2007 MERCEDES-BENZ E350 Fuelpropulsion System Problems

Recently my wife and I noticed a very strong fuel smell from cabin of this car. When I inspected and lifted the seat there was a puddle of fuel leaked over the sending unit. This is extremely dangerous and potentially deadly for my family especially with 2 young children who are always seating in back seat. Upon checking with Benzel Busch Mercedes dealer in Englewood New Jersey, they said they cannot fix my issue because my warranty has expired. I am now writing to you to help me as I feel this should strictly be a recall and Mercedes USA should be required to fix this leak free of charge. Please understand that out of pocket will be more than $8,000 for this repair and I do have the means to come up with that amount of money. Upon checking on internet there are many E class Mercedes Benz between...

FUEL SMELL COMING FROM THE REAR, CAR IS A PZEV AND OUT OF WARRANTY, SMELL IS VERY STRONG AND I AM UNABLE TO DRIVE IT WITH A CHILD IN THE BACK BECAUSE THEY GET DIZZY. UNABLE TO FILL UP WITH GAS UP TO A CERTAIN POINT OR SMELL WILL LINGER.

Fuel sending unit warranty was extended but only for a short time. Mine has failed and gas is leaking into the car and MB won’t honor warranty because it expired on my car and entire fuel tank has to be replaced.

FUEL TANK AND FUEL PARTS LEAKING. 2 REPAIRS AND CAR OFTEN SMELLS OF GASOLINE ESPECIALLY IN THE GARAGE.

Fuel tank fuel leak, NHTSA Action Number EA13003 I purchased a 2007 Mercedes E Class used a few months ago, and recently I noticed a fuel leak, strong fuel smell outside of vehicle when fuel tank is filled higher. More fuel means more fuel odor. Upon research, it seems like there was a warranty extension for 15 years, and with my luck, warranty extension ran out just after I bought the car but before I noticed the problem. As fuel is a safety issue and can easily ignite, and also affects emissions, I feel like the remedy should not just be a 15 year warranty extension, but longer as cars are staying on the road longer and longer. I'm sure I'm not the only one with this issue out of warranty extension period.

Due to the odor of gasoline both inside and outside my car I brought my car to the local Mercedes’ dealership. Upon inspection they found a small crack in my fuel tank which allowed gasoline to leak into another compartment. The dealer stated they would not be able to replace fuel pump without replacing the gasoline because of the “danger and risk of fire”. I believe that the leakage of gasoline and the fumes associated inhaled presents a very real danger, and risk to health. Upon research I found that this is a major issue that has been addressed by your department. After a 3 year investigation this investigation was closed due to the extension of the manufactures warranty to 15 years. My car is 8 months out of the extended warranty. When speaking to Mercedes’ Benz hotline, the representative stated receiving several phone calls recently with reports of the...

Vehicle fuel system known component issue, fuel pump failure, intermittent. Driving vehicle can lose power at speed, causing potential loss of control as hydraulic assist to steering and braking fails with engine. This known issue has intermittently cause our car to fail to start, or fail in operation. This was a known issue, the manufacturer was allowed to avoid a recall by extending the warranty for this component (fuel pump in fuel tank assembly) to 15 years. Our car started showing this around that time (3 months ago, when extended warranty expired), however we were not then aware of said warranty. Now that we've been two months of diagnosis and discussions with MBUSA Customer Care, they are not willing to replace the known failure point as warranty expired 3 months ago. This should have been a recall from the beginning, and now we, and many others to come, will have...

The component/s that have failed are (reputedly) the fuel system resulting in significant fuel fumes permeating into the cabin of the vehicle as well as being very evident around the rear outside of the vehicle. This seems to be more obvious after the car has been filled with fuel. Having fuel fumes leaking into the cabin of the car should be self evident as a risk to anyone travelling in the vehicle, especially in the rear seats. The fumes eminating from the car, externally, are a potential fire hazard should anyone walk by with a cigarette or naked flame. This is an on going problem well known to Mercedes Benz and one that should have been the subject of immediate recalls by MB and not subject to a Mileage, Time Frame or VIN number. Why should I, or anyone, have to foot a fairly significant bill, for fixing a manufacturing...

AFTER I FILLED UP MY GAS TANK AND CAME HOME AND PARKED MY CAR IN THE GARAGE. AFTER A FEW HOURS I SMELL STRONG GAS SMELL. WHEN I RESEARCHED MBWORLD, I SAW MANY PEOPLE HAVING THE SAME / SIMILAR ISSUE, AND MERCEDES BENZ HAD EXTENDED THE WARRANTY TO 15 YEARS TOWARDS FUEL LEAK ISSUES. THERE WERE MANY ARTICLES ON THE FORUM. WHEN I CALLED MY DEALER, HE SAID THAT I THERE ARE NO RECALLS ON IT. HOW DO I RESOLVE THIS ISSUE?

WHEN I FILL THE GAS TANK TO THE TOP, I SMELL FUEL IN THE CABIN, I THINK THERE WAS A RECALL FOR THAT, BUT DEALERSHIP SAYS NO, THERE IS A VIDEO ON THIS ISSUE ON YOUTUBE AS WELL, I GOT THIS RECALL NUMBER FROM A FRIEND NHTSA#13003, COULD YOU PLEASE CHECK AND HELP ME OUT.

WHEN I FILL UP THE GAS TANK I NOTICE A GAS SMELL FROM OUTSIDE OF THE CAR ON THE REAR DRIVERS SIDE. WHEN THE FUEL LEVEL DROPS TO 3/4 FULL THE SMELL DISAPPEARS. I'M AFRAID OF AN EXPLOSION IF I PARK IN AN ENCLOSED GARAGE

I RECENTLY BOUGHT AN 07 MERCEDES E350 I'VE FOUND THIS SAME COMPLAINT ON NUMEROUS WEBSITES THE WHOLE CAB OF THE CAR FILLS WITH A TERRIBLE FUEL SMELL ONLY ON THE INSIDE OF THE CABIN BUT ITS SO BAD ID HESITATE LIGHTING A LIGHTER IN THE CAR UNTIL THE WINDOWS HAVE BEEN ROLLED DOWN AND AIRED OUT ITS SUPPOSEDLY UNDER THE VERY SPOT MY 5 YEAR OLD GRANDDAUGHTER WOULD BE SEATED THIS IS NOT ONLY HIGHLY DANGEROUS AND FLAMMABLE BUT WILL GIVE THE DRIVER AND OCCUPANTS TERRIBLE HEADACHES, NAUSEA AT TIMES AND IN MY OPINION IS A NOT ONLY FIRE HAZARD BUT ALSO A HEALTH HAZARD AND IT DOES THIS SITTING STATIONARY WITHOUT THE CAR RUNNING I'VE TRIED EVERYTHING NOT FILLING THE CAR TO THE TOP BUT EVEN AT A HALF TANK YOU HAVE THE SAME PROBLEM ITS SO BAD I WOULD RETURN THE CAR IF THE DEALER WOULD TAKE IT...

MY CAR WAS RUNNING SUDDENLY STOP AND DOES NOT START, I TAKE IT TO MERCEDES DEALER AND THEY CHARGE ME $195.00 PLUS TAX TO SCANNED IT THEY FOUND THE ECM ENGINE CONTROL MODULE NEED TO BE REPLACE. COST IS $2,300 PLUS TAX. PLEASE CONTACT ME FOR AT YOUR CONVENIENCE SO I CAN TAKE FURTHER STEPS TOWARDS MERCEDES BENZ. *TR

PROBLEM: CAR LEAKS FUEL TO THE GROUND NEAR THE REAR EXHAUST PART OF THE CAR WHEN GAS TANK FILLED PAST 3/4 FULL OF A TANK. CAR LEAKS FUEL, AND SMELLS EXCESSIVELY LIKE GASOLINE INSIDE, AND OUTSIDE OF THE CAR. THIS COULD BE A POTENTIAL HEALTH RISK DUE TO THE FUMES OF THE GASOLINE, AND GASOLINE LEAKING. THE PROBLEM COULD BE A SAFETY ISSUE DUE TO GASOLINE POTENTIALLY LEAKING ON THE EXHAUST, AND IGNITING. THE CAR ALSO WILL NOT PASS EMISSIONS DUE TO EVAPORATION LEAK CHECK ENGINE CODES. THIS HAPPENS EVERY TIME A GAS FILL UP MORE THAN 3/4 OF A TANK OF FUEL. I HAVE PICTURES OF THE FUEL LEAK.

TL* THE CONTACT OWNS A 2007 MERCEDES BENZ E-350. THE CONTACT STATED THAT THE VEHICLE HAD AN ODOR OF FUEL INSIDE. THE VEHICLE STALLED. THE CONTACT STATED THAT THE ODOR WAS MORE PREVALENT IN AND UNDER THE REAR PASSENGER SEATS. THE VEHICLE WAS TOWED TO A FIELDS MOTORCARS LOCATED AT (4141 N FLORIDA AVE, LAKE LAND, FL 33805) AND WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THAT THE FUEL ODOR MADE HER ILL. THE MANUFACTURER WAS CONTACTED AND THE CONTACT WAS REFERRED BACK TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 148,000.

TL* THE CONTACT OWNS A 2007 MERCEDES BENZ E350. THE CONTACT STATED THAT AFTER FILLING UP FUEL TANK, THE VEHICLE EMITTED AN ABNORMAL FUEL ODOR. THE CONTACT STATED THAT THE VEHICLE HAD CEASED TO OPERATE WITHOUT WARNING WHILE TRAVELING AT 50 MPH. UPON INVESTIGATION, THE CONTACT DISCOVERED AN INVESTIGATION WAS OPENED AND CLOSED UNDER NHTSA ACTION NUMBER: EA13003 (FUEL SYSTEM, GASOLINE) FOR WHICH THE MANUFACTURER EXTENDED THE WARRANTY TO 15 YEARS WITH UNLIMITED MILEAGE. THE CONTACT TOOK THE VEHICLE TO MERCEDES-BENZ OF PORTLAND 1605 SW NAITO PKWY, PORTLAND, OR 97201 WHERE THE CONTACT WAS INFORMED THAT THE DEFECT WAS RELATED TO THE FUEL SENDING UNIT AND NOT THE FUEL TANK. THE DEALER HAD REFUSED TO SERVICE THE VEHICLE UNDER THE EXTENDED WARRANTY AND PROVIDED THE CONTACT AN ESTIMATE OF APPROXIMATELY $3,000 TO HAVE THE VEHICLE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OFFERED THAT CONTACT NO...

THERE IS A STRONG SMELL OF GASOLINE DUE TO A DEFECTIVE GAS TANK SEAL - THIS PROBLEM IS EXACERBATED WHEN THE GAS TANK IS FILLED OR NEARLY FILLED, THE EXTREME DANGER OF THE GAS FUMES EMITTED MANIFESTS ITSELF IN THE PROBABLE EXPLOSION CAUSING DEATHLY HARM TO PEOPLE, OWNERS AND INNOCENT BYSTANDERS, PROPERTY, INCLUDING THE CAR ITSELF. THE CAR IS A 2007 MERCEDES-BENZ E-350

MY VEHICLE SHUT OFF WHILE I WAS DRIVING ON A MAIN STREET. TWO MINUTES LATER I COULD START IT. THEN NEXT DAY I COULD SO I TOOK IT TO A TRUSTED MECHANIC AND WAS INFORMED ABOUT RECALL. IT HASN'T STARTED SINCE. THE MECHANIC ISN'T CERTAIN ABOUT EXACTLY THE PROBLEM BUT SAID THERE WAS SOME MISFIRES ON SENSORS. UNKNOWN EXACTLY WHAT'S WRONG. I DID GET A LETTER IN THE MAIL ABOUT A RECALL OFFERED TO ME IF SIMILAR CONDITIONS HAPPEN.

I CAN SMELL GAS FUMES AND MY FUEL PUMP FAILED IN MY 2007 MERCEDES E350. WHILE MERCEDES EXTENDED THE WARRANTY ON THE FUEL TANK / PUMPS FOR THE E SERIES, NON-PZEV, I HAVE BEEN ADVISED THAT MY CAR HAS PZEV EMISSIONS AND I AM NOT COVERED. THE NON-PZEV CARS RECEIVED A 15 YEAR EXTENDED WARRANTY WITH UNLIMITED MILEAGE. THE PZEV CARS HAVE MILEAGE CAPPED AT 150K. THE RESOLUTION MERCEDES PROVIDED TO THE NHTSA WAS MISLEADING SINCE THEY DID NOT PROVIDE A RESOLUTION FOR ALL OF THE CARS WITH FUEL TANK / PUMP ISSUES.

TL* THE CONTACT OWNS A 2007 MERCEDES-BENZ E350. THE CONTACT NOTICED AN ABNORMAL ODOR OF FUEL INSIDE THE VEHICLE AFTER FILLING THE TANK WITH FUEL. ALSO, THE CHECK ENGINE WARNING INDICATOR WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO MERCEDES-BENZ OF BAKERSFIELD (5600 GASOLINE ALLEY DR, BAKERSFIELD, CA 93313, (661) 536-5588) WHERE IT WAS DETERMINED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS UNKNOWN.

TL* THE CONTACT OWNS A 2007 MERCEDES-BENZ E350. WHILE DRIVING VARIOUS SPEEDS, THE BATTERY WARNING INDICATOR ILLUMINATED. IN ADDITION, THE POWER STEERING BECAME DIFFICULT TO MANEUVER AND THE VEHICLE STALLED. ALSO, THE CHECK ENGINE WARNING INDICATOR REMAINED ILLUMINATED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TOWED TO MERCEDES-BENZ OF WEST CHESTER (LOCATED AT 1260 WILMINGTON PIKE, WEST CHESTER, PA 19382, (484) 313-1100) WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE FUEL PUMP WAS REPLACED; HOWEVER, THE FAILURE RECURRED TWICE. ADDITIONALLY, THE FUEL PUMP FILER, WATER PUMP, TENSIONER PULLEY, AND SERPENTINE BELT (WHICH WAS REPLACED NINE TIMES) WERE REPLACED, BUT THE FAILURE RECURRED. THE CONTACT WAS ALSO INFORMED THAT THERE WAS AN ELECTRONIC FAILURE FOR WHICH THE MECHANIC WAS UNABLE TO REPAIR. THE CONTACT ALSO STATED THAT THE FUEL GAUGE AND COOLANT SYSTEM WERE INOPERABLE, AND THERE WAS A FAILURE WITH THE...

TL* THE CONTACT OWNS A 2007 MERCEDES-BENZ E350. THE CONTACT SMELLED A FUEL ODOR WHILE DRIVING THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, BUT A FAILURE WAS NOT FOUND. RECENTLY, THE CONTACT WAS UNABLE TO START THE VEHICLE AND HAD IT TOWED TO THE SAME INDEPENDENT MECHANIC. THE MECHANIC DIAGNOSED THAT THE FUEL PUMP WAS DEFECTIVE AND THE ENTIRE FUEL TANK WOULD NEED TO BE REPLACED IN ORDER TO REPAIR THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE VEHICLE HAD NOT BEEN REPAIRED. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 130,000.

STRONG GAS ODOR WHEN TANK FILLED UP. KEEPING FUEL LEVEL AT ONLY HALF TANK DO NOT SMELL - BUT WHEN FUEL UP TO FULL OR CLOSE TO IT STRONG ODOR IS BACK.

AS THE CO-OWNER/BUYER OF A 2007 MERCEDES-BENZ E350, I AM VERY DISPLEASED WITH THIS FIRST CAR PURCHASE FROM THE DEALERSHIP IN PLEASANTON. HONESTLY, THE LOOK/MAKE OF THE CAR CAN BE VERY DECEIVING. IN FACT, IT ONLY TOOK ONE DAY TO REALIZE THE CAR SMELLED OF GAS INSIDE THE VEHICLE. ALSO, AFTER TAKING THE BACKSEAT OFF, GAS WAS LEAKING FROM THE FUEL PUMP LOCATED UNDER THE SEAT SO MY DAD AND I DECIDED TO TAKE THE VEHICLE TO THE DEALERSHIP IN OAKLAND TO SEE IF THERE WERE ANY RECALLS UNDER THE CAR'S VIN OR IF THERE WAS ANYTHING THEY COULD DO ABOUT IT THAT DIDN'T HAVE TO COST US, BUT SADLY NO. THE THING THAT MAKES THIS SITUATION EVEN MORE WORSE WAS THAT NOT ONCE DID BOTH DEALERSHIPS MENTION ANYTHING ABOUT THE WARRANTY FOR A FUEL TANK REPLACEMENT THAT THIS PARTICULAR MODEL CAME WITH AND THE MAIN COMPLAINT IN ORDER TO...

VERY STRONG GAS SMELL ESPECIALLY WHEN THE GAS TANK IS FULL.

STRONG SMELL OF GASOLINE INSIDE AND OUTSIDE OF CAR AFTER REFUELING! SEEMS TO LESSEN WHEN THE TANK IS BELOW 3/4 FULL.

TL* THE CONTACT OWNS A 2007 MERCEDES-BENZ E350W. THE CONTACT NOTICED A STRONG FUEL ODOR AND A FUEL LEAK WHILE PLACING FUEL INTO THE VEHICLE. THE VEHICLE WAS TAKEN TO FLETCHER JONES MOTOCARS (3300 JAMBOREE RD, NEWPORT BEACH, CA 92600) WHERE IT WAS DETERMINED THAT THE VEHICLE WAS NOT INCLUDED IN THE UNLIMITED MILEAGE EXTENDED WARRANTY FOR FUEL LEAKS. THE MANUFACTURER WAS ALSO NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 162,000. *TR *TR

STRONG ODORS AND FUMES OF GASOLINE INSIDE OF VEHICLE INTERMITTTENLY, THEY GO AWAY AND THEN COME BACK, PRETTY SURE ITS RELATED TO GAS TANK AND FUEL SENDING UNIT COMPONENTS GASKETS, SEAL ETC, THERE IS LOT OF COMPLAINTS ABOUT THIS SAME ISSUE .

TL* THE CONTACT OWNS A 2007 MERCEDES-BENZ E350. THE CONTACT STATED THAT THERE WAS AN ABNORMAL FUEL ODOR COMING FROM THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE VEHICLE NEEDED A NEW FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 139,462.

GAS LEAK AND SMELL FROM THE GAS TANK.

TL* THE CONTACT OWNS A 2007 MERCEDES-BENZ E350. WHILE THE VEHICLE WAS STATIONARY, THE FUEL SYSTEM FAILED. WHEN THE CONTACT FILLED THE FUEL TANK, FUEL ENTERED INTO THE CABIN OF THE VEHICLE. ALSO, THE VEHICLE FAILED TO START AFTER THE FUEL TANK WAS FILLED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP FAILED. DICK DYER & ASSOCIATES (5825 TWO NOTCH COLUMBIA RD, SOUTH CAROLINA 29223, (803) 786-8888) WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT REFERENCED TSB NUMBER: P-47-10-63. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. *DT UPDATED 12/06/18*JB

WHEN FILLING THE TANK, THERE IS AN UNUSUAL SMELL OF GAS THROUGHT THE VEHICLE. WHICH I ATTRIBUTED TO GAS BEING ON MY HAND SINCE I LIVE IN A STATE WHERE MOST GAS STATION ARE SELF SERVICE. LAST WEEK WHILE DRIVING, MY CAR SUDDENLY SHUT OFF WHILE SITTING AT A TRAFFIC LIGHT. AFTER VEHICLE WAS DIAGNOSED TO BE A FAULT FUEL PUMP, I STARTED LOOKING ON LINE AND FOUND THAT THIS IS A PERSISTENT PROBLEM WITH VEHICLE OF THE SAME MAKE MODEL AND YEAR, BUT NOT THE VEHICLE ID NUMBER. THE MANUFACTURER DID EXTEND WARRANTY ON SOME VEHICLES, BUT NOT TP ALL THAT HAVE THE SAME ISSUES. I DO NOT SEE HOW ALL VEHICLES COULD EXHIBIT THE SAME PROBLEM, BUT NOT RECEIVED THE SAME COVERAGE. ALTHOUGH MY VEHICLE WAS DESIGNED FOR THE STRICT EMISSION STANDARD THEY HAVE IN CALIFORNIA, I STILL BELIEVE THEY USE THE SAME GAS TANK ON THE SAME...

VEHICLE STALLS WHILE DRIVING,ABLE TO PULL OVER TO SIDE OF HIGHWAY.ENGINE WILL NOT RESTARTED.TOWED VEHICLE TO MERCEDES DEALER,DIAGNOSIS DISCOVER THAT FUEL PUMP FAILED.FUEL PUMP NEED REPLACEMENT.THIS IS A VERY UNSAFE CONDITION,VEHICLE CAN STALL AT ANY TIME AND CAUSE SERIOUS ACCIDENT/CRASH.FIND INFORMATION NHTSA INVESTIGATION EA 13-003 ABOUT FUEL TANK/FUEL SYSTEM THAT RELATED TO THIS CONDITION SINCE FUEL PUMP IS PART OF FUEL TANK AS TOLD BY REPAIR DEALER, BUT DEALER AND MERCEDES MANUFACTURE CUSTOMER SERVICE REFUSE/DECLINE TO PERFORM THIS REPAIR UNDER THIS INVESTIGATION AGREEMENT.CAN WE HAVE SOME ASSISTANCE ON THIS MATTER

LEAK FROM THE GAS TANK UNDER BACK SEAT. SMELL OF GAS INSIDE THE CAR. FUEL PUMP DOESN'T WORK.

TL* THE CONTACT OWNS A 2007 MERCEDES-BENZ E350. AFTER THE CONTACT FILLED UP THE VEHICLE WITH FUEL, THE ODOR OF FUEL WAS PRESENT INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (WALTERS MERCEDES-BENZ, 3213 ADAMS AUTO CENTER DR., RIVERSIDE, CA) WHERE IT WAS DIAGNOSED THAT THE FUEL TANK AND FUEL PUMP WERE FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 150,000.

EVERY TIME I FILL UP MY CAR I GET A STRONG GAS SMELL INSIDE AND OUTSIDE THE CAR. IT ALSO LEAKS GAS ON THE DRIVER SIDE ON MY DRIVEWAY AT HOME OR WHERE I DRIVE AND PARK FOR ABOUT THE FIRST 50 MILES. THE WAY I HAVE LEARNED TO AVOID THE GAS SMELL IS I ONLY FILL THE TANK UP TO 3/4.

WHILE DRIVING THE VEHICLE ON THE HIGHWAY, THE ENGINE SUDDENLY LOST POWER, MAKING THE VEHICLE DIFFICULT TO CONTROL WHILE NAVIGATING TO THE SHOULDER. THE ENGINE THEN STALLED AND WOULD NOT START. VEHICLE WAS TOWED 120 MILES TO NEAREST DEALER WHERE THEY REPLACED THE FUEL PUMP AND RELATED PARTS, WHICH FIXED THE PROBLEM, INCLUDING THE FOLLOWING: ABOUT TWO WEEKS PRIOR TO THIS, ANOTHER DEALERSHIP HAD WORKED ON THE CAR DUE TO INTERMITTENT DIFFICULT STARTING. THEY WERE UNABLE TO DUPLICATE THE PROBLEM, BUT DID REPLACE FUEL FILTER AND RELATED PARTS. ALL REPAIRS WERE OUT OUT OF POCKET EXPENSES. SINCE THEN, MERCEDES-BENZ SENT A LETTER NOTIFYING THAT THE WARRANTY HAD BEEN EXTENDED ON FUEL TANK COMPONENTS. THE LETTER INCLUDED INSTRUCTIONS ON HOW TO PLACE A CLAIM FOR PRIOR EXPENSES THAT ARE NOW COVERED UNDER THIS EXTENDED WARRANTY. A CLAIM FOR REIMBURSEMENT OF THE REPAIR CHARGES INCURRED AT BOTH DEALERSHIPS WAS SUBMITTED TO MERCEDES....

"STRONG SMELL OF GAS ON 2007 MERCEDES BENZ E350" WHENEVER I FILL MY CAR WITH GAS, THERE IS A STRONG GAS SMELL ON THE INSIDE AND OUTSIDE OF MY CAR. IT IS SO STRONG THAT IT CAUSES MY ENTIRE GARAGE TO SMELL LIKE GAS. IT IS MORE PRONOUNCED WHEN I FILL MY TANK UP WITH GAS. AS THE TANK EMPTIES WITH DRIVING, THE SMELL IS LESS STRONG. THIS STRONG SMELL OF GAS IS EVERPRESENT WITH A FULL AND PARTIALLY FILLED TANK. THIS HAS OCCURRED FOR SOME TIME NOW. TODAY, I TOOK MY CAR TO THE MERCEDES BENZ ONTARIO DEALER SERVICE DEPARTMENT TO ASK FOR REPAIR BASED ON AN EXTENDED RECALL (AND UNLIMITED MILEAGE), THEY SAID THEY WILL NOT REPAIR IT USING THE RECALL, TOO MANY MILES. MY CURRENT MILEAGE IS 178278. MERCEDES NEEDS TO RECALL ALL MODEL YEARS. THIS IS VERY DANGEROUS, AND I QUESTION THE LIABILITY IN THE EVENT...

GOOD MORNING, I PURCHASED MY 2007 MERCEDES E350 IN APRIL OF 2016 WITH A 161,000 MILES ON THE CAR. I HAVE NOTICED SEVERAL WEEKS AFTER, THE CAR BEGAN TO SMELL LIKE GASOLINE FUMES AFTER, I FILLED UP. I DECIDED TO PARTIALLY FILL UP DURING THE NEXT VISIT. IT DOES WORK SOMETIMES . HOWEVER, I NOW NOTICE THE PUGENT ODOR HAS BECOME STRONGER. I DRIVE WITH THE BACK WINDOW PARTIALLY DOWN POST FILL-UP TO AVOID BEING OVER-WHELMED BY FUMES.

FUEL ASSEMBLY RECALL. MERCEDES BENZ E350 2007 INSIDE AND OUTSIDE PUNGENT FUEL ODOR WHEN FILLING GAS TANK. WATERY EYES, NAUSEA, HEADACHE AND CHEST CONGESTION WHEN BREATHING IN FUMES.

THERE IS A RECURRING SMELL OF GAS WHEN THE TANK IS FILLED ABOVE 1/2 OR SO. UPON INSPECTION BY A MECHANIC, THE TANK IS METAL AND IS LEAKING IN SPOTS AT THE TOP OF THE TANK. MERCEDES BENZ ISSUED AN EXTENDED WARRANTY FOR 15 YEARS TO COVER THIS MAKE, MODEL AND YEAR BUT FOR SOME REASON THIS SPECIFIC VIN NUMBER IS NOT BEING HONORED BY MERCEDES. THE MECHANIC SAYS THIS IS A SAFETY ISSUE AND MUST BE ADDRESSED AS TIMELY AS POSSIBLE. THERE IS A BULLETIN FROM MERCEDES BENZ DATED JANUARY 2015 THAT SPEAKS SPECIFICALLY TO THIS ISSUE. I HAVE CONTACTED TWO DIFFERENT MERCEDES BENZ SERVICE DEPARTMENTS (DAYTONA BEACH AND NORTH ORLANDO) WHO CONFIRM THIS IS A SERIOUS ISSUE AND IT NEEDS TO BE ADDRESSED. THEY BOTH REFERRED ME TO THE MERCEDES BENZ CUSTOMER SERVICE ASSISTANCE CENTER IN NEW JERSEY. UPON CONTACTING THEM, THEY SAID MY ISSUE HAD TO BE...

NHTSA ACTION NUMBER: PE12001 FUEL LEAK WHEN TANK IS FULL.

STRONG GAS SMELL WHEN TANK IS FILLED ALL THE WAY. THIS SMELL IS PROMINENT BOTH WHEN STATIONARY OR MOVING. THE SMELL GOES AWAY WHEN THE TANK IS 3/4 FULL OR LESS. GAS HAS LEAKED FROM UNDER THE REAR SEAT ON OCCASION. THE SMELL FILLS UP THE INTERIOR OF CAR AS WELL AS OUTSIDE. MAKES MY WHOLE GARAGE WREAK OF GAS AND FEELS VERY UNSAFE.

FUEL PUMP LEAK.

WHEN GAS TANK IS FILLED THERE IS A VERY STRONG GAS SMELL. THE FUMES FILL UP THE WHOLE GARAGE AND CAN BE SMELLED WHILE DRIVING. ONCE FUEL IS DOWN TO 3/4 TANK THE SMELL GOES AWAY. DEALER SAYS MY CAR IS PZEV AND THEREFORE DOES NOT QUALIFY FOR ACTION PE12001. THEY SAY MY VEHICLE IS EXEMPT FROM THE WARRANTY EXTENSION AFFORDED ALL OTHER CARS IN ITS CLASS. LOOKING FOR RECOURSE AS MY MECHANIC SAYS THE FUEL SYSTEM IS IDENTICAL IN THE PZEV AND NON PZEV VEHICLES.

PUNGENT FUEL ODOR AFTER FILLING UP GAS TANK. THE SMELL IS SO STRONG THAT IT CAUSES DRIVERS NAUSEA, HEADACHES, AND DIZZINESS. LOCAL DEALER (RBM OF ALPHARETTA) STATES: "MY TECH FOUND THE FUEL SENDING UNIT SEALING RING TO BE CRACKED AND LEAKING WHEN HE PULLED UP THE BACK SEAT. THEN HE GOT THE VEHICLE UP IN THE AIR AN COULD SEE FUEL RESIDUE ON THE BACK SIDE OF THE FUEL TANK THAT HAD DRIPPED DOWN FROM THE TOP. THE SOLUTION FOR REPAIR IS TO REPLACE THE FUEL TANK ASSEMBLY, REASON FOR THIS IS YOUR VEHICLE IS A PZEV OR PARTIAL ZERO EMISSIONS VEHICLE. THE FUEL TANK AND SENDING UNIT ARE SEALED FROM THE FACTORY FOR ZERO EMISSION STANDARDS. WHEN YOU ARRIVED THIS MORNING I REVIEWED THE VMI FOR YOUR CAR TO SHOW YOU IT WAS NOT PART OF THE WARRANTY EXTENSION FOR THE FUEL TANK YOU SPOKE OF. I STILL RAN...

STRONG GAS FUMES INSIDE THE CAR. STARTED SMELLING IT AFTER 100,000

I'M SMELLING A HEAVY GAS ODOR IN MY VEHICLE. LIKE THERE'S A LEAK IN THE BACK SEAT.I FEEL UNSAFE IN MY VEHICLES. IS THIS PROBLEM COVERED UNDER RECALL?

TL* THE CONTACT OWNS A 2007 MERCEDES-BENZ E350. WHILE DRIVING 75 MPH ON THE HIGHWAY, THE VEHICLE RAN OUT OF FUEL AND SHUT OFF. THE DEALER DIAGNOSED THAT THE FUEL PUMP WAS FAULTY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 116,000.

HELLO GUYS. I AM HAVING AN ISSUE WITH MY E350 (07), EVERYTIME I FILL UP MY TANK I CAN SMELL THE GAS. I DON'T SMELL IT INSIDE THE CAR BUT OUTSIDE THE CAR AND IT IS STRONG. IT IS REALLY STRONG THAT YOU THOUGHT THE GAS SPILLED. ONCE THE GAS GOES DOWN TO LIKE 3/4 OF A TANK THE ODOR WILL BE GONE. I TRIED TRACING WHERE THE GAS ODOR IS COMING FROM AND I THINK IT IS UNDER THE FENDER ON THE REAR DRIVER SIDE.