2020 MERCEDES-BENZ SPRINTER 2500 — Problems, Recalls & Safety Data

On November 28, 2025, I experienced a vehicle fire in my Mercedes 2020 Sprinter 2500 4WD van. The van engine was on and idling while heating up with the van heater blower on level 6 (out of 7). After about 45 minutes, I saw a haze first and then smelled smoke. Unsure of the source, I turned the vehicle off and exited with my dog. I opened the hood to look for smoke in the engine bay. No smoke under the hood. I contact Mercedes Roadside and open the driver side door where I see flames under the seat. I grabbed the fire extinguisher I installed and put the fire out within 20-25 seconds of seeing it. I believe the root cause of the fire was running the van blower at a high setting for a sustained 45 minutes. My dog and I were inside and definitely in danger. It scares me to think of a scenario where the van was idling with only my dog inside and something like this occurring. The incident is currently under investigation with MB USA and my insurance company, Progressive. No warning signs or dashboard messages. In general, the electrical wiring for my vehicle has been spotty and was completely rewired by the dealer service center in 2021. Currently, there is an issue blacking out the dashboard screen so there is no screen function including gps, entertainment, or vehicle info.

I had 5 recalls completed at the MB Sprinter dealership in Pleasanton CA on 11/06/2025. Had hardly driven it 100 miles or 5 times since then when I noticed it was not always going into park. One recall had to do with not going in park when you push park button while foot on brake. I was not having that problem until the MB Sprinter dealership did the recall work. Now every 5th time or so it does not go in park when I push park button while foot on brake. Dealership insists I must pay to have this fixed even though their recall work caused it. This is a severe safety hazard that could result in death!

I’ve had two issues with my sprinter van that were transmission shift module that left me stranded with no way to shift the car into neutral. I was blocking a fuel pump and couldn’t get the car into gear. The first time I was stuck in a parking lot with the same issue. I can’t believe no one else had this issue. The screen message said “Service required do not shift gears” I purchased the van new in 2020. It only has 17000 miles on it. The dealerships Mercedes Benz in Sioux Falls and Mercedes Benz in Rochester Minnesota repaired the van.

The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that while in reverse, the rearview camera failed to display a rearview image. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to provide a cause for the failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V411000 (Electrical System, Back Over Prevention); but the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 51,000.

The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that while in reverse, the rearview camera failed to display a rearview image. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to provide a cause for the failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V411000 (Electrical System, Back Over Prevention); but the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 51,000.