2017 FORD FUSION Engine Problems

My 2017 Ford Fusion started with a grumble, saw white smoke exhaust. Drove about 6 miles turned off car, restarted the car and the engine light came on. Brought the car a week later to Dons Ford, they diagnosed a coil issue caused the engine light being on. Roughly a $700.00 repair. Few days later engine light came back on. Took it back to the dealer, they said they probably didn't reset the computer, so the computer thinks it still has a problem. They checked and rechecked my issue. This car has been a gem, 69,000 miles. Bought the car because I buy American made, my son worked in Detroit for Ford. Engine light came back on about 5 days later. Diagnoses, you need a new engine. $9,000. They say my car can catch on fire, but the dealer said I can drive it. There is more I could say...

2017 Ford Fusion with 90,000miles-Check engine light went on in the AM, no drivable concerns noticed. Took fusion to my mechanic, motor had coolant leak into cylinder #4, cylinder #4 had stopped firing. Complete 1.5L engine replacement needed. Engine coolant thermostat house gasket replaced Engine gasket kit/seals replaced Complete Engine assembly performed Removed & replaced 1.5L engine Engine Long Block replaced $7,900.00 in parts and labor Had the engine seized while driving due to this coolant leak catastrophic incident may have incurred with possible death. Found that other Ford models have had a recall for this issue but that 2017 Ford Fusions do not have enough incidents to be included. Extremely dangerous and deadly.

MY 2017 Ford FUSION 2.0 Eco COULD HAVE CAUGHT ON FIRE WITH MY 6 YEAR OLD INSIDE!! I went to start my car & it didn’t want to turn over. Turned car off. Tried again. Started up but sputtered manically..then “kind of” settled down. I was maybe 2 miles down the road && COOLANT TEMP HIGH light turned on. I pulled over immediately turned car off. Checked coolant levels….it was BELOW minimum (NO VISIBLE LEAKS) replaced coolant, car started smoother. 2 days later. I started my car it was a little rough && as I began driving I could see what looked like white smoke coming from exhaust. I looked for a safe place to quickly pull over and the COOLANT TEMP HIGH light dinged on again. I checked levels…again BELOW minimum..this is 2 days AFTER I refilled the coolant….once again there are no visible leaks on the ground. It...

I had the car about 3 months when the first service light appeared. Misfire - replaced the cylinder. But 2 months later service light came on again for same issue. Ford Dealership said it was coolant intrusion. Car repeatedly overheats. Service engine light comes on/stays on. Temperature gauge will indicate high temp, then will drop to normal seconds later, then shoot to the top again. At times engine will decrease power, and I have to pull over and park until engine cools, no matter where it happens. I don't feel safe driving on the highway, or any distance more than 20 miles or so. I am also afraid to park in the garage at night in case it's too hot. Ford dealership says it needs a new engine. Called Ford Customer Service but my VIN was not on the service action 19B37 or 21N12 (even though it was manufactured at...

The contact owns a 2017 Ford Fusion. The contact stated while accelerating from a stop, the vehicle stalled with the check engine warning light and several other unknown warning lights illuminated. The vehicle was restarted on the third attempt; however, the failure recurred. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The contact stated that the failure persisted. The manufacturer was notified of the failure. The failure mileage was 156,782.

The vehicle experienced engine failure due to engine coolant intruding into the cylinders. This was formally diagnosed by a Ford Dealership service team after the vehicle broke down on the side of the highway. This is the exact issue outlined in TSB #22-2229. The check engine light was activated indicating there was an issue. I filled up the coolant basin with a gallon of the manufacturer recommended coolant, and within 6 days, all the coolant was gone and the engine shut down when I was driving at approximately 50mph. Ford Corporate will not lend any financial assistance for the repairs, which is a complete engine replacement. This replacement costs between $7,000-$10,000.

My car is experiencing the issue noted in Technical Service Bulletin 22-2229 (09-June-2022). My car leaks engine coolant into the engine/cylinders causing an excessive draining of coolant, overheating the engine, and shutting off the car. Specifically, my engine overheated and shut off, making the car undriveable. I was forced off the road on a single lane highway with speed limits of 55mph. This occurred at [XXX] on Friday, [XXX]. The area where the care came to rest was not particularly safe due to the narrow roads and high speed limit. The check engine light came on when this issue became a problem. My car was inspected by Bull Valley Ford in Woodstock, IL. They diagnosed that the issue is indeed the same issue in TSB 22-2229. The quoted price to repair is $7,000.00. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Driving on a highway engine began to shake and lose power engine had no problems prior to this all oil changes were up to date. After Engine began shaking violently pulled over on side of road no check engine light was present. Had vehicle towed where even when engine was on no check engine light. After checking the codes with ob2 reader it was determined a cylinder 1 and 2 misfire was present I replaced spark plugs and coil packs and that did not resolve the issue. It was then towed to a repair shop where they confirmed there was catastrophic engine failure including metal in the enigne there were no warning signs that this could happen the dealer and ford have been 0 help except wanting 12,000 to replace the engine

Coolant was leaking into the Engine. This is a known issue with this make and model of the Ford Fusion, yet not all the engines were recalled. Ford told us this was a known issue, but we received no notification of this being a potential issue. We have taken our vehicle to Ford since we bought it new in 2017, and nothing was ever said. Now that the engine has the issue that is part of the recall, Ford would not take any responsibility for it and refused to help pay for the repairs. If the engine is doing exactly what the recall was for, then Ford should be held responsible for the repairs.

Transmission went out , 2017 fusion had recall with something with transmission never got notice from

I have a 2017 ford fusion with a 2.0 ecoboost engine. First, I received service engine soon message on my car which was diagnosed as a misfire. Following that, a few days later, my car overheated on the way to my work. I checked the coolant which was low and added more. There had been no signs of leaking under the car at any time. I was able to drive the car home but by the time I got home the coolant was again very low. I had it towed to a Ford dealership where I was given the catastrophic news that it was due to coolant intrusion and I need a whole new engine that will cost 9,000.00 after folloeing the TSB. I have approximately 60,000 miles on it and Ford has refused to help in any way. I have had the oil changed as recommended since I bought...

2017 Ford Fusion Titanium 2.0L Ecoboost purchased brand new. Coolant intrusion into Cylinder #1, causing a misfire,registered in Vehicle Health Alert system; check engine light on. Liberty Ford dealership was notified within the first week of the 1st misfire. Autozone found fault code P0301. Code scanner suggested replacing cylinder #1 spark plug. If misfire cont., it stated to replace Coil on cyl #1. All four spark plugs were replaced and Coil for cylinder #1 was replaced. Veh.began to exhibit a low coolant level, white exhaust smoke & rough running. Coolant fumes were entering the veh. cabin. Coolant added as soon as "Engine Coolant Over Temperature" dash alert. Diagnostic completed at Firestone Complete Auto Care: Determined "Cyl 1 is full of coolant & misfire occurring due to engine burning coolant.TSB out for this issue stating engine block replacement will be needed. Recommend dealership*** Manufacturer's recommended maintenance.… They provided a copy of...

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle made an abnormal sound and vibrated. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed with a coolant leak into the engine, and it was determined that the short block needed to be replaced. The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion); however, the VIN was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was 98,526.

Vehicle was sputtering while idle or in park. Engine light came on and when tested the diagnostic said “cylinder 2 misfire” Noticed coolant level would decrease quite drastically in short matter of time, also causing vehicle to run hot or begin to over heat. It’s not always possible (or safe) to pull over on the side of a busy freeway or wherever you are driving when this happens. After investigating, found that coolant was leaking into the cylinders. Being that this was a common issue in these specific eco boost engines I knew my engine block would need to be replaced. Car was at 40,000 miles when this started happening and still under warranty. Took car to the dealership explained the issue only for them to try to say there was nothing wrong with it after not even getting down into the engine. After much back and fourth they finally...

#4 cylinder has fouled 3 spark plugs in the last 5 months. Car sputters at start, anti-freeze is missing bit no visible leak, blue smoke from exhaust. Took to dealer for diagnostic and was told engine rebuild/replace is needed and was quoted cost of $7465. My car is just over 91k miles and my extended warranty expired in March of this year.

Shaking of the vehicle and resistant to accelerate on so dangerous to drive especially on highways. Check engine light on. Both independent service center and Ford dealership confirmed spark plugs are damaged, leaking oil, need new engine and this is a known issue with this ford engine.

2.0l EcoBoost engine illuminated malfunction indicator light (MIL) diagnostic trouble code indicates presence of coolant intrusion into one or more cylinders. defect causes corrosion, misfires, engine failure, and fires.

The contact owns a 2017 Ford Fusion. The contact stated that while the vehicle was parked on several occasions, the check engine warning light illuminated. Additionally, the contact stated that while driving at various speeds, the check engine warning light illuminated intermittently. The vehicle was taken to the dealer where it was diagnosed and determined that the engine needed to be replaced due to a coolant intrusion into cylinder #1. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 76,000.

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the vehicle briefly vibrated, and there was excessive white smoke coming from the exhaust. The contact stated that the message "Low Coolant Level" was displayed, and the check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the spark plugs. The vehicle was repaired, but the failure reoccurred. The vehicle was then taken to the dealer, who diagnosed a failure with the fuel injectors. The vehicle was repaired, but the failure reoccurred. The vehicle was taken back to the dealer, and the contact was informed there was a misfire in cylinder #2. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance....

There is a coolant intrusion into the vehicle’s engine, which has in turn created the need for a new engine entirely. This issue is known in 2017 Ford Fusions and vehicles have been recalled but only those made in certain manufacturing areas. The car is currently at the ford dealer for service and the dealership informed us this is a known issue and the engines have been recalled previously. After our own research it is clearly a known issue and should be recalled across the board. This vehicle is under 100,000 miles and inoperable, due to a manufacturer error. This needs to be made right and be an active recall for the 2017 ford fusion. There was no warning. I was driving one day at about 50 mph when the car lost all power to the engine and immediately slowed down on me. There is nothing safe about this and...

The coolant leaked into the engine. The dealership said it needs a new engine. I had no problems with the car until all of a sudden the overheat light came on. Regular maintenance has been done. The car is in great condition. Less than 72,000 miles.

I drove through a strip mall shopping center on 8/13/2024, without warning, my 2017 Ford Fusion's engine shut down and I could not re-start the engine. There was no "Check Engine" light. The shutdown later proved to be caused by the failed Mas Air Flow (MAF) sensor, Ford Part #Part #: AFLS195 (8V2Z12B579A). My understanding is that the MAF sensor sends data to the Powertrain Control Module (PCM) to deliver the specific amount of fuel that’s proportional to the airflow and without that information, the engine just stops. I read, the MAF sensor failure shutdown occurs in vehicles of many makes. I was in a shopping center when the engine shut down, leaving me stranded in the traffic, but minutes before I was in 45 MPH speed limit traffic on a main multi-lane thoroughfare. Had the engine shut down had occurred then. I may have been in a dangerous situation....

Engine coolant leaks into the cylinder block due to a manufacturing defect. Car needs a new engine.

Engine ran rough on startup. Coolant temperatures increased causing the car to reduce power while driving on the freeway at 60MPH. Refilled coolant as the levels were low. The check engine light appeared on the instrument panel. The code was a P0301 which is a cylinder #1 misfire. Replaced all spark plugs and ignition coil for cylinder #1. The vehicle was taken to an independent service center where a diagnostic test was performed. The diagnostic showed coolant intrusion into engine cylinder #1 which resulted in engine failure. The failure mileage was approximately 54,000.

The contact owns a 2017 Ford Fusion. The contact stated while driving at various speeds occasionally, the vehicle stalled. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the engine needed to be replaced. The vehicle was taken to another independent mechanic for a second opinion where it was confirmed that the engine needed to be replaced. The vehicle was taken to a local dealer where it was diagnosed that the short block needed to be replaced. The vehicle was not repaired. Upon further investigation, the contact related the failure to Technical Service Bulletin: 22-2134: however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 75,554.

while trying to pass another car, my car stalled and would not speed up, then the high temp light came on then it cut off. it has been diagnosed with coolant intrusion by Kirk Brothers which is where I bought it.I can't understand why ford will not do something about this. I guess someone will have to get killed before something gets done. I can't afford to get the car fixed and it's my only vehicle. I commute 40 miles every day to work and have no other option than to drive this unsafe car. I'm scared for my life but if I don't go to work, I cant provide for my family or pay for this car. my car has all the criteria i see on the ford's customer satisfaction page, why is it not on recall. And it was made at the Hermosillo, Mexico plant which has a...

Excessive blue smoke from tailpipe, car overheats on road, fails emission tests. Local repair shop diagnosed as bad head gasket due to improper engine block engineering design, known problem Ford 2017 1.5 Ecoboost Engine, per mechanic.

twice while driving my motor stalled and the engine light came on. once the motor shut off completely. white smoke comes from the tail pipe. I took the car to kirk brothers ford greenwood Ms. which is where i bought the car and they diagnosed it as having coolant leaking into the engine. They will not fix it because they say there is no recall. I bought the car in November of 23 and it had less than 80,000 miles on it.

I am unable to change gears on my vehicle because the bushing on the shifter cable has degraded and no longer holds the shifter cable in place. This has caused me to be stuck blocking traffic in busy shopping centers. I have to make sure to apply my parking break because I never know if my car really is in park. I have had the full shifter cable replaced 3 times and I have replaced the bushing 2 times all I'm a 16 month period.

2017 Ford Fusion (87,000 miles): Check engine light was illuminated. Visited independent garage next day. approx $700 repairs did not fix the issue. Light came on a second time the following week. Took back to independent garage and was told it was a historical alert and not an active alert. Alert cleared. several days later the light came on again. Called to make dealer appointment. While waiting for the appointment, the overheating warning message came on. Stopped at the dealer who topped off coolant. 3 days later with almost no driving in between, dealer diagnosed Coolant Leak, misfire cylinder #2 - similar to information available online - coolant almost empty. All vehicle maintenance and 4 previous recalls properly maintained for vehicle. No known recall notice related to the Ford Fusion Coolant Leak known issues. Cost of repair quoted at $9,000 to replace engine. car not drivable and will take a...

The contact owns a 2017 Ford Fusion. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated, and the temperature gauge indicated that the vehicle was overheated. The vehicle was taken to an independent mechanic where it was diagnosed with coolant leak and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 70,000.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the transmission experienced rough shifting from first to second gear. Additionally, the engine was misfiring. The check engine warning light was illuminated. The vehicle was taken to the dealer, where it was diagnosed that the transmission needed to be replaced. The vehicle was then taken to two other independent mechanics, and it was determined that the transmission needed to be replaced as well as the engine due to coolant intrusion into the engine. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 60,790.

My car has been diagnosed with the known engine coolant leak issue with the 2.0L engines in the 2013-2018 Ford Fusions. It just now today, 8/1/2024, threw up a check engine light and I went to an ASE certified technician and they diagnosed it to be the same problem Ford has covered in their own technical service bulletins.

Coolant intrusion into cylinder causing spark plug corrosion and warping of head. Confirmed by dealer that this is a known common issue with the engine and requires the engine to be replaced. Only warning sign on my car was an occasional misfiring that I brought the car in for within a week of noticing. Told that there was a recall on the model but not my specific car and it has expired so nothing can be done.

Engine cylinder cracked, coolant intrusion into cylinder. Engine had to be replaced. Vehicle only had 54,776 miles.

My engine started to act up so I took it to the dealership. I was told that there was coolant intrusion in the cylinder head due to manufacturer known defect and that my vehicle was unsafe to drive and that the recall for this issue was expired. I was told my vehicle was unsafe to drive as it could hydrolock and cause an accident. This is a frightening issue that should not have a time limit given the fact that it can cause the engine to suddenly lock up which could cause a serious even fatal accident. This issue was confirmed by the dealer technician. There were no warning lamps untill the failure.

The contact owns a 2017 Ford Fusion. The contact stated on several occasions when the vehicle was started, the check engine warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the engine needed to be repaired. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 55,730.

My car is a 2017 Ford Fusion with a 1.5 liter eco boost engine. 2 weeks ago my check engine light came on. I brought my car and there was apparently a coolant leak that caused my entire engine to cease and I was told by ford my entire engine needs to be replaced for over 8500 dollars. My car is under 67000 miles. The coolant problem was stated to me as something that is seen by a lot of these engines. I did research to find out that this has been a common occurrence with fords carrying these types of engines. The coolant leak could lead to engine stopping in the middle of driving! I have a [XXX] son and a baby on the way. Knowing ford is still letting people drive these cars is unsafe and on top of that making people pay for something that is their...

The contact owns a 2017 Ford Fusion. The contact stated while driving at various speeds, the accelerator pedal was depressed, and the vehicle accelerated violently. The engine temperature and check engine warning lights were illuminated. The vehicle was taken to a local dealer where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The vehicle was diagnosed by an independent mechanic with cylinder #3 misfire due to a coolant leak. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 95,005.

The contact owns a 2017 Ford Fusion. The contact stated that when the vehicle was started, the check engine light warning light illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that there was coolant leaking into cylinder #3. Additionally, there was a crack in the short block, and the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 78,000.

The contact owns a 2017 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle revved aggressively while depressing the accelerator pedal. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local independent mechanic where two burned spark plugs were discovered and replaced. The contact stated that while driving away from the independent mechanic, the failure reoccurred. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 103,000.

The contact owns a 2017 Ford Fusion. The contact stated that on several occasions while driving at various speeds, the check engine warning light illuminated. The vehicle was taken to an independent mechanic twice to be diagnosed. The contact was made aware of an engine misfire and that there was coolant intrusion into the combustion chamber. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 51,000.

Engine light came on. Took it for repair and found coolant is leaking into the firing chamber resulting in the need for a longblock engine replacement. I was told I could keep driving it but it stranded me on a highway. It has been inspected by the dealership in Louisburg Kansas and two other auto shops.

2017 Ford Fusion has 52,000 miles and needs an engine. Price of new engine and install 9,000. All service completed by Ford om required basis, but now needs an engine at 52K miles.

I took our 2017 Ford Fusion in a couple of weeks ago for a service code showing we had a misfire on #2. We had the repair completed which included new plugs and coils. This past week, the car showed an alert that said the car was overheating. I drove it to the service center and the car gave me an alert that the computer had reduced power to lower the temp of the engine. The mechanic just called me and said that we have coolant in the cylinder. They said this is a known problem and that it is listed under TSB 22-2229 which superseded TSB 22-2133. I have called Ford and Ford dealerships and they sent me to this site to file a complaint. Their answer was that they couldn't fix it until the NHTSA told them to fix it--even though they stated they have seen a lot...

While driving my Ford Fusion to the Local Ford Dealer (Monday 7.1.2024) for the scheduled Oil change the check engine light came on. I informed the Service writer at the dealership upon arrival. He stated they can complete the oil change but, could not check that problem with the engine light coming on due to the fact you have to make an appointment to have the car serviced. At that time I did make an appointment for that service to have my car inspected for the following Monday (7.8.2024). on my way home the car started to run rough, like it was not running on all cylinders. On Friday 7.5.2024 I contacted an independent service mechanic took my car to an independent service mechanic. He ran a diagnostic test. he determined that coolant was leaking into cylinder #2, he stated it was due to either a broken head gasket or...

The contact owns a 2017 Ford Fusion. The contact stated that while her son was driving 55 MPH, the vehicle began to shake and vibrate, prompting the driver to pull over to the shoulder of the road and turn off the vehicle. The vehicle then failed to restart. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic, who determined that there was no compression in cylinder #2, resulting in damages to the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 106,000.

I was driving the car and it started to overheat so I pulled over. I then drove the car to my home and it had a miss in the engine along with white smoke coming out of the exhaust. After getting home I checked the coolant and it was low so i filled it up and as the car sat there idling you could see the coolant disappear and the white smoke and rough idle. I could not see where the coolant leaked out on the ground. I also had to have the transmission replace at the dealership I bought it from due to transmission complete failure. Time to recall this make and model. 1. Engine, Transmission failure 2. Sitting along the highway in the middle of no where.. a woman, you can guess, not safe!! 3.Yes Transmission replaced by dealership and Engine confirmed by service center to have coolant...

The check engine light began coming on. I took it to the mechanic to determine what may be going on, but he could not find anything. The check engine light continued to come on. Took it back in for deep-dive diagnostics. Service Charging System came on - randomly and intermittently - took it to two different mechanics. At this time problem was intermittent and not consistent. Three mechanics attempted to dive deep into the situation but could not find it. They ruled out the alternator and other issues they suspected. The coolant and Temperature lamps came on once. I immediately stopped driving and checked the coolant. Then, I had mechanics check the coolant and make sure all was good. I took it to another mechanic, and he said it was now throwing all kinds of codes. Took vehicle to local Ford dealership where I was told I needed a new...

The contact owns a 2017 Ford Fusion. The contact stated that when the vehicle was started, the contact stated there was an abnormal amount of white smoke coming from the exhaust tips. The contact stated that the failure was persistent. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 45,000.