2005 FORD F-150 Power Trainautomatic Transmission Problems

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT WAS DRIVING 60 MPH UPHILL WHEN THE ENGINE BECAME HESITANT AND THE TRANSMISSION WOULD NOT DOWNSHIFT PROPERLY. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 83,189.

2005 FORD F150 TRUCK 4X4 AUTO TRANSMISSION EXPERIENCED MECHANICAL FAILURE WITH NO WARNING. LOST FORWARD LOW GEARS. ONLY HAS 57K MILES. TRUCK WAS ALWAYS DEALERSHIP SERVICED AND MAINTAINED AS RECOMMENDED. NO HARSH WEATHER CONDITIONS EXPERIENCED. NO HEAVY TOWING DONE. REPLACED WITH REBUILT TRANSMISSION. OLD PART WILL BE MADE AVAILABLE. *TR

2005 F150 STALLED WITHOUT WARNING WHILE DRIVING SOMETIMES AT HIGHSPEED ON THE HIGHWAY. IT HAPPENED VERY FREQUENTLY AND THE CHECK ENGINE LIGHT FINALLY CAME ON SO I TOOK IT TO THE DEALERSHIP FOR REPAIR. I WAS TOLD THAT THE THROTTLE BODY WOULD NEED REPLACING AT APPROX $750.00 AND WAS TOLD THAT THIS IS A TYPICAL REPAIR FOR THIS VEHICLE. I UNDERSTAND MANY OTHERS HAVE HAD THIS ISSUE. PRIOR TO REPAIRING I STALLED SEVERAL TIMES IN THE HIGH SPEED LANE AND HAD TO PULL OVER TO THE LEFT HAND OF THE 4 LANE HIGHWAY WHICH I WAS FORTUNATE NOT TO BE HIT. THIS SEEMS TO BE A VERY SERIOUS SAFETY ISSUE. *TR

ORIGINAL FLYWHEEL BROKEN. TOLD WILL COST $1K TO $1,4K TO REPLACE THAT AND STARTER B/C FLYWHEEL 'PROBABLY' DAMAGED STARTER. TRUCK WON'T START SOMETIMES, AND GRINDS WHEN I TRY TO START IT. WAS STRANDED 2 TIMES AND HAD TO BE TOWED. *TR

I OWN A 2005 FORD F150 5.4 AUTOMATIC W/ 63,000. UNEXPECTED FAILURE OF TRANSMISSION CAUSED BY, AS DEALER STATED, A DEGRADATION OF A BEARING WHICH CAME LOOSE AND BECAME LODGED IN SIDE OF THE TRANSMISSION. I REPLIED TO THE FORD SERVICE MANAGER DOES THIS MEAN THAT WHAT CAUSED THE FAILURE WAS A DEFECTIVE PART, HE ANSWERED YES AND GAVE ME THE QUOTE FOR A NEW TRANSMISSION. I HAVE DONE SOME RESEARCH AND HAVE FOUND OVER 6,000 CASES OF CUSTOMERS WITH SAME ISSUE( NO TOWING, PROPER MAINTENANCE INTERVALS AND DOCUMENTATION, ETC.) YET INVESTIGATION IS BEING CONDUCTED TO FIND SOLUTION TO THE PREMATURE FAILURE. TALKED TO 3 NATIONALLY KNOWN TRANSMISSION REPAIR FACILITIES AND THEY ALSO HAVE STATED NUMEROUS PROBLEMS WITH THE 4R75W AND 4R70E/W TRANSMISSION THAT FORD IS INSTALLING IN ITS VEHICLES, PRIMARILY WITH THE EXACT SAME SYMPTOMS. *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHEN ACCELERATING FROM LOW SPEEDS OF 15-25 MPH, THE VEHICLE WOULD VIBRATE EXCESSIVELY, CAUSING THE TRANSMISSION TO SHIFT HARD. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ADVISED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER FOR THEM TO INSPECT AND DIAGNOSE THE VEHICLE FOR REPAIRS. THE FAILURE MILEAGE WAS 64,000.

TRANSMISSION FAILED WHILE DRIVING. LEAVING ME STRANDED ON THE HIGHWAY. FRONT BEARING WENT OUT ,ROOT CAUSE OF FAILURE ACCORDING TO AAMCO MECHANIC. TRUCK ONLY HAS 49,000 MILES. TRUCK HAS ALWAYS HAD A VIBRATION . LANCE CUNNINGHAM FORD ALWAYS POINTED TO TIRES, DRIVE SHAFT. I BELIEVE THAT THE TRUE PROBLEM HAS NOW CAME TO LIGHT. UNFORTUNATELY THE ORIGINAL WARRANTY WAS FOR 3 YEARS OR 36,000 MILES. *TR

I BOUGHT THIS TRUCK WITH 48,000 MILES ON IT. IT HAD A BAD SHAKE IN THE REAR AREA. ALSO A BAD BRAKE SHIMMY. TOOK TO FORD DEALERSHIP I BOUGHT IT. COULDN'T FIND ANYTHING WRONG. TOLD NORMAL! I WORKED IN THE SERVICE DEPT OF A FORD DEALERSHIP I KNOW NORMAL. 53,000 OR SO MILES BAD CLUNKING FROM TRANSFER AREA WOULDN'T GO INTO 4 WHEEL DRIVE 1/2 THE TIME TOOK TO FORD, TOLD NOTHING WRONG AGAIN. 72,000 MILES TRANSMISSION GOES OUT. TOLD NOTHING COULD BE DONE, OUT BY 2000 MILES. I WAS A SERVICE MANAGER FOR A FORD DEALERSHIP THEY COULD DO A SUPPLEMENT ON THE WARRANTY. I ASKED FOR 1/2 OF COST TOLD NO. EVEN AFTER DOCUMENTATION OF ALL THE SERVICES AND COMPLAINTS TOLD TO BAD SO SAD. THIS TRUCK HAS HAD TRANSMISSION TROUBLES, 4 WHEEL DRIVE TROUBLE, THE POWER WINDOW SWITCH FELL APART IN THE DOOR AND A BAD BRAKE...

5.4L, SUPERCREW-- ENGINE WAS REPLACED BY FORD AT 38,000 MILES (AFTER COMPLAINT TO FORD CUST SVC) DUE TO INJECTOR FAILURE AND CYLINDER HYDRA-LOCK. NOW AT 46,000 MILES, COMPLETE TRANSMISSION FAILURE. ONLY USED FOR DAILY DRIVER, NO TOWING, NEVER OFF-ROAD. TRANSMISSION FAILED ON INITIAL START ON 60 DEGREE MORNING, NO PRE-FAILURE INDICATORS. PAID $2800 FOR TRANSMISSION REBUILD. I HAVE NOTICED A FAIRLY LARGE NUMBER OF PROBLEMS REPORTED ON SUB-STANDARD FACTORY TRANSMISSION AND ENGINE PARTS ON FORD TRUCKS. *TR

FORD F-150 SUPER CREW WITH 57,000 MILES WILL NOT ENGAGE IN OVERDRIVE. WHILE DRIVING, THE TRANSMISSION COMPLETELY SLIPPED OUT OF GEAR. AFTER PULLING OFF THE ROAD AND TESTING IT IN REVERSE AND DRIVE, I WAS ABLE TO RESUME BUT AS SOON AS THE TRANSMISSION REACHED OVERDRIVE IT DISENGAGED COMPLETELY. DEALER CLAIMS A PIN WAS BROKEN THAT LOCKS THE TRANSMISSION IN OVERDRIVE. *TR

TL*THE CONTACT OWNS A 2005 FORD F150. SINCE THE VEHICLE WAS PURCHASED, THE TRANSMISSION EXPERIENCED IRREGULARITIES WHILE SHIFTING. THE VEHICLE WOULD SHIFT IN AND OUT OF GEAR. THE CONTACT HEARD A NOISE WHEN THE VEHICLE SHIFTED INTO OVERDRIVE. THE VEHICLE WAS TAKEN BACK TO THE DEALER AT 23,400 MILES AND THEY STATED THAT NOTHING WAS WRONG WITH THE VEHICLE. ROCKS WERE REMOVED FROM THE EXHAUST SHIELD. THE TECHNICIAN TEST DROVE THE VEHICLE AND STATED THAT THE NOISE WAS NORMAL. WHILE DRIVING AT 55 MPH, THE VEHICLE BEGAN JERKING AND THE TRANSMISSION FAILED WITHOUT WARNING. THE DEALER STATED THAT SOMETHING BECAME LOOSE WITHIN THE TRANSMISSION AND IT NEEDED TO BE REPLACED. FORD STATED THAT THE CONTACT WOULD HAVE TO PAY OUT OF POCKET BECAUSE THE VEHICLE WAS NOT UNDER WARRANTY. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT MILEAGE WAS 67,000 AND FAILURE MILEAGE WAS 8.

TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 40 MPH HE STATED THAT THE GEAR SHIFT INDICATOR DISENGAGED WHEN HE CAME TO A STOP, WHICH CAUSED THE VEHICLE TO JERK HARD. THERE WAS ALSO AN INCREASE IN THE RPM, WHICH CAUSED THE VEHICLE GEAR SHIFT INDICTOR TO ENGAGE WITHOUT WARNING. THE CONTACT STATED THE TRANSMISSIONS SLIPPED OUT OF GEAR WOULD NOT ACCELERATE. THE FAILURE MILEAGE WAS 9,000 AND THE CURRENT MILEAGE WAS 19,000.

UPON ACCELERATION OUR F150 EXCAB MAKES A GRINDING NOISE. ALSO, WOULD NOT DISENGAGE FROM 4HI, HAD TO STOP AND START A FEW TIMES TO GET IT TO DISENGAGE. TALKED TO FORD DEALER HERE AND HE SAID IF THE GRINDING NOISE HAPPENS AGAIN BRING IT IN WHILE IT IS HAPPENING SO A MECHANIC CAN GO FOR A RIDE. THE PROBLEM IS IT IS VERY SPORADIC AND PROBABLY WON'T HAPPEN WHEN THERE IS A MECHANIC IN THE TRUCK. *TR

CLUNKING/OR JEARKING WHEN SLOWING OR ACCELERATION.*AK

2005 F150 SUPERCREW 4X4, TRANSMISSION AT 48000 MILES BEGAN TO MIS-SHIFT INTO OVERDRIVE. WITHIN A FEW DAYS THE TRANSMISSION MISSED ALL SHIFT POINTS AND WENT INTO NEUTRAL. TRANSMISSION WAS REPLACED BY EXTENDED WARRANTY AT DEALERSHIP. NO CAUSE TO FAILURE WAS FOUND. *JB

VEHICLE ROLLED AWAY WITH TRANSMISSION PLACED IN PARK AND KEY REMOVED. INCIDENT HAS HAPPENED 8 TIMES AND DEALER ATTEMPTED REPAIR 4 TIMES, LAST REPAIR IS 17 NOV 2005. UNKNOWN IF IT WILL WORK. *NM

VEHICLE'S TRANSMISSION FAILED AFTER ONLY 18 MONTHS, 38,925 MILES. DEALER UNABLE TO DETERMINE WHY TRANSMISSION FAILED. NO LACK OF FLUID, VEHICLE IS NOT USED TO TOW. COULD ONLY STATE THAT EXCESSIVE HEAT BUILD UP IN TRANSMISSION AND RESULTED IN FAILURE. VEHICLE AND BEEN DRIVEN HOME PRIOR EVENING WITH NO ISSUES, NEXT MORNING FAILED AT START UP. MANUFACTURER WILL NOT WARRANTY DUE TO MILEAGE, REPLACED WITH A REBUILT UNIT AT A COST OF $2,800. *JB

PLEASE HELP A CONSUMER! I QUESTION THE SAFETY AND LONG TERM VALUE OF THE NEW FORD F150 TRUCKS MY NAME IS [XXX] AND I AM WRITING YOU AS A LAST DITCH EFFORT TO INFORM THE PUBLIC ABOUT A PRODUCTION ISSUE WITH THE FORD F150 TRUCKS THAT VIBRATE UNDER NORMAL DRIVING CONDITIONS. ABOUT THREE MONTHS AGO I PURCHASED A NEW F150 AND FROM THAT POINT I HAVE HAD A VIBRATION AND TRANSMISSION ISSUE. FORD HAS NOT BEEN ABLE TO CORRECT IT AND IN THE PROCESS I FOUND THAT THE DEALERSHIP I BOUGHT THE TRUCK FROM FORGED SOME INVOICE DOCUMENTS. I WAS SHOCKED TO FIND THIS PROBLEM ALL OVER THE COUNTRY WHEN I STARTED TO LOOK INTO IT. YOU CAN SEE FOR YOURSELF IF YOU SEARCH GOOGLE FOR TOPICS LIKE "2005 F150 VIBRATION". IF YOU WOULD LIKE, I COULD SEND YOU A LIST OF WEBSITES TO HELP. IN ALL FAIRNESS TO FORD...

THE AUTOMATIC TRANSMISSION IN THE CONSUMER'S 2005 FORD F150 FAILED. *NM

JERKING AND BUMPING NOISE IN DRIVE LINE AT LIGHT ACCELERATION JUST BEFORE OR JUST AFTER TRANSMISSION SHIFTS TO THE NEXT GEAR. DEALER ADDED A GEAR FLUID ADDITIVE THAT THEY SAID WAS LEFT OUT AT FACTORY. THIS DID NOT FIX THE PROBLEM. *NM

POPPING FROM REAR-END AT SLOW SPEEDS AND SHUTTERING AT DOWN SHIFT ON HIGHWAY. LOCAL DEALER SAID REAR PINION GEAR OUT OF ALIGNMENT, AND CLUTCH PACKS WERE BAD THEY HAD TO ORDER PARTS TO FIX THE PROBLEMS. *NM

MY PAINT JOB WAS DEFECTIVE AND THIN, MY WINDSHIELD WAS NOT SEALED PROPERLY, THERE ARE TICKING NOISES FROM UNDER THE DASHBOARD, THE FRONT END IS TOO HEAVY FOR THE ADDED WEIGHT TO THE TRUCK, THE TRANSMISSION STALLS THE TRUCK WHEN IT ROLLS BACKWARDS IN DRIVE, THE TRUCK SHAKES AT HIGH SPEEDS AND HAS EXCESSIVE TIRE WEAR, WHICH IS THE ONLY THING THAT FORD HAS ALL BUT ADMITTED TO BY EXTENDING THE EXCESSIVE TIRE WEAR/RIDE HARSHNESS WARRANTY FROM 1YR/12,000 MILES TO 3YRS/36,000 MILES. HAVE YOU EVER HEARD OF A CAR COMPANY GIVING AWAY SOMETHING UNLESS THERE WAS A SERIOUS PROBLEM WITH THIS VEHICLE. *NM

AUTOMATIC TRANSMISSION ON 2005 FORD 150, GOES INTO NUTERAL WHEN YOU STOP ON A HILL AND WILL ROLL BACKWARDS EVEN THOUGH THE TRUCK IS IN DRIVE OR THE TRUCK WILL ROLL FORWARD EVEN WITH THE TRUCK IN REVERSE. THE TRUCK ALSO GOES INTO NUTERAL WHEN GOING DOWN A HILL AND YOU TAKE YOUR FOOT OFF THE GAS . TRANSMISSION THEN CLUNKS WHEN GOES BACK INTO GEAR. ALSO WHEN TUCK DOWN SHIFTS WHEN GOING UP HILL IT SEEMS TO HIT A DEAD SPACE IN THE TRANSMISSION. WAS TOLD THIS IS ALL NORMAL BY FORD REPS. *NM

I CURRENTLY OWN A 2005 FORD F-150 4X4 SUPERCREW TRUCK AND HAVE STARTED EXPERIENCING SOME GRINDING/ PULLING IN THE TRANSMISSION. I FIRST THOUGHT IT WOULD PROBABLY JUST GO AWAY AND NOW IT JUST GETS WORSE EACH TIME. THE PROBLEM CREATES A RATHER LOUD NOISE AND HAS GREATLY CONCERNED ME. I CONTACTED THE DEALERSHIP WHERE I PURCHASED THE TRUCK, RIVERTOWN FORD/ COLUMBUS,GA, AND I DISCOVERED THAT THIS PROBLEM SEEMS TO BE WIDE SPREAD WITH THE F-150. I AM IN PROCESS OF TRYING TO SOLVE THIS PROBLEM NOW. FORD MOTOR CO. NEEDS TO ISSUE A RECALL FOR THIS ISSUE. *NM

I HAVE A NEW 2005 F150 SUPER CREW 4X4 W/ 5.4L. ESPECIALLY NOTICEABLE IN CITY TRAFFIC, WHENEVER I SLOW DOWN AND THEN ACCELERATE, THERE IS A AT LEAST ONE OR MORE BUMPS OR JERKS SEEMING TO COME FROM THE TRANSMISSION OR DRIVE TRAIN. FORD WON'T DO ANYTHING ABOUT IT. THIS IS TOO MAJOR OF A BUMP TO NOT CAUSE DAMAGE OR PROBLEMS LATER ON. *NM

DT: THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATES THAT THE AUTOMATIC TRANSMISSION IS NOT WORKING PROPERLY. WHILE DRIVING UP A HILL THE VEHICLE WILL ROLL BACK. ALSO, WHEN DRIVING DOWN A HILL THE VEHICLE WILL ROLL BACK AS WELL. IN ADDITION, TRANSMISSION IS MAKING A CLANKING NOISE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOUR TIMES, AND THEY WOULD LIKE TO FIX THE VEHICLE, BUT THEY CONTACTED FORD. THE DEALERSHIP SPOKE WITH THE REGIONAL FORD REPRESENTATIVE, WHO TOLD THEM THIS WAS NORMAL FOR THE VEHICLE ALTHOUGH NONE OF THE OTHER TRUCKS HAD A SIMILAR PROBLEM. THE CONTACT TEST DROVE A 1999 MODEL AND DROVE IT THE SAME PLACES WHERE SHE EXPERIENCED THE PROBLEM ,AND THAT VEHICLE DID NOT EXPERIENCE THE SAME PROBLEM. THE DEALERSHIP WAS GOING TO TEAR THE VEHICLE APART TO SEE WHAT WAS WRONG WITH IT BECAUSE THEY TEST DROVE IT AS WELL AND NOTICED...

I PURCHASED F150 LARIAT FROM LEIF JOHNSON FORD IN AUSTIN OCT 2004. I HAVE BEEN EXPERIENCING TROUBLE WITH THE TRUCK NOT WANTING TO COME OUT OF PARK. YOU CAN PUT YOUR FOOT ON THE BRAKE ALL DAY LONG AND TRY TO PUSH THE BUTTON IN TO MOVE THE GEAR AND NOTHING HAPPENS. I HAVE BEEN TO THE DEALERSHIP 4 TIMES IN THE PAST MONTH TRYING TO RESOLVE THE PROBLEM. LAST FRIDAY 8-05-05 THEY CHANGED OUT THE COMPLETE GEAR SHIFT THINKING THAT WAS THE PROBLEM AND HAVE THE SAME PROBLEM ON THAT SATURDAY 8-06-05 AND AGAIN 8-07-05,8-08-05 IN WHICH I RETURNED TO FORD.*JB

DT: THE CONSUMER STATED 2005 FORD F150 SURGED FORWARD. IT FELT LIKE CRUISE CONTROL KICKED IN. HE TOOK THE VEHICLE TO DEALER, AND DEALERSHIP CALLED FORD, AND THEY HAD THE ACCELERATOR CHIP REALIGNED. AFTER THE VEHICLE WAS FIXED THE SURGING CONTINUED. HE CONTINUED TO CONTACT THE DEALERSHIP AND FORD. ACCORDING TO CUSTOMER SERVICE THE ENGINEERS SAID THEY COULD NOT FIND ANYTHING WRONG WITH IT. CONSUMER WAS CURRENTLY AFRAID TO DRIVE THE VEHICLE, SO WAS SITTING IN THE DRIVEWAY. THE VEHICLE WAS TAKEN IN LAST WEEK, AND THEY KEPT IT FOR A WEEK, AND THEY STATED THEY COULD NOT FIND ANYTHING WRONG WITH IT. ON THE WAY HOME TRANSMISSION SLIPPED AND SURGED FORWARD. DEALERSHIP AND THE MANUFACTURER KEPT TELLING HIM TO CALL THE OTHER. CONSUMER STATED VEHICLE HAS BEEN AT DEALERSHIP AT LEAST FIVE TIMES, AND GOT A DIFFERENT SERVICE MANAGER EVERY TIME. THE PROBLEM STARTED THE NIGHT HE PURCHASED THE...

I HAVE A 2003 F-150 WITH A 5.4 ENGINE. THERE IS SLACK IN THE TRANSMISSION AROUND THE TORQUE CONVERTER. WHWNEVER YOU SLOW DOWN THE GENTLY BUMP THE ACCELERATOR YOU HEAR A BUMPING NOISE. IS THIS NORMAL