2020 FORD FUSION Electrical System Problems

"The incident occurred immediately after shifting the vehicle into reverse and starting to move. The engine suddenly shut down with a 'System Performance' alert, and cooling fans engaged at maximum speed. Moments later, a thermal runaway event began in the high-voltage Li-ion battery pack, leading to a catastrophic fire. This is directly related to Recall 23V440 / 23S33 (BECM failure). The fire was extinguished by the local fire department in Telavi, Georgia (Country)."

COMPONENT: ELECTRICAL SYSTEM, ENGINE I HAVE HAD THIS SENSOR THAT MAKES MY CHECK ENGINE LIGHT STAY ON 3 SEPARATE TIMES! THIS NEEDS TO BE RE CALLED I SEE MULTIPLE COMPLAINTS WITH THE SAME CONCERN

I don't know what failed, but my vehicle spontaneously combusted this morning in front of my apartment.and is a total loss. Fire Marshal's [XXX] ) Case# XX-XXX. The fire also destroyed the vehicle sittling next to it. We are lucky the building didn't catch on fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am the second owner on my Ford fusion 2020 SE all-wheel-drive I got the car at 21,000 I had warranty since I had the warranty. I've been going for this power training code and having them check my car out all the time they always say there's nothing wrong with it. It's just the code is being erased so by the time my warranty went out all these problems are coming up and now they could find those problems I've been inquiring about

When these problems started it was only 6 months after purchase and I was already having issues with power train malfunctions and it didnt want to switch gears. I purchased this at roughly 47,000 miles and it didnt make it to 70,000 miles before I ultimately decided it was not the safe vehicle that was advertised to my family and I. It was taken to the dealership over 3 times in under a year and for some reason the problem never got resolved. I have been sued for the remaining balance now despite that toward the end of my time owning it the vehicle was reving out with barely any pressure on the gas pedal, having issues braking on its own (anti-collision assist), and occasionally the steering wheel would jerk me in to oncoming traffic. I am just trying to get a recall issued at this point because this car...

2020 Ford Fusion SE- Transmission problems. Only 98,000 miles on the car and have had issues with this transmission after a year of having it. Transmission fluid was good but there is a small leak, slipping gears, winding, and gear auto shifting back to park. No combustion or power until it hits 60 mph. Has been checked by mechanics. No lights on dash at all!

The contact owns a 2020 Ford Fusion. The contact received notification of NHTSA Campaign Number: 23V440000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure.

RANDOMLY 'SERVICE ADVANCE TRAC', 'PRE-COLLISION ASSIST NOT AVAILABLE', LANE ASSIST NOT AVAILABLE', POWER ASSIST STEERING NOT AVAILABLE', HILL ASSIST NOT AVAILABLE', WARNING LIGHTS APPEAR. WHEN THEY DO I COMPLETELY LOSE POWER STEERING. WHICH IS EXTREMELY DANGEROUS WHILE DRIVING. MOST THE TIME I CAN TURN OFF AND RESTART THE CAR AND IT GOES AWAY. HOWEVER, NOW IT HAS BECOME MORE FREQUENT AND HAS STARTED LOSING COMPLETE POWER OF THE CAR TURNING OFF WHILE DRIVING. I ALMOST DIED ON THE INTERSTATE. FORD DEALERSHIPS ONLY RECOMMENDATION WAS A NEW CIRCUIT BOARD THAT WAS LIKE $5K, MORE THAN THE CAR IS WORTH. THEY SAID IT WAS SOMETHING COMMON WITH THE FORD FUSIONS, THATS WHY THEY WERE QUIT BEING MADE. I RESEARCHED AND IT IS A COMMON ISSUE, BUT NO RECALLS HAVE BEEN MADE???!!???

since day number one this vehicle has had an issue of maintaining a charge even when you drive it regularly , if you don't start it the next day it needs a jump , agew days after purchase a new battery was installed and the problem persisted , this vehicle has the same issues as the other 2020 Ford Fusion models that have been recalled?? But unfortunately under the VIN there has been no recall when this vehicle suffers from the same issues the ones that have been recalled suffer from Just add it like the others please . The incident has happened every day since 2020 If you miss a day starting it the next day it needs a jump even in warm weather , and it's been driven .,Just doesn't hold a charge I assume , needs a jump There's a record on the Ford app of the...

I purchased a used 2020 Ford Fusion from Carmax n 2023 with about 56,800 miles. A week later was involved in a nor side impact accident on the back end driver side, insurance paid for a dinted door and there was no other issues with the vehicle according to SONS ford. In 2024 I was on the highway (going about 80 mph) when my engine light came on, no more than 3 minutes later all the lights in my car flickered and i lost power to my entire car almost causing me my life, roadside assistance and a mechanic who had thankfully pulled over explained that my alternator completely shredded my belt. I paid for both my alternator and belt to be replaced But most recently (2025) I continued to whirring and knocking noises for 3 days (no warning lights) , I took it to firestone who stated I needed...

Component or system that failed: Flex plate, engine electrical system, and alternator (possible related failures). The issue has been diagnosed by a licensed mechanic and is available for inspection upon request. Incident Description: On April 15, 2025, while driving my 2020 Ford Fusion SE 1.5L Turbo, the vehicle suddenly experienced a total power failure. The check engine light began flashing, and the battery light blinked rapidly. Within seconds, the engine shut down completely while I was mid-drive in traffic, leaving me stuck and unable to move for over 20 seconds. This was a terrifying and dangerous situation that nearly put my life at risk. I was eventually able to restart the vehicle, but it began shaking and rumbling violently — worse than ever before. This issue was never present before my car was involved in two separate collisions, where both other drivers were found 100% at fault. The vehicle was...

I have had 2 transmissions within the last year, making this the third Transmission on my vehicle. I had to have another common issue with the car replaced, which is a purge valve. My ABS light goes off often causing difficulty to steer the car and warning lights are activated showing that the safety features are not available. Lastly, there is a crack in the engine block caused by coolant in the spark plug due to overheating. This engine issue is one with the engines that Ford is aware of but I do NOT see a recall. The engine is blown due to this design and the warranties do NOT cover it. Case number [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My vehicle was in service with my dealer for several months 3 separate occasions for powertrain issues which werent resolved and now the alignment in my steering wheel is really off. My spouse and I believe the PCM is messed up but have had no progress with our dealership and suspect them of committing consumer fraud and selling us a lemon. The vehicle in question is around 70,000 and started messing up at 60,000.

The alternator was producing too many volts, which would short circuit the battery and electrical components in the car. This would cause the car to lose power and not be able to accelerate. My car would randomly lose power on the highway, with no warning, resulting in my car suddenly slowing down. This was dangerous for the cars around me who are going 60+ and then my car quickly drops to 40 or less mph. In addition, to solve the issue I would have to pull off onto a shoulder to shut the car off and back on. This issue started around 3-4 yrs ago and has gotten worse as time passed. The problem was identified and resolved by Firestone when they ran a diagnostic. No check engine light was on in the car to alert me of any issues. I replaced both parts on the car.

The entire media display gets stuck off or will freeze up, when I place the vehicle in reverse the rear camera comes on but parking assist, the rear sensors and cross traffic sensors won't work. Once I place the car in drive the display will either stay all blue or shut completely off. I cannot adjust the climate control, use GPS, or use the media. I have to shut the car off and then after about 10 minutes there is a bunch of clicking noise under the dash and after it stops clicking I can restart the car, the display will sometimes begin to work and if it dossent then I have to shut off the car again and go through the motions again. It has started to be more and more frequently, at first it was maybe once a week and now it is happening at every start.

APIM is faulty per the ford dealer ship. (Rusty Eck Ford) They state that it is a known issue but there has not been a recall. This affects the SYNC, navigation, instrument panel, connectivity to ford connect app, etc. In order for some things to be used temporarily, it has to be hard reset on the console. Nothing leading up to the issue.

At first the check engine light was on and the car would not start. The dash would display all the lights and at one point it turned off while driving luckily I was going 20-30mph. Took it to the dealership and they said an Intake Valve had to be replaced and it was covered by the warranty. Next the engine light was on and a MAP censor had to be replaced which wasn’t covered. Once again the engine light and service light came on and the code is saying the same censor needs to be replaced. Each time it has effected how the car drives and is dangerous especially on the interstate because it will not go over 20mph. When the car is in reverse it will shake and turn off displaying auto start stop issue and place the car in park. It will then turn off. It is hit...

the first time the incident happened I was driving home from work, i took and a turn and lost power, the car indicated a message that read " Auto StartStop Shift to P, then restart Engine. I tried starting my car a few times and it turned on. A week later I was driving on the highway and it happend. I pulled over and same thing. I took it to a Ford dealership and they couldn't replicate the problem.

Issues with Ford Sync Infotainment system have been occurring for over a year now, with the latest being on May 25th. Backup camera stays on when in drive, and then turns to a blue or black screen that says contact dealer. GPS will fail randomly and will show my vehicle driving off roads and not following the route I am driving. A/C will randomly stop working and show a Fan Speed of 0 no matter how many times you try to increase the fan speed, then once you are able to adjust the fan speed after restarting the car it will only blow very hot air at any temperature setting except in Max A/C. Which even in Max A/C the air coming out is not very cold. The backup camera staying on is dangerous you are not able to control any other functions of your vehicle because the vehicle believes...

According to dealership, the 12-volt, 7 year battery passes all testing and has a "Good" (best) rating (battery is only 3 years old). Diagnostics reveal batter at 80%. When battery falls below 85% (such as frequently happens in cold weather), the computer program shuts down several features including remote car starting. Electrical programming must be changed to when a battery falls below 50%...when a car battery should be changed out. Please recall these vehicles and require Ford Motor Company to reprogram the electronic system. Thank you.

If the car is parked in directly sunlight and I start the car a "Front camera temporarily unavailable" message will appear. It happens more when the outside temperature is warmer.

Water is leaking into the trunk of our vehicle through the tail light assembly and soaking all the electrical wiring in the base of the trunk. The wheel well is becoming flooded with water. All the wiring going in and out of the trunk is soaking wet. If you Google this issue. Other Ford Fusion owners with older model vehicles and the same tail light assembly are having the exact same issue where water is coming into the trunk from the tail light assembly. This is clearly a design flaw and with water coming inside and covering the electrical system I want to believe this is major safety concern.

The contact owns a 2020 Ford Fusion. The contact stated that while driving and attempting to make a right turn, the parking brake activated causing the vehicle to abruptly stop. The contact was turned off and then restarted the vehicle. Approximately 3 miles later while driving, the failure reoccurred. The odometer lights began flickering, the gear shift indicator (PRNDL) light started to change, the location of the gear shifter started to switch gears, and the radio malfunctioned. The shift sensor malfunction and fault warning lights were illuminated. The failure occurred a total of 5 times. The contact took the vehicle to a certified mechanic who reset the vehicle to remove of all the codes however, the failure reoccurred. The contact scheduled an appointment with the dealer however, the vehicle had not yet been diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the...

(Fleet Vehicle) Car was dead; had to jump start; battery replaced under warranty

Car dead again; had to be jumped. Towed into dealer. battery Concern

(same fleet vehicle from before) Electrical system concern again; battery issue. Battery was already replaced on 2/02/21. Dealer had to replace battery again.

Dead battery again; this is a major concern on this particular fleet car that we have. Dealer had car towed in. I told them to check the connections. This seems to be a concern of other 2020 Ford Fusion owners as well, after researching. We need this vehicle in our fleet and we cannot have this keep happening. No dealer paperwork yet as the problem has not yet been resolved; car still at the dealer.

BATTERY DRAINS VERY QUICKLY AND NEEDS TO BE JUMP-STARTED REPEATEDLY, WHICH HAS RISKS TO SAFETY AND EQUIPMENT. THIS IS A FLEET VEHICLE.

BATTERY DRAINS VERY QUICKLY AND NEEDS TO BE JUMP-STARTED REPEATEDLY, WHICH HAS RISKS TO SAFETY AND EQUIPMENT. A NEW BATTERY WAS INSTALLED EARLIER THIS MONTH AND IT HAS ALREADY DRAINED ALSO. THIS IS A FLEET VEHICLE.

THE TOUCHSCREEN DISPLAY IS NOT WORKING. IT TURNED COMPLETELY BLACK. I CANNOT CHANGE THE RADIO STATION. I SHUT OFF MY CAR AND TURNED IT BACK ON AND IT IS STILL NOT WORKING HAD TO HARD RESET THE SYSTEM CAR ALSO SHIFTS HARD IN AND OUT OF PARK AND REVERSE, MAKES A CLUNKING SOUND AND SHIFTS HARD IN FIRST AND SECOND

THE TOUCHSCREEN DISPLAY IS NOT WORKING. IT TURNED COMPLETELY BLACK. I CAN CHANGE THE VOLUME USING THE DIALS, BUT I CANNOT CHANGE THE RADIO STATION. IT ALSO WILL NOT SHOW MY BACK UP CAMERA. I SHUT OFF MY CAR AND TURNED IT BACK ON AND IT IS STILL NOT WORKING

AS I'M DRIVING MY RADIO SHUTS OFF AND WILL NOT POWER ON. THE VEHICLE WAS IN MOTION

TL* THE CONTACT OWNS A 2020 FORD FUSION. THE CONTACT STATED THAT THE BACKUP CAMERA REMAINED ON WHILE DRIVING AT AN UNKNOWN SPEED. THE VEHICLE WAS TAKEN TO THE ROYAL OAK FORD DEALER, LOCATED AT: 27550 WOODWARD AVE, ROYAL OAK, MI 48067, WHERE THE SENSOR WAS REPLACED. THE CONTACT STATED THAT WHILE DRIVING HOME, THE VEHICLE HIT A POT HOLE, THE FRONT PASSENGER'S TIRE WENT FLAT. THERE WAS NOT SPARE TIRE. THE CONTACT'S HUSBAND PURCHASED A NEW TIRE, JACKED THE VEHICLE UP TO REPLACE THE TIRE. WHILE ON THE JACK, THE VEHICLE WENT IN REVERSE, ROLLED BACK AND FELL OFF THE JACK. THE VEHICLE WAS TAKEN TO THE SAME DEALER WHO STATED THAT THE VEHICLE WAS NOT EQUIPPED WITH A SPARE TIRE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND REFERRED THE CONTACT TO THE DEALER. THE CONTACT WAS TOLD TO TAKE THE VEHICLE TO A BODY SHOP TO...