2016 KIA SORENTO Engine Problems

The contact owned a 2016 Kia Sorento. The contact stated that as he had parked and shut the vehicle off, he saw smoke emitting from under the hood. The contact exited the vehicle and saw flames from under the front of the vehicle. As the contact was stepping away from the vehicle he saw that flames were issuing from the rear passenger side wheel well where the fuel filler door was located. The contact stated that there was no warning light. The fire department was called and extinguished the flames. The police were on the scene and issued a report. The vehicle was towed away to an impound lot and later declared a total loss by the contact's insurance provider. The manufacturer was informed of the failure. The failure mileage was approximately 99,000.

I’ve had my 2016 KIA Sorento for a month. The engine locked up. So, I would like for it to be repaired at no cost to me since it was within the 30 period of purchase. I need to know what to do at this point. My car is at the dealership where I bought it from. Thank you for a speedy response.

The contact owns a 2016 Kia Sorento. The contact stated while driving 25 MPH, the vehicle stalled. The contact was able to push the vehicle off the roadway. There were no warning lights illuminated. The vehicle was towed to the residence. The contact called the local dealer and was informed that the vehicle needed to be diagnosed. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and informed the contact that the vehicle needed to be diagnosed. The approximate failure mileage was 100,000.

Last year before my 100,000 mile warranty was up, my vehicles engine light and oil light came on. This was following an oil change which was approximately 3000 in. I checked the oil to find out there was no oil. After adding oil, I took it to the Kia dealership and was told the place who changed the oil didn’t tighten my oil filter which was not true because there was no oil on the garage floor where it was parked. They then proceeded to tell me this engine uses a quart of oil every 1000 miles. Fast forward, to last week, I was driving on the highway when my car all the sudden had high RPM but wouldn’t accelerate. The vehicle started stalling and died. I pulled over and again tried to start the car which it died again. The oil level was fine. I took it to a...

My 2016 Sorento LX is consuming 3quarts of oil in 1000 miles, I have asked the dealership and mentioned this to them and now after warranty is over they finally did oil consumption test and my car needs a new engine, I was told it could blow up at anytime, I have all maintenance papers and was told I would have to pay $7,000 to replace engine

Does not show low oil light when the car has no oil in the engine

My car started jumping while driving we had put oil in my car 3 weeks prior. It also smelt like my car was burning while the heat was on I had 2 babies in the back seat and I was scared to death. I haven’t received anything in the mail about any recalls what so ever. I had to hear by a family friend the day of the incident that he thinks they’re recalls on my call so I looked it up. My car is currently not working now and I have work and doctors appointments for babies I got to Kia tomorrow they’re saying I don’t have any recalls on my car and I looked it up on here and I do. I’m pretty sure they’re just not wanting to pay for it. They said if I have a warranty they could do. I just don’t know what to...

due to low oil pressure the timing chain failed causing immediate loss of power. The call was then rolled off the highway at idle speed creating a hazard while this was being done. There were no warning lamps prior to incident. This was inspected by the dealer "Team KIA El Cajon".

Engine light come on and had someone to check it and they said recall on motor car has been using a lot of oil I put in one quart every two weeks the car is stalling and missing also

A lot of oil in the floor. Oil Pressure Sensor Fail Lock of all doors are crazy (lock and unlock so many times)

While driving car sputtered, was able to get to side of road. Turned car off, waited and then turned on again and was able to proceed, engine light on - got occasional performance issues. Kia dealer checked out and servicing, informed me of the oil was depleted issue and in need of substantial engine repair. (Provided written estimate, approx $4800). Able to continue driving but risk of stalling, told eventually timing belt will fail. Got estimates for repairing, and total engine replace to compare options. (Have not done either option as yet).

Engine began regularly overheating. Problem began in May 2023. No warning lights, other than the temperature gauge going up. Thermostat was replaced, radiator was cleaned and checked, without defects found. No leaking hoses. Problem continued to get worse, requiring coolant be added every time the car was driven. Mechanic decided the head gasket was failing. Due to the nature of the head bolts, the recommendation was to replace the engine. This has not been done and the car is unusable and unsellable due to the failure.

The engine has not worked properly in over a year and has problems accelerating and skipping. Engine light remains on at all times.

2016 Sorento 3.3L with approximately 136,000 miles on it. Did not have heat. Diagnosed with low coolant and possible head gasket leak due to loose head bolts. No warning lights. Seems to be a common manufacturing issue with these engines.

17-year-old daughter driving 65 mph down the highway when engine just gave out. Loss drive power but was able to make it to the side of highway, once stopped coolant find blowing out. There was no overheating warning or light luminated on dash. Once towed to shop and inspected told head gasket blown out dur to loose head bolts & possible head crack due to lost coolant.

Engine stalled when merging in the freeway. Mechanic said that the engine stalled because there was not enough oil. I did an oil change a month prior, and no oil light indication came on until after the car broke down.

2016 Kia Sorento SX 3.3l engine failure at 87k miles. Head bolts backed out. Kia dealership verified the issue. The engine could have seized why driving which is a safety risk. No warning lights at all.

I was taking my mom to her knee appointment after her surgery, and my temperature gauge started to rise. No lights or warnings came on in the car what so ever. I pulled over before it reached the red, let it cool and checked fluids. From what I could see the oil, and coolant were fine. The heat in the car stopped working, and the car kept wanting to over heat in the lower gears. I got it to Lion Country Kia in St.College and diagnosed it as finding a cylinder head gasket. My car could no longer be driven, from St.College to my home in St.Mary’s. I had to have it towed, as well as checked here as well to find they were right with a cylinder head gasket issue. I was under the assumption I had the power train warranty as well because it’s under 10/100,000 but unknown...

I noticed one day when filling up my wiper fluid that the engine was just slightly below the coolant low level. I topped off the coolant and tried to see if there was any leaks under the car. I couldn't see any. I started the vehicle and noticed there was bubbling in the coolant reservoir.I called my local mechanic and scheduled an appointment to bring the car in. The car wasn't driven until the day it was going in to be looked at. When driving the car in it started rough and slugish but then went back to normal. I drove it to my mechanics and on the way the car started running very rough engine shaking and the check engine light started flashing. I was only a few blocks away from the shop so I coasted in. They took the car in said it had a code for a...

The engine threw a rod while driving on a flat stretch of US HWY 285. The vehicle is available for further inspection if needed. The engine has 61,300 miles on it. We were forced to stop on a small 2-lane highway and wait for hours for a tow. This was inspected by the dealership and needs to be replaced for the vehicle to be safe to drive again. This is not covered under warranty as I am the second owner with a warranty up to 60,000 miles. No warning lights or messages occurred prior to the rod being thrown.

Vehicle is burning excessive amounts of oil. The check engine light nor low oil light has came on and vehicle was (4) quarts low (according to independent mechanic). Was told by KIA dealership that they would not repair unless the engine was completely blown up. I was told to add oil, get more frequent oil changes, trade vehicle, or come up with $8,500. The engine only has 61,000 miles on it and is a 2016 model. This is a widely known issue and KIA needs to admit the failures and fix the problem.

My car has been having high oil consumption. I have taken it to my Kia dealership. They informed me this is a problem with the make and model. They told me this is the beginning of an engine problem that will ultimately cause engine failure affecting connecting rods and bearings. My options are to drive the car until it fails then Kia will replace the engine. I a,so co tacted Kia corporate Customer service a d was told the same thing. I ask her to file a complaint and accelerate it. She said 5hat was. Ot he process. I am 77 year old widow. I'm active and drive my car day a night almost every day. I am usually alone. The solutions are not acceptable. There is a danger for me getting suddenly stranded alone at my age. I think the engine should be replaced now. Can you help me...

In November last year, my car caught fire while I was driving on a highway at a rate of about 70 mph. Some good Samaritans flagged me down and I was able to pull off the road and escape injury. My car was a total loss as were the contents of it. The fire department tapped out the fire. Kia admitted responsibility saying it was a manufacturing defect (I have the email conversation saved) but only wanted to pay my insurance company back and refund me my deductible. Kia would not pay for my lost iPhone and belongings because they said they could only do so if I provided a receipts for those items. Who has a receipt for everything in their car? I didn't claim to loss a Rolex or anything crazy. I refused the offer and am out for the loss of my car, deductible and its contents...

Car started making a knocking noise and before I could pull over the car shut off. Told now engine needs to be replaced. Kia could not look at it until November 1st and will not give us a car to use. We only have this car as a mode of transportation.

car has been burning oil, I'm filling it every other week and i barely drive it (less than 30 miles a week). Was driving to the dealer to have it looked at and it failed - I suddenly could not accelerate on a busy highway over 3mph! No warning lights came on at all and it is not throwing any codes. I was almost rear ended. One Kia dealership told me "just keep topping off the oil and drive it till it fails" That seems like an unsafe solution. Will Kia be responsible if I get into a collision if my car suddenly fails?

Excessive oil consumption, concerned about engine seizing while driving due to this.

Engine burned oil with no warning lights. Engine failed on highway with no warning lights. Regular maintenance and oil change done to vehicle, this was not negligible.

premature engine failure due to excessive oil consumption, without indication from warning light of low oil. Checked my oil and registered 0 on the dip stick. the engine knock became present pulling into my driveway

The contact owns a 2016 Kia Sorento. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated that the engine consumed 2 quarts of oil for every 1,000 miles driven. The dealer was made aware of the failure and performed an oil consumption test. The vehicle failed the oil consumption test twice. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 71,000.

Car got caught on fire while driving with my 5kids

The contact owns a 2016 Kia Sorento. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to CarMax, where the mechanic retrieved DTC code: P017 (Crank Shaft). The contact stated that unknown repairs were made to the vehicle; however, the contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer who replaced the battery; however, the failure recurred. The dealer informed the contact that the engine had misfired, and that the engine had a crack in the manifold that had been glued together. Additionally, the dealer informed the contact that the transmission had previously been replaced. The dealer informed the contact that the top of the engine needed to be taken apart. The warranty company requested the records of all the oil changes. The vehicle was not repaired....

Driving vehicle and check engine light came on, pulled over to an advance auto to have codes pulled. When lifting the hood to double check everything while waiting on codes to be pulled, I could smell a burning smell. After codes pulled, I sat in parking lot and researched codes P001100 and P208800. With codes and smell of burning, I had vehicle towed to Ferber's Tire & Auto Service, Inc. at 10383 Leadbetter Rd. Ashland, VA. 23005. They pulled codes and found that a recall was issued by KIA for this issue with CVVT Assembly. I called KIA and I was told that my VIN was not covered for this recall but that if the recall was expanded and covered my VIN that they would notify me. At this point I had no choice but to repair vehicle on my own even though KIA knew of this issue with their...

Car ran fine until we stopped for gas, went to get back on the highway when the car wouldn't accelerate >25mphs,almost got hit from this. The car was then towed to the near by Kia dealership and they found that it was a compression issue with a known issue in the engine and now we need a new engine or scrap the car. Kia is not willing to fix their horrible product and has told us to just suffer.

UNKNOWN Possible head gasket, radiator or water pump damage. Light smoke from engine. Constantly have to fill car up with antifreeze & water every few miles. Car is never driven over 45 mph.Car easily overheats & leaves us stranded as we live in a rural location. Have to purchase antifreeze every 3 days that we cannot afford. Have VERY LIMITED funds to assist with mechanical work, but we can contribute a little. No income whatsoever coming in due to job loss. Can't rely on car to get to work, but can work from home. Currently seeking employment, but competition has been tough. This is our only car for our family of 4. 2 kids in school age 8 & 4. No bus or friends/relatives who can help.Was referred to this program by a friend as they informed me that it offers financial assistance for some repairs. This affects the safety...

this vehicle is a match box waiting to kill someone. I've been reporting these problems an nobody has follow up. on 08/20/2023 fuel pump had to be replaced after fumes coming into vents report one on 06/03/2023 issue happened again, 0n 09/04/2023 engine went out. after getting vehicle back catalytic converter and manifold was burnt out do to engine .had it inspected by a muffler shop. kia will not replace anything even if they are told it was caused on behalf of there produce

My engine failed with no warning, my car shut down on the hwy. It was a safety issue because the car shut down while driving on the hwy and could have resulted in a traffic accident. This problen is all over the internet. There were no warning lights. Car ran fine up until it stalled and lost power and shut down. When towed to the repair shop, I was told it was completely out of oil, metal shavings were in the oil filter. The shop replaced oil and the car ran for a bit with knocking noise. On the way to the kia dealership, after learning this was an issue with my type of vehicle, the car shut down again and had to be towed to the dealership. My request for engine replacement was denied even though it is well within 100.000 miles and or 10yrs. It has 84,000 miles....

Sometimes the cruise control works. Sometimes it doesn't work. Even after vehicle is warmed up still no resolution. Engine oil disappears without notice or warning.

Car shutters and stalls and metal shavings in the oil pan

2016 Kia Sorento suddenly without any warning lights started losing power while driving on busy intersection. Vehicle dies, have towed, they say looks like there was no oil despite fairly recent oil change and without oil light popping up. Mechanic states it was ok for now but would need to start thinking about a new engine. Pick up vehicle and it didn’t even make it home before it lost power in an intersection again. Called Kia multiple times and despite other Kia’s having this issue apparently my vehicle is not one of the ones with a recall. There is nothing they can do for me. Owe 11k on vehicle, motor will probably be close to that. For now I am making payments on a vehicle that won’t go anywhere. Went to Kia dealership to see what help they could provide and their suggestion was to stop making payments and let...

3.3 liter engine - no warning not part of recall or knock sensor per Kia - driving slow ( thank God ) just died . Towed to the dealer - hearing 3 different story’s ? Diagnosis ? Manifold or Rod Bearing issue - whole engine needs replaced over 15k cost . Doing research on this issue snd see many complaints on all makes and models / expect a recall on this vehicle in time as well - it’s only a matter of time till someone is hurt or killed due to Kias repeated negligence in regards to engine failure - the dealer and corporate are ignoring this and that is not acceptable .

Car engine suddenly started to fail, no power, engine knocking, died in traffics turning into an intersection extremely dangerous

The vehicle lost.all power engine started to knock stopped in the middle of traffic in 4 lanes almost causing an accident 700 miles from home. Mechanic states engine is blown and that Kia engines don't last past 100000 it will cost me almost 11000 to get a new Kia plus had to pay for rental car motel etc to get home. Pathetic and extremely dangerous and car has to be pushed out of traffic and get a tow truck to haul it. I will never ever purchase a Kia again and will tell everyone I know not to purchase and of course the warranty was off so I have no can and lose 110000..Kia should be held responsible as it looks like this is a continuing and dangerous issue.

I purchased a like new 2016 KIA Sorento with about 6000 miles on it. Maintenance was performed by Dealer on regular schedule. After appx 40,000 miles, early in 2021, I noticed obscene oil consumption, at least 1 quart every 325 miles. Dealer checked the engine and said "Yes, it is losing oil somewhere.", but did nothing to fix it. High oil consumption continued and eventually cylinders 2 and 4 blew out on interstate with a car load of kids mid-year 2022. Dealer fixed this at my cost of about $1700.00. Late 2022, just past 100,00 miles, one of the exhaust valves broke and pretty much destroyed the engine. Dealer confirmed the issue and stated they would not replace the engine or repair the engine, and recommended I find a mechanic. Since December 2022, I've had the car towed multiple times to the Dealer and then to 2 different shops and...

My oil light was not working and even though I was having maintenance done on my car regularly, my piston rings failed and my car was burning oil between oil changes and I did not know it. Now, my car needs a new engine which I cannot afford and Car Shield is refusing to honor their warranty. I have been without a car for 4 months while it sits at a shop

The contact owns a 2016 Kia Sorento. The contact stated that she noticed that the temperature gauge was continuously fluctuating. The contact checked the oil level and noticed that there was no oil in the vehicle; even though the engine oil had been changed two weeks prior. The contact added 3 quarts of oil in the vehicle. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the engine needed to be replaced, and that the failure was related to Kia Campaign Number: 2002B. The vehicle was taken to the dealer, who informed the contact that they could not replace the engine unless it had completely failed. The vehicle was not repaired. The manufacturer was notified of the failure and advised as the dealer. The failure mileage was approximately 73,000.

My engine was replaced under the recall approx 10,000km ago. Now, my car is over heating. Check engine light has NOT come on ever. There seems to be oil in my radiator as the colour is that of a milky brown.

The engine on our 2016 Kia Sorento blew in February (2023) with 120k miles on it. When this happened, it blew a fist sized hole on each side of the engine. A brief fire was seen under the car but quickly went out. Since it was over the MFG warranty, we had to buy a used engine for $7k. Labor was $3k. There were absolutely no warning lights on the dash. Fast forward 6 months, the replacement engine now just seized. You just can't make this up. Kia should not be allowed to make cars. The car broke down in a small town 3 hours from home. With $11k still owed on the vehicle, I just can't justify spending another $10k to replace the motor again. There were no warning signs this time either. Our engine is the 3.3L which Kia is not offering lifetime warranty on and out of...

Total engine failure on highway with no warning. Kia dealership says a piston broke and a valve is stuck open. Total engine replacement required with a cost of $12,000. Kia refused to help with cost due to car being at 101,000 miles. Only 1,000 miles over the powertrain warranty.

The contact owns a 2016 Kia Sorento. The contact stated that while driving at 70 MPH, the vehicle lost oil , the low oil and low fuel warning lights did not illuminate. The vehicle started to slow down and it made an abnormal noise and lost power. When she depressed the accelerator pedal, the vehicle would make a jerking motion. The contact was able to pull over to the shoulder and the vehicle was towed to a safe area. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was unknown.

The contact owns a 2016 Kia Sorento. The contact received notification of NHTSA Campaign Number: 22V703000 (Trailer Hitches) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while attempting to drive at highway speeds, the vehicle lagged and was unable to exceed 50 MPH. The check engine warning light was illuminated. The manufacturer was not made aware of the issue. The failure mileage was unknown. Parts distribution disconnect.