2019 FORD RANGER Electrical System Problems

The climate control system on my 2019 Ford Ranger has a recurring failure that prevents the vehicle from properly adjusting temperature or directing air through the vents. The failure causes a constant clicking/snapping noise behind the dashboard, and the blend door does not move when the temperature is changed. This malfunction matches Ford’s published SSM 49264, which identifies a known defect in 2019–2020 Rangers built on or before 7/30/2020 and states that the entire HVAC housing assembly must be replaced. This issue creates a safety hazard because the truck cannot reliably defrost the windshield in cold or wet weather. Loss of defrosting capability severely limits visibility and makes safe operation of the vehicle difficult. The issue is reproducible every time the temperature is adjusted. The problem began when the vehicle was still within the original mileage window of the factory warranty, but the dealership did not repair it. Ford has...

Hood/cowling along the windshield allows water to leak under the hood of the vehicle and wets the coils and plugs causing the engine to mis fire and shutter violently. This engine mis fire and sudden lack of power can cause the vehicle to obstruct the flow of traffic resulting in an accident. Problem was reproduced by the dealer and they replace coils, plugs, and installed an accessory engine cover to prevent the issue in the future. All at my cost. The problem remains that there are many Ford Rangers on the road unaware of this problem. This problem is documented in a Ford TSB but a more aggressive approaching is needed to resolve this issue.

Air bag malfunctions and not active passanger and driver side, hvac malfunction replaced twice, power train shifting out of gears, PCM malfunctions and triggering failures to sensors. Passanger seat belt not working. Collision sensor malfunction and not working.

After hookup of any type of trailer to electrical on vehicle, left turn signal fails to operate on vehicle or trailer, and warning message is displayed on panel. After disconnection of trailer operation of all turn signals in vehicle resume as designed.

My tail lights just stopped working. I didn't know that they were out until someone behind me told me that they were out. I didn't have any collision, nothing like that. I called the Ford Dealership and they told me to bring it in so that they can see what the problem is. They have been having issues with tail lights just going out.

The contact owns a 2019 Ford Ranger. The contact stated while driving approximately 10-15 MPH into the driveway at the residence, the vehicle lost electrical power and the vehicle shutoff as if there was no fuel going to the engine. The contact stated that there also a message that the rearview camera was inoperable, along with messages that features inside the cabin of the vehicle was inoperable. The contact restarted the vehicle and the vehicle shutoff immediately. The contact stated that the engine was not receiving fuel because the fuel pump was on the wiring harness that was not operating as needed. The contact stated that the messages “Cross Traffic Sensor Disconnected", “Rear Parking Sensor Disconnected” and "Rearview Camera Disconnected" were displayed on the instrument panel. The vehicle was taken to a dealer where it was diagnosed and determined that the electrical connector to the camera was corroded and not...

This is in relation to an existing recall on the 2019 Ford Ranger, NHTSA Recall no. 19V-839 This recall was for improperly connected inline electrical connectors from the Ford factory causing issues with rear brake lamps. I have recently had a fault with the same connector, which Ford technicians discovered was not properly connected. This connector failed due to the loose connection, causing all electrical connections in the rear frame (fuel pump, rear view camera, cross traffic warning, parking sensors) to fail. Upon discovering recall 19V-839, I contacted Ford support. I was informed that my truck was built in the same factory as the recalled vehicles, but was completed three days after the impacted period ( JUN 04, 2018 - AUG 16, 2019). Therefor Ford will not consider my issue part of the recall. Ford has advised me to bring this up to the NHTSA to broaden the scope of...

The contact owns a 2019 Ford Ranger. The contact stated that the temperature failed to adjust as needed. The contact stated that the damper was stuck. The heater was continuously blowing out hot air on the driver's side. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 19V726000 (Visibility). The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and opened a case, and referred the contact to the NHTSA Hotline. The failure mileage was approximately 25,152.

I have a 2019 Ford ranger that was built June 24th 2019 the internet states that any Ford ranger 2019 XLT built before July 30th 2019 has a recall for the HVAC system in the blower motor well my truck did not make the recall list but yet it has every single issue that they recall every time I call all they say is my vehicle VIN number is not on the recall but what is the chances that my blower motor and my blend door actuator does not work. When I bought the truck in 2021 I heard a ticking noise but the air still worked me being a female never thought much of it I thought it was my radio or something so this problem has existed since the day I bought it with 20,000 miles on it from the dealership. it has been tested by the Ford...

The contact owns a 2019 Ford Ranger. The contact stated that while driving at various speeds, the lights on the instrument panel became inoperable, causing the vehicle to lose power. The contact stated that the messages “Unsafe Driving” and “Head-on Collision" were displayed. The contact waited until the engine cooled down before restarting and driving the vehicle. The contact stated that the vehicle also experienced a failure with A/C unit, and the failures became more persistent. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 42,000.

HVAC BLOWER MOTOR NEEDS REPLACED AND EVAP BOX PER FORD DEALERSHIP TODD JUDY FORD. THERE HAS BEEN A PREVIOUS RECALL ON THE SAME MODEL FORD RANGER YEAR 2019. AIR CONDITIONING WORK FINE ON THE PASSENGER VENTS BUT BLOWS OUT HOT AIR ON DRIVERS SIDE. 2 SEPARATE MECHANICS AT INDEPENDENT MECHANIC AND TODD JUDY FORD DEALERSHIP REPORT THERE HAVE BEEN PROBLEMS WITH THE FORD RANGER AIR CONDITIONING AND HEATING SYSTEM REGARDING DUAL TEMPERATURE UNITS. DEALERSHIP REPORTS THAT THIS IS NOT COVERED UNDER WARRANTY AND IS ESTIMATED $3200 IN REPAIR. THE INDEPENDENT MECHANIC IS NOT ABLE TO OBTAIN THE PART AND DISCOVERED THERE WAS A PREVIOUS RECALL ON THIS PART ON THE 2019 FORD RANGER. I HAVE CONTACTED FORD CUSTOMER SERVICE DEPARTMENT AND THEY SPECIFY THAT THIS PART AND FAILURE OF MY 2019 FORD RANGER DOES NOT HAVE MY VEHICLE LISTED UNDER THE RECALL ALTHOUGH IT IS THE SAME MODEL. THE PROBLEM...

There's something wrong with the heater motor or the heater itself. When the heat is on even at the lowest setting the heat is too high. It gets very hot in the vehicle and I have to turn the heat off. The vehicle will fog up when the heater is turned off. There's also a smell like something's burning or overheating and there are clicking noises coming from behind the radio/ heater area. Also If the AC is turned on only the passenger side gets cold, and the driver side blows very hot air. The heat is on even in AC mode, very frustrating.

The contact owns a 2019 Ford Ranger. The contact stated while driving at an undisclosed speed, the air conditioner was activated. The air conditioner made a ticking sound. In addition, the A/C started blowing out hot air. The contact stated that the failure occurred when the temperature was 100 degrees. The contact stated that because of health issues, the air conditioner was required during the heated temperatures. The vehicle was taken to an independent mechanic where it was diagnosed with a failed A/C blower motor. The contact was informed that the A/C blower motor needed to be replaced. The vehicle was not repaired. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 120,000.

Vehicle presented a blind spot system fault warning and a cross traffic system fault. Immediately after this warning appears the vehicle ac/ heater shutdown, passengers seat belts light came up and radio got frozen. None of the ac/ heater controls worked. Blinkers appears to be advising that the were not working properly. Vehicle rums but everything else regarding de console stopped working.

The blindspot sensor on my truck appears to have gotten very hot. It melted the tail light and the wiring harness.

See related steering problem report. After Electronic Power Steering Assist went out on vehicle without warning of any kind to owner, dealer's service department diagnostics as best as I can determine did NOT indicate a problem with the parts that were replaced. The parts replaced were: 1. steering gear/rack and pinion/EPAS (which seems to go by various names), and, when installing this new, expensive, and long-in-coming part didn't get the power steering to work, 2. the battery. The scenario suggests that the root problem was the battery, not the steering gear. A representative of another dealer has advised that the first thing they check in cases involving electronic components is the battery. He also advised that Ford does not have a standard operating procedure or service bulletin that says this is something that is to be done. Can this be? Apparently, at least for this vehicle, there was/is no system...

In May of 2022 at approximatley 46,000 miles a family members 2019 Ford Ranger had the A/C unit on, but VERY hot air was blowing on drivers side. After inspection and Pin Point Test the Ford Dealership determined a manufactures Drivers Side Temp Blend Door was malfunctioning and was replaced at full charge of both parts and labor to the owner. A few days later after the manufactures malfunctioning part was replaced, the VERY same issue developed and caused a family member to pass out due to over 100 degress inside the vehicle. After OTHER inspection by the Ford Dealership it was determined the manufactures Blend Door Acuator, was malfunctioning and was replaced at full charge of both parts and labor to the owner. ON THE WEEK OF APRIL 10, 2023, THIS VIN'S FORD RANGER HAS EXPERIENCED THE EXACT SAME ISSUES AND HAS BEEN DETERMINED THE EXACT SAME MANUFACTURES PARTS...

The contact owns a 2019 Ford Ranger. The contact stated that while driving approximately 30-40 MPH, there was an abnormal burning odor detected. The contact stated that the front driver’s side heated seat had burned a two-inch hole into the seat, the upper back rest, and heating pad. The contact also noticed that the heated seat was inoperable. There were no warning lights illuminated. There were no blown fuses. The vehicle was taken to the dealer however, a service date was not available. The vehicle was not diagnosed or repaired. The contact repaired the seat himself. The manufacturer was notified of the failure and referred him to the local dealer for assistance. The failure mileage was approximately 54,000.

My brake lights, turn signals, running lights, and hazards don't work. The Ford dealership has inspected it. There were no warning signs or symptoms prior to failure.

Both of my taillights no longer work, at first it was intermittent and they would come back on but after a while nothing worked. No turn signal, hazard, or brake lights for the rear taillights only. The overhead one above the bed still works. The vehicles behind me cannot tell whether I am braking, turning or driving. It appears this was a common issue on earlier vehicles in production. It has been reproduced by an independent service center. It has not been inspected by the manufacturer, and no there was no other symptoms prior to the failure other than the intermittent working and not working.

On Jan 04,2022 while flat towing my truck behind my motorhome it caught fire and burned to the ground. It was too badly burned for the insurance to make a determination of the cause. However, it started in the engine compartment. I know it was not a bad tire because all tires were inflated until the fire popped them. I was able to get the truck disconnected from the RV and know that it remain in Neutral with nothing seized up like the transmission or brakes because the truck rolled on its own once it was disconnected and had to be chocked. I had followed all the proper procedures and my key was in acc position. I had towed this truck many hundred miles prior. That day I had towed it 5-6 hours prior to the fire. This incident took place in Alachua County Florida. Alachua County Fire Rescur case...

The contact owns a 2019 Ford Ranger. The contact stated while driving 35 MPH, the air bag warning light illuminated. The contact also stated that the windshield wipers, the defroster, headlights low and high beams failed to work. The contact veered to the side of the road for a short while and then drove the vehicle to the dealer to be diagnosed. The contact was informed that the rodents had damaged the soy-based insulated wiring harnesses at the front of the vehicle. The contact stated that the vehicle was repaired however, the rear lights would fail to turn off. The vehicle was taken to the dealer who diagnosed that the soy-based insulated wiring harnesses at the rear of the vehicle had sustained rodent damage. The manufacturer was made aware of the failure and a case was opened. The vehicle was not repaired. The approximate failure mileage was 31,000.

RODENTS KEEP EATING THE WIRING IN THE ENGINE CAUSING THOUSANDS OF DOLLARS IN DAMAGE.THIS HAS HAPPENED TWICE IN A TWO MONTH SPAN. I FOUND INFORMATION THAT FORD USES PLANT BASED MATERIALS TO COAT THE WIRING AND TO MAKE SOME OF THE HOSES. I'VE TRIED DIFFERENT MEASURES TO PREVENT THE RODENTS FROM DAMAGING THE WIRING TO NO AVAIL. THIS DAMAGE CAUSES MY ELECTRICAL SYSTEM TO FAIL AND KNOCKED OUT MY HORN AND OTHER VEHICLE FEATURES. IT DOESN'T SEEM FAIR AND GOOD BUSINESS PRACTICE BY FORD TO KEEP USING THESE PRODUCTS AND NOT TO INFORM BUYERS ABOUT THIS ISSUE. MY WIFE OWNS A HONDA AND HER VEHICLE ISN'T TOUCHED BY THE RODENTS.

THE INFO SCREEN WHICH CONTROLS HVAC FREEZES UP PREVENTING THE USER FROM CHANGING THE HVAC SETTINGS WHICH COULD CAUSE THE WINDSHIELD TO FOG OR FREEZE . VERY DANGEROUS...IT'S HAPPENING IN ALL FORDS NOT JUST THE RANGER YET NO RECAL AS OF YET

SOFTWARE THAT OPERATES STEREO AND ALL OTHER SOUNDS SYSTEM FEATURES FREEZES UP AND FAILS. VEHICLE MUST BE SHUTDOWN COMPLETELY TO REBOOT SYSTEM BEFORE IT WILL WORK AGAIN. THIS IS A REPETITIVE PROBLEM THAT NEEDS TO BE DEALT WITH.

TL* THE CONTACT OWNS A 2019 FORD RANGER. THE CONTACT STATED THAT A CHIPMUNK ENTERED INTO THE VEHICLE AND ATE SOME ELECTRICAL WIRES. THE VEHICLE WAS TAKEN TO BILL DUBE TOYOTA (40 DOVER POINT RD, DOVER, NH 03820; (603) 749-5500), WHERE IT WAS DIAGNOSED WITH NEEDING THE HEATING UNIT TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT CONTINUED TO EXPERIENCE THE FAILURE. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 7,000.

THE HORN DOES NOT ALWAYS SOUND WHEN YOU PRESS THE HORN SWITCH ON THE STEERING WHEEL. IT IS ESPECIALLY NOT LIKELY TO SOUND IF YOU TRY TO SOUND THE HORN IN AN EMERGENCY

AFTER THE AUTO START STOP FEATURE ENGAGES AT A STOP, THE ENGINE BEGINS TO RE-START BUT THEN SHUTS DOWN COMPLETELY ALONG WITH ALL ELECTRIC FUNCTIONS IN THE VEHICLE. CANNOT ENGAGE HAZARD LIGHTS OR RE-START THE ENGINE UNTIL THE THE BATTERY IS JUMP-STARTED. ONCE THE VEHICLE IS JUMPED, IT FUNCTIONS NORMALLY AND DOES NOT DISPLAY ANY BATTERY OR CHECK ENGINE INDICATOR. THIS HAPPENED ONCE AT A STOP SIGN IN A RESIDENTIAL AREA, AND AGAIN AT A RED LIGHT ON A MULTI-LANE BOULEVARD WITH SPEED LIMIT 45 MPH.

I RECEIVED NOTIFICATION FROM FORDPASS THAT MY 2019 RANGER WAS IN DEEP SLEEP MODE AND THAT I NEEDED TO MANUALLY START IT. I GOT INTO THE VEHICLE AND DEPRESSED THE BRAKE PEDAL AS NORMAL AND PRESSED THE START BUTTON. MANY THINGS HAPPENED SIMULTANEOUSLY. MOSTLY LIGHTS FLASHING ON THE DASH AND EVENTUALLY THE HEADLIGHTS SEEMED TO BE SENDING MORSE CODE. BUT THE ENGINE BARELY RESPONDED AT ALL. LATER I HOOKED UP A BATTERY CHARGER AND WHEN SWITCHED ON THE GAUGE BOUNCED BACK AND FORTH SO FAST IT APPEARED TO BE AN AIRCRAFT PROPELLER. THE VEHICLE WAS STATIONARY IN MY DRIVEWAY.

A STRONG ACRID SMELL OF MELTING PLASTIC IS NOTICED WHEN I USE THE HEATING AND AC UNIT.

TAIL LIGHT RECALL: TOOK VEHICLE TO GRAPEVINE FORD IN GRAPEVINE TX AND THEY SAID THEY HAD DONE THE WORK. LOOKING AT THE DATABASE IT STILL SHOWS NO REPAIRED. UNSURE WHAT TO DO ABOUT IT.

I WAS DRIVING MY VEHICLE AND TRYING TO STOP TO AVOID A COLLISION. THE SYSTEM INDICATED COLLISION DETECTION WAS ENGAGED; HOWEVER, THE BRAKES WOULD NOT STOP AND THERE WAS A WRECK.

TAKATA RECALL- I WAS RECENTLY IN A CAR ACCIDENT WITH MY 2019 FORD RANGER AND WHEN I PRESSED THE BRAKE THE WOULD NOT APPLY SO I CONTINUED TO PUMP THE BRAKE AND WOULD NOT APPLY AS I APPROACHED THE OTHER VEHICLE THE PRECOLLISON ASSIST TURNED ON AND STILL NOTHING AS I HELD THE BRAKES DOWN CAUSING AN ACCIDENT