2001 TOYOTA TUNDRA Structurebody Problems

I brought my 2001 Toyota Tundra into my dealer today, and he advised me that the frame of the Toyota is very rusted and cracking and close to completely breaking. He said Toyota issued a recall on this, but it is no longer in effect. I have learned this is a common issue with the 2000-2003 Toyota Tundras. Please advise!

Heavy rust on frame as well as rusting out under support. Causing the bed of the truck to rub on the Cab. Causing the frame to start to bend, I use his vehicle. To transport my special needs child. I’m wondering why, my vehicle? Isn’t covered under the recall ???

The contact owns a 2001 Toyota Tundra. The contact stated that she noticed an unknown part hanging from the vehicle. The contact's son noticed that the cross member had fractured causing the fuel tank to detach. The vehicle was taken to the local dealer where it was diagnosed that the sub frame needed to be replaced. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The failure mileage was approximately 227,780. The contact stated repairs would cost $3800 and up but the contact can not afford the repairs. The contact is requesting further assistance on this matter as she was unable to find resolution.

The contact owns a 2001 Toyota Tundra. The contact stated that the sub frame of the vehicle was severely corroded. The dealer was notified of the failure and advised the contact that they could not repair the vehicle. The manufacturer was notified of the failure and did not provide any assistance. The vehicle was not diagnosed nor repaired. The approximate failure mileage was 115,000.

CHASSIS RUST AND HOLES IN THE FRAME. OBVIOUSLY LARGE RUST HOLES IN THE DIRECTION OF THE FRAME BEHIND THE FRONT DRIVER SIDE WHEEL. FRAME HOLES CAUSE GREAT CONCERN FOR THE OVERALL OPERATIONAL SAFETY OF THE VEHICLE. I CONSIDER THIS DEGREE OF RUST DEGRADATION EXCESSIVE AND A CRAFTSMANSHIP DEFECT. HEAVY STEEL VEHICLE FRAMES SHULD NOT EXHIBIT RUST HOLES TO THIS DEGREE. UPON RECALL NOTICE AND INSPECTION BY TOYOTA, THE VEHICLE RECEIVED A CNC UNDERCOAT TO MUCH OF THE CHASSIS/FRAME AS A MEASURE TO PREVENT FURTHER/FUTURE RUST FORMATION. OBVIOUSLY, THE UNDERCOAT WAS INSUFFICIENT AT PREVENTING FURTHER RUST FORMATION ON THIS PART OF THE FRAME. I DO NOT KNOW EXACTLY WHEN THE RUST HOLES APPEARED. I ENTERED TODAY'S DATE WHEN ANSWERING THE QUESTION OF "WHEN DID THIS HAPPEN", BUT IT IS REASONABLE TO ASSUME THE RUST FORMATION HAS BEEN IN EXISTANCE FOR MANY MONTHS TO YEARS.

MY VEHICLE WAS SUPPOSED TO HAVE BEEN REPAIRED UNDER A PREVIOUS RECALL FOR FRAME RUST, WITH A COATING, BUT IT IS APPARENT THAT TOYOTA DID NOT REPAIR ALL AREA'S AS TODAY DRIVING DOWN THE HIGHWAY MY SHOCKMOUNT COMPLETELY RUSTED AWAY, CAUSING ME TO ALMOST HIT SEVERAL CARS, AND PIECES OF THE MOUNT FLEW BEHIND ME INTO TRAFFIC. FROM THE OUTSIDE THIS TRUCK LOOKS TO BE IN EXCELLENT SHAPE, HOWEVER THE TOW DRIVER LOOKED UNDERNEATH AND SAID HE COULD NOT BELIEVE THE RUST DAMAGE. MY VEHICLE HAS NOW BEEN DEEMED UNSAFE AND NOT ROADWORTHY. MY FEAR IS HOW MANY UNSUSPECTING OWNERS ARE THERE THAT THOUGHT THE RECALL REPAIRS WERE DONE CORRECTLY, AND COULD HAVE AN ACCIDENT THAT COULD LEAD TO SERIOUS INJURY OR DEATH IF THESE GO UNTREATED, REPAIRED OR REPLACED. I WAS DRIVING ON THE MAIN OUTERBELT FREEWAY IN COLUMBUS, I-270 AT 60-65 MPH WHEN THE PART CAME OFF.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE AT AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED THAT THE FRAME WAS RUSTED. THE CONTACT STATED THAT THE BRAKES AND POWER STEERING RACK WERE RUSTED BEFORE AND PREVIOUSLY REPAIRED. THE CONTACT CALLED LIA TOYOTA OF NORTHAMPTON (LOCATED AT 280 KING ST, NORTHAMPTON, MA 01060, (413) 341-5299) AND INFORMED THEM OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 135,000.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE VEHICLE WAS TAKEN TO DUNNING TOYOTA (877-356-9318, LOCATED AT 3745 JACKSON RD, ANN ARBOR, MI 48103) WHERE IT WAS STATED THAT THE VEHICLE WAS TOO DANGEROUS TO BE REPAIRED DUE TO EXCESSIVE CORROSION. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND STATED THAT THE DEALER WOULD NOT BE FORCED TO REPAIR THE VEHICLE IF THE VEHICLE WERE FOUND TO BE UNSAFE TO BE REPAIRED OR DRIVEN. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 260,000.

HI, I HAVE A 2001 TUNDRA THAT THE FRAME IS SHOT ON. I HAVE FIXED IT A FEW TIMES TO TRY TO KEEP IT ON THE ROAD BUT IT JUST KEEPS GETTING WORSE AND WORSE. ITS TO THE POINT WHERE I FEEL ITS NOT SAFE TO DRIVE ANYMORE BUT TOYOTA REFUSES TO FIX IT. THEY SAY IT DOESN'T QUALIFY FOR THEIR FRAME RECALL. I FIND THIS HARD TO BELIEVE BEINGS THEY HAVE REPLACED THOUSANDS OF FRAMES FOR CORROSION SO CLEARLY THEY KNOW ITS AN ISSUE BUT YET MINE DOESN'T QUALIFY. THE FRAME RUSTED COMPLETELY IN HALF BEHIND THE CAB AND I WELDED IN A STEEL PLATE SO I COULD DRIVE IT AGAIN. IT ALSO HAS LARGE HOLES IN VARIOUS OTHER LOCATIONS OF THE FRAME AS WELL. THIS IS A BIT RIDICULOUS AS THE TRUCK ONLY HAS 135K MILES ON IT.

BOUGHT TRUCK NEW IN 8/2001. BROUGHT TRUCK TO DEALER WHEN IT WAS RECALLED FOR RUST IN 2012 AND WAS TOLD RUST WASN'T BAD ENOUGH TO DO ANYTHING. BROUGHT TRUCK BACK TO DEALER MULTIPLE TIMES AFTER 2012 (LAST IN 11/18) AND WAS TOLD EVERYTHING WAS FINE ON EACH OCCASION. IN 8/2019 I HEARD A SQUEAK FROM UNDERCARRIAGE AND WHEN I LOOKED, THE SPARE TIRE CROSSMEMBER WAS HANGING DOWN AND THE RIGHT SIDE UPPER SHOCK MOUNT WAS COMPLETELY RUSTED THROUGH AND THE TOP OF THE SHOCK WAS RUBBING AGAINST THE BOTTOM OF THE TRUCK BED (TOP SHOCK MOUNT WAS COMPLETELY RUSTED AWAY). LOCAL SERVICE CENTER TOLD ME TO REMOVE THE SHOCK AND SPARE TIRE FOR SAFETY. THIS RUST IS LIMITED TO THE UPPER SHOCK MOUNT AND THE CROSSMEMBER HOLDING THE SPARE TIRE. OTHER CROSSMEMBERS AND FRAME RAILS ARE ALL STABLE WITH ONLY THE AMOUNT OF SURFACE RUST EXPECTED ON A 18 YEAR...

THERE WAS A SAFETY RECALL ISSUED FOR CORROSION/RUSTED FRAMES ON 2000-2001 TOYOTA TUNDRAS IN WHAT TOYOTA DEFINED AS SEVERE COLD WEATHER STATES. IOWA WAS NOT INCLUDED. WHY? WE HAVE A 2001 TOYOTA TUNDRA WITH ONLY 120,000+MILES ON IT THAT NOW HAS A RUSTED OUT WHOLE THE SIZE OF MY FIST IN ITS FRAME. I DO NOT HAVE A PHOTO TO ATTACH, BUT CAN GET ONE IF NEED BE. WE'VE TALKED TO THE DEALER AND TOYOTA CUSTOMER SERVICE, THEY WON'T DO ANYTHING ABOUT IT. TOYOTA CUSTOMER SERVICE LOOKED UP THE VIN AND SAID IT WASN'T PART OF THE RECALL. WHY? IOWA IS A COLD WEATHER STATE! THIS TRUCK CAME THRU PRINCETON IN. HOW COME TOYOTA GETS TO DECIDE WHAT STATES THE RECALL APPLIES TO? ACCORDING TO THE TUNDRA RECALL BLOG, HTTPS://WWW.TUNDRAS.COM/THREADS/2000-TUNDRA-FRAME-REPLACEMENT.7215/, THEY ARE STILL FIXING TRUCKS IN NEW YORK AS OF 2018. DOESN'T IOWA COUNT? HOW MANY OTHER TRUCKS ARE OUT...

VEHICLE FRAME HAS SUFFICIENT RUST INCLUDING HOLES IN THE FRAME. THERE WERE TWO RECALLS DEALING WITH THIS RUST ISSUE, NEITHER FIXED THE PROBLEM. THIS HAS BEEN AN ON GOING ISSUE FOR TOYOTA INCLUDING CLASS ACTION LAWSUITS - BUT THOSE DIDN'T INCLUDE 2001 TUNDRA. I HAVE CONTACTED THE DEALERSHIP WHERE PURCHASED NEW, THE DEALERSHIP THAT UNDERCOATED OVER TOP OF THE RUST (SECOND RECALL - HAD THERE BEEN HOLES IN THE FRAME 10MM OR LARGE, THEY SAID THEY WOULD HAVE REPLACED THE FRAME AT THAT TIME. BUT THEY WERE NOT ALLOWED TO BEAD BLAST OR WIRE BRUSH WHICH MOST LIKELY WERE HAVE PRODUCTS SEVERAL HOLE GREATER THEN 10MM), AND TOYOTA HEADQUARTERS. BECAUSE THE RECALLS WERE CLOSED, THEY ALL SAID THERE IS NOTHING THEY ARE WILLING TO DO. THE VEHICLE IS NOT SAFE TO DRIVE AND FRAME REPLACEMENT IS ESTIMATED TO BE $15,000 WHICH IS MORE THEN THE VEHICLE IS WORTH. I ALSO...

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. UPON INSPECTION, IT WAS DISCOVERED THAT THE SUBFRAME SUSTAINED SEVERE RUSTING AND CORROSION. THE VEHICLE WAS TAKEN TO CURRY TOYOTA (832 STRAITS TURNPIKE, WATERTOWN, CT) WHO CONFIRMED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). DUE TO THE SEVERE RUSTING OF THE SUBFRAME, THE RECALL REMEDY COULD NOT BE PERFORMED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 102,000.

I HAVE ONLY OWNED THIS VEHICLE FOR 6 MONTHS. ON 8/18/18 THE CONTROL ARM ON THE PASSENGER SIDE FELL OFF, I HAD THE TRUCK TOWED BY AAA TO A LOCAL REPAIR SHOP. AFTER EXAMINING THE VEHICLE, THE MECHANIC STATED THAT THE DRIVER SIDE CONTROL ARM WAS ALSO READY TO FALL OFF BUT THE BIGGER PROBLEM IS THAT THE FRAME IS ROTTED, HOLES EVERYWHERE AND THE VEHICLE IS NOT SAFE TO DRIVE. I INQUIRED AT LYNCH TOYOTA ABOUT A REMEDY THROUGH THE FRAME RECALL AND THEY INFORMED ME THAT THERE WAS A PREVENTION SPRAY DONE IN 2014 AT WESTBROOK TOYOTA - WHICH MAKES THIS WORSE, BECAUSE THERE SHOULDN'T BE ANY ROT/CORROSION IF THE SPRAY WAS EFFECTIVE. I CALLED TOYOTA CORPORATE TO ASK ABOUT A REMEDY AND THEY REFUSED, STATING THAT A GUARANTEE OF THE SPRAY WAS ONLY FOR 12 MONTHS AFTER THE (INEFFECTIVE) SPRAY WAS APPLIED AND AFTER THAT THE CUSTOMER...

MY 2001 TOYOTA TUNDDA WAS PART OF THE FRAME SERVICE CAMPAIGN. UPON RECEIVING NOTICE I IMMEDIATELY SCHEDULED AN INSPECTION AND MY FRAME WAS COATED IN THE PROTECTIVE COATING SUPPLIED BY TOYOTA AT THE TOYOTA DEALER I PURCHASED THE TRUCK FROM. IN THE YEARS TO COME THAT COATING WOULD FALL OFF AND MY TRUCK FRAME WOULD CONTINUE TO RUST. IN AUGUST OF 2018 I TOOK IT TO MY LOCAL TOYOTA DEALER FOR INSPECTION WHO SAID A HOLE HAS RUSTED IN THE FRAME NEAR THE GAS TANK. THEY ALSO INFORMED ME THAT TOYOTA WILL NOT DO ANYTHING TO CORRECT HER PROBLEM SINCE THE PROGRAM HAD EXPIRED. I RECEIVED THIS SAME INFORMATION FROM THE DEALER I BOUGHT IT FROM AND TOYOTA CORPORATE. IN ADDITION TO THE HOLE IN THE FRAME BOTH POWER STEERING LINES RUSTED THROUGH AND SO DID THE POWER STEERING RACK. TOYOTA'S ATTEMPT AT FIXING THE PROBLEM FAILED AND NOW I'M...

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE CHECKING UNDERNEATH THE VEHICLE, THE CONTACT NOTICED SEVERE RUST WHERE THE LEAF SPRING SHACKLES WERE LOCATED NEAR THE FUEL TANK. THE CONTACT DROVE THE VEHICLE TO TANSKY MOTORS TOYOTA IN LOGAN, OHIO AND WAS ADVISED NOT TO HAUL ANYTHING ON THE VEHICLE BECAUSE THE FRAME COULD FRACTURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT STATED THAT THE MANUFACTURER SENT A NOTIFICATION TO HAVE THE VEHICLE EVALUATED AT DON WOODS TOYOTA IN ATHENS, OHIO. THE DON WOODS DEALER DETERMINED THAT THE FRAME WAS OK. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 177,000. ...UPDATED 10/19/17 *BF THE CONSUMER STATED THE DEALER RUST PROOFED THE VEHICLE. UPDATED 10/26/2017*JS

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE THE VEHICLE WAS STATIONARY, IT BECAME RUSTED AND SEVERELY CORRODED. THE VEHICLE WAS TAKEN TO TNC TOYOTA OF MARIETTA, OHIO WHERE IT WAS TREATED FOR RUST AND CORROSION WITH A SPRAY COATING PER A RECALL. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN. UPDATED 08/22/17*LJ THE CONSUMER STATED AFTER THE VEHICLE WAS REPAIRED THE CORROSION WORSENED. THE DEALER STATED SINCE THE CONSUMER SIGNED THE COMPLETED REPAIR ORDER THE WOULD NOT BE ABLE TO ASSIST WITH THE REPAIR. UPDATED 08/28/2017*JS

LOWER DRIVERS SIDE BALL JOINT POPPED OUT GOING DOWN HYWAY. TIRE ENDED UP COLLAPSING IN ON DRIVERS FENDER DOOR AND BROKE CV SHAFT AND TWISTED A ARMS. VERY DANGEROUS. NO PRIOR SIGN OF CLUNKING OR POPPING.

I WAS DRIVING IN A TOYOTA TUNDRA 2001 WITH MY PREGNANT WIFE AND TWO GOATS IN THE BED, WHEN I DROVE OVER A SMALL BUMP BY A LITTLE BRIDGE WHEN I HEARD A NOISE AND LOST CONTROL OFF THE TRUCK ALMOST HITTING A TREE. I WAS WITHIN A HALF MILE FROM MY HOME SO WHEN I GOT HOME I INSPECTED THE TRUCK TO FIND OUT THE LOWER CONTROL ARM BROKE OFF . IF YOU DRIVE THE TRUCK NOW IT WILL PULL THE TRUCK HARD TO THE LEFT AND IT FEELS LIKE ITS ABOUT TO FALL APART. TOYOTA ALSO HAD A SO CALLED RECALL ON THE FRAMES BUT, EVEN STILL THE FRAME IS IN TERRIBLE CONDITION AND THEY REFUSE TO HELP . IM MOST PISSED BECAUSE THIS HAPPENED WHILE MY WIFE WAS IN THE TRUCK AND WE ALREADY LOST ONE CHILD TOGETHER.

TRUCK HAS RUSTED HOLES IN FRAME. REPORTED TO TOYOTA, WAS TOLD IT WAS LOOKED PREVIOUSLY, NO LONGER UNDER RECALL. FOUND OUT LATER WAS DENIED FRAME REPLACEMENT TO PREVIOUS OWNER WHILE STILL UNDER RECALL.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE HAVING THE VEHICLE INSPECTED FOR A MANDATORY ANNUAL STATE INSPECTION, THE VEHICLE FAILED DUE TO CORROSION OF THE SUBFRAME. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CORROSION WOULD HAVE TO BE WELDED. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS PREVIOUSLY SERVICED PER NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE CONTACT MENTIONED THAT THE CORROSION PROTECTION COMPOUND WAS NOT AN ADEQUATE PREVENTIVE MEASURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

I CONTACTED TOYOTA ABOUT RUSTING OF MY 2001 TUNDRA WITH 137000 MILES ON IT. THERE ARE HOLES THAT YOU CAN PUT YOUR THUMB THROUGH IN THE FRAME. TOYOTA SAID THERE WAS A LIMITED RECALL AND IT HAS EXPIRED. WHY IS THIS NOT A SAFETY RECALL? IS THERE ANY RECOURSE HERE?

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT OBSERVED THAT THE FRONT PASSENGER SIDE FRAME WAS DETERIORATED AND RUSTED OUT A TWO INCH CIRCUMFERENCE HOLE. THE VEHICLE WAS SERVICED PER NHTSA CAMPAIGN NUMBER: 12V345000 (STRUCTURE:BODY), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. INSTEAD OF THE FRAME BEING REPLACED, THE CONTACT STATED THAT IT WAS SPRAYED PREVIOUSLY WITH A COMPOUND. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 113,000.

THERE WAS A RECALL ON 2000- 2003 TUNDRA FRAMES & BRAKE LINES I CONTACTED TOYOTA THAT FRAME WAS RUSTED & UNSAFE . TOYOTA FIRST ASKED IF I WANTED A BUY BACK OR A REPLACEMENT ON FRAME OF TRUCK . I ASKED FOR FURTHER DETAILS ON BOTH , THEY TAKE ALL MY INFORMATION & OPENED A CASE WITH # [XXX] THEY INFORMED ME A CASE MANAGER WOULD BE IN CONTACT WITH ME . WITHIN 72 HOURS I WAS CONTACTED BY CASE MANAGER [XXX] CAPTAIN WHO INFORMED ME THAT THE FRAME WAS TREATED WITH CORROSION RESISTANT COMPOUND & THERE WAS NOTHING ELSE TOYOTA WOULD DO FOR ME . I DON'T UNDERSTAND HOW THEY CAN SAY THEY TREATED THE FRAME & ITS ROTTED OUT ! THERE IS NO RUST ON ANY OF THE BODY PARTS OF THIS TRUCK . NOW I HAVE A TRUCK WITH A GOOD BODY , MOTOR , & TRANS...

SUMMARY: PURCHASED 2001 TOYOTA TUNDRA IN APRIL 2015 FROM FAULKNER BUICK GMC OF WEST CHESTER PA.APRIL 2015 THE DEALER PASSED INSPECTION WHILE ACTIVE RECALLS ON FRAME CORROSION WERE NOT COMPLETE,CORRODED FRAME PRESENT.PER CURRENT INSPECTION FAIL-3-2016-THIS SHOULD NEVER HAVE BEEN PASSED IN 2015 BY DEALER. FAULKNER BUICK GMC OF WEST CHESTER PA, 705 AUTOPARK BLVD,WEST CHESTER, PA 19382 1.THE PRIOR USED CAR DEALER PASSED INSPECTION 2015,SHOULD HAVE FAILED FOR ROTTED FRAME (LEGAL ISSUE);2.PRIOR OWNER,USED CAR DEALER-IGNORED ALL PAST/CURRENT FRAME RECALLS;3.PURCHASED TRUCK 4-2015;4.FAIL INSPECTION-ROTTED FRAME 3-2016;5. TRICOUNTY TOYOTA,LIMERICK, PA,3/15/16 - THEY TOLD MY SON ITS NOT ROTTED ENOUGH, DRIVE A FEW MONTHS AND SEE IF ITS WORSE (EVEN THOUGH THERE IS AN ACTIVE RECALL NOW.;6.WENT TO CONICELLI TOYOTA - CONSHOHOCKEN,PA MARCH17, 2016 - VERY HELPFUL IN TESTING THE CORROSION, THEY AGREE ITS ROTTED THRU, NO WAY TO FIX OTHER THAN COMPLETE REPLACEMENT OF FRAME, SEVERAL TESTS AND PICS GIVEN TO TOYOTA "FIELD...

PURCHASED 2001 TOYOTA TUNDRA IN APRIL 2015 FROM FAULKNER BUICK GMC OF WEST CHESTER PA.APRIL 2015 THE DEALER PASSED INSPECTION WHILE ACTIVE RECALLS ON FRAME CORROSION WERE NOT COMPLETE,CORRODED FRAME PRESENT.PER CURRENT INSPECTION FAIL-3-2016-THIS SHOULD NEVER HAVE BEEN PASSED IN 2015 BY DEALER. FAULKNER BUICK GMC OF WEST CHESTER PA, 705 AUTOPARK BLVD,WEST CHESTER, PA 19382 1.THE PRIOR USED CAR DEALER PASSED INSPECTION 2015,SHOULD HAVE FAILED FOR ROTTED FRAME (LEGAL ISSUE);2.PRIOR OWNER,USED CAR DEALER-IGNORED ALL PAST/CURRENT FRAME RECALLS;3.PURCHASED TRUCK 4-2015;4.FAIL INSPECTION-ROTTED FRAME 3-2016;5. TRICOUNTY TOYOTA,LIMERICK, PA,3/15/16 - THEY TOLD MY SON ITS NOT ROTTED ENOUGH, DRIVE A FEW MONTHS AND SEE IF ITS WORSE (EVEN THOUGH THERE IS AN ACTIVE RECALL NOW.;6.WENT TO CONICELLI TOYOTA - CONSHOHOCKEN,PA MARCH17, 2016 - VERY HELPFUL IN TESTING THE CORROSION, THEY AGREE ITS ROTTED THRU, NO WAY TO FIX OTHER THAN COMPLETE REPLACEMENT OF FRAME, SEVERAL TESTS AND PICS GIVEN TO TOYOTA "FIELD REP."...

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRAME WAS RUSTED OUT WITHOUT WARNING. THE DEALER REPAIRED THE VEHICLE FOUR YEARS AGO AND STATED THAT NOTHING COULD BE DONE FOR THE RECENT FAILURE. THE MANUFACTURER STATED THAT THE FRAME WAS ALREADY SPRAYED, SO NOTHING COULD BE DONE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000.

IN 2010 TOYOTA HAD A RECALL ON THE FRAME AND SPARE TIRE HOLDER RESULTING IN THE SPARE TIRE COMING OFF AND CAUSING ACCIDENTS. I WAS NOTIFIED BY MAIL TO GET THE FRAME/CROSS MEMBER CHECKED BY THE CLOSEST DEALER POSSIBLE. SO I SET UP AN APPOINTMENT WITH JOHNSON CITY TOYOTA IN TENNESSEE AND WHEN THE PART WOULD ARRIVE THEY WOULD CALL ME. I NEVER GOT THE PHONE CALL SO AFTER TWO MONTHS OF WAITING I CALLED THE DEALERSHIP AND THEY HAD TOLD ME THE RECALL HAS EXPIRED AND I'M OUT OF LUCK. I HAD BOUGHT THE 2001 TUNDRA IN JULY 11, 2011 SO I REALLY DIDN'T HAVE MUCH TIME FROM THE GET GO AND WASN'T TOLD ABOUT THE RECALL WHEN I BOUGHT THE TRUCK FROM AN INDIVIDUAL SELLER,"MIGHT FAULT" FOR NOT GOING OVER THE WHOLE THING ANYWAY, BUT MY PROBLEM IS THAT THE FRAME AND THE SPARE TIRE HOLDER IS AN...

ADDENDUM TO REFERENCE NUMBER 10785255 ON 1/7/16, CHRIS ADAMOS [OPERATIONS MANAGER] CALLED FROM TOYOTA HEADQUARTERS DUE TO MY ONGOING CONCERNS OFT RUST PERFORATION COMPROMISING MY FRAME, MAKING IT UNSAFE. I EXPLAINED THAT I AM CONCERNED THAT 1) THE CRC INTERVENTION [PROPOSED BY TOYOTA] DID NOT REMEDY A PROBLEM [THAT HAD BEEN IDENTIFIED BY TOYOTA], 2) THUS THE PROBLEM REMAINS UNRESOLVED, AND 3) SAFETY ISSUES CONTINUE TO EXIST AND THAT THE FRAME IS ACTUALLY WORSE THAN IT HAD BEEN WHEN INSPECTED IN 2012. CHRIS STATED, 'THE CRC WAS NOT MEANT TO REMEDY THE PROBLEM, IT WAS MEANT TO MITIGATE THE PROBLEM.' HE EXPLAINED THAT, WHEN THE 2012 RECALL INSPECTIONS OCCURRED, 'IF A FRAME WAS PERFORATED, IT WAS REPLACED. IF THERE WAS NO PERFORATION, THE CRC WOULD BE APPLIED AND THAT MAY HELP FOR 6 MONTHS, A YEAR, OR 3 YEARS IN YOUR CASE, BUT IT WAS APPLIED WITH THE THOUGHT THAT...

THE FRAME ON MY 2001 TOYOTA TUNDRA WAS COATED WITH A CORROSIVE RESISTANT COMPOUND [CRC] PER BILL KIDD TOYOTA DEALER IN 2012 DUE TO "SAFETY RECALL BOD & 90M & SERVICE CAMPAIGN AOF." IN 2015, PRIORITY TOYOTA [VA] STATED MY FRAME HAD RUST PERFORATIONS & NEEDED A FULL FRAME REPLACEMENT. PRIORITY TOLD ME TO CONTACT TOYOTA HEADQUARTERS ASAP TO EXPLAIN THE DANGEROUSNESS OF THE VEHICLE'S COMPROMISED STRUCTURE. MY CASE MANAGER AT HEADQUARTERS, AUTUMN, & ANOTHER REPRESENTATIVE [ERICA] INFORMED ME THAT TOYOTA WON'T OFFER AN OUT OF WARRANTY ASSISTANCE NOR A "GOOD WILL GESTURE." BOTH EXPLAINED THAT HEADQUARTERS HAS APPROVED FRAME REPLACEMENTS AFTER THE SERVICE CAMPAIGN'S EXPIRATION BASED ON THE FOLLOWING: REPAIR COSTS [I WAS TOLD REPAIRS ON MY TUNDRA WERE CONSIDERED 'EXTENSIVE,'] AGE/MILEAGE, CUSTOMER LOYALTY AND SERVICE RECORDS. I WAS DENIED A FULL FRAME REPLACEMENT; HOWEVER, I'M IN CONTACT WITH ANOTHER TOY CONSUMER WHO EXPERIENCED A SIMILAR ISSUE WITH A...

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRAME WAS COMPLETELY CORRODED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE AND DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFUSED TO PROVIDE ANY ASSISTANCE OR APPROVE THE FRAME REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 170,000. UPDATED 02/10/16*LJ ...UPDATED 02/19/16 *BF CONSUMER TOOK THE VEHICLE TO DEALER (4/19/12) UPDATED 05/18/18*JB

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. WHILE DRIVING AT AN UNKNOWN SPEED, AN ABNORMAL BANGING NOISE EMITTED FROM THE REAR OF THE VEHICLE. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE REAR CROSS MEMBER WAS COMPLETELY CORRODED AND THE REAR SHOCK WAS FRACTURED. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY SERVICED UNDER AN UNKNOWN MANUFACTURER CUSTOMER SATISFACTION CAMPAIGN IN WHICH THE VEHICLE WAS TREATED FOR RUST. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 164,000.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE REAR DRIVER SIDE SUBFRAME PERFORATED DUE TO EXCESSIVE CORROSION. IN 2012, THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V444000 (SUSPENSION); HOWEVER, THE FAILURE RECURRED. THE REMEDY CONSISTED OF SPRAYING A CORROSION PROTECTOR ONTO THE ENTIRE FRAME, WHICH FAILED TO PREVENT THE SUBFRAME CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 370,000.

I PURCHASED THE VEHICLE IN OCTOBER 2014 AND WAS INFORMED ABOUT A FRAME CORROSION ISSUE CAUSING FAILURES AND FAILURE TO PASS VT STATE INSPECTIONS BY A FAMILY FRIEND IN JANUARY. I CONTACTED TOYOTA AND PROVIDED [XXX], THE CUSTOMER SERVICE REPRESENTATIVE WITH ALL VIN INFORMATION. HE LOOKED UP SERVICE RECORDS AND INFORMED ME THAT THE VEHICLE HAD A CORROSION APPLICATION APPLIED IN 2010 UNDER THE PREVIOUS OWNER AND THERE WAS NOTHING FURTHER REQUIRED. UNDER THE RECALL ACTION THAT WAS ALL REQUIRED BASED I MY VIN NUMBER. I DID ASK IF IT HAD ISSUES DISCOVERED WHAT WAS I TO DO, [XXX] TOLD ME TO CONTACT TOYOTA AGAIN IF THAT OCCURRED. I TOOK THE VEHICLE TO BE INSPECTED ON 27 MARCH, 2015 AT GROTON GARAGE, IN GROTON VT AND THE OWNER [XXX]. CONTACTED ME TO INFORM ME THAT IT COULD NOT BE INSPECTED DUE TO MULTIPLE FRAME CORROSION ISSUES THAT ARE FAILURES. HE...

TL*THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE) AND THE DEALER SPRAYED THE CROSS MEMBER WITH A CORROSION PROTECTION COMPOUND. THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH, THE SPARE TIRE DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE THEY REFUSED TO REPAIR THE VEHICLE UNDER THE RECALL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS REPAIRED. THE DETAILS OF THE REPAIRS WERE UNAVAILABLE. THE FAILURE MILEAGE WAS 180,000.

SPARE TIRE HOLDER RUSTED & SPARE TIRE FLEW OFF INTO TRAFFIC. THIS IS A SAFETY ISSUE. *TR

YOU MIGHT BE CURIOUS TO KNOW THAT THE FRAME RECALL THAT TOYOTA HAD AND THAT ENDED IN 2012 IS RECURRING ON THE TOYOTAS AGAIN. I HAD MINE CHECKED IN 2012 AND WAS TOLD IT WAS FINE BUT THEY WERE GOING TO UNDER COAT IT IN ORDER TO PREVENT IT FROM HAPPENING IN THE FUTURE. I WENT TO HAVE IT INSPECTED LAST WEEK FOR THEM TO TELL ME THAT THE FRAME IS SOFT AND RUSTED THROUGH WITH A HOLE, IN THE EXACT SPOT THE RECALL WAS REFERRING TO. I BROUGHT IT TO THE TOYOTA DEALERSHIP WHO DID THE UNDER COATING TO BEGIN WITH JUST FOR THEM TO CONFIRM THAT THE HOLE WAS THERE, THE RUST WAS OCCURRING BUT THE RECALL HAD ENDED IN 2012 AND THEY CAN NO LONGER HELP US. IN TURN THEY TOLD US TO CONTACT TOYOTA CORPORATION, WHICH WE DID, AND THEY TOLD US THEY CAN NOT HELP...

ON 11//18/0/01IRC'D A RECALL FOR EXCESSIVE CORROSION OF THE REAR CROSS MEMBER. IN 10/2012,I WAS INFORMED THAT THE TRUCK FRAME PASSED INSPECTION AND WAS GOOD.THEY DID REPLACE TWO GAS TANK STRAPS AND TOLD ME THE UNDERCOATING THAT SHOULD BE SPRAYED ON IT AS PART OF THE RECALL WAS NOT AVAILABLE.I NEVER RECEIVED ANY ADDITION CORRESPONDENCE REGARDING THE UNDERCOATING.ON 12/23,14 I TOOK MY TRUCK TO TJ TOYOTA FOR A TRAILER LIGHT WHIP REPAIR. AT THAT TIME, THE MECHANIC HAD ME LOOK AT THE FRAME RAIL.IT IS RUSTED SO BAD I COULD SEE RIGHT THROUGH THE RAIL.THE CONNECTION OF THIS RAIL TO THE FRAME HAS EXCESSIVE SCALING.THE TRUCK WAS DUE FOR AN INSPECTION AT THE END OF THE MONTH, AND I WAS TOLD THEY WOULD NOT DO AN INSPECTION.THE MECHANIC CONTINUED TO TELL ME HE FELT THE TRUCK WAS "JUNK" UNSUITABLE FOR TOWING ANYTHING.I CALLED 1-800-331-4331 AT TOYOTA AND SPOKE WITH [XXX],...

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT IN JANUARY 2012 THE VEHICLE WAS TAKEN TO THE DEALER TO BE INSPECTED FOR FRAME CORROSION. AFTER INSPECTING THE VEHICLE THE MECHANIC DETERMINED THAT THE FRAME DID NOT NEED TO BE REPAIRED OR REPLACED AND SPRAYED THE FRAME WITH AN ANTI CORROSION SUBSTANCE CRC. IN OCTOBER 2014 THE VEHICLE FAILED AN INSPECTION DUE TO A PERFORATED SUB FRAME CAUSED BY CORROSION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN NUMBER WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 187,000.

I PURCHASED A 2001 TOYOTA TUNDRA EXTENDED CAB PICK UP TRUCK NEW IN FEB. 2001. THE VEHICLE WAS SERVICED AT A TOYOTA DEALERSHIP FOR YEARS. ON DEC. 11, 2011 I RECEIVED A RECALL NOTICE FROM TOYOTA (SSC 90M) REGARDING SEVERE CORROSION OF THE REAR CROSS-MEMBER. ON FEB. 18, 2012 THE TRUCK WAS SERVICED AT KOONS TOYOTA IN WESTMINSTER, MD. AT THAT TIME AN INSPECTION WAS COMPLETED AND THE PAPER WORK I WAS GIVEN INDICATED THE FOLLOWING; "INSPECT, REMOVE RUST & CLEAN FRAME, NO RUST EX SPEC, APPLY CRC. THE TRUCK WAS BACK AT THE SAME DEALERSHIP IN 2013 FOR A ROUTINE OIL CHANGE AND NO MENTION OF RUST WAS MADE BY THE SERVICE DEPARTMENT. IN OCT. 2014 THE VEHICLE WAS SERVICED AT A CERTIFIED AUTOMOBILE REPAIR STATION. AT THIS TIME I WAS INFORMED THE MECHANIC THAT MY FRAME WAS BADLY RUSTED. I HAVE CONTACTED TOYOTA AND THEY WILL ONLY SAY...

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THE FRAME WAS CORRODED AND CAUSED THE PROTECTIVE COATING TO CHIP OFF. THE CONTACT MENTIONED THAT THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE). HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 122,000. UPDATED 01/07/14*LJ THE CONSUMER STTED THE VEHICLE WAS TAKEN TO A MECHANIC HWO ADVISED THE FAILURE WAS DUE TO RUST JACKING. THE MACHANIC SUGGESTED THE VEHICLE BE TAKEN TO THE DEALER. THE DEALER STATED THERE WERE NO RUST HOLES. UPDATED 6/8/2015 *JS

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 09V444000 (STRUCTURE) AND TOOK THE VEHICLE TO THE DEALER FOR RECALL SERVICE. MONTHS LATER, THE VEHICLE BEGAN TO EXHIBIT SIGNS OF RUSTING. THE CONTACT HAD NOT ENCOUNTERED ANY ISSUES PRIOR TO HAVING THE RECALL SERVICE PERFORMED. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 180,968.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE SPARE TIRE BECAME DETACHED FROM THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V444000 (STRUCTURE) AND THE RECALL REPAIR WAS PERFORMED HOWEVER, THE DEALER WOULD NOT COVER THE REPLACEMENT OF THE CROSS MEMBER THAT HELD THE SPARE TIRE IN PLACE. THE APPROXIMATE FAILURE MILEAGE WAS 217,000.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT STATED THAT THERE WAS CORROSION AND RUST ON THE FRAME, REAR AXLE AND BRAKE SYSTEM. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 09V444000 (STRUCTURE: FRAME AND MEMBERS: UNDERBODY SHIELDS). THE VEHICLE WAS TAKEN TO DEALER WHERE THE CONTACT WAS ADVISED THAT THE RECALL REPAIRS COULD NOT BE PERFOMRED DUE TO THE STATE IN WHICH THE VHEICLE WAS HOUSED. THE DEALER THEN ADVISED THAT THERE WERE NO HOLES IN THE FRAME THAT WOULD REQUIRE IMMEDIATE ATTENTION. THE BUMPER, GRILL, HOOD AND FENDER WERE REPLACED. THE CURRENT AND FAILURE MILEAGE WAS 90,000.

TL* THE CONTACT OWNS A 2001 TOYOTA TUNDRA. THE CONTACT MADE AN APPOINTMENT TO HAVE THE VEHICLE REPAIRED UNDER THE NHTSA CAMPAIGN ID NUMBER: 09V444000 (STRUCTURE: FRAME AND MEMBERS:UNDER BODY SHIELDS) RECALL. THE CONTACT RECEIVED A VOICE MAIL MESSAGE FROM THE DEALER STATING THAT THE APPOINTMENT WAS CANCELLED AND THEY WERE UNABLE TO ASSIST HIM AT THIS TIME, WITHOUT GIVING AN EXPLANATION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND A COMPLAINT WAS FILED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 160,000.

NOTICED OIL IN DRIVE WAY LOOKED UNDER TRUCK AND NOTICE MY STEERING RACK WAS LEAKING AND STABILIZER LINKS WERE RUSTED OFF. TOOK TO MECHANIC FOR REPAIRS AND HE INFORMED ME MY WHOLE EXHAUST WAS RUSTED AS WELL AS THE BODY. TOOK TO A TOYOTA DEALERSHIP BACK IN 2009 FOR BODY RUST RECALL AND WAS TOLD IT WAS OK. I NOW NO THAT WAS NOT TRUE. *TR

THE REAR SECTION OF THE FRAME IS SEVERELY RUSTED. THE FLOOR OF THE TRUCK BOX HAS SEVERAL LARGE HOLES THAT ARE RUSTED CLEAR THROUGH THE FLOOR. *TR

2001 TOYOTA TUNDRA ISSUES - AFTER SEEING THE LATEST REPORT ON TUNDRAS, I FELT IT WAS NECESSARY TO FILE A COMPLAINT. MY TRUCK HAS HAD NUMEROUS ITEMS CRACK ON IT STARTING AROUND THE 85K MILE RANGE. FIRST THE MANIFOLDS, THEN THE LEAF SPRINGS, LEAKING FRONT CALIPERS. WE NOTIFIED TOYOTA WHEN ALL THESE ISSUES HAPPENED BECAUSE THE REPAIR COSTS WERE GOING TO BE 3,000. THEY SENT US A CHECK AT ONE POINT FOR $500 TO BE USED AT THE DEALER. NOW I AM GOING TO TAKE MY TRUCK IN FOR RUST INVESTIGATION BECAUSE OF THE NEWS REPORT I SAW THIS EVENING. *TR