2006 SATURN ION Electrical System Problems

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

PER WITNESSES MY DAUGHTER'S SATURN ION HIT THE REAR OF A SEMI TRUCK THAT HAD STOPPED ON NORTHBOUND I-81 NEAR MILE MARKER 210.5. THE WITNESSES STATE THAT THE AIR BAGS DID NOT DEPLOY. THE CAR CAUGHT FIRE AND WAS DESTROYED. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE VEHICLE HAS STALLED ON NUMEROUS OCCASIONS WITH THE KEY LOCK WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED THREE TIMES OVER A PERIOD OF THREE YEARS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO COULD NOT DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 54,000.

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED WHILE TRAVELING AT VARIOUS LOW SPEEDS, THE ENGINE STALLED WITH THE ILLUMINATION OF THE WARNING INDICATOR. THE VEHICLE ENGINE AND RESUMED NORMALLY. THE FAILURE RECURRED INTERMITTENTLY. THERE WAS A RECALL RELATED TO THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS , ELECTRICAL SYSTEM); HOWEVER , THE PART NEEDED TO PERFORM THE REPAIR WAS CURRENTLY UNAVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 78,000.

2006 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE IGNITION PROBLEMS. *SMD THE CONSUMER STATED A YEAR AGO, SHE COULD NOT TURN THE IGNITION KEY, AND A MESSAGE STATED THE KEY DID NOT MATCH THE IGNITION AND WAS LOCKED. AFTER AN HOUR, THE VEHICLE FINALLY STARTED. THE REPAIR SHOP WAS UNABLE TO FIND A PROBLEM. IT HAPPENED 3 MORE TIMES. *JB THE CONSUMER RECEIVED A RECALL LETTER, REGARDING THE POWER STEERING. HOWEVER, THE PARTS WERE NOT AVAILABLE. UPDATED 09/08/14

DRIVER ATTEMPTED TO SHUT OFF CAR WHEN PARKING. KEY WOULD NOT TURN AND CAR REMAINED RUNNING. VEHICLE WAS THEN DRIVEN TO LOCAL GM SERVICE DEALER WHO CONFIRMED THAT KEY WAS STUCK. SERVICE ORDER CAUSE WAS LISTED AS "FOUND IGNITION LOCK CYLINDER FROZEN". DEALER DID MANAGE TO REMOVE AND REPLACE IGNITION LOCK CYLINDER. CUSTOMER PAID FOR REPAIR. *TR

THIS CAR HAS BEEN CURSED WITH ELECTRONIC STEERING PROBLEMS. THE CAR HAS BEEN SERVICED REPEATEDLY. I HAVE HAD VERY LITTLE RESPONSE AND ZERO SATISFACTION FROM GM. THE KEY OFTEN DOES NOT RELEASE FROM THE IGNITION. THE CAR WAS INVOLVED IN A VIOLENT FRONT END COLLISION THAT WAS CAUSED BY THESE ISSUES. I BOUGHT THE CAR (BASED ON A FALSE SATURN PROMISE) AND I HAD TWO DAUGHTERS IN THE FRONT OF THE CAR DURING THE PREVENTABLE COLLISION. I COULDN'T FIGURE OUT WHY THE BAGS DID NOT DEPLOY. NOW I GET IT! THE CAR CUTS OFF WHEN MAKING A RIGHT HAND TURN. I DO NOT BELIEVE A SINGLE THING THAT GM SAYS TO ME. I AM GOING IN FOR A RENTAL CAR TOMORROW. I. DO NOT EVEN BELIEVE THAT THIS WILL GO ACCORDING TO PLAN. I TAKE THE CAR FOR SERVICE, THEY TELL ME THAT THEY, "CANNOT REPEAT THE PROBLEM." GM SUCKS...

THIS CAR HAS BEEN CURSED WITH ELECTRONIC STEERING PROBLEMS. THE CAR HAS BEEN SERVICED REPEATEDLY. I HAVE HAD VERY LITTLE RESPONSE AND ZERO SATISFACTION FROM GM. THE KEY OFTEN DOES NOT RELEASE FROM THE IGNITION. THE CAR WAS INVOLVED IN A VIOLENT FRONT END COLLISION THAT WAS CAUSED BY THESE ISSUES. I BOUGHT THE CAR (BASED ON A FALSE SATURN PROMISE) AND I HAD TWO DAUGHTERS IN THE FRONT OF THE CAR DURING THE PREVENTABLE COLLISION. I COULDN'T FIGURE OUT WHY THE BAGS DID NOT DEPLOY. NOW I GET IT! THE CAR CUTS OFF WHEN MAKING A RIGHT HAND TURN. I DO NOT BELIEVE A SINGLE THING THAT GM SAYS TO ME. I AM GOING IN FOR A RENTAL CAR TOMORROW. I. DO NOT EVEN BELIEVE THAT THIS WILL GO ACCORDING TO PLAN. I TAKE THE CAR FOR SERVICE, THEY TELL ME THAT THEY, "CANNOT REPEAT THE PROBLEM." GM SUCKS...

ON COLD MORNINGS CAR WILL NOT START. RADIO AND LIGHTS WORK. THE PASSLOCK SECURITY LIGHT ON THE DASH BLINKS. LEAVING KEY IN IGNITION FOR TEN MINUTES THEN THE CAR WILL START. *TR

KEYS OFTEN GET STUCK IN IGNITION UPON TURNING THE ENGINE OFF. TIME IT TAKES TO GET KEYS OUT VARIES. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD AND WAS RESTARTED. ONCE THE CONTACT REACHED HER DESTINATION, THE KEY WOULD NOT TURN IN THE IGNITION TO SHUT THE VEHICLE OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO REPLACED THE IGNITION SWITCH. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,400.

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE POWER STEERING SENSOR LIGHT ILLUMINATED AS THE POWER STEERING ASSIST MALFUNCTIONED. THE FAILURE MADE IT VERY DIFFICULT FOR THE CONTACT TO MANEUVER THE VEHICLE. THE CONTACT ALSO STATED THAT THE IGNITION KEY WOULD BECOME STUCK IN THE IGNITION SWITCH RECURRINGLY. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT BOTH DEFECTS WERE CAUSED BY A FAULTY IGNITION SWITCH. THE IGNITION SWITCH WAS REPLACED BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT CONTACTED IN REFERENCE TO THE DEFECTS. THE FAILURE MILEAGE WAS 107,000.

COULD NOT SHUT OFF ENGINE. HAD IGNITION, KEYS AND ELECTRICAL REPLACED AT MY EXPENSE OF $751.40. GMC DEALER REFUSES TO REIMBURSE ME FOR THE EXPENSE I INCURRED FOR RECALL 14063 AND NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION CAMPAIGN ID NUMBER FOR THIS REDALL IS 14V-047. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE SHE ATTEMPTED TO START THE VEHICLE BUT THE KEY WOULD NOT TURN IN THE IGNITION SWITCH. THE FAILURE WAS RECURRING. ADDITIONALLY, THE KEY WOULD BECOME STUCK IN THE IGNITION OR WOULD NOT TURN WHEN THE CONTACT ATTEMPTED TO SHUT THE ENGINE OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IGNITION SWITCH WOULD NEED TO BE REPLACED. THE MECHANIC REPLACED THE IGNITION SWITCH. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 55,000.

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT AFTER STARTING THE ENGINE, THE KEY BECAME STUCK IN THE IGNITION SWITCH AND THE VEHICLE COULD NOT BE TURNED OFF. THE CONTACT INDICATED THAT ON SOME OCCASIONS THE BATTERY WOULD BECOME DRAINED BECAUSE THE KEY COULD NOT BE REMOVED. THE VEHICLE WAS DIAGNOSED AND REPAIRED BY THE DEALER AND THE IGNITION SWITCH WAS REPLACED BUT THE FAILURE PERSISTED. THE DEALER THEN REPLACED THE IGNITION MICRO SWITCH AND THE DEFECT WAS REMEDIED. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 25,000.

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE WAS RECURRING. ADDITIONALLY, THE CONTACT WOULD HAVE TO MOVE THE KEY AROUND IN THE IGNITION AND APPLY EXTREME FORCE TO THE BRAKE PEDAL BEFORE BEING ABLE TO INSERT OR REMOVE THE KEY FROM THE IGNITION. THE CONTACT ALSO STATED THAT THE POWER STEERING ASSIST WOULD SPORADICALLY FAIL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER HOWEVER, THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT LATER RECEIVED NOTIFICATION THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V047000 (AIR BAGS AND ELECTRICAL SYSTEM) AFTER THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

A NEW IGN LOCK CYLINDER WAS REPLACED AT FIRESTONE IN DUBUQUE, IOWA, BECAUSE THE CAR WOULD NOT TURN OFF EVEN WITH THE KEY EXTRACTED FROM THE IGNITGION. THE CAR HAD BEEN SHUTTING DOWN WHILE OUR DAUGHTER WAS DRIVING THE CAR FOR ABOUT A WEEK. REPAIR COST $374.26 OUR DAUGHTER BEING AT COLLEGE DID NOT DRIVE THE CAR MUCH THE REST OF THE MONTH AND CAME HOME TO DECORAH, IOWA, AND ON THE WAY HOME AND WHILE HOME THE CAR CONTINUED TO SHUT ITSELF OFF, WITH THE LAST TIME BEING ON A HILL SHE WAS ABLE TO COAST INTO A PARKING SPACE, BUT THE CAR HAD TO BE TOWED TO THE DEALERSHIP IN DECORAH, WHERE REPORT SHOWS: CHECKED FOR CODES B1443 DEVISE IGNITION OFF, RUN AND CRANK, B2957; SECURITY SYSTEM SENSOR CIRCUIT LOW VOLTAGE, B2958 SECURITY SYSTEM; DATA HIGH, B1441, CHECKED FUSES AND WIRING( ALL WORKED AT THIS TIME);REMOVED AND REPLACED...

#1. KEY. IN 2008 THE KEY STARTED GETTING STUCK IN THE IGNITION WHEN I ATTEMPTED TO TURN THE CAR OFF. THE CAR KEPT RUNNING. IT WOULD TAKE UP TO 10 TRIES BEFORE THE ENGINE STOPPED. EVEN THEN I COULD NOT ALWAYS GET THE KEY TO COME OUT RIGHT AWAY. I COULD NOT GET THE KEY TO TURN WHEN TRYING TO START THE CAR. THE KEY OFTEN WOULD ALSO GET STUCK IN THE IGNITION AND I COULD NOT GET IT OUT AND WOULD HAVE TO LEAVE IT IN. 2014 I COULD NOT GET IT TO COME OUT AT ALL AND AT ONE POINT THE CAR WOULD NOT SHUT OFF. MECHANIC REPLACED (AT MY EXPENSE) THE IGNITION. #2. WHEN I PURCHASED THE CAR AN ADD ON OFFERED WAS A PASSIVE KILL SWITCH CALLED ID SYSTEM. REPEATEDLY THE AIR BAG LIGHT WOULD COME ON, AND THE ON-STAR SYSTEM ALSO NOTIFIED ME. IT WOULD...

THE CAR WOULD NOT START ON SEVERAL OCCASIONS. WOULD HAVE A HARD TIME TURNING THE KEY IN THE IGNITION AND IT WILL START AFTER 15-20 MINUTES. THIS WOULD HAPPEN ANYWHERE, ANYTIME. SO, WE TOOK IT TO THE DEALER BIDDULPH MAZDA, WHICH IS WHERE WE PURCHASED IT. THEY SERVICED THE CAR. THEY TESTED THE STARTER, THERE WAS NOTHING WRONG WITH THE STARTER. THEY COULD NOT PIN POINT THE PROBLEM, SO THEY TOLD US TO HAVE A NEW KEY MADE. GOT A NEW KEY MADE, BUT THE PROBLEM CONTINUED. TO THIS DAY, IT STILL HAPPENS OCCASIONALLY. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT SHE WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION SWITCH. THE CONTACT INDICATED THAT THE BATTERY HAD TO BE DISCONNECTED IN ORDER TO TURN OFF THE POWER TO THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 58,000.

MY CAR WAS BEING PARKED IN MY DRIVEWAY ON JANUARY 4TH AROUND 12:30 A.M., WHEN THE KEY WOULD NOT TURN THE CAR OFF, NOR WOULD IT COME OUT OF THE IGNITION. THAT JUST SO HAPPENED TO BE THE WEEKEND OF THE FAMOUS POLAR VOPRTEX, FEATURING A SNOW STORM AND RECORD-BREAKING FREEZING TEMPERATURES. I DROVE MY CAR TO THE NEAREST REPAIR SHOP, AND REQUESTED AN EMERGENCY ROAD SERVICE TECHNICIAN THROUGH MY INSURANCE COMPANY. WHEN HE ARRIVED, THE ONLY WAY HE COULD TURN THE CAR OFF WAS TO REMOVE A FUSE. ONCE EXAMINED ON 1/8/14 BY THE REPAIR SHOP, IT WAS DETERMINED THAT THE CAR WOULD THEN HAVE TO BE TOWED TO THE NEAREST GENERAL MOTORS DEALER, ADVANTAGE CHEVROLET IN BOLINGBROOK, IL. AFTER BEING NOTIFIED BY THE DEALERSHIP OF WHAT THE PROBLEM WAS, BEING QUOTED THE PRICE OF $431.00 TO REPAIR IT, I RESEARCHED THE IGNITION SWITCH PROBLEM AND DISCOVERED OVER 500...

I WAS REAR ENDED ON THE FREEWAY ON 11/17/13. I WENT TO GET IT FIXED ABOUT A WEEK LATER. THEY HAD MY CAR FOR ABOUT 3 DAYS. WHEN I WENT TO PICK UP MY CAR, THERE WAS NO POWER STEERING. WHEN THE GENTLEMAN TRIED TO PUT POWER STEERING FLUID IN IT, HE NOTICED IT WAS ELECTRIC. HE SAID IT MUST HAVE GONE OUT. NOW I HAVE TO PAY TO FIX MY POWER STEERING AND I DIDN'T HAVE MY CAR WHEN IT WENT OUT! *TR

ON SOME COLD DAYS, THE CAR WILL NOT START. THIS IS AN INTERMITTENT PROBLEM. THE LIGHTS, RADIO, ETC. WILL TURN ON WHEN THE KEY IS TURNED, BUT THE CAR WILL NOT START AND THE ANTI-THEFT INDICATOR LIGHT WILL BLINK. YOU HAVE TO WAIT ANYWHERE FROM 10-30 MINUTES FOR THE ANTI-THEFT SYSTEM TO RESET TO ALLOW THE VEHICLE TO START. I ONLY HAVE THIS PROBLEM ON COLD DAYS. THIS HAS HAPPENED MULTIPLE TIMES AND WE'VE CONTACTED GM TWICE, BUT THEY SAY THEY HAVE NEVER HEARD OF ANY COMPLAINTS. *TR

EACH TIME I KILL THE ENGINE I HAVE TO SIT AND WAIT FOR THE STRING OF ELECTRONIC TICS TO QUIT BEFORE MY CAR WILL LET GO OF THE KEY. EACH EPISODE SEAMS TO DIFFER ON THE LENGTH OF TIME IT, TAKES OR DECIDES, TO LET GO OF THE KEY. *TR

I WAS DRIVING MY 2006 SATURN ION ON A LOCAL STREET, PICKING UP MY CHILD FROM SCHOOL, WHEN THE IGNITION WENT OFF. THE CAR HAD NO POWER & I HAD ONLY A FEW SECONDS TO STEER THE CAR OFF TO THE SIDE BEFORE THE POWER STEERING STOPPED WORKING. I PUT THE CAR IN NEUTRAL & COASTED TO A STOP. I TURNED THE CAR OFF, WAITED A MINUTE, & THEN TURNED THE KEY AGAIN. AT THAT TIME, THE CAR STARTED UP AGAIN & I TOOK IT DIRECTLY HOME. IN THE DAYS FOLLOWING THIS INCIDENT, SEVERAL DIFFERENT TIMES THE IGNITION WOULD GO OF BY ITSELF. IT FELT AS IF THE KEY WAS NOT STAYING IN THE ON POSITION. NOT BEING AWARE OF A WARRANTY FROM SATURN, I TOOK IT TO A LOCAL REPAIR SHOP. WHEN THE MECHANIC TRIED TO TAKE THE KEY OUT OF THE IGNITION, IT WOULD NOT TURN OFF OR...

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF ALL OF THE WARNING GAUGES. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE IT WAS RESTARTED AND FUNCTIONED NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND REPAIR. THE BATTERY WAS REPLACED BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE MANUFACTURER WAS NOTIFIED ABOUT THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 52,000.

I BOUGHT MY CAR USED OFF OF A USED CAR LOT, THE POWER STEERING WAS RECALLED AND IT GOT FIX, BUT NOW THE ELECTRICAL SYSTEM IS MESSED UP. MY CAR ALARM WILL GO OFF ALL HOURS OF THE NIGHT, THE WINDOWS WONT ROLL ALL THE WAY UP AND THE KEY GETS STUCK IN THE IGNITION AND I CAN'T TURN MY CAR OFF. MY DRUM BRAKES ON THE BACK ABSOLUTELY SHATTERED ON THE INSIDE OF THE DRUM. *TR

DROVE TO LOCAL MARKET, 5 MINUTES FROM MY HOME, KEY STUCK IN ON POSITION, COULD NOT TURN CAR OFF, DROVE BACK HOME, CONTACTED ON-STAR ROAD SIDE ASSISTANCE-FUSE TO DISENGAGE FUEL PUMP WAS PULLED AND BATTERY DISCONNECTED (IT WAS THE ONLY WAY TO TURN OFF THE CAR)-CAR TOWED TO GM DEALER REPLACEMENT OF IGNITION SWITCH WITH CORE DRILLING TO FIX VEHICLE-COST $340.00 PLUS COST OF RENTAL CAR FOR 2 DAYS! *TR

VEHICLE OPERATOR TRIED TO TURN OFF MOTOR WHILE IN A PAID PARKING LOT. KEY WAS STUCK IN IGNITION AND CAR WOULD NOT SHUT OFF. DEALER STATIONS WERE CLOSED AT TIME OF INCIDENT. OPERATOR RETURNED 30 MILES HOME AFTER VARIOUS ATTEMPTS TO REMOVE KEY AND A FAMILY MEMBER DISCONNECTED THE BATTERY. NEXT DAY THE BATTERY WAS RECONNECTED AND OPERATOR WENT TO DEALERSHIP WHERE IGNITION LOCK CYLINDER, HOUSING AND KEY WERE REPLACED FOR $461.47 PLUS TAX. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION II. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGNITION SWITCH AND HE UNABLE TO TURN THE VEHICLE OFF. THE CONTACT MENTIONED THAT HE HAD TO DISCONNECT THE BATTERY IN ORDER TO TURN OFF THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 127,000.

WITH REGARDS TO THE 2006 SATURN ION, MY ION HAS SUFFERED THREE OF THE MAJOR PROBLEMS DESCRIBED IN THE COMPLAIN SECTION OF THE NHTSA WEB SITE. {1} FUEL LEAKING FROM FUEL PUMP AREA. {2} IGNITION KEY GETS STUCK IN THE ON POSITION CAR CAN NOT BE SHUT OFF. {3} POWER STEERING STOPS WORKING WHILE CAR IS RUNNING MAKING IT DIFFICULT TO STEER. WITH REGARDS TO THE LAST PROBLEM I BROUGHT MY CAR TO A G.M. DEALER AND WAS ADVISED THAT THE PROBLEM WAS THE POWER STEERING MOTOR. THEY REPLACED THE MOTOR AT NO CHARGE.TELLING ME IT WAS UNDER WARRANTY. THEY ALSO ADVISED ME THAT THERE WAS A RECALL REGARDING THE FUEL PUMP MODULATOR. I AM NOW FIGHTING WITH GM TO TRY AND GET MY MONEY BACK. WITH REGARDS TO THE STICKING KEY IN THE IGNITION I BELIEVE THAT IF WE GET ENOUGH COMPLAINANTS MAYBE NHTSA CAN DO SOMETHING. IF YOU...

AFTER DRIVING VEHICLE AND ARRIVING AT DESTINATION, THE NORMAL ATTEMPT TO TURN OFF IGNITION AND VACATE VEHICLE FAILED INSOMUCH THAT IGNITION KEY FAILED TO TURN TO THE OFF POSITION DUE TO A STUCK IGNITION CYLINDER. CAR COULD NOT BE TURNED OFF AND REMOVING BATTERY TERMINAL FAILED TO KILL THE ENGINE. ONLY AFTER A CRITICAL FUSE WAS REMOVED WOULD THE ENGINE DIE. INTERNET SEARCHES HAS REVEALED A CHRONIC TREND FOR THIS FAILURE AND TYPICAL REPAIR COSTS AT DEALERSHIPS AVERAGE OVER $400. IF THIS FAILURE SHOULD OCCUR AT AN ACCIDENT SCENE WHERE THERE IS SPILLED FUEL THE CONSEQUENCES COULD BE LIFE THREATENING. I AM APPALLED THAT GM HAS NOT ISSUED A RECALL TO WHAT IS OBVIOUSLY EITHER A FLAWED DESIGN OR THE USE OF INADEQUATE MATERIALS IN THE CONSTRUCTION OF THEIR IGNITION LOCK ASSEMBLY. *TR

IN THE SUMMER OF 2010, WHILE ATTEMPTING TO TURN OFF MY CAR MY KEY BECAME STUCK IN THE IGNITION. ALL ATTEMPTS TO REMOVE KEY FAILED AND HAD CAR TOWED TO DEALERSHIP. WAS TOLD THAT LOCK IGNITION FELL APART AND NEEDED TO BE REPLACED. BECAUSE CAR WAS STILL UNDER WARRANTY I DID NOT HAVE TO PAY FOR REPAIR. NEARLY THREE YEARS LATER (JUNE 2013), I WAS ATTEMPTING TO TURN OFF MY CAR AND KEY WAS STUCK IN ON POSITION. AGAIN ALL ATTEMPTS TO GET KEY OUT FAILED. HAD TO GET SERVICE TECHNICIAN TO TURN OFF CAR BY REMOVING FUSE IN CAR TO TURN IT OFF. TOWED CAR TO DEALERSHIP AND WAS TOLD THAT LOCK IGNITION NEEDED TO BE REPLACED AGAIN. THIS TIME CAR WAS NOT UNDER WARRANTY AND I HAD TO PAY OUT OF POCKET FOR REPAIR AND RENTAL CAR. LESS THAN ONE MONTH LATER I HAD BEGUN TO SMELL GAS...

KEY BECAME STUCK IN IGNITION. COULD NOT REMOVE, CAR WOULD NOT SHUT OFF. EMERGENCY IGNITION RELEASE DID NOT WORK. TOOK CAR TO AUTHORIZED GM DEALER, WAS TOLD THE IGNITION CYLINDER AND HOUSING HAD FALLEN APART AND NEEDED TO BE REPLACED, AND THAT IT IS FREQUENTLY SEEN WITH THIS CAR MODEL. TOTAL REPAIR COST $569.97. *TR

IN AUGUST OF 2008 AT APPX 37000 MILES, THE IGNITION SWITCH LOCKED IN THE 'RUN' POSITION. SINCE THE CAR WAS A MANUAL, I STALLED IT OUT AND CALLED A LOCKSMITH, WHO COULD NOT REMOVE OR TURN THE KEY EITHER. HE DISCONNECTED THE CAR FROM THE BATTERY SO THAT IT WOULD NOT DRAIN DUE TO THE ACCESSORIES STILL BEING ACTIVE. HE TOLD ME HOW TO RECONNECT THE BATTERY SO THAT I COULD DRIVE IN FOR REPAIRS. I HAVE NOT HAD ANY MORE PROBLEMS UNTIL YESTERDAY (JUNE 2013) AT APPX 100000 MILES. THE IGNITION WOULD NOT TURN BEYOND THE ACCESSORIES POSITION. AFTER SEVERAL ATTEMPTS, KEY POSITIONS, CLUTCH POSITIONS, I WAS ABLE TO START THE CAR AND IMMEDIATELY DROVE IT TO A REPAIR CENTER. I HAVE SEEN NUMEROUS SIMILAR COMPLAINTS ON THIS WEBSITE AND YET THERE ARE NO RECALLS FOR THIS FAULTY IGNITION PROBLEM. I HAVE HAD THE ISSUE FROM BOTH SIDES (COULDN'T...

MY SATURN ION HAS HAD TO HAVE THE IGNITION AND OR THE STEERING COLUMN REPLACED ON FOUR SEPARATE OCCASIONS SINCE 29,000 MILES .IT CURRENTLY HAS 143,000 MILES AND HAS ISSUES ONCE AGAIN. EACH TIME EITHER THE KEY WOULD CLICK BACK ONLY ONE NOTCH AND COULD NOT BE REMOVED, THE CAR COULD NOT BE TURNED OFF AT ALL DUE TO THE KEY BEING "FROZEN" IN THE CYLINDER OR THE KEY WOULD NOT SPRING BACK FROM THE STARTING POSITION TO THE RUN POSITION THUS MAKING A GRINDING NOISE AFTER CAR STARTED. THE LAST DEALERSHIP SAID THEY WERE GOING TO REPORT THE INCIDENT TO GM AS THEY HAVE DONE FOR OTHER CAR OWNERS BEFORE, BUT WITH NO RESULT. EACH TIME IT HAS COST ME ANYWHERE FROM $350. TO $700.00 NOT INCLUDING TOWING AND RENTING OF AN ALTERNATE VEHICLE. I UNDERSTAND THAT IT TECHNICALLY NOT A SAFETY ISSUE BUT I FEEL THIS SHOULD BE...

THE IGNITION WOULDNT TURN OFF, THE KEY CAME OUT, LEAVING THE CAR RUNNING. I TRIED WIGGLING THE KEY, CHECKING THE SHIFTER, EVERYTHING, THIS IS THE 2ND TIME THIS HAS HAPPENED. IVE SEEN AN EXTREME AMOUNT OF COMPLAINTS ABOUT THIS, AND FEEL SOMETHING SHOULD BE DONE, GM IS LOOSING A LOT OF BUSINESS DUE TO NOT SOLVING THIS ISSUE. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE IGNITION FAILED AND THE KEY COULD NOT BE TURNED OR RELEASED FROM THE IGNITION TO SHUT OFF THE ENGINE. THE BATTERY AND FUEL SENSOR WAS DISCONNECTED IN ORDER TO POWER THE VEHICLE OFF. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 100,000.

I WAS DRIVING MY SATURN ION 2 UNDER NORMAL CONDITIONS 5/6/13. I PARKED THE VEHICLE AND ATTEMPTED TO TURN IT OFF BUT THE KEY WOULD NOT MOVE. THE IGNITION WAS LOCKED. I COULD NOT TURN OFF THE ION. I DROVE TO A MECHANIC, WHO DISCONNECTED THE BATTERY. I PAID $292.68 FOR A NEW IGNITION LOCK AND IGNITION CYLINDER. I SEE HUNDREDS OR THOUSANDS OF SIMILAR COMPLAINTS ONLINE YET AT NO POINT DID GM NOTIFY ME OF THE POTENTIAL PROBLEM NOR OFFER TO FIX IT. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT HE WAS UNABLE TO TURN THE IGNITION TO THE OFF POSITION TO REMOVE THE KEY. THE VEHICLE REMAINED POWERED ON AND THE CONTACT HAD TO DISCONNECT A WIRE UNDER THE STEERING COLUMN TO TURN OFF THE VEHICLE. THE CHECK ENGINE WARNING LIGHT WOULD OCCASIONALLY ILLUMINATE. THE VEHICLE WAS INSPECTED BY THE DEALER HOWEVER THE CAUSE OF THE FAILURE WAS UNDETERMINED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT OFFERED NO FURTHER ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 57,117.

THE KEY STICKS IN IGNITION AND THE CAR CAN'T BE TURNED OFF UNLESS THE BATTERY IS DISCONNECTED OR THE FUEL PUMP IS DISCONNECTED. THIS CAUSES A SAFETY HAZARD TO THE AVERAGE USER, LIKE MYSELF, WHO ISN'T AWARE WHAT NEEDS TO BE DONE POSES THE RISK OF BEING SHOCKED OR BURNED TRYING TO TURN OFF THE CAR. *TR

MY KEY BECAME STUCK IN THE IGNITION AND WOULD NOT TURN WHILE THE CAR WAS STILL RUNNING. I HAD TO PULL THE FUEL INJECTOR FUSE AND DISCONNECT MY BATTERY TO TURN THE CAR OFF. IN RESEARCHING THIS PROBLEM ONLINE, I'VE FOUND THAT TONS OF OTHER SATURN OWNERS HAVE ENCOUNTERED THIS SAME PROBLEM WITH THEIR IGNITION CYLINDERS. I BELIEVE SINCE THIS IS SUCH AN EXPENSIVE AND COMMON PROBLEM, THAT THERE SHOULD BE A RECALL MADE ON THIS PART. *TR

MY CAR WILL NOT START WHEN IT IS COLD IT HAS TO WARM UP BEFORE IT WILL START RIGHT UP NOW WHEN IT IS WARM OUT SIDE NOT COLD IT STARTS RIGHT UP. THEN MY KEY GOT STUCK IN THE ON POSITION AND COULD NOT CUT THE CAR OFF. HAD TO LOOK ON GOOGLE FOR OTHER SIMILAR PROBLEMS TO FIND OUT HOW TO GET THE CAR TO TURN OFF. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY WAS UNABLE TO BE REMOVED FROM THE IGNITION AND THE CONTACT WAS UNABLE TO POWER OFF THE VEHICLE. ALSO, THE CONTACT MENTIONED HE WAS ABLE TO SWITCH GEARS WITHOUT DEPRESSING THE BRAKE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THAT THE IGNITION KEY CYLINDER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 78,000.

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION AND THE CONTACT WAS UNABLE TO POWER OFF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING AND WAS ADVISED THAT A FOREIGN OBJECT HAD BECOME FRACTURED INSIDE OF THE IGNITION SWITCH. THE DEALER REPLACED THE IGNITION SWITCH. THE FAILURE MILEAGE WAS 69,000.

KEY LOCKS UP IN IGNITION AND WILL NOT TURN TO OFF POSITION. KEY IS STUCK AND WILL NOT RELEASE FROM IGNITION. TO GET KEY OUT CAR MUST BE TURNED TO ON POSITION AND BACK OFF AGAIN. FRIENDS OF OURS ALSO HAD A SATURN ION FROM 2005 AND THEY HAD THE SAME ISSUE. THE KEY WOULD BECOME STUCK IN THE IGNITION AND THEY WOULD HAVE TO START THE CAR AND TURN IT OFF (SOMETIMES SEVERAL TIMES) TO GET THE KEY OUT. OUR WORRY IS THAT THE PROBLEM WILL BECOME MORE EXTREME AND DANGEROUS WHERE WE CANNOT TURN THE CAR OFF (AS I HAVE READ IN OTHER COMPLAINTS) AS WELL AS NOT BEING ABLE TO EVENTUALLY FREE THE KEY. THIS IS A DEFECT THAT NEEDS TO BE RECALLED AND FIXED! *TR

PUT THE KEY IN AND NOW IT WILL NOT SHUT OFF....HAD TO PULL FUSE...KEY WILL NOT TURN BACK AND CAN NOT GET IT OUT. *TR

WHEN I TRY TO TAKE OUT MY KEY I CAN NOT REMOVE IT. I AM ABLE TO TURN OFF THE MOTOR, BUT THEN THE KEY IS STUCK IN THAT POSITION AND I CAN NOT REMOVE IT. I AM CONCERN THAT THEY KEY COULD STICK IN THE POSITION WHERE THE CAR IS STILL RUNNING OR THAT IT WON'T COME OUT AT ALL.. I SOMETIMES HAVE TO STAY IN MY CAR FOR 2-3 MINUTES, SO THAT I CAN REMOVE THE KEY. I KNOW I CAN REMOVE THE KEY WHEN THE CAR MAKES A CERTAIN SOUND. IT IS A SOFT CLICK, AS IF SOMETHING IS RELEASED. IT SOUNDS SIMILAR TO THE WHEN YOU UNLOCK YOUR CAR DOORS WITH THE AUTOMATIC SWITCH, BUT QUIETER. THE KEY STICKS 1-2 TIMES/WEEK AT LEAST. (I USE MY CAR TWICE A DAY, TO AND FROM WORK, THIS HAS BEEN GOING ON SINCE I PURCHASED THE CAR SEVERAL YEARS...

THIS VEHICLE WAS PURCHASED BRAND NEW AND DRIVEN VERY LITTLE. PROTECTED IN CLOSED IN GARAGE. DROVE TO COLORADO SPRINGS FOR VACATION AND WENT TO VISIT RELATIVES. PARKED VEHICLE IN FRONT OF RELATIVE HOME AND THE KEY COULDN'T BE TURNED TO SHUT OFF THE CAR. FORTUNATELY THERE WAS A NEIGHBOR OF MY RELATIVES THAT NEW HOW TO SHUT IT OFF BY DISCONNECTING THE BATTERY CABLES. TO START THE CAR THE CABLES HAD TO BE HOOKED BACK UP. DROVE TO FERGUSON BUICK GMC IN COLORADO SPRINGS AND THEY CHECKED IT. THE TUMBLER CAME APART, WON'T TURN OFF , REPLACED IGNITION LOCK. WAS CHARGED FOR HOUSING KIT (15857948), CODE CYL, CYLINDER KIT (20869121), LABOR AND COST OF PARTS TOTALLED $614.22. WITH ONLY 16, 607 MILES FROM 2006 TO 2012 THIS SHOULD NOT HAVE HAPPENED. TODAY, NOVEMBER 30, 2012, I WENT TO DRIVE MY VEHICLE AND WHEN I STARTED THE ENGINE ALL THE LIGHTS...

TL* THE CONTACT OWNS A 2006 SATURN ION 2. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS MERGED TO THE SIDE OF THE ROAD AND AFTER WAITING TEN MINUTES THE VEHICLE RESTARTED. THE FAILURE OCCURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THE FAULTY ANTI THEFT PASS LOCK WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS UNAVAILABLE.