2019 FORD RANGER Power Train Problems

The vehicle is experiencing a severe power train failure involving erratic and violent gear selection. The transmission unexpectedly jumps from 2nd, 3rd, or 4th gear directly up to 7th or 8th gear, resulting in a total loss of acceleration. This is immediately followed by the transmission "slamming" down into lower gears, usually 1st or 2nd gear without driver input. This behavior is accompanied by a strong burning smell and a dashboard "wrench" warning light. The symptoms match the manufacturing defect documented in Ford TSB 24-2101 (CDF clutch drum). Diagnosis & Manufacturer Response: The issue began in October 2025 with a noticeable transmission shudder. I paid for two transmission flushes at Big O Tires to attempt to resolve the issue, but the mechanical failure has since escalated. When the "wrench" light appeared, an independent diagnostic computer was unable to retrieve an error code, as the light is a proprietary Ford powertrain...

The transmission stutters at sustained modest speed (25-45 mph). It was taken to the dealer, who determined it was affected by tsb 25-2134. This is a widely known issue and the dealer refused any servicing without payment. This should have been a recall, since hundreds of known issues in and out of warranty have occurred.

The automatic transmission and related transmission control system malfunctioned. The vehicle experienced improper shifting and loss of gears, including a condition in which 4th gear is disabled due to a failsafe logic triggered by the transmission control module. The vehicle and all affected components are currently available for inspection upon request and are at a Ford-authorized dealership. This malfunction posed a safety risk because the vehicle was unable to shift normally or maintain consistent acceleration. The unpredictable shifting and loss of gears could create hazardous situations when merging, accelerating, or driving at highway speeds, potentially endangering the driver and others. The problem has been reproduced and confirmed by a Ford dealership. After inspection and diagnostic testing, the dealership advised that the transmission requires replacement. The vehicle has been inspected by a Ford-authorized dealer. It has not been inspected by the manufacturer directly, police, or insurance representatives (UNKNOWN). Prior to the...

Transmission shifting issues. Will shift out of gear or delay shifting several seconds and sometimes limited power. The 1080r 10 speed transmission has a know design flaw that was finally fixed in 2023. My 2019 is now having the issue and is $8000 to fix for a bushing that moves out of place

Truck looses gear when pulling into traffic. It will shift out of gear and only allow coasting. At speeds of 40 MPH and higher it will down shift causing dramatic reduced speed with no brake warning to other drivers behind. It will also randomly loose power. It will have delayed shifts squealing tires upon shifting and excessive jerking that is uncontrollable.

I have had my 2019 Ford Ranger in for service to address issues with the transmission on 3 different occasions starting in Fall of 2023. Each time paying $106 for the deductible on the warranty to service a "Technical Service Bulletin" (TSB). Each time, being told of a different TSB that they would be addressing. Never addressing them all at the same time. In May of 2025, still experiencing the same/similar issues, I brought in in again only to be told that there was a TSB that they did not service, that my warranty had expired. Upon searching the internet, there are many people reporting similar issues with a similar response from Ford. I have spoken to multiple dealerships as well as reached out to Ford car with little to no response.

I’ve been noticing a delay in shit out of 1st, 3rd, 6th, and 9th gear. Sometimes it slams but most of the time not. Anyways, this morning on my way to work I passed a slow driver on 2 lane road. After I merged back into the lane, I resumed cruise control and basically lost all power to the wheels. The vehicle I passed about slammed into the back of me. I canceled cruise control to give gas and the transmission was fighting me to stay in a gear. It finally caught and I drove it the rest of the way to work with the “normal” 1,3,6,and 9 being weird. My safety and the other vehicles safety was definitely at risk. The was no warning lights that came on. I haven’t had it checked out yet because this is same day

My 2019 Ford Ranger 4x4 was bought new in April of 2019 and has approxiamatly 73,400 miles. Over time a slight glitch in the transission got to be more frequent. When first starting out within the first mile of operation, the vehicle would hang between gears and act like it ran out of fuel for a few seconds at low speed, as in pulling out from a stop sign or accelerating from a dead stop. My guess is inbetween first and second or second and third gear. It just wouldn'd go. Fortunatley I was not involved in any accidents. I can see where this could easily cause a mjor accident. There are several TSB's for this transmission and I believe Ford and General Motors use this same transmission. I have had my truck at the dealer for almost a month after it got scary to drive it got scary to...

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission shuddered abnormally. In addition, while driving approximately 45 MPH, the vehicle drove without issues. No warning light was illuminated. The vehicle was taken to the dealer, and the failure was diagnosed as an internal transmission pump failure. The contact was informed that the transmission pump needed to be replaced. The vehicle was not repaired. In addition, the contact was informed that the manufacturer was aware of the failure; however, the repair was not covered under the recall. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 78,000.

Air bag malfunctions and not active passanger and driver side, hvac malfunction replaced twice, power train shifting out of gears, PCM malfunctions and triggering failures to sensors. Passanger seat belt not working. Collision sensor malfunction and not working.

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. There was an abnormal sound coming from the vehicle. The contact stated that the check engine and the service warning lights then became illuminated. The vehicle was driven to a nearby Ford dealer. The vehicle was diagnosed with internal failure of the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The contact referenced an unknown recall with a similar description of the failure; however, the VIN was not associated with the recall. The failure mileage was approximately 73,000.

My transmission failed on the highway. I was merging on the highway one day and all of a sudden I felt a sudden reduction in power which was dangerous for the people behind me, and heard an awful grinding/whining noise. I immediately limped it to the dealership and was told several days later the transmission (Ford 10R80) had a catastrophic failure and was lucky to get it to the dealership. This is unacceptable and I know I’m not the only one with issues with these transmissions. The dealership told me it happens all the time. This is a safety issue and unacceptable for the truck that is 5 years old.

Own a 2019 Ford Ranger, which is experiencing severe transmission issues including harsh and delayed shifting. A diagnostic scan revealed code P07F7-00, which matches Ford's TSB 24-2046 / 25-2024, related to known defects in the 10R80 10-speed transmission. Despite this being a documented issue, authorized Ford dealerships have refused to properly diagnose the TSB entirely and claiming it was no longer valid. This unresolved defect affects the safety and reliability of my vehicle. I am filing a complaint to request that the NHTSA investigate this widespread problem and consider issuing a recall to address the transmission defect affecting many Ford Rangers (and other vehicles with this transmission). Thank you for your attention to this serious safety concern.

Vehicle lurching and loosing power, almost caused accident. Determined DPFE sensor had water in it, replaced sensor. Problem continued with slipping gears and mis-shift. Transmission fluid was burnt and had metal shavings. Repair was complete transmission replacement. Vehicle has 94000 miles.

The contact owns a 2019 Ford Ranger. The contact stated that while driving 65 MPH, the vehicle decelerated to 35 MPH. The contact stated that while driving at various speeds, the transmission was skipping gear, slipping, and shifting hard. The check engine warning light was briefly illuminated. The vehicle was taken to the dealer, who diagnosed that the head gasket was failing. The dealer stated that coolant was intruding into the engine, and there was engine oil was entering into the spark plugs, causing engine failure. The dealer also diagnosed the vehicle with transmission failure. The head gasket and the transmission were replaced; however, the failure persisted. The dealer informed the contact that the vehicle needed to be drive more often for the vehicle to run properly. The dealer was unable to duplicate the failure. The vehicle was taken to another dealer, Mountain Grove Ford (11311 Bus Dr #60, Mountain...

10R80 Transmission delays Shifts and slams into gear when it does shift extremely hard.Has caused my back pain. This is a known defect caused by the CD&F drum bushing. This problem has almost caused me and my family to be killed at an Intersection since the vehicle will not accelerate while waiting for gear selection.

Transmission failer. Lurches at start up even in park refuses to shift gears

Transmission feels like it is delayed in engaging gears at various speeds. Stop and go traffic is most noticeable. When it does change gears, it often feels jerky. Lower speeds at most noticeable but over 50mph seems to run fine.

The contact owns a 2019 Ford Ranger. The contact stated while operating the vehicle, the transmission was shifting while shifting rough from first to second gear. The contact stated that over time, the failure progressed and had occurred while shifting into gear. The contact stated that the failure had self-corrected as the engine warmed up. The vehicle was taken to the local dealer who diagnosed that the transmission was faulty and needed to be replaced. The vehicle was then taken to an independent mechanic who confirmed that the transmission was faulty. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 77,000.

Transmission is pushing forward from 1st to 2nd gear. Pushing so hard that it hard to stop

Transmission bucks and shutters at low RPM. Dealer did not disclose the transmission issues

The transmission is shifting hard, delay in shifting, and slipping gears. All of this started when my vehicle reached 50,000 miles. Ford has issued a TSB for the issue, but refuses to cover the cost of repairs. Ford is reporting this issue in all 10R80 transmissions installed in several of their models.

The ten-speed transmission "10R80" has Rough and harsh shifting, "upshifts and downshifts," which sometimes causes the vehicle to lunge forward unexpectedly. The dealer has reprogrammed the transmission twice with no change.

The contact owns a 2019 Ford Ranger. The contact stated that while driving at various speeds, the vehicle jerked forward while slightly depressing the accelerator pedal. There was no warning light illuminated. In addition, the transmission was shifting hard while shifting from first through third gear. The vehicle was taken to an independent mechanic to be diagnosed; however, the contact was informed that no fault codes were retrieved. The manufacturer was notified of the failure and the contact was referred to a local dealer for assistance. The vehicle was not repaired. The failure mileage was approximately 100,000.

The 10R80 10 speed transmission in my truck has failed, due to the steel to aluminum drum being different materials it cause pre mature catastrophic failure. the damaged components resulted in needing a full overhaul/rebuild of my transmission at my full expense. my ford dealer stated there is a known tech service bulletin about this exact failure which means ford knows there's a problem but will not fix it. the resulting damage was the sun gear has failed, the drum has failed, and there are chunks missing from gears 5,6 and 7, which also resulted in needing a new valve body, and new torque converter. i opted to take my ranger to a independent shop as i no longer trusted ford to rebuild the transmission correctly and i do also have the failed components. The safety issues were losing all drive train function randomly when in operation, on several occasions...

When turning on to another road and accelerating, engine will suddenly loose all power. releasing accelerator will regain some power until vehicle speed increases. Throttle control is often erratic and transmission shifting is inconsistent resulting in hard clunks during shift. Pulling into traffic with a sudden loss of power leaves me vulnerable to a collision.

In my 2019 Ford Ranger, which has 75,570 miles, on [XXX], I was at a stop sign on [XXX] , at [XXX] , near Statesboro, GA, waiting for a break in traffic to safely cross. When a safe break occurred, I proceeded to cross, and at about the halfway point of crossing, the transmission bucked, and the truck began to slow to a halt. As a tractor trailer was bearing down on me broadside, the transmission jumped into gear, and I was able to proceed, and narrowly avoided a broadside collision. Afterward, the warning lamp indicated a powertrain malfunction (wrench) light. I took the truck to my local Autozone, where I used their OBD, and the test result fault was "Power Train System, P07F7-00, Gear 10 Incorrect Ratio". I have an appointment at Metter Ford to repair the issue on January 17th, 2025. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF...

The contact owns a 2019 Ford Ranger. The contact stated that while driving at an undisclosed speed, the vehicle independently accelerated. The contact turned off the vehicle for the vehicle to stop. The vehicle was taken to the dealer to be diagnosed, and the contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was 65,000.

Truck has noticeable hard shifts into reverse and drive. Sometimes searching for gear while accelerating.

Transmission 10R80, 10 speed. Had HARD shifting, 1st to 2nd gear, excessive engine RPM in 1st gear then dropping hard into 2nd causing tire squawk. Hesitation in power after hard shift causing loss of acceleration, dangerous in heavy traffic. No warning lights and no fault codes produced. Warranty time period expired mid June 2024. Mileage at 52236 was under 60000 limit. Ford dealership refused to cover any costs. Complaints filed with Ford Motor Company twice. Corp refused any support or compensation. Vehicle was taken to independent Certified Mechanic who verified the problems. Mechanic followed Ford Technical Bulletins to make repairs. Three separate steps in the repair process produced no favorable results. Transmission had to be removed and rebuilt with Ford factory OEM parts. Several parts replaced were of new design, indicating Ford knows of the problems and is attempting to redesign the transmission, but NOT supporting customers out of warranty....

The contact owns a 2019 Ford Ranger. The contact stated while driving 65-70 MPH, the transmission was slipping. The wrench symbol was displayed on the instrument panel. The check service manual message was displayed. The vehicle was taken to the local dealer, where it was diagnosed and determined that the transmission needed to be replaced. The dealer informed the contact that there was no warranty coverage on the vehicle for the repair. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 80,000.

In the past 3 months, my 2019 Ford ranger has had a multitude of issues come up all at once. First, my transmission destroyed a gear and needed to be rebuilt. Next was an engine misfire code that Ford detected, and ended up being spark plugs at 66k miles. The current issue is that my fan clutch failed, causing it to rip off the wiring harness that was nearby that led to the oil pressure sensor. This caused an instant loss in power on the highway and almost caused an accident. This truck has been given servicing on every mileage checkpoint that it was suppose to.

Transmission is in signs of failure. Ford is offering updates to the computer to attempt to remedy the issue. Very similar behavior across all models with this family of 10 speed transmissions. Discouraging for owners just coming out of warranty. TSBs show Ford knows of these issues. No warning lights, violent shifting and worse yet when the vehicle is cold the shift will be missed and make it extremely dangerous when merging into traffic. I feel like I am about to be rear ended every day leaving work. There is no way these transmissions are 'okay' or that this is considered the 'new-norm' that the Ford Dealer is pushing. I have some dash cam footage that I shared with Ford (and on my personal youtube account).

Transmission jerky. Trying to come up with a solution.

Transmission has been slipping from gears 3 into 4th & 7th into 8th. Also check engine light turns on & a wrench symbols. Then a notification pops up on my ford app in my iPhone stating powertrain 4 wheel drive problems. My vechile looses all boost from turbo and un bale to get up to any type of speed within the original engine’s capabilities.

The contact owns a 2019 Ford Ranger. The contact stated while driving from a complete stop and up to 45 MPH, the vehicle jerked, lunged, and shuddered while the transmission was shifting gear. Additionally, the contact stated that the transmission was slipping while in low gear and in higher gears. There was no warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The manufacturer referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 78,000. The VIN was not available.

The contact owns a 2019 Ford Ranger. The contact stated that while driving at various speeds on several occasions, the vehicle downshifted unexpectedly. An unknown warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with transmission failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 50,000.

There is insufficient shielding to prevent water from reaching the top of the engine. This results in water dripping on the coil packs and also entering the spark plug wells, causing loss of spark and reduced engine output. Over time, this issue also leads to rust in the engine head, potentially resulting in engine failure. Additionally, water can reach the EGR DPFE sensor, causing the engine to hesitate and shutter at various speeds. Both of these issues together cause a misfire when applying the accelerator and will cause the vehicle to initially hesitate then surge forward. Even with the engine cover, the venting at the base of the windshield allows water to drip down on the engine head, causing the above issues. Ford does recognize that there is an issue and have written several TSBs on the it.

i HAVE A 10R80 10 SPEED TRANSMISSION WITH 102,OOO MILES . IT STARTED BUCKING ON ME WHEN CHANGING GEARS AND SOMETIMES FEELS LIKE NO POWER OR SOMETIMES WANTS TO SPEED UP ON ME. KIND OF SCARY WHEN MERGING INTO TRAFFIC ON HIGHWY

The check engine light illuminated after leaving residence and traveling less than 5 miles. Had the vehicle check by a certified ASE mechanic, He stated that my vehicle had a misfire code (PO300), if it was a PO301 OR PO302 or etc, it would indicate a specific coil was misfiring, but the PO300 is a general misfire code. Vehicle is jerking, pulling, bogging down as if doesn't want to go forward or is losing power, mechanic changed the spark pulls the first time thinking it was time due to mileage of the vehicle, and cleared the code. One week later check engine light is back on with the same PO300 code, he says we can try changing the coils next to see if this fixes the problem. I called my local ford dealer, who says the will charge me $167 dollars to diagnose the problem, and tell me whats wrong....

The vehicle skips gears when upshifting and does not shift through all the gears when in cruise mode. The truck will buck and bang jolting the passengers and appear to stall out without any warning. This has happened on numerous occasions and has even stalled out in the middle of a very busy intersection almost causing a collision by the truck not having enough power to coast through the intersection. Based on conversations with the dealership, this is not an isolated issue with our vehicle.

My 2019 Ford Ranger (Lariat) has as what I've discovered is a habitual problem that many other Ford Ranger owners are experiencing. While driving at lower speeds (28-40 mph) the trucks transmission will begin to knock and buck very hard. I've noticed, according to the gear indicator, that it is in either 7th or 8th gear. The problem has gotten consistently worse and I'm in fear of greater damage to the mechanics, or worse, a potential accident if it completely gives out while driving. - The truck has not had any modifications what-so-ever that would have in any way affected the transmission.

[XXX] my transmission, went out on my 2019 Ford Ranger 4 x 4. I was driving on the interstate in Houston, TX during the Friday afternoon rush-hour, when I completely lost power. It was very difficult to get off the interstate due to the traffic. I had experienced some transmission issues in the week before it failed there had been some jerking, hesitation, and the truck would lurch forward when accelerating from a stopped position and while driving there was harsh shifting. I had checked the transmission fluid and it was normal. There were no warning messages prior to it going out. I had the truck towed to a Ford dealership where I was told the transmission was still under warranty. It took the dealership nine weeks to repair the transmission. It is now one year later, and I have just started experiencing the same harsh shifting on the interstate,...

Manufacture defected valve cover allows water to gather and leak into coils causing vehicle to shut down at highway speeds ! This is EXTREMELY dangerous and FORD admitted knowing of the issue and even has an active internal fix but demands payment to fix issue. My service advisor said Ford has known of this issue but would only repair if the customer pays for it. Please take this matter under heavy consideration as I nearly lost my life on [XXX] . I have personally read over 7300 online complaints of similar findings from not only Ford Ranger owners , but mechanics from private shops to Ford certified repair shops. Please , please, please contact Ford customer care, they will tell you there is a know issue that they agree poses a threat to drivers . Thank you very much . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),...

I lose power in my vehicle and the code is saying something about my exhaust not showing the correct air pressure. This is causing my truck to shake and gas and brake pedal to stiffen while driving

The contact owns a 2019 Ford Ranger. The contact stated while driving from a complete stop, the vehicle was jerking, and the transmission was slipping and shifting hard. There was no warning light illuminated. The contact stated that the failure mostly occurred while driving from 0-20 MPH. The vehicle was taken to the dealer, where it was diagnosed, and the dealer determined that the transmission needed to be replaced. The dealer informed the contact the manufacturer was contacted and offered to partially cover the cost of the repair. The vehicle was not repaired. The failure mileage was approximately 67,800.

The contact owns a 2019 Ford Ranger. The contact stated that there was a mixture of fluid and oil inside the rear passenger’s side wheel, and onto the brake calipers and the rear axle. The dealer determined that the passenger's side rear axle seal was leaking. The dealer replaced the passenger's side rear axle seal. Additionally, the contact stated while driving at various speeds, the vehicle jerked and jolted while the transmission skipped from 1st to 3rd gear. The contact also stated that the vehicle hesitated to respond and made an abnormal sound while accelerating and decelerating, and then jolted when shifting into gear. The contact stated that the failure had been recurring more increasingly. The dealer was notified of the failure and an appointment was scheduled for a diagnostic test. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure and referred the contact to...

2019 Ranger went into limp mode in traffic at the worst possible time. Error code appeared and referred to transmission fault at roughly 38k. Was taken to ford and I was told PCM just needed updating. By 45k the transmission was right back to shifting rough with sudden shifts jerking the truck. Called Ford to say hey it’s not right still. It’s continuing to downshift from 10th gear at 65mph instantly down to 3rd gear nearly ripping the transmission out. Every Ford dealership within 3.5hrs from me all told me the same thing. “We are told to say it’s normal for the 10r80 to do hard shifts. Ford knows they are a problem but want issue a recall, the only thing you can do it blow up the transmission while your under 60k warranty so they have no choice but to replace it.” Now at 80k I’m screwed and have...

Transmission is shifting extremely rough, lunges forward or completely disengaged in lower gears. Initially started to happen with cold starts but now continues to happen regardless of the amount of drive time. Completely unsafe when merging into traffic because transmission will either exhibit low power, shift roughly or completely disengage. Transmission has disengaged 5 times so far during initial acceleration. Issue has been confirmed by my Ford dealer. Vehicle is currently being serviced for complete transmission replacement. Dealer has told me that this a frequent complaint that they are experiencing with Ford car owners with the 10R80 transmission.

THE TRANSMISSION "BUCKING" DURING SPEED ACCELERATION. THIS CAUSES THE VEHICLE TO DE-ACCELERATE BEFORE ACCELERATING TO DESIRE SPEED. PROBLEM: PROGRAMIMG OF THE PCM FOR THE TRANSMISSION. ACCORDING TO THE DATA COLLECTED ON THE FORD FORUM THIS PROBLEM AFFECTS ALL FORD RANGER FOR 2019 MODELS.