2006 TOYOTA SIENNA Latcheslockslinkages Problems

I HAVE A TOYOTA SIENNA WITH 69,451 MILES. I HAVE HAD BOTH REAR SLIDING DOORS REPAIRED TWICE EACH. THE DOORS STILL DO NOT ENGAGE AND LOCK. I HAVE TWO CHILDREN AND MULTIPLE TIMES THE DOORS HAVE OPENED WHILE DRIVING. TOYOTA RECENTLY HAS A RECALL ON THIS ISSUE, BUT IT ONLY DATES BACK TO 2011. THIS IS AN ISSUE FOR MANY EARLIER MODELS AND I AM FURIOUS IT WAS NOT INCLUDED. TOYOTA SAYS THERE IS NOTHING ELSE THEY CAN DO FOR ME. WHEN ONE OF MY CHILDREN FALLS OUT THE BACK AND GETS INJURED IS NOT THE TIME TO ADDRESS IT. I DEMAND THAT THE 2006 MODEL BE INCLUDED IN THE RECALL FOR SAFETY ISSUES, NOT JUST FOR ME AND MY CHILDREN, BUT FOR MANY, MANY OTHERS WHO HAVE COMPLAINED ABOUT THE SAME ISSUE. PLEASE ADDRESS THIS PROBLEM BEFORE SOMEONE GETS HURT OR WORSE. THANK YOU FOR YOUR PROMPT ATTENTION. THE...

TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE'S REAR DOOR WAS NOT LOCKING AND THE DOOR AJAR WARNING INDICATOR ILLUMINATED. ONCE THE DOOR WAS AJAR, IT DID NOT LOCK AND TOOK SEVERAL ATTEMPTS. THE CONTACT WAS CONCERNED THAT THE DOORS WOULD OPEN WHILE DRIVING. THE DEALER REPAIRED THE VEHICLE TWICE, BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 45,000. UPDATED 01/26/2017*CT CONSUMER STATED BOTH DOORS HAD THE ISSUE OF NOT LOCKING MULTIPLE TIMES. ALL AUTOMATIC DOOR FEATURES HAVE HAD TO BE DISENGAGED AND THE RIGHT REAR (PASSENGER) DOOR WILL NOT ENGAGE THE LOCK. UPDATED 7/10/18*JB

TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE MOTOR TO THE BACK DOOR LATCH ON THE PASSENGER SIDE OF THE VEHICLE FAILED TO LOCK AUTOMATICALLY. IN ORDER TO LOCK THE DOOR, THE CONTACT HAD TO MANUALLY CLOSE THE DOOR. THE CONTACT TOOK THE VEHICLE TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 108,000.

NHTSA ACTION NUMBER : EA06020 THE REPLACEMENT STRUT FOR THE REAR LIFT GATE UNDER THE RECALL NHTSA ACTION NUMBER : EA06020 ARE FAILING AGAIN. THEY WERE ALREADY REPLACE ONCE UNDER THE RECALL. IF IT'S A NORMAL WEAR ITEM THEN SHOULD BE LISTED UNDER MAINTENANCE. *TR

PASSENGER SIDE SLIDING DOOR FAILED TO LOCK. THE "DOOR OPEN" LIGHT ON THE DASHBOARD REMAINED LIT. THIS IS A POTENTIAL SAFETY ISSUE SINCE THE DOOR COULD OPEN WHILE DRIVING. I TOOK IT TO TOYOTA DEALERSHIP SERVICE DEPARTMENT WHICH IDENTIFIED FAULTY REAR LATCH AND GAVE ME AN ESTIMATE OF REPAIR COST OF $526. THIS IS AN EXPENSIVE REPAIR COST WHICH THE CONSUMER SHOULD NOT HAVE TO PAY SINCE THE FAULTY LATCH MECHANISM IS NOT A RESULT OF USAGE OF THE VEHICLE, RATHER IT IS PROBABLY DUE TO A FAULTY DESIGN. TOYOTA SHOULD HAVE ISSUED A RECALL OF THIS FAULTY LATCH MECHANISM. *TR

THE PASSENGER SIDE POWER SLIDING DOOR FAILS TO REMAIN CLOSED EVEN WHILE THE LOCKS ARE ENGAGED. THE BACK LATCH OF THE DOOR FAILS TO KEEP THE DOOR CLOSED WHILE DRIVING, SOMETIMES THE DOOR SLIDES INTO THE FULL OPEN POSITION WHILE DRIVING. THE FIRST FAILURE OCCURRED AFTER TWO YEARS AND 35,000 MILES OF OWNERSHIP AND HAS RECURRED AFTER 5 YEARS AND 92,000 MILES. THE MOTOR AND DOOR LATCH WAS INITIALLY REPLACED. TOYOTA CORPORATION AND DEALERSHIP SAYS THE VEHICLE IS NOW OUT OF WARRANTY AND REPAIR COSTS ARE ESTIMATED AT $1,100 - $1,800. THIS IS NOW A SAFETY HAZARD FOR PASSENGERS IN THE REAR SEATS AS SOMETIMES AFTER FORCING THE DOOR LATCH CLOSED, THE DOOR WILL NOT OPEN MANUALLY FROM THE OUTSIDE OR INSIDE.. *TT

OUR 2006 TOYOTA SIENNA VAN HAS ONE OF THE AUTOMATIC SIDE DOORS THAT OPENS BACK UP ON ITS OWN BECAUSE IT DOES NOT CLOSE PROPERLY. THIS HAS BEEN A PROBLEM SINCE THE CAR WAS FAIRLY NEW WITH A LITTLE OVER 36,000 MILES. TOYOTA DOES NOT CONSIDER A DOOR THAT OPENS ON ITS OWN A SAFETY ISSUE, THEREFORE THEY WOULD NOT FIX THE PROBLEM WITHOUT CHARGE. I CONSIDER THIS DANGEROUS BECAUSE A DOOR THAT CONTINUES TO OPEN ON ITS OWN IS CLEARLY NOT SAFE. *TR

AUTOMATIC DOOR WILL NOT LATCH CLOSED MANUALLY OR AUTOMATICALLY. *TR

MOTOR ON AUTOMATIC DOOR IS BROKEN AND DOOR WILL NOT CLOSE AND LATCH PROPERLY. *TR

MY DRIVERS SIDE POWER SLIDING PASSENGER DOOR CABLE JAMMED WITHOUT WARNING WHILE OUT WITH MY FAMILY. I HAD 2 SMALL CHILDREN IN THE BACK SEAT. I WAS UNABLE TO CLOSE THE DOOR, EVEN AFTER TURNING OFF THE POWER SWITCH TRYING TO USE IT "MANUALLY". HAD TO CALL A FRIEND TO TAKE US HOME, AS I COULD NOT DRIVE THE VEHICLE WITH THE DOOR OPEN. MY HUSBAND WAS ABLE TO PULL ON THE DOOR HARD ENOUGH TO SNAP THE STRIPPED CABLE, AND THE DOOR WILL NOW FUNCTION MANUALLY. UPON INSPECTION, IT APPEARS THAT THE PROTECTIVE COATING ON THE CABLE WORE OFF, EXPOSING THE BARE WIRE WHICH STARTED TO UNCOIL...THUS CAUSING THE DOOR TO JAM. I HAVE BEEN TOLD THE REPAIR WILL COST ME $1800.00. THIS IS UNACCEPTABLE, AND I AM INSISTING ON A RECALL FOR THE POWER DOOR CABLES. *TR

2006 TOYOTA SIENNA AUTOMATIC SLIDING DOOR ON PASSENGER SIDE WILL NOT OPEN AND CLOSE WHEN USING REMOTE, OR CONSOLE BUTTONS. THIS STARTING OCCURRING AUGUST 1, 2011. *TR

TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE AUTOMATIC SLIDING DOOR WOULD NOT LATCH TO SECURE THE DOOR CLOSED. THE DEALER MDE REPAIRS TO THE DOOR, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 85,000.

THE DOOR STOP WELD BROKE AFTER WARRANTY EXPIRED. THIS IS A COMMON TOYOTA PROBLEM AND NEEDS A RECALL. THE REPAIR IS VERY EXPENSIVE AND TOYOTA REFUSES TO CONTACT CUSTOMERS ABOUT THIS ISSUE. *KB

WE HAVE A 2006 TOYOTA SIENNA. WE HAVE HAD THE LEFT SLIDING DOOR LATCH REPLACED TWICE. WE HAVE HAD THE RIGHT SLIDING DOOR LATCH REPLACED ONCE. THE LEFT ONE HAS FAILED ONCE AGAIN. EVERYTIME IT FAILS MY WIFE HAS BEEN DRIVING AND THE LEFT SLIDING DOOR HAS OPENED WHEN THE VAN IS IN MOTION. TOYOTA KNOWS ABOUT THE PROBLEM AND THERE HAVE BEEN NO RECALLS YET. I HAVE ALREADY SPENT $1700 ON MAINTENANCE ON THESE DOORS. *TT

TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE PASSENGER SLIDING DOOR DOES NOT OPEN FROM THE INSIDE OR THE OUTSIDE. THE VEHICLE WAS NOT INSPECTED BY A DEALER NOR WAS IT REPAIRED. THE MANUFACTURER WAS CONTACTED AND ADVISED HER TO TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 58,000.

THE 2006 TOYOTA SIENNA PASSENGER POWER SLIDING DOOR DOES NOT HAVE A MANUAL OVERRIDE. WHEN THE POWER SIDING DOOR MECHANISM FAILS THE PASSENGER(S) IS (ARE) TRAPPED IN THE VEHICLE OR ARE FORCED TO EXIT INTO TRAFFIC OR CLIMB TO THE FRONT TO EXIT THE VEHICLE. ALTHOUGH THIS INCIDENT DID NOT RESULT IN AN ACCIDENT OR INJURE, IT DOES CREATE A SAFETY ISSUE, ESPECIALLY IF CHILDREN ARE IN THE VEHICLE. *TR

SIENNA 2006 MODEL BACK DOOR IS SHUTTING/CLOSING DOWN. I WAS CAUGHT IN BETWEEN AND IT SHUTS DOWN QUICK AND HARD. *TR

THE PASSENGER SIDE SLIDING DOOR ON MY 2006 TOYOTA SIENNA WILL NOT OPEN, EITHER MANUALLY OR ANY OTHER WAY. *TR

DOOR VERY HARD TO OPEN AND CLOSE. PLASTIC SHEETING COMES OFF THE CABLE MAKING IT NON FUNCTIONAL. BAD DESIGN IF YOU ASK ME. $1800 TO REPLACE THE MOTOR WHICH IS OUTRAGEOUS. $1100 FOR THE MOTOR, WHICH AGAIN SHOULD NOT COST AS MUCH. HIGHWAY ROBBERY. I CAN UNDERSTAND IF IT COUPLE HUNDRED FOR THE MOTOR. THIS NEEDS TO GO ON A RECALL. TOO MANY SIENNA OWNERS HAVE SIMILAR PROBLEM. JUST GOOGLE AND YOU WILL FIND ALL THE FORUMS. MY FIRST AND LAST TOYOTA....... *TR

OUR AUTOMATIC SLIDING DOOR IS NOT WORKING AT 55,000 MILES. THE TOYOTA COMPANY REFUSES TO PAY TO FIX THE SLIDING DOOR. I AM SURPRISE WITH TOYOTA'S REPUTATION THAT THE AUTOMATIC SLIDING DOOR HAS STOP WORKING. I AM VERY CONCERNED ABOUT THE AUTOMATIC DOOR NOT WORKING. RIGHT NOW THE DOOR IS ON MANUAL. IT IS VERY DIFFICULT TO OPEN AND CLOSE FOR MY FAMILY. MY SPOUSE AND MY HANDS HURT WHEN WE PULL TO OPEN AND CLOSE THE SLIDING DOOR. OUR THREE KIDS ARE UNABLE TO OPEN AND CLOSE THE DOOR ON THEIR OWN. I AM VERY CONCERNED BECAUSE GOD FOR BID IF WE WERE TO GET INTO AN ACCIDENT MY KIDS MAY NOT BE ABLE TO GET OUT. *TR

TL*THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE PARKED, THE AUTOMATIC SLIDING DOOR OF THE REAR PASSENGER SIDE LOCKED AND WAS UNABLE TO OPEN. THE FAILURE OCCURRED ON THE REAR DRIVER SIDE MANUAL DOOR TWO MONTHS LATER. THE DEALER AND MANUFACTURER WERE WHO STATED THE REPAIRS WOULD NOT BE COVERED BECAUSE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 29,000. UPDATED 02/23/11 *BF UPDATED 04/28/11

RIGHT SIDE ELECTRIC SLIDING DOOR ON TOYOTA SIENNA FAILS. FAULTY HINGES AND DRIVE CABLES. *TR

2006 TOYOTA SIENNA MINIVAN. BOTH SIDE SLIDING DOORS FAIL TO CLOSE PROPERLY. UNABLE TO MANUALLY CLOSE. DOOR WILL SLIDE OPEN. REPAIRED DRIVER SIDE SLIDING DOOR IN 2008. NOW IN JULY 2010, PASSENGER SIDE SLIDING DOOR DID NOT CLOSE BUT HAD BEEN REPAIRED BUT NOW AGAIN IN DECEMBER 2010 DOOR CONTINUES TO NOT CLOSE PROPERLY. *TR

WHILE STARTING FORWARD AFTER LOADING GRANDSON IN DRIVER SIDE SECOND ROW OF SEATS DRIVERS SIDE SLIDING DOOR OPENED HALF WAY(DOORS ARE ELECTRICALLY OPERATED). I STOPPED AND ATTEMPTED TO CLOSE DOOR AUTOMATICALLY. DOOR WOULD NOT CLOSE BUT REMAINED HALF OPEN. TRIED MANUAL OPERATION TO NO AVAIL. CALLED TOW TRUCK. TOW TRUCK OPERATOR EXAMINED DOOR AND SAID THAT THE CABLE THAT OPERATES DOOR WAS JAMMED AND THE ONLY WAY TO CLOSE DOOR WAS TO CUT CABLE. AFTER CUTTING CABLE DOOR CLOSED MANUALLY. DROVE HOME. IF DOOR HAD OPENED AT SPEED ON HIGHWAY IT WOULD HAVE CAUSED GREAT DANGER AS MY GRANDSON WAS SITTING NEXT TO DOOR. CALLED CUSTOMER SERVICE AT TOYOTA TO COMPLAIN. WAS GIVEN NO EXPLANATION. *TR

THE GAS IN THE LIFT GATE SUPPORT OF THE BACK DOOR ESCAPED 3 YEARS AFTER I BOUGHT IT. *TR

2006 TOYOTA SIENNA PASSENGER POWER SLIDING DOOR WILL NOT WORK. DRIVERS SIDE MANUAL SLIDING DOOR WORKS INTERMITTENTLY. *TR

MY 2006 TOYOTA SIENNA RIGHT REAR POWER SLIDING DOOR WOULD NOT CLOSE. IT ROLLED ALMOST SHUT, THEN OPENED AGAIN. THE CABLE THAT PULLS THE DOOR SHUT WAS LOOSE ALONG THE TRACK AND I NOTICED IT SEEMED TO BE FRAYED. I HAD MY 3 CHILDREN IN THE CAR AND IT WAS RAINING. I HAD TO FORCEFULLY PULL THE DOOR CLOSED AND STILL COULD NOT GET IT CLOSED BECAUSE THE CABLE WAS KEEPING IT FROM CLOSING. I WAS FORCED TO GET PLIERS AND CUT THE CABLE SO I COULD KEEP MY CHILDREN SAFE AND DRIVE BACK HOME WITH THE DOOR CLOSED. THE CAR HAS JUST OVER 60,000 MILES ON IT. NOW I HAVE REMOVED THE CABLE AND USE THE DOOR AS A MANUAL DOOR BECAUSE THE COST TO REPLACE IT IS TOO HIGH. THIS IS UNACCEPTABLE. *TR

POWER SLIDING DOOR ON PASSENGER SIDE DOES NOT ALWAYS LATCH. IT APPEARS THAT THE MOTOR IS TOO WEAK TO MAKE THE DOOR LATCH FULLY. THIS DOES NOT HAPPEN ALL THE TIME, AND IT SEEMS TO BE RANDOM. HAVE NOTICED THAT THE DOOR SEEMS TO MOVE MORE SLOWLY WHEN IT HAS THE LATCHING PROBLEM. *TR

1. WE WERE AT CHURCH AND TRIED TO PUSH THE POWER DOOR BUTTON TO OPEN THE DOOR, IT OPENED FINE, BUT WHEN IT WENT TO CLOSE, IT MADE A GRINDING CATCHING NOISE AND KEPT STOPPING PARTIALLY CLOSED AND RE-OPENING. WE THEN HAD TO MANUALLY CLOSE IT AND WHEN DOING SO HEARD A LOUD POP. UPON FURTHER INVESTIGATION AT HOME, THE DOOR CABLES AT THE TOP CORRODED ON THE OUTSIDE, FRAYED, AND CAUSED THE JAM, WHICH ULTIMATELY CAUSED THE BREAKAGE. THIS IS NOT A SUFFICIENT WEATHER PROOF CABLE, AND FAILURE COSTS TO REPAIR OVER 1800. WE HAVE NOT YET ATTEMPTED TO REPAIR DUE TO COST BEING SO HIGH. *TR

THE CABLE ON MY SLIDING DOOR OF MY 2006 TOYOTA SIENNA SNAPPED WHEN I PUSHED THE BUTTON TO CLOSE THE AUTOMATIC DOOR. THIS RESULTED IN A SHARP PIECE OF CABLE STICKING OUT TOWARDS MY CHILD WHO WAS SITTING IN HIS CAR SEAT. I'VE TAKEN THE CAR TO TOYOTA AND THEY SAID IT WAS NOT COVERED UNDER WARRANTY EVEN THOUGH I HAVE AN EXTENDED WARRANTY. *TR

AUTOMATIC SLIDING DOOR WOULD NOT LATCH. COST $900 TO REPAIR. *TR

2006 SIENNA MANUAL REAR HATCH LIFT\STRUTS ARE NO LONGER WORKING. HAVE TO MANUALLY HOLD THE DOOR UP, WHICH IS VERY HEAVY. WAS TOLD IT WOULD COST $270 FOR ONE SIDE. *TR

I OWN A 2006 TOYOTA SIENNA VAN AND THE PASSENGER SIDE SLIDING DOOR IS NOT WORKING CORRECTLY. THE SLIDING AUTOMATIC DOOR DOES NOT CLOSE COMPLETELY ON A CONSISTENT BASIS. IT REQUIRES ASSISTANCE TO CLOSE AND WHEN SHUT, IT DOESN'T SEEM TO BE FULLY/SAFELY LATCHED. WE CAN HEAR MORE ROAD NOISE NOW THAT BEFORE. WE CONTRACTED THE LOCAL TOYOTA DEALERSHIP WHERE WE PURCHASED THE VAN AND THEY KNEW RIGHT AWAY THAT THE DOOR MOTOR WAS STARTING TO FAIL AND WE WERE TOLD IT COULD NOT BE FIXED WITHOUT REPLACEMENT. WE WERE QUOTED $1800 TO REPAIR WITHOUT ANYONE EVEN WANTING TO LOOK AT THE PROBLEM. THEY INDICATED THAT THIS IS A PRETTY COMMON PROBLEM WITH THESE VANS. AFTER REVIEWING SOME WEB POSTINGS ON THIS PROBLEM, I AM IN THE SAME BOAT AS A LARGE AMOUNT OF CONSUMERS THAT HAVE PURCHASED THIS MAKE/MODEL/YEAR OF VAN. SAFETY IS OF UTMOST CONCERN TO ENSURE MY...

SIDE SLIDING DOOR CABLE/MOTOR BROKE. THERE IS NO WAY TO MANUALLY CLOSE DOOR WHEN THIS HAPPENS. I HAD TO DRIVE A CONSIDERABLE DISTANCE WITH 3 LITTLE KIDS IN THE CAR AND THE SIDE DOOR OPEN. TOYOTA HAS TO REPLACE THE CABLE AND MOTOR ASSEMBLY AND WILL CHARGE $1800 TO DO THAT. *TR

2006 TOYOTA SIENNA LE PASSENGER-SIDE SLIDING DOOR DOES NOT OPEN AND CLOSE PROPERLY. DEALER SAYS A BUSHING IN THE "HINGE ASSEMBLY" HAS FAILED. AT PRESENT UNFIXED - THE DOOR WILL CLOSE WITH SIGNIFICANT EFFORT ONLY. TOYOTA REFUSES TO REPAIR UNDER EXTENDED WARRANTY BECAUSE "HINGES" ARE EXCLUDED FROM COVERAGE. THEY CHOOSE TO DEFINE THE GLIDER ASSEMBLY THAT HOLDS THE DOOR IN THE TRACK AS A HINGE, DESPITE THE FACT THAT THERE IS NO PIVOT POINT, AND NOTHING THAT MEETS AN ACCEPTED DEFINITION OF A HINGE.

THE PASSENGER SIDE POWER DOOR WILL NOT OPEN OR CLOSE ELECTRONICALLY *CN

I HAVE A 2006 SIENNA AND HAVE A FEW COMPLAINTS. AS I HAVE LEARNED FROM READING SOME OTHER COMPLAINTS I KNOW I AM NOT THE ONLY ONE WHO HAS EXPERIENCED A HESITATION UPON ACCELERATION WITH THE CAR FROM DAY 1 (JANUARY 2006 WHEN THE CAR WAS PURCHASED). I HAVE BEEN TOLD BY THE TOYOTA DEALER NOTHING IS WRONG. RECENTLY, ON A VERY COLD DAY I NOTICED THE STEERING WHEEL WAS EXTREMELY STIFF AND HARD TO MOVE- ALMOST LIKE NOT HAVING POWERING STEERING. THE MOST IMPORTANT REASON WHY I AM FILING THIS IS BECAUSE I TOO HAVE STARTED TO HAVE A PROBLEM WITH THE RIGHT SIDE PASSENGER SLIDING DOOR. IT STARTED TO MALFUNCTION IN JANUARY OF THIS YEAR (2010)- ONE MONTH AGO. FIRST THE DOOR WOULDN'T OPEN. IT WOULD POP TO RELEASE BUT NOT REALLY OPEN . YOU COULD NOT MOVE THE DOOR TO FULLY OPEN IT OR THEN CLOSE IT....

COUPLE THINGS HAPPENED- RIGHT AFTER WE BOTH SIENNA, ABOUT 1 MONTH LATER THE BRAKE LIGHT WENT ON. IT WAS LATE SUNDAY NIGHT, SO THE DEALERSHIP WAS CLOSED. WE WENT THERE THE FOLLOWING WEEK. THEY COULDN'T FIND A PROBLEM, CAUSE THE LIGHT WENT OFF. WHEN I LEFT THE DEALER, THE LIGHT WENT BACK ON SO I LEFT MY CAR THEREAND TOLD THEM I'M NOT GOING TO DRIVE UNTIL THEY FIND A PROBLEM. I HAVE 2 SMALL KIDS AND THEIR SAFETY IS FIRST. THEY FIX IT AND SAID THAT SOME SENSOR UNFORTUNATELY WAS DAMAGED DURING THE DELIVERY AND THEY REPLACE IT. THEN I GOT PROBLEM WITH MY POWER SIDE DOOR- WILL STILL BE CLOSING EVEN IF YOU TRY TO STOP IT. SOLUTION FROM THE DEALER- LUBRICATE AND THAT'S IT- IT STILL HAPPEN FROM TIME TO TIME. NEXT- FRONT PASSENGER AND SECOND ROW SEAT BELTS- LOCK DURING THE TRIP. DEALER SOLUTION- THEY DON'T...

DESCRIPTION OF PROBLEM: 2006 TOYOTA SIENNA SLIDING DOOR ON DRIVER'S SIDE WON'T CLOSE. EVENTS LEADING UP TO PROBLEM: DROVE VEHICLE ABOUT 25 MILES FROM HOME, OPENED SLIDING DOOR FOR CHILD TO EXIT VEHICLE, DOOR WOULD NOT CLOSE AFTER THAT. FRONT LATCH CAN BE SECURED WITH GREAT FORCE, HOWEVER THE REAR LATCH WILL NOT ENGAGE. DOOR REMAINS OPEN AND IS A VERY SERIOUS SAFETY RISK AS THE FRONT LATCH SECURITY/RELIABILITY IS INSUFFICIENT. SLIDING DOOR COULD OPEN WITHOUT WARNING WHILE DRIVING 70 MPH. LIGHTS IN VAN STAY ON, PRESENTING ANOTHER RISK AT NIGHT BECAUSE VISION IS INHIBITED GREATLY BY INTERIOR LIGHTING. HAD TO DRIVE HOME WITHOUT DOOR FULLY CLOSED AT NIGHT. THIS LACK OF VISIBILITY NEARLY RESULTED IN SEVERAL ACCIDENTS. PROBLEM STEMS FROM THE MECHANISM THAT GRABS THE METAL LOOP THAT IS CONNECTED TO THE REAR DOOR FRAME. THE C SHAPED LATCH IS COVERED WITH A PLASTIC COATING WHICH WHEN WORN OR...

2006 TOYOTA SIENNA TWO POTENTIAL SAFETY FAILURES: (1) THE DRIVERS SIDE SLIDING DOOR WHEN OPENING WILL SLIDE INTO THE GAS FUEL DOOR WHILE ANOTHER PERSON IS FUELING THE VEHICLE. THERE IS NO STOP THAT PREVENTS THE DOOR FROM STRIKING THE GAS DOOR WHEN A PERSON IS EXITING THE VEHICLE. WHEN THIS HAPPENED, THE FUELING NOZZLE WAS JARRED LOOSE AND FUEL WAS SPLASHED ON THE VEHICLE. ALSO, THE FUEL MESSAGE STAYED ON FOLLOWING THIS EVENT ON THE DASHBOARD. (2) DRIVER'S SIDE AND PASSENGER'S SIDE FRONT DOOR POWER LOCKS BOTH FAILED(DRIVER'S SIDE AT 37,000MILES & THE PASSENGER'S SIDE AT 58,000 MILES.) THIS MAY OR MAY NOT BECOME A SAFETY FAILURE; HOWEVER, IF THE DOORS ARE NOT LOCKED MANUALLY, THE LACK OF LOCKED DOORS COULD PROVE TO BE DANGEROUS WHEN THE CAR IS MOVING. *TR

2006 TOYOTA SIENNA POWER SLIDING DOOR JAMMED (PARTIALLY OPEN). WAS UNABLE TO MOVE DOOR EITHER DIRECTION. POWER DOOR DISABLE SWITCH DID NOT RELEASE DOOR. HAD TO DRIVE CAR WITH DOOR PARTIALLY OPEN. FORTUNATELY THIS WAS IN A PARKING LOT AND NOT DURING AN EMERGENCY. *TR

THE PASSENGER SIDE ELECTRIC SLIDING DOOR HAS FAILED. THE DOOR KEPT GOING OPEN AND SHUT ONE EVENING AND THEN STAYED SHUT AND HAS BEEN INOPERABLE SINCE. THE DOOR WILL NOT OPEN MANUALLY NOW AND HAS CREATED A SAFETY HAZARD. TOYOTA HAS REFUSED TO FIX THE PROBLEM AND SAYS THAT IT CAN ONLY REPLACE THE MOTOR WHICH WILL COST OVER $2000. THE FAILURE IS THAT THE DOOR WILL NOT OPEN AT ALL. IT IS A SAFETY HAZARD FOR THE PASSENGERS. THE DOOR HAS A MANUAL MODE, AND SHOULD THEREFORE BE ABLE TO OPERATE MANUALLY WITHOUT THE MOTOR. THE DEALERSHIP WOULD DO NOTHING TO HELP BESIDES CHARGE OVER $2000 FOR WHAT WILL SURELY BE A TEMPORARY REPAIR. *TR

RIGHT-SIDE POWER SLIDING DOOR IS BEGINNING TO FAIL. THERE ARE THERE HINGES THAT SUPPORT THE DOOR. TWO ARE LOCATED AT THE FRONT OF THE DOOR (ONE AT THE TOP AND ONE AT THE BOTTOM). THE THIRD HINGE IS LOCATED AT THE REAR OF THE DOOR (IN THE CENTER). IT IS THE CENTER HINGE WHICH IS FAILING. THE HINGE IS SAGGING, AND SCRAPING THE REAR BODY PANEL (UNDER THE REAR QUARTER WINDOW). GIVEN THE FAILURE OF THE HINGE, PROPER CLEARANCES ARE NOT MAINTAINED, AND THE DOOR SCRAPES THE FRONT EDGE OF THAT BODY PANEL. IT ALSO CATCHES ON THE DOOR FRAME (BODY FRAME) WHEN OPENING AND CLOSING. THIS IS A WELL-DOCUMENTED PROBLEM WITH THESE VANS AND TOYOTA REFUSES TO ACKNOWLEDGE ANY FAULT. EVENTUALLY THIS DOOR WILL CEASE TO FUNCTION. OTHERS HAVE HAD IT FAIL IN THE OPEN POSITION, WHILE OTHERS HAVE HAD IT FAIL IN THE CLOSED POSITION. THERE HAVE BEEN...

I HAVE A 2006 TOYOTA SIENNA WITH AN AUTOMATIC SLIDING DOOR. THE CAR IS 6 MONTHS OUT OF WARRANTY. RECENTLY, I DROVE MY CHILDREN SOMEWHERE AND THE DOOR WOULD NOT CLOSE AND BECAME COMPLETELY INOPERABLE. I TOOK THE CAR TO A LOCAL DEALER AND TOYOTA MOTOR CORP WOULD NO TAKE RESPONSIBILITY TO HAVE IT FIXED. I CHECKED OTHER SOURCES AND HAVE FOUND THAT THIS IS A SYSTEMIC PROBLEM WITH THESE MODELS AND THAT IT CLEARLY PRESENTS A DANGER TO PASSENGERS INCLUDING CHILDREN WHO ARE OFTEN PASSENGERS IN MINIVANS. THE PROBLEM ITSELF APPEARS TO BE CAUSED BY POOR DESIGN. TOYOTA HAS HAD OTHER RECALL PROBLEMS WITH IT'S DOOR DESIGNS AND THIS APPEARS TO BE ANOTHER ONE. *TR

REAR PASSENGER SLIDING DOOR WILL NOT LOCK..REMAINS UNLOCKED AND AJAR IN BOTH MANUAL AND POWER SETTING. DOOR HAS LARGE SCRATCH ON SIDE. DOOR WORKED FINE FOR THREE MONTHS AFTER SCRATCH THEN STOPPED WORKING. TOOK VAN TO ADVANTAGE TOYOTA IN LYNNBROOK NY WHO BLAMED LOCK PROBLEM ON DOOR SCRATCH AND WILL NOT FIX UNDER EXTENDED WARRANTY. *TR

2006 TOYOTA SIENNA XLE; DOOR BEGAN OPENING WHEN IN AN UNLOCKED POSITION. THEN UNABLE TO CLOSE DOOR AND THEREFORE UNABLE TO OPERATE VEHICLE IS SAFE MANNER. CONTACTED DEALER; AFTER INSPECTING VEHICLE TOLD CABLE FRAYING/FAILURE SIDE DOOR STUCK IN OPEN POSITION. DEALER STATES UNABLE TO RECTIFY PROBLEM BY OVERRIDING CABLE SYSTEM TO ALLOW DOOR TO BE OPERATED MANUALLY; FORCED TO REPLACE ENTIRE MECHANICAL DOOR OPERATION SYSTEM BECAUSE OF CABLE FAILURE RESULTING IN COST OF APPROXIMATELY $2000 TO DEALER. *TR

I HAVE A 2006 TOYOTA SIENNA MINIVAN. THE LATCH ON THE DRIVER'S SIDE PASSENGER SLIDING DOOR FAILED TO KEEP THE DOOR SECURED WHEN DRIVING DOWN THE ROAD. THE DOOR WOULD BECOME UNLATCHED AND OPEN SLIGHTLY IN TRANSIT. I TOOK THE CAR TO THE DEALER AND THEY INFORMED ME THAT THE LATCH WOULD HAVE TO BE REPLACED. I TALKED TO THE SERVICE MANAGER WHO TOLD ME THAT THERE WAS NOTHING HE COULD DO ABOUT IT NOR WAS IT COVERED BY ANY RECALL OR WARRANTY. I TRIED TO HAVE THE REGIONAL PARTS MANAGER CALL ME, HOWEVER, HE WOULD NOT RETURN MY CALL. THIS A MAJOR SAFETY ISSUE FOR TOYOTA, BUT THEY DID NOT WANT TO HEAR ABOUT IT NOR DO ANYTHING ABOUT IT. WHAT REALLY BOTHERS ME IS THAT THIS DOOR GETS USED WHEN THE GRANDCHILDREN ARE TRAVELING WITH US. I FIND IT VERY UPSETTING THAT THIS DOOR UNLATCHES BY ITSELF WITHOUT...

POWER SLIDER DOOR FAILED ON 2006 SIENNA VAN. WILL NOT CLOSE. *TR

AUTOMATIC DOOR FAILURE. *TR

2006 TOYOTA SIENNA MANUAL SLIDING DOORS HAVE FAULTY LATCH SYSTEM. AT LEAST ONCE A WEEK WHEN I OPEN THEM THEY WILL NOT LATCH OPEN. I'VE DISCOVERED WHY IT WON'T LATCH, BUT DEALERSHIP REFUSES TO FIX IT SINCE THEY CANNOT REPRODUCE IT. IT HAPPENS TO BOTH DOORS AT THE SAME TIME AND TEN MINUTES LATER THEY ARE BOTH WORKING AGAIN. I HAVE ACTUALLY BEEN HIT IN THE HEAD ONCE ALREADY WHEN THE DOOR FLEW BACK AT ME INSTEAD OF LOCKING IN PLACE. *TR