2006 SATURN ION Engine Problems

Airbags

TL* THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING APPROXIMATELY 15-20 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO VANDERGRIFF CHEVROLET (LOCATED AT 1200 W INTERSTATE 20, ARLINGTON, TX 76017, (682) 323-2486) TO BE DIAGNOSED, BUT THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE CONTACT STATED THAT THE FAILURE RECURRED FIVE TIMES. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.

TL* THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING VARIOUS SPEEDS ON DIFFERENT OCCASIONS, THE BRAKE PEDAL WAS DEPRESSED AND THE VEHICLE STALLED. IN ADDITION, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART AND WAS TAKEN TO CHEVROLET OF DOVER (1450 S DUPONT HWY, DOVER, DE 19901, (302) 760-9956), BUT THE DIAGNOSIS AND REPAIRS WERE UNKNOWN TO THE CONTACT. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 185,000.

TAKATA RECALL THE ENGINE IS ON. WHEN I TURN THE KEY TO TURN THE ENGINE OFF, THE KEY DOESN'T GO IN THE OFF POSITION. I HAVE TO TURN THE ENGINE ON AGAIN AND THEN TRY TO TURN THE ENGINE OFF.SOMETIMES 2 OR 3 TIMES I HAVE TO TURN THE ENGINE ON AND THEN TRY TO TURN THE ENGINE OFF. THE CAR IS PARKED.

ENGINE REDUCTION, SERIOUS SAFETY CONCERN, WAS ALMOST HIT BY A SEMI, ENGINE REDUCTION LIGHT COMES ON, LOSE POWER AND CAR SLOWS AT A HIGH RATE CAUSING EXTREME SAFETY HAZARD IN TRAFFIC, MUST PULL OFF INTERSTATE TURN CAR OFF TO RESET, HAPPENING 2-3 TIMES A DAY, STRONG SMELL OF GAS, HAVE A LEAK AND IT IS NOT COVERED UNDER THE WARRANTY, SOONER OR LATER SOMEONE IS GOING TO BE CRUISING DOWN THE INTERSTATE AND THEIR SATURN IS GOING TO REDUCE ENGINE POWER AND THEY WILL NOT HAVE TIME TO GET OUT OF THE WAY, THEY WILL BE PLOWED DOWN BY A SEMI. ARE WE GOING TO CONTINUE TO ALLOW GM TO IGNORE THIS ISSUE LIKE THEY IGNORED THE IGNITION SWITCH PROBELMS UNTIL IT STARTS CAUSING DEATHS, WHY NOT SOLVE THE ISSUE BEFORE THE DEATHS START TO OCCUR, IT SEEMS THE OLDER THESE YEAR MODELS GET THE WORSE THIS PROBLEM BECOMES. I...

TL* THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 175,400. UPDATED 10/19/16*LJ THE CONSUMER STATED WHILE DRIVING, THE STEERING LOCKED UP. SHE HAD TO REDUCE HER SPEED INTO ORDER TO MAINTAIN THE STEERING WHEEL. THE CONSUMER TURNED THE VEHICLE OFF, AND THE STEERING RESET IT SELF. THE CONSUMER HAS SINCE EXPERIENCED A SIMILAR INCIDENT. UPDATED 11/03/16.*JB

CAR INSPECTION REJECTED CODEB0092 PASS PRESENSE SYSTEM1 PERFORMANCE JUST PUT CATALIT CONVERTER AND AN ENGINE IN THIS CAR LOOKING FOR TECH. SERVICE BUL. TSB3677 CAR IS REJECTED DEMED UNSAFE TO DRIVE

A FEW WEEKS AGO I NOTICED A SMELL OF FUEL COMING FROM MY CAR WHEN I STOP, OR SLOW DOWN. THE LAST COUPLE DAYS THE SMELL HAS BIN GETTING STRONGER.. I SEE ALL THESE COMPLAINTS, BUT NOTHING BEING DONE OR IT ONLY FOR A FEW STATES. AS A SINGLE MOTHER OF TWO I DON'T FEEL SAFE HAVING MY KIDS IN THE CAR.

I WAS LEAVING A LOCAL GROCERY STORE, STARTED MY CAR AND PROCEEDED TO DRIVE OUT OF THE PARKING LOT TO THE MAIN ROAD, ROUTE 611, A FAIRLY BUSY THOROUGHFARE. AS I TURNED RIGHT AND ATTEMPTED TO ACCELERATE, THE CHECK ENGINE LIGHT CAME ON AS WELL AS THE 'REDUCED ENGINE POWER LIGHT'. DESPITE PRESSING ON THE THE GAS PEDAL TO ACCELERATE SAFELY INTO THE FLOW OF TRAFFIC (AROUND 40 MPH), MY CAR WOULD NOT ACCELERATE PAST 10 MILES PER HOUR. I AM SO VERY LUCKY THAT I WAS NOT IN AN ACCIDENT. I FOLLOWED THE INSTRUCTION IN THE SATURN ION MANUAL WHICH SAYS TO TURN OFF THE CAR AND THE ERROR SHOULD CLEAR ITSELF AFTER 10 MINUTES. I DID THIS AND THE 'REDUCED ENGINE POWER LIGHT' WENT OUT BUT NOT THE CHECK ENGINE LIGHT. I TOOK THE CAR IMMEDIATELY TO MY LOCAL MECHANIC WHO RAN A INCONCLUSIVE DIAGNOSTIC TEST. THEY CLEARED...

WHILE DRIVING THE CAR WILL AUTOMATICALLY SHUT OFF. I CAN BE ON THE FREEWAY AT 55 MILES AND THE CAR WILL JUST DIE. I CAN BE AT A STOP LIGHT AND THE CAR WILL DIE. I HAVE TAKEN IT IN AND TWICE THEY SAID THEY FOUND NOTHING HOWEVER THE PROBLEM STILL EXIST. I THOUGHT THAT WITH THE RECALL REPAIR OF THE IGNITION SWITCH IT MIGHT HELP BUT IT HASN'T AND MY KEY STILL GETS STUCK IN THE IGNITION AT TIMES AND I DON'T EVEN HAVE ANYTHING HANGING ON THE KEY ONLY THE REMOTE. BASICALLY ONCE YOU FEEL THE CAR LOSING POWER AND ALL DASH LIGHTS SHOW UP, YOU NEED TO RESTART THE CAR TO PROCEED. VERY DANGEROUS ESPECIALLY ON THE ROAD. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION 3. THE CONTACT STATED THAT WHILE WAITING AT A STOP SIGN, THE ENGINE STALLED AND THE CHECK ENGINE WARNING INDICATOR WAS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO DEALER OR INDEPENDENT MECHANIC. THE CONTACT RECEIVED A RECALL NHTSA CAMPAIGN NUMBER: 14E021000 (ELECTRICAL SYSTEM). THE VEHICLE WAS TAKEN TO DEALER. THE VEHICLE WAS REPAIRED BUT THE PROBLEM RECURRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

IT WAS ABOUT 32 DEGREES IN THE MORNING. I STARTED MY CAR AND WARMED IT UP FOR ABOUT 5 MINUTES OR SO. LONG ENOUGH TO DEFROST BOTH THE FRONT AND REAR WINDOWS. I DROVE A LITTLE OVER MILE GOING ABOUT THE CITY SPEED LIMIT OF 45. THE VEHICLE STARTED SHAKING FROM THE ENGINE AREA. I PULLED OFF THE ROAD INTO A PARKING LOT AND THE VEHICLE BEGAN TO LOSE POWER. I WAS ABLE TO COAST INTO A PARKING SPACE. THE CHECK ENGINE LIGHT CAME ON AT SOME POINT. I TURNED THE VEHICLE OFF, I WAITED A FEW MINUTES AND TURNED THE VEHICLE BACK ON. IT STARTED FINE I DROVE IT THE 10 MILES TO THE DEALERSHIP WITH NO PROBLEMS, CHECK ENGINE LIGHT WAS STILL ON. THE DEALERSHIP ADVISED THAT THE ICE HAD FORMED ON THE THROTTLE BODY AND WHEN IT MELTED WATER GOT INTO THE THROTTLE BODY. HE COULD PUT...

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED BY THE AUTHORIZED DEALER FOR NHTSA CAMPAIGN NUMBERS: 09V419000 (FUEL SYSTEM, GASOLINE) AND14E021000 (ELECTRICAL SYSTEM). THE SERVICE ENGINE SENSOR ILLUMINATED BEFORE AND AFTER BOTH RECALL REPAIRS. THE CONTACT INDICATED THAT THE DEALER REPLACED THE IGNITION SWITCH AND THE FUEL PUMP, BUT THE FAILURE RECURRED. THE CONTACT INDICATED THAT THE SERVICE ENGINE SENSOR CONTINUED TO ILLUMINATE AND THE VEHICLE STALLED REPEATEDLY. THE TWO RECALL REPAIRS DID NOT REMEDY THE VEHICLE AND THE FAILURES WERE HAPPENING INTERMITTENTLY. THE VEHICLE WAS TOWED TO THE AUTHORIZED DEALER FOR FURTHER INSPECTION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 18,900.

TL* THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 64,000.

JUST ENTERED ONTO A HIGHWAY AND SUDDENLY COULD NOT ACCELERATE. WHEN HITTING THE GAS PEDAL, CAR WOULD NOT ACCELERATE. THE CAR WAS IN DRIVE AND HAD BEEN MOVING FOR 10 MINUTES PRIOR WITH NO ISSUES. NO PRIOR ISSUES BEFORE THIS. PULLED OFF THE SIDE OF THE HIGHWAY AND TURNED OFF CAR. WHEN TURNED ON AGAIN, WOULD NOT CRANK. LIGHTS WORKED FINE BUT CAR JUST WOULDN'T TURN ON. MECHANIC IS NOT SURE WHY CAR WON'T START STILL. *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT THEN SHIFTED THE VEHICLE INTO NEUTRAL AND RESTARTED THE VEHICLE. THE PROBLEM RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER: 14V047000 AIR BAGS , ELECTRICAL SYSTEM) AND THE DEALER STATED THAT THE PARTS WERE UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

LOST POWER/CONTROL WHILE DRIVING, FELT LIKE THE BOTTOM OF THE CAR WAS FALLING OUT, UPON REPAIR WAS INFORMED A BAD IGNITION COIL. *TR

I PURCHASED MY 2006 SATURN ION 3 IN 2008 FROM A DEALERSHIP. I HAVE HAD ALL THE RECALL ISSUES HAPPEN TO MY VEHICLE. 1) I HAVE REPLACED THE IGNITION SWITCH AND CYLINDER TWICE DUE TO THE CAR BEING UNABLE TO SHUT OFF. THIS HAPPENED IN 2008 AND AGAIN IN 2012. BOTH TIMES IT WAS COVERED UNDER WARRANTY AND REPAIRS WERE DONE BY GM DEALERSHIP. EVEN THOUGH THESE HAVE BEEN REPLACED I WAS TOLD THEY NEED TO BE REPLACED AGAIN UNDER THE RECALL BECAUSE THOSE PARTS ARE FAULTY AS WELL. I HAVE BEEN IN CONTACT WITH THE DEALERSHIP AND WAS TOLD THEY DO NOT HAVE THE PARTS YET AND WILL LET ME KNOW WHEN THEY ARE AVAILABLE. 2) IN NOVEMBER 2013 MY VEHICLE SMELLED OF GAS AND WAS MAKING ME AND MY CHILDREN SICK. I HAD IT CHECKED OUT AT THE DEALERSHIP AND IT WAS THE FUEL MODULE. THIS WAS COVERED...

ON OR ABOUT 9/12/2012, I WAS DRIVING IN MY SATURN ION GOING 45 MILES AN HOUR, IN HEAVY MORNING TRAFFIC, WHEN IN AN INSTANT MY CAR DECELERATED AND WAS AT A SLOW CRAWL. I COULD NOT GET ANY ACCELERATION EVEN WHEN PRESSING THE GAS. I WAS ONLY A COUPLE BLOCKS AWAY FROM WORK, SO I COASTED UNTIL I GOT THERE. I WAS ALMOST HIT. BUT I COULD NOT GO ANY FASTER. I WAS AFRAID TO TURN OFF THE CAR FOR FEAR THAT IT WOULD NOT START UP AGAIN. I WAS AFRAID TO DRIVE IT AND I CALLED TO HAVE IT TOWED TO THE DEALERSHIP TO HAVE IT LOOKED AT. HENDERSON CHEVROLET LOOKED AT IT AND SAID THAT IT WAS THE COMPUTER MOTHERBOARD OF THE CAR. THIS WAS REPLACED AT A COST TO ME OF $800.00+. IT HAPPENED AGAIN ON 11/20/12. THE CAR WENT FROM 30 TO 5 MILES PER HOUR...

I FIRST BOUGHT MY 2006 SATURN ION IN MARCH OF 2013. THREE DAYS LATER I NOTICE THAT WHEN I WOULD GET ON THE HIGHWAY MY CAR WOULD SWAY EXTREMELY BAD. OUR HWY SPEED IS 75. GOING 70MPH WAS TOO MUCH AND IT WOULD SWAY A LOT. MIND YOU I WAS PREGNANT AT THE TIME. THE CAR SPUN OUT AS I WAS EXITING THE HIGHWAY. I WAS TERRIFIED BECAUSE CARS WERE RIGHT BEHIND ME. THANK GOD I GOT OUT OF THE WAY BEFORE I GOT HIT. YOU CAN UNDERSTAND HOW UPSET I WAS DUE TO THE FACT THAT I WAS 4MONTHS PREGNANT AT THE TIME. SINCE THEN MY HUSBAND HAS SPUN OUT 5 TIMES DRIVING OUR CAR. WE'VE TAKING IT TO THE MECHANICS MULTIPLE TIMES AND THEY DON'T EVEN KNOW WHAT TO DO WITH IT. OUR WHEEL ALIGNMENTS ARE FINE. ALSO, OUR KEY GETS STUCK IN THE IGNITION A LOT UPON...

2006 SATURN ION. CONSUMER WRITES IN REGARDS TO VEHICLE ELECTRICAL SYSTEM ISSUES. *SMD RECENTLY, THE EMERGENCY BRAKE THE CONSUMER STATED THE CHECK ENGINE LIGHT ILLUMINATED TWICE AND FINALLY, THE FUEL INJECTORS WERE REPLACED. RECENTLY, THE EMERGENCY BRAKE LIGHT ILLUMINATED AND STAYED ON WITHOUT THE EMERGENCY BRAKE BEING PULLED. ALSO, WHEN SHE PUSHED THE SHIFTER KNOB, THERE WAS A NOISE IN THE STEERING COLUMN. THERE WAS AN ISSUE WITH THE ELECTRICAL POWER STEERING. IT WOULD GO OUT AND RESUME NORMAL OPERATION, WHILE DRIVING. *JB THE CONSUMER STATED SHE HEARD A KNOCKING NOISE, WHEN SHE DROVE OVER A BUMP AND THE CHECK ENGINE LIGHT ILLUMINATED AGAIN. UPDATED 08/06/14

I WAS DRIVING THE 2006 SATURN ION IN MY NEIGHBORHOOD. I REACHED THE INTERSECTION AT THE END OF MY STREET AND CAME TO A STOP/YIELD. AS I TOOK MY FOOT OFF THE BRAKE TO SHIFT TO THE GAS AND BEGAN STEERING TO TURN LEFT, THE ENGINE SUDDENLY TURNED OFF. THE BATTERY LIGHT ON THE DASH APPEARED. I WAS ABLE TO PUT THE CAR IN PARK, TURN OFF THE VEHICLE, AND RESTART IT. I RETURNED HOME INSTEAD OF CONTINUING MY TRIP. MY VEHICLE IS AFFECTED BY THE RECALL WITH CAMPAIGN ID NUMBER 14V-047. I HAD REMOVED ALL ADDITIONAL KEYS FROM MY KEYRING AS RECOMMENDED IN THE THREE RECALL LETTERS I RECEIVED, BUT I STILL BELIEVE THAT THIS ISSUE WAS RELATED TO THE ISSUE THE IGNITION SWITCH. I HAVE CHOSEN TO FILE THIS COMPLAINT BECAUSE ONE OF THE LETTERS I RECEIVED FROM [XXX]OF GM ASSERTED THAT THE VEHICLE WAS SAFE TO DRIVE...

VEHICLE'S ENGINE SHUT OFF WHILE OPERATING, HOWEVER ELECTRICAL REMAINS ON. USUALLY HAPPENS GOING OVER SPEED BUMPS AT LOW SPEEDS. HAD TO TURN OFF AND RESTART ENGINE TO OPERATE. INCIDENT OCCURRED 2 TIMES IN 2009. DIDN'T GIVE MUCH THOUGHT UNTIL IT STARTED TO RECUR IN 2012. HAS HAPPENED 3-4 TIMES SINCE. ALSO KEY GETS STUCK WHEN TRYING TO SHUT VEHICLE OFF. THE KEY GETTING STUCK WHEN TRYING TO SHUT OFF HAS OCCURRED ALMOST DAILY FOR THE PAST 4 MONTHS. DIDN'T REALIZE THE INCIDENTS WERE RELATED UNTIL I HEARD ABOUT THE SATURN RECALL ON IGNITION SWITCHES AND HEARD ABOUT SIMILAR PROBLEMS. *JS

VEHICLE DOESN'T TURN ON IN BELOW FREEZING TEMPERATURES. HAS HAPPENED ON MULTIPLE OCCASIONS. ELECTRICAL WORKS, BUT ENGINE WON'T TURN OVER, JUST MAKES A CLICKING NOISE. AFTER TEMPERATURE WARMS, VEHICLE WILL START. *JS

THE CAR WILL OCCASIONALLY START RIGHT UP OR IT SOMETIMES TAKE ANYWHERE FROM 2 MINUTES TO 10 MINUTES TO GET STARTED. HAVE HAD THE ALTERNATOR LOOKED AT AND THAT IS FINE. CARS LIGHTS AND EVERYTHING TURNS ON AND TESTED THE BATTERY THAT IS FINE. CAR SIMPLY WON'T GO INTO THE RUN POSITION. MAYBE THE NEW FIX WILL CHANGE THIS WITH THE RECALL BUT JUST ANOTHER PROBLEM THAT I HAVE SEEN DOCUMENTED ONLINE AND HAVE EXPERIENCED CONSTANTLY. *JS

A NEW IGN LOCK CYLINDER WAS REPLACED AT FIRESTONE IN DUBUQUE, IOWA, BECAUSE THE CAR WOULD NOT TURN OFF EVEN WITH THE KEY EXTRACTED FROM THE IGNITGION. THE CAR HAD BEEN SHUTTING DOWN WHILE OUR DAUGHTER WAS DRIVING THE CAR FOR ABOUT A WEEK. REPAIR COST $374.26 OUR DAUGHTER BEING AT COLLEGE DID NOT DRIVE THE CAR MUCH THE REST OF THE MONTH AND CAME HOME TO DECORAH, IOWA, AND ON THE WAY HOME AND WHILE HOME THE CAR CONTINUED TO SHUT ITSELF OFF, WITH THE LAST TIME BEING ON A HILL SHE WAS ABLE TO COAST INTO A PARKING SPACE, BUT THE CAR HAD TO BE TOWED TO THE DEALERSHIP IN DECORAH, WHERE REPORT SHOWS: CHECKED FOR CODES B1443 DEVISE IGNITION OFF, RUN AND CRANK, B2957; SECURITY SYSTEM SENSOR CIRCUIT LOW VOLTAGE, B2958 SECURITY SYSTEM; DATA HIGH, B1441, CHECKED FUSES AND WIRING( ALL WORKED AT THIS TIME);REMOVED AND REPLACED...

MY DAUGHTER WAS GOING TO WORK - SHE BACKED OUT OF OUR DRIVEWAY - PUT THE CAR IN DRIVE - STARTED FORWARD AND THE CAR ENGINE CUT OFF - SHE COULD NOT STEER THE CAR AND RAN INTO TWO OTHER CARS ON OUR STREET - HIT ONE IN THE SIDE AND THE OTHER VEHICLE IN THE FRONT ON ITS DRIVER SIDE - WE CALLED SATURN AND NOTIFIED THEM OF THE ISSUE - THEY SENT A TOW TRUCK AND TOOK IT 70 MILES TO THE NEAREST DEALERSHIP - THEY SAID THAT THEY HAD TO CALL IN A SPECIAL REPRESENTATIVE TO CHECK IT OUT - HE CALLED US BACK AND SAID THAT HE COULD NOT FIND ANYTHING IN THE COMPUTER THAT WOULD HAVE CAUSED THE ISSUE AND TOLD US TO COME BACK AND GET THE CAR (ABOUT A 140 MILE TRIP TO PICK UP A CAR WE WERE AFRAID OF WHICH WE...

WHILE TRAVELING BETWEEN 70-75MPH ON I-35 SOUTHBOUND BETWEEN 2ND ST. MERGE AND 15TH STREET EXIT IN EDMOND OK, WE WENT TO CHANGE LANES (MIDDLE LANE TO RIGHT LANE) AND THERE WAS A SUDDEN BOOM, THE CAR LOST CONTROL, BEGAN TO SPIN OUT OF CONTROL (NUMEROUS SLIDES AND 2-360 DEG TURNS AND BEING FLUNG IN A BACKWARDS MOTION). AS WE ATTEMPTED TO GET TO THE SIDE OF THE ROAD, OUR CAR BEGAN TO SPIN OUT OF CONTROL - WE SPUN INTO A 360 DEGREE TURN, CAR CAUGHT FIRE AS THE OIL WAS DUMPED FROM MY CAR AND SPRAYED ALL ALONG THE UNDERNEATH OF MY CAR AND TIRES, WE SLID SIDEWAYS TOWARDS CONCRETE BARRIER SEPARATING N-S BOUND TRAFFIC, WENT INTO A SECOND 360 DEGREE TURN, SLID SIDEWAYS - AS WE STARTED HEADING ONCE AGAIN FORWARD TOWARDS ONCOMING TRAFFIC THE VEHICLE SUDDENLY STARTED GOING BACKWARDS (EVEN THOUGH CAR WAS IN DRIVE)... WE FINALLY...

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT WAS DRIVING 65 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MERGED OFF ROAD AND RESTARTED THE VEHICLE. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000. *TR

TL* THE CONTACT SUBMITTED AN EMAIL COMPLAINT AND REQUESTED TO HAVE THE COMPLAINT SUBMITTED VERBATIM TO THE EMAIL SUBMISSION.RE: 2006 SATURN ION GENERAL MOTORS CASE NUMBER: 71-1262884818 DEAR MS. DAVIS: I AM WRITING THIS LETTER TO EXPRESS MY EXTREME DISSATISFACTION WITH A RECENT REPAIR THAT WAS DONE ON MY 2006 SATURN ION. ON SATURDAY, JANUARY 4, 2014, MY SON ARRIVED HOME WITH MY CAR AND SAID HE COULD NOT TURN THE CAR OFF. FINDING THIS STRANGE, I WENT OUTSIDE TO TRY, AND COULD NOT REMOVE THE KEY FROM THE IGNITION OR TURN OFF THE CAR. I CALLED EMERGENCY ROAD ASSISTANCE TO SEE IF THEY COULD ASSIST ME. UPON THEIR ARRIVAL, THEY COULD NOT GET THE KEY OUT, SO I HAD THE TECHNICIAN TO FOLLOW ME TO THE NEAREST AUTO REPAIR SHOP. ONCE THERE, THE EMERGENCY ROAD TECHNICIAN RECEIVED INSTRUCTIONS OVER THE PHONE ON HOW TO AT LEAST TURN THE CAR...

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE STALLED WITH THE ILLUMINATION OF ALL OF THE WARNING GAUGES. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE IT WAS RESTARTED AND FUNCTIONED NORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND REPAIR. THE BATTERY WAS REPLACED BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE MANUFACTURER WAS NOTIFIED ABOUT THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 52,000.

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHILE TRAVELING 68 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE IT WAS RESTARTED. THE VEHICLE FUNCTIONED NORMALLY AND WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 50,000.

THE IGNITION WOULDNT TURN OFF, THE KEY CAME OUT, LEAVING THE CAR RUNNING. I TRIED WIGGLING THE KEY, CHECKING THE SHIFTER, EVERYTHING, THIS IS THE 2ND TIME THIS HAS HAPPENED. IVE SEEN AN EXTREME AMOUNT OF COMPLAINTS ABOUT THIS, AND FEEL SOMETHING SHOULD BE DONE, GM IS LOOSING A LOT OF BUSINESS DUE TO NOT SOLVING THIS ISSUE. *TR

ON AND OFF FOR THE PAST YEAR MY CAR HAS HAD MOMENTS WHEN IT WOULD SHUT OFF WHILE I AM DRIVING. AT FIRST IT WOULD HAPPEN WHEN I MAY ACCELERATE OUT OF A PARKING SPACE. ONE DAY I'M JUST DRIVING DOWN A PARKWAY AT ABOUT 40MPH, AND THE CAR JUST SHUT OFF. THE RADIO STAYED ON BUT THE ENGINE JUST SHUT OFF. LUCKILY NO OTHER CARS WERE NEAR ME AT THAT POINT. I TOOK MY CAR TO SEVERAL MECHANICS AND THEY ALL SAID IT MAY BE THE BATTERY. WE CHANGED THE BATTERY AND THAT DIDN'T STOP THE PROBLEM. MOST RECENTLY, I PULLED OUT INTO ON COMING TRAFFIC. I COULDN'T HAVE BEEN, AT THAT MOMENT, MORE THAN 10MPH AND THE CAR SHUT OFF AGAIN WITH CARS RAPIDLY SPEEDING UP ON ME AND MY CAR NOT MOVING. IT WAS TERRIFYING AND I NO LONGER FEEL SAFE DRIVING THIS VEHICLE. *TR

I STARTED SMELLING GAS WHEN WAS STOPPED. I FIGURED THERE MAY BE A LEAK. I TOOK IT TO A SHOP AND THEY SAID I HAVE ONE. I RESEARCHED ONLINE AND FOUND THAT THERE WAS A RECALL ON PARTS OF THE FUEL SYSTEM BUT THAT IT DOESN'T APPLY IN MY STATE. SO NOW IM GOING TO HAVE TO PAY THE $600 OR SO TO GET IT FIXED. *TR

I AM NOT ABLE TO TURN OFF THE CAR. THE KEY WILL NOT TURN TO SHUT OFF THE CAR. I HAD TO FIND THE FUSE FOR THE IGNITION IN ORDER TO BE ABLE TO TURN OFF THE CAR. I HAVE READ THAT THERE ARE MANY PEOPLE HAVING THIS ISSUE AND THIS COULD HAVE BEEN A DISASTER IF I WERE OUT OF TOWN. I CAN'T BELIEVE THERE IS NOT A RECALL FOR THIS ISSUE. THIS ALSO HAPPENED TO MY SON WHO HAS THE SAME MODEL AND YEAR THAT I HAVE. I DON'T KNOW HOW I AM GOING TO GET GAS AS YOU HAVE TO TURN THE CAR OFF TO DO THIS, AS IT IS A FEDERAL REGULATION. *TR

I WAS GOING DOWN ROAD, STEERING BECAUSE HARD, TRANSMISSION BECAME STUCK, PWR STR LIGHT CAME UP ON MILEAGE SCREEN AND THE ENGINE LIGHT CAME ON. I WAS READING THAT OTHERS HAVE HAD PROBLEM WITH STEERING COLUMN. PLEASE LET ME KNOW. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT MANAGED THE VEHICLE TO THE SHOULDER AND REALIZED THAT THE POWER STEERING HAD ALSO FAILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 48,000. UPDATED 7/31/12 *CN THE CONSUMER STATED THE VEHICLE SUDDENLY LOST POWER STEERING AT A HIGH SPEED OF 65 MPH. IT WAS DIFFICULT TO TURN OFF THE ROAD, BUT HE MANAGED TO DO SO. IT OCCURRED AGAIN AT SLOWER SPEEDS, TOO. THE CONSUMER STATED HE READ ONLINE THAT STOPPING THE VEHICLE, AND TURNING IT OFF WOULD RE-ACTIVATE THE POWER STEERING FOR AWHILE. THE DEALER REPLACED THE POWER STEERING MOTOR FREE OF CHARGE. UPDATED 08/01/12

BOUGHT MY SATURN ION 2 2006 IN 2005 OBVIOUSLY BRAND NEW AND WAS TALKED INTO PURCHASING A $1500 BUMPER TO BUMPER WARRANTY. I IMMEDIATELY HAD PROBLEMS BUT WAS TOLD BY SATURN MECHANICS NOTHING WAS WRONG WITH MY CAR. IN 2009 AS I WAS GETTING HOME THE KEY GOT STUCK IN THE IGNITION AND WOULDN'T TURN OFF, I COULDN'T TURN OFF THE CAR AT ALL. I WAS LUCKY THAT THE DEALERSHIP WAS OPEN AND ABLE TO UNPLUG THE BATTERY. THEY FIXED IT BUT THE WARRANTY WOULDN'T PAY, SO I PAID OUT OF POCKET TO FIX IT. WELL, LAST SUNDAY IT HAPPENED AGAIN, IN 105 DEGREE HEAT. I HAD NO WHERE TO TAKE IT SINCE DEALERSHIPS ARE CLOSED SUNDAYS. MY CAR RAN FOR OVER 5 HOURS BECAUSE NO ONE COULD FIGURE OUT HOW TO UNPLUG THE BATTERY. ONLY A PROFESSIONAL KNOWS HOW TO TURN OFF THE CAR SAFELY, YET MANY PEOPLE RISKED...

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED THAT THE POWER STEERING WARNING LIGHT ILLUMINATED AND THE STEERING WHEEL SEIZED. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD SPORADICALLY STALL WITHOUT WARNING. THE VEHICLE RETURNED TO NORMAL OPERATION WHEN IT WAS RESTARTED AFTER THE FAILURES. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURES DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 86,000.