2016 FORD F-150 Unknown Or Other Problems

Ford has known about these 2 issues but refuses to do anything about it one of them they flat failed to mention at to anyone. The climate control seat module burns due to a ground wire. But they have to release the information they on 2014-2019 you can’ use aftermarket thermostat as they’re not calibrated right for the motor and also fit bit differently which causes people to spend so much to fix a cooling problem that doesn’t exist

Vehicle: 2016 Ford F-150, 5.0L V8, 6R80 automatic transmission Mileage at time of failure: Approximately 118,000 miles Approximate date of occurrence: Late 2025 (Late October to Early November) While driving at speeds above approximately 40 mph, the transmission would randomly and unexpectedly downshift, causing a severe and sudden jerking motion accompanied by extremely high engine RPMs. After several seconds, the transmission would violently upshift back into the original gear. Most occurrences involved the transmission downshifting one or two gears; however, on multiple occasions it downshifted from 6th gear directly to 2nd gear while traveling at highway speeds. This caused the rear wheels to momentarily lock up, creating a dangerous loss of traction and loss of vehicle control. These events occurred frequently, including during short trips, and were not related to driver input, braking, or road conditions. During these incidents, the check engine light and wrench warning light would illuminate. Diagnostic...

Our 2016 Ford F-150 experienced a sudden, forceful, uncommanded lane deviation while traveling at highway speed. Without warning or driver input, the vehicle abruptly jolted into the left lane. The steering was corrected and returned to our lane, but shortly afterward the truck again forcefully veered left. The movement felt comparable to being struck by another vehicle. There was no oncoming traffic at the time; however, had there been oncoming traffic, this would have resulted in a head-on collision. Weather conditions were calm, roads were dry, and visibility was clear. Prior to this incident, the vehicle exhibited no warning signs, including no pulling, steering issues, warning lights, or diagnostic codes. We immediately pulled over and had the vehicle towed to a mechanic who inspected the truck but could not replicate the issue. Although the vehicle was later driven approximately 120 miles home and short distances locally without recurrence, we believe...

When shifting into reverse, backup camera screen went to a constant blue screen — no rear image at all now.

No incident yet, but the frame is rotted.

Front Driver side and passenger side door latches that freeze and do not latch when shut.

My truck driver door won’t latch,in cold weather. Like it won’t catch when I try close it less I lock it then it catch but won’t close all the way tell it warm up. Seem like whn it’s down in teens a single digits or below and windy. I’ve had it happen two times so far. Thank you

Back up camera is flickering and goes to a blue screen glitches multi colors.

Back up camera failure the day after I bought the truck from a dealership. With the vehicle lifted in the rear and the blind spots it has mirrors only do so much before you have to open the door while backing up just to make sure it’s good enough or you aren’t sticking out while parked. It hasn’t been professionally inspected. No lights but it started as a black screen with green lines and eventually turned to a bright blue screen that is blinding at night when trying to back up.

The Hood is peeling the clear coat. The upper cab on both drivers side and passengers side from front to back is down to bare metal. Top of the pickup box is down to the bare metal along both sides. Tailgate top is down to bare metal. These spots are clearly do to the prep and paint work.

LaFontaine Ford Birch Run MI falsified recalls on my 2016 f150. They claimed they were done, however i have had several other Ford dealers state that there is missing parts and it was obvious it was not completed. This recall is for my door cables freezing up making it unsafe for me to commute when cold. I have held my door shut all the way to work multiple times because it would not latch. Other ford dealers near me quoted me 2 thousand to fix both front doors. I reached out to Lafontaine myself, they seemed to have wanted to help right away but as soon as they heard more of the story they quickly began to not answer my calls. (Service managers).

Severe rust on frame, both sides. Mechanic refused to do service until rust situation is remediated. Said vehicle is unsafe to drive!

My rear view camera shows either a static rainbow screen while vehicle is in reverse. Or it shows a frozen faint image of what's behind my vehicle from the last time it was in reverse.

The rearview backup camera on my 2016 Ford F-150 began malfunctioning around July/August 2025. At first, the image would flicker briefly when the truck was shifted into reverse, but it would return to normal after a few seconds or days. After about a week, the issue became constant — the display now stays completely blue whenever the vehicle is in reverse and no rear image is visible. This failure eliminates all rear visibility when backing up and creates a serious safety risk, especially in parking lots or residential areas where pedestrians, pets, or objects may be behind the vehicle. The problem matches the description of Ford’s current backup camera recalls (including 23S23 and 24S59), but my vehicle’s VIN does not appear to be included in those campaigns. The vehicle has not yet been inspected by a dealer or independent service center, but I plan to have it evaluated. The backup...

faulty backup camera - resulted in backing incident and tailgate damage. Reported backup camera malfunction to NHTSA in 2022 and emailed photo of camera defect, but multiple news articles about F150's being recently recalled for backup camera issued. These recalls do not include 2016 models to recall for updates and need to be added. Approximate cost of truck tailgate replacement $1500.

The voice recognition quit working on my Ford Sync. When I took it in for diagnosis, an update was attempted by the Ford dealer and wiped out my system, which means I have no back up camera, no radio, no USB ports, etc. I was told this is something I have to pay for to get repaired. The primary safety concern is, according to the dealer, the update cause the APIM module to fail, which means I no longer have a back up camera unless I pay for the repair.

At fifty six thousand miles, I had to replace the frame on the sunroof and the drain hose.We're not draining like they were supposed to.This is a real problem with these trucks.And everybody is having the same problem.This needs to be a recall.They need to rework the sunroof and replace it

My backup camera is not working, isn't that a safety feature? Every vehicle except mine is being recalled for the backup camera. I want it fixed as I have small grandchildren and I live in a park where there are small children riding their bikes. Thank you Sincerely [XXX] Just want to let you know I did contact Ford Motor Company and they basically told me I could pay to get it fixed because there is no recall on it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The back-up camera seems to only work in cold weather. This has been an on-going problem since 2019. This creates a safety issue when backing up as you cannot see directly behind the truck. The back-up camera seems to be a problem in other Ford models.

While trying to backup my rear view screen camera is black and flashing on and off so fast that I can’t gauge how close or far I am away from an object. Everything works ( radio, GPS, source and other things) with in the screen it self. But the problem is threatening to my safety. I ve tried to reset it by the recommendation of Ford but to no avail.

The rear backup camera has malfunctioned and it is not working.

When you put vehicle in reverse the back up camera has a blank screen

Dear Sir/Madam, I own a 2016 Ford F-150. Over the past few months the vehicle will suddenly hesitate and downshift while driving and the mechanics symbol will appear on the dashboard. This happened to me a few times. At the end of June I had two different mechanics look at the vehicle and both kept the truck for a couple of days and drove it around and neither one could see a problem. I drove the vehicle from Rhode Island to Pennsylvania and this happened 4 times during the trip driving on the highway!!!! It then happened again (with a witness in the vehicle) while driving. I could have been killed driving 70 mph on the highway during these times that the vehicle hesitated and downshifted. I researched possible recalls that I might have missed and learned of the investigation into by NHTSA by other consumers and I contacted Ford....

2016 F150, 6R80 Transmission - threw codes P0720 and P0722, dealer indicated known issue under recall 24S37, but my VIN is not included, but should be. Unexpected downshift to first gear, check engine light, truck enters "limp" mode, only allowing 3rd and 5th gear - real safety issue - especially if Ford knows it has a fix - although parts are in short supply (molded lead frame)

I was going to pass someone and as I was speeding up the check engine light came on. I pulled over and there was nothing wrong with the truck. Months later there was a warning that came up on the dash it said something about shifting and i was to park the truck. I took it to a transmission shop, come to find out that the shifting sensor had went out. They cleared the check engine light and it came back on. Ran a diagnostic on it and it said there was like 8 different things that needs to be fixed. There was Catalyst System Efficiency Below Threshold, Air Distribution Damper Position Sensor- Circuit Short to Ground or Open, Bank 1 Air/Fuel Ration Imbalance, Sensor Circuit, Internal Control Module Torque Performance, Heater Control Circuit (Bank 1, Sensor 1). When I am at a certain speed the truck will vibrate (feels...

The transmission had to be replaced. I knew something was wrong because the truck was lunging. I took it to the garage and the mechanic said not to worry because everything looked great. I was pulling down a tree and the transmission stopped working. I had to get the transmission replaced.

I went for an oil change, tire rotation, etc at the dealer on 6/9/25 and was told that my frame had rust damage/holes and would not pass inspection this coming December. Went to Ziebart on 6/11/25 and they confirmed multiple hole/rust damage on frame which needed repair. They were perplexed as no problem was seen at my last yearly check of the rust protection in July of 2024. Also, no mention of a potential problem was found at my last vehicle inspection in December of 2024. How does this kind of damage occur in 6 months? I'm reading on-line that this is an issue with Ford F-150s, but no recall?

After passing a car on a two lane highway 120 miles from home a wrench light came on and the transmission got stuck in 5th gear. We pulled over, stopped the truck and then it got stuck in 3rd gear and then the check engine light came on. The truck then proceeded to on into limp mode. At that point with the transmission clunking we and the truck shutting down we didn't feel safe driving the vehicle to our weekend destination nor did we feel safe driving it home as we had no idea if the transmission would completely fail. These were two lanes roads with not much shoulder and steep cliffs along the road in many areas and it was very unpopulated so any number of things could have happened to put us at risk. We had the truck towed 120 mileshome and taken to the nearest Ford Dealership,...

2016 Ford F-150 XLT panoramic sunroof rails damaged not adhered to truck properly and water leaking into Vehicle. excessive water damage from faulty Sunroof. Danger of separation from roof and breaking and flying off.

Engine failure at 90,000 miles Services all done at ford dealership yet the engine still didn’t work somehow. Wheel bearing at 100,000 failing causing rattling of wheels

2016 Ford F-150 pickup has no backup camera or front camera. Resets have done nothing. Defective module, camera wiring or camera itself has to be defective. I heard the 2015 model Ford pickups have a recall associated with this problem.

Backup camera only works intermittently. Half the time it only shows a "white square with a truck icon" instead of the actual view.

When traveling at around 70-75 mph the vehicle will downshift to 5th gear and vehicle speed drops as well, without warning. This causes the vehicle to not want to excel until it comes to a complete stop or turns off and then turns back on.

My moon roof is stuck closed. It will not open and makes a cracking noise if I press the button to try and open it.

Passenger door will not latch and close on 2016 Ford F-150 after snow storm. While the vehicle was parked, the front passenger's side door latch failed to latch as intended. We discovered the issue when we were trying to leave our house during the extremely cold freezing weather. The door had to be manually held closed when traveling a short distance. We were able to get it latched to drive on the interstate to church, but then it failed to latch after coming out of church service, when we had to hold it closed manually for a short distance. We then had to use rope to keep the door shut by securing it to another door on the opposite side while traveling back on the interstate to get home. The truck has not been diagnosed or repaired by an independent mechanic or the dealer. The failure mileage was approximately 106,000.

I have a recall that claims to be completed on my truck, but two dealerships claim that it is not done with photo evidence. I would like this recall addressed properly as i am not trying to pay two thousand dollars out of pocket for just the driver and passenger doors. This recall is on my 2016 F150 . This is a door latch problem on all 4 doors. I noticed this when winter came around and my driver door latch/cable would freeze. I drove to work multiple times holding my door shut. I have been trying to get this resolved for the past 3 months and i keep getting a different answer from everyone i have reached out to including poor customer service. This is unacceptable and i certainly wont be purchasing a ford ever again.

Passenger side door lock actuator goes in and out. Sometimes the door will open sometimes it won’t. One time the door opened by it self while driving. I don’t know if it’s a short or what’s going on with it but it seems to be a problem with other ford owners as well.

Due to the freezing (around 20 degrees F) temperatures, the latch of the front-driver’s side door was frozen and was unable to close. The door would initially open, but any attempt to close it afterwards became unsuccessful.

I NEED TO REPORT FAILURE FIXING MY CAR RECALL NAMED *Faulty door Latch HARVARD FORD TEXTED ME TO RAKE MY CAR TO GET DONE BUT THEY DID A BAD JOB REPAIR INSTEAD OF REPLACE RECALL PART THEY DIDNT THEY DID CUT OUT WIRE HARNESS INSTEAD .Therefore THAT DAMAGED TYE AUTO NOW REVERSE CAM SCREEN IS NOT WORKING .TYE DOORS OPEN ITSELF WHILE IM DRIVING IT .DASH Board IS NOT ALSO WORKING IM FILLING A COMPLAINT AGAINST HARVARD FORD DEALERSHIP THE SOLUTION zI need is the following they need to REPLACE ALL COMPLETE NEW WIRE HARNESS ASAP.ALDI NEW REVERSE CAM AND SCREEN .IM ATTACHED ALL PROOF OF THE DAMAGE ..

Sunroof rails broke for the second time, and the sunroof will not close on the drivers side. This problem is putting extra pressure on the glass since it isn’t seated properly. Water also leaks in during rain storms and has caused electrical issues. I can now only drive this $95,000 vehicle in good weather.

Substantial amount of water coming in through rear windshield/rear sliding glass windshield door, causing mold.

I have a 2016 Ford F-150 with the 3.5 Ecoboost engine with 92,019 miles. This morning (9/11/2024) as I headed to work, I pulled out to cross highway 54 and the truck suddenly lost power. It would only idle. As I tried pushing harder on the gas pedal, it would not come out of an idle and I barely made it to the center divide with multiple vehicles headed right at my drivers side going 65 - 70 mph. The check engine came on and stayed on. The truck was shaking and vibrating tremendously. I could not leave the truck there as it was blocking traffic in both directions. I was able to back up and cross back over the highway and pulled to the shoulder. I turned the truck off and started to make a call for AAA when I received a notification from my Bouncie. It threw a...

Driver side door some times will not close and have to lock and unlock the door to get it to close, and transmission is making hard gear changes.....

This has happened on four separate occasions. When driving, we suddenly get a warning about hill assist, immediately followed by a warning about stability control, immediately followed by the check engine wrench light. At the exact same time, vehicle shakes very hard and loses acceleration, almost like the connection between the pedal and the engine was cut. Today, we were going about 70mph on the freeway when it happened, and all we could do was put the hazards on and let it roll in neutral. Luckily, we found a bit of shoulder to pull off on. Everyone was in danger because we lost the engine at speed. I'm scared to imagine what would have happened going up an incline. On each of these occasions, turning everything off, waiting, and then turning it back on was what it took for it to be drivable again. We have taken it to the...

During the scheduled oil change service on 8/15/2024, I was informed that wheel lug nuts were swollen and tire rotation and inspection were not completed, even though I paid for a maintenance package. I replaced the lug nut two years ago for the same issue, and this will be my 3rd time replacing lug nuts on the vehicle.

Exhaust manifold broken studs(bolds) causing exhaust fumes in cab. Carbon monoxide and also loss of performance. This is an ongoing issue with the 3.5 L equal boost motors. Pre 2017. The 2017 motor and further have been redesigned. Why aren’t they doing a recall on pre 2017?

Nothing wrong

Got into vehicle and before starting window just shattered. No issues prior with the rear window just random and for no apparent reason it shattered from inside out.

take your truck to a ford dealer to see if they car refresh or reprogram the tcm for the transmission shudder witch is being caused by the torque converter if they can’t refresh or reprogram your truck will need a new torque converter.

2016 Ford F150 Platinum 5.0L V8 with automatic 6R80 transmission. Erratic gear shifting while driving. Sometimes not getting out of/stuck in 3rd gear and sometimes not downshifting below 3rd gear. Orange wrench or illuminated MIL light came on followed by a solid check engine light. Took it to dealership - DTC P0720 and P0722 appeared. Dealership tech states that he reprogrammed the PCM and output shaft speed sensor, and that the next step is to drive it and see how it does and if it didn’t fix the problem then he will have to change the molded leadframe. This issue is exactly the same issue as the customer satisfaction program 19N01. The safety concern is I don’t want to drive it around, waiting for the leadframe to fail one day while I’m driving down the freeway with my family in 6th gear and have the truck shift abruptly to 3rd...