2005 DODGE GRAND CARAVAN Electrical System Problems

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE POWER DOOR LOCKS FAILED TO OPERATE AS NEEDED, WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE DRIVER'S SIDE DOOR WAS THE ONLY DOOR THAT COULD BE OPENED MANUALLY WITH THE KEY. UPON INVESTIGATION, THE CONTACT DISCOVERED THAT UPON DISCONNECTING THE BATTERY, THE SYSTEM WOULD RESET AND RESUME NORMAL OPERATION. THE CONTACT ATTEMPTED THE PROCEDURE TWICE HOWEVER, THE FAILURE RESUMED SOON AFTER THE RESET. THE VEHICLE WAS NOT TAKEN TO A DEALER NOR INDEPENDENT MECHANIC TO BE DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 155,000.

ON THE EVENING OF 03/04/2021 @ 9:00PM. WHILR DRIVING HOME FROM THE GROCERY STORE DOING APPROX 35 MPH, MY VAN SUDDENLY LOST ALL POWER AND ABILITY TO USE POWER STEERING AND USE OF BRAKES. I HAD MY CHILDREN IN THE VEHICLE AT THE TIME AND THEY WERE ABLE TO HELP ME GET THE VAN OUT OF THE TRAVEL LANE AND SAFELY INTO A PARKING LOT. VAN DID NOT WANT TO START AFTER CUTTING OFF THE IGNITION SWITCH AND CUTTING IT BACK ON. WHEN I RESTARTED THE VAN IT WOULDNT ACCELERATE PASSED 15MPH WITH THE PEDAL ALL THE WAY DOWN TO THE FLOOR THEN IT CONSTANTLY STALLED OUT 8-10 TIMES THE LAST MILE FROM HOME.

WHILE AT A STOP LIGHT, ANOTHER DRIVER TOLD US THE VAN'S TAIL LIGHT WAS SMOKING. WE PULLED AROUND A CORNER AND INTO A PARKING LOT AND FOUND THAT THE PASSENGER TAIL LIGHT ASSEMBLY WAS ON FIRE WITH FLAMES LAPPING UP THE SIDE OF THE VAN. THE VAN WAS TURNED OFF AND THE FIRE WAS EXTINGUISHED. WE REMOVED THE TAIL LIGHT ASSEMBLY AND FOUND THAT THE INSIDE OF THE ASSEMBLY AND THE WIRING HARNESS WERE DESTROYED. THERE IS ALSO BODY DAMAGE. WE HAVE HAD PROBLEMS WITH THE BRAKE LIGHT BULB IN THE PASSENGER SIDE BURNING OUT FREQUENTLY, AND HAD SEEN EVIDENCE OF OVERHEATING AND SOME MELTING IN THE BRAKE LIGHT CONNECTOR SOCKET IN ABOUT 2010. ALTHOUGH THE LIGHTS BURN OUT FREQUENTLY, THE MELTING HAD NOT GOTTEN WORSE SINCE THEN. THE DRIVER'S SIDE TAIL LIGHT HAS NEVER EXHIBITED A PROBLEM LIKE THIS. AT THIS TIME IT IS UNKNOWN IF THERE IS ANY...

THE WIRING INSIDE OF THE POWER SLIDING DOOR CAUGHT FIRE WITH OUT BEING USED. IT WAS THE DOOR ON THE DRIVERS SIDE. THE VEHICLE HAD JUST BEEN DRIVEN AND PARKED FOR APPROX 10 MIN WHEN THE FIRE WAS NOTICED DUE TO THE SMELL.

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. WHEN THE VEHICLE WAS PURCHASED, THE AIR BAG LIGHT WAS ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO A DEALER WHERE IT WAS DIAGNOSED THAT THE AIR BAG SENSORS NEEDED TO BE REPLACED. THE CONTACT WAS INFORMED THAT THE REPAIRS SHOULD BE COVERED UNDER A RECALL. IT WAS DETERMINED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.

POWER LOCKS MALFUNCTIONING, LIGHTS GO ON AND OFF ON THEIR OWN, DRIVING AT NIGHT DANGEROUS. SOMETHING WRONG WITH ELECTRONIC SYSTEMS. WORK ONE TIME THAN THEY DONT. NOW MY LIGHTS WANT TO STAY ON OR COME ON RANDOMLY N I END UP WITH DEAD BATTERY. LOCKS DANGEROUS WHEN YOU CAN'T UNLOCK REAR DOOR TO GET CHILD OUT. TURN SIGNAL DOESN'T TURN OFF ON ITS OWN. STALLS AFTER FILLING FUEL TANK. POWER DRIVERS SEAT HAS STOOPED WORKING PROPERLY SLSO, I'M SHORT AND WOULD RATHER NOT HAVE TO SIT ON TOP OF SIR BAG BUT NOT ALL OF THE ADJUSTMENT FUNCTIONS ARE WORKING PROPERLY. SO CAN'T TILT SEAT INSTEAD I HAVE TO SIT ON TOP OF AIR BAG, AT A WEIGHT OF 129 N UNDER 5 FEET TALL I SURE HOPE THAT SIR BAG NEVER DEPLOYS ON ME

THE ELECTRIC DOOR LOCKS DO NOT WORK UNLESS YOU RESET THE COMPUTER BY REMOVING THE BATTERY CABLE FOR ONE MIN. AND CONNECTING IT BACK. COMPUTER NEEDS TO BE FLASHED FOR A PERMANENT FIX. THE REMOVING THE CABLE IS JUST A TEMPORARY FIX.I BOUGHT IT BROKEN.

THE BATTERY ON OUR VAN KEPT GOING DEAD.THE BATTERY WAS NEW.WE TOOK OUR VAN TO 5 DIFFERENT REPAIR SHOPS,BUYING PARTS& 3 NEW BATTERIES& WE ARE STILL WITH THE SAME PROBLEM.OUR VAN WHILE WE ARE DRIVING GOES IN & OUT OF OVER DRIVE.IT IS LIKE YOU ARE PUSHING THE GAS PEDAL & LETTING OFF,PUSHING&LETTING OFF.THE CRUISE WON'T WORK(WELL IT DOES & THEN IT DOESN'T)THERE IS A CLICKING SOUND IN THE DASH THAT SOUNDS LIKE THE DOORS ARE LOCKING YET THEY AREN'T,THE BACK DOOR WHEN YOU USE YOUR REMOTE,THE DOOR OPEN& CLOSES,OPENS & CLOSES TILL YOU HAVE TO CLOSE IT & USE YOUR KEY SO YOU ARE ABLE TO PUT YOUR GROCERIES IN WITHOUT GETTING CRUSHED BY THE DOOR,THE HANDICAPPED LIFT WON'T COME DOWN WE KNOW THERE IS A SHORTAGE SOME WHERE,YET NOBODY IS ABLE TO FIX OUR VAN!WE HAVE ONE WORKING & WE HAVE PAID SO MANY HUNDREDS OUT FOR REPAIRS...

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. AFTER EXITING THE VEHICLE, THE CONTACT ATTEMPTED TO LOCK THE DOORS AND THE LOCKS FAILED TO ENGAGE. THE CONTACT HAD TO REMOVE THE I.O.D FUSE FROM THE FUSE BOX AND RESET THE COMPUTER IN ORDER FOR THE LOCKS TO ENGAGE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000. THE VIN WAS UNAVAILABLE.

POWER LOCKS STOPPED WORKING SIGNAL LIGHTS CAN ONLY BE TURNED OFF MANUALLY BLOWER DEFROST FAN WILL NOT TURN OFF BACK SEAT FAULTY FOLDING INTO THE FLOOR

HE'S LIGHTS FLICKER WHILE DRIVING, WHICH MAKES NIGHT DRIVING DANGEROUS TO THE THE ANNOYANCE OF LIGHTS FLICKERING AND DIMMING. THE DASH LIGHTS ARE ALSO FLICKERING.

WHILE DRIVING AT HIGHWAY SPEED, THE RADIO ABRUPTLY SHUT OFF WITH A LOUD POP AT THE SAME TIME THE DASHBOARD CLUSTER IE: FUEL, SPEEDOMETER AND TEMP GAUGE SUDDENLY DROPPED AND THEN CAME BACK UP TO THERE PREVIOUS LEVEL. THE ODOMETER WENT BLANK AS WELL AND CAME ON AGAIN. THE CAR WAS STILL RUNNING BUT IT WAS QUITE DISCONCERTING TO LOOK AT THE DASHBOARD AND SEE ALL THE GAUGES IN THE SAME POSITION AS IF THE CAR WAS OFF. Y WIFE HAS TOLD ME THAT IT HAD HAPPENED PREVIOUSLY BUT SHE COULD NOT RECALL THE DATE.

ALL THE LIGHTS IN CAR LIGHTS FLICKERS, RADIO SHUT OFF AND ON, GAGES GO COMPLETELY AROUND AND CAR DIES OUT INSTANTLY. I HAD CAR REPAIRED UNDER WARRANTY BACK IN 2012. I HAD TO HAVE THE SAME ISSUE REPAIRED IN MARCH 2015 AND NOW ITS AUG 2015 IT IS OCCURRING AGAIN...

THE POWER LOCKS STOPPED WORKING. NEITHER THE REMOTE NOR THE ACTUAL INTERIOR LOCK WOULD WORK TO LOCK ALL THE DOORS AT ONCE. WE NOW NEED TO INDIVIDUALLY LOCK EACH DOOR.

MY ELECTRICAL SYSTEM HAS A DEMAND. IT STARTED WITH POWER SLIDING DOOR NOT OPENING THEN THE LOCKS WOULD NOT UNLOCK IF I DID NOT SLAM THE SIDE DOOR SHUT THE FLASHERS WOULD COME ON AND I COULD NOT SHUT THEM OFF THE REAR WINDOW WIPER STARTED MOVING I COULD NOT SHUT IF OFF ALL THE DASH LIGHTS STARTED FLASHING AND INDICATED I HAD NO GAS. THIS IS A HANDICAPPED MODIFIED VAN AND I USE A WHEELCHAIR TO AMBULATE. I HAVE TAKEN OFF WORK FOR FULL DAYS AND PARTIAL DAYS TO GET THIS PROBLEM DIAGNOSED AND FIXED. AFTER A $2,488 DOLLAR BILL TO EXCISE THE DEMAND THE DOOR STILL WILL NOT OPEN AND THE WHEELCHAIR RAMP WILL NOT DEPLOY. I HAVE TO WORK AND I AM ALMOST OUT OF LEAVE. DODGE SHOULD COME TO THE RESCUE AND ASSUME RESPONSIBILITY FOR THE COMPUTER PROBLEM THAT THEY ARE AWARE OF AND RECALL THESE...

THE 2005 DODGE GRAND CARAVAN AND 2005 CHRYSLER TOWN AND COUNTRY HAVE A KNOWN SOFTWARE BUG FOR THE BODY CONTROL MODULE THAT CONTROLS THE POWER LOCKS ON THE VEHICLE. ONCE THIS OCCURS ON YOUR VEHICLE, THE OWNER IS UNABLE TO LOCK THE VEHICLE REMOTELY OR FROM THE POWER LOCK SWITCH OR WHEN THE VEHICLE EXCEEDS 10 MPH AUTO LOCK FEATURE. KNOWN SERVICE BULLETINS ARE: 08-028-05 AND 08-040-04 TO PERMANENTLY FIX THIS ISSUE WITH THE LOCKS THE OWNER CAN TEMPORARILY FIX THE PROBLEM BY PULLING THE POWER TO THE VEHICLE AND LETTING TEH BODY CONTROL MODULE RESET. THIS IS ONLY A TEMPORARY FIX AS THE PROBLEM HAS RE-OCCURRED 3 TIMES SINCE THE ORIGINAL ISSUE CAME UP. THE PERMANENT FIX FOR THIS KNOWN SOFTWARE ISSUE RESULTS IN THE CONSUMER/OWNER OF THE VEHICLE TO TAKE INTO A DEALERSHIP FOR DIAGNOSTICS AND REPAIR A MINIMUM OF $130+TAX. I BELIEVE THIS A SAFETY ISSUE FOR...

POWER DOOR LOCKS WERE INOPERABLE EITHER BY THE KEY FOB OR THE INTERIOR DOOR LOCK SWITCHES. RETURNED VEHICLE TO DEALER ON 10/07/2014 FOR REPAIR. IN THAT I HAD EXTENDED COVERAGE I HAD TO PAY THE $100.00 CO-PAY. *TR

WHILE ATTEMPTING TO OPERATE THE ELECTRIC SLIDING SIDE DOOR, A LARGE SPARK AND SMALL DEBRIS FIRE WAS SEEN IN THE BOTTOM DOOR RAIL. UPON INSPECTION, A BREAK IN THE WIRE HARNESS HAD ALOUD WIRES TO BE SEVERED THAT CONTROLS THE DOOR AND LOCKING SYSTEM. THE AUTOMATIC DOOR LOCKS ON BOTH SIDE DOORS NO LONGER WORKED AND THE PASSENGER SIDE DOOR WOULD NO LONGER OPEN ELECTRICALLY. I REMOVED THE WIRING HARNESS AND WIRES AND DISCARDED THEM TO AVOID ANY MORE PROBLEMS (SPARKING AND/OR FIRES). THIS COULD CAUSE A MAJOR FIRE HAZARD IN THE RIGHT ENVIRONMENT. *TR

WHILE SLOWING DOWN MOTOR WILL TRY AND SHUT OFF. IF YOU COME TO A STOP IT WILL SHUT OFF. SEAT BELTS DO NOT LOCK IN PLACE. REAR WINDSHIELD WIPER WILL NOT MOVE. PASSENGER SIDE CARGO DOOR WILL NOT UNLOCK. SOME SETTINGS FOR HEAT AND AC WILL NOT WORK. LEFT TURN SIGNAL WON'T SHUT OFF AFTER TURNING. *TR

THE AUTOMATIC LOCK SYSTEM ON MY 05 DODGE GRAND CARAVAN DOESN'T WORK, WITH THE KEY FOB OR WHEN PUSHING THE AUTOMATED LOCK BUTTONS INSIDE THE VEHICLE. THE CAR BEEPS LIKE IT IS LOCKING WHEN YOU PUSH THE KEY FOB. HOWEVER, IT REALLY ISN'T LOCKING. AFTER DOING SOME RESEARCH, I HAVE FOUND THAT THIS IS A COMMON ISSUE WITH THE 2005 DODGE CARAVAN MODELS. THAT BEING SAID, I CONTACTED THE DEALERSHIP & WAS TOLD THAT THERE HAS NOT BEEN A RECALL, BECAUSE THIS IS "NOT CONSIDERED A SAFETY ISSUE." HOW IS THIS NOT A SAFETY ISSUE? DODGE, THEMSELVES, ACTUALLY CALLS PART OF THE AUTOMATED LOCK SYSTEM A "SAFETY FEATURE." THE SYSTEM IS SUPPOSED TO AUTOMATICALLY LOCK, ONCE YOU REACH A SPEED OF 15 MPH. WELL, THIS NO LONGER WORKS EITHER. HOW IS IT CALLED A "SAFETY FEATURE" WHEN IT WORKS, BUT THEN IT ISN'T A "SAFETY ISSUE" WHEN IT DOESN'T WORK?...

ELECTRIC LOCKS FAIL. AFTER R&R A FUSE THE LOCKS WOULD WORK FOR A PERIOD OF TIME THEN FAIL AGAIN. REPEAT. *TR

DOOR LOCK SYSTEM HAS FAILED DUE TO COMPUTER GLITCH. FROM WHAT I HAVE FOUND ON-LINE THIS PROBLEM HAS BEEN HAPPENING FOR YEARS AND SHOULD BE COVERED BY A RECALL.

I HAVE BEEN EXPERIENCING RANDOM ELECTRICAL ISSUES INTERMITTENTLY FOR A FEW WEEKS, BUT TODAY, IT WAS NOTICED THAT MY POWER LOCKS ARE NOT ABLE TO BE ENGAGED OR DISENGAGED VIA EITHER MY KEY FOB OR MANUAL BY THE BUTTON ON THE SIDE OF THE DRIVER'S OR PASSENGER'S DOOR. THEY ALSO DO NOT ENGAGE ONCE THE VEHICLE REACHES THE APPROPRIATE SPEED. THE ONLY WAY TO LOCK OR UNLOCK THE VEHICLE AT THIS TIME, IS VIA THE KEY IN THE DOOR, AND MANUALLY PUSHING DOWN/PULLING UP THE LOCKS THEMSELVES. AS A MOM OF THREE CHILDREN UNDER THE AGE OF 10, HAVING THEM RIDING IN THE BACK OF THE VEHICLE AND NOT KNOWING FOR SURE THAT THEIR DOORS ARE LOCKED, CAUSES DISTRESS IN REGARD TO THEIR SAFETY. I NEED TO KNOW THAT I CAN LOCK MY VEHICLE QUICKLY BEHIND MY CHILDREN, IF NECESSARY, AND KNOW THAT IF THEY HAPPEN TO PULL ON THE...

POWER LOCK FUNCTION STOPPED WORKING ON MY 2005 DODGE GRAND CARAVAN. POWER DOOR LOCKS COULD NOT BE ACTIVATED USING THE POWER DOOR LOCK SWITCHES ON THE DRIVER'S DOOR, THE PASSENGER DOOR, THE KEY FOB, AND THE 15 MPH AUTO LOCK FEATURE. ATTEMPTING TO ACTIVATE POWER DOOR LOCKS FROM THE KEY FOB GIVES A FALSE INDICATION THAT THE DOORS HAVE LOCKED SINCE THE HORN BEEPS WITHOUT THE DOORS LOCKING. NOT HAVING THE AUTO-LOCK FEATURE AND NOT HAVING CONTROL OF THE POWER DOOR LOCKS FROM THE DRIVER OR PASSENGER DOORS IS A SAFETY HAZARD FOR PASSENGERS EXITING THE VEHICLE IN CASE OF EMERGENCY. *TR

THE ELECTRIC DOOR LOCKS COMPLETELY QUIT WORKING. WE TRIED THE PULLING OF THE FUSE AND UNHOOKING OF THE BATTERY AND THAT WORKED. NOW A FEW YEARS LATER HERE WE ARE AGAIN. THE ELECTRICAL LOCKS HAVE COMPLETELY QUIT AGAIN 09/2014. THIS VAN HAS HAD ONE ELECTRICAL PROBLEM AFTER ANOTHER. OUR ELECTRIC WINDOWS HAVE GONE OUT AT LEAST 3 TIMES AND BEEN REPLACED. WE HAVE FINALLY GIVEN UP REPLACING AND THE PASSENGER WINDOW WON'T GO DOWN. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED AND THE HORN FAILED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE CLOCK SPRING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 226,000.

HAVE HAD NUMEROUS PROBLEMS WITH VAN STARTING 3 MONTHS AFTER PURCHASE. DASH LIGHTS FLASH BUT ONLY FOR SECONDS SO NO CODE CAN BE READ. ELECTRIC WINDOWS FAILING, BATTERIES REPLACED NUMEROUS TIMES. HAVE GOTTEN TO POINT I PURCHASE WINDOW TRACKS AND REPLACE MYSELF TO SAVE ON COST. MOST RECENTLY DASH LIGHTS AND HEADLIGHTS FLASHING RAPIDLY RADIO AND AIR GO OUT AND VEHICLE WANTING TO STALL. THIS IS A CONVERSION VAN BY BRAUN. HAD HANDICAPPED PERSON IN WHEELCHAIR IN PASSENGER SIDE FRONT. VAN STALLED IN INTERSECTION BUT WAS ABLE TO GET OFF TO SIDE OF ROAD. WHERE I WAS, I COULD NOT GET WHEELCHAIR OUT OF VAN. WE COULD HAVE BEEN KILLED NOT TO MENTION I LIVE IN FLORIDA AND HEAT WAS AT A FEEL LIKE TEMP OF 108. AFTER 10 OR 15 MINUTES VAN RESTARTED AND WAS ABLE TO LIMP HOME. AUTO ELECTRIC REPAIR SHOP REPLACED IGNITION WIRING HARNESS BUT AFTER...

THE LEFT SIDE REAR SLIDING DOOR STOPPED WORKING IN JUNE 2013 BY ONLY OPENING ABOUT 3 INCHES AND STOPPING, THEN LATER STARTED NOT UNLOCKING AUTOMATICALLY. YOU THEN HAD TO EITHER PULL THE DOOR OPEN OR PULL IT SHUT. IN JULY OF 2014 THE RIGHT SIDE REAR SLIDING DOOR STOPPED WORKING AND UNLOCKING AUTOMATICALLY. WE ACTUALLY STARTED HAVING PROBLEM WITH IT SHORTLY AFTER WE BOUGHT IT IN APRIL 2005. IF YOU HAD IT OPEN, IT WOULD OCCASIONALLY NOT CLOSE AT ALL EVEN MANUALLY UNTIL YOU PULLED ON IT FOR A WHILE. WE TOOK IT TO THE DEALER MORE THAN ONCE AND THEY SAID NOTHING WAS WRONG WITH IT. NOW, BOTH HAVE TO BE MANUALLY UNLOCKED AND ON OCCASION THE RIGHT SIDE WILL OPEN AUTOMATICALLY AFTER YOU MANUALLY UNLOCK IT. NEITHER OF THE REAR SLIDING DOORS LOCK OR UNLOCK AUTOMATICALLY WITH THE BUTTON ON THE HEADLINER, THE AUTOMATIC BUTTON ON THE DOOR,...

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT ALSO STATED THAT THE SHIFTING HAD TO BE TAMPERED IN ORDER TO RESTART THE VEHICLE AFTER MULTIPLE ATTEMPTS. IN ADDITION, THE AUTOMATIC DOOR ON THE DRIVER SIDE WOULD NOT CLOSE PROPERLY,WHICH CAUSED HER TO DRIVE THE VEHICLE WITH THE DOOR COMPLETELY OPEN. THE PROBLEM RECURRED MULTIPLE TIMES. ALSO, THE DRIVER SIDE AIR BAG WARNING LIGHT ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS NOT TAKEN TO A MECHANIC FOR A DIAGNOSIS AND THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE AND THE APPROXIMATE FAILURE MILEAGE WAS 104,000.

I ACTIVATED THE PASSENGER SIDE AUTOMATIC SLIDING DOOR. THERE WAS A POP AND A FLASH INDICATIVE OF AN ELECTRICAL SHORT AND THE DOOR NO LONGER OPENED OR CLOSED AUTOMATICALLY. I INSPECTED THE WIRES AND FOUND THAT TWO WIRES WERE BROKEN AND POSSIBLY MADE CONTACT WITH EACH OTHER, CAUSING AN ELECTRICAL SHORT. THE VEHICLE WAS INSIDE MY GARAGE AT THE TIME AND NO ONE WAS INSIDE. HOWEVER, THIS IS A DANGEROUS SITUATION SHOULD THE VEHICLE CATCH FIRE BECAUSE OF THE FLIMSY WIRING ON THE DOORS. THE DRIVER SIDE DOOR STOPPED WORKING TWO DAYS LATER, BUT WITH NO POP OR FLASH. I NOTICED SEVERAL OTHER VEHICLES HAD THE SAME PROBLEM, AND THERE ARE SEVERAL DOCUMENTED CASES OF THE SAME PROBLEM THROUGHOUT THE WEB. *TR

2005 DODGE GRAND CARAVAN HEADLIGHT SWITCH WILL NOT TURN THE LIGHTS ON. YOU HAVE TO KEEP TURNING THE SWITCH TO MAKE IT TURN ON. AS YOU ARE GOING DOWN THE ROAD AT NIGHT THE LIGHTS WILL FLASH OR THEY WILL JUST TURN OFF. *TR

THE HEADLIGHTS STARTED GOING OFF WHILE DRIVING. FIRST THE FOG LIGHTS STARTED FLASHING ON AND OFF ON THEIR OWN AND WHEN I WOULD PULL ON THE HEADLIGHT SWITCH OUT TO ENGAGE THE FOG LIGHTS, THE HEADLIGHTS WOULD TURN OFF. I SAW ON LINE THAT MANY OTHER PEOPLE ARE HAVING THIS PROBLEM WITH THEIR GRAND CARAVANS. *TR

I WAS GOING THROUGH A DRIVE-THRU WHEN MY KNEE ACCIDENTALLY BUMPED THE KEY IN THE IGNITION AND THE VEHICLE CUT OFF. I TURNED IT BACK ON AND BUMPED IT AGAIN TO TEST IT, AND IT HAPPENED AGAIN. I TRIED IT WHILE THE VEHICLE WAS IN PARK AS WELL AS IN DRIVE AND REVERSE AND IT HAPPENED EACH TIME. I RECENTLY READ ABOUT THE GM / DODGE /CHRYSLER IGNITION AND AIRBAG ISSUES, BUT MY VEHICLE YEAR IS NOT BEING INVESTIGATED OR RECALLED. I DEMAND THAT THE INVESTIGATION AND RECALLS ARE EXPANDED TO INCLUDE MODELS GOING BACK TO AT LEAST 2005, INCLUDING ANY VEHICLES WITH THIS ENGINEERING OR PART DEFECT. *TR

POWER DOOR LOCKS ARE NOT WORKING. UNABLE TO LOCK OR UNLOCK DOORS WITH EITHER KEY REMOTE OR BUTTON LOCATED ON THE DOOR. THIS IS A CONCERN BECAUSE THE LOCKS DO NOT ENGAGE WHEN VEHICLE IS IN MODE OF TRAVEL. THIS FIRST STARTED IN AUGUST OF 2012 WITH THE PASSENGER SLIDING DOOR AND NOW BOTH SLIDING DOOR LOCKS ARE INOPERABLE AS WELL AS THE TRUNK HATCH. HAVE TRIED CHANGING FUSES WITHOUT SUCCESS. I RESEARCHED INFORMATION ONLINE AND FOUND A SITE THAT INDICATED THAT A BCM SOFTWARE UPDATE COULD FIX THE PROBLEM BUT DEALERSHIPS CHARGE FOR THE UPDATE. SHOULD THERE BE A FEE INVOLVED WHEN THIS MECHANISM IS SECONDARY TO A SOFTWARE ISSUE THAT CREATES A SAFETY HAZARD? BECAUSE SAFETY ISSUES ARE AT HAND SHOULD THIS BE LISTED AS SAFETY RECALL? *TR

THE POWER DOOR LOCKS DON'T WORK. TAILGATE IS STUCK IN UNLOCKED POSITION. ALL OTHER LOCKS HAVE TO BE OPERATED MANUALLY, THERE IS NO WAY TO LOCK THE TAILGATE MANUALLY. REMOVING AND REINSERTING THE FUSE FIXED THE PROBLEM FOR SEVERAL WEEKS AT A TIME. EVENTUALLY REMOVING THE FUSE STOPPED WORKING. I RESEARCHED AND FOUND THAT THERE WAS A SERVICE BULLETIN ON THIS THAT THE REPAIR WAS TO FLASH THE BODY CONTROLLER. THIS ISSUE ALSO IS CAUSING A P0135 CODE WHICH IS FOR AN O2 SENSOR HEATER. THIS CODE COMES UP EVEN AFTER REPLACING THE O2 SENSOR. THIS ISSUE IS A SAFETY CONCERN WITH THE TAILGATE NOT BEING ABLE TO LOCK WHICH IS AN EASY WAY FOR SOMEONE TO GET INTO THE VEHICLE AND EITHER CARJACK IT OR STEAL IT, OR BELONGINGS. AS FOR THE P0135 CODE IT HAS CAUSED ME TO CHASE MONEY AFTER AN EMISSIONS PROBLEM THAT REALLY DOES NOT...

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT POWER DOOR LOCKS WERE INOPERABLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE BCM NEEDED TO BE REPROGRAMMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE. UPDATED 5/19/14*CN UPDATED 06/04/2014 *JS

AIR BAG LIGHT ILLUMINATED, NO HORN OR CRUISE CONTROL. INDICATIVE OF A FAILED CLOCKSPRING AS IN EARLIER MODELS. THIS CONDITION EXISTED AT PURCHASE SO EXACT DATE MILEAGE OF INITIAL FAILURE UNKNOWN. *TR

POWER DOOR LOCKS FAIL TO OPERATE EITHER WITH SWITCHES OR KEY FOB ON SOME OF THE DOORS. CAN'T GET INTO THE VEHICLE ON DOORS THAT DON'T HAVE KEY HOLES. DOORS DON'T LOCK WHEN LEAVING VEHICLE PARKED CAUSING POTENTIAL THEFT OPPORTUNITY. *TR

HEADLIGHTS WENT OUT WHILE DRIVING AT NIGHT. HAD TO FIDDLE WITH THE ON OFF SWITCH REPEATEDLY TO GET THEM TO COME BACK ON. COULD NOT GET ISSUE TO REPLICATE. *TR

I HAVE BEEN HAVING INTERMITTENT ISSUES WITH MY HEADLAMPS NOT TURNING ON. IF I JIGGLE THE FUSE BOX OR PULL THE RELAY OUT THEY WILL COME ON. THE ISSUE HAS GOTTEN PROGRESSIVELY WORSE TO THE POINT THAT I HAVE TO MANIPULATE THE FUSE BOX TO GET MY HEADLIGHTS ON AT ALL. ALL OTHER LIGHTS WORK. I FEEL VERY UNSAFE IN MY VAN SINCE I HAVE TO POP THE HOOD EVERY TIME I NEED HEADLIGHTS AND SOMETIMES IT CAN TAKE SEVERAL MINUTES BEFORE THEY WORK. AS A WOMAN IT IS NOT SAFE TO BE IN A PUBLIC PLACE WITH MY VAN HOOD UP. I WOULD LIKE TO SEE DODGE CORRECT THIS DEFECT! *TR

DOORS LOCK THEMSELVES AND DOOR LOCK SWITCH FAILS TO FUNCTION INTERMITTENTLY. *TR

MY VAN HAS HAD FLICKERING HEADLIGHTS AND DASHBOARD LIGHTS. I REPLACED THE ALTERNATOR AND THE BATTERY HAD BEEN REPLACED RECENTLY AS WELL AND IT IS STILL DOING IT. DRIVING HOME FROM WORK TODAY IT WAS FLICKERING A LOT AND THE DASH BOARD LIGHTS WERE FLICKERING A LOT AS WELL. MAKES IT HARD TO SEE DRIVING AT NIGHT. *TR

MY POWER DOOR LOCKS NO LONGER WORK. WE CAN PULL THE FUSE AND PUT IT BACK AND THEY WILL WORK FOR A FEW DAYS. ONE TIME OUR BATTERY DIED AND AFTER CHARGING THE DOOR LOCKS WORKED FOR A FEW WEEKS. ALSO THE POWER WINDOW ON THE DRIVER SIDE INTERMITTENTLY DOES NOT WORK AND NOW EVERY TIME I OPEN THE DOOR THE HORN BLOWS. *TR

POWER DOOR LOCKS STOP WORKING. DOES NOT LOCK AT 20MPH. *TR

MY VANS LOCKS DON'T WORK ANYMORE ON THE REMOTE ON BY PUSHING THE BUTTON BUT IF I CHARGE THE BATTERY EVEN IF ITS NOT DEAD IT'LL WORK FOR A COUPLE DAYS I FEEL THIS SHOULD BE FIXED FOR SAFETY. *TR

THE FIRST PROBLEM WAS THE AUTOMATIC DOOR LOCKS FAILED TO FUNCTION WHEN REACHING THE REQUIRED SPEED. EVEN WOULD NOT LOCK WITH THE KEY TOOK IT TO MECHANIC WAS ADVISED THAT WOULD HAVE TO REPLACE THE COMPUTER, BUT BY DISCONNECTING THE BATTERY THAT IT WOULD RESET THE COMPUTER, IT IS ONLY A TEMPORARY SOLUTION.SECOND PROBLEM WAS THE DOOR MOTOR STOP WORKING HAD THAT REPLACED. THIRD PROBLEM WAS THE FRONT AXLE BROKE WITH NO APPARENT WEAR, HAD THAT REPLACED. NOW IT'S THE GAS TANK, CAR WANTS TO STALL WAS ADVISED BY MECHANIC THAT THE GAS TANK WOULD HAVE TO BE REPLACED, THAT IT IS A DEFECTIVE VALVE THAT HAS SINCE BEEN CORRECTED IN THE NEWER MODELS. *TR

COURTESY LAMP SOCKET MELTED NEEDING REPLACEMENT. MORE RECENTLY, THE RIGHT REAR TURN SIGNAL FAILED. WHEN I REPLACED THE LAMP, I NOTICED THAT BOTH SIDES THE SOCKET ASSEMBLY HAD MELTED. THE REPLACEMENT BULB IS NOT ABLE TO FUNCTION AS THE CONTACTS ARE NOT ABLE TO CONNECT. THE ENTIRE ASSEMBLY NEEDS TO BE REPLACED. *TR

STARTED UP THE CAR AND ALL THE LIGHTS ON THE DASH STAYED ON, FUEL LIGHT, ENG LIGHT, ABS LIGHT ....ALL THE LIGHTED SQUARES AROUND THE GEAR (DL321) STAYED LIT AND WOULD NOT SHUT OFF UNTIL I TURNED THE ENGINE OFF AND THEN THEY DIDN'T SHUT OFF UNTIL THE AUTOMATIC CUT OFF ..SHUT THEM DOWN. CHECKED ALL THE FUSES AND THE FMC AND THE PDC TO CLEAN CONNECTIONS AND DIDN'T CHANGE. DISCONNECTED THE BATTERY CABLES AND THEN RECONNECTED THEM. STILL NOTHING CALLED THE DEALER AND HE SAID THAT THEY COULD CONNECT THE DIAGNOSTIC BUT SOUNDED LIKE THE MODULE NEEDED TO BE REPLACED AT A START OF $500. MY HEADLIGHTS HAVE BEEN HAVING ON AND OFF PROBLEMS EVERY ONCE IN A WHILE ALONG WITH THE DRIVERS WINDOW NOT GOING DOWN THEN IT WORKS FINE FOR A LONG TIME AND THEN STOPS AGAIN. *TR

ELECTRIC OPERATION OF LOCKS QUIT AND HAS NOT RESUMED. NEITHER KEYS REMOTE FEATURE WORKS TO LOCK OR UNLOCK THE VAN, ALTHOUGH THEY BOTH CAUSE THE LIGHTS TO FLASH AS USUAL. LOCK SWITCHES ON DRIVER AND FRONT PASSENGER DOORS ALSO DO NOT WORK. MANUAL LOCKING VIA THE OLD FASHIONED BUTTONS WORKS OK, AS DO KEY LOCKS ON REAR HATCH AND DRIVER'S DOOR. *TR

THE SAME AS SO MANY OTHER COMPLAINTS. THE ELECTRIC LOCKING SYSTEM AND POWER SIDE DOORS STOPPED WORKING. CAR DOES NOT LOCK WHEN REACHING SPEED EITHER. THIS IS A SAFETY HAZARD. I HAVE A CHILD IN THE BACK AND CANNOT BE ASSURED DOORS ARE LOCKED. I DO NOT HAVE THE ABILITY TO LOCK OR UNLOCK IN CASE OF EMERGENCY. REAR DOOR LOCKING IS HIT OR MISS. IF IT'S TRUE THAT THE SYSTEM NEEDS AN UPGRADE WHY DO I HAVE TO PAY FOR THAT? SHOULDN'T THE COMPANY THAT BUILT THE DEFECTIVE PART HAVE TO FIX IT? NOT THE FIRST ELECTRICAL PROBLEM I HAVE HAD. HEADLIGHTS STOPPED WORKING WHILE DRIVING MULTIPLE TIMES. I REPLACED THE SWITCH, WORKS FOR NOW. I ALSO HAD A DEFECTIVE WINDOW MOTOR AND SWITCH WHICH HAD TO BE REPLACED. *TR