAD TO PAY 824.00 TO REPLACE THE THROTTLE BODY. FORD NEVER MENTIONED ANYTHING ABOUT THIS BEING A PROBLEM. I HAVE SEEN NUMEROUS NEWS STORIES ABOUT THIS VERY PROBLEM. *TR

FOR THE LAST COUPLE OF WEEKS I HAVE BEEN HAVING AN ISSUE WITH MY 3 YEAR OLD FORD FUSION (2010) STARTED STALLING OUT AT RANDOM TIMES FOR NO APPARENT REASON. WHEN THIS HAPPENED THE FIRST TIME I CALLED MY LOCAL DEALER AND ASKED HIM WHAT MAY BE WRONG WITH MY VEHICLE AND HE SAID THAT THERE WAS A COMMON ISSUE WITH THE THROTTLE BODY, WHICH CAUSES THE CAR TO STALL OCCASIONALLY AND THAT IT WOULD COST ME AROUND $350 FOR THE PART ALONE. I BELIEVE THIS TO A MAJOR SAFETY PROBLEM BECAUSE ONE TIME THIS HAPPENED TO ME I WAS TRAVELING ON THE HIGHWAY AT 60MPH WITH A SEMI-TRUCK BEHIND ME AND THE TRUCKER CAME VERY CLOSE TO HITTING ME. I ALSO HAD THIS HAPPEN TO ME AT AN INTERSECTION WHILE TAKING OFF FROM A RED LIGHT, TURNING LEFT. I HAVE DONE SOME ONLINE RESEARCH ABOUT THIS ISSUE AND IT...

MY 18 YEAR OLD SON WAS GETTING READY TO GET ON THE FREEWAY AND THE VEHICLE SUDDENLY SLOWED TO 30 MPH. WE TOOK THE VEHICLE TO THE DEALER AND THEY REPLACED THE THROTTLE BODY AT OUR EXPENSE. THIS ISSUE IS SO COMMON THAT FORD IS HAVING A HARD TIME PRODUCING ENOUGH THROTTLE BODIES. THE PART IS ON NATIONAL BACK ORDER AND THIS PARTICULAR DEALER HAD A CAR IN THE SHOP THAT HAD WAITED 1 MONTH FOR THIS PART. THIS IS A SERIOUS SAFETY ISSUE. ONE MINUTE LATER AND MY SON WOULD HAVE BEEN DOING 65MPH ON THE FREEWAY. IMAGINE IF HE WAS IN TRAFFIC AND SUDDENLY COULD NOT TRAVEL FASTER THAN 30 MPH. IN ADDITION, SINCE THIS EVENT THE FORD SYNC AND BLUETOOTH FEATURES NO LONGER WORK. *TR