2005 DODGE GRAND CARAVAN Steering Problems

WHILE DRIVING DOWN THE ROAD ABOUT 35 MPH MY VAN JUST DIED OUT IN TRAFFIC N WOULD NOT RESTART. THANK GOD I WAS NOT ON INTERSTATE

VAN LOSE POWER STEERING DURING HEAVY RAIN ONLY. I PURCHASE THIS VAN IN JUNE/JULY 2018 RECENTLY HAD POWER STEERING CHECK AND NO ISSUES FOUND. YET THIS THE FIFTH TIME THIS HAS HAPPENED. TODAY I WAS DRIVING IN THE RAIN TO PICKUP MY DAUGHTER FROM SCHOOL AND IT HAPPENED AGAIN. THE WHEEL TIGHTEN UP AND I WAS UNABLE TURN. I HAD TO TURN ON MY HAZARDS LIGHT AND TURN CAR OFF IN THE MIDDLE OF THE ROAD. AFTER LETTING VEHICLE SIT ABOUT 15 MINUTES I WAS ABLE TO DRIVE HOME. I REPEAT IT ONLY HAPPENS IN THE RAIN WHY I BELIEVE THERE IS A MANUFACTOR DEFECT AND NEEDS TO BE RECALLED.

LAST NIGHT - FOR THE 4TH TIME NOW - AFTER FILLING THE TANK AT THE GAS STATION, MY CAR JUST DIED. THE FIRST 3 TIMES IT WAS WHEN I STOPPED AT THE STOP SIGN LEAVING THE GAS STATION PARKING LOT. LAST NIGHT, IT WAS AFTER I WAS OUT ON THE MAIN ROAD AND IN HEAVY TRAFFIC. IT WAS STOP AND GO RUSH HOUR TRAFFIC, SO I WAS THANKFULLY ONLY GOING APPROX 15-20 MILES AN HOUR. POWER STEERING WAS LOST, BRAKES WERE PRACTICALLY NON EXISTENT. BARELY MANAGED TO PULL OFF INTO A PARKING LOT AND WAS ABLE TO SET THE PARKING BRAKE TO FINISH STOPPING. ONCE STOPPED AND IN PARK, WAS ABLE TO START IT RIGHT BACK UP. EVERY TIME THIS HAS HAPPENED IT HAS BEEN RIGHT AFTER FUELING UP. I NEVER THOUGHT MUCH ABOUT IT THE OTHER 3 TIMES, BUT THIS TIME WAS DIFFERENT, AND VERY DANGEROUS. I WAS ALMOST...

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE ENTIRE DOOR LATCHING SYSTEM FAILED AND THE STEERING WHEEL EMITTED A LOUD WHINING NOISE. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THE DOOR LATCHES NEEDED TO BE REPROGRAMMED AND THE POWER STEERING FLUID NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 124,000. UPDATED 6/24/15*CN UPDATED 10/12/2017*CN

VEHICLE STALLED TWICE AFTER FILLING UP WITH GAS. FIRST STALL HAPPENED APPROXIMATELY 500 FEET FROM FILLING STATION, WHILE STILL IN A PARKING LOT. THE SECOND STALL HAPPENED APPROXIMATELY 0.5 MILES FROM THE FILLING STATION WHILE TURNING FROM A ROADWAY INTO A BUSINESS. EACH STALL REQUIRED SEVERAL CRANKS OF THE ENGINE TO RE-START. WHEN THE ENGINE QUITS, THE POWER STEERING ALSO GOES AWAY. THIS HAS BEEN AN INTERMITTENT OCCURRENCE SINCE EARLY 2013, WITH IT BECOMING A REGULAR OCCURRENCE AFTER EACH GASOLINE FILL UP (LATER IN 2013). THE TANK IS ALWAYS FILLED UNTIL THE PUMP SHUTS OFF. IT IS NEVER PARTIALLY FILLED, SO I CANNOT SAY IF IT ONLY OCCURS WITH A FULL FILL UP. THIS IS THE FIRST TIME I DECIDED TO RESEARCH THE SITUATION AND FILE A COMPLAINT. *TR

TOOK OWNERSHIP OF THE VEHICLE IN JANUARY 2014. NEARLY EVERY TIME THE GAS TANK HAS BEEN FILLED UP (TO FULL), THE VEHICLE WILL RUN OK FOR A BRIEF PERIOD OF TIME, IT WILL THEN BEGIN TO BUCK AND STALL. THIS HAPPENS AT NEARLY ANY ENGINE SPEED. ONCE THE VEHICLE STALLS IT IS DIFFICULT TO RESTART FOR ONE ATTEMPT. AFTER THE GAS TANK GETS JUST UNDER FULL THE OPERATION IS COMPLETELY NORMAL. THIS IS DANGEROUS AS USUALLY YOU ARE IN TRAFFIC. *TR

NEARLY EVERY TIME THE WE FILL THE TANK FULL OF FUEL THE ENGINE SHUTS DOWN AFTER LEAVING THE STATION. TYPICALLY IT WILL HAPPEN MID TURN WHILE PULLING OUT OF THE STATION OR ELSE WITHIN A BLOCK OF LEAVING. WHEN IT HAPPENS THE STEERING STOPS WORKING NORMALLY. WE HAVE TO SHIFT THE VEHICLE TO NEUTRAL AND RESTART IT AND THEN PUT IT BACK IN DRIVE AND GO. *TR

AFTER MAKING A RIGHT HAND TURN, MY STEERING WHEEL LOCKED UP AND I COULD NOT RETURN TO CENTER. I WAS GOING SLOWLY, SO I WAS ABLE TO STOP THE CAR BEFORE IT WENT INTO THE DITCH. IF THIS HAD HAPPENED AT HIGHWAY SPEEDS OR WHERE MOST ROADS IN MISSOURI HAVE LIMITED SHOULDERS, I WOULD HAVE CRASHED INTO THE DITCH. I WAS ABLE TO WORK IT LOOSE AND THEN LIMP IT HOME VERY SLOWLY, ESP. AROUND CURVES OR CORNERS WHEN IT WOULD STICK AGAIN. UPON TAKING IT TO A MECHANIC, HE FOUND OUT THAT THE RACK AND PINION HAD TO BE REPLACED. IT PROCEEDED TO GO OUT 2 MORE TIMES SINCE THE FIRST INCIDENT. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE POWER STEERING ASSIST FAILED, AND THE STEERING WHEEL BECAME HARD TO TURN WHEN THE CONTACT DROVE OVER A PUDDLE OF WATER. THE FAILURE WAS RECURRING OVER A PERIOD OF NINE YEARS. THE VEHICLE WAS TAKEN TO A DEALER, WHO REPLACED THE SERPENTINE BELT AND IDLER PULLEY HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000.

AFTER FILLING VEHICLE WITH FUEL, OUR VAN HAS BEEN STALLING UPON STOPPING AT A LIGHT WITHIN 5 MINUTES OF LEAVING GAS STATION. MOST RECENTLY VEHICLE CUT OFF LESS THAN 1/4 MILE AFTER REFILLING WHEN DRIVING ON ROAD. WHEN THIS HAPPENS, ELECTRIC OF VEHICLE SHUTS OFF ALONG WITH LOSING POWER STEERING. THE PROBLEM OF VEHICLE SHUTTING OFF HAS GONE ON INTERMITTENTLY FOR ABOUT 1-2 YEARS NOW BUT IS GETTING WORSE. UNTIL ABOUT A WEEK AGO, THIS ALWAYS HAPPENED AT A STOP BUT THE LAST INCIDENT IS CONCERNING CONSIDERING IT HAPPENED WHILE THE VEHICLE WAS IN MOTION. THIS IS A SERIOUS SAFETY ISSUE, ESPECIALLY CONSIDERING MY WIFE USES THIS AS PRIMARY TRANSPORTATION FOR HER AND OUR 3 CHILDREN. WHAT IF THIS CUTS OFF ON THE HIGHWAY OR IN AN INTERSECTION? I DID A LOT OF RESEARCH ONLINE TRYING TO FIND POSSIBLE ROOT CAUSES. THERE SEEMS TO BE AN OVERWHELMINGLY LARGE NUMBER OF...

AS I WAS DRIVING MY 2005 DODGE GRAND CARAVAN, THE DASHBOARD FLICKERED AND THEN THE CAR SHUT DOWN. POWER STEERING WAS DISABLED BUT I WAS LUCKILY ABLE TO DRIFT IT TO THE SIDE OF THE ROAD. AFTER RESEARCHING ONLINE, IT SEEMS THIS ELECTRICAL SHUT DOWN IS ONGOING AND PROBLEMATIC FOR THIS YEAR AND MAKE. I HAD LITTLE CHILDREN IN THE CAR AND WITHOUT WARNING THE CAR DIES. THIS NEEDS TO BE A RECALL AS IT POSES SERIOUS SAFETY CONCERNS FOR THE DRIVER OF THE VEHICLE AND CARS AROUND IT. HAD I BEEN ON THE HIGHWAY, I WOULD NOT BE ABLE TO TELL YOU ABOUT THIS INCIDENT. WHEN I BROUGHT THE VEHICLE IN TO THE DEALER, I WAS TOLD IT NEEDED AN ELECTRICAL SYSTEM SOFTWARE UPDATE OTHERWISE IT WILL GET PROGRESSIVELY WORSE. THE DEALER ALSO EXPLAINED THAT THE OTHER ELECTRICAL ISSUES THAT I HAVE BEEN HAVING - TAIL LIGHTS BURNING OUT,...

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT VEHICLE WAS COMPLETING STATE INSPECTION WHEN HE WAS INFORMED THAT THE RACK PINION STEERING NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. *TR

THE RACK AND PINION ARE SEVERELY LEAKING AND ALSO GETTING REALLY HOT AND CAUSING THE LEAKING FLUID TO FUME INTO THE CABIN OF THE CAR...THIS HAS CAUSED WORRY FOR INABILITY TO STEER AT HIGH SPEEDS AND ALSO LIGHT HEADEDNESS IN CAR FROM COLLECTING FUMES INTO CABIN AT STOPS...SO MANY HAVE REPORTED THIS AND I AM REGRETTABLY NOW ONE OF THEM... *TR

IMMEDIATELY AFTER MAKING A RIGHT TURN, THE STEERING WHEEL LOCKED. THE LOWER SPEED AND ADEQUATE SHOULDER ON THE ROAD ARE THE ONLY THINGS THAT KEPT ME FROM GOING INTO THE DITCH. IT ENDED UP BEING A STEERING GEAR THAT WAS REPLACED TO FIX THE PROBLEM. IT HAS WENT BAD 3 MORE TIMES SINCE. *TR

2005 GRAND CARAVAN RACK & PINION LEAK FAILURE- IT BEGAN AS A SLIGHT GRUNT WHEN TURNING THE STEERING WHEEL WHILE SITTING STILL, LIKE IN A PACKING LOT, THEN I TOOK THE VAN IN FOR A VEHICLE SAFETY INSPECTION FOR PLATE RENEWAL WHEN I WAS INFORMED I HAD A BAD RIGHT STRUT AND A LEAK, THEY REPLACE THE STRUT AND RE-ALIGNED THE FRONT END BUT INFORMED ME I WOULD HAVE TO REPLACE THE RACK & PINION BOX TO FIX THE FLUID LEAK. I DID NOT BELIEVE THEM SO I TOOK IT TO ANOTHER SHOP FOR A SECOND OPINION, AND FOR SURE THAT'S WHAT IT IS AND THE EXPECTED REPAIR COST TO BE NEAR $1000.00 THE VAN ONLY HAS 80,100 GENTLE MILES ON IT, I CAN'T BELIEVE THIS FAILED ALREADY, I TREAT THIS VAN REALLY WELL. SINCE THEN I HAVE LEARNED THIS IS A BIG PROBLEM WITH THIS VAN, LITTLE DID I...

TOOK MY 2005 GRAND CARAVAN TO THE DEALERSHIP DUE TO A LOUD NOISE WHEN TURNING. WAS JUST INFORMED BY DEALERSHIP THAT I NEED A POWER STEERING PUMP, AND RACK AND PINION, BUSHINGS AND BEARINGS. ALSO NEED A NEW RADIATOR. THIS IS RIDICULOUS FOR A BARELY 6 YEAR OLD VEHICLE WITH 70,000 MILES ON IT. I HAVE ALSO HAD THE PROBLEM WITH HEADLIGHT NOT COMING ON WHEN YOU FLIP THE SWITCH. THAT IS A HUGE SAFETY ISSUE! *TR

I OWN 2005 DODGE GRAND CARAVAN. RECENTLY I NOTICED A WHINNING SOUND FROM FRONT END WHEN I TURN THE STEERING WHEEL. ITOOK IT TO AMECHANIC HE SAID I HAD LEAKING STEERING RAIL. I ONLY HAD 60000 MILES IM TOLD THIS RAIL IS SOMETHING THAT SHOULD NEVER HAVE TO BE REPLACED UNLESS OF COURSE ITS DAMAGED BY ACCIDENT. IVE VISITED FORUMS ONLINE AND FOUND THAT LOTS OF OTHER OWNERS OF THIS VAN HAVE PROBLEMS WITH STEERING SYSTEM VIBRATIONS AND LOSS OF POWER ASSIST, JUST AS I HAVE. I DONT THIK THIS IS SAFE. *TR

BOUGHT A USED 2005 GRAND CARAVAN 4 MONTHS AGO. TOOK IT TO THE DEALERSHIP TODAY TO HAVE THE AIRBAG SENSOR REPLACED (RECALL ITEM). THE DEALERSHIP DID A "COURTESY INSPECTION" FOR AND FOUND A LEAK IN THE POWER STEERING RACK, PLAY IN THE LEFT TIE ROD, AND A LEFT FRONT AXLE SEAL. THE VEHICLE ONLY HAS 54,000 MILES ON IT SO THIS SHOULD NOT BE FAILING THIS SOON (AS I SEE IT IS WITH MANY OTHER PEOPLES' VEHICLES). *TR

POWER ASSISTED STEERING RACK ON 2005 DODGE GRAND CARAVAN SXT 3.8L SEALS LEAKING CAUSING POSSIBLE LOSS OF STEERING. *TR

TL*THE CONTACT OWNS 2005 DODGE GRAND CARAVAN. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH ATTEMPTING TO PARK, THE STEERING WHEEL BEGAN TO VIBRATE WHEN MAKING A TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY REPLACED THE STEERING RACK AND THE INNER TIE ROD ENDS. IN ADDITION, ON A DIFFERENT OCCASION THE VEHICLE EXHIBITED AN EXTREMELY LOUD RATTLING NOISE COMING FROM THE FRONT END OF THE VEHICLE AND AN INDEPENDENT MECHANIC REPLACED THE SWAY BAR END LINKS AND BUSHINGS TO CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 42,943. UPDATED 03/16/11 *BF UPDATED 04/27/11

2005 DODGE GRAND CARAVAN FAILING STEERING RACK. *TR

VEHICLE SHUTS DOWN WITHOUT WARNING;POWER DOOR LOCKS INOPERATIVE AT TIMES;PREMATURE FAILURE FRONT STABILIZER BUSHINGS;PREMATURE FAILURE OUTER TIE ROD END. NO REPAIRS MADE BUT ESTIMATES HAVE BEEN OBTAINED. *TR

STARTED HEARING GRINDING NOISE WHEN TURNING SEVERAL MONTHS AGO. DODGE DEALERSHIP DIAGNOSED IT AS FAULTY STRUT AND SPRING AND REPLACED. GRINDING NOISE CONTINUED. NOW, DODGE DEALERSHIP DIAGNOSED AS LEAKING POWER STEERING RACK - WANT $1,100+ TO REPLACE. *TR

2005 DODGE GRAND CARAVAN 3.8 STEERING NOISY AND RACK & PINION LEAKING. HAD TO REPLACE STEERING RACK AND RESERVOIR. $1000 AND ONLY HAD 50000 MILES. HAD IT TO DEALER 2 TIMES FOR STEERING NOISE UNDER 3-36 WARRANTY. *TR

POWER STEERING LEAK , RACK AND PINION 2005 DODGE CARAVAN. *TR

POWER STEERING MAKES GRINDING NOISE. THE NOISE DOESN'T HAPPEN ALL THE TIME USUALLY WHEN DRIVEN ALOT. TOOK IT TO DEALER THEY SAID THEY COULDN'T FIND ANY PROBLEM. I LOOKED ONLINE AND READ THAT THERE ARE MANY COMPLAINTS ABOUT THIS PROBLEM. *TR

TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. WHEN THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR REGULAR MAINTENANCE, IT WAS DISCOVERED THAT THE STEERING WHEEL COLUMN RACK WAS LEAKING POWER STEERING FLUID. THE DEALER ESTIMATED THAT IT WOULD COST $1,000 TO REPLACE THE RACK. THERE WERE NO RECALLS LISTED FOR THE FAILURE. DUE TO THE FACT THAT THE VEHICLE WAS ONE MONTH OUT OF WARRANTY, THE MANUFACTURER WOULD NOT ASSIST WITH THE REPAIRS. THE VIN WAS NOT ACCEPTED BY THE SYSTEM. THE FAILURE AND CURRENT MILEAGES WERE LESS THAN 17,274.

WE HAVE TAKEN OUR 2005 DODGE SXT GRAND CARAVAN IN NUMEROUS TIMES FOR ELECTRICAL PROBLEMS WHICH MOST OF THE TIME THEY CAN NOT DUPLICATE. THEN ON MONDAY MARCH 23 AFTER LEAVING THE CITY AND BRINGING MY CHILDREN HOME FROM SCHOOL I WENT TO MAKE A LEFT HAND TURN AND MY STEERING COLUMN LOCKED UP AND I COULD NOT COMPLETE THE TURN. WITH ONCOMING TRAFFIC AND TRAFFIC BEHIND I HAD NO CHOICE BUT TO GUN THE ENGINE AND GO INTO THE FIELD. I STOPPED THE CAR WITH BRAKES THAT WORKED, AT LEAST, AND TURNED THE VEHICLE OFF. I THEN RESTARTED THE VEHICLE AND THERE WAS COMPLETE FREE PLAY IN THE WHEEL. I TURNED THE WHEEL ALL THE WAY TO THE RIGHT AND THERE WAS A CLUNK AND THEN I AGAIN HAD REGULAR MOVEMENT OF TIRES WITH THE WHEEL. I IMMEDIATELY CALLED MY DEALERSHIP AND TOLD THEM WHAT HAPPENED AND THAT I...

NORMAL DRIVING, VEHICLE HAS BEEN INVOLVED IN NO ACCIDENTS. AT ABOUT 34,000 MILES ON VEHICLE, AND 3 AND A HALF YEARS OLD, AIRBAG LIGHT ON DASH STARTED ILLUMINATING. WOULD TURN OFF SOMETIMES, BUT USUALLY STAYED ON. DEALER DIAGNOSED FAILURE OF "CLOCKSPRING" IN STEERING COLUMN, WHICH HAD TO BE REPLACED AT COST OF ABOUT $250.00. *TR

VAN STARTED TO MAKE A LOUD SOUND FROM THE ENGINE AREA. TOOK THE VAN IN TO SEE WHAT WAS WRONG, FIRST GARAGE COULD NOT IDENTIFY THE PROBLEM IN NOVEMBER. TOOK THE VAN IN AGAIN 12/21/08 AND THEY IDENTIFIED THAT THE RACK AND PINION WAS GOING OUT AND LEAKING FLUID. THAT WAS MAKING THE NOISE. WAS INFORMED THAT THIS IS NOT A COMMON REPAIR AND IT IS UNUSUAL FOR THIS TYPE OF REPAIR TO HAVE TO BE DONE ON A VEHICLE THAT GETS REGULAR MAINTENANCE AND HAS NEVER BEEN IN ANY KIND OF ACCIDENT. THE MECHANIC SAID HE HAD SEEN SEVERAL OF THE SAME VEHICLE WITH SAME PROBLEM. IT APPEARS TO BE A MANUFACTURER DEFECT IN THE BUILD OF THE RACK AND PINION SYSTEM. *TR

BAD NOISES FROM STEERING COLUMN AND RIGHT FRONT SUSPENSION. *TR

RACK AND PINION ON 2005 DODGE CARAVAN - NOTICED MANY OTHERS HAVE SAME COMPLAINT. INTERNAL SEAL ON ASSEMBLY IS WEARING OUT AROUND 65000. MUST REPLACE ENTIRE RACK AND PINION ASSEMBLY. HOW MANY BEFORE RECALL? *TR

I HAVE A 2005 DODGE GRAND CARAVAN AND WHEN I HAVE REACH 35000 MILES I NOTICES THAT MY POWER STEERING FLUID KEPT GET LOW, BUT I COULD NOT FIND ANY LEAKS TO SHOW ME THAT I HAD A PROBLEM. THIS WAS DOING THE WINTER TIME IN OHIO WITH SNOW ON THE GROUND WITH MADE IT EVEN MORE STRANGE THAT I DID NOT SEE ANY OIL LEAK IN THE SNOW SHOWING ME THAT I HAD A PROBLEM. THEN WHEN I REACH 50000 MILE MY BRAKE STARTED SQUEAKING AND I KNEW IT COULD NOT BE MY BRAKE PADS ON THE FRONT BECAUSE THEY HAD BEEN REPLACE ABOUT 18 MONTH BACK. I JUST THOUGHT IT WAS JUST SOME ROAD GRIME THAT MIGHT HAVE GOT ON THE ROTOR. WHEN THE SOUND DID NOT STOP I RECHECK THE PAD TO MAKE SURE THAT THEY WAS STILL GOOD AND THAT WHEN I FOUND OUT THAT MY...

AT ABOUT 12,000 OUR 2005 DODGE GRAND CARAVAN DEVELOPED A THUMPING/BINDING IN THE STEERING/FRONT AXLE. WE HAD IT IN SEVERAL TIMES DURING THE WARRANTY PERIOD FOR THE SAME PROBLEM; BOTH AXLES WERE REPLACED AND THE STEERING COLUMN WAS REPLACED ALSO, YET THE THUMPING/BINDING NEVER TRULY WENT AWAY. SHORTLY OUTSIDE THE COMPREHENSIVE WARRANTY PERIOD, THE RIGHT FRONT AXLE BROKE. FORTUNATELY IT WAS IN A PARKING LOT, NOT ON THE HIGHWAY. THE RIGHT AXLE WAS REPLACED, BUT NOW THE THUMPING/BINDING IS BACK JUST LIKE IT WAS WHEN WE FIRST STARTED PURSUING GETTING THE PROBLEM FIXED. THE VAN ONLY HAS 30,300 MILES ON IT. *TR

FROM THE DAY I DROVE THIS BRAND NEW VEHICLE OFF OF THE DEALERS LOT I BEGAN COMPLAINING ABOUT A NOISE WHEN I TURNED RIGHT. I BROUGHT IT IN SEVERAL TIMES TO HAVE IT CHECKED OUT AND WAS TOLD THAT THEY COULD NOT DUPLICATE THE NOISE SO ALL WAS FINE. EVENTUALLY IT GOT SO BAD THAT THE FRONT END WAS BOUNCING. THEY FINALLY DETERMINED AFTER 22 MONTHS THAT IT WAS A BAD SWAY BAR BUSHING THAT NEEDED TO BE REPLACED. *TR

STEERING RACK RAPIDLY DEGRADED AND "WAS ABOUT TO FALL OUT OF CAR". SEEMS LIKE DODGE MINI-VANS HAVE LOT SOF PROBLEMS WITH THIS. I HAD THIS HAPPENING MY OLD VAN TWICE BUT IT WAS A SLOWER PROGRESSIVE PROBLEM . MY NEW VAN STARTED TO MAKE SOME NOISES ON OCCASION. SHOPS CHECKED IT OUT BUT COULDN'T FIND ANY PROBLEMS.... I CONTINUED TO DRIVE IT... OVER COURSE OF ONE WEEK NOISE INCREASED A BIT AND BROUGHT BACK IN... SHOP'S WORDS " STEERING RACK WAS ABOUT TO FALL OUT".. MANY PEOPLE ARE NOT AS ATTUNE TO NOISES AND SENSATIONS AS I AM. I COULD EASILY SEE SOMEONE ELSE DRIVING WITHOUT DETECTING THIS PROBLEM HAVING A SERIOUS STEERING FAILURE. *TR

EVERY TIME I TOOK MY VAN IN FOR AN OIL CHANGE I WAS TOLD THE POWER STEERING FLUID WAS LOW, OBVIOUSLY DIDN'T THINK MUCH OF IT AT THE TIME. I STARTED HEARING A WHINING SOUND 5,000 MILES AFTER THE WARRANTY WAS UP, TOOK THE VAN IN AND THEY FOUND THE POWER STEERING RACK LEAKING FLUID, RESERVOIR EMPTY AND BLOCKED WITH P/S GEAR REMAINS, AND P/S PUMP NOISY. THEY REPLACED THE P/S GEAR, PUMP, AND RESERVOIR AT MY EXPENSE OF $1200.00. I WOULDN'T THINK THAT A 2005 VAN SHOULD HAVE MAJOR POWER STEERING PROBLEMS AFTER 2 YEARS. I BELIEVE THIS IS A MANUFACTURING PROBLEM. *NM

I PURCHASED A CPO 05 GRD CARAVAN FROM A LOCAL DEALER. WITHIN MONTHS THE ELECTRIC DOOR LOCKS WOULD GO UP AND DOWN WHILE UNLOCKING THE DOORS BY THE KEY, WOULD GO UP AND DOWN WHILE TRAVELING DOWN THE ROAD & WHILE OPENING THE ELECTRIC WINDOWS WHILE INSIDE THE VAN..* * THE STEERING WHEEL WOULD LOCK UP WHILE PULLING OUT ONTO THE ROAD. MY WIFE AND KIDS COULD HAVE BEEN KILLED BY THE APPROACHING FULLY LOADED LOG TRUCK. THE VAN WAS TAKEN TO THE LITHIA IN ROSEBURG & WAS INFORMED OF THE ISSUED. IT WAS INSPECTED AND THE REPLY WAS THAT "THEY COULD NOT FIND ANY PROBLEMS & THEY SAID THEY COULD NOT GET THE DOOR LOCKS TO GO UP AND DOWN. THE VAN WAS TAKEN IN A 2ND TIME ON 07/28/2006 WITH THE SAME ISSUES, AGAIN THEY KEPT THE RIG AND TOLD US THEY COULD NOT GET THE DOOR LOCKS...

SINCE PURCHASING IN 2004. I HAVE HAD TO TAKE BACK THE VAN NUMEROUS TIMES TO COMPLAIN TO THE DEALERSHIP ABOUT NOISES WHILE DRIVING IN THE STEERING BRAKES AND FRONT RIGHT WHEEL BASE AREA. BRAKES POPPING AND SCRUBBING, WHEEL BASE MAKES A SCRUBBING/CRACKING NOISES, AND THERE WAS A WHINING NOISE WHILE SLOWING AT STOPS AND IN PARKING LOTS. THEY HAVE REPLACED A MAP LIGHT. MY SLIDING DOORS HAVE STOPPED WORKING ONCE BUT THE PROBLEM HAS NOT OCCURRED AGAIN TO TAKE TO THE DEALER. AT A RED LIGHT WHEN IT TURNED GREEN I WENT TO GO AND THE ENGINE CUT OFF WOULD NOT RESTART IMMEDIATELY. LUCKILY NO ONE WAS BEHIND ME AND NO ONCOMING TRAFFIC. I WAS ON A HILL AND ABLE TO ROLL TO THE SIDE AND PUT THE VAN BACK IN PARK TO RESTART. 08/11/05 TOOK TO DEALER SHIP AND THEY PERFORMED A COMPUTER FLASH UPDATE AND LISTED A LABEL...