NHTSA Complaint #11717430 — 2021 FORD BRONCO SPORT

This vehicle is subject to NHTSA Recall 25V467 involving potential fuel injector cracking and risk of fuel leaking onto the engine, creating a fire hazard. The recall status shows “Remedy Not Yet Available,” leaving the defect unresolved. While driving, the vehicle suddenly displayed an engine overheating warning and immediately entered limp mode, causing abrupt loss of power. The vehicle decelerated unexpectedly and was not able to maintain normal driving speed. This created a dangerous situation in active traffic and required a safety tow. The sudden power reduction could have resulted in a rear-end collision or loss of vehicle control. There were no prior overheating warnings immediately before this incident. The failure occurred abruptly. A warning message appeared at the time of the event, followed by limp mode activation. The vehicle had to be towed to a dealership for inspection. Given that the open recall involves fuel injector cracking and potential fuel accumulation near hot engine components, there is concern that the unresolved recall condition may be related to engine overheating and loss of power. The vehicle remains under an active fire-risk recall, yet no repair remedy is available. Owners are left operating vehicles with a known safety defect and no corrective action timeline. The defect has not been remedied because parts are not available. The vehicle was inspected by a dealership after the overheating event. The primary safety concern is the combination of an open fire-risk recall and a sudden overheating/limp mode event causing abrupt power loss in traffic, creating a serious risk of injury. Due to this open recall with no available remedy, the vehicle cannot be listed or rented on a peer-to-peer vehicle sharing platform, resulting in loss of legitimate income. The vehicle was previously eligible for use, but is now restricted solely because the safety recall remains unresolved without a repair solution. Owners are financially impacted.