2016 KIA SORENTO Engine Problems

The engine stalled while driving on the expressway. Myself and my daughter and her friend were in the car. The vehicle started right back up, and I was able to drive the car home (less than 2 miles away). The following day, my wife got an oil change, and went on the expressway, and the engine stalled again causing her to have to navigate the car, with no engine power, to the side of the highway and wait for myself and a tow truck. Both times were very dangerous. We had the vehicle towed to a mechanic, who said the crank shaft & rods and bearings for the engine look like they failed and seized up, causing the engine to complete lock up and stall, requiring a full engine replacement. Kia is refusing replacement saying we are not covered by the previous complaints and concerns, stating our vehicle is not...

My car totally stopped on me due to one of the 8 recalls I have undone related to my car. My insurance company verified that the recalls were open related to my car. I verified it to make sure by vin number at NHTSA.gov. up until today 2/13/2026 as I spoked with a representative at NHTSA my 8 recalls went from 8 to 0 recalls all of a sudden. I'm pretty sure the young lady went updated they website to read just that. I still have some proof that the 8 recalls pertain to my car and needs to be repaired.the dealership had me to bring my car in due to the recalls but because it had a motor failure now they're saying it's my fault for going over the approximate mileage of getting an oil change which is not true. The recalls were due way before my time and...

Our 2016 Kia Sorento had 96k miles on it, my 2.4 Liter, V4 GDI engine. I was driving it to my house on the streets, when the vehicle it completes died on me in the middle of the streets, it won't turn on, had it tow to my house. Made an appointment to take it to body shop on 2/12/2026, when it died while driving it to the auto shop, won't turn on, had it tow to auto shop. It has been burning oil for quite a while, keep putting engine oil very often. Auto shop confirmed vehicle found no codes, inspect engine oil, engine oil is very dark, manually rotated engine crankshaft, found engine seized. Vehicle has internal engine damage, possible connecting to the rods and bearings damage. Estimated repair is 9k. It is available for inspection.

3 times head gasket has been replaced and repaired and every time oil is changed, they say I am losing oil

The vehicles is showing all this codes P0340, P0365, P0780, PO010.

Our 2016 Kia Sorento had 86k miles on it, loud knocking began and days later catastrophic engine failure. Rods and bearings are busted on my 3.3 Liter, V6 GDI engine. It died while my wife was driving it to the dealership. Estimated repair is 19k, metal shavings in the oil. It is available for inspection. My wife was driving it on the highway when the engine failed. Dealer confirmed the rods and bearings were broken.

Failed oil pressure switch and now my engine is no good

Head gasket leaking, yes Causes engine to overheat. Radiator looses coolant and backs up into overflow. Makes heat and ac flow coolant fumes into vehicle. No longer clear air. Not yet. Still researching. Independent Mechanics shop. No There was no warning when the vehicle overheated

The contact owns a 2016 Kia Sorento. The contact stated that while driving at 50 MPH and depressing the accelerator pedal, the vehicle speed decreased. The contact was able to pull into a parking lot safely. The contact attempted to restart the vehicle, but the vehicle failed to restart as intended. An independent mechanic and a dealer were contacted. The vehicle was towed to the dealer, where it was diagnosed that the engine starter needed to be replaced. The vehicle was then towed to an independent mechanic, where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 83,000.

The vehicle is a 2016 Kia Sorento equipped with a 2.0L Turbo Theta II engine subject to the KSDS (Knock Sensor Detection System) safety recall. The original engine was replaced at approximately 70,000 miles under Kia’s engine service program. The replacement engine currently has approximately 32,000 miles. The vehicle developed internal engine damage diagnosed by a Kia dealership as a burnt exhaust valve. A burnt exhaust valve indicates abnormal combustion conditions such as lean operation, pre-ignition, detonation, timing deviation, injector malfunction, or lubrication failure. These are conditions the KSDS recall was intended to detect and mitigate. Kia Consumer Affairs denied warranty coverage, stating that the extended warranty applies only to rod bearing failure and that no further escalation would be pursued. Kia Consumer Affairs declined to escalate the matter for District Parts & Service Manager review and directed the owner back to the dealership. During the prior engine replacement, the...

Engine suddenly started making a lot of clattering noise. Oil consumption has been extremely high! Mechanic stated engine needs replaced.

Vehicle: 2016 Kia Sorento, VIN [XXX] Incident Date: November 13, 2025 Incident Location: Durham, NC (3828 Guess Rd) Cause of Loss: Engine Fire, confirmed by Durham Fire Department Report (Incident #253663) as "originated from under the hood." TECHNICAL NARRATIVE & SYMPTOMS (CRITICAL FOR LIABILITY): I am filing this complaint to report a catastrophic vehicle fire that I believe is directly linked to multiple acknowledged manufacturing defects that create a fire risk in Kia vehicles. ABS/Traction Control Light Warning (Direct Fire Risk Symptom): Immediately prior to the loss, the ABS and Traction Control warning lights were constantly illuminated. This is a known precursor symptom for the defective Hydraulic Electronic Control Unit (HECU) or ABS Module short-circuit, which has been cited in numerous Kia fire recalls (e.g., NHTSA 20V019, 20V519). The fire's origin under the hood is consistent with this component failure. Prior Engine Failures (Systemic Defect History): This vehicle has a...

The safety hazard began with a pattern of ignored warnings by the authorized dealer network. On Aug 15, 2025, I brought the vehicle to Luther Kia of Bloomington for a Check Engine Light. The dealer simply cleared the code without diagnosis, failing to catch early signs of engine trouble. On Sept 22, 2025, the engine failed again. I drove the vehicle in unsafe "limp mode" to Luther Nissan Kia [XXX] ). They found the engine was "4 quarts low on oil" (severe starvation just 37 days after a dealer oil change). Despite this catastrophic finding, they failed to diagnose the root cause and released the unsafe vehicle to me after selling only a spark plug replacement. On Sept 26, when I attempted to pick up the vehicle, the Check Engine Light was flashing immediately at handover. I refused to take the unsafe vehicle. The dealer then replaced an Oil Control...

For about 23,000 miles our mechanic has mentioned that the engine is burning oil. The exhaust pipe is covered in black soot. I monitor the oil level and it is always low even after oil changes with no oil leak. This has been provided to Kia with no remedy. Recently our Sorento was in a busy highway and the check engine, oil and battery lights came on and the car went into limp mode. We had the vehicle towed to Kia Chula Vista and the engine will be replaced by them. My concern is that the catalytic converter will soon fail and the engine issues need to be addressed for all of these makes/models before someone gets seriously hurt or killed.

The car was running as normal and then randomly it started kind of rough and seemed like maybe just cold. But I had my mechanic take a look, and he said that when he started it, which was the next day that it made a loud knocking sound upon start. On the 30th I had it towed out to West Hills Kia in Bremerton. And they reported back that the engine needed full repair. I only owned this car one year and before me it was reportedly well maintained. I maintained it well also! Kia is denying all recall, but it’s a 2016 Kia sorento. It’s within the one or two years that the recall doesn’t cover??? The brake lights also work and always one of them is not working. It is not exclusively one or the other but the bulbs keep burning out. I need to know what to...

Engine failed. Took car to Johnson City Kia dealership as advised by Kia of north America. The dealership said the engine failed due to carbon build up which is a problem with the engines, that it was not covered under warranty. I paid over $6,400 to have the engine replaced. When I was driving the car home the engine light came on and I lost power on the interstate causing me to almost get hit by a semi-truck. I took the car back to Kia of Johnson City Tn. the next day. Kia stated that the high-pressure fuel pump had went bad from the time I left the dealership and got home. I paid over $1,350 to replace a High-Pressure Fuel Pump. On the way home engine light and loss of power. I returned to Kia. They stated that gas had gotten into my oil. They changed the oil and...

Lost motor power while driving. No warning light before engine failure.

Mixing coolant with oil engine failure

My 2016 KIA SORRENTO consumed all oil resulting in engine (3.3L Lambda II) failure within 72 days (3,442 miles driven) of Kia dealer service department complete inspection and service (including oil).

Around 140k miles the engine started to randomly overheat. We changed the serpentine belt as well as all hoses. The engine then started to burn large quantities of oil. At 142k miles it failed all together and we are now looking at having to purchase a new engine or a new vehicle. After doing some research I read that this was a common issue with the 3.3L V6 Motors and felt the need to provide my case as well.

Over heating , loss of heat in the vehicle , oil in the radiator fluid so possibly a bad head gasket car has 121000 on it

The engine failed. Had a new engine put in the car. Driving the car home the car lost power on the interstate causing me to almost get hit by a semi trailer. Called Kia Dealership and was told to bring car back. They said it had a bad high pressure fuel pump. I had it replaced, same issue. They said they would not fix the engine to take it somewhere else. Called Kia of north America to report the safety issue and I didn't feel safe driving the car. I wanted the car to be bought back. They denied it and would not honor the warranty. They said i could not file a lawsuit against them? Engine is bad. I sent a written statement to Kia of American with all paperwork notarized.

Loss oil in big quantities headed to engine damage

While driving the vehicle started making loud engine noises. Contacted the extended warranty department and got the car in the shop. The engine had blown and had metal in the oil pan and oil filter. The car had a fresh oil change and showed to have a clean maintenance history. Just purchased the car a month prior. Warranty covered the replacement of the motor.

The intake valve cam Engine Variable Valve Timing (VVT) Sprocket pin wasn't properly seated in the phaser and worked its way out. Additionally, the corresponding hole in the camshaft was machined too deep, allowing the pin to completely depart the phaser and move into the camshaft. This resulted in no control over valve timing and the Bank 2 camshaft over-advancing the intake valves to 63 degrees from standard. This is under-engineering of critical engine parts and poor quality control by Kia. It caused the engine to go into "limp home mode" with a significant reduction in power and a flashing check engine light. Had this happened towing a trailer, or in poor driving conditions, the vehicle may have been difficult to control and put occupants in danger. The pin was found completely inside the camshaft. There seems to be low quality engineering with this manufacturer, as there are many reports...

I am receiving an engine problem on uvo. I took it to autozone to run a diagnostic test and states cam sensor engine problem. It is using excessive oil. I keep my engine oil changed consistently on time. It is not making it to the next oil change date before I have to add oil. This is my main source of transportation and I am on social security and cannot afford engine failure repair. This should not be happening since I have my oil changed consistently. Please advise.

My KIA, engine just died. I was at a stop light, the light turned green I pressed on the accelerator to go and at the middle of the intersection the engine died. Not certain what had happened or why the engine would die. After a week I had the vehicle towed to a car shop. The same shop that had just done a maintenance on the vehicle in July 2025. I have attached the copy of receipt from the work that the shop had done. When they looked at it they thought at first it was the key fob, so a new key fob was done, it still did not start. Then it was thought to believe it was the starter, so a new starter was installed, vehicle still did not start. At that time I was advised that it was the engine that had siezed. My complaint is that...

Just bought the car, was perfectly fine during the test drive, no lights on or engine codes present. On my way home check engine light came on showing code P0420 , catalyst system efficiency below threshold (bank 1), saying the catalytic converter needs to be replaced. Did some research and found there were certain 2016 Kia Sorentos recalled for this issue, but doesn’t show up on affected vehicles list when I look up my VIN # .

got into my vehicle pushed button to start, could hear a clicking for the first few seconds, then clicking went away. Drove off, went approximately 0.30 mile at a stop light when started to go it stalled in the the middle of an intersection. No warning light no other warning of anything wrong with vehichle, no other warning signs that there could be anything wrong. In July 2025 I had just took vehicle in for a major maintenance, oil, air filters, spark plugs, timing belt, and I checked oil and again no warning signs that there was anything wrong with vehicle. Took to a shop, mechanic believed it was the key fob, due to immobilize, had a new key reprogrammed and still not start, then proceeded to check the starter and installed a new starter still not start and found to be engine siezed.

Engine seized up while driving. I had just visited the dealership and had 5 RECALLS done.

I now believe I've had a lemon. Since I purchased my car in 2016 they have been trying to diagnose a smell from the exhaust and started replacing parts, this was in Miami. Then for a few years in Vegas the car spent months at the dealership trying to fix a burning oil issue which I've been told there is a known problem with the turbo still isn't fixed. From the first year I had paint peeling on my snow white pearl color which has numerous forums about KIA/Hyundai paint issues especially with my color. I had them repaint the hood which took twice after the bad job the first time. I saw little bumps in the paint which I thought was over-spray from that incident and now I have peeling from one of those spots which is how they form from what i read. My car is 2016 but...

83,000 miles just changed oil and knock sensor and engine seized

The had the same oil leakage recall fixed two times by a dealership which it is still leaking BAD! That was said to be an oil pressure switch. My trunk also will not open.

My son was driving on the hwy and a banging sound started- lights started flashing on dash and it lost speed. Stranded on road. Read that 2016 KIA SORENTO v6 engines have this prob but apparently ours doesn’t??? According to Kia these run quite a while so 160K isn’t many miles! And all maintenance done at same location the life of vehicle. Makes no sense that it states everywhere I’ve read 2016 V6 have this problem, why not ours?? Now we battle with putting a new motor in a vehicle I just bought less than a year ago for the same price that I bought it for! It’s very nice interior and body but that does me no good with no engine! UNFAIR KIA!

We have been having problems with the speed control not functioning. Sometimes we couldn't set the speed or slow it down. Now it doesn't function at all! When it was working the cancel switch would also not work and we had to use the brake pedal to shut it off. Later on while driving through town with the cruise control still on, I stopped at a traffic light and the engine began to race at a high rpms. I took my foot off the gas pedal not knowing exactly what it would do and rpms settled down. Luckily the suv didn't accelerate into the vehicle in front of me. The engine has done this a couple of times with or without the cruise control on. My wife drives this vehicle with our grand children onboard and I am highly concerned about their safety.

This scenerio happened and fire resulted with total loss. Fuel system, gasoline: Delivery: Hoses, lines/piping, and fittings Recall date 2018-12-18 Recall no. 18V907000 Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak. Hide details Recall consequence A fuel leak in the presence of an ignition source can increase the risk of a fire. Recall action Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is...

I purchased my Kia sorento in August of 2024 in April 2025 my Kia went into limp mode p1326.  It was determined to be part of the ksds recall but all they did is replace the sensor.  Something caused that sensor to go off and I feel they just masked the problem.   At the same time in April I was told that there is a severe case of oil consumption that the Kia dealership requested information i do a $700 engine cleaning but actually made the oil consumption worse.   Also just in the last 11 months ive had excessive paint issues where overall there's random chips, then peeling on the hood, side of the windshield and top of vehicle.  I messaged Kia USA where I was informed neither situation is covered under warranty.   My thoughts on oil consumption is i myself and the previous owners via carfax show consistent maintenance...

Paint peeling everywhere an innocent burning excessive oil.

Driving in traffic at night. Engine suddenly began running erratically, lost power and died. Upon opening the hood I found oily coolant all over the engine compartment that had shorted out the engine electrical systems. I determined that it has shorted out from coolant because after sitting for about 30 minutes the coolant apparently evaporated and the engine started again. This could have been life threatening to my wife, me and others if the engine had died on the very curvy road we'd just gotten off of. I have since found out that there is a TSB (WTY035) that extends the warranty due to faulty head bolts. But this is also a safety issue.

My Sorento burned oil excessively, without warning, and now has a damaged engine, requiring replacement. This is a serious problem and common. There are two other Kia vehicles with the 3.3L Lambda engine in Weston Kia for the same problem - low/no oil and no “low oil” light. Those two vehicles and mine now require new engines. When my car experienced the problem, the car shook and the engine vibrated with a significant loss of power. This would’ve been extremely dangerous if towing anything or driving uphill. This is a common problem among Kia forums and Kia is unwilling to assist.

Driving on the frwy when car started loosing power/acceleration, no warning lights or indicators on dashboard. Safely able to merge off the frwy. Turned off vehicle, engine would not turn back on. But all the dash lights came up as warning including engine light. Started to smell like burnt. Open the hood and it smelled like burning oil. Towed my vehicle & under the vehicle a pool of engine oil. Dealer confirmed engine seized. When repairs began water pump was damaged & engine mounts due to engine seizing.

I’m driving down the road my engine started knocking like head gasket lifter and rod was knocking

While I am driving it can be jerking anytime and also the slippery light come on the dashboard.Sometimes the engine light come on too.

While driving on the highway, the vehicle engine began to shake violently. The check engine light came on. The car was driving normally prior to this moment. The car has been well maintained and is in excellent condition. I looked it up and found tons of cases that reference a judgement directive from the Theta II Engine Class Action Settlement (Case No. 8:17-cv-00838-JLS-JDE), where the warranty coverage has been extended due to known engine issues. The KSDS software update (SC260) was installed in 2023, by Kia of Orange Park. The vehicle now has approximately 127,121 miles. We towed the vehicle to Daytona Kia who diagnosed the engine as failed, but declined to initiate a warranty claim or submit the case to Kia Corporate because diagnostic trouble code P1326 was not present. I purchased this diagnostic for nearly $200 from Daytona Kia and they verified the second cylinder failed. They blamed...

My 2016 Kia Sorento (VIN: [XXX] ) has suffered a head gasket failure due to a known manufacturing defect identified in a Kia Technical Service Bulletin (TSB WTY035). The defect causes head gasket failure, which in my case has resulted in external oil leakage. While Kia issued a TSB acknowledging this defect, they are denying warranty repair on a technicality — stating that the failure must involve coolant entering the combustion chamber to qualify, despite acknowledging the underlying part defect. The vehicle’s engine is losing oil through the failed gasket, and the issue poses increasing risk of engine damage or sudden performance loss. Kia’s denial is inconsistent with the intent of the warranty and the federal Magnuson-Moss Warranty Act. This problem affects vehicle function and reliability. It is also being experienced by other owners of the same model and engine. I am filing this complaint so NHTSA is aware of...

he component that failed was the engine. Specifically, the engine block burst while the vehicle was traveling on the highway at over 50 miles per hour. The explosion of the engine block during driving posed a serious risk to my safety and that of other drivers. The sudden failure could have caused a loss of vehicle control, a collision, or even a fire. Fortunately, I was able to stop in the emergency lane in time without causing an accident. The issue was confirmed by an independent mechanic, who verified the structural damage to the engine block and its complete loss of functionality. At no time before the incident did any warning lights—oil or engine—come on. There were no messages on the dashboard indicating a potential imminent failure. The engine is available for inspection if necessary.

I was driving my Sorento SXL on a highway, at approximately 50 mph. With no warning, the engine began to run rough. The check engine light immediately began flashing. I was able to drive the car approximately three more miles to an auto service center. The engine ran very rough the entire time, wanting to stall when slowing down. The mechanic determined that my car’s oil reservoir was 4 quarts low, yet no engine oil light ever illuminated on the dashboard. It holds 6.2 quarts, and had only 2.2 quarts in it. Again, there was no illuminated light whatsoever telling me my car was dangerously low on oil. Because of this low oil condition, one of my timing chains skipped, and the cam rotated approximately 62° out of center. That’s what caused it to run rough. It appears my only options now are to have the engine apart, and hope...

My wife was taking my granddaughter to her dance recital on 06/14/2025 she went to pass a car and the Sorento started missing out then died. She had to get to the side of the road and call for help. Once I arrived, I noticed oil on the ground under the vehicle. After I had my mechanic look at the car it was determined that it threw a rod out bottom of motor and the car was towed home. This is a 2016 kia sorento LX with the 3.3 motor. We have had no issues with this car and it has had regular maintenance perforemd since we purchased it at 27000 mikes. It now has 11000 miles warranty ran out at 100000

The contact owns a 2016 Kia Sorento. The contact stated while driving approximately 65 MPH, the vehicle experienced a loss of automotive power. The contact was able to pull over to the shoulder of the road. However, upon further inspection, the engine oil dipstick had an abnormal fuel odor. No warning lights were illuminated. The vehicle was towed to a local dealer; however, the vehicle was not diagnosed or repaired due to a lack of maintenance records and the costs. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000.

Possible Head Gasket Failure, present problems Coolant leak, scent of coolant, oil leaks, overheating, hydrocarbons where found in cooling system, Engine failed Coolant pressure test. Complete engine may need to be replaced.Car presently has 74,000 miles break down reported at AllStar Kia, San Bernardino, Ca 92408 on May 29, 2025. 909-763-4740 Victor Morales & Joe West. Car running fine, took in for simple oil change, and the problems above were reported.