2016 RAM 1500 Structurebody Problems

The tailgate on my 2016 Dodge Ram will not stay locked and falls open during cold weather. I've contacted the dealer but they said this particular vin is not included in a recall. I've accessed the inside panel on the tailgate several times to clean and lubricate, but it only works for a short time. It's been a continuous problem for the last 5 to 6 years...only when it is cold.

RAM has an extended warranty out regarding the front strap for the fuel tank that is known to fail. When the strap failed, the fuel tank dropped causing a gouge in the drive shaft. In addition to the compromised drive shaft, the metal bracket was touching the ground. Should I have been driving during when this failed, the metal could have caused sparks causing the fuel tank to ignite. This problem should be moved from an extended warranty to a recall.

the a pillar on the right side of the windshield is rusted and the trim falling off which could rollover safety and parts flying off and possibly striking other vehicles on the road.

Rear sliding window leaks . Water fill up over the track inside and drain can't keep up with volume of water and make my truck wet inside . Notes bulid mold and rust .

FUEL LEVEL SENSER NOT READING , WENT ON VACATION FUEL WASNT READING AN I JUST FILLED IT UP . TOOK IT TO THE DEALER AN THEY SAID ITS WORKING NOW , AFTER WE WENT ON THE WAY BACK IT STARTED DOING IT MORE AN MORE . AN PLUS THE TAILGATE OPENS ON IT OWN ALL THE TIME

Front fuel tank strap broke. This is a known issue for Dodge ram trucks. It is the same issue that happened on the 2009 through 2012 Dodge ram recalls. My truck is a 2016 Dodge ram. Has been mostly in Virginia and Ohio over the last 8 years. The strap broke through the chassis due to rust and corrosion. This is a known issue with a lot of Dodge Ram trucks and is something the NHTSA should look into and force the dealerships to issue a recall.

I was driving home when a trailer went by and a nut flew off the trailer and damaged my bumper and fog light. When I went to trade in my truck the dealer pulled a Carfax and said my truck was in a collision.Tey lowballed me on a trade .They offered me $25k for my truck when it is worth $40 K,the low balled me beacuse of carfax,which the report was not true.

The tailgate of the truck does not remain shut. It unlatches and opens while the vehicle is in motion causing potential road hazards to other drivers. Vehicle has been inspected by a local body shop repair but does not show any worn or out of place parts.

The contact owns a 2016 RAM 1500. The contact stated while the vehicle was at a standstill, he noticed the water was leaking into the rear driver’s side of the vehicle. The vehicle was not diagnosed or repaired. A dealer was not contacted. The manufacturer had not been informed of the failure. The failure mileage was approximately 55,000.

WHILE HAVING A ROUTINE OIL CHANGE I DISCOVERED ON THE VEHICLE SEVERAL SMALL AREAS OF CHIPPED PAINT AND RUST IMMEDIATELY ABOVE THE WINDSHIELD. THE WINDSHIELD IS THE ORIGINAL AND NEVER CHANGED SO THERE IS NO REASON FOR THE PAINT DEFECTS ALONG THE WINDSHIELD SEAM AREA SO THAT WHEN THE RUST GOES THROUGH THE WINDSHIELD WILL BECOME UNSTABLE AND POSE A POTENTIAL HAZARD OR COULD FAIL ALTOGETHER. I SPOKE WITH A RAM DEALER WHO WAS UNINTERESTED IN THE PROBLEM. I HAVE CALLED RAM COOPERATE HEADQUARTERS AND REPORTED THE ISSUE. PLEASE SEE ATTACHED PHOTOS.

MY 2016 DODGE RAM, REAR WINDOW BEGAN LEAKING DURING A HEAVY RAIN. WATER BEGAN RUNNING IN FROM THE TOP, PASSENGER SIDE OF TEAR WINDOW WHILE DRIVING DOWN THE HIGHWAY. MY SON IN LAW HAS A 2015 RAM. HIS REAR WINDOW HAD THE SAME PROB. WARRANTY FIXED IT. CHECKED INTERNET. SEEMS TO BE A VERY COMMON PROBLEM.

MY TAILGATE HAS OPENED BY ITSELF 4 TIMES RECENTLY. I CHECK EVERY TIME I CLOSE IT TO ENSURE THAT IT'S CLOSED AND LOCKED PROPERLY. EVERY TIME I HAVE BEEN DRIVING AND IT'S FALLEN OPEN. THIS LAST TIME, I WAS HAULING A TRAILER AND IT OPEN BY ITSELF, GOING DOWN THE ROAD AND THE TAILGATE LANDED ON THE TRAILER TONGUE JACK AND DAMAGED MY TAILGATE.

I NOW HAVE 4 INCH CRACK IN FLOOR MIDWAY THROUGH VAN

THE DRIVER'S SIDE INTERIOR DOOR LATCH HAS FAILED EVEN THOUGH THE VEHICLE HAS LESS THAN 50K MILES. THIS OCCURRED WHEN THE VEHICLE WAS STATIONARY. I AM A SAFETY ENGINEER. THE INTERIOR LATCH FUNCTION IS A SAFETY CRITICAL MEANS OF EMERGENCY EGRESS AKIN TO CRASH BARS ON BUILDINGS; NO WAY SHOULD IT FAIL IN A VEHICLE THIS RECENTLY BUILT AND OF SUCH LOW MILEAGE. RAM INFORMED ME IT WAS A NON-WARRANTY ITEM WHICH IN ITSELF SURPRISING. THE REPAIR BILL IS $521, WHICH IN SOME CASES WILL BE EXPENSIVE ENOUGH THAT SOME WILL FORGO GETTING IT FIXED, IMPERILING THEMSELVES SHOULD THEY NEED TO QUICKLY EGRESS THE VEHICLE IN THE EVEN OF A FIRE OR SUBMERSION, FOR EXAMPLE. I ASKED THEM FOR INFORMATION ON HOW FREQUENTLY THIS PARTICULAR TYPE OF FAILURE PARTICULAR LATCH MECHANISM AND THEY WERE MOST DEFINITELY NOT FORTHCOMING. I ASKED THEM TO ELEVATE MY CASE TO SOMEONE MORE SENIOR, GIVEN...

WHILE DRIVING THE TRUCK BACK FIRE POURING SMOKE PULLED OVER OPEN HOOD SAW FLAMES MOVE TO SAFETY FILED COMPLAINT WITH FCA THEY SENT AN ARM CHAIR INVESTIGATOR WHO SAID INVESTIGATING HE FOUND NOTHING THAT SHOWS NO RESPONSIBILITY FOR FCA THEY STATED EVEN THOUGH THERE IS RECALL THAT WARNS OF FIRE HAZARD DOES NOT MEAN IT IS THERE FAULT. SO FAR THEY DO NOT HAVE REPAIR PARTS TO FIX AND FOR ME IT IS TO LATE TRUCK WAS DESTROYED BY THE FIRE FIRE FCA NEEDS TO BE HELD ACCOUNTABLE. *TR

LAST MONTH (DECEMBER 2019) ON A COLD DAY, I TRIED TO PUT DOWN THE DRIVER'S WINDOW IN 2016 RAM 1500. HOWEVER, THE WINDOW WAS FROZEN IN PLACE DUE TO AN OVERNIGHT SNOWSTORM. THE WINDOW DIDN'T MOVE AND I RELEASED THE BUTTON. THEN, WHILE PARKED IN A PUBLIC PARKING LOT, THE WINDOW WENT HALF WAY DOWN ON ITS OWN. I FOUND IT THIS WAY WHEN I RETURNED TO THE TRUCK. IT WENT UP WITH THE BUTTON AND I BEGAN MY TRIP HOME. DURING THIS TRIP HOME, WHILE I WAS DRIVING AND I HAD NOT TOUCHED THE BUTTON, THE WINDOW FELL COMPLETELY INTO DOOR. APPARENTLY THE WINDOW HAD COME APART FROM THE PLASTIC CLIPS HOLDING IT TO THE UP/DOWN MECHANISM. TODAY, JANUARY 9, 2020, ANOTHER COLD DAY, MY WIFE PRESSED THE BUTTON TO NUDGE THE PASSENGER WINDOW UP (IT WAS OPEN JUST A TAD) AND INSTEAD OF GOING UP, THE WINDOW DROPPED...

MY TAILGATE IS LOOSE AND THE LATCH GOT REPLACED FROM A RECALL BUT IT RATTLES GOING OVER RUG AREAS!

VEHICLE TAKEN IN ON 8-12-19 TO DEALERSHIP TO CHECK OUT DRIVEABILITY CONCERNS AFTER "APPROVED EMISSON MODIFICATION" THEY HAD IT TO APPLY UPDATE FROM 5-17-19 TO 6-12-19, CONCERNS ON 8-12-19 WERE ACCELERATION, ALSO TO CHECK EGR SYSTEM AS I WAS LOSING COOLANT THEY HAD MY VEHICLE FROM 8-12-19/9-13-19 WHEN THEY CALLED ME TELLING ME I NEEDED TO RETURN THE RENTAL CAR AND PICK MY VEHICLE AS THEY COULDN'T DO ANYTHING FOR THE ACCELERATION I WOULD HAVE TO WAIT FOR AN UPDATE TO BE RELEASED. THEY DIDN'T CHECK THE EGR SYSTEM ONLY TOPPED IT OFF WITH COOLANT AND TOLD ME TO WATCH IT. ALL WAS FINE UNTIL 9-16-19 WHEN I WAS ON MY WAY TO WORK, ABOUT 7 MILES FROM WORK THE CHECK ENGINE LIGHT CAME ON I CONTINUED ON ABOUT A MILE FROM MY WORK LOCATION THE SERVICE THROTTLE CONTROL LIGHT ILLUMINATED I LOST THE ABILITY TO ACCELERATE AND ABOUT 1/4-1/2...

DRIVER SIDE WINDOW CLIPS KEEP BREAKING WHENEVER TEMPERATURE GOES BELIE FREEZING. 3 TIMES TO DEALER TO REPAIR. DEALER STATES ITS A COMMON DESIGN DEFECT. IT IS A SAFETY HAZARD AS WINDOW FALLS INTO TRACK AND CANT BE OPERATED OR MINE HAS LODGED UP THEN UNEXPECTEDLY DROPPED. IVE BEEN TOLD NOT TO OPEN WINDOW IN COLD WEATHER THATS UNSATISFACTORY. DODGE NEEDS TO RECALL AND CORRECT DESIGN ISSUE AND HAZARD.

TL* THE CONTACT OWNS A 2016 RAM 1500. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 18V486000 (STRUCTURE, LATCHES/LOCKS/LINKAGES) THE DEALER (CARBONE DODGE CHRYSLER JEEP RAM, 5017 COMMERCIAL DR, YORKVILLE, NY 13495, 1-315-736-3371) SCHEDULED THE REPAIR TWO WEEKS AGO. WHEN THE CONTACT ARRIVED FOR THE APPOINTMENT, THE DEALER STATED THAT THE PART WAS NOT AVAILABLE. THE DEALER STATED THAT THEY WOULD FOLLOW-UP WHEN THE PART WAS AVAILABLE. THE CONTACT HAD NOT RECEIVED A RESPONSE. THE CONTACT SENT AN ONLINE INQUIRY TO THE MANUFACTURER THROUGH THEIR WEBSITE, BUT HAD NOT RECEIVED A RESPONSE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

WHILE TRAVELING ON I-5 SOUTH AT APPROX. 65 MPH, USING THE CRUISE CONTROL, THE VEHICLE SUDDENLY SPED UP AND THE DRIVER WAS UNABLE TO DECREASE THE SPEED OF THE VEHICLE CAUSING THE DRIVER TO VEER WEST OFF INTO THE DIRT SHOULDER STRIKING THE DIRT EMBANKMENT AND WOOD FENCE. THE DRIVER SUSTAINED MAJOR INJURIES TO HIS FACE, ANKLE AND PAIN IN CHEST. *BF *TR THE CONSUMER STATED THE VEHICLE WAS SCRAPED BEFORE INFORMATION FROM THE COMPUTER WAS RECEIVED. THE DRIVER BECAME DISABLED AND COULD NO LONGER WORK. *JS

THE TRUNK DOOR LATELY, IS OPENING CONSTANTLY EITHER WHEN DRIVING OR IN A STOP

DROPPING BOAT IN WATER ON SLIGHT GRADE RAMP. PUT CAR IN PARK AND SHUT DOWN. AS I DROPPED BOAT FROM THE TRAILER THE TRUCK ROLLED DOWN THE RAMP IMMERSING 3/4 OF THE BODY IN THE SALT WATER. NO ONE WAS BEHIND THE WHEEL. THIS PRODUCT HAS HAD ISSUES WITH ROLLAWAYS

TAILGATE RANDOMLY OPENS WHEN THE VEHICLE HITS 15 MPH AND ACTIVATES THE DOOR LOCKS ALONG WITH THE TAILGATE LOCK. CONTENTS SPILL OUT OF THE BED AND INTO TRAFFIC. I CANT FIND A SAFETY BULLETIN BUT THIS APPEARS TO BE A COMMON ISSUE. THIS SHOULD BE RECALLED IMMEDIATELY. THIS HAS HAPPENED 15 TIMES ON MY VEHICLE IN THE LAST MONTH. THE VEHICLE IS APPROX 18 MONTHS OLD AND HAS LESS THAN 30K MILES ON IT. EXAMPLE OF THE ISSUE. HTTPS://WWW.YOUTUBE.COM/WATCH?V=UHA6WUVQTHG

VEHICLE WAS POINTED DOWNHILL ON A CONCRETE DRIVEWAY WITH A TRAILER ATTACHED WHICH WEIGHED APPROXIMATELY 1200 POUNDS. THE VEHICLE'S TRANSMISSION WAS IN PARK, THE PARKING BRAKE APPLIED AND THE ENGINE OFF. A WHEEL CHOCK WAS PLACED IN FRONT (DOWNHILL SIDE) OF THE DRIVERS REAR WHEEL. THE VEHICLE WAS LEFT UNDISTRIBUTED FOR APPROXIMATELY 20 TO 30 MINUTES WHEN IT BEGAN TO ROLL DOWNHILL ON ITS OWN. IT CAME TO REST IN A DITCH.

THE TAILGATE COMES OPEN SOMETIMES WHEN DRIVING. THE TAILGATE DID NOT HAVE ANY CARGO AGAINST IT. THE TAILGATE HAS CAME OPEN SEVERAL TIMES OVER THE LAST TWO MONTHS. LAST TIME IT HAPPENED WAS ON 5/18/2018.

PUT TRUCK IN PARK. LEFT THE MOTOR RUNNING. GOT OUT WENT INTO SHOP CAME BACK OUT A COUPLE OF MINUTES LATER AND TRUCK HAD ROLLED BACKWARDS AND STRUCK A TELEPHONE POLE. WHEN I OPENED THE DRIVERS DOOR THE GEAR SELECTOR SAID IT WAS IN REVERSE.

IN COLD WEATHER THE ELECTRIC DRIVER SIDE WINDOW REPEATEDLY DISCONNECTED FROM THE TRACK. THIS CAUSES THE WINDOW TO FREE FALL INTO THE DOOR WHILE DRIVING AT HIGHWAY SPEED. FCA CLAIMS THIS IS A SAFETY FEATURE AND WILL NOT COVER REPEATED REPAIR UNDER WARRANTY. DEALER SUGGESTION TO PREVENT PROBLEM IS TO NOT USE WINDOW IN WEATHER BELOW 32 DEGREES. PERSONALLY HAD MY WINDOW COME OFF TRACK TWICE IN 1 WEEK, ONCE WITHOUT EVEN TRYING TO OPERATE THE WINDOW.

MY TRUCK HAS UNDER 20,000 MILES, AND I HAVE HAD AN ELECTRICAL FIRE UNDERNEATH MY DRIVERS SEAT, THAT CAUSED THE WHOLE TRUCK TO FILL WITH SMOKE. LESS THAN 2 WEEKS LATER, MY PASSENGER SIDE FRONT WINDOW FELL OFF THE TRACK AND INTO THE DOOR, DURING A HEAVY SNOWSTORM, THROWING SLUSH, AND SNOW INTO MY PASSENGER'S FACE.*BF * *TR

TRUCK PROCEEDING AT ABOUT 30-35 MILES PER HR. ON A MAIN CITY STREET WHEN A CAR TRAVELED DIRECTLY IN FRONT OF IT DUE TO ITS FAILURE TO STOP AT A STOP SIGN ON A SIDE STREET. FRONT OF TRUCK CRASHED INTO CAR. EXTENSIVE DAMAGE TO FRONT OF TRUCK RESULTED. QUESTIONING WHY NO DEPLOYMENT OF AIR BAG IN THIS HEAD- ON CRASH. TRUCK'S DRIVER HIT STEERING WHEEL WITH FOREHEAD AND WAS KNOCKED UNCONSCIOUS FOR A BRIEF PERIOD OF TIME. NECK AND HIP INJURIES WERE LIKEWISE SUSTAINED. DRIVER OF TRUCK WAS AMBULANCED TO NEARBY HOSPITAL FOR TESTS AND OBSERVATION. DRIVER OF TRUCK WAS WEARING SEATBELT AT TIME OF COLLISION. POLICE REPORT NOT YET AVAILABLE. ACCIDENT OCCURRED 4/3/17 IN THE EVENING.