2021 TESLA MODEL Y Electrical System12v24v48v Battery Problems

This incident appears to relate to NHTSA ongoing investigation at Tesla's low voltage battery system failure causing door handle malfunction. (September 26, 2025) 2021 Model Y front and rear doors (all four) was locked down with a seven years old child inside the car at home garage driveway. Mom unable to open up doors from exterior. A few hours later, left driver door was able to open but other passengers door remained locked down. (October 2, 2025) Sent Model Y to Tesla service center and identified low voltage battery and vehicle controller failure. Tesla technician replaced those electrical components with service fee charged.

On August 20th, 2025 at 2:50pm, my eight-month-old infant was trapped inside my Tesla Model Y for approximately 30 minutes due to a critical systems failure. The vehicle experienced an error with the 12V battery that rendered the doors, windows, and trunk completely inoperable, preventing any means of access or escape. My infant was flushed, diaphoretic, and crying while stuck in his car seat with an indoor temperature exceeding 104 degrees fahrenheit. Despite all attempts to override the system, the car remained locked, and the battery dead, and emergency services had to be contacted. Officers from the Santa Barbara Sheriff’s Department, California Highway Patrol, and Montecito Fire Department arrived on scene and, in order to rescue my baby, were forced to smash a window to gain entry. The police officer was advised by a Tesla representative to do so, as he confirmed there would be no way to override the...

On July 5, 2025, I entered my vehicle parked in my home garage and the door latched shut. Upon putting my foot on the brake. Center screen was blank (did not power on). I attempted to press the unlock button on the door and there was no sound from the motor to open the door. The door was still locked from the inside of the vehicle and I was locked inside. I waited around 5 minutes (after attempting to call my wife to try to let me out of car and tried the open the drivers door again by pressing the exit button. The door unlatched by normally the window rolls down partially to exit. This time the window did not move and I have to force the door open by pressing my shoulder hard against the interior door panel. I hear a popping sound from inside the door and...

- Open rear passenger door and secured child in car seat. - Try to open driver side rear passenger door - which would not open. - Tried to open rear passenger door where child was in, and the door would not open. - Car was powered off and none of the doors opened. - After approximately 5 minutes, front passenger door opened, and child was removed form the car through the front door. - Requested roadside assistance with the diagnosis of 12V battery failure. - No warning that 12V battery was near end of life - Software updated the previous night.

On [XXX], the car was parked at my regular parking garage. The valet entered to the car to bring it down for pick up. After he entered, the power on the vehicle went out and the door would not open. He did not know about the manual door release. I walked up to see what the delay was and found him locked inside. The car was parked on an upper floor and the it was over 100 degrees in the car. We contacted 911 but eventually found the door release. Tesla was notified and towed the car several hours later. They jumped the car to get it open. It seems that the 12V battery had died without warning. Notes from Tesla Concern: Car won't power on/enter drive - Case MergedCustomer States : vehicle will not power on or drive Originating Phone Number : [XXX] IVR Context - No Results. Please...

[XXX] , my [XXX] son, was strapped in his car seat, wide-eyed and confused, as we sat trapped in our Tesla for thirty agonizing minutes. The battery had died without warning, leaving us locked inside our own garage. No power, no way to open the doors. I tried to keep [XXX] calm, singing his favorite songs, but my heart raced as I called for help. A tow truck finally arrived and jumped the car—not enough juice to start the engine, but just enough to unlock the doors. Freedom at last. Tesla’s response? No roadside service; they insisted the car be towed to their service center. Easier said than done—the tow truck couldn’t maneuver it out of the garage. Frustration mounted as I realized I’d have to miss work. Days later, I drove to the service center, where they replaced the battery. But the ordeal wasn’t over. The trim was damaged...

In December 2023 I strapped my [XXX] son into his carseat in our Model Y and walked around to the front to get into the car as well. In those few seconds the 12v car battery died (I did not get any notification in my app) and I was unable to open any doors, so my infant son was trapped. We live in Florida and this was an 80 degree day. With no other recourse I was forced to call 911 to have my son removed from the vehicle. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle shut down and individual was locked in the car. Unable to release the doors. Incident occurred on June 23rd with a temp of 95 degrees and higher heat index. Individual was Stuck in the car in a parking garage with no one around to hear screams for help. Called home for assistance to come to the parking garage to help free them. Informed by online article about the Model Y 2021 model having other incidents of the same. We thought it was just a freak occurrence of our vehicle until reading about the probe. No warning indications that the auxiliary battery needed replacing that controls such functions. Tesla's Repair Notes: "The vehicle was unable to power on when parked, which was verified by the technician's inspection and the customer's report. The issue was caused by a failing 12V battery. The technician replaced the 12V battery to resolve the problem....

The contact owns a 2021 Tesla Model Y. The contact stated that his wife drove to a nearby park and while attempting to leave the park, the vehicle was started, and after his wife put her son and daughter in the vehicle, the vehicle shut off unintendedly and all the doors locked. The doors failed to open with the mobile card or the manual key. The contact stated that the manual card was inside the vehicle. The contact stated that the temperature control was off inside the vehicle and the screen was inoperable. There were no reported injuries. The contact broke the window to enter the vehicle. There were no warning lights illuminated prior to the failure. The contact called a tow truck, and the vehicle was jumpstarted. The contact stated that the vehicle operated as designed the following day. The contact stated that an unknown local dealer was contacted....

The contact owns a 2021 Tesla Model Y. The contact stated after placing the children in the vehicle, he was unable to enter the vehicle. The contact stated that the vehicle lost electric power while attempting to open the door with the key fob and with the phone App however, the door remained closed. The local Fire Department was contacted, and the contact was advised to break the window to remove the children from the vehicle. The contact broke the driver's side front window to remove the children as recommended by the Fire Department. The contact stated that the 12-volt battery had overheated; however, a report was not filed. The vehicle was taken to the dealer, but the vehicle was not diagnosed. The contact stated that the window was replaced, and the 12-volt battery was also replaced. The manufacturer was made aware of the failure. The failure mileage was approximately...

The contact owns a 2021 Tesla Model Y. The contact stated while driving 20–45 MPH on a six-lane highway, the contact attempted a hard acceleration, and there was an abnormal banging sound heard. The battery was disconnected. The pyrotechnic fuse went into failure mode. There were no warning lights illuminated. The vehicle slowed down, pulsated, and then shut down. The hazard lights, steering, and brake system became inoperable. The brake pedal was depressed to stop the vehicle from rolling. Additionally, while closing the driver's side door, the glass window fractured. The local dealer was contacted and retrieved a system failure with the 12-volt battery. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 58,044.