2011 FORD F-250 SD Fuelpropulsion System Problems

THE FUEL RAIL PRESSURE SENSOR STARTED SPRAYING DIESEL FUEL ALL OVER THE TOP OF THE MOTOR . THE FUEL IS COMING OUT OF THE TOP OF THE SENSOR .THIS IS ON 05/25/19 .. THIS TRUCK ONLY HAS 132214 ON THE MILEAGE . I AM GETTING TIRED OF PAYING FOR A BROKEN TRUCK EVERY WEEK . LAST WEEK ON 05/05/17/19 THE INNER COOLER BOOT DUCT BLEW APART . THAT WAS A $480 FIX .

7/7/17 - 2011 FORD F250, 6.7L DIESEL ENGINE, MILEAGE 79530. (PURCHASED DECEMBER 2010). I WAS PULLING A SMALL TRAILER UP AN INCLINE (8%) ON I-64 IN WV. ON THIS PORTION OF THE INTERSTATE THERE WAS NO EMERGENCY PULL OFF SHOULDER. THE TRUCK OPERATED NORMALLY FOR THE FIRST 3 MILES ASCENDING THE HILL. DURING THE 4TH MILE, THE TRUCK BEGAN TO GRADUALLY, BUT PROGRESSIVELY LOSE POWER, GOING FROM 70 MPH DOWN TO 0. AT APPROXIMATELY 30 MPH, THE TRUCK BEGAN TO SHUTTER SLIGHTLY, AND CONTINUED TO DO SO UNTIL IT STOPPED IN THE LANE OF TRAFFIC AND STALLED. THERE WERE NO WARNING LAMPS OR CHIMES THAT WENT OFF BEFORE THE ENGINE STALLED. THIS VEHICLE IS EQUIPPED WITH A 'STOP SAFELY NOW' WARNING, ALONG WITH MANY OTHER WARNING INDICATORS ' BUT IT DIDN'T ILLUMINATE. THE TRUCK WOULD NOT RESTART. I IMMEDIATELY CALL 911 TO REPORT THAT MY VEHICLE WAS DISABLED IN THE...

2011 FORD SUPER [XXX], 6.7L FIRE HAZARD, FUEL INJECTOR HOLD DOWN FAILURE WHILE IDLING IN YARD, SPRAYING FUEL ALL OVER PLACE, TOWED TO DEALER, RECOMMENDS REPLACING ALL HOLD DOWNS DO TO FAULTY PART. TSP ON IT.. 1600.00 NOT COVERED UNDER WARRANTY 86,000 MILES. FIRE HAZARD. GLAD I'M NOT THE ONE THAT'S GOING TO BURN IN THE SUPER [XXX] TRUCK RECOMMEND YOU HAVE FORD RECALL ALL 2011 6.7 LITERS TO REPLACE THE DEFECTIVE PARTS. SELL FORD STOCK. FIRE PROFESSOR AND ENGINEERING STUDENTS. COME ON PEOPLE REALLY!!!!!!!!!!!!!!!!!!!!!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THIS ISSUE IS AROUND THE DIESEL EXHAUST FLUID SYSTEM - SPECIFICALLY THE REDUCTANT HEATER ASSEMBLY BUT HAS ALSO NOW AFFECTED THE FUEL PUMP AND ASSOCIATED EMISSIONS. THE PROBLEM IS INTERMITTENT BUT OCCURS WHEN THE TEMPERATURE FALLS BELOW 30 DEGREES. THIS CARE HAS BEEN IN DEALERSHIP REPEATEDLY OVER THE PAST 14 MONTHS FOR THIS ISSUE. PART OF THE DESIGN OF THIS SYSTEM FAILURE IS TO DEPOWER THE ENGINE WHICH NEARLY CAUSED AN ACCIDENT WHILE I WAS DRIVING. I HAVE EXHAUSTED MY ABILITIES AND PATIENCE WITH FORD MOTOR COMPANY AND NOW SUBMIT IT TO YOU FOR REDRESS. SEE ATTACHED PDF DOCUMENT FOR FULL DETAILS..

WHILE DRIVING AT AROUND 60 MPH THE DASH STARTING CHIMING AND GAVE ME A STOP SAFELY NOW MESSAGE. I SLOWED DOWN AND PULLED OVER TO THE SIDE OF THE ROAD. AT ABOUT 5 MPH THE TRUCK SHUT OFF, POWER STEERING AND BRAKES FADED. I WAS BARELY OUT OF THE LANE OF TRAFFIC AND MY ATTEMPTS TO RESTART THE TRUCK AND GET IT FURTHER OFF THE ROAD TO A SAFER SPOT WERE NOT ALLOWED BY THE COMPUTER SYSTEM. I HAD THE TRUCK HAULED TO A NEARBY FORD DEALER AND AFTER COOLING OFF ALL NIGHT THE TRUCK WOULD RESTART. THE LOCAL DEALER COULD NOT FIX THE PROBLEM DUE TO TROUBLE WITH HIS DIAGNOSTIC COMPUTER SO HE SUGGESTED I TRAVEL TO ANOTHER DEALER. HE FELT I COULD MAKE IT THERE WITH THE TRUCK. I WENT TO THE MOTEL WHERE MY WIFE AND I HAD TO SPEND THE NIGHT TO PICK HER UP, A...

TRUCK SHUT DOWN AUTOMATICALLY AND WOULD NOT RE-START DUE TO EMISSION SENSORS PER THE DEALERSHIP. *TR

ON 11/03/2014, MY WIFE WAS DRIVING OUR 2011 FORD F-250 6.7 LITER DIESEL ON E. KIEHL AVE IN SHERWOOD, AR. THE VEHICLE ALL OF A SUDDEN LOST POWER AND SHUT OFF LEAVING HER TO HAVE TO NEGOTIATE TRAFFIC WITHOUT POWER STEERING OR POWER BRAKES. SHE WAS ABLE TO AVOID A CRASH. WE HAVE NEVER HAD A PROBLEM WITH OUR TRUCK. I JUST HAD THE VEHICLE SERVICED ON 09/30/2014 WHERE THE OIL AND FUEL FILTERS WERE CHANGED. THE TRUCK WAS TOWED TO NORTH POINT FORD IN NORTH LITTLE ROCK, AR. THEY DREW FUEL OUT OF THE SYSTEM PAST THE SECONDARY FILTER. I WAS ADVISED THAT THE FUEL WAS CLOUDY AND CONTAINED METAL FRAGMENTS AND WATER. THE VEHICLE IS COVERED UNDER A 100,000 MILE POWERTRAIN WARRANTY. HOWEVER, FORD ADVISED THAT THE HIGH PRESSURE FUEL SYSTEM HAD FAILED AND THAT IT WAS DUE TO CONTAMINATED FUEL SO THEY WOULD NOT COVER IT UNDER...

I PURCHASED THE VEHICLE IN OCTOBER OF 2013 WITH 99,000 MILES ON IT. IN JANUARY OF 2014 I HAD A CHECK ENGINE LIGHT COME ON. I RETURNED TO THE DEALER TO HAVE THE CODE READ. AT THIS POINT THE DIESEL TECH COMES AND TELLS ME THAT MY FUEL SYSTEM HAS BEEN CONTAMINATED AND THEY HAVE TO REPLACE THE ENTIRE FUEL SYSTEM AND THAT I SHOULD CALL MY INSURANCE COMPANY TO COVER THE COST. THE INSURANCE COMPANY SENT OUT AN INSPECTOR WHO TOOK SEVERAL FUEL SAMPLES. NOW AFTER 16 DAYS WITHOUT MY TRUCK THE TEST SAMPLES HAVE CAME BACK AS 100% PURE DIESEL FUEL WITH NO TRACE EVIDENCE OF CONTAMINATION AND THEY WILL NOT COVER THE COST. THEY ARE CURRENTLY SENDING ME LEGAL DOCUMENTATION AS WELL. THE FORD DEALER KNOWING THIS INFORMATION REFUSES TO BUDGE FROM THEIR CONTAMINATION CLAIMS. *TR

DRIVING DOWN A 6 LANE HIGHWAY IN MID DAY TRAFFIC. HAD JUST LEFT MY HOUSE NOT 2 MINUTES EARLIER. LIGHT COMES ON SAYS STOP SAFELY NOW. I START TO SWITCH LANES AND THE ENGINE SHUTS DOWN. I AVOIDED A NEAR COLLISION AND SWERVED INTO A TURN LANE. THE TRUCK WOULD NOT EVEN TURN OVER. CALLED THE DEALER AND AFTER I EXPLAINED WHAT HAPPENED THEY STATED OH YOU HAVE A BAD EGT EXHAUST SENSOR IT SHUTS THE VEHICLE DOWN AND WAS INFORMED IT IS A REGULAR THING. WHEN I GOT TO THE DEALERSHIP THEY SAID THERE IS NO FIX OR UPGRADE JUST CHANGE THE SENSOR. THEY ALSO SAID THERE IS NO WAY TO KNOW WHEN THEY ARE GOING TO GO OUT. THEY EXPLAINED WHEN ONE OF THE FOUR SENSORS GOES BAD IT READS A HIGH TEMP READING AND THAT TRIGGERS THE SHUT DOWN. ASKED WHY THEY DON'T CHANGE THE SOFTWARE TO...