2000 FORD WINDSTAR Vehicle Speed Control Problems

THE ABS WARNING LIGHT CAME ON. WHEN DRIVING CAR OVER 45MPH, THE SPEEDOMETER STARTS JUMPING ALL OVER THE METER AND THE ODOMETER IS NO LONGER READING MILES. THIS IS THE SAME EXACT ISSUE AS NHTSA CAMPAIGN NUMBER 09V399000. APPARENTLY, EVEN THOUGH FORD RECALLED WINDSTARS, OUR WINDSTAR WAS SOMEHOW NOT QUALIFIED EVEN THOUGH WE'RE NOT EXPERIENCING THE SAME EXACT ISSUE. *TR

DURING A TRIP ON THE HIGHWAY AT APPROX. 70 MPH THE ABS LIGHT CAME ON AND STAYS ON AS LONG AS VEHICLE IS BEING DRIVEN UNTIL ITS RESTARTED AGAIN AND CYCLE CONTINUES. *TR

FOR SOME REASON MY INSTRUMENT PANEL CUSTARD NEEDLES STARTED,TO BOUNCE UP AND DOWN FOR NO REASON AND SOMETIMES ITS OK.THAN YOU BE DRIVING AND EVERYTHING ITS OK, BUT THAN THERE GOES THE NEEDLES BOUNCING UP AND DOWN AGAIN AND THAN IT STOPS OR IF I STOP AT STORE OR GAS STATION AND START THE IGNITION AGAIN IT DOES IT AGAIN.PROBLEM 2, BEFORE THE FIRES ON THE FORD VEHICLES ON THE CRUISE CONTROL SWITCH MINE HAD ALREADY BURNED OUT AS I WAS AT THE STORE PARKING LOT I PICKED UP MY HOOD AND THERE WAS THE SMOKE AND SHORT WIRES BELOW THE BRAKE FLUID HOLDER I FIXED IT,ON MY OWN THAN SEE ALL THE PROBLEMS ON THE DAILY NEWS. THIS HAPPEN WHEN I ONLY HADABOUT 85000 MILES.PROBLEM 3, FOR SOME REASON I'M HAVING WITH MY ABS,THE LIGHT KEEPS COMING ON AND MY BRAKES DON'T WORK RIGHT,BUT WHEN THE ABS LIGHT IS...

I HAD STOPPED AT THE STOP SIGN. WHEN IT WAS CLEAR FOR ME TO GO, I ACCELERATED AND WHEN I GOT TO THE NEXT STO SIGN AND SLOWED OWN, MY CAR WOULD NOT SLOW DOWN. I PUSHED ON THE BRAKES, HEARD A LOUD VROOM AND THE CAR KEPT GOING. IT'S HAPPEN 3 MORE TIMES. ONE TIME, I WAS AT A FAST FOOD RESTAURANT DRIVE THRU. I WAS SLOWING DOWN AS I GOT IN LINE AND WHEN I PUT ON THE BRAKES, THE CAR MADE A LOUD VROOM SOUND AND KEEP GOING. I KEPT PUSHING ON THE BRAKES AND IT FINALLY STOPPED. I CANNOT REMEMBER IF I PUT THE CAR IN PARK OR NOT BUT I THINK I DID THAT TIME. I WOULD HAVE TAPPED THE TRUCK IN FRONT OF ME. I READ ONLINE ABOUT A SON WHOSE MOTHERS WIND STAR HAD THE SAME PROBLEM. IT MAY NEED TO BE RECALLED....

THE BRAKE PRESSURE DIFFERENTIAL DEACTIVATION SWITCH (SCDS) (2B264) LOCATED UNDER THE MASTER CYLINDER (BEHIND THE AIR FILTER) OVER TIME DEVELOPS A LEAK. THIS CAUSES A SHORT AND A FUSE TRIP, FUSE #10 IF THE ENGINE IS ON. THIS LEAK ALSO CAUSES BRAKE FLUID TO WICK DOWN TWO WIRES TO THE ABS BRAKE MODULE (2C219). THE FLUID ACCUMULATES ON THE (ALWAYS ON) POWER CONNECTORS FOR THE ABS BRAKE SYSTEM WHICH ARE POWERED BY FUSES 101 AND 102 AND ARE BOTH 40 AMP. THE FLUID ATTRACTS MOISTURE, ROAD SALT AND LEADS TO A FIRE WHEN THE FLUID AND MOISTURE ACT AS CONDUCTOR BETWEEN THE HOT LEADS AND GROUND. THIS SWITCH HAS BEEN THE SUBJECT OF OTHER FORD RECALLS, JUST NOT MY WINDSTAR VAN YET. MY WIRING HARNESS WHEN INSPECTED WAS WET WITH BRAKE FLUID, INCLUDING THE CONNECTIONS AND THE INLINE FUSES, WHICH BASICALLY PERMITS ELECTRICITY TO JUMP PAST THE INLINE FUSES AND...

TL* THE CONTACT OWNS A 2000 FORD WINDSTAR. THE CONTACT STATED THAT THE VEHICLE HAD BEEN PARKED FOR AN HOUR WHEN HE DISCOVERED THAT THE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE AND THERE WERE NO INJURIES. THE CONTACT CALLED THE DEALER AND WAS ADVISED THAT THE CRUISE CONTROL DEACTIVATION SWITCH WAS REPLACED DUE TO A RECALL IN 2011, WHICH COULD HAVE BEEN ASSOCIATED WITH THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

2000 FORD WINDSTAR. CONSUMER WRITES IN REGARDS TO THE SPEED CONTROL SYSTEM MODIFICATION RECALL NOTICE PROBLEMS. *SMD THE CONSUMER STATED AFTER HE RETRIEVED THE VEHICLE FROM THE DEALER, THE VEHICLE WAS NOT IDLING CORRECTLY. THE DEALER STATED THE WORK PERFORMED ON THE VEHICLE, HAD NOTHING TO DO WITH THE IMPROPER IDLING ISSUE. THE DEALER INFORMED THE CONSUMER THE VEHICLE HAD A VACUUM LEAK, AROUND THE MASTER CYLINDER. *JB

THE ABS AND CHECK ENGINE LIGHTS WENT ON (AGAIN, AFTER I HAD NUMEROUS ITEMS REPAIRED OR REPLACED ON THIS VAN). I WENT BACK TO MY MECHANIC WHO FOUND THAT A PART WAS NEEDED, CALLED THE C1185 AND IS PART OF THE ABS MODULE SYSTEM. I THEN WENT TO FORD DEALERSHIP TO SEE IF THIS PART COULD BE REPLACED, AND THEY TOLD ME THAT THE MANUFACTURER FOR THIS PART HAD GONE OUT OF BUSINESS AND THE PART WAS NO LONGER MADE! I HAVE HAD THESE ITEMS REPAIRED/REPLACED ON THIS 2000 WINDSTAR SINCE I BOUGHT THE VEHICLE IN DECEMBER 2013: 1) FORD DEALERSHIP REPLACED TEN-SPEED CONTROL DEACTIVATION SWITCH PER RECALL 2) MY MECHANIC THEN REPAIRED THE ELECTRONIC BRAKING SYSTEM, SPEEDOMETER AND ODOMETER, WHICH WAS TIED IN WITH THE SPEED CONTROL DEACTIVATION SWITCH (REPAIRS WERE OVER $420) 3) MY MECHANIC REINSTALLED IMPROPERLY INSTALLED REAR WINDSHIELD WIPER 4) MY MECHANIC INSTALLED NEW BATTERY *TR

ABS AND TRACTION CONTROL LIGHTS ILLUMINATED WHILE BRAKING ON SNOW AND ICE, ABS STOPPED WORKING AND VAN SKIDDED OUT OF MY CONTROL, PUMPED BRAKES UNTIL VEHICLE CAME TO STOP, LUCKILY DID NOT OCCUR AT NEXT INTERSECTION,OR WOULD HAVE SLID INTO BUSY INTERSECTION !! BROUGHT TO SHOP AND THEY DID SOME DIAGNOSTICS AND CAME UP WITH VAN NEEDING A NEW ABS/TRACTION CONTROL MODULE. VERY EXPENSIVE REPAIR. UPWARDS OF $2000.00, IF BOTH ABS MODULE AND ABS HYDRAULIC CONTROL PARTS NEED TO BE REPLACED. WENT ONLINE AND HAVE READ MANY MANY COMPLAINTS OF THIS PROBLEM ON THIS MODEL OF VAN. FORD KNOWS AND THEY WONT ISSUE OR RECALL A MAJOR SAFETY / BRAKE RECALL......THIS COULD CAUSE SOMEONE SEVERE INJURY OR DEATH !!! BRAKES ARE THERE TO SAFELY STOP A VEHICLES MOTION !!!!! DEALER SAYS VERY COMMON PROBLEM WITH THESE WINDSTARS.IF FORD COULD FESS UP AND MAKE PART VERY AFFORDABLE THEN I COULD FIX...

AS I WAS DRIVING DOWN THE HIGHWAY, CRUISE CONTROL SET TO 60MPH. MY CRUISE SHUT OFF, MY ABS AND TRACTION CONTROL LIGHTS CAME ON. IF YOU SHUT THE VEHICLE OFF AND LET IT COOL DOWN, IT WILL STAY OFF FOR A WHILE, BUT USUALLY COMES ON WITHIN A FEW MOMENTS OF BEGINNING TO DRIVE. AND THE BRAKES WILL WORK, BUT I WILL NOT HAVE ABS OR TRACTION CONTROL AT ALL. *TR

WE WERE DRIVING ON LOCAL HIGHWAY WHEN ABS AND TRACTION LIGHT CAME ON. WE THEN HEARD A GRINDING NOISE AND THE SPEEDOMETER WAS JUMPING FROM 20 TO 50 SPORADICALLY. WHEN THE VEHICLE IS TURNED OFF AND RESTARTED EVERYTHING IS NORMAL, BUT RECURS SHORTLY AFTER DRIVING. *TR

THE ABS LIGHT HAS BEEN GOING ON AND OFF FOR NO REASON. I TOOK IT TO A MECHANIC AND THEY SAID THE ONLY CODE THAT WAS AFFECTING THE LIGHT WAS THE FRONT RIGHT TIRE SPEED SENSOR WHICH WE REPLACED AND THE CODE WENT AWAY. THE CRUISE CONTROL DOSENT WORK AND THE LIGHT COMES ON AND BREAKING IS SOMETIMES MUCH MORE DIFFICULT WHEN SLICK/WET AND LIABLE TO CAUSE AN ACCIDENT. THE MECHANIC TOLD ME MY VEHICLE WAS INCLUDED IN THE FORD RECALL FROM 6/2012 RELATINGN TO ABS LIGHT AND DIAGNOSTIC TROUBLE CODE C1185

ABS LIGHT COMES ON AND OFF WHILE DRIVING, CRUISE CONTROL DOES NOT WORK, SPEEDOMETER AND RMP GUAGE GOES CRAZY AND STOPS WORKING, LEAKING BREAK FLIUD BUT CAN'T SEEM TO LOCATE PROBLEM, INTERIOR LIGHTS FLICKER ON AND OFF, DOOR LOCKS WILL START GOING UP AND DOWN WHILE DRIVING, REAR PASSENGER DOOR DOES NOT CLOSE ALL THE WAY AND WILL SOMETIME POP OUT BUT NOT COMPLETELY OPEN WHILE DRIVING, MAKES NOISE WHEN TURING LEFT I HAD THE RACK AND PINION CHANGED BUT THAT DID NOT SOLVE THE PROBLEM THE NOISE JUST GOT WORSE. *TR

ABS LIGHT ON INTERMITTENTLY. INSTRUMENT PANEL GAUGES ERRATIC SOMETIMES. CRUISE CONTROL NOT FUNCTIONAL AT TIMES. *TR

TL* THE CONTACT OWNS A 2000 FORD WINDSTAR. THE CONTACT STATED THAT WHILE ENTERING INTO A PARKING SPACE, THE VEHICLE LUNGED FORWARD ERRONEOUSLY. THE VEHICLE WAS TAKEN TO A DEALER HOWEVER, THE TECHNICIAN WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 130,000. *TR UPDATED 05/10/13*LJ UPDATED 05/17/2013 *JS

MY 2000 FORD WINDSTAR VAN HAS FREQUENT AND INTERMITTENT PROBLEMS WITH THE ABS LIGHT COMING ON AND EVENTUALLY GOING OFF; THE CRUISE CONTROL NOT WORKING SOMETIMES EVEN AFTER IT WAS REPAIRED BY THE DEALER; AND THE GAUGES IN THE INSTRUMENT PANEL (INCLUDING THE SPEEDOMETER) ERRATICALLY MALFUNCTIONING. I HAVE BEEN TOLD THAT THESE ARE COMMON PROBLEMS WITH FORD WINDSTAR AND MAY BE SUBJECT TO RECALLS. (EVEN THOUGH THE MILEAGE IS HIGH, I REPLACED THE TRANSMISSION AND ENGINE WITH A BRAND NEW TRANSMISSION AND A BRAND NEW ENGINE IN 2006 AND 2007, RESPECTIVELY. ONLY LESS THAN 50,000 MILES ON THE VEHICLE SINCE 2006.) *TR

TL* THE CONTACT OWNS A 2000 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS BURNING FUMES WERE EMITTED INTO THE VEHICLE. ALSO, THE CONTACT MENTIONED THAT THE VEHICLE WOULD CONTINUE TO ACCELERATE AFTER ENGAGING THE BRAKES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 200,000 AND THE CURRENT MILEAGE WAS 200,140.

TL* THE CONTACT OWNS A 2000 FORD WINDSTAR. THE CONTACT STATED THAT WHILE SITTING AT A STOP LIGHT, THE VEHICLE ACCELERATED INDEPENDENTLY. THE CONTACT HAD TO APPLY PRESSURE TO THE BRAKES USING BOTH AND TURNED OFF THE IGNITION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE A VACUUM LINE WAS DISCONNECTED HOWEVER, DID NOT SOLVE THE PROBLEM. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS WHERE THE FUEL SYSTEM WAS SERVICED AND THE THROTTLE BODY WAS DECARBONIZED. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 128,000.

THE ABS LIGHT BEGAN COMING ON INTERMITTENTLY FOR NO KNOWN REASON; GRADUALLY IT HAS BEEN ON MORE. IN RECENT WEEKS, HAVE ALSO BEGUN HAVING PROBLEMS WITH THE SPEED CONTROL WORKING ONLY INTERMITTENTLY, AND LAST WEEK THE SPEEDOMETER STOPPED WORKING INCORRECTLY; THE HIGHEST SPEED IT REGISTERS IS 28-29 MPH, EVEN THOUGH I KNOW I'M GOING FASTER. THE WINDSHIELD WIPERS NOW SUDDENLY WORK ONLY ON LOW OR, IF TURNED UP TO THE HIGHEST POSSIBLE SETTING, THEY GO HALF SPEED. TWO WEEKS AGO A BRAKE SET UP FOR NO KNOWN REASON, TO THE POINT THAT I SMELLED 'BURNING.' I STOPPED TO INVESTIGATE WHEN TRAFFIC ALLOWED AND COULD SEE NOTHING WRONG. I DROVE TO A HOSPITAL WHERE SON WAS WORKING AND HE INVESTIGATED AND FOUND THE FROZEN-UP BRAKE. HE WAS ABLE TO EVENTUALLY GET IT FREED UP. A VEHICLE THAT ONCE WAS A VERY DEPENDABLE WORKHORSE HAS SUDDENLY BECOME ERRATIC AND DOWNRIGHT SCARY. *TR

ON SUNDAY 5/20/12, UPON STARTING OUR 2000 FORD WINDSTAR VAN, I NOTICED THAT THE SPEEDOMETER WAS NOT WORKING AND THE ABS (YELLOW) LIGHT WAS PERSISTENTLY ON. (HOWEVER THE RED BRAKE LIGHT THAT HAD BEEN SHINING ON THE DASHBOARD PERSISTENTLY FOR MANY, MANY MONTHS, EVEN AFTER RECALL SERVICING, WAS NOW OFF.) DRIVING FOR A FEW MINUTES, WE REALIZED THAT THE AIR CONDITIONING WAS NOT PUTTING OUT COOL AIR, ONLY WARM, AND THAT THE ODOMETER WAS DISPLAYING ONLY DASHES. I SHOULD ALSO MENTION, NOW THAT I HAVE READ UP ON THESE PROBLEMS, WHICH HAD SEEMED UNRELATED, BUT ARE APPARENTLY ALL TRACEABLE TO A DEFECTIVE/LEAKING SDCD, THAT THE CRUISE CONTROL ON THIS VEHICLE HAS NOT WORKED FOR MANY MONTHS. *TR

AS IS TYPICAL WITH THE WINDSTAR, THE DEACTIVATION SWITCH IS LEAKING BRAKE FLUID. THUS, CAUSING PROBLEMS WITH THE ABS AND CRUISE. UNFORTUNATELY, FORD ALREADY HONORED THE RECALL (09S09) ON THIS VEHICLE. AT THAT TIME THE DEACTIVATION SWITCH WAS NOT LEAKING SO THEY INSTALLED A WIRE HARNESS TO AVOID A FIRE WHEN IT DID START LEAKING. (WHY PUT ON A WIRE HARNESS? BECAUSE THEY KNEW THE SWITCH WAS GOING TO FAIL. WHY NOT JUST REPLACE THE SWITCH IN THE FIRST PLACE?) NOW FORD WILL NOT RE-OPEN THE RECALL TO REPLACE THE SWITCH AND FIX THE OTHER RELATED PROBLEMS. *TR

HELLO I REPORTED THE ABS CONDITION WITH INCREASED BRAKING A WHILE BACK I DON'T KNOW THE EXACT DATE BUT SINCE THEN I HAVE HAD CONTINUED ISSUES WITH ABS CONTROL MODULE NOT WORKING ON MY VAN I TOOK THE CAR TO STEPHENS AUTO IN DANVILLE WV FOR THE RECALLS ON THE AXLES AND HAD THEM CHECK ON THE ABS LIGHT STAYING ON ALSO I HAVE READ ON AN INTERNET COMPLAINT SITE WHERE THE COMPUTER CONTROL BOARDS IN THE ABS CONTROL MODULE HAVE SODDER CONNECTIONS BROKEN IS WHAT THE PROBLEM IS I ASK THAT YOU HAVE FORD RECALL AND REPLACE THE ABS CONTROL MODULES BEFORE SOMEONE GETS KILLED DRIVING ONE OF THESE VANS. *TR

BACK IN 2008 I WAS INVOLVED IN A FENDER BENDER (ABOUT $6,000 IN DAMAGES) WHEN MY ABS FAILED CAUSING ME TO SLIDE INTO ANOTHER CAR. AT FIRST I THOUGHT IT WAS MINOR ISSUE, BUT HAVE SINCE BEEN TOLD IT'S A MAJOR ISSUE WITH MANY OWNERS. I'VE FOUND THAT THE RECALL (09S09) DOES NOT ADDRESS ALL THE UNDERLYING ISSUES AND THE FORD DEALER WILL NOT FIX ALL OF THE ISSUES. ADDITIONALLY I WAS TOLD BY MY LOCAL FORD DEALER THAT THERE WERE NO OPEN ITEMS ON MY VAN FOR ABS. WHEN I INQUIRED WHAT THAT MEANT, THEY SAID THAT THERE WAS NOTHING ON RECALL FOR ABS ON MY VEHICLE. I HAD NEVER HAD ANYTHING DONE TO THE ABS, SO IT WAS NOT BECAUSE IT WAS ALREADY FIXED. A WEEK AGO, I WAS ALMOST INVOLVED IN AN ACCIDENT BECAUSE OF THE FAILURE OF THE ABS SYSTEM; I WAS ONLY GOING 40 MPH....

LAST WEEK AS I WAS DRIVING AROUND TOWN AND MY INSTRUMENT PANEL STOPPED WORKING AND THE ABS LIGHTS WOULD NOT TURN OFF. THE NEXT MORNING I HAD TO TAKE MY SON TO ONE OF HIS ACTIVITIES AND THE INSTRUMENT PANEL WAS STILL NOT WORKING AND I NOTICED I HAD TO PUSH THE BRAKE PEDAL ALL THE WAY DOWN TO THE FLOOR. I WENT HOME AND NOTICED THAT MY CAR WAS LEAKING BRAKE FLUID. AFTER MUCH RESEARCH I FOUND MY VEHICLE HAD A RECALL. (09S09) I TOOK MY CAR IN THIS MORNING TO HAVE THIS RECALL FIXED. THIS DID NOT FIX MY INSTRUMENT PANEL. AFTER I GOT HOME I RESEARCHED WHAT THE PROBLEM MIGHT BE AND HAVE FOUND NUMEROUS COMPLAINTS ABOUT THE SAME PROBLEM FROM BRAKE FLUID LEAKING ON THE SOME OF THE WIRES. I CONTACTED FORD TO SEE IF THIS WOULD BE COVERED UNDER THE RECALL AND THEY EXPLAINED TO...

FOR A YEAR NOW WE BE NOTICING ODOMETER FAILURE, BRAKE LIGHT AND ABS LIGHT COMING ON. RECENTLY WE FOUND OUT THE BRAKES WEREN'T WORKING AT ALL. LUCKILY NO ACCIDENTS. I INSPECTED THE BRAKE FLUID CONTAINER WHICH WAS EMPTY. I REFILLED IT AND CHECKED AROUND TO SEE FOR ANY LEAKS. I NOTICED IT WAS LEAKING AT THE SCDS SWITCH. I WENT ONLINE AND FOUND A WEBSITE WHERE THEY DESCRIBED THIS TO BE A COMMON PROBLEM AND THAT THERE WAS A RECALL FOR THIS. LUCKY IT HASN'T CAUSED ANY FIRE LIKE IT DID BY SOME OTHER OWNERS. *TR

I HAD RECEIVED A RECALL NOTICE FOR MY FORD WINDSTAR 09S09. I HAD TAKEN MY VEHICLE IN TO THE DEALERSHIP WHERE THEY ASCERTAINED THAT THE PART WAS DEFECTIVE AND HAD LEAKED. IT WAS NOTED WITH FORD THAT MY ABS LIGHT WAS ALWAYS ON, AS WAS THE CHECK ENGINE LIGHT AND THAT MY CRUISE CONTROL DID NOT FUNCTION ANY MORE. MY SPEED INDICATOR AND ODOMETER DID NOT FUNCTION PROPERLY EITHER READING ONLY HALF OF THE ACTUAL SPEED AND MILEAGE. THESE WERE ALL NOTED AND THE DEALERSHIP REPLACED THE DEFECTIVE PART BUT STATED THAT THEY WOULD NOT REPAIR THE OTHER PROBLEMS THAT WERE CAUSED BY THE LEAKED HYDRAULIC FLUID. I STILL HAVE ISSUES WITH EVERYTHING STATED BECAUSE THEY DID NOT DO ANYTHING TO FIX THESE PROBLEMS JUST CHANGED THE PART. AT THIS POINT I WAS TOLD THAT IT WAS TOO LATE TO DO ANYTHING BECAUSE ACCORDING TO FORD THE RECALL CASE WAS...

WE HAVE BEEN EXPERIENCING VARIOUS ELECTRICAL PROBLEMS WITH OUR WINDSTAR AND UPON RESEARCH THROUGH THE INTERNET FOUND THAT OTHERS HAVE HAD THE SAME PROBLEMS. THE CRUISE CONTROL HAS STOPPED WORKING FOR THE LAST TWO YEARS. THE ABS AND BRAKE LIGHTS HAVE PERIODICALLY COME ON AND THEN WENT OFF. THE SPEEDOMETER WILL BE WORKING FINE AND THEN DROP TO ONLY 20 MPH EVEN THOUGH WE ARE EXCEEDING THAT SPEED. IT WILL THEN JUMP BACK TO THE PROPER SPEED AND THIS PROCESS WILL CONTINUE FOR A PERIOD OF TIME.

TL* THE CONTACT OWNS A 2000 FORD WINDSTAR. THE CONTACT STATED THAT THE BRAKES WERE ABNORMALLY SOFT AND THERE WAS A DECREASE IN BRAKING POWER. IN ADDITION, THE CRUISE CONTROL WAS INOPERABLE AND THE ABS WARNING LIGHT WAS ILLUMINATED. THE CONTACT WAS ADVISED BY HIS PERSONAL MECHANIC THAT THE BRAKE PRESSURE SWITCH, WHICH WAS ALSO THE SPEED CONTROL DEACTIVATION SWITCH, HAD FAILED AND WOULD NEED TO BE REPLACED. THE CONTACT WAS ADVISED THERE WAS A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL). HOWEVER, WHEN CONTACTING THE MANUFACTURER THE CONTACT WAS ADVISED THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THE FAILURE AND CURRENT MILEAGE WAS 119,520.

TL*THE CONTACT OWNS A 2000 FORD WINDSTAR. THE CONTACT NOTICED THAT THE SPEED CONTROL DEACTIVATION SWITCH LEAKED BRAKE FLUID INSIDE THE ENGINE COMPARTMENT, CAUSING THE FLUID TO SPILL ONTO THE WIRING. THE DEALER MADE AN ATTEMPT TO REPAIR THE PROBLEM UNDER NHTSA RECALL NUMBER: 09V399000 (VEHICLE SPEED CONTROL); HOWEVER, THE FLUID CONTINUED TO LEAK. THE MANUFACTURER WAS NOTIFIED AND THEY ADVISED THE CONTACT TO TAKE THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 93,000. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000. UPDATED 02/23/11 *BF THE CONSUMER STATED A WIRING JUMPER WAS ADDED TO PREVENT A POSSIBLE FUTURE LEAK OF BRAKE FLUID, SINCE THE PRESSURE SWITCH WAS NOT LEAKING. WITHIN 3,00 MILES, THE PRESSURE SWITCH BEGAN LEAKING BRAKE FLUID INTO THE ENGINE COMPARTMENT DIRECTLY ONTO THE TRANSMISSION SPEED CONTROL SENSOR. THE TRANSMISSION SPEED CONTROL SENSOR SUBSEQUENTLY FAILED AND NEEDED TO BE...

I HAD MY MOTHERS' 2000 FORD WINDSTAR IN TO BE REPAIRED FOR TWO RECALLS, ONE DEALING WITH THE ABS SYSTEM AND FLUID LEAKING THAT COULD CAUSE A FIRE, AND ONE DEALING WITH ELECTRICAL ISSUES IN THE TRAILER WIRING. AFTER FOUR DAYS WITHOUT A VEHICLE, I PICKED UP THE VAN (SECOND RECALL STILL NOT COMPLETED DUE TO LACK OF PARTS). I LEFT THE DEALERSHIP AND WITHIN 5 MILES THE ABS LIGHT CAME BACK ON. WHEN THE LIGHT CAME ON, I NOTICED THE VAN STARTED RUNNING ROUGH AND BRAKING WAS MORE DIFFICULT AND FELT VERY SOFT. WHEN I RETURNED HOME, THE DEALERSHIP TOLD US TO BRING THE VEHICLE BACK IN ON MONDAY. THEY DID NOT OFFER TO GIVE MY MOTHER A LOANER DURING THE FIRST REPAIR AND SAID NOTHING FOR THE SECOND EITHER. I AM VERY DISPLEASED WITH THE SERVICE REGARDING THESE RECALLS, AND IT SEEMS LIKE THE PROBLEM STILL IS NOT...

THE BRAKE PRESSURE DIFFERENTIAL DEACTIVATION SWITCH (SCDS) (2B264) LOCATED UNDER THE MASTER CYLINDER (BEHIND THE AIR FILTER) OVER TIME DEVELOPED A LEAK. THIS LEAK LEAD TO THE LOSS OF CRUISE CONTROL. AFTER SOME TIME IT WAS REPLACED, THE RECALL WAS THEN ISSUED AND I HAD THE VAN CHECKED BY FORD. THEY REIMBURSED ME FOR THE REPAIR I HAD DONE PER THE RECALL 09S09. SINCE THE PROBLEM OCCURRED I HAVE INTERMITTENT ABS LIGHT COMING ON WHILE DRIVING. IT SEEMS THIS HAPPENS ESPECIALLY IN WARMER WEATHER. I CAN SEE ON MY VAN WHERE FLUID LEAKED ONTO SOME WIRES BELOW THE SWITCH THAT WAS REPLACED. FORD SAID THERE WAS NO PROBLEM. *TR

TL*THE CONTACT OWNS A 2000 FORD WINDSTAR. THE CONTACT STATED THAT WHEN THE CRUISE CONTROL WAS TURNED OFF, THE VEHICLE CONTINUED TO TRAVEL AT THE SPEED IT WAS MOVING WHEN THE CRUISE CONTROL WAS ACTIVATED; HE HAD TO DEPRESS THE BRAKE PEDAL TO SLOW IT DOWN. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED FOR THE FAILURE. ALSO, THE FRONT AND REAR COIL SPRINGS BROKE; THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE IT WAS REPAIRED. FURTHERMORE, THE LOCKS ON THE REAR SLIDING DOORS DID NOT FUNCTION INTERMITTENTLY. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 130,000.

FORD WINDSTAR 2000 CAR SAFETY PROBLEM WAS REPORTED ON SEPTEMBER 9 2010, HAD A PROBLEM WITH THE VEHICLE SUDDENLY ACCELERATING. MY WIFE HAD BACKED OUR 2000 WINDSTAR SEL OUT OF THE GARAGE SO WE COULD SWEEP OUT THE GARAGE. THE CAR HAD SAT FOR ABOUT FIVE HOURS IN THE DRIVEWAY WHEN SHE WAS GOING TO DRIVE IT BACK INTO THE GARAGE. WHILE RELEASING THE BRAKES THE VEHICLE ACCELERATED SUDDENLY AND UNEXPECTEDLY. RESULTING IN A COLLISION WITH THE GARAGE CABINETS AT THE REAR OF THE GARAGE, FORCING THE SIDES OF THE CABINET THROUGH THE REAR OF THE GARAGE. THE IMPACT DESTROYED TWO FULL SEVEN FOOT CABINETS AND A TREE DRAWER CABINET. THE FRONT BUMPER COVER WAS TORN AND PUSHED BACK ABOUT INCH ON THE PASSENGER SIDE. THE A/C COIL WAS PIERCED AND LEAKING, THE RADIATOR BRACKET WAS PUSHED BACK INTO THE BATTERY. AND THE AIR BAGS NEVER DEPLOYED!! VEHICLE WAS TOWED...

2000 FORD WINDSTAR LX MINIVAN WAS SUBJECT TO RECALL 09S09 DUE TO FIRES LINKED TO SCDS 10/27/2009. TOOK TO DEALER AT WHICH TIME FUSIBLE LINK WAS REPLACED. STILL HAVING ISSUES WITH ABS LIGHT COMING ON AND INTERMITTENT SPEEDOMETER/ODOMETER OPERATION SINCE MAY 2010. TOOK BACK TO MIKE CASTRUCCI FORD IN MILFORD, OHIO AND PERSON THERE HAD NO IDEA WHAT I WAS TALKING ABOUT. *TR

MY ABS LIGHT HAS COME ON THREE TIMES. NOW MY BRAKES ARE STUCK SO I AM UNABLE TO DRIVE. I HAVE NOT TAKEN IT TO A SHOP YET. *TR

2000 FORD WINDSTAR VAN (WITH 72,000 MILES) - SCDS RECALL DID NOT CORRECT THE PROBLEM. YELLOW ABS LIGHT STAYS ON ALL THE TIME NOW AND BRAKING DISTANCE HAS INCREASED. NOR DID IT RESOLVE THE SPEED CONTROL SWITCH EITHER - IT STILL DOES NOT FUNCTION. *TR

TL* THE CONTACT OWNS A 2000 FORD WINDSTAR. THE CONTACT STATED SHE RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 09V399000 (VEHICLE SPEED CONTROL) AND RECEIVED REPAIRS AT AN AUTHORIZED DEALER. AFTER REPAIRS, THE ABS WARNING LIGHT WOULD CONTINUOUSLY ILLUMINATE SPORADICALLY. THE VEHICLE WAS TAKEN BACK TO THE DEALER WHERE IT WAS DISCOVERED THAT FLUID WAS LEAKING ONTO THE ABS MODULE. THE DEALER ADVISED THE CONTACT THAT THE REPAIRS WOULD BE AT HER EXPENSE BECAUSE THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL CAMPAIGN. THE MANUFACTURER ADVISED THAT THE DECISION IF THE VEHICLE WOULD BE REPAIRED A SECOND TIME WOULD BE AT THE DEALERS DISCLOSURE AND THAT RECALL REPAIRS WERE A ONE TIME REPLACEMENT OF THE FAILURE. THE CONTACT STATED THAT SHE DID NOT EXPERIENCE ANY FAILURES PRIOR TO HAVING REPAIRS UNDER THE RECALL. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 70,000. UPDATED 11/03/10 *BF THE CONSUMER STATED...

2000 FORD WINDSTAR. CONSUMER WRITES REGARDING RECALL FOR SPEED CONTROL DEACTIVATION *TGW THE CONSUMER STATED THE CRUISE CONTROL STOPPED WORKING. THE CONSUMER WOULD LIKE THE REPAIRS MADE FREE OF CHARGE, SINCE A RECALL HAD BEEN ISSUED. *JB

SPEED CONTROL SUDDENLY STOPPED WORKING. BRAKING DISTANCE SUDDENLY INCREASED. *TR

CRUISE CONTROL PROBLEMS MY CRUISE CONTROL WILL NOT WORK AFTER BEING REPLACED WITH THE NEW SWITCH FROM THE RECENT RECALL ON MY VEHICLE. MY VEHICLE IS BEING FIXED AND I WILL HAVE TO PAY FOR THE PARTS AND SERVICE. HAS SOMETHING TO DO WITH THE SCDS AND ABS. *TR

FORD WINDSTAR RECALL, NHTSA CAMPAIGN ID NUMBER: 09V399000, FOR ABS ECM MODULE THAT CAN CAUSE A FIRE. FORD ONLY INSTALLED A FUSIBLE LINK AS A SOLUTION AND I AM STILL HAVING TROUBLES. THE ADDRESSED THE INITIAL CAUSE, BUT PROBLEM HAD ALREADY STARTED. POWER STEERING OUT, ODOMETER, SPEEDOMETER DO NOT WORK, ALL DOCUMENTED ISSUES FOR THE RECALL THAT CAN LEAD TO FIRE. *TR

ON JULY 5, 2007 MY 2000 FORD WINDSTAR CAUGHT FIRE WITH MY WIFE AND 3 YEAR OLD DAUGHTER IN THE CAR. UPON INSPECTION, IT WAS OVERWHELMINGLY OBVIOUS THAT THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT. *TR

HAD FORD DEALER REPLACE RECALLED SWITCH. STILL HAVE TROUBLE WITH ABS LIGHT ON. CRUISE CONTROL STILL DOESN'T WORK. STILL USING UP A LOT OF BRAKE FLUID. *TR

I OWN A 200 FORD WINDSTAR AND RECENTLY TOOK IT TO A FORD DEALER TO HAVE THE SPEED CONTROL MODULE REPLACED DUE TO RECALL. I DID SO AFTER HAVING PROBLEMS WITH MY BRAKE SYSTEM (NOT HAVING ANY BRAKE). I ORIGINALLY BROUGHT IT TO A REGULAR GARAGE AND THEY COULD NOT FIGURE OUT WHY I HAD NO BRAKE BECAUSE MY BRAKES WERE GOOD SO THEY TOLD ME TO GET TO FORD AND HAVE RECALL SITUATION TAKEN CARE OF. AFTER DOING SO I STILL HAVE HARDLY ANY BRAKE AND THE ABS LIGHT STILL COMES ON. EVERY WEEK I SEEM TO BE PUTTING IN BRAKE FLUID BECAUSE THE RED BRAKE LIGHT COMES ON. ON A FEW OCCASIONS I HAVE HAD PROBLEMS GETTING OUT OF PARK AND HAVE NO IDEA WHY. I AM DUE TO HAVE AN INSPECTION AND DON'T KNOW WHAT IM GOING TO DO IF IT DOES NOT PASS DUE TO NOT...

BRAKE FLUID LEAKING AROUND THE BRAKE PRESSURE DIFFERENTIAL DEACTIVATION SWITCH (SCDS) (2B264) LOCATED UNDER THE MASTER CYLINDER (BEHIND THE AIR FILTER) OVER TIME DEVELOPS A LEAK. THIS CAUSES A SHORT AND A FUSE TRIP, FUSE #10 IF THE ENGINE IS ON. THIS LEAK ALSO CAUSES BRAKE FLUID TO WICK DOWN TWO WIRES TO THE ABS BRAKE MODULE (2C219). THE FLUID ACCUMULATES ON THE (ALWAYS ON) POWER CONNECTORS FOR THE ABS BRAKE SYSTEM WHICH ARE POWERED BY FUSES 101 AND 102 AND ARE BOTH 40 AMP. THE FLUID ATTRACTS MOISTURE, ROAD SALT AND LEADS TO A FIRE WHEN THE FLUID AND MOISTURE ACT AS CONDUCTOR BETWEEN THE HOT LEADS AND GROUND. *TR

MY 2000 FORD WINDSTAR, ABS LIGHT COMES ON SPORADICALLY ABOUT EVERY TIME I DRIVE IT THE LIGHT COMES ON. OF COURSE I LIVE IN NORTHERN MN AND I NEED ABS. ITS A HAZARD, WHEN I DON'T KNOW IF I'M GOING TO BE ABLE TO STOP. I TOOK IT INTO A MECHANIC AND PULLED THE CODE C1185(POWER RELAY CIRCUIT MALFUNCTION). NEEDS A NEW ABS MODULE. *TR

TL*THE CONTACT OWNS A 2000 FORD WINDSTAR. THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH ON NORMAL ROAD CONDITIONS WHEN THE BRAKE PEDAL TRAVELED TO THE FLOOR WITHOUT RESISTANCE WHILE ENGAGING THE BRAKE PEDAL. THE VEHICLE FAILED TO SLOW DOWN AND CRASHED INTO THE PROCEEDING VEHICLE ON THE REAR PASSENGER SIDE. THERE WERE NO INJURIES. THE POLICE WERE NOTIFIED. THE CONTACT SUSTAINED DAMAGES TO THE FRONT DRIVER SIDE AND HOOD AREA OF THE VEHICLE. IN ADDITION, THERE WAS AN EXCESSIVE LEAKAGE OF BRAKE FLUID. THE CONTACT STATED THAT THE FAILURE WAS RELATED TO THE RECALL UNDER THE NHTSA CAMPAIGN ID NUMBER 09V399000 (VEHICLE SPEED CONTROL); HOWEVER, THE VEHICLE WAS NOT REPAIRED DUE TO THE CONSEQUENCE THAT MAY OCCUR WITH THE REMEDY REPAIR. UPDATED 2/26/10 *CN UPDATED 08/11/10

TL*THE CONTACT OWNS A 2000 FORD WINDSTAR. HE RECEIVED A RECALL NOTICE FOR THE CRUISE CONTROL SWITCH. HE STATED THAT THE CRUISE CONTROL FAILED PRIOR TO RECEIVING THE RECALL NOTICE AND THE VEHICLE CAUGHT FIRE. PRIOR TO THE FIRE THE DEALER STATED THAT THEY WOULD NEED PERFORM A DIAGNOSTIC TEST. FORD CONFIRMED THAT THE SWITCH SHOULD BE REPAIRED WITHOUT DIAGNOSTIC TESTING. THERE HAVE BEEN NO REPAIRS. THE FAILURE IS DIRECTLY RELATED TO NHTSA CAMPAIGN ID NUMBER 09V399000, VEHICLE SPEED CONTROL. THE FAILURE AND CURRENT MILEAGE WERE UNKNOWN. UPDATED 11/08/10 * BF ACCORDING TO THE PAPERWORK, THE CONSUMER WAS IN AN ACCIDENT DUE TO THE POWER STEERING FAILING. THE CONSUMER ALSO STATED ALL OF THE COMPONENTS ON THE INSTRUMENT PANEL FAILED. UPDATED 11/10/10

TL* THE CONTACT OWNS A 2000 FORD WINDSTAR. WHEN ATTEMPTING TO START THE VEHICLE SHE SAW SMOKE, SO SHE IMMEDIATELY TURNED OFF THE VEHICLE. AFTERWARDS WHILE DRIVING THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE TECHNICIANS COULD NOT IDENTIFY THE CAUSE OF THE FAILURE. SHE THEN RECEIVED RECALL NOTICE # 09V399000 (VEHICLE SPEED CONTROL). SHE CONTACTED THE DEALER TO HAVE THE VEHICLE TOWED TO THEIR FACILITY. THE TECHNICIAN STATED THAT THEY WERE NOT RESPONSIBLE FOR TOWING THE VEHICLE. NO REPAIRS WERE MADE. THE FAILURE AND CURRENT MILEAGES WERE 100,000.

TL*THE CONTACT OWNS A 2000 FORD WINDSTAR. THE BRAKE FLUID WAS LEAKING FROM THE SPEED CONTROL DEACTIVATION SWITCH ONTO THE WIRING HARNESS AND IT'S COMPONENTS WHICH CAUSED THE ABS LIGHT TO ILLUMINATE. THE LEAK WAS CAUSED BY A DEFECT WHICH LED TO RECALL 09V399000. THE DEALER STATED THAT THEY WOULD NOT REPAIR ANYTHING OUTSIDE OF THE COMPONENT LISTED IN THE RECALL. THE MANUFACTURER STATED THAT THEY WOULD NOT ASSIST HIM UNTIL HE TOOK HIS VEHICLE TO THE DEALER. THE CURRENT MILEAGE WAS APPROXIMATELY 125,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 124,500.