2006 TOYOTA SIENNA Structurebodydoor Problems

2006 TOYOTA SIENNA. CONSUMER WRITES IN REGARDS TO ELECTRIC DOORS SAFETY RECALL. *LD THE CONSUMER STATED THE DOORS FAILED AFTER HAVING THE RECALL REPAIR PERFORMED.*JS

LEFT HAND POWER DOOR HAS OPENED AND AT A DIFFERENT TIME CLOSED WITHOUT ANY ACTION BY US.. BOTH TIMES THE VEHICLE WAS NOT MOVING! REASON IS UNKNOWN. *TR

I HAVE A TOYOTA SIENNA WITH 69,451 MILES. I HAVE HAD BOTH REAR SLIDING DOORS REPAIRED TWICE EACH. THE DOORS STILL DO NOT ENGAGE AND LOCK. I HAVE TWO CHILDREN AND MULTIPLE TIMES THE DOORS HAVE OPENED WHILE DRIVING. TOYOTA RECENTLY HAS A RECALL ON THIS ISSUE, BUT IT ONLY DATES BACK TO 2011. THIS IS AN ISSUE FOR MANY EARLIER MODELS AND I AM FURIOUS IT WAS NOT INCLUDED. TOYOTA SAYS THERE IS NOTHING ELSE THEY CAN DO FOR ME. WHEN ONE OF MY CHILDREN FALLS OUT THE BACK AND GETS INJURED IS NOT THE TIME TO ADDRESS IT. I DEMAND THAT THE 2006 MODEL BE INCLUDED IN THE RECALL FOR SAFETY ISSUES, NOT JUST FOR ME AND MY CHILDREN, BUT FOR MANY, MANY OTHERS WHO HAVE COMPLAINED ABOUT THE SAME ISSUE. PLEASE ADDRESS THIS PROBLEM BEFORE SOMEONE GETS HURT OR WORSE. THANK YOU FOR YOUR PROMPT ATTENTION. THE...

TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE VEHICLE'S REAR DOOR WAS NOT LOCKING AND THE DOOR AJAR WARNING INDICATOR ILLUMINATED. ONCE THE DOOR WAS AJAR, IT DID NOT LOCK AND TOOK SEVERAL ATTEMPTS. THE CONTACT WAS CONCERNED THAT THE DOORS WOULD OPEN WHILE DRIVING. THE DEALER REPAIRED THE VEHICLE TWICE, BUT THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 45,000. UPDATED 01/26/2017*CT CONSUMER STATED BOTH DOORS HAD THE ISSUE OF NOT LOCKING MULTIPLE TIMES. ALL AUTOMATIC DOOR FEATURES HAVE HAD TO BE DISENGAGED AND THE RIGHT REAR (PASSENGER) DOOR WILL NOT ENGAGE THE LOCK. UPDATED 7/10/18*JB

TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. WHILE ATTEMPTING TO OPEN THE PASSENGER SIDE REAR SLIDING DOOR AUTOMATICALLY, IT WOULD NOT OPEN. THE DOOR HAD TO BE OPENED MANUALLY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000.

THE DOOR DRIVER SIDE HAS THE PROBLEM: THE DOOR MAKING NOISE LIKE CRACKING INSIDE THE DOOR, THE AUTO REPAIR SHOP THEY TOLD ME THE YEAR 2005 AND 2006 SAME MY PROBLEM ALOT,BECAUSE THE WELDING INSIDE DOOR PANEL ATTACH WITH LATCH THE WELDING CAME OFF,THAT WHY WHEN I OPEN AND CLOSE DOOR IT MAKE CRACKING NOISE,THEY TOLD ME HARD TO REPAIR AND COST ALOT MONEY. CAN YOU INVESTIGATE THIS PROBLEM AND THE TOYOTA FACTORY RECALL TO FIX THIS PROBLEM! THANK YOU VERY MUCH, TO HEAR FROM YOU SOON😒 *TR

TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT THE REAR PASSENGER SIDE SLIDING DOOR BECAME STUCK AND FAILED TO OPEN. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FAILURE WAS DUE TO A FRACTURED CABLE WITHIN THE DOOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 192,000.

WIRE CABLE THAT OPERATES AUTOMATIC DOOR ON PASSENGER SIDE SNAPPED WITHOUT WARNING. DOOR NO LONGER OPENS OR CLOSES - EVEN MANUALLY WITHOUT SOME EFFORT. VEHICLE ONLY HAS 55K MILES. *TR

THE SLIDING POWER DOOR, PASSENGER SIDE DOES NOT OPEN AND IS STUCK CLOSED. TOYOTA IS CHARGING OVER $1500 FOR THE FIX, EVEN THOUGH THE PROBLEM HAS EXISTED FOR YEARS. ANY ON-LINE SEARCH WILL CLEARLY INDICATE A NEED FOR A RECALL ON THIS SAFETY ISSUE: "TO DATE, TOYOTA HAS NOT ISSUED A RECALL FOR THE SIENNA, ALTHOUGH SOME OWNERS HAVE REPORTED THAT THE AUTOMAKER HAS ISSUED TECHNICAL SERVICE BULLETINS (TSB) FOR THE AUTOMATIC SLIDING DOORS. A TSB IS EFFECTIVELY A HIDDEN RECALL, MEANING THAT TOYOTA IS ATTEMPTING TO HANDLE THE PROBLEM IN-HOUSE. CONTACT YOUR TOYOTA DEALER FOR ASSISTANCE. CHECK THE NHTSA WEBSITE FOR CURRENT RECALL INFORMATION" I HAVE CONTACTED TOYOTA, MANY TIMES AND THEY JUST DON?T CARE. SO CAN THE NHTSA DO SOMETHING ABOUT THIS ISSUE OR NOT???? THANK YOU. *TR

TL* THE CONTACT OWNS A 2006 TOYOTA SIENNA. THE CONTACT STATED THAT ALL THE DOORS ON THE VEHICLE FAILED TO OPEN WHEN ATTEMPTING TO EXIT THE VEHICLE. THE FAILURE OCCURRED MULTIPLE TIMES. THE DEALER STATED THAT THE DOORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 177,000.

ORIGINAL RECALL FOR BACK DOOR STAY KIT, COVERED UNDER WARRANTY 12/17/08-DEALERSHIP REPLACED REAR HATCH STAYS. DOOR CONTINUES TO BE FAULTY. WHEN YOU PRESS THE BUTTON TO CLOSE, IT RESPONDS TEMPORARILY, THAN BEGINS TO LIFT. *TR

2006 TOYOTA SIENNA. CONSUMER WRITES IN REGARDS TO DRIVER SIDE DOOR WELD FAILURE. *SMD THE CONSUMER STATED LAST WEEK, THE DRIVER SIDE DOOR DEVELOPED A POPPING NOISE THAT OCCURRED WHENEVER THE DOOR WAS OPENED OR CLOSED. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE AN INSPECTION REVEALED THE SPOT WELDS HAD BROKEN AWAY FROM THE DOOR STRUCTURE. *JB

LESS THAN A YEAR AGO A CREAKING NOISE TURN INTO A CRACKING NOISE AND NOW IS WORSE LIKE A POPPING SOUND THAT FEEL LIKE THE DOOR IS GOING TO FALL WHEN YOU TRY TO CLOSE IT AND WHEN YOU ARE IN THE HIGHWAY THE DOOR VIBRATES AND IT FEELS LIKE IS GOING TO FALL FROM THE VEHICLE. TOYOTA SEND A NOTICE TO EXTEND THE WARRANTY 5 YRS OR 100000 AND MY MINI VAN MOSTLY IS USED IN THE WEEKENDS SO I HAVE ONLY ABOUT 60000K FOR A 8 YEARS OLD CAR (LOW MILEAGE USE). OF COURSE THE NOISE START TO HAPPEN JUST AFTER 5 YRS BUT LESS THAN 6 YRS OR 100000 MILES AND TOYOTA APPARENTLY DOES NOT COVER THE REPAIR. I'M WANDERING IF THE DOOR FALL OFF FROM THE CAR IN THE HIGHWAY CAUSING A MAJOR ACCIDENT WHO IS GOING TO BE RESPONSIBLE. THIS IS VERY COMMON PROBLEM OF...

RIGHT SIDE POWER SLIDING DOOR WILL NOT OPEN OR CLOSE ALL THE WAY. NEED EXTREME MANUAL PRESSURE TO FORCE IT TO CLOSE. TURNING OFF POWER FOR THE SLIDING DOOR STILL DOES NOT ALLOW IT TO BE CLOSED WITHOUT NEEDING EXTREME MANUAL PRESSURE. AT THIS POINT IN TIME, WE ARE ONLY USING THE LEFT PASSENGER SLIDING DOOR TO ENTER AND EXIT THE VEHICLE. *TR

2006 TOYOTA SIENNA. CONSUMER WRITES IN REGARDS TO DRIVERS SIDE DOOR ISSUES. *SMD THE CONSUMER STATED SEVERAL WEEKS AGO, THE DRIVER'S SIDE DOOR STARTED MAKING A POPPING NOISE WHEN IT WAS OPENED AND CLOSED. THE CONSUMER DID SOME RESEARCH, AND DISCOVERED THE ISSUE WAS DUE TO POOR ENGINEERING ON THE DOOR WELD, THAT COULD NOT STAND THE STRESS OF OPENING AND CLOSING. THE CONSUMER CALLED TOYOTA CUSTOMER CARE AND WAS REASSURED THEY WOULD BE ABLE HELP HIM. THEY INDICATED, THEY WERE AWARE OF THE ISSUE. AFTER SEVERAL PHONE CALLS AND DRIVING AROUND TO GET VARIOUS ESTIMATED, TOYOTA DECIDED THEY WERE NOT GOING TO ASSIST THE CONSUMER. THE PROBLEM HAS SINCE WORSENED AND NOW REQUIRES A COMPLETE DOOR REPLACEMENT.

THE DRIVER-SIDE REAR SLIDING DOOR WOULD NOT CLOSE BY INTERIOR CONTROLS OR REMOTE. AFTER SEVERAL ATTEMPTS I WAS ABLE TO MANUALLY FORCE THE DOOR CLOSED. HAS HAPPENED 3 TIMES SINCE, ONCE LEAVING THE LIGHTS ON AND DOOR OPEN OVERNIGHT IN THE COLD, DRAINING THE BATTERY AND LEAVING MY BELONGINGS UNPROTECTED AND ANOTHER TIME WHILE MY KIDS WERE LOADED INTO THE VEHICHLE IN EXTREME WINTER CONDITIONS AND WE WERE NOT ABLE TO CLOSE THE DOOR OR DRIVE HOME. HUGE SAFETY CONCERN! I EXPECT MY CHILDREN TO BE SAFE IN MY VAN WHICH IS WHY I PURHASED A TOYOTA AND BECAUSE I EXPECT THEM TO BE NON-ACCESSIBLE TO STRANGERS/CRIMINAL ACTS WHEN THEY CLIMB INTO OUR FAMILY VAN AND I CLOSE THE DOOR... DEALER IS SAYING THAT THE ISSUE IS WITH THE HINGE AND IS NOT COVERED BY THE SAFETY RECALL ISSUED. *TR

STARTED GETTING THE DRIVE SIDE FRONT DOOR POP NOISE. DOOR ASSEMBLE IS NOT WELDED PROPERLY OR LOUSE OR DESIGN IS NOT CORRECT TO LAST THIS DOOR WELDING LIFE OF VEHICLE. AS I NOW FROM OTHER VEHICLES DOOR ASSEMBLE SHOULD LAST LIFE OF VEHICLE AND THERE SHOULD BE NO PROBLEM. THERE WAS RECALLED ON THIS DOOR NOISE WHEN I WAS RECEIVED THE RECALL LETTER FROM TOYOTA, I SHOWED THIS RECALL LETTER TO TOYOTA SERVICE CENTER TIME OF REGULAR SERVICE TO MANAGER AND HE MENTIONS THAT THERE IS NO NEED TO REPAIR THIS TIME. NOW TOYOTA CUSTOMER IS NOT HONORING THIS REPAIR. GIVING ME THE REASON YOU ARE OUT OF WARRANTY. THIS TYPE OF STRUCTURAL BODY PROBLEM SHOULD BE LIFE OF VEHICLE. AS CUSTOMER AND SAFETY I DO NOT FILL SAFE DRIVING THIS VEHICLE SINCE I PURCHASED THIS VEHICLE, THERE ARE SO MANY ISSUES, REPAIRS, AND RECALL. VEHICLE DETAIL MAKE AND YEAR:...

BOTH POWER SLIDING DOORS HAVE BECOME INOPERABLE. IT IS A SAFETY ISSUE BECAUSE MY CHILDREN CANNOT OPEN THE DOORS FROM THE INSIDE OF THE VEHICLE. TOYOTA WILL NOT STAND BEHIND THEIR PRODUCT. *TR

DRIVER SIDE SLIDING DOOR WOULD NOT CLOSE. TRIED TO USE CAR REMOTE, INTERIOR CONTROL ... NEITHER WORKED. WAS ABLE TO MANUALLY CLOSE IT, BUT IT WAS DIFFICULT TO DO. DOOR IS NOT CURRENTLY OPERATIONAL. *TR

CPSC#I270307A. 2006 TOYOTA SIENNA. CONSUMER STATED THAT THERE IS A SERIOUS PROBLEM WITH THE MECHANICAL PASSENGER DOORS. STATED ON ONE OCCASION THE REAR PASSENGER DOOR EXPLODED WHILE HER CHILDREN WERE INSIDE. *LN THE CONSUMER ALSO STATED WHITE SMOKE COULD BE SEEN COMING FROM THE DOOR. THE DEALER STATED THE MOTOR EXPLODED AND IT WAS VERY COMMON. THE CONSUMER ALSO STATED THE ONLY WORKING DOOR IS ALSO EXHIBITING PROBLEMS. THE CONSUMER STATED AS HER DAUGHTER WAS ENTERING THE VEHICLE, THE DOOR SUDDENLY SLAMMED SHUT VERY QUICKLY, JUST MISSING HER BY SECONDS. *JB

THE POWER DOOR GOT STUCK IN THE OPEN POSITION THUS LOCKING THE TRANSMISSION AND MAKING IT IMPOSSIBLE TO MOVE THE VEHICLE. LUCKILY THIS HAPPENED WHEN PARKED IN A RESIDENTIAL NEIGHBORHOOD AND NOT ALONG AN INTERSTATE OR BUSY CITY ROAD. *TR

THE REAR HATCH RUBBER DOOR HANDLE MELTED DUE TO HEAT DURING THE SUMMER. DURING COLD WEATHER, THE REAR HATCH CANNOT BE OPENED DUE TO THE MELTING DOOR HANDLE. I HAVE TAKEN THE VEHICLE TO THE DEALER WHERE THE DEALER ADVISED THAT THE DOOR HANDLE NEEDED TO BE REPLACED AT A PRETTY HIGH COST. THE VEHICLE WAS NOT REPAIRED. I HAVE READ NUMEROUS COMPLAINTS ONLINE REGARDING THE MELTING DOOR HANDLE. *JS

THE POWER/AUTOMATIC SLIDING LEFT SIDE DOOR STOPPED WORKING. IT NOW MUST BE OPERATED MANUALLY. *TR

PASSENGER DOOR THE ELECTRONICS JUST STOPPED WORKING. I'VE BEEN TOLD I CAN USE THIS MANUAL RIGHT NOW BUT EVENTUALLY WILL SEIZE UP BY THE DEALERSHIP. VERY COSTLY PART. RESEARCHING ON LINE THERE ARE MANY OWNERS OF THIS VAN WITH THE SAME ISSUE. NO VOLUNTARY RECALL ON THIS PART. I FIND THIS A SAFETY HAZARD AS YOU DO NOT KNOW WHEN THE DOOR MAY CEASE TO OPEN. IN THE EVENT OF AN ACCIDENT ON OPPOSITE SIDE OF VAN AND DOOR WILL NOT OPEN AND THE PASSENGER SIDE NO LONGER WORKS, PEOPLE IN THE BACK OF THE VAN WILL BE TRAPPED. NOT SURE WHY TOYOTA HAS NOT HAD A RECALL ON THIS PART. *JS

WE PURCHASED THE VAN USED IN 2009 WITH 12000 MILES ON IT AND MADE OUR PURCHASE DECISION BASED ON THE REPUTATION FOR QUALITY AND SAFETY THAT TOYOTA HAD AT THE TIME. IN JULY 2009 THE SRS WARNING LIGHT BEGAN TO ILLUMINATE. ACCORDING TO THE DEALER THE AIR BAG WIRING HARNESS AND SYSTEM WAS KNOWN TO HAVE ISSUES. LUCKILY THE DEALER CONVINCED TOYOTA USA TO COVER THE REPAIR. IN NOVEMBER 2011 THE LIGHT AGAIN CAME ON AND DID ITS BLINKING THING. CURRENTLY WE HAVE A LITTLE OVER 48000 MILES ON THE VAN AND THE DEALER SAID THAT BECAUSE WE ARE PAST WARRANTY THAT IT WON'T BE COVERED. A PRIVATE MECHANIC TESTED THE SYSTEM AND DETERMINED THE AIRBAGS ARE NOT FUNCTIONING AND THAT TOYOTA HAS PUBLISHED A BULLETIN ACKNOWLEDGING THE ISSUE BUT REFUSES TO REPAIR THIS SAFETY CONCERN. WHEN THE LIGHT IS BLINKING OR ON, THE AIRBAGS WILL NOT DEPLOY, PUTTING EVERYONE...

WHEN WE TRIED TO CLOSE THE REAR PASSENGER SIDE POWER SLIDING REAR DOOR THIS AFTERNOON, IN THE SUPERMARKET PARKING LOT (WE HAD OUR 2 YOUNG CHILDREN WITH US), IT BEGAN TO CLOSE, THEN OPENED, AND THEN WE COULDN'T CLOSE THE DOOR, EITHER BY USING THE AUTOMATIC/POWER OPTIONS OR BY CLOSING THE DOOR MANUALLY. AFTER 15 MINUTES OR SO, WE FINALLY DID MANAGE TO GET IT CLOSED BY ROCKING THE DOOR BACK-AND-FORTH, BUT WE CANNOT -- AND WILL NOT -- USE THE DOOR AT ALL NOW, AS WE ARE AFRAID THAT WE WON'T BE ABLE TO CLOSE IT AGAIN. PRIOR TO TODAY, WE HAD NO PROBLEMS WITH THE DOOR, AND WE TAKE VERY GOOD CARE OF OUR CAR. WE BOUGHT THE MINIVAN FOR THE SPECIFIC PURPOSE OF TRANSPORTING US AND OUR YOUNG CHILDREN. NOW WE ARE VERY CONCERNED ABOUT THE SAFETY OF DRIVING THE CAR, ESPECIALLY WITH OUR KIDS IN IT....

WHILE PARKED I WENT TO OPEN MY PASSENGER SIDE AUTOMATIC BACK DOOR, AND IT WOULDN'T OPEN MORE THAN ABOUT 18". THIS HAPPENED WHILE A 4 HOUR DRIVE FROM HOME. WE LEFT THE CAR LIKE THIS FOR A COUPLE MONTHS. THEN IN ABOUT FEBRUARY THE DOOR STOPPED CLOSING FULLY. I CALLED TOYOTA AND THE LOCAL DEALER, AND THEY WON'T PAY FOR IT. $1100 ESTIMATE FOR A SAFETY HAZARD. *TR

IN OCTOBER OF 2011 THE PASSENGER SIDE POWER SLIDING DOOR CLOSED ITSELF WEDGING ME BETWEEN IT AND THE FRAME OF THE VAN. THE DOOR DIDN'T STOP AND TRY TO OPEN BACK UP, IT JUST STOPPED. AFTER THIS THE DOOR WOULDN'T OPEN OR CLOSE ON ITS OWN. IT HAD TO BE "MUSCLED" IN TO EITHER THE FULLY OPEN OR CLOSED POSITION. I HAD TO DO THIS MYSELF AS MY WIFE WAS NOT STRONG ENOUGH TO MUSCLE IT OPEN OR CLOSE. AFTER THIS INCIDENT I CONTACTED MY LOCAL TOYOTA DEALER AND WAS TOLD THE REPAIRS COULD BE IN EXCESS OF $1500, WE JUST STOPPED USING THAT DOOR. ON FEBRUARY 24 2012 I WAS INFORMED BY MY WIFE WHO WAS WITH ONE OF OUR CHILDREN THAT SHE WAS STRANDED IN A PARKING LOT BECAUSE THE DRIVERS SIDE DOOR, THE GOOD DOOR, WAS STUCK HALFWAY OPEN AND WOULDN'T OPEN OR CLOSE. I CONTACTED MY...

AUTOMATIC POWER SLIDING DOOR ON THE PASSENGER SIDE RECENTLY STOPPED WORKING CORRECTLY. THE DOOR MOTOR TRIES TO OPEN THE DOOR BUT OFTEN STOPS AFTER ONLY MOVING AN INCH OR SO. ONCE YOU GET IT TO OPEN (EITHER MANUALLY OR WITH THE POWER OPEN OPTION WHEN IT RANDOMLY WORKS) DOOR WILL NOT CLOSE WHEN BUTTONS ARE PUSHED. THE DOOR AGAIN WILL MOVE 2 INCHES MAXIMUM AND THEN STOP. IF YOU ARE ABLE TO MANUALLY CLOSE THE DOOR (WHICH IS VERY HARD TO DO) IT DOES NOT ALWAYS LATCH COMPLETELY CLOSED. THIS IS A MAJOR SAFETY ISSUE. IF I CAN NOT OPEN THE DOOR AT SCHOOL TO DROP OFF MY CHILD, WHAT IS GOING TO HAPPEN IN AN EMERGENCY WHEN I NEED TO GET MY CHILD OUT? I HAVE FOUND HUNDREDS OF SIMILAR COMPLAINTS ON MULTIPLE WEB FORUMS, TOYOTA NEEDS TO REPLACE THE DEFECTIVE PART THAT THEY QUOTED ME ALMOST $900 TO...

THE SLIDING DOOR ON MY MINI-VAN ONLY OPENS HALF-WAY AND THEN CLOSES WITHOUT WARNING. I'M GRATEFUL MY 5 YEAR OLD DIDN'T CLIMB IN WHILE OPENING BECAUSE SHE WOULD HAVE BEEN HURT VERY BADLY WITH IT CLOSING ON HER. I WAS LEANING IN TO GET MY PURSE AND IT NEARLY HIT MY HEAD BUT I WAS ABLE TO GET OUT IN TIME. I'VE HEARD THIS IS CURRENTLY HAPPENING WITH A LOT OF SIENNA'S AFTER ABOUT 4 YEARS, SO I WANTED TO MAKE SURE I GOT A COMPLAINT IN SO TOYOTA CAN SEE IT'S NOT JUST A ONE-OFF. VERY DANGEROUS!! *TR

THE AUTOMATIC DOOR STOPPED FUNCTIONING. WE ARE TRYING TO CLOSE AND OPEN IT MANUALLY BUT IT STILL FUNCTIONS AUTOMATICALLY JUST AT THE END OF THE CLOSURE. WE FEAR THAT ONE DAY IT WILL JUST REFUSE TO CLOSE, OR MAY SPRING OPEN WHILE WE ARE DRIVING AND HAVE CHILDREN IN THE BACK SEATS. THIS SHOULD BE COVERED BUT TOYOTA SAYS IT IS NOT. IT IS A HAZARD!! *TR

THE AUTOMATIC REAR PASSENGER DOOR BEGAN TO GRIND WHILE OPENING. AS WE WENT TO CLOSE THE DOOR WITH THE AUTOMATIC FEATURE IT STOPPED WORKING. THE DOOR WAS JAMMED SLIGHTLY OPEN. WE COULD NOT OPEN OR CLOSE THE DOOR EVEN WHEN PUTTING IT INTO MANUAL MODE. UPON INSPECTION MY HUSBAND SAW THAT THE CABLE THAT IS BELOW THE REAR WINDOW WAS SHEARED. HE WAS ABLE TO CUT THIS CABLE AND FREE THE DOOR FROM BEING JAMMED. IT WAS A VERY LONG PAINFUL PROCESS AS WE WERE AWAY FROM HOME AND ONLY HAD ACCESS TO A VERY SMALL DULL KNIFE. THIS IS A MAJOR SAFETY ISSUE. WE HAVE A MINIVAN BECAUSE WE HAVE SEVERAL SMALL CHILDREN. SMALL CHILDREN OFTEN DART IN FRONT OF AUTOMATIC DOORS WITHOUT REALIZING THEY ARE CLOSING. IF THIS DOOR HAD GOTTEN JAMMED WITH ONE OF OUR SMALL CHILDREN CAUGHT IN IT THEY WOULD HAVE BEEN IN GREAT DANGER...

MY EIGHT YEAR OLD DAUGHTER GOT HER FOUR FINGERS ON THE RIGHT HAND CRUSHED BY THE SLIDING PASSENGER AUTOMATIC DOOR WHEN IT WAS CLOSING. THE DOOR DID NOT OPEN LIKE IT SHOULD. SHE DOES NOT FEEL THE TIP OF HER FINGERS. HELP! *TR

THE AUTOMATIC DOOR ON OUR SIENNA VAN JUST STARTED FAILING. IT IS NO LONGER AUTOMATED AND NOW IS ALMOST IMPOSSIBLE TO OPEN OR CLOSE COMPLETELY. *TR

POWER SLIDING DOOR WAS JAMMED IN THE OPEN POSITION. BECAUSE IT HAPPENED ON SUNDAY WE NEEDED TO DRIVE HOME WITH THIS DOOR FULLY OPENED. THIS SITUATION WOULD HAVE BEEN EVEN WORST IF OUR CHILDREN WERE WITH US. *TR

SPOT WELDS BROKE LOOSE ON FRONT DOOR CAUSING POPPING WHEN DOOR IS OPENED. *KB

PASSENGER SIDE AUTOMATIC DOOR FAILURE. THE DOOR WAS STUCK HALF OPEN AND COULD NOT BE CLOSED WHILE AWAY FROM HOME. SAFETY ISSUE OF TRAVELING WITH CHILDREN AND COULD NOT TRANSPORT THEM IN THE CAR. *TT

POWER SLIDING DOOR WAS STUCK HALFWAY OPEN, AND WOULD NOT OPEN MORE NOR CLOSE. LOOKING INSIDE THE DOOR MACHINERY I COULD SEE THE METAL CABLE WAS FRAYED AND MATERIAL WAS STUCK IN THE WORKS, PREVENTING THE DOOR FROM MOVING IN EITHER DIRECTION. I WAS ABLE TO FORCE THE DOOR CLOSED BECAUSE WE NEEDED TO TRANSPORT CHILDREN HOME. BUT NOW THE DOOR CANNOT OPEN, AND IS UNSAFE. FROM SEARCHING ONLINE, NOW I SEE THAT THIS IS A PROBLEM THAT THOUSANDS OF SIENNA CUSTOMERS HAVE ENCOUNTERED. *TR

THE PASSENGER POWERED SLIDING DOOR SEIZED FOR A MOMENT, OPENED, THEN CLOSED THEN OPENED, THEN CLOSED 3/4 OF THE WAY. IT WAS THEN STUCK IN THAT POSITION. *TR

I BOUGHT A 2006 TOYOTA SIENNA LE AWD FOR MY SPECIAL NEEDS DAUGHTER .THE SLIDING DOOR SNAPPED A CABLE AND WOULDN'T OPEN.,SO I HAD TO CRAWL IN FROM OTHER SIDE TO GET HER OUT,THAT WAS NOT A EASY TASK B/C SHE IS IMMOBILE AND COULD NOT HELP ME WITH GETTING HER OUT OF SPECIAL CARSEAT AND BRACE..I THINK THIS SHOULD BE TOYOTA'S JOB TO REPLACE OR AT LEAST HELP WITH REPLACING,IF NOT I WILL NEVER PURCHASE OR RECOMMEND THIS VAN TO ANYONE..I HAD HER SPECIAL SEAT ON THAT SIDE JUST FOR THAT REASON AND I WILL FILE A CLAIM WITH THIS.. *TR

SLIDING SIDE DOOR DOES NOT LATCH. I HAVE SEE THOUSANDS OF COMPLAINTS AND STILL NO RECALL. $2500 DOLLARS TO REPAIR. *TR

POWER SLIDING DOOR STOPPED WORKING, PASSENGER SIDE. I WENT OUT TO LOAD THE KIDS IN THE VAN, AND THE POWER DOOR OPENED ABOUT HALF WAY, THEN SHUT BY ITSELF. I THEN TRIED TO OPEN THE DOOR AGAIN, BUT IT WOULD ONLY OPEN A TINY BIT AND WOULD NOT SHUT. I DID NOT USE THE DOOR ANY FURTHER UNTIL I TOOK IT BACK TO THE DEALER TO HAVE IT LOOKED AT. THE FINAL VERDICT, 1400 DOLLARS TO FIX THE DOOR. I BOUGHT THE VAN 2 WEEKS PRIOR TO THIS HAPPENING, AND IT ONLY HAD 61,000 MILES ON IT. THE DEALERSHIP REFUSED TO HELP OUT IN ANY WAY, EXCEPT THAT THEY DID CUT THE CABLE AND NOW WE CAN USE IT AS A MANUAL DOOR. 5 YEAR OLD VAN WITH 61,000 MILES, AND THE AUTOMATIC DOOR FAILED. I WISH I WOULD HAVE DONE A LITTLE MORE RESEARCH, AS THIS SEEMS TO BE...

AUTO SLIDING DOOR WILL NOT CLOSE TIGHTLY- LOOKS CLOSED THEN WHEN YOU PUT IT IN DRIVE OR REVERSE, THE DOOR BEEPS AND OPENS. TAKES MULTIPLE TIMES OF PUSHING DOOR BUTTON TO GET IT TO SHUT TIGHT. SOMETIMES YOU HAVE TO GET OUT AND TRY AND PUSH IT TO LOCK. IT IS VERY DIFFICULT AND NOW I DON'T USE IT BECAUSE I'M AFRAID IT WON'T CLOSE AND A PASSENGER WOULD BE IN DANGER. *TR

THE POWER SLIDING DOOR ON MY 2006 TOYOTA SIENNA VAN FAILS TO OPEN EITHER MANUALLY OR BY THE POWER CONTROLS. THE TOYOTA DEALER REFUSED TO FIX IT SINCE IT WAS PAST THE WARRANTY PERIOD. I BELIEVE THIS TO BE A SAFETY CONCERN SINCE THE DOOR CANNOT BE OPENED, EVEN MANUALLY. THE TOYOTA DEALER WANTS BETWEEN $1,000 AND $2,000 TO FIX IT WITH NO GUARANTEES THAT IT WON'T HAPPEN AGAIN. *TR

THE BACK PASSENGER SIDE DOOR OF MY TOYOTA SIENNA DOES NOT WORK PROPERLY. WHEN THE BUTTON IS PUSHED TO CLOSE OR OPEN THE DOOR, NOTHING HAPPENS. IT WILL OPEN AND CLOSE WHEN THE HANDLE IS LIFTED AND THE DOOR IS GUIDED A LITTLE ON THE TRACK. I HAVE LOOKED ONLINE AND IT SEEMS TO BE A VERY COMMON ISSUE WITH TOYOTA SIENNAS. THIS DISAPPOINTS ME AS IT IS A VERY EXPENSIVE REPAIR! I THINK A RECALL IS IN ORDER. *TT

WE RECENTLY PURCHASED THIS VEHICLE AND ARE VERY DISAPPOINTED IN THE QUALITY OF THE POWER DOORS. AFTER OWNING IT FOR ABOUT 2 MONTHS THE DOOR JUST BROKE. THE COST TO FIX IT IS $1800.00 PLUS TAX. WE HAVE DISCOVERED THAT THIS SEEMS TO BE AN ISSUE FOR MANY OTHER TOYOTA OWNERS. IT SEEMS THAT IT IS WAS POORLY DESIGNED AND IT WOULD BE MORE THAN NICE IF TOYOTA WOULD DO A RECALL FOR THIS SITUATION. IT IS A VERY EXPENSIVE ISSUE TO FIX AND TAKES AWAY ONE OF THE NICEST FEATURES OF THE VEHICLE TO NOT HAVE THE POWER DOOR WORK. MY HOPE IS THAT WITH ALL THE COMPLAINTS OUT THERE WE CAN GET TOYOTA TO OWN UP TO THIS MISTAKE AND REIMBURSE US FOR HAVING TO FIX THIS INEVITABLE PROBLEM. THANKS FOR YOUR HELP IN THIS MATTER. *TR

SLIDING DOOR MOTOR FAILURE. DOOR FAILED TO CLOSE. HAD TO DRIVE WITH SIDE DOOR OPEN! *TR

MY POWER SLIDING DOOR IS STUCK CLOSED. THIS HAPPENED AFTER IT OPENED PROPERLY USING THE POWER BUTTON, BUT WHEN I CLOSED IT, IT STOPPED HALFWAY. AFTER SEVERAL ATTEMPTS USING THE POWER BUTTONS TO CLOSE IT, AS WELL AS TURNING OFF THE POWER DOOR FEATURE, IT STILL WOULDN'T CLOSE. SINCE I WAS OUT WITH MY 2 CHILDREN, I FORCED IT CLOSED WITH THE HELP OF SOMEONE ELSE. NOW IT WON'T OPEN, MANUALLY OR POWERED, AND I AM AFRAID OF DOING MORE DAMAGE TO THE VEHICLE BY TRYING TO FORCE IT OPEN. *TR

THE TOYOTA SIENNA 2006 AUTOMATED SLIDING SIDE DOOR BEGAN TO STICK AND CLOSE MORE SLOWLY ABOUT A MONTH BEFORE IT BECAME PERMANENTLY STUCK. ONCE IT BECAME STUCK, THE DOOR WOULD NOT CLOSE, REQUIRING ME TO DRIVE WITH A HALF-OPEN DOOR TO THE DEALERSHIP OR HAVE THE CAR TOWED. WHEN I TOOK IT TO THE TOYOTA DEALERSHIP THEY INFORMED ME I COULD PAY $1600 TO REPLACE THE DOOR MOTOR AND FIX THE CABLE. TOYOTA DID NOT INFORM ME THAT WE COULD CUT THE CABLE AS A WAY TO MAKE THE DOOR AT LEAST FUNCTION. I REQUESTED THEY CUT THE CABLE, PERMANENTLY CONVERTING THE SLIDING SIDE DOOR TO A MANUALLY OPERATED SLIDING DOOR. THERE SHOULD BE A RECALL ON THIS DOOR MALFUNCTION, WHICH PLACES CHILDREN SITTING IN THE BACK AREA OF THE SIENNA AT RISK WHEN THE SLIDING DOOR UNEXPECTEDLY FAILS. *TR

DRIVER SIDE SIDE PASSENGER DOOR FAILED TO CLOSE. NO REASON EVIDENT. *TR