2015 KIA FORTE Engine Problems

The contact owns a 2015 Kia Forte. The contact stated while driving at an undisclosed speed, the vehicle stalled without warning. The contact stated that she pushed the vehicle off the roadway. The vehicle failed to restart. The vehicle was towed to an independent mechanic where it was diagnosed that the engine failed. The contact was notified of NHTSA Campaign Number 20V750000 (Engine). The vehicle was then towed to the dealer where it was diagnosed that the engine needed to be replaced. The contact made the dealer of the recall campaign and was informed that the recall repair had been performed prior to the failure. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that she was responsible for the failure. The failure mileage was approximately 133,000.

Engine Oil over pressure caused my oil filter to explode oil in to my engine compartment. Destroyed my engine as well. My car is not listed in the recall list for cars with this exact same problem.

The oil plug in my vehicle came out on it's own after parking. The oil fell out of my vehicle. An oil change was then done and too much oil was put back in. Another oil change was done a few days later to fix the excessive amount of oil the Kia service department put in and when they were prepping for it, they noticed that the oil plug was finger tight and on the verge of falling out again. The engine is ruined according to the Kia dealership. No warning lamps came on during this process until the oil plug actually came out of the vehicle. The vehicle has been inspected by the dealership and a third party mechanic. Within two weeks, my oil plug came out completely once and almost fell off another time. The dealership is refusing warranty coverage and recommending I do NOT file a complaint...

While driving the vehicle is completely shuts down without warning and stalls in the middle of traffic. It is a danger to safety do to risk of getting hit. There are no codes and no warnings. It starts back up but stalls again. I had it checked by a mechanic and even he couldn't figure out what is happening.

The contact owns a 2015 Kia Forte. The contact stated that while driving at various speeds, there was an abnormal knocking sound detected. There were no warning lights illuminated. The vehicle was taken to the local dealer who informed the contact that the vehicle was operating as designed. The vehicle was not diagnosed or repaired. The contact stated the failure was related to NHTSA Campaign Number: 20V750000 (Engine). The manufacturer was not contacted. The approximate failure mileage was 56,000.

The contact owns a 2015 Kia Forte. The contact stated that while driving at approximately 70 MPH, the check engine warning light illuminated. The contact stated when she drove across the lanes to get to the emergency lane the vehicle began to lose motive power and stalled. The vehicle was towed to an independent mechanic who diagnosed and related the failure to NHTSA Campaign Number: 20V750000 (Engine). The contact stated that the vehicle was previously repaired under the recall. The vehicle was not repaired by the independent mechanic but was instead towed to the local dealer. The dealer serviced the vehicle and completed an oil change and informed the contact that no fault codes had been retrieved. The vehicle was returned to the contact. The contact then stated that while her daughter was driving at an undisclosed speed, the vehicle was sputtering. There was no warning light illuminated. The vehicle...

The contact owns a 2015 Kia Forte. The contact stated while the vehicle was parked, she checked the fluids and noticed that the oil was unexpectedly low. The vehicle was then taken to the dealer where the battery was recharged; however, a diagnostic test was undetermined. The contact then stated that without warning, the engine started to require an excessive amount of oil. The vehicle was then taken to the dealer where it was diagnosed and determined that the engine had consumed 3.5 to 4 quarts of oil per 1,000 miles driven. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 62,000. The consumer is reiterating the request for a engine replacement at no cost. Further stating the engine had multiple issues which includes failing to start, white smoke coming...

Engine is making a knocking noise, independent mechanic as well as Kia dealer inspected and said engine is about to fail, which could leave driver stranded or impede traffic. No warning lights are on, vehicle has been regularly maintained.

The contact owns a 2015 Kia Forte. The contact stated that his daughter received recall notification of NHTSA Campaign Number: 20V750000 (Engine) and the Knock Sensor Detection System (KSDS) software was updated. The contact stated that the check engine warning light illuminated while driving. The vehicle was taken back to the dealer where the Knock Sensor Detection System (KSDS) software was reset. However, the failure reoccurred while driving. The vehicle was taken to a second dealer, Gerald Kia of Naperville (1661 Aurora Ave, Naperville, IL 60540), where it was diagnosed that the Knock Sensor Detection System (KSDS) software was operating as designed and the engine needed to be replaced. Additionally, the second dealer informed the contact that the first dealer had misdiagnosed the vehicle during the recall repair as the engine should have been replaced then. The dealer filed a claim with the manufacturer and informed the contact that the...

I recently inherited this car from my mother and it appears that the engine may have issues. There is a loud noise that comes from the engine intermittently. It is louder at times then other times. The oil level is fine and recent. I've done a lot of research and it appears this is a common problem for the 2.0 engine. I feel as though this could turn into a bigger scenario if something is not done for the lack of expense a person must put into these engines.

experienced engine knocking noise when driving on freeways, and it got progressively louder as time went on. brought the issue to the local Kia dealership and it was resolved at the time, but wanted to report the incident so NHTSA can document this. thanks.

The contact owns a 2015 Kia Forte. The contact stated that while driving approximately 10 - 20 mph and making a right turn from being idle when the vehicle started smoking from the exhaust of the vehicle. The contact pulled the vehicle over and turned off the vehicle where the smoke began to dissipate. There were no warning lights. The contact had the vehicle towed to a certified mechanic who diagnosed that there was a leak occurring that could possibly cause an engine failure, however, the specifics of what needed to be repaired were not known. The vehicle had not been repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 135,000.

I maintain the vehicle on a regular basis and have maintenance records. After recent oil change shortly there after the engine light came on then vehicle cut off. The vehicle towed to shop. The service station stated the vehicle engine seized. The vehicle has 120.000 miles

Engine burning through oil FAST, possible engine fire.

Was just told about recalls for oil leaks and I’m concerned about my daughter driving the car and the engine catching on fire as it seems this has happened to many of the 2015 Kia Forte’s and I haven’t received a recall, but seem to have all the same problems has the people who have had recalls on the same model car.

The car started to smoke and caught on fire not even 2 from My house I had called and scheduled a appointment for the recall butt kia set the date to far away I only had the car for maybe 2 weeks not even 150000 miles on it

I want to preface this by saying my car (2015 Kia Forte5 EX) has been burning or leaking oil for a while now and no one I brought it to could ever figure out where. I brought it in for the recall check up a few months ago and they claimed to not find anything either. A couple of weeks ago I noticed a fairly loud ticking or knocking noise coming from my engine, I thought that maybe my oil was low even though I had just gotten it changed 2 weeks prior but I checked it and it was fine. Fast forward a few days and I get a prompt on my navigation screen to immediately have the car services and my check engine light started blinking. I brought it in to my local Kia dealership and today they told me that the engine is unfixable, and that they...

My car consistently is running out of and low on oil which is affecting my engine and how it runs. My car did break down and now Kia is performing an engine test over 3000 miles but have not recalled the engine/car even though they've told me this is a common issue with these cars. Prior to the breakdown, there were no warning lamps or messages for me to know this was happening.

The contact owns a 2015 Kia Forte. The contact stated that while driving at an undisclosed speed, there was a knocking sound coming from the vehicle. The vehicle then lost motive power. The vehicle was towed to an independent mechanic and diagnosed with rod bearing failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 85,000.

The contact owns a 2015 Kia Forte. The contact stated while his girlfriend was driving approximately 30 MPH, there was a knocking sound coming from the engine compartment. The vehicle then stalled without warning. Upon inspection, it was discovered that there was no oil in the engine although oil had recently been added. The vehicle was towed to the local dealer who diagnosed that the engine was damaged and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure but no assistance was offered. The failure mileage was 62,000.

The contact owns a 2015 Kia Forte. The contact stated that the vehicle started smoking while stopped at a traffic light. The smoke was coming from the engine. Additionally, while driving 35 MPH, the vehicle was stopping and stalling while driving. There was no warning light illuminated. The vehicle was taken to the dealer however, the vehicle was not yet repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 74,000.

The cylinder 3 connecting rod broke and shot a hole through my engine block. It also sucked metal pieces into my turbo and damaged my starter. This is the exact same issue that the 2.0 liter engines have and yet I have to pay out of pocket for my repairs. I was on the interstate going 70 mph when this happened. What if instead of shooting down, it shot back towards me? What if my child was in the car? Now Kia won’t cover this and I think they should. I took the car to multiple mechanics and not one of them told me this could happen. The check engine light kept coming on, I kept being told to replace the spark plugs and the ignition coils and it never resolved my issue. These were Kia certified dealers. Now one of these Kia certified dealers wants to charge me $13,000...

Every few months my car won’t crank. I have to get it towed to the dealership. They normally change the spark plugs and it runs again. Recently, they changed the spark plugs but I was also told that I had an engine oil leak(which is very hazardous), oil is leaking onto my engine which is causing my spark plugs to burn out so quick. They claimed they didn’t know what was causing it and told me I would have to wait until my car breaks down completely before being able to know exactly what’s causing it. Informed me that changing the spark plugs is only a temporary fix and I would go through this process again(my car not cranking and spark plugs needing to be replaced).

The contact owns a 2015 Kia Forte. The contact stated that while driving at an undisclosed speed, a burning smoke odor was detected. The contact pulled over and noticed there was smoke coming from under the hood. Additionally, there were engine parts that had melted and a puddle of fluid on the ground. A bystander assisted the contact in pushing the vehicle to her residence. The vehicle was not diagnosed nor repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. Upon investigation, the contact related the failure to NHTSA Campaign Number: 20V750000 (Engine). The VIN was included in the recall; however, the contact did not receive a recall notification. The failure mileage was 99,880.

The contact owns a 2015 Kia Forte. The contact stated while driving at 45 MPH, he heard an abnormal knocking sound coming from the engine with the check engine warning light illuminated. The contact took the vehicle to an independent mechanic for an oil change. The contact stated that while driving for approximately two miles down the road the knocking sound returned. The contact veered to the side of the road and attempted to restart the vehicle and heard another loud knocking sound coming from the engine. The vehicle would not restart. The contact had the vehicle towed to an independent mechanic who inspected the vehicle and diagnosed the failure as rod blown in the engine and that the engine needed to be replaced. The contact then had the vehicle towed to the local dealer to be diagnosed. The dealer confirmed the previous diagnosis and informed the contact that the...

2015 forte with 1.8l engine. Rod nock noise developed after 104k miles. Loss of power and drivability is decreasing. No diagnostic lights on. Called Kia and was told that the 1.8L are not under the recall. However there are several 1.8 motors exhibiting the same symptoms. Oil changes have been done at suggested intervals. I believe the recall needs to be expanded. Kia wants me to take to dealer to verify. ASE mechanic has looked at it.

Engine has blown a rod. Inspected and confirmed by certified auto mechanic.(Lucky's Amoco Service) No warnings or lights were present at time of vehicle breakdown.

My motor blew at 63k miles in Nov 2018. I was driving and it make a loud awful sound and was on fire and smoking and there was a huge hole in my engine. The kia warranty had just passed and they refused to cover the replacement

The contact owns a 2015 Kia Forte. The contact stated that the engine warning light was illuminated. The contact received notification of NHTSA campaign number: 20V750000 (Engine) however, the part to do the recall repair was unavailable. The vehicle was taken to the local dealer who confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the failure. The approximate failure mileage was 98,000. Parts distribution disconnect.

Car engine caught on fire while driving without any indication. Car stopped and engulfed in flames. Car dashboard warning lights were not present until fire began but car shut off due to fire. The car was a total loss. Driver and passengers life were at risk. Exited car within seconds of car engulfing

Car was running great. No issues, had my regular oil changes and check ups. I was driving down the road and a piston rod blew in my engine. But oil was in my engine.

The engine seized up and smoke was noted on April 29, 2021. The vehicle was towed to Woodstock Carriage Kia, after being told that vehicle would start being repaired within 1 to 3 days. The service dated has been changed 3 times. Three months later, the dealer still does not have the short block engine from South Korea. The dealer did state that Kia would reimburse me for towing and a rental car (will not pay taxes or insurance for a rental car) eventually after car is repaired. I do not have the financial resources to pay for a rental car upfront for an unknown time period. The dealer stated they only have one loaner car, which they will not loan to me. The dealer also explained there are vehicles on the lot that have been sitting there since Nov. 2020, waiting for engines due to this recall. This is...

vehicle caught fire

While driving, my engine started knocking. I stopped driving and turned off my car. I had it towed to a shop and was informed it was the same issue as the recall for 2.4 engines and told me to call Kia. Kia said it’s not covered under the recall so they won’t look at it.

The engine has lower engine knocking. It has a rod knocking very loud. It could throw a rod through engine at any time, cause the vehicle to wreck and catch on fire. Yes, it was confirmed that it had a rod knocking in engine. yes, An ASE Certified mechanic. No check engine light came on. It just started knocking real bad and lost power.They appeared as I was driving down the road.

The contact owns a 2015 Kia Forte. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated that the check engine warning light was illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 85,022.

My car engine burns oil like crazy. I received a recall notice and brought my vehicle to Gary Rome Kia in Enfield. I brought it in with the check engine light on as it was on listed conditions for the recall and when i was told everything passed i still had a check engine light and excessive burning of oil. The engine is not working properly and wasn't rectified during the recall process. I am afraid with how much oil it is burning it may lead to a fire in the engine compartment. I have followed all of the usual recommended services and was not made whole during the recall event.

THE CAR WAS BOUGHT IN JAN 2021 FROM A DEALERSHIP WITH UNDER 20,000 MILES. IT WAS NOT INSPECTED BY THE DEALERSHIP PRIOR TO THEM SELLING IT.THEY DID NOT OFFER A WARRANTY ON THIS CAR. IN APRIL 2021, THE ENGINE DIED. THERE IS NO RECALL ON THIS VEHICLE AT THIS TIME, BUT CLEARLY THERE IS A PROBLEM WITH THIS MOTOR. 0

PREMATURE ENGINE FAILURE, MECHANIC NOTICE METAL PIECES IN THE OIL FROM THE ENGINE COMPARTMENT. THE DEALERSHIP SAID THE ENGINE NEEDS TO BE REPLACED. THE VEHICLE HAS 120,289 MILES. ENGINE WAS KNOCKING, CHECK ENGINE LIGHT, AND OIL LIGHT ILLUMINATED. WHEN VEHICLE IS IN MOTION, MAKES LOUD NOISES, PUTTERS, KNOCKS AND THEN STALLS. CANNOT USE ON HIGHWAY, TOO DANGEROUS, IT WONT GO HIGH SPEEDS. I HAVE OIL CHANGES RECEIPTS FOR THE ENTIRE 120K MILES.

JUST FINANCED FROM A DEALER ON 4/12, HAD MAJOR OIL LEAK, HAD TO RETURN TO DEALERSHIP. SUPPOSED TO HAVE BEEN FIXED, BUT CURRENTLY STILL HAVE A BAD OIL LEAK. STILL WAITING FOR A WEEK FOR AN APPOINTMENT TO TAKE IT BACK TO THE DEALER TO HAVE IT CHECKED OUT. ENGINE MAKES A NOISE WHEN IDLING, ALMOST LIKE A "MISS"

MY ENGINE JUST STARTED MAKING "KNOCKING" SOUNDS OUT OF NOWHERE...IM UP TO DATE ON OIL CHANGES AND I CHECK THE OIL OFTEN...IT KNOCKS WHILE IDLE AND IN MOTION.

THE ENGINE OIL LIGHT TURNED ON AT A TRAFFIC STOP. AT THE NEXT STOP. THE ENGINE TURNED OFF AND THE IMMOBILIZER INDICATOR LIGHT TURNED ON AND AFTER ADDING OIL, THE ENGINE WILL NOT START.. KIA REFUSED TO TAKE THE CAR TO A DEALERSHIP AS THE PROBLEM CAUSE IS DESCRIBED BY THE RECALL. I TOOK THE CAR TO FREDY KIA ON 04/08/21 AND IT WILL BE CHECKED UNTIL 04/19/21.

OIL LEAKS FROM THE ENGINE DUE TO A THREADING PROBLEM, HAS HAPPENED MORE THAN ONCE AND I HAVE HAD TO GET MY VEHICLE TOWED AND WORKED ON AT A SHOP. THE VEHICLE STARTED POURING OIL WHILE DRIVING ON A 35MPH ROAD. THE VEHICLE STARTED SHAKING AS WELL. I HAVE VIDEOS OF THE CAR AND THE NOISE IT MADE

2015 KIA FORTE. CONSUMER WRITES IN REGARDS TO ENGINE ISSUES. *LD THE CONSUMER STATED THE DEALER ADVISED THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE MILEAGE ON THE VEHICLE. *JS

MY CAR LEFT MY CHILD STRANDED ON THE INTERSTATE IN ORANGEBURG ON THE WAY HOME TO MACEDONIA, SC. IT WAS IN MOTION WHEN THE VEHICLE SHUT OFF AND SHE HAD TO COAST TO THE SIDE OF THE ROAD. APPARENTLY THERE IS A RECALL ON MY ENGINE & I NEVER RECEIVED IT. I NOW HAVE A UNUSABLE CAR IN THE SHOP THAT NEEDS A NEW ENGINE DUE TO OIL LEAKING. IT IS CURRENTLY AT SHOP LIFE @ 2005 N MAIN ST, SUMMERVILLE SC (843) 475-9366.

I WILL BE DRIVING MY 2015 KIA FORTE AND IT WILL AUTOMATICALLY SHUT OFF. NO WARNING AT ALL. JUST THANKFUL THAT I HAVE NOT BEEN HIT BY ANYONE. CAN SOMEONE PLEASE TELL ME WHY THIS IS HAPPENING AND HOW TO FIX IT. I HAVE ALREADY TAKEN IT TO A AUTO PARTS STORE AND THEIR MACHINE SAYS THERE IS NOTHING WRONG SHOWING

ALMOST 2 WEEKS AGO MY 2015 KIA FORTE WITH LESS THEN 80000 MILES STARTED TO MAKE A NOCKING NOISE IN THE ENGINE ESPECIALLY NO MATTERIF THE CAR IS PARKEDOR MOVING IT MAKE A NOISE BUT IT GOES AWAY AND COMES BACK IT'SNOT CONSTANTLY LOUD NOISE BUT SOMETIMES ITS AND IT GETS REALLY ANNOYING. I DON'T KNOW IF THE CAR IS SAFE TO DRIVE. BECAUSE EVERY TIME I TRY TO MAKE AN APPOINTMENT AT THE DEALERSHIP THEY TRY TO CHARGE ME MORE MONEY FOR THE CAR EVALUATION AND THEY TOLD ME THAT THE WARRANTY IS NOT COVERING MY CAR BECAUSE IT DOESN'T HAVE A RECALL BASE ON MY VIN.. NUMBER KIA MOTORS HELP ME PLEASE

I FIRST NOTICED 3/1/2021 THAT MY CAR WAS USING HIGHER RPMS THAN NORMAL. THEN THE FOLLOWING MORNING OF 3/2/2021 WHEN I TURNED THE CAR ON IT IMMEDIATELY STARTED MAKING A TICKING/WINDING SOUND WHEN I PUSHED THE GAS PEDAL. BY THE END OF THE DAY THE NOISE AND ISSUE HAD GOTTEN WORSE WHEN I WAS TRYING TO DRIVE. IT STARTED NOT BEING ABLE TO ACCELERATE AT ALL AND FINALLY IT STARTED SMOKING AND TURNED COMPLETELY OFF AND LEAVING ME STRANDED ON THE SIDE OF THE ROAD.

I MADE A FORMER COMPLAINT REGARDING OIL CONSUMPTION. I THEN BROUGHT MY KIA FORTE5 IN DUE TO CATASTROPHIC ENGINE FAILURE & KNOCKING (OIL CONSUMPTION WAS THE SYMPTOM). IT ALSO HAD A RATTLING NOISE WHICH WE SUSPECTED MAY BE THE CAT. LONG STORY SHORT, KIA HASN'T PAID A DIME FOR THIS, DESPITE THERE BEING A RECALL WHICH INCLUDES MY VIN. THE DEALERSHIP HAS COME UP WITH EVERY EXCUSE IN THE BOOK TO NOT TAKE RESPONSIBILITY. MY SHORT BLOCK MAY BE REPAIRED, BUT NOW THEY'RE SAYING I NEED TO PAY $2700 FOR A NEW CAT & MUFFLER... WHICH WAS DAMAGED FROM THE DEFECTIVE/RECALLED ENGINE. THE CUSTOMER SERVICE AT THE DEALERSHIP & CONSUMER ASSISTANCE CENTER HAS BEEN DEPLORABLE AT BEST. THIS HAS BEEN THE MOST STRESSFUL EXPERIENCE. MY CAR HAS BEEN IN THEIR SHOP FOR OVER A MONTH. THEY ALSO ARE CHARGER ME FOR NEW SPARK PLUGS, EVEN THOUGH I WOULDN'T HAVE HAD...

VECHILE STALLS OUT WHILE DRIVING DOWN THE HIGHWAY WITH OUT WARNING