2005 FORD F-150 Electrical System Problems

My electrical fixtures have failed or blinks off and on, on its own.

Pulled out of driveway and made it 50 feet and whole truck shut down right on the road. Could not make the vehical restart no click or anything dead right where it stopped. Could of caused an accident. Had to have truck taken to a shop they took a week to find out that the electrical fuel system harness had a dead short in it. So no fuel going to the feul injectors or to the key to start the vehical. Still have head lights and breaks and radio. Just no way to restart the vehical. They checked thw wires and after unplugging many wires to the fuel system and retesting it started. Left with the truck a day later the same thing happen but this time i had to jump a curb to avoid an accident and coasted into a parking lot. I got out and wiggled a few...

I BOUGHT USED CASH TRUCK, DROVE FINE FOR FIRST DAY, SECOND DAY WHILE TRUCK WAS IN MOTION AND PUT IN REVERSE IT DIES, TOOK A COUPLE TURNS TO STARTED UP AND IT STARTED CODING THE CAMSAFT SENSORS, GOT CODES CLEARED, AND IT DROVE OK FOR 30 MINUTES COATED AGAIN STARTED TO STALL AND STUTTER A BIT. I HEARD A LOT ABOUT FORDS IN THE CAMSHAFT SENSORS DOES THAT MEAN MY TRUCK IS DONE FOR. MY TRUCK HAS TO CAMSHAFT SENSORS. 5.4

ON DECEMBER 3, 2020 AT APPROXIMATELY 11:30 PM OUR 2005 F150 BURST INTO BLAMES FROM THE ENGINE AREA. THE VEHICLE HAD BEEN PARKED SINCE APPROXIMATELY 3:30 PM EARLIER THAT DAY IN OUR PERSONALLY DRIVE WAY. WITNESS STATED THAT THEY SAW THE FIRE START NEAR THE ENGINE AREA OF THE TRUCK.

JUST PURCHASED VEHICLE AIR BAG LIGHT FLASHES AND TURNS ON WHEN DRIVING LOOKED INTO ISSUE. FOUND RECALL FOR AIRBAG THAT CAUSES THIS. RECALL 11S18B. CONTACTED FORD THEY SAID RECALL HAD NOT BEEN PERFORMED AND SET UP APPOINTMENT TO HAVE IT DONE. FORD COMPLETED RECALL. PICKED UP VEHICLE DROVE 1000 FEET AIRBAG LIGHT CAME BACK ON. TURNED AROUND AND INFORMED SERVICE DEPARTMENT. THEY TOLD ME THE RECALL HAS NOTHING TO SO WITH THE AIRBAG OR LIGHT AND THAT IF I PAY 100 THEY WILL DIAGNOSE VEHICLE. I INFORMED THEM THAT IT SHOWS RIGHT ON FOR THAT THE RECALL CAUSES LIGHT TO FLASH AND POSSIBLY AIRBAG TO DEPLOY. THEY TOLD ME IT DOES NOT AND I WAS WRONG AND SENT ME ON MY WAY

THE BRAKE WARNING LITE REMAINS ON. I'M TOLD BY MY MECHANIC THAT IT IS DUE TO A BROKEN CONNECTION IN THE DASH BOARD CIRCUIT BOARD AND HE SAID IT IS A RELATIVELY COMMON FAULT. REPAIR REQUIRES REMOVING THE ENTIRE DASH BOARD AND REPLACEMENT OF THE CIRCUIT BOARD.

HAVE OWNED THIS TRUCK BOUGHT NEW, 2005. HAVE USED SPARINGLY ONLY 15K + MILES. OVER THE YEARS I HAVE EXPERIANCED A NUMBER OF OCCASIONS WHEN IT TRIED TO ACCELLERATE WHEN I WENT TO BRAKE. FIRST THOUGHT IT A QUIRK OR FLOOR MATS. RECENTLY NEARLY TRASHED A PARKED CAR WHILE BACKING ITO A PARKING SPACE. CONTINUED TO ACCELLERATE DISPITE STANDING ON BRAKE. THERE IS NO LONGER ANY DOUBT THAT THIS IS A PROBLEM WITH SUA, SUDDEN UNINTENDED ACCELLERATION, THAT FORD HAS NEVER ADMITTED. I HAVE MADE SURE I AM OFF THE GAS PEDAL AND THE FLOOR MAT HAS BEEN REMOVED. THIS HAPPENS WHEN THE VEHICLE IS MOVING AND WHEN TRYING TO BRAKE!

MY 2005 FORD F150 TRUCK HAS HAD SO MANY PROBLEMS & SOME REPLACE TWICE & IM OVER IT IM ABOUT TO HAVE A HEART ATTACK NOW IT SOUNDS LIKE MY ACULATOR AGAIN WITH THE SOUND OF METAL SCRAPING ON THE GROUND AND WHEN I SWITCH IT TO 44 THE SOUNDS STOPS .BUT IF ITS NOT IN 44 THE SOUND STAYS AND IT IS LOUD ! I HAVE SPENT SO MUCH GET MY TRUCK FIXED AND WHAT UPSETS ME IS I TAKE CARE OF MY TRUCK CHANGE OIL SPARK PLUGS EVERYTHING SINCE PURCHASED IN 2005 BRAND NEW AND IM OVER IT SOMETHING NEEDS TO DONE WITH ALL THESE PARTS DEFECTED AND IT WILL CONTINUE UNTIL SOMETHING IS DONE.

PURCHASED FORD F150 FROM OLD SAYBROOK FORD, FEB. 16. THE TRUCK HAS THE 5.4 ENGINE WHICH HAS NUMEROUS COMPLAINTS OF ENGINE FAILURE. DRIVING ON ROUTE 1 WHEN TRUCK ECCELORATES OR LOSES POWER. WHEN WE BOUGHT THE TRUCK THE CHAIN GUIDE WAS BROKE AND EATING THROUGH THE CASE. SPARK PLUGS GET STUCK IN ENGINE OR PROPEL THEM SELVES THROUGH THE TRUCK HOOD. DANGEROUS ENGINE TO HAVE ON ROAD. I OWE 8000.00 ON A TRUCK THAT NOW NEEDS 4-6000 WORTH OF WORK.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING, THE VEHICLE IDLED WITHOUT WARNING. THE CONTACT HAD TO PULL THE VEHICLE OVER TO RESTART IT, BUT IT CONTINUED TO IDLE. THE MAINTENANCE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE DEALER WAS NOT NOTIFIED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THERE WAS NO RECALL ASSOCIATED WITH THE VIN. THE APPROXIMATE FAILURE MILEAGE WAS 98,778.

VEHICLE WENT INTO "FAILSAFE" MODE ON TWO SEPARATE OCCASIONS WITHIN THE LAST YEAR! AND MOST RECENTLY, TWO WEEKS AGO! BOTH AT HIGHWAY SPEED ON TWO DIFFERENT INTERSTATES IN FLORIDA! VERY DANGEROUS, AND HARD TO CONTROL VEHICLE TO "LIMP" TO A SAFE PLACE TO STOP! MANY POSSIBLE CAUSES FROM ELECTRICAL, FUEL, OR ENGINE ISSUES THAT ARE WELL DOCUMENTED ON MANY INTERNET SITES AND F150 FORUMS! ALSO RUST ISSUES ON ROOF OF VEHICLE IN RAIN CHANNELS! VERY COMMON,AND VERY POOR DESIGN!

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE AT 65 MPH, THE VEHICLE BEGAN STALLING INTIMITTENTLY THEN THE ENGINE AND MAINTANENENCE WARNING LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO A MECHANIC WHERE IT WAS DIAGNOSED THAT THE AIR FILTER WAS OUTDATED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 108,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 40 MPH, THE DRIVER SIDE AIR BAG LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

FUSE 14 CONTROLLING ABS MODULE, DTR SENSOR, REVERSE LIGHTS, PCV HEATER, AIR CONDITIONER COMPRESSOR, CRUISE CONTROL DEACTIVATOR SWITCH AND DAYTIME HEADLIGHTS WAS REPEATEDLY BLOWING. TRUCK WAS SERVICED BY DEALER ON 3-23-16, REPLACING THE A/C COMPRESSOR. REPLACING THE A/C COMPRESSOR DID NOT RESOLVE ANY ISSUES. THE TRUCK WAS RETURNED TO THE DEALER ON 4-6-16 FOR THE SAME ISSUE WITH THE SAME FUSE. THE DEALERSHIP REPLACED THE FUSE AND PERFORMED DIAGNOSTIC TESTS ON THE TRUCK, THEN INFORMING ME THAT THEY COULD NOT DIAGNOSE OR LOCATE THE SHORT. THE DEALERSHIP INFORMED ME THAT I WOULD HAVE TO DRIVE THE TRUCK UNTIL THE FUSE STARTED BLOWING MORE FREQUENTLY. THE FIRST TIME THE TRUCK WAS DRIVEN AFTER WORK WAS PERFORMED THE CRUISE CONTROL WAS NOT FUNCTIONING PROPERLY. THE TRUCK ENGINE WOULD SURGE AS THE TRUCK WENT DOWN THE ROAD WITH THE CRUISE CONTROL ON. THE ISSUE WITH THE CRUISE CONTROL HAPPENED ON 4-9-16. ON THE...

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AND MAKING A RIGHT TURN, THE VEHICLE LOST POWER AND STALLED. THE CONTACT HEARD A BEEP SOUND PRIOR TO THE FAILURE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DUPLICATE THE FAILURE OR RETRIEVE A FAULT CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

A NUMBER OF WIRES LEADING FROM THE BODY INTO THE DRIVER'S SIDE DOOR HAVE BEEN CUT/WORN POSSIBLY DUE TO CONTACT WITH THE INSIDE OF THE DOOR. THE RUBBER AND PLASTIC PARTS MEANT TO PROTECT THE WIRES WERE ALSO CUT/WORN. THIS HAS LED TO COMPLETE FAILURE OF ALL ELECTRONICS IN THE DOOR INCLUDING POWER LOCK, POWER WINDOWS, AUTOMATIC SHUTOFF OF RADIO, DOOR CHIME, KEYPAD, AND MIRRORS. DISCUSSION WITH FORD DEALER INDICATED THAT THEY HAVE SEEN THIS PROBLEM IN THE PAST.

ON THE MORNING OF MARCH 5TH 2015 I STARTED MY TRUCK TO WARM THE INSIDE AND ALSO MELT THE SNOW OFF MY WINDSHIELD. I GOT IN THE TRUCK AND BACKED OUT AWAY FROM HOUSE. DUE TO HAVING SNOW ON THE DRIVEWAY I TURNED ON THE 4 WHEEL DRIVE IN HIGH. MY FOUR WHEEL DRIVE WOULD NOT WORK SO I TRIED TO SWICTH TO 2 WHEEL DRIVE BACK TO FOUR WHEEL DRIVE BUT THE 4 WHEEL DRIVE WOULD NOT TURN ON. I GRABBED THE GEAR SHIFT TO PUT THE TRUCK BACK IN PARK WHEN I NOTICED MY GEAR SHIFT COULD FLOAT TO PARK TO 1ST GEAR FREELY AND WOULD NOT SHIFT. AT THIS TIME I NOTICED SMOKE STARTING TO COME INSIDE CAB FROM UNDER DASH AND THRU THE VENTS. I JUMPED OUT AND OPENED THE HOOD. A 1 FOOT SECTION OF A WIRING HARNES MOUNTED TO THE FIREWALL HAD CAUGHT FIRE....

I STARTED THE TRUCK AND THEN TURNED ON THE REAR DEFROST, WHICH I RARELY USE. IT WAS ABOUT 55 DEGREES OUTSIDE. AFTER ABOUT 2 MINUTES I HEARD A HISSING NOISE THAT LASTED FOR ABOUT 5 SECONDS AND THEN A HEARD LOUD POP AND THEN THE WINDSHIELD SHATTERED. MANY OTHER ARTICLES ON THE WEB INDICATE THAT THIS IS A KNOWN DEFECT WITH THE REAR DEFROST. I CALLED FORD AND THEY WILL NOT OFFER AND COMPENSATION TO HAVE IT FIXED EVEN THOUGH IT IS A KNOWN ISSUE. MY DAUGHTER WAS IN THE BACK SEAT AND GOT GLASS IN HER HAIR. *TR

WE HAVE HAD OUR 2005 F-150 KING RANCH FOR ABOUT 10 YEARS NOW. TODAY (FEB 10,2015), MY WIFE AND OUR ONE YEAR BABE WERE HEADING TO THE POST OFFICE THE TRUCK DISPLAYED A MESSAGE READING "ENGINE FAILSAFE MODE". THE TRUCK LOST ALL POWER, NO STEERING, AND IT STALL ON THE HIGHWAY GOING ABOUT 65 MPH. LUCKILY, SHE SAID THERE WERE VEHICLES BEHIND HER AND SHE PULLED IT OVER WITH NO STEERING AND THE ENGINE DEAD. MY WIFE THEN SAT ON THE HIGHWAY FOR ABOUT 10 MINUTES AND TRIED TO START THE VEHICLE, WHICH STARTED AND THERE WERE NO "ENGINE FAILSAFE MODE" ON DISPLAY ANYMORE. KNOW WITH-IN THE LAST YEAR OUR TRUCK HAS HAD THE CHECK ENGINE LIGHT AND THE ABS LIGHT HAS COME ON AND OFF EVERY OTHER MONTH. I HAVE CHECKED THE FUSES AND HAD REPLACE A FEW BUT AT TIME IT IS NOT THE FUSE. I'VE HAD THE...

2005 F150 GOES INTO "FAIL SAFE MODE" AND SHUTS DOWN WHILE DRIVING. IT ONLY OCCURRED ONCE PER YEAR STARTING AT 65,000 MILES, BUT NOW HAPPENS EVERY 3-4 WEEKS AT 114,000 MILES. ONCE THE ENGINE SHUTS DOWN, I PUT THE TRANSMISSION INTO NEUTRAL WHILE COASTING AND IT RESTARTS EASILY. THE ENGINE LIGHT ILLUMINATES FOR 3-4 DAYS AND THEN TURNS OFF. IN RESEARCHING THE ISSUE, IT SEEMS TO BE A RATHER COMMON PROBLEM WITH THIS VEHICLE AND IS USUALLY CAUSED BY A FAULTY THROTTLE BODY. FORD STATES THAT THEY ARE AWARE OF THE PROBLEM. *TR

AFTER THE RECALL TO PREVENT A SHORT BETWEEN HORN AND AIR BAG WAS COMPLETED IN 2011 A SHORT TIME THEREAFTER IN THE MIDDLE OF THE NIGHT THE HORN CAME ON BY ITSELF IN THE LOCKED VEHICLE WITH NO ONE IN IT. AFTER TRYING EVERYTHING I COULD THINK OF LIKE STARTING THE ENGINE AND PUSHING THE HORN BUTTON NUMEROUS TIMES. I WAS ABOUT READY TO DISCONNECT THE BATTERY WHEN IN ANGER I HIT THE CENTER OF THE STEERING WHEEL VERY HARD WITH MY HAND AND THE HORN STOPPED BLOWING. FROM THAT DAY ON THE AIRBAG WARNING LIGHT STAYS ON WHEN THE ENGINE RUNS. AND THE HORN BLOWS HALF AS LOUD AS IT ORIGINALLY DID WHEN ACTIVATED. FORD SAYS ITS MY PROBLEM BECAUSE THE RECALL WAS ALREADY COMPLETED. ONLY PROBLEM HERE IS THAT THEIR WAS NO PROBLEM AT ALL UNTIL AFTER THE RECALL WORK. *TR

OVER THE PAST 5 YEARS I HAVE HAD MY TRUCK GO INTO FAIL SAFE MODE. MY TRUCK WILL FLASH FAIL SAFE AND I WILL LOSE ALL POWER TO THE VEHICLE. I'M ABLE TO COAST TO A STOP. I HAVE BEEN ABLE TO RE START MY VEHICLE AND CONTINUE DRIVING. *TR

2005 FORD F-150. CONSUMER WRITES IN REGARDS TO SPARK PLUGS AND COILS PROBLEM. *SMD THE CONSUMER STATED THE VEHICLE STALLED, UPON ACCELERATION. THE CONSUMER ALSO STATED THE CHECK ENGINE LIGHT ILLUMINATED AND FLASHED WHEN A SPARK PLUS MISFIRED. *JB

2005 FORD F-150. CONSUMER WRITES IN REGARDS TO ENGINE FAIL SAFE MODE MALFUNCTIONS CAUSES VEHICLE TO LOSE ALL POWER, BRAKES AND STEERING. CONSUMER HAS DIFFERENT VEHICLE COMPLAINT IN ARTEMIS. *SMD THE DEALER INVESTIGATED THE COMPLAINT, BUT WAS UNABLE TO IDENTIFY THE CAUSE. *JB

I STARTED THE TRUCK AND THE ALL THE INITIAL BEFORE ENGINE STARTS LIGHTS CAME ON, TACHOMETER WENT TO ZERO AND THERE WAS A WARNING BUZZER. I RAPPED THE TOP OF THE DASH AFTER TRYING THREE RESTARTS WHERE NOTHING CHANGED. THE TRUCK NORMALIZED AND I DROVE IT. I DO NOT OFTEN DRIVE THE TRUCK, SO ABOUT THREE WEEKS LATER I WAS HEADED TO PENNSYLVANIA AND WAS ABOUT TO ENTER THE HRBT TUNNEL WHEN THE INSTRUMENT CLUSTER WENT TO KEY ON STATUS (NO TACHOMETER OR SPEEDOMETER FUNCTION, MULTITUDE OF WARNING LIGHTS AND WARNING BUZZER). SO AT 55MPH I HIT THE TOP OF THE DASH AND THE INSTRUMENT CLUSTER BRIEFLY CAME BACK ON THEN SHUT OFF AGAIN. I REPEATED THE BLOW ON THE TOP OF THE DASH AND THE PROBLEM WENT AWAY FOR ABOUT FIVE HOURS AND THEN CAME BACK AGAIN. IT'S QUITE DISCONCERTING TO HAVE THE SPEEDOMETER SHUT DOWN WHILE DRIVING AND...

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHENEVER HE CAME TO STOP, THE GEARS WOULD ENGAGE INDEPENDENTLY AND MAKE A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES WHERE THE TECHNICIAN DIAGNOSED THAT THE ALTERNATOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE CONTACT MENTIONED THAT HE HAD TO REPLACE THE ALTERNATOR A TOTAL OF FOUR TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 175,000 AND THE CURRENT MILEAGE WAS 190,000.

DASH ELECTRICAL RELAY ISSUE,PAINT PEELING TAILGATE,TRANSMISSION SHUTTER GOING INTO OVERDRIVE 45 MPH. *TR

I PURCHASES A USED 2005 FORD F150 ABOUT 5 MONTHS AGO. TODAY, FEB 28, 2014, I WAS LEAVING MY NEIGHBORHOOD AND MY TRUCKS DISPLAY FLASHED AN MESSAGE READING "ENGINE FAILSAFE MODE". MY TRUCK LOST ALL POWER, NO STEERING AND DIED. LUCKILY I WAS ON SURFACE STREETS AND PULLED IT OVER WITH NO POWER STEERING AND ENGINE DEAD. THE MECHANICS CANNOT FIND THE CAUSE AND THE ENGINE WILL START BUT CONTINUES TO TURN OFF AND THE VEHICLE'S COMPUTER SHUTS DOWN. ONLINE I READ OF THIS HAPPENING ON THE FREEWAY AT 65 MPH. IAM NOW TERRIFIED THAT MY TRUCK WILL SHUT OFF ON THE FREEWAY WITH MY CHILDREN IN THE TRUCK WITH ME. THIS SEEMS TO BE A LIFE THREATENING PROBLEM. I CALLED A FORD DEALERSHIP AND THE SERVICE DEPT CLAIMED THEY NEVER HEARD OF THIS BUT CAN WORK ON IT IF I BRING IT IN. WHAT IS MY RECOURSE? THANK YOU....

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, ALL OF THE GAUGES AND LIGHTS ON THE INSTRUMENT PANEL BEGAN TO MALFUNCTION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 83,490.

OK SO WE BOUGHT A FORD F150 2005 ON FRIDAY OF LAST WEEK WHICH WOULD BE 08/09/2013 . THE MAN ASSURED US THIS WAS A SAFE AND RELIABLE VEHICLE. SO WE START OUR TRIP ACROSS THE COUNTRY TO LOOK AT A NEW HOUSE IN EASTERN NORTH CAROLINA. WE STOPPED IN ARIZONA TO SEE MY GIRLFRIENDS MOM. SUR ENOUGH THE TRUCK WOULD NOT START THE NEXT DAY. WE TAKE IT TO A MECHANIC AND HE SAYS ITS THE FUEL PUMP SO HE CHANGES IT OUT WE DRIVE IT 2 BLOCKS DOWN THE STREET BACK TO HER PARENTS HOUSE TURN OFF THE TRUCK LOAD IT UP WITH OUR STUFF AND IT WILL NOT START AGAIN. SO THE MECHANIC COMES BACK OVER SAYS OK IT MUST BE THE FUEL MODULATOR. SO HE CHANGES OUT THE FUEL MODULATOR AND SURE ENOUGH IT WORKED WE DROVE IT TWO BLOCKS TURNED IT OFF, RELOADED THE TRUCK...

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE STALLED. THE CONTACT STATED THAT HE REPLACED THE BATTERY PRIOR TO THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 77,000. *TR

REAR PASSENGER WINDOW REGULATOR STOPPED WORKING AND WINDOW FELL INTO DOOR. HAD MY DAUGHTER DONE THIS WHILE DRIVING SHE WOULD HAVE BEEN SCARED BY THE LOUD POPPING NOISE AND POTENTIALLY CRASHED INTO OBJECT INJURING HERSELF AND OR OTHERS. THIS IS A COMMON PROBLEM AND FORD NEEDS TO RECALL THE TRUCKS WITH THE PLASTIC PARTS AND FALTY MECHANISM. SEARCH THE WEB AND THERE ARE HUNDREDS OF VEHICLES WITH THE SAME ISSUE . YEARS 2004-2006. FORD NEEDS TO RECALL!! *TR

WHEN VEHICLE'S ENGINE IS COLD, AND APPROXIMATELY 8 MINUTES INTO DRIVING, VEHICLE WILL CUT OFF WHILE IN MOTION & WRENCH LIGHT COMES ON. VEHICLE THEN HAS TO BE GUIDED TO A STOP WITH NO POWER OR CAN BE SHIFTED INTO NEUTRAL & RESTARTED WHILE STILL MOVING. FOLLOWING VEHICLE RESTART ENGINE LIGHT IS ON. CODE INDICATES TRUCK HAS BEEN PLACED IN "LIMP HOME MODE". AFTER ABOUT 2 WEEKS, ENGINE LIGHT GOES OFF. I WAS ADVISED TO REPLACE THE THROTTLE BODY IN FEB. 2010, HOWEVER THE THROTTLE BODY HAD JUST BEEN REPLACED IN APRIL 2007 WHEN THE VEHICLE WAS ONLY 2 YEARS OLD. *TR

MY FUEL CONTROL MODULE SHORTED OUT WHICH CAUSED MY PCM TO BE ERASED. IT SEEMS TO BE A COMMON PROBLEM AFTER RESEARCHING IT, BUT NO RECALL HAS BEEN ISSUED. MY PREGNANT WIFE WAS DRIVING MY TRUCK AND LOST ALL POWER. THIS RESULTED IN A NEAR ACCIDENT DUE TO HAVING NO POWER STEERING AND LESS BRAKE CONTROL. IF THIS IS SUCH A COMMON PROBLEM WITH THE PLACEMENT OF THE CONTROL MODULE WHY HAS THIS NOT BEEN RECALLED. $1000 LATER I HOPE THIS DOESN'T HAPPEN AGAIN. *TR

THE TRUCK HAS BEEN BACK TO FORD MANY TIMES FOR DRAINING THE BATTERY. IF IT IS PARKED FOR 2 TO 3 DAYS I WOULD HAVE TO JUMP START IT. THE DEALERS COULD NOT FIND THE PROBLEM AND KEEP REPLACING THE BATTERY. AFTER IT WAS OUT OF WARRANTY PAID OUT OF MY OWN POCKET TO FIND THE PROBLEM STILL COULD NOT FIND. I HAVE A VIDEO OF THE TRUCK IN12/11 OF THE HEATER/DEFROSTER RUNNING AFTER THE TRUCK WAS PARKED FOR 3 HOURS WITH NO KEYS IN THE TRUCK. ON 5/16/2012 THE TRUCK WAS PARKED IN MY DRIVEWAY AND CAUGHT FIRE UNDER THE DASH. *TR

FORD FACTORY SPARK PLUG BREAKS WITHIN THE HEAD CAUSING POTENTIAL INTERNAL ENGINE DAMAGE. AN EXTREMELY COMMON ISSUE THAT HAS LEAD TO THE INVENTION OF A SPECIAL TOOL USED JUST BECAUSE F THE ISSUE. COMMONLY REACHING HUNDREDS AND EVEN THOUSANDS OF DOLLARS TO REPAIR. FORD HAS CHANGED THEIR TSB FROM CHANGING PLUGS AT 100K MILES TO 60K MILES. HOWEVER BY THE TIME A ISSUE WAS NOTICED MANY OF US OWNERS HAVE OVER THE 60K MILE MARK. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, A LOUD POP NOISE WAS HEARD AND THE VEHICLE ERUPTED INTO FLAMES. THE VEHICLE CAUSED EXTENSIVE DAMAGE TO A COMMERCIAL BUILDING IN WHICH IT WAS PARKED NEAR. THE POLICE WERE CONTACTED AND A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT DID NOT DETERMINE THE CAUSE OF THE FIRE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000. UPDATED 03/28/12 *BF UPDATED 03/30/12

MY FUEL PUMP MODULE SHORTED OUT. IT HAD BECOME CORRODED. THERE WAS A MELTING OF PLASTIC PARTS IN THE MODULE. I COULD SMELL THE PLASTIC BURNING BEFORE THE UNIT FAILED. THE TRUCK WAS RUNNING FINE AND THEN SUDDENLY DIED WHEN THE MODULE FAILED. FORTUNATELY, I WAS DRIVING THROUGH A SMALL TOWN WHEN THIS HAPPENED. IF IT WOULD HAVE HAPPENED ON THE HIGHWAY IT COULD HAVE BEEN A VERY DANGEROUS SITUATION. I FEEL FORD SHOULD BE PERFORMING A RECALL ON THESE MODULES. IT'S A VERY POOR DESIGN. I ALSO FEEL THAT THE TRUCK OWNERS SHOULD BE COMPENSATED FOR THE REPAIRS THAT HAVE ALREADY BEEN DONE. *TR

I JUST BOUGHT THIS VECHILE WITH IN THE PAST 2 WEEKS AND THE WINDOW ON THE DRIVER SIDE, MADE A LOUD GRINDING SOUND .....THEN A LOUD BANG AS THE WINDOW FELL DOWN IN THE DOOR! I'M VERY LUCKY THAT I DID NOT TOTAL MY VECHILE AS I WAS PULLING INTO MAIN TRAFFIC ON A BUSY ROAD THAT I LIVE ON! THIS WAS MY DADS OLD VECHILE AND HE HAD THE SAME PROBLEM WITH THE PASSENGER SIDE.....NOT TO LONG AGO! ALSO HAVE BEEN DOING SOME DIGGING ON THIS ISSUE AND I SEE THAT QUITE A FEW OTHER PEOPLE HAVE BEEN GOING THROUGHT THE SAME PROBLEM AS WELL! JUST MAKING FIRST FEW PAYMENTS AND BOOM!!!! THERE GO'S A BUNCH OF MONEY ON A SAFETY PART THAT REALLY NEEDS FIXED! FORD .........WAKE UP AND FIX THIS ISSUE ALREADY!!! *TR

WHILE DRIVING OUR TRUCK THE DRIVER SIDE WINDOW SLOWLY LOWERED ITSELF AND WOULD NOT RAISE UP. THIS WAS APPROXIMATELY 2 YEARS AGO. YESTERDAY, SEPTEMBER 25, 2011 ABOUT 2PM, THE PASSENGER SIDE WINDOW WENT DOWN ON ITS OWN AND WOULD NOT RAISE UP. I TURNED OFF THE HWY I WAS ON AND LUCKILY AVOIDED A WRECK. TODAY SEPT. 29, 2011, I CALLED FORD MOTOR COMPANY, TOLD THEM ABOUT THE WINDOW AND THE PREVIOUS WINDOW BEING FIXED, GAVE THEM MY VIN#, NAME, TELEPHONE# AND WAS TOLD THERE ARE NO RECALL'S AND THEY ARE NOT AWARE OF ANY PROBLEMS AND CANNOT HELP US FINANCIALLY WITH THIS PROBLEM. I TOLD THEM, I WAS FILLING A COMPLAINT WITH THEM AND NOTIFYING YOU. *TR

THE TRUCK WAS NOT RUNNING. WHEN THE DOOR WAS OPENED THE FLAMES , FROM THE BURNING SEAT SHOT UP AND BURNT THE CARPET AND DOOR PANEL , BEFORE IT COULD BE PUT OUT. THE CONTROLS ON THE SEAT WERE COMPLETELY MELTED. IT STILL HAS A SMELL OF AN ELECTRICAL FIRE. *TT

VEHICLE STALLS OUT COMPLETELY WHEN COMING TO A STOP AND AT HIGHWAY SPEED. VEHICLE GOES INTO FAIL SAFE MODE. VERY HARD TO CONTROL VEHICLE. VEHICLE CAN BE RESTARTED ONCE PUT IN PARK AND SHUT OFF.

WHILE DRIVING VEHICLE AT ANY SPEED FROM 10 MPH TO 70 MPH THE TRUCK WILL GO INTO SAFE MODE (LIMP-HOME MODE) GOING DOWN TO 5 MPH AND LOSING ALL POWER STEERING. WHEN DIAGNOSED IT IS THE THROTTLE BODY CONTROL TO ME THIS IS A SAFETY ISSUE WHAT HAPPENS IF I AM DRIVING 70 MPH ON THE HIGHWAY AND IT GOES INTO SAFETY MODE AND I LOSE ALL POWER STEERING. DOES SOMEONE HAVE TO DIE BEFORE THERE IS A RECALL ON THIS??? IT WILL COST ME AROUND $1000.00 TO FIX PER BRONDES FORD IN TOLEDO OHIO AND I AM TOLD FORD HAS 2 OR 3 VEHICLES A WEEK COME IN FOR THE SAME PROBLEM. TO ME THIS IS NOT STANDARD MAINTENANCE.

TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE ENGINE FAIL SAFE LIGHT ILLUMINATED AND THE VEHICLE SUDDENLY STOPPED ON A RAILROAD TRACK. THE CONTACT STATED THAT THE FAILURE ALSMOST CAUSED A CRASH. THE VEHICLE WOULD NOT MOVE ALTHOUGH THE ENGINE WAS STILL RUNNING. THE FAILURE COULD NOT BE DIAGNOSED BY THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 46,000.

TL*THE CONTACT OWNS A 2005 FORD F-150. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH AND ATTEMPTING TO SLOW DOWN, THE VEHICLE SUDDENLY ACCELERATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED THAT UPDATES NEEDED TO BE MADE TO THE COMPUTER. THE UPDATES WERE MADE BUT THE FAILURE CONTINUED. THE FAILURE MILEAGE WAS APPROXIMATELY 69,000.

"ELECTRONIC THROTTLE CONTROL" FAILURE CAUSES THE ENGINE TO LOSE ALL POWER, POWER STEERING IS INOPERABLE AND VEHICLE MUST BE STOPPED, IGNITION TURNED OFF AND ON AGAIN BEFORE VEHICLE IS ABLE TO PROCEED. THIS HAS HAPPENED ON 4 OCCASIONS IN THE PAST YEAR WITH NO WARNING. THIS DEFECT POSES A SERIOUSLY DANGEROUS SITUATION, ESPECIALLY AT HIGHWAY SPEEDS, AS THE OPERATOR HAS NO CONTROL OVER THE VEHICLE UNTIL ABLE TO PULL TO THE SIDE, TURN IGNITION OFF AND THEN RESTART THE ENGINE. FORD SERVICE SAYS THEY ARE UNAWARE OF THIS PROBLEM BUT, IT IS REPORTED NUMEROUS TIMES IN FORUMS ON FORD VEHICLE SAFETY AS A $500-$600 REPAIR. THIS DOESN'T SEEM LIKE A NORMAL WEAR & TEAR ISSUE BUT RATHER A FACTORY DEFECT THAT FORD SHOULD ADDRESS BEFORE SOMEONE IS INJURED?

DRIVER SIDE POWER WINDOW IS HAVING ISSUES ROLLING UP. WILL ROLL DOWN FINE, BUT WHEN I GO TO ROLL IT UP, GETS STUCK HALFWAY THROUGH. I HAVE TO GRAB TOP OF THE WINDOW TO FORCE IT BACK ALL THE WAY UP. I HAD THIS PROBLEM 2 YEARS AGO WHEN TRUCK WAS UNDER WARRANTY AND DEALER REPLACED FREE OF CHARGE. NOW I'M ALREADY HAVING THE SAME ISSUE ONLY 2 YEARS LATER- I READ A TON OF POSTS ON THE WEB AND IT LOOKS LIKE THIS IS AN ONGOING PROBLEM WITH FORDS AND SHOULD BE SOMETHING THAT SHOULD BE RECALLED. THERE ARE REPORTS OF WINDOWS SHATTERING ON THE HIGHWAY FOR BEING ONLY ROLLED UP HALFWAY WHEN THE WINDOW WOULD NOT ROLL UP- ALSO WHAT IF I GET STUCK IN A BAD PART OF TOWN, LIKE COMPTON, CA AND MY WINDOW WON'T ROLL UP? *TR

MY 2005 FORD F150 PICK-UP DRIVERS SIDE WINDOW MADE A LOUD BANG WHEN I WENT TO ROLL IT UP. I WAS DRIVING WHEN THIS HAPPENED AND WAS VERY STARTLED, ALMOST HITTING THE CAR NEXT TO ME. I LOOKED FOR A WEBSITE TO FIX IT AND FOUND THEY HAVE SEVERAL ISSUES WITH THEIR ELECTRIC WINDOWS. ADD ONE MORE. *TR

7 OF 8 SPARK PLUGS BROKE OFF WHILE CHANGING OUT ON MY VEHICAL THIS IS CRAZY HEARD ALOT OF COMPLAINTS. *TR

I HAVE A 2005 FORD F150 TRUCK. THE END OF DECEMBER 2009 THE DRIVER'S SIDE WINDOW FELL DOWN. IT STARTED WITH THE ELECTRIC WINDOW BUTTON STICKING AND ENDED UP ALL OF A SUDDEN FALLING DOWN. THE FORD MECHANICS SAID THIS IS NOT UNUSUAL AND COULD HAPPEN TO ALL 4 WINDOWS. THIS IS NOT A COVERED SERVICE FOR REPAIR.*CW