2020 SUBARU OUTBACK Visibilitywiper Problems

Windshield cracked for no apparent reason. Crack initiated at the top of the windshield and formed a curve to turn horizontal. Total length of crack approx. 18 inches.

I heard a pebble tap the windshield and I immediately saw a crack from the passenger side to the middle of the windshield. I just had the windshield replaced on 6 Aug 2021. It costs $600 just to calibrate the cameras. Then the cost of replacing the windshield. This isn't right. I've had plenty of vehicles and this is the worst windshield I have seen. The windshield didn't last 1600 miles. And this is the first time I have been back on the interstate since getting the windshield replaced in August. I am not happy and I think this is a safety hazard.

Windshield crack

Crack windshield The windshield just crack during driving on the freeway.

The car has had 3 windshields already replaced and the current windshield is broken and will need to be replaced. The car only had 9,800 miles on it. Afraid the visibility is greatly impacted. Several dealers have indicated that there are problems with the strength of the windshield on this auto/model. And the manufacturer has also implied that there may be issues. I am getting the dealership to inspect the windshield tomorrow (9/11/2021). I have not received any prior notification of windshield issues prior to current breakage. I first discovered the defective nature of the windshield on 9/9/2021. I have contacted independent repair shops to verify that this is not a sole incident and has occurred many times same makes and model.

Before driving I noticed a thin crack in the driver side lower part of windshield without hitting anything. - This is presumed to occur spontaneously. Consumer stated it is not a crack but a hard to remove substance and would like to remove the report.*JB

Windshield developed crack from lower edge 10 inches long with no indication of any damage.

Rearview mirror broke off of the windshield during normal use. At no time did I pull on the rearview mirror with excessive force.

Windshield has a Crack line from the center bottom edge of the Windshield going up towards the center to the right then left as it expands. It was parked and appeared the next morning with no sign of impact.

On 04/09/2020 the windshield spontaneously cracked across the lower right side while sitting in our garage. There was a very small etch that could have been caused by a small rock however we were never aware of a rock hitting the windshield. The first indication was the large crack after sitting in the garage over night. This windshield was replaced with new. On 07/26/2021 the windshield spontaneously cracked again, while driving, starting at the lower center and then immediately spreading across to the left side. There was no indication of a rock hitting the windshield though there is a small etch at the crack start point. I have had several windshields hit by rock which always only left at most a small crack at the hit point and never broke across the whole windshield like these two incidents. Both incidents resulted in distorted vision making driving dangerous.

Was driving on freeway and heard a pop and windshield developed a hairline crack from bottom and extended up as we continue driving. Not even a chip but immediately a crack. Windshield is too brittle.

A Small rock hit my windshield and the windshield instantly cracked. Subaru said the windshield was not covered under standard warranty and recommended a local glass company. The windshield was replaced with another Subaru windshield that cracked 3 days later while the car was parked inside my closed garage. The second windshield never got hit by anything - it just cracked for no reason. The glass company said it was a stress fracture. The initial fracture was right across my line of sight, making it difficult to see. The fracture continued to spread and new cracks were developing. I now have a third windshield on a car that is one year old.

My vehicle is about 15 months old. It has lots of tiny chips in the windshield. No cracks yet, but I've read about many other Subaru Outback owners with this problem.

While driving along the freeway, I heard a "pop" and noticed a crack along the windshield. It was along the passenger side, about 10"-12" above the dashboard, and went all the way to the passenger side edge of the windshield. There was a vehicle ahead of me, maybe 1/4 mile ahead. As I kept driving, it grew a little more towards the middle of the windshield. This is the third time this has happened to this vehicle, as the previous owner had to get the windshield replaced twice in the past 6 months.

Windshield cracked after a slight impact to the glass from something off the road. Car was purchased new in April 2020, first windshield was replaced in February 2021 and second windshield was replaced in July 2021. Three windshields in 15 months

Windhshield spontaneously broke in linear pattern, approximately 2ft in length, across passenger side, without spidering/inpact. Car was parked in open sun parking lot for apprimately 5 hours. Taken to Safelite autoglass for repair when they stated that they see 2-3 newer subaru’s a day for similar issues.

Driving north on the interstate with no other vehicles on the road. Windshield spontaneously cracked from passenger side defrost to middle of windshield. Took the car into the dealer, and they claimed a rock hit it because they could run their fingernail into the crack. I strongly disagree with Subaru’s maintenance division as I was there when it happened and there is no chip or star shaped damage from an impact of any object. The crack quickly spread across the entire length of the windshield.

Purchased new and front windshield spontaneously cracked in multiple directions overnight. No impact evidence at the center of the crack. Noticed online that many Outback owners are reporting this same problem. Not sure if it’s a defective windshield or body flex which caused windshield to flex and crack. I expect the windshield to be replaced by Subaru at no charge.

Today, 7/11/2021 my 3rd OEM Subaru windshield cracked spontaneously, while driving. All windshields were replaced at Beardmore Subaru, in Belleville, NE using Subaru replacement windshields. In all instances the windshield has cracked spontaneously without impact on either the passenger side or at the bottom of the windshield, near the middle. The cracks continue to propagate quickly while driving or when parked overnight, until the crack terminates on the side opposite the crack. This spontaneous cracking, is a safety hazard in that it not only compromises the integrity of the glass, but also can affect the Subaru EyeSight safety vision system, by impairing camera view thru the windshield if a crack propagates through the cameras field of view. This new instance means that in less than 10,000 miles I have had 4 windshields in this car. I have never had this occur on any vehicle I have owned previously, nor to...

2020 Subaru Outback purchased in January 2020 has had to have windshield replaced twice. I have owned dozens of vehicles and never had to replace a windshield more than once even on vehicles I owned for 10 - 15 years. The windshields clearly are defective as evidenced by the many complaints regarding windshields for multiple Subaru models over several years.

Windshield cracked without any incident. The crack is approximately 12 inches long and located on the drivers side of the vehicle. With no incident causing this crack, I am concerned that this crack may cause severe injuries and is an obvious safety concern.

On 4/01/2021 the windshield cracked while the car was parked inside my garage for some unknown reason. I scheduled and paid for a new windshield and eyesight calibration, which was installed by dealer (Briggs Subaru Topeka, Ks). Windshield cracked again two months later on 6/23/2021 for an unknown reason. The crack occurred while I was parked at work. There is no sign of a rock chip or other object cracking the windshield. I scheduled my car for an inspection on 7/01/2021 at the same dealership.

I was driving down the interstate with no cars around and my outback windshield cracked. I was far enough away from cars and I didn’t see anything hit the window. I heard a loud pop. A soft but quick pop, not like the sound of a rock hitting but different. Then I drove on down the road and saw a large crack forming from the bottom of the passenger side of the window. And there’s no dimple anywhere in the crack.

The front windshield cracked unexpectedly today while driving. There were no visible rock chips where the crack emanated from but I have noticed other chips in the glass. I only have 15,000 miles on this vehicle. There was a loud pop and a large crack appeared on my windshield.

Went to drive vehicle and found windshield cracked down the middle from top to bottom. No chips and no prior damage of any kind to windshield. Windshield spontaneously cracked for no reason whatsoever.

The front windshield of our 2020 Subaru Outback spontaneously cracked, impairing the ability to see outside. I drove the car yesterday with my wife in the passenger side (June 11, 2021), returning about 1500, and parked the car. We went out today, at about 1400 to go on an errand, not having driven the car since the previous day, and found a crack in the windshield. Compared to other cracks we've experienced in other cars, there is no impact area (and we didn't hear one when driving the previous day). See picture attached. There are no other drivers of this car in our home.

Windshield cracked while sitting in driveway, nothing hit the windshield.

I purchased a 2020 Subaru Outback XT in March 2020 (approximately 14 months of driving at the time of this submission). The vehicle currently has almost 15k miles on it. I recently had my fourth (4th!) windshield installed. The first replacement windshield was installed after a pebble the size of a grain of rice (I saw kicked up by a truck in front of me) hit the windshield and caused a large lateral crack the propagated. The vehicle had approximately 1500 miles at the point. The first replacement (OEM) cracked after hitting another pebble on the highway. I did not see the size this time because it was on the part of the windshield obstructed by the side posts on the outside of the windshield. The crack propagated horizontally across the entire windshield. This occurred at approximately 8K miles. The second replacement (aftermarket made to OEM specs) cracked after hitting...

Windshield cracked while on the freeway. I don't think anything hit it, we were driving at 75 MPH when we heard a crack, and instantly a crack went from the bottom left side of the windshield in an upward direction almost all the way across the center of the glass. The glass at the bottom left side where the crack started is broken deeply into the glass and may be all the way through. We are concerned that if a large rock hit the windshield it would break apart and fall into the car. I brought the car to the Subaru dealer we purchased the car from. The service manager looked at it and instantly said, rock hit, not covered and wouldn't talk to us after that. The car has less than 10,000 miles.

On one of my first times driving my new car to work on my morning commute I was traveling at a normal rate of speed and with a lot of distance from the car in front of me I heard a crack and saw the windshield beginning to show signs of a straight crack. That was December 15, 2020. Now on May 19, 2021 I have a crack from the far right side of the windshield and runs to the initial location, about 70% across my windshield.

Large, long windshield crack. No rocks or debris, nothing hit the windshield. I went out to my car one morning and there is a long crack in my windshield starting at the middle edge.

I AM ON MY 4TH WINDSHIELD. MY WINDSHIELDS KEEP CRACKING FROM CHIPS,, WHILE DRIVING ON HIGHWAYS.

WINDSHIELD SPONTANEOUSLY CRACKED OVERNIGHT WHILE NOT IN USE WITHIN 6 WEEKS OF PURCHASING NEW 2020 OUTBACK. CRACK HAS PROGRESSED TO SPAN ENTIRE WINDSHIELD.

WINDSHIELD FORMED A LARGE CRACK AT 2495 MILES (APPROX. 2/15/20) FROM LEFT BOTTOM CORNER TO CENTER ABOVE DRIVER POSITION. ONLY INDICATED CAUSE A 1/8 INCH SHALLOW SCRATCH. WINDSHIELD AGAIN CRACKED, ALMOST IDENTICAL SIZE AND POSITION AT 8934 MILES (APPROX.4/20/21), ONLY INDICATED DAMAGE A SMALL PIT AT LEFT BOTTOM. CRACKS ONLY APPEARED AFTER SITTING OVERNIGHT IN GARAGE---NOTHING NOTICED PRIOR. EMAIL WITH GM AT DEALER PRODUCED NO RESPONSE. TOTAL COST OF REPLACEMENTS $979.10. NO DAMAGE TO WINDSHIELDS OF 2 OTHER VEHICLES DRIVEN ON THE SAME ROUTES. IN MY OPINION, BOTH WINDSHIELD MARKS WERE EXTREMELY MINOR AND SHOULD NOT HAVE PRODUCED WINDSHIELD FAILURE.

VEHICLE WAS PARKED WHEN WINDSHIELD CRACKED. THERE WAS NO PREVIOUS DAMAGE TO THE WINDSHIELD BEFORE CRACKING. CRACK BEGAIN ON THE DRIVERS SIDE LOWER PORTION WHERE THE WINDSHIELD WAS PAINTED. ONGOING ISSUE WITH 2020 SUBARU OUTBACK WINDSHIELDS.

MY WINDSHIELD DEVELOPED A MASSIVE CRACK (ABOUT 6 IN VERTICAL AND 8 IN ACROSS) SPONTANEOUSLY. MY FIANCEE AND I WERE OUT RUNNING ERRANDS AND STOPPED INTO A SHOP. DURING THE DRIVE TO THE SHOP, WE DID NOT HEAR OR SEE ANY ROAD DEBRIS HIT THE WINDSHIELD. WHEN WE PARKED, THE WINDSHIELD WAS INTACT AND COMPLETELY NORMAL. ONCE WE COMPLETED OUR SHOPPING (ABOUT 30 MINUTES FROM THE TIME THAT WE PARKED), WE RETURNED AND FOUND OUR VEHICLE HAD THIS LONG, RIDICULOUS CRACK. TO REITERATE. MY CAR WAS AT A COMPLETE STOP AND PARKED. I WAS IN A PARKING LOT AND WAS AT LEAST 200 YARDS AWAY FROM THE NEAREST ROAD. NOW, I HAVE TO GET MY WINDSHIELD COMPLETELY REPLACED IN ORDER TO SEE CLEARLY. INCREDIBLY EXPENSIVE. I AM THE ORIGINAL OWNER OF THE VEHICLE, AND THIS OUTBACK HAS NEVER BEEN INVOLVED IN ANY ACCIDENTS OR WRECKS. MY FIANCEE AND I ARE...

WHEN DRIVING DOWN THE ROAD WINDSHIELD JUST STARTED CRACKING ON PASSENGER SIDE FROM BELOW THE WINDSHIELD WIPER BELOW THE WINDOW TRIM. WITHIN MINUTES IT WENT FROM A 3-4 INCH CRACK TO ENCOMPASSING THE MAJORITY OF THE RIGHT SIDE OF THE WINDOW. THIS IS THE SECOND INCIDENT WITH THIS WINDSHIELD. IN DECEMBER A SMALL PEBBLE BARELY TAPPED THIS DRIVER'S SIDE AND CAUSED AN INSTANT GOUGE.

THE WINDSHIELD ON MY OUTBACK CRACKED WITH NO WARNING OR IMPACT. I HAD PULLED OUT OF MY DRIVEWAY AND WAS JUST BEGINNING TO MOVE FORWARD ON MY STREET WHEN I HEARD A SOUND IN THE CABIN. I DIDN'T KNOW WHAT IT WAS BUT LOOKED AROUND AS I REACHED A NEARBY STOP SIGN. THERE IS A LARGE Y-SHAPED CRACK FROM THE TOP OF MY WINDSHIELD, PARTIALLY HIDDEN BY THE REAR VIEW MIRROR.

A 12 INCH CRACK IN THE WINDSHIELD APPEARED AFTER I HEARD A LOUD SHARP SOUND. THE VEHICLE WAS IN MOTION TRAVELING 55 MPH ON A FOUR LANE HIGHWAY (BRILEY PARKWAY) IN NASHVILLE, TENNESSEE.

WITHOUT ANY WARNING, AND WITH NO ANTECEDENT ROCK OR OTHER IMPACT, WINDSHIELD INCURRED LARGE DIAGONAL CRACK. AT THE TIME, CAR WAS BEING DRIVEN ON A HGHWAY IN GOOD WEATHER.

DRIVING AND NOTICED A CRACK ON MY WINDSHIELD. AS I CONTINUED TO DRIVE I CAN HEAR THE GLASS MAKING CRACKING SOUNDS AND THE CRACK STARTED TO SPREAD FAST ACROSS THE WINDSHIELD. DID NOT DRIVE VEHICLE FOR OVER 2 WEEKS AND CRACK GREW WITHIN THE TIME FRAME.

SPONTANEOUS WINDSHIELD CRACK. LOWER EDGE OF DRIVERS SIDE CRACK. 25 MPH ZONE WITH NO TRAFFIC IN FRONT OF ME. BECOMING LARGER TOWARDS PASSENGER SIDE, EACH DAY, CURRENTLY MID WINDSHIELD. I HAVE HAD TO MAKE A CLAIM WITH INSURANCE TODAY.

SMALL ROCK HIT WINDSHIELD ON INTERSTATE, LEAVING A NICE CHIP WITH FIVE LINES COMING OUT. IN THE AM FOUND 2 LINES EXPANDED SEVERAL INCHES OUTWARD. -THIS IS THE 2ND TIME I HAD A WINDSHIELD BREAK IN THE THIS CAR (IN THE LAST YEAR)! MILEAGE IS AT 19000, OWNED NEW 1.5 YRS.

ON 9/27/2021 I BOUGHT A NEW 2020 SUBURU OUTBACK FROM CAMELBACK SUBURU IN PHOENIX AZ. WE HAVE NOW HAD TWO WINDSHIELDS CRACK STARTING FROM THE LEFT A PILLAR AND CONTINUE ACROSS THE REST OF THE WINDSHIELD IN SHORT ORDER. BOTH WINDSHIELDS CRACKED FROM THE SAME SPOT WITHOUT ANY CAUSE, IE ROCKS ETC. THE DEALERSHIP IS CLAIMING IT IS FROM ROCKS. ABSOLUTELY NOT. I BELIEVE THEY KNOW EXACTLY WHAT IS GOING ON AND ARE DEFRAUDING ME OUT OF A LEGITIMATE MANUFACTURERS WARRANTY CLAIM. I HAVE TALKED WITH MY INSURANCE AGENT AND THIS WILL BE AN ISSUE WITH THEM WITH TWO CLAIMS IIN SUCH A SHORT TIME.

WHILE DRIVING NORTH ON A STRAIGHT STRETCH OF I-15 IN MONTANA ON A SUNDAY AFTERNOON AROUND 6:30PM THE FRONT WINDSHIELD OF MY 2020 SUBARU OUTBACK RANDOMLY CRACKED FROM LOW ON THE PASSENGER SIDE TO THE MIDDLE OF THE WINDSHIELD BELOW THE REAR VIEW MIRROR. THERE WERE NO OTHER CARS ON THE ROAD AND THERE WAS NO NOTICEABLE IMPACT TO THE WINDSHIELD. ROAD CONDITIONS SEEMED SMOOTH AT THE TIME OF THE CRACK AND THE WEATHER WAS CLEAR AROUND MID 40 DEGREES F. THE CAR HAD BEEN RUNNING FOR SEVERAL HOURS SO THE INSIDE TEMPERATURE SHOULD HAVE BEEN STABLE WITH NO WILD TEMPERATURE SWINGS. INSPECTION OF THE WINDSHIELD AFTER THE EVENT SHOWS NO SIGNS OF CHIPS OR IMPACTS NEAR THE CRACK. THE CAR HAS APPROXIMATELY 6,000 MILES ON IT WITH NO OTHER MECHANICAL ISSUES NOTED.

THE WINDSHIELD ON OUR 2020 SUBARU OUTBACK WAS NOT CRACKED WHEN I PARKED IT IN THE GARAGE ONE NIGHT. THE NEXT AFTERNOON WHEN WE GOT IN TO DRIVE TO THE GROCERY STORE, THE WINDSHIELD HAD AN UNEXPECTED CRACK APPROXIMATELY 14 INCHES LONG, ON THE PASSENGER SIDE, ABOUT 1/3 OF THE WAY DOWN FROM THE TOP, GOING HORIZONTALLY ACROSS THE WINDSHIELD. THIS CRACK CAME SEEMINGLY OUT OF NOWHERE. THE VEHICLE SEEMS TO HAVE BEEN STATIONARY WHEN THIS OCCURRED. WE HAVE HAD THE CAR FOR ABOUT SIX MONTHS. THIS CRACK APPEARED ON SUNDAY AND IS HUGE, WE WILL NEED THE WINDSHIELD REPLACED.

BOUGHT THE VEHICLE BRAND NEW AND WOKE UP THE NEXT DAY TO IT NOT STARTING. THE CAR WAS SOLD TO US WITH A BAD BATTERY AND MISSING PARTS ACCORDING TO THE DEALERSHIP. ALMOST EXACTLY A YEAR LATER OUR TRANSMISSION BLEW FOR NO APPARENT REASON WHILE GETTING OFF THE HIGHWAY AND COMPLETELY STOPPED RUNNING. NOW THE VEHICLE HAS A CRACKED WINDSHIELD WHEN NO ROCKS OR ANYTHING HAS HIT IT.

WINDSHIELD CRACKED FROM THE LOWER CENTER WHILE PARKING IN THE GARAGE. NO KNOWN IMPACT HAPPENED.

WINDSHIELD HAS CHIPPED 3 TIMES IN THE LAST MONTH AS OF 4/7/21 ON OUR 2020 OUTBACK, FROM EXTREMELY LIGHT AND TINY ROAD DEBRIS/ROCK STRIKES. NOW HAS A 4TH, LARGER CHIP NEAR THE BASE OF THE WINDSHIELD WITH A 18" CRACK THAT GREW OVER THE COURSE OF A FEW HOURS. ALL OCCURRED WHILE IN MOTION ON HIGHWAYS. ALL DURING MILD WEATHER. ALL WERE FROM ROCKS ALMOST TOO SMALL TO SEE. THE SAME THING HAPPENED WITH OUR 2018 SUBARU. SUBARU NOW OFFERS WINDSHIELD COVERAGE AT ADDITIONAL CHARGE. SALESMAN NOTED THAT IT WAS "BECAUSE THEY USE THINNER GLASS DUE TO THE EYESIGHT SYSTEM". THIS WOULD SUGGEST SUBARU KNOWS THERE IS A PROBLEM.

WINDSHIELD HAS CRACKED TWICE WITHIN 15 MONTHS. BOTH CRACKS STARTED AS SMALL CHIPS AND QUICKLY (WITHIN HOURS) TURNED INTO LARGE CRACKS SPANNING THE MAJORITY OF THE WINDSHIELD. BOTH CHIPS OCCURRED WHILE DRIVING ON HIGHWAY.