2016 FORD FOCUS Power Train Problems

The vehicle experienced failure of the DPS6 dual-clutch automatic transmission. The transmission began slipping during acceleration, hesitating between gear engagement, and triggering a “Transmission Overheat” warning. Eventually, the vehicle lost the ability to reliably shift between Drive and Reverse and would not consistently engage gears. The vehicle can start and move forward but cannot reliably switch directions within the same ignition cycle. The vehicle is available for inspection. The transmission malfunction created safety concerns due to delayed or failed acceleration when entering traffic. The vehicle hesitated and slipped under throttle input, which could prevent timely acceleration when merging or crossing intersections. Additionally, the inability to reliably shift between Drive and Reverse could create hazardous situations in parking lots or emergency maneuvering scenarios. The sudden transmission overheat warning and gear disengagement could result in loss of power in traffic. The issue has been confirmed by an independent mechanic who diagnosed transmission...

Transmission is slipping. Check engine light is on. Code P07A5 (3/3) Permanent Transmission Friction Element B Stuck on.

When driving my car all of a sudden it loses power almost like it’s struggling to go but the RPM revs up and makes a loud noise and my car kind of got stuck for a minute and there were cars behind me then it started going but every couple minutes it would do that again rev up really loud even when I barely push the gas and lose power and then go I have no idea why it was doing that I took it to get it looked at, but there was no light on then a light finally came on and it came up with P07A3. Transmission friction element A stuck on. It starts end doing that with no notice. Light came on later after I tried to get it scanned. There seems to be extended warranty satisfaction things offered on vehicles at the same time mine was...

The contact owns a 2016 Ford Focus. The contact stated that while driving at various speeds, the vehicle unexpectedly stalled with the message "Transmission Overheating" displayed. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. The contact stated that the failure persisted. The manufacturer was not contacted regarding the failure. The failure mileage was 55,000.

Fuel purge valve is malfunctioning. Vehicle loses power and is sluggish. Idles very rough and sometimes has a loss of power. My car has been at Ford twice in the last six months and problem still isn't fixed. Complete engine was replaced about a year and a half ago due to recall issue which I don't want happening again. I do not feel safe driving this car. I made an appointment with Ford a month ago for tomorrow for same stalling issue. I went to drop off and explain I wanted the repairs done for the recall to see if that fixed the problem. I filled up my gas tank on Sunday. The car wouldn't start and engine light came on saying engine failure service now. I let it sit for about ten minutes and it hesitantly cranked and engine light went off but accelerates slower with loss of power....

Having fuel problems with this ford se. Adding gas after starting the car it doesn't run right. It misses n doesn't have power. Plus Transmission went out two times again. First time it went out. It was about a year ago. Now the second time [XXX]. First time was about a year ago. It was repaired. Because I had a car warranty from the car dealer ship. Now they won't repair it again. This ford focus Se had the double clutch in it Plus the notorious speed shifter known to go out. These transmissions are known to have problems. But the car place never told me. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Something wrong with the transmission the one that Ford extended warranty on and my car is a 2016 and Ford extended it 10 years and they said it ended a few months ago as well as the TCM replacement I didn't know about because I just purchased the vehicle a little over a year ago.

Lee County was working on the road and were replacing a section of Lazy D Farm Road and there was a section cut out and try to get across the section the transmission over heating light came on

The clutch had to be replaced a second time and the engine became disabled while driving due to parts failure and it blowing up. This is all happening with 60,000 miles on the vehicle. My safety came into question with both failures disabling my car while I was driving on the interstate. The clutch was replaced and paid for out of pocket and I have been trying to work with ford about the engine but they have not helped at all. The issues just popped up and failed immediately while driving. This engine failure issue is covered for my vehicle, but my VIN is not covered. The only explanation I have received is that it is because my car is a manual transmission, which has no link to the part that failed on the engine. I was also notified by the ford service manager that my vehicle was made in...

The contact owns a 2016 Ford Focus. The contact stated while driving 40 MPH and depressing the accelerator pedal, the vehicle hesitated. The contact also stated that while attempting to start the vehicle, the vehicle failed to respond as intended. Additionally, while driving at an undisclosed speed and attempting to make a left or right turn, the lost motive power. An independent mechanic was contacted, and the vehicle was taken to the independent mechanic to be diagnosed. The mechanic retrieved DTC: P2872 (Clutch "A" Stuck Engaged). The vehicle was not repaired. The contact related the failure to Customer Satisfaction Program: 14N02 (Extended Warranty Coverage for PCM Reprograming in the Event of ABS Vehicle Speed Signal Related Communication Loss that Disables OBDII System Monitors); however, the VIN was not included in the CSP. The manufacturer was notified of the failure, and informed the contact that the VIN was not under warranty...

I was driving the car other all of a sudden died on me and told me to put it in park I put it in park and then turned the key off and tried to restart it. It did not restart and would not turn of kept popping up a warning saying starter system failure. Could not turn my wheel or pit it in neutral to get it out of te middle of the road.

The contact owns a 2016 Ford Focus. The contact stated that while driving at approximately 60 MPH, the vehicle started losing motive power. The contact heard an abnormal grinding sound coming from under the floorboard. The contact stated that while depressing the accelerator pedal, the vehicle failed to accelerate as intended and was jerking and vibrating abnormally. The contact stated that the failure was more pronounced after the initial failure. The contact stated that later, the check engine warning light illuminated, and the vehicle was difficult to start. The contact stated that the check engine warning light was orange. The vehicle was taken to a local dealer, where it was diagnosed, and determined that the clutch actuators needed to be replaced. The vehicle was repaired. The contact researched online and related the failure to a problem with the dual clutch transmission installed in the vehicle. The manufacturer was informed of...

The car failed to start, it did not recognize it was in park. After trying to start my car with the keys it failed. My safety is put at risk, my car failing to recognize which gear shift it is in causes malfunctions while I am on the road, especially since I drive long distances at high speeds. I had a Master Technician review and preform a diagnostic on my vehicle and the codes formed for this test matched hand in hand with TCM issues under the TSB. After this, I went to the dealership to discuss this issue and the only thing that came of it was informing me that I was not eligible for a recall due to my VIN, even if I have all the symptoms under the TSB for my Ford Focus 2016. Since my car failed to start I was not able to bring it...

It is my transmission problem, there is an engine light on and the shifting is very rough and it also jumps gears, i know ford had a recall for this problem i believe it should be under warranty it is the TCM

The contact's son owns a 2016 Ford Focus. The contact stated that while at a stop, the vehicle shuddered while depressing the accelerator pedal. There was no warning light illuminated. The contact then stated that while his son was driving at an undisclosed speed, the message "Transmission Hot - Wait 5 Mins" was displayed on the instrument panel. The contact's son followed the instruction; however, the warning light returned soon after restart the vehicle. Due to the failure, the vehicle was towed to the residence. The manufacturer was notified of the failure but offered no assistance. The vehicle was not repaired. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was approximately 137,000.

Transmission Control Module failed and i had that replaced. Now the clutch pack failed and had that replaced. Now it says transmission hot and to pull over. All of this has been recalled on 2012 to 2016 but for some reason my car is not and its the same powershift transmission. Im over 4000 dollars into these repairs and still having problems.

The transmission is slipping. Research shows it's a known issue. Ford has acknowledged the issue and extended support. My local ford dealership is refusing to fix the issue even though I fall within the extended service mileage. I called 2 transmission shops who refused to work on this specific model due to the dual clutch design and known problems. Attached is a letter I am disseminating requesting proper assistance with this issue.

Additional information related to a case I opened earlier today Vehicle: 2016 Ford Focus SE Component: PowerTrain – Transmission My 2016 Ford Focus has experienced three failed clutch packs with the Ford DPS6 PowerShift transmission. The first clutch was replaced at ~22,000 miles, the second at ~27,500 miles, and it now requires a third replacement at 80,000 miles. This is a known and dangerous defect that was part of a class-action lawsuit. Despite multiple replacements and low mileage, Ford is requiring me to pay over $4,000 for a third repair. This transmission causes slipping, hesitation, and safety issues when pulling into traffic or hills. I am requesting that NHTSA re-investigate or expand the scope of past complaints on this vehicle to include continued post-settlement failures.

I am writing you today because my ford focus with transmission DPS6,7SPDCT has all the same problems the older models have. Ford has stopped there 10 year 150000 mile warranty on there transmission on all models built after November 5 2015. Mine is January 1 2016 with all same transmission components. And all my warranty is ran out and still having transmission problems.

The contact owns a 2016 Ford Focus. The contact stated while driving 50 MPH, the transmission was slipping, the vehicle exceeded 3,000 RPM and suddenly lost motive power. There was no warning light illuminated. The contact was able to pull over to the side of the road. The contact was able to resume driving; however, the failure recurred while at a complete stop at a four-way intersection. The contact was able to drive approximately 2 MPH to his son's residence. The vehicle was towed to the dealer, where it was diagnosed that the fuel pressure regulator had failed, and a fuel line was rusted. The dealer replaced the parts. Additionally, the dealer diagnosed that the transmission clutch needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage...

The contact owns a 2016 Ford Focus. The contact stated that while idling at a stop sign and attempting to accelerate, the transmission failed to shift into gear and the vehicle failed to respond. The contact shifted to park until the transmission shifted to drive. The message that the transmission was overheating was displayed and informed the contact to park the vehicle. The vehicle was taken to the dealer, who diagnosed that the traction control module and clutch had failed. The contact related the failure to NHTSA Campaign Numbers: 18V845000 (Power Train) and 18V169000 (Power Train); however, the VIN was not included in the recalls. The vehicle was not repaired. The manufacturer was informed of the failure, and a case was opened. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 82,000.

Purchased 2016 Ford Focus SE with 132,000 Mi on Wednesday June 11, 2025. Drove with no problem when I took it for a long test drive. Drove it Thursday June 12, 2025 with no problem. On Friday June 13, 2025 I thought I felt a little slippage going from 1st to 2nd gear. On Friday June 14, 2025 my 17yr old daughter drove it to the beach and while driving back home she got a msg "Transmission Overheating". She pulled over and called me. I was able to put the key 2 clicks into the starting position and switch to neutral where I got a msg " Transmission now Ready". I then put my scanner on it and was it read Shift Error PO7A3, Clutch "A" Disengagement P286F, Clutch "B" Stuck Engaged P287A. I took it to the dealer I bought it from but it was a As Is Purchase....

There are known issues with the 2016 ford focus transmission dual clutch transmission shudder. My vehicle is the se and seems to have this but there is no safety recall for the se or my vehicle specifically. There was even a law suit for the 2016 ford focus se with this issue. My car has under 77,000 miles. When I asked ford about this issue previously they said there was nothing g they could do

The transmission is awful, delayed acceleration, rough shifting and lack of power. Delayed acceleration is the main issue due to it “ lagging “ in the middle of intersections and at green lights, etc. may fall under the ford focus lawsuit but when I look up my vin on this website, no recalls pop up but all the signs of the other models recalled are shown and present in my model of the Focus.

The contact owns a 2016 Ford Focus. The contact stated that while depressing the accelerator pedal, the vehicle hesitated and then jerked into the next gear. The contact stated that the hesitation occurred at various speeds. The contact stated that the check engine warning light was illuminated. Additionally, the contact stated that while slowing down, the vehicle hesitated, and then the transmission downshifted, and the vehicle jerked. The contact had not taken the vehicle to a dealer or independent mechanic to be diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 131,206.

The contact owns a 2016 Ford Focus. The contact stated that while driving 20 MPH, the vehicle briefly began to jump and jolted before returning to normal functionality. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the clutch, determining that the transmission friction element B was stuck on. The contact was informed that the clutch needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 100,000.

The contact owns a 2016 Ford Focus. The contact stated that while driving at an undisclosed speed, the vehicle briefly jolted and hesitated before returning to normal functionality. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the clutch motor. The vehicle was repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 16V479000 (Power Train); but the VIN was not included. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 134,000.

The contact owns a 2016 Ford Focus. The contact stated while driving at various speeds, the transmission was slipping, and the vehicle jerked until shifting into gear. The contact stated that the check engine warning light was illuminated. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The contact was advised that the VIN was not under recall. The manufacturer was notified of the failure. The approximate failure mileage was 116,000.

The transmission (powertrain) on my 2016 Ford Focus SE (VIN: [XXX] ) has had persistent issues since shortly after I purchased the car in April 2022. It has not completely failed yet, but the symptoms — including shuddering, slipping, jerking, and hesitation when accelerating or shifting — have worsened over time. It uses a dual-clutch transmission with no dipstick, making it difficult to properly monitor or service. The vehicle is in my possession and available for inspection upon request. Due to the unpredictable and unsafe driving behavior, I have stopped driving the vehicle altogether and have not driven it in over a month. The car hesitates when shifting, especially at stop signs or when merging into traffic, creating serious safety concerns for myself and others. The issue has been reproduced multiple times and addressed at the CarMax dealership in Tinley Park, IL, where I bought the car. However, their repairs...

The vehicle shutters and fails to engage while taking off from a stop. The transmission feels like the clutch slips (Automatic transmission). This 2016 Ford Focus is having the exact same issues as mentioned in the Ford customer satisfaction program 14M02 -Supplement #7. In this memo Ford outlines that 2012-2016 Ford Focus models with the DPS6 automatic transmission built between August 1st 2010 - November 5th 2015 in Michigan can get repairs made. I contacted Ford and they are saying they will not honor repairing the vehicle since it isn't showing the recall attached to it specifically even though they acknowledge the issues exist in my vehicle. On the 14M02 recall supplemental #7 the Fords with that transmission have received additional extended warranties to 10yrs 150,000 miles. My car has 132,000 miles and is 9 years old. I had this same issue fixed prior while the vehicle was still under...

The contact owns a 2016 Ford Focus. The contact stated that the vehicle failed to shift into second gear while driving. The contact stated there was an abnormal grinding sound while turning the steering wheel. The contact stated that while driving approximately 10-50 MPH, the vehicle began to slow down and kick back. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed with transmission control module, purge valve, and power control module failure, and a software reprogramming was needed. The vehicle was repaired, but the failure recurred. The vehicle was taken back to the local dealer, who replaced the transmission. The vehicle was repaired, but the failure persisted. The vehicle was taken back to the same dealer, where it was diagnosed and determined that the clutch needed to be replaced. The manufacturer was contacted and referred the contact to the...

The contact's daughter owns a 2016 Ford Focus. The contact stated that while driving at various speeds, the vehicle jerked and hesitated while depressing the accelerator pedal, with several unknown warning lights illuminated. Due to the failure, the vehicle was towed to the dealer and was diagnosed with a defective clutch module. The contact was provided an estimate for the repair and was later referred to the manufacturer for assistance. The manufacturer was notified of the failure and informed the contact that the vehicle was not included in NHTSA Campaign Number: 18V845000 (Power Train). The vehicle was not repaired. The failure mileage was approximately 100,000.

The contact owns a 2016 Ford Focus. The contact stated while driving at an undisclosed speed and accelerating, the vehicle shuddered and jerked before shifting into gear. No warning lights were illuminated. The vehicle was taken to a dealer, who diagnosed a failure with the transmission. The vehicle was not repaired. The contact related the failure to TSB Number: 16-0129. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 86,000.

The contact owns a 2016 Ford Focus. The contact stated while driving at an undisclosed speed and accelerating, the vehicle shuddered and jerked before shifting into gear. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed the vehicle with transmission failure. The vehicle was taken to the local dealer, where it was confirmed that the failure was with the transmission. The vehicle was not repaired. The contact related the failure to TSB Number: 19N08. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline. The failure mileage was approximately 107,000.

The contact owns a 2016 Ford Focus. The contact stated while driving on an Interstate at 50 MPH, the “Transmission Fault Service Now" message was displayed and the check engine warning light was illuminated. The vehicle was taken to a local dealer where the vehicle was diagnosed, and DTC: P07A3 and P2872 were retrieved. The contact was advised that the clutch, transmission, and the passenger’s side engine mount were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 222,440.

The contact owns a 2016 Ford Focus. The contact stated that while her husband was driving approximately 50 MPH, the vehicle failed to accelerate as intended. The contact stated that the message "Transmission Overheating" was displayed. The vehicle was pulled over to the side of the road and then towed to a dealer to be diagnosed. The vehicle was diagnosed with internal clutch failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 100,000.

Transmission shuddering, slipping

I’m having a very difficult time with ford dealership there is a lot of information about this 2016 ford focus automatic transmission that has problems with either its dry clutch or the tcm transmission control module. It is revving high when you stop it doesn’t shift gears properly it jerks hard it won’t go into higher gears it will start reversing out of no were that’s a very very terrifying situation especially that me and my fiancé have a little boy in this vehicle. We were so happy to buy this vehicle and ended up having huge problems for only having 100k miles on the odometer. This is are only vehicle spent are taxes on this vehicle to get us around for a few years go on vacations all that. To call ford and be told basically if this vehicle wasn’t involved in the lawsuit against ford about this certain...

Several clutch repairs have been needed and ford is refusing to fix it.

Transmision gets hot and i have to pull over right away, otherwise I might cause an accident. Once is get hot it won't move at all. Obd code p2872 and p2872dp. Clutch A stack engaged. My car only has 75400 miles. I took it to ford liner. And they told me the car has no recalls at all. They charge 196 dollars to inspect the car. They also told me that they need to change the couch A because is stuck but want to charge me 4,650$

Battery was disconnected in order to install new radio. After installation, car started just fine but could not go faster than 20mph and would "stall" (even though it is auto transmission) once getting up to that speed. Ford dealership diagnosed as needing a new transmission control module. I was also told this problem would have occurred whenever the battery died, so it was no fault on the radio installation. There is a recall on these parts but for some reason my vehicle is not included in any warranties or recalls. I do not have any written communication with the Ford dealership yet as all contact has been via phone calls.

The contact owns a 2016 Ford Focus. The contact stated while driving approximately 35-40 MPH, the transmission was slipping. No warning light was illuminated. The vehicle was taken to the dealer; however, the contact was informed that the vehicle had performed as designed. The vehicle later failed to reverse while the transmission was shifted to reverse(R). The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 18V845000 (Power Train); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was unknown.

I am dealing with a dual clutch going bad the car is stalling hesitating and loosing power very dangerous to drive. Also i just replaced transmission without finding any help from ford even there was a recall now my dual clutch is going on and there was a recall i never got to be apart of when i first got the car in 2015. I need help please point in the direction i feel like ford should fixed this buy the car back

The contact owns a 2016 Ford Focus. The contact stated while driving at an undisclosed speed, the vehicle inadvertently lost motive power; however, the RPM continued to increase, prompting the contact to immediately turn off the vehicle. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the transmission control module, resulting in damages to the transmission. After investigating the failure, the contact related the failure to Customer Satisfaction Program: 14M02. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 51,000.

My clutch and or transmission is malfunctioning. When I drive up hill the car shudders and I lose power, it's a risk when another vehicle or pedestrian is behind me. When I accelerate from a full stop, same symptoms. If in an emergency I have to move I would be at risk because then the vehicle would hesitate. The issue was confirmed with the manufacturer's dealership service center. No warning lamps, no messages just a sudden appearance of the symptoms that were progressively getting worse. I looked up two separate customer satisfaction programs which I believe I should be eligible but bought the vehicle after their expiration and even though I think the vehicle satisfies the programs' terms, the manufacturer did not include my vehicle's vin.

The contact owns a 2016 Ford Focus. The contact stated that while accelerating from a complete stop, the front-end shuddered and vibrated significantly. There was no warning light illuminated. The contact stated that the dealer had picked up the vehicle for the repair of Ford Campaign Number: 24N07; however, upon diagnosing the vehicle, the dealer informed the contact that the failure was not related to the Service Campaign, but instead to the transmission dual dry clutch. The vehicle was then taken to an independent mechanic, where it was diagnosed that the failure was related to the failure listed in NHTSA Campaign Number: 18V845000 (Power Train). The dealer was contacted and informed the contact that the VIN was not included in the recall. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered because the VIN was not included...

My vehicle started having issues with the transmission, like shifting issues while starting to accelerate , not going into gear while I am accelerating as well as going in and out of gear in current speed levels with the flow of traffic. It would go from a drive engagement to neutral and would cause me to be in dangerous situations while having passengers in my car as well as my children. I do Lyft an Uber as a current profession, and the last 10 rides that I have given people have been put in positions of compromise or danger due to the shifting issues. After googling issues online, I discovered my Transmission has had various online complaints of Same danger issues. I had 2 Mechanics also verify the issues as well. I contacted ford customer service and they have denied any issues or any recalls attached to my vin. After...

The contact owns a 2016 Ford Focus. The contact stated while driving approximately 35 MPH, the check transmission warning light illuminated. The contact stated that the vehicle was shaking abnormally, and the transmission was shifting hard. The contact stated that the failure was recurring. Additionally, the contact stated that the transmission was difficult to shift into reverse(R). The contact stated that the transmission was also slipping out of gear. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the shift actuator needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Hotline. The failure mileage was approximately 111,700.

2016—2022 Ford EcoSport® and Focus® 1.0L Engine--- My car is experiencing the same issue as the Automatic transmission. The car is not listed on the Oil Pump Failure Recall on the Ford Website as it shows that it applies to automatic transmission, and doesn't mentioned manual transmission. Both transmission carry the same issue as it's an engine design flaw and not a transmission related issue. The car experienced a bad idle that results to lost of power and Oil light went on as I drove it to the Mechanic shop. Currently there's no parts available and ford website the part is back ordered. The reference number is 23S64 for the current recall of the 1.0L engines. Please see reference below. I've contacted Ford support about the issue and was informed to report the issue here. Website for reference: [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),...

Ford recall 14M02 for transmission control module (TCM) does not cover parts and labor required to fix additional equipment problems created by a faulty TCM such as the clutch. My 2016 Ford Focus only has 58,000 miles on it. The TCM is being repaired a 2nd time but Ford will not repair the subsequent damage to the clutch. This is a function and safety issue.