2021 FORD BRONCO SPORT Engine Problems

This vehicle is subject to NHTSA Recall 25V467 involving potential fuel injector cracking and risk of fuel leaking onto the engine, creating a fire hazard. The recall status shows “Remedy Not Yet Available,” leaving the defect unresolved. While driving, the vehicle suddenly displayed an engine overheating warning and immediately entered limp mode, causing abrupt loss of power. The vehicle decelerated unexpectedly and was not able to maintain normal driving speed. This created a dangerous situation in active traffic and required a safety tow. The sudden power reduction could have resulted in a rear-end collision or loss of vehicle control. There were no prior overheating warnings immediately before this incident. The failure occurred abruptly. A warning message appeared at the time of the event, followed by limp mode activation. The vehicle had to be towed to a dealership for inspection. Given that the open recall involves fuel injector cracking and potential...

Since my car hit 40000 miles it has had nothing but issues. I've had it in the shop at least 10 times. My brakes went out while driving with my [XXX] old, I've had loss of power, smell of exhaust in the cabin for the last 3 months and dealership says it can't be fixed, yesterday I had complete engine failure while on the freeway. Stalled and wouldn't start back up for 5 min. The dealership has never fully fixed anything but has only updated the computer system. I feel very unsafe in this vehicle. We still owe on this vehicle so trading it in is not an option since its not even worth the down payment I put down. It has a fuel injector recall that can't be fixed yet due to not having the parts available. What are we suppose to do if we can't drive the vehicle...

Car check engine light came on, I came home parked the car, in about 5 minutes the cars embarked in flames, the car burned down to the ground. The safety of my entire home (flames caught onto house) and neighbors home was at risk. The burning car was inspected by Fire Chief of Christiana Fire Company

The contact owns a 2021 Ford Bronco Sport. The contact received notification of NHTSA Campaign Number: 25V467000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and there was an abnormal sound coming from the vehicle while driving. The contact was unable to determine the location of the sound. The vehicle was taken to the local Auto Zone, where an undisclosed system failure had occurred. No further information was available. The failure mileage was 77,000.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving approximately 45 MPH, there was a loud scraping sound coming from the engine compartment, and the vehicle jerked abnormally. The vehicle was taken to an independent mechanic, and the failure was associated with the torque converter. The manufacturer was notified of the failure. The failure mileage was 91,000.

My Check Engine Light came on today. I went to Advance Auto Parts and had them check the code (P0171). I took my vehicle to University Ford in Huntington and expressed concern that my fuel injector may cause a fire and I am not comfortable driving the car. They could not diagnose my car or loan me a safe vehicle. They sent me away in an unsafe vehicle. I am to bring the car back in the morning at 8am. I believe this problem is due to the open recall. I also believe all of the damaged parts that my car came with have depreciated the value of my car. I’ve driven Fords exclusively for 20 years. I’ve never had a Ford like this Bronco. Nothing but a nightmare. Tomorrow I hope the dealership fixes my problem or loans me a safe vehicle to pick my grandsons up from school...

The contact's son owns a 2021 Ford Bronco Sport. While the contact's son was driving at an undisclosed speed, the driver heard an abnormal grinding sound coming from the rear differential. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed with a failed vent tube and water intrusion. The contact was informed that the water intrusion damaged the clutch and gears. The contact was informed that the rear differential and vent tube needed to be replaced. The vehicle was being repaired. The manufacturer was made aware of the failure, and a case was filed. The contact was provided a discount on the cost of the part. In addition, the contact was informed that the failure was a known failure with the model vehicle; however, a recall had not been initiated. The failure mileage was approximately 81,421.

While driving my 2021 Ford Bronco Sport, I experienced a strong chemical/fume smell entering the cabin, which caused headache and nausea. I later found that the battery installed in the vehicle had vent holes with visible liquid residue indicating leakage. I did not authorize or install this battery — it appears the battery was changed without my knowledge while the vehicle was in a lender’s possession. This created a serious safety concern because the fumes entered the HVAC system and the vehicle became unsafe to operate. I had the vehicle towed to two separate Ford dealerships. Both refused to inspect the HVAC system or provide a proper safety diagnosis. One dealer admitted the battery had “traces of leaking fluid,” but no diagnostic inspection was performed, and they attempted to close the repair order without documenting the safety concern. I was forced to replace the battery out of pocket just to...

We purchased this vehicle 02/2025. The salesman stated there was a 5 point inspection and the car was good on fluids oil and brakes. We questioned the rough idle and odd sound the car made and we were told that it was normal. 07/2025 a mobile mechanic came out and repaired a recall. He stated in his notes that the car had an oil leak but he could not determine where. Fast forward to now, my car has been needing oil more than usual since we have got the car. There is a leak but it does not leak on the ground. 11/11/2025, I contacted Big Valley Ford in Stockton CA with concerns about the oil depleting rapidly and how my check engine light comes on which tells me my car has absolutely no oil. I mentioned a recall I saw online 22S21 and Greg (the man I spoke with)...

In 2024, we had our battery replaced in our 2021 Bronco Sport by the Ford certified dealer in response to Recall Number 24S24. We did not have any issues with the previous battery. They replaced the original battery with the AGM battery, which they represented would prevent the issues that necessitated the recall - catastrophic degradation of the battery and complete loss of drive power. In mid-October 2025, my wife experienced unexpected and complete loss of drive power when exiting the interstate in the car, and was stuck in the freeway exit lane as oncoming traffic was exiting at high speeds with minimal time to avoid the stalled car. It was a dangerous situation and the car was almost struck numerous times. No warnings or messages appeared - even the hazards did not work. After about 20 minutes, we were finally able to obtain assistance from a police officer and...

I took my vehicle into my local ford dealership to get three active recalls remedied. Within 24 hours, my check engine light reappeared as well as "service engine soon" on my way into work. Upon leaving work, the dash lights were gone. They would come and go periodically. After about a week, it would pop up "service engine soon" and within ten minutes, regardless of speed, the RPMs would fly all the way up and the vehicle would act as if I took my foot off of the gas, almost immediately stopping on the highway. I would have to almost immediately pull off of the road and my vehicle would stall, flashing "shift system failure" as well as failing to let me put the vehicle into park or any other gear. Taking it into the shop, they told me that was due to a software bug WHICH THEY JUST "FIXED"...

On 7/22/2025 Luther Ford, When asked to drive the vehicle into the service area, the car would not go in to drive. It would not move at all. The service advisor stated we need to have the transmission taken out and taken apart to see what the issue is. He said that the transmission was needing to be replaced, and with the transmission, it is mostly because of an issue with the motor as well, but this cannot be diagnosed until the transmission issue is corrected. The vehicle is still at Luther Ford in Fargo waiting on repair. Ford offered limited financial assistance for this. With myself still owing $5758.38. There have been multiple times that I have requested the dealership drive the vehicle because of the vehicle shifting hard or cutting out when stepping on the gas. On 3/3/2023 20,991 miles I had taken the vehicle in to RM...

Keeps cutting off and my screen aswell.

My 2021 Ford Bronco Sport Big Bend 1.5L EcoBoost (VIN: [XXX] ) suffered a turbocharger failure due to oil leakage, which caused overheating and smoke from the engine bay. The vehicle became unsafe to drive due to loss of power and risk of fire from leaking oil near hot engine components. I’ve found numerous reports online of similar failures in other 2021–2022 Bronco Sport 1.5L models, suggesting a possible design or component defect. This issue poses a serious safety concern, as the engine can overheat or lose power suddenly while driving, increasing the risk of crash or fire. Please investigate this matter to determine if a recall or safety campaign should be initiated to address recurring turbocharger and oil leak failures in these vehicles. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owned a 2021 Ford Bronco. The contact stated that while driving at an undisclosed speed, the contact noticed smoke coming from the front of the vehicle. After pulling to the side of the road, the contact noticed that the engine compartment had caught fire. The fire was extinguished by the Fire Department. A fire report was filed, but a fire report number was not provided. The cause of the fire had not yet been determined. A police report was not filed. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System, Gasoline). The dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was destroyed. The manufacturer was made aware of the failure, and a case was opened. The approximate failure mileage was 83,000.

The contact owns a 2021 Ford Bronco Sport. The contact stated that on several occasions while attempting to start the vehicle, the vehicle failed to start-up with several unknown warning lights illuminated and flickering. The contact received notification of NHTSA Campaign Number: 25V467000 (Fuel System); however, the part to do the recall repair was not yet available. The vehicle was towed to the dealer, where it was diagnosed and determined that the fuel injector and catalytic converter had failed and needed to be replaced. The dealer confirmed that parts for the recall repair were not yet available. The vehicle was not repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 90,200.

I own a 2021 Ford Bronco Sport that has had repeated premature failures of critical components. At ~52,000 miles the water pump failed and was replaced along with coolant and belts. Less than 21,000 miles later (at ~73,000 miles) the water pump has failed again, with coolant leakage and a burning coolant smell. Ford has issued TSB 23-2104 acknowledging coolant leaks at the water pump/hose connection, yet no recall or extended coverage has been offered. This is not the only issue. My alternator has also failed twice and required multiple replacements in under 4 years of ownership. Having two major components (water pump and alternator) fail repeatedly within such a short period clearly shows a systemic defect, not normal wear and tear. Safety risks: coolant leaks can drip or vaporize onto hot engine components, creating a fire hazard. Alternator failure risks sudden loss of power and stalling in traffic. Both...

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the transmission failed to shift into the intended gear. The vehicle only operated in low gear. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed and determined the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 100,200.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at 30 MPH, the vehicle lost automotive power, with several unknown warning lights were illuminated. The contact pulled over and restarted the vehicle, and the vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that a software update was required; however, soon after the software update, the vehicle stalled while leaving the dealer. The contact was informed that the failure was attributed to the software update. The contact stated that 48 hours after the software update was performed, while driving 70 MPH, the vehicle lost automotive power. There was no warning light illuminated. The contact pulled over, and the vehicle restarted after several attempts, with several unknown warning lights illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed; however, the contact was advised that...

Car was put into drive and wouldn’t go. It would finally go but Everytime the engine changed gears it dropped to 0 rpm’s making it very dangerous to drive!!! Lots of lights came on and my app sent me two things wrong with it. After having it checked the codes said it was a valve body issue. Replacing the transmission is $4000, and I’m not the first with this problem a friend of mine had the same issue a couple weekend before me.Had two mechanics one of which was from the dealership tell me this was happening a lot! It’s very dangerous especially when you have kids in the car like I did and are having to stop at red lights and such. There were no issues or lights to show warning of this happening either.

Transmission shudders at low speeds (around 25-40 mph) when accelerating. This happens when shifting around 2nd gear something’s between 2nd and 3rd. Many online forums report the same issue in similar model vehicles and year when vehicle is just outside of warranty period issue occurred out of nowhere and happens consistently.

The contact owns a 2021 Ford Bronco Sport. The contact stated while her husband was driving 15 MPH and depressing the accelerator pedal, there was an abnormal popping sound coming from the engine. The driver was able to pull into a parking lot and noticed white smoke coming from the engine while awaiting tow truck assistance. A local dealer was contacted. The vehicle was taken to the dealer to be diagnosed. The vehicle was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified on the failure and was waiting to make a decision on what assistance to provide. The approximate failure mileage was 90,000.

My car is only 4 years old and is now in need of a brand new transmission. The power train lights are on, the emissions lights stay on, it shuts off after getting gas and won’t restart. I’ve been to the Ford dealer to fix “recalls” and was told there was no fix for it yet and that the noises I was hearing and the problems I was having was all fine and that there should be no long term issues with my car. Now, a few months later my car is back at the dealership in need of a whole new transmission. I am so sick of the issues and constant battles with this car and being told it’s fine and to wait for a call for the update to be ready. I am now out of a vehicle and I haven’t even owned it a year yet.

Since I have bought this used vehicle in September 2024, it has been shutting off completely with having to restart the engine. There was a recall for the battery in January 2025 that was finally approved to be replaced maybe in May or so. Battery was replaced but it keeps shutting off. I just took it in July 7 for the fuel pump to be replaced as they said that was the final cause. I drove it home the same day when it was finished and it has been shutting off still. It has shut off while I have been at the light, in reverse and as well as putting my vehicle into reverse by itself which could cause an accident. This situation has since be unresolved. I have taken it to the ford dealership with them many times with them saying there is nothing wrong with it.

Vehicle: 2021 Ford Bronco VIN: [XXX] Mileage: Approximately 88,000 miles Complaint: I am reporting major safety and drivability concerns with my 2021 Ford Bronco, which is currently undrivable and in the shop at Ron DuPrat Ford in Dixon, California. Despite experiencing issues nearly identical to those covered under existing recalls, my vehicle’s VIN is not currently included. While driving on the freeway, the vehicle suddenly malfunctioned. Without warning, it dropped into first gear at high speed, causing a rapid and unexpected deceleration. This could have easily resulted in a serious accident or even death — not only for my family but for others on the road. This is a major safety issue. After pulling off the road, the vehicle would no longer go into reverse and became completely undrivable. I also received multiple dashboard alerts, including: “An electrical fault has occurred with the transmission fluid pressure sensor circuit and its...

The contact owns a 2021 Ford Bronco Sport. The contact stated that while operating the vehicle, the instrument panel malfunctioned, with the message "Pull Over and Restart the Engine" displayed. The battery was replaced, and failure was resolved. Additionally, the contact stated while driving at an undisclosed speed, the vehicle suddenly lost motive power and stalled. The vehicle was towed to the local dealer who diagnosed that the engine was faulty and needed to be replaced. The engine was replaced, and the vehicle was repaired. The contact stated that later while driving at various speeds, the vehicle started jerking while changing gear. The vehicle was towed to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. The transmission was replaced, and the vehicle was repaired. The contact stated that the vehicle later experienced a failure while attempting to accelerate, with the check engine warning...

I have attached a letter that I mailed to Ford Consumer Affairs detailing the issues with this vehicle and asking them to repair the transmission. I received a response letter from them yesterday denying my claim. I am seeking advice on how I can proceed with Ford, if at all, to try to get them to fix this issue that was clearly caused by multiple recalls. I am not the only consumer reporting the exact same problem with this vehicle. Thank You, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I took my 21 Bronco Sport Big Bend in to have a different recall fixed and also have an oil change performed. I told the service technician that my coolant level was always low but I could not find any leaks under the vehicle. The service department called me and told me that there was coolant leaking into the cylinders of my engine and I needed the long block replaced. There was no indicator light for the low coolant or any type of engine light that would alert me of an issue. I eventually got a call that they had received parts for my engine replacement. The service technician told me that they are seeing a lot of Bronco Sports have this issue, but I never received a recall notice nor can I find an open recall online for this issue. I believe my family and I were put at...

Husbands Ford Bronco sport has had a constant smell of exhaust that fills the interior of the vehicle since purchased. Dealer said there was a “recall and fixed the problem”. It only lasted 2 days until it began again. My husband gets lightheaded and dizzy while driving and has to stop and roll his windows down. He almost passed out while driving home with our children. Dealership says “this is a common problem and Ford doesn’t have enough parts at the moment to fix it and it will be around 2-3 months until they do.” Also, the car has suddenly stopped while driving or won’t start back up. It has to sit for a day or so and then it will start. Tried replacing the battery and it didn’t work. We’ve had to leave it sitting in random parking lots several times.

The water pump has been replaced twice already and the water pump needs to be replaced again at 105,000 miles. This will be the fourth water pump this vehicle has. The originally came with, two replacements, and now the one that it needs because it is leaking like the previous three. The turbo charger failed and was burning oil. That was replaced. A month later it is back at the dealership being replaced again

My car has left me in the middle of the road twice in 2 weeks . I am scared and nervous can’t understand what’s going on , I am with my kids and no one to help . Every light comes on and off and it won’t start , the first time my ex husband jumped it with his jumping cables and it came right back to life , but this second time , we jumped it for about 5 times and nothing . Towing truck came in the night the day after it happened and he jumped it and it started, drove my car really carefully back home and now I’m scared to use my car because I’m afraid it’ll leave me in the middle of the highway or what’s worse it can cause an accident and my kids inside . I couldn’t even imagine how devastating that would...

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power inadvertently. The contact was able to pull over to the shoulder of the roadway. The vehicle was able to restart and operated as needed. The contact stated that the failure had been recurring while driving. No warning light was illuminated. The vehicle was taken to the dealer, where the failure could not be duplicated. The vehicle was not diagnosed or repaired. The contact related the failure to NHTSA Campaign Number: 25V019000 (Electrical System); which included the VIN; however, the part to do the recall repair was not yet available. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 49,000.

I was unaware of any previous recalls before I purchased my Bronco Sport used. There is an active recall that has no remedy for the battery. I am actively having issues with my fuel system. It was inspected more than once. Diagnostics returned zero issues 3 times and no warning lights. I insisted further inspection this time which revealed bad purge valve, charcoal canister full of fuel, coolant leak resulting in water pump replacement needed. No warning lights. No codes, active or stored. Due to the absence of codes, they will not replace my fuel injectors per customer satisfaction program 22N18. Was not ever informed that recalls 22S73, 22S21, and 21C31 were either inspected or completed on my vehicle as it was not ever disclosed to me and the Ford website only state "scheduled maintenance" was performed. I still cannot obtain documentation of those previous service records so that I...

MY VEHICLE IS 4 YEARS OLD AND HAVE HAD 6 RECALLS ! THIS IS NOT A SAFE VEHICLE AND I WANT MY MONEY BACK.

Driver was driving on the interstate. The car flashed several electrical system failure issues and notified that the alternator no longer functioned and that the system would then pull from the battery. The battery light came on and then flashed several warnings along with sounds. Driver was luckily able to exit the interstate and make it to a parking lot off before vehicle lost all power. Once parked and turned off, the accessories like radio and dashboard screen and lights were still functioning. The car would not start until we jumped it. Afterwards the car would not switch gears and then again flashed the electric system was experiencing failure. This and along with some whirring sounds from under the hood (what I could hear from driver seat), gave me enough reason to stop trying altogether to avoid further issues. After turning the car off, the dashboard flashed errors saying that...

Immediately after the driver started the car, many notifications popped up on the dashboard including: cross traffic system fault, service vehicle soon, full accessory power active, hill start assist not available, service AdvanceTrac, Engine Coolant Over Temperature, and Cross Traffic System Fault. The gauge showed fuel empty and other dashboard indicators were illuminated such as engine, battery, oil, seatbelt, airbag, faulty blindspot monitoring, and traction control. Driver took pictures of these notifications and indicators for documentation. Driver turned off the car and discovered recall # 25S02 for the vehicle. Owner recognized the notification explosion from similar experience on May 5, 2024 in reference to recall # 24V267000. In May 2024, the notification system showed all of the above alerts before the vehicle shut off and lost power. At this time, the vehicle was traveling at 60 mph on the interstate. Driver was fortunately able to exit and get to a...

I bought a 2021 Bronco Sport Brand new and ever since the car has been a problem. The rear axle wasn’t getting enough lubricants so it was grinding and I didn’t know what it was at the time but I took it to a Ford dealership and was told after spending 200$ on diagnostic testing that absolutely nothing was wrong with the vehicle. The vehicle kept doing the same thing grinding noises so I took it in again and got the same results now mind you this is way before my power train was up. The car felt so unstable and unsafe it got to the point where I had to just leave it at the dealership until Ford could help me with some financial assistance. While at the dealership Ford told the mechanic to check the transmission and upon checking the transmission the mechanic found a problem. The total...

The evaporative emissions system failure involving the purge valve and vapor canister purge valve is a recurrent issue on this car and has been reported by hundreds if not thousand of bronco sport owners. All recall for 1.5L and I am sure the badlands have the same parks and is not included in the recall. less than 60,00o mile with a check engine light on. The safety issue that arises from this is that we are emitting more fuel vapors into the atmosphere. Please add recall to cover Badland if they contain same parks as 1.5L!!!! Also the windshield wiper pump did not work. I can not clean the windshield wen needing to see out of it. i have to pull over and clean at local gas station.

This has been an ongoing issue since I purchased the vehicle in July 2024. It has become so bad that the vehicle is nearly un-driveable. FORD states it is a non-issue, non safety related and there is no know fix at this time. FORD has been buying vehicles back due to this "secret recall" but after numerous calls and visits to both dealers and the Ford customer care line, nothing is being done. And while FORD might state it is an "inconvenience", when driving on the highway and a cylinder just randomly shuts down, the vehicle loses power and backfires and vibrates it is a safety concern. I have been EXTREMELY patience and professional in all my dealings with FORD on this matter, yet they refuse to offer me any help or come to a resolution in my case.

The car has now on three separate occasions lost power while driving. As I slow down coming to stop or reducing speed car will completely lose power and then struggle to restart. Both occasions were on busy roads. Additionally, when you put fuel in the car it does not turn on right away it smells like fuel is burning and fumes enter into the cabin. When you push start after fueling it struggles to turn car on to drive. There is full accessory power but no power to drive the car even when giving it gas. It requires multiple attempts at starting the vehicle and it will tremble and shake once it starts running and stutters as if about to shut off even when you start driving it. Today it powered down again while driving and we avoided and accident but it is becoming dangerous to drive the vehicle due...

The vehicle has been in the shop since day one with many many problems! The TURBO failed under warranty so they replaced it without doing proper procedures. A few months later the turbo failed again out of warranty but this time cracked the head causing damages I can not afford!! The vehicle is sitting at the dealership not fixed!! I want out of this lemon!!! I tried getting them to buy it back when I took it to the shop three different times due to break issues they could not fix but a Ford representative told me it "had too many miles" I work out of this vehicle and have not been able to work now for three months!! Note...after the first TURBO was replaced I told the dealership the vehicle was loosing antifreeze but all they did was pressure check the radiator. A few months later engine failure due...

My daughter was operating the vehicle when it unexpectedly lost power and came to a stop without warning. The instrument panel began flashing, and she was unable to restart the vehicle to move it out of traffic. A jump-start was required to get the vehicle operational. It has been taken to Koons Ford Annapolis for evaluation. Vehicle mileage is aprox. 27,000

The car caught fire the morning of Dec 11, 2024 while the vehicle's owner was driving their children to school. There are photos and a fire report is being generated. The vehicle's owner and her children could have been killed. Early indications are that the fire was caused by the same faulty engine/exhaust system defect that the owner has been complaining to Ford about for years. It is assumed the fire report will confirm that. For the past two or more years the vehicle has been emitting exhaust fumes into the passenger compartment of the vehicle while driving. This has caused the vehicle's owner and her children to get sick and forced them to drive the vehicle with the windows down at all times even in cold weather. Ford's dealers have confirmed the problem several times, but either could not or refused to fix it. A summary of the vehicle's...

The contact owns a 2021 Ford Bronco Sport. The contact stated while driving at an undisclosed speed, the vehicle started losing motive power. A message advising a power train failure was displayed. The driver was able to exit the highway at 15 MPH. The vehicle was driven to a nearby dealer, where the computer was rebooted; however, the failure recurred several times while driving. The vehicle was taken back to the dealer several times, and the transmission was rebuilt. The contact stated that the failure had been recurring while driving. The contact stated while her husband was driving 70-80 MPH, the vehicle lost electrical power and stalled. The check engine and the power train warning lights were illuminated. The driver was able to pull to the side of the road. The vehicle was able to restart but failed to exceed 15 MPH. The driver continued driving on the shoulder of...

Torque converter failure at 100,000 miles. Car hesitates when it accelerates creating delay when going from stop to start.

[XXX]. about 3 months ago my wife started to smell what she referred to as raw gas odor in the cabin of car. took it to dealership, nothing found. then again complaint of odor in cabin. nothing found. then again smell in cabin. nothing found. I drove the car 40, mils. on errons. had a after oil smell like a oil breather was disconnected. dealership nothing found. wife it smells bad in cabin of car. my truck went in for service, I took the bronco to work, had to have the windows rolled down. on the way home it was real bad. called Ford Moter company. was told to take to another dealer. called our dealer asked for the owner. not around asked for number 2 he was told him we were done. he said he would find the problem. he did the catalytic converter had a crack somewhere. I...

My 2021 Bronco Sport suddenly died on [XXX]. The parking brake engaged unexpectedly, locking all four brakes and resulting in a significant skid mark. An error message flashed: “Park Not Available. Apply Park Brake Before Exiting,” and the park gear light blinked. I turned off the engine again, but the car was dead when I tried to restart it. After getting a jump start, the car turned on. However, the parking brake engaged again shortly after. I was able to drive it off the road. My wife, a research librarian, found that many others have reported issues related to “Sudden Death Syndrome." See below. [XXX] [XXX] ). The car was towed from PA, where we were visiting, to Stanford Ford, where we purchased it on [XXX]. On 11/13, the dealership told us there was a short circuit in the wiring connected to the solenoid and estimated $900.00 for labor. At...

The evaporative emissions system failure involving the purge valve and vapor canister purge valve is a recurrent issue on this car and has been reported by hundreds if not thousand of bronco sport owners. The safety issue that arises from this is that we are emitting more fuel vapors into the atmosphere, not only does this not help with emissions control into the atmosphere, but it decreases fuel efficiency and increases gasoline smell into the vehicles cabin.

The contact owns a 2021 Ford Bronco Sport. The contact stated that while driving 55 MPH, the engine started overheating. The vehicle was towed to a dealer where it was diagnosed that the water pump and the catalytic converter needed to be replaced. The vehicle was repaired; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was 100,000.

Currently at 30,000 miles. Water pump goes out every 10k miles, rear differential went out, front control arm and strut went out.