2004 FORD F-150 Structurebody Problems

The underbody frame is 95% rusted out, this vehicle is available for inspection upon request. I could have been fatally injured, not knowing the under frame was gone, until vehicle was taken in for new tires. The vehicle was inspected by Firestone tire and Gene Butman Ford. There were no warning messages and the problem was first noticed in 2019 and was told the vehicle was unsafe to drive, a hazard and should not be driven.

The truck has had a complete body frame failure. The entire frame is rusted through with large holes. I am unable to put it on a jack to change the tires. It has failed inspections and has not been inspected since 2019. I have a 1992 ford truck that has NO rust issue on the frame. This year is a complete design failure where they used substandard steel or other garbage. It is a safety hazard.

Hitch broke off due to ford common frame rot. Frame is rotted from leaf spring shackle and back

THE FRAME IS ROTTED COMPLETELY. IT IS A SAFETY ISSUE THAT WHEN DISCOVERED AND SEARCHED SEEMS TO A HUGE ISSUE. I WAS ADVISED NOT TO DRIVE THE VEHICLE AS IT NOT SAFE TO DRIVE. I BOUGHT THIS TWO DAYS AGO.

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED WHILE ROUTINE MAINTENANCE WAS BEING PERFORMED ON THE VEHICLE, THE CONTACT DISCOVERED THAT THE SUBFRAME WAS EXTREMELY CORRODED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 167,000.

PAINT CRACKED ,COILS MALFUNCTION,SPRINGS FRONT

THIS VEHICLE IS OTHERWISE IN GOOD CONDITION WITH VERY LITTLE BODY RUST LIMITED TO THE BACK CORNER OF THE PASSENGER CABIN. HOWEVER THE LEFT FRAME RAIL STARTING 14 INCHES AHEAD OF THE FRONT ATTACHMENT POINT OF THE LEAF SPRING. THE RUST HOLE EXTENDS THE WIDTH OF THE FRAME RAIL FOR A DISTANCE OF 17 INCHES. ONE FINGER SIZE HOLE WAS OBSERVED. THE FRAME BOTTOM STEEL WAS EASILY STRIPPED AWAY WITH TWO FINGERS AND A THUMB TO THE LENGTH AND WIDTH DESCRIBED. THE REMAINDER OF THE FRAME HAS EXTENSIVE SURFACE RUST BUT NO HOLE AND OTHERWISE FAIR CONDITION. THE LICENSED STATE VEHICLE INSPECTION SHOP FAILED THE VEHICLE DUE TO THE FRAME RUST AT THIS LOCATION. OTHERWISE, WITH SOME MINOR MECHANICAL ISSUES, THE TRUCK IS IN GOOD CONDITION AND COULD BE SAFELY USED FOR A NUMBER OF MORE YEARS. ONLINE THIS RUST PROBLEM AT THIS POINT HAS A LARGE NUMBER OF COMPLAINTS...

TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE INDEPENDENT MECHANIC DISCOVERED THAT THE FRAME AND CHASSIS OF THE VEHICLE WERE RUSTED AND CORRODED. FLAGSHIP FORD (850 FERN DR, BALDWIN, WI) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 138,000.

MY 2004 FORD F-150 HAS 61,000 MILES AND NO RUST ON THE OUTSIDE OF THE VEHICLE. I'VE KEPT THE TRUCK WELL MAINTAINED AND IT LOOKS ALMOST NEW. THE FRAME HOWEVER RIGHT WHERE THE REAR LEAF SPRING ATTACHES TO THE FRAME IS RUSTED RIGHT THROUGH. IT IS INCREDIBLE THAT THIS HAS NOT BEEN RECALLED AS OF YET. HOPEFULLY IT WILL BE RECALLED. WHILE DRIVING A PART OF THE EXHAUST HEAT SHIELD FELL ONTO THE DRIVESHAFT. WHEN I WENT TO INSPECT THE UNDERSIDE I FOUND A HOLE IN THE FRAME AND I WAS ABLE TO PUT MY FINGER RIGHT THROUGH IT. *DT CONSUMER STATED ONE IMPORTANT FACT THAT I FORGOT TO ADD TO MY COMPLAINT IS THE SECTION OF THE FRAME THAT RUSTED THROUGH HAS THE EXACT SAME ISSUE IN THE SAME SPOT ON BOTH THE PASSENGER FRAME RAIL AS WELL AS THE DRIVER'S SIDE FRAME RAIL. THE 2004 FORD ESCAPE WAS...

THE MAIN FRAME RAILS( THAT RUN FROM FRONT BACK) HAVE AN EXTRA CLADDING THAT IS WELDED TO THE MAIN FRAME RAILS. THIS AREA I AM REFERRING TO IS WHERE A CROSS MEMBER( HOLDING THE WEIGHT OF THE REAR ENGINE AND TRANSMISSION) IS WELDED TO THE CLADDING AND THE TWO MAIN FRAME RAILS. THE CLADDING WAS NOT COMPLETELY WELDED SO WATER HAS GOTTEN BETWEEN THE CLADDING AND MAIN FRAME RAILS CAUSING SEVERE CORROSION AND FAILURE OF THAT CONNECTION POINT. EVEN THOUGH IT COULD BE SAID I TAKE EXTREMELY GOOD CARE OF MY VEHICLES THIS AREA SUDDENLY PRESENTED AS A BULGE AND SUBSEQUENT DISCOVERY OF AN EXTREME FAILURE. THIS CONSISTENT FAILURE HAPPENED ON BOTH FRAME RAIL CONNECTION POINTS. I FEEL THAT THIS FAILURE WILL BE OVERLOOKED AS IT WAS WITH ME ....AND COULD CAUSE FRAME FAILURE CAUSING PUBLIC HARM.

SAME DEAL AS EVERY OTHER MEMO I READ. MAJOR HIGHLIGHTING POINTS: - PREMATURE FRAME CORROSION AND RUST. - MECHANIC INFORMED ME THAT THE FRAME ON THE REAR HALF. - RUSTED AND CRACKED UNDER BED AND REAR WHEEL WELLS - FRAME WOULD NO LONGER SUPPORT WEIGHT OF VEHICLE - RUST THRU HOLES AND LONGITUDINAL CRACKS FORMED ON THE BOTTOM AND SIDE FRAME SURFACES AT THE STRESS POINT BEFORE THE REAR WHEEL BEND. - EXTREMELY UNUSUAL, TRUCK HAS BEEN GENERALLY BEEN GARAGE KEPT AND MAINTAINED IN GOOD MECHANICAL CONDITION. - THE EXTERIOR BODY DOES NOT EXHIBITS SPOTS OR SURFACE RUST ON VISIBLE BODY PANELS. - NO EVIDENT SIGNS OF RUST OR DEGRADATION OF STRUCTURE. - METICULOUSLY MAINTAINED VEHICLE OTHERWISE. (NEW TRANSMISSION, DRIVE SHAFT, ENGINE RETIMED, SPRAY BED LINER, ETC.) - CATASTROPHIC FAILURE OF THE FRAME STRUCTURE WAS IMMINENT AND THAT THE VEHICLE WAS NO LONGER SAFE TO DRIVE. - CANNOT BE REPAIRED...

THIS A.M. AS I ENTERED MY DRIVEWAY, A NEIGHBOR STOPPED ME TO TALK. I STOPPED AND ROLLED DOWN MY WINDOW. HE WENT ON AND ON. SUDDENLY, MY TRUCK ACCELERATED AT FULL THROTTLE TOWARD MY GARAGE 70 FEET AWAY. MY FOOT WAS ON THE BRAKE TO NO AVAIL. I TURNED SLIGHTLY TO THE RIGHT AND HIT THE CORNER OF THE GARAGE. THE AIR BAGS DEPLOYED. MY GLASSES WENT FLYING. I WAS NOT HURT. A TREE HAD SOFTEN THE IMPACT. I WAS SEVERELY SHAKEN. MY BLOOD PRESSURE WAS ELEVATED. FORD MOTOR COMPANY IS NOT HELPFUL. MY INSURANCE COMPANY, GEICO, IS HANDLING THE ISSUE.

THE TRUCK WAS TAKEN INTO MECHANIC. THE MECHANIC PUT IT UP, AND SAW THAT ENTIRE FRAME WAS RUSTED. IT IS NOT FIXABLE. CONTACTED JOHN LANCE FORD, WHERE IT WAS PURCHASED. THEY ADVISED TO TAKE TRUCK TO NEAREST FORD DEALER. WE TOOK IT TO FORD IN PORT CLINTON, OHIO. THE SERVICE MANAGER TOOK PICTURES AND SENT IT TO CORPORATE OFFICE. IT HAS BEEN LONGER THAN 6 WEEKS, AND HAVE NOT HEARD BACK.

TL* THE CONTACT OWNS A 2004 FORD F-150. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR REPAIRS. ONCE THE VEHICLE WAS PLACED ON A LIFT, THE MECHANIC NOTICED THAT THE MAIN RAILS THAT SUPPORT THE FRAME AND THE FRAME OF THE VEHICLE HAD EXTENSIVE RUST. THE FAILURE COULD CAUSE THE STRUCTURE TO POTENTIALLY FRACTURE OR DISINTEGRATE. THE INDEPENDENT MECHANIC DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

MY TRUCKS FRAME HAS RUSTED OUT FROM THE CAB CORNERS TO THE REAR PART OF THE FRAME RAILS. FORD MOTOR COMPANY WONT DO ANYTHING ABOUT THIS PROBLEM. NUMEROUS COMPLAINTS HAVE BEEN FILED, YET THEY WONT DO ANYTHING ABOUT IT. IM NOT SELLING MY TRUCK BECAUSE ITS A RARE VERSION OF THE 04 NEW STYLE F-150. THIS IS A VERY SERIOUS PROBLEM THAT PEOPLE CAN DIE FROM AND FORD WONT BACK THEM UP ON THE 04-08 TRUCKS.

THE FRAME ON MY TRUCK HAS SPLIT IN HALF ALWAYS BEEN TAKEN CARE OF. IVE HAD IT FOR 6 YEARS AND IT BEEN GOOD. UNTIL RECENTLY THE BED HAS STARTED TO SHAKE VERY VIOLENTLY. MY DAD AND I HAVE FIGURED OUT THAT THE FRAME ON MY TRUCK HAS SPLIT IN HALF! I DID SOME RESEARCH ON THIS ISSUE OF FRAMES FAILING. MOST 11TH GEN OWNERS LIKE ME HAVE OR HAD THIS KIND OF PROBLEM. SOME FRAMES HAVE ROTTED OUT COMPLETELY DUE TO FORD. THIS TRUCK IS VERY UNSAFE! AND IVE ASKED FORD IF THEY COULD DO ANYTHING AND THEY COULDNT DO ANYTHING. THEY WONT BACK UP THEIR PRODUCTS.

BROUGHT MY 2004 F150 XLT TO HAVE SOME SERVICE WORK DONE, THE TRUCK NEEDED A MUFFLER AND A NEW FRONT UPPER CONTROL ARM, I WAS ADVISED BY THE SERVICE MANAGER THAT I SHOULD HAVE MY FRAME LOOKED AT BEFORE GOING ANY FURTHER, BOTH RIGHT AND LEFT SIDES OF THE FRAME IN THE MIDDLE OF THE TRUCK HAVE SEVERE RUST AND I BELIEVE THE STRUCTURE IS DOOMED TO FAIL, I HAD PLANNED ON DRIVING THIS TRUCK FOR SEVERAL MORE YEARS AS IT IS MY DAILY DRIVER. I AM NOW LEFT WITH A TRUCK THAT CANNOT BE CERTIFIED FOR RESALE AND HAS LOST ITS VALUE AND FURTHER IT IS NO LONGER SAFE. BY THE WAY THE TRUCK ONLY HAS 190 THOUSAND KMS ON IT.

I HAVE A 2004 FORD F-150 XL EXTENDED CAB PICK UP WITH 140,000 MILES. I RECENTLY PURCHASED NEW TIRES AND AN EXHAUST . DROPPED OF THE TRUCK AT THE MECHANIC TO HAVE ITEMS INSTALLED. RECEIVED A CALL THE NEXT MORNING THAT THERE WAS A PROBLEM, SO WENT IN TO SEE WHAT THE ISSUE WAS. TURNS OUT THE FRAME OF THE TRUCK HAS ROTTED ON BOTH THE PASSENGER AND DRIVERS SIDE, WHERE THE BED MEETS THE CAB. WHEN THEY TRIED TO LIFT THE TRUCK TO INSTALL THE TIRES THE TRUCK DIDN'T MOVE, THE LIFT JUST STARTED CRUSHING THROUGH THE FRAME RAIL. QUITE DEVASTATING NEWS TO RECEIVE SINCE THE TRUCK RUNS AND DRIVES GREAT, BUT IS NOW A BIG HUNK OF SCRAP. WORRISOME ALSO AS I HAD JUST TAKEN MY FAMILY ON A 7 HOUR TRIP IN THE TRUCK A MONTH EARLIER AND HATE TO CONSIDER WHAT COULD HAVE HAPPENED IF WE...

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE REAR DRIVER SIDE FRAME OF THE VEHICLE WAS RUSTED OUT NEAR THE FUEL TANK. THE CONTACT TOOK THE VEHICLE TO THE LANGLEY FORD DEALER WHO STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALL REGARDING THE FRAME. THE VEHICLE WAS NOT OFFICIALLY DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND CONFIRMED THE DEALER'S INFORMATION. THE APPROXIMATE FAILURE MILEAGE WAS 124,000. UPDATED 08/09/17*LJ *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. WHILE PERFORMING ROUTINE MAINTENANCE ON THE VEHICLE, THE CONTACT BECAME AWARE OF EXTREME CORROSION TO THE SUBFRAME OF THE VEHICLE. THE CONTACT WAS CONCERNED THAT THE VEHICLE COULD FRACTURE AND SEPARATE AT THE CENTER BETWEEN THE BED AND THE CABIN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE FRAME WAS FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000.

MY TRUCK HAS 106,XXX MILES ON IT. I HAVE ONLY OWNED IT FOR 9 MONTHS. I TOOK IT TO THE SHOP FOR A REPAIR AND WAS TOLD THE FRAME WAS SO ROTTEN OUT THEY COULDN'T PUT IT ON THE LIFT.

MY TRUCK HAS ALWAYS BEEN WELL TAKEN CARE OF HAS 92, 000 MILES ON IT WHICH IS VERY LOW ON A 2004. IT WAS ALWAYS SERVICED AT THE DEALER WHERE WE PURCHASED THE TRUCK. I HAD 2 EXTENDED SERVICE WARRANTIES THROUGH THIS DEALER. THERE IS NO RUST ON THE BODY AT ALL. I TOOK IT TO ANOTHER GARAGE TO HAVE SOME WORK DONE ON IT AND WHEN THEY PUT IT ON THE LIFT THE BOX ON THE TRUCK STARTED TO PULL AWAY FROM THE CAB. WHEN IT WAS LOWERED, AND INSPECTED THE FRAME ON BOTH SIDES OF THE TRUCK WAS COMPLETELY ROTTED THRU. I HAD NO IDEA THAT IT WAS THIS BAD. THE FRAME MUST BE COMPLETELY RECONSTRUCTED AND OF COURSE FORD AND THE DEALER DON'T WANT TO TAKE ANY RESPONSIBILITY FOR IT. SOMEONE COULD HAVE BEEN KILLED NOT KNOWING THE SEVERITY OF THE FRAME. I DEPENDED ON FORD TO...

WITHIN A COUPLE YEARS OF MANUFACTURE NOTICED OXIDATION APPEARING ON UNDERSIDE OF HOOD, AND SOME PAINT BLISTERING ON FRONT EDGE OF UPPER SIDE OF HOOD. THESE ISSUES HAVE WORSENED OVER TIME

FRAME RUSTED IN HALF,

HOOD PAINT AND ROOF PAINT PEELING UP FOR THE LAST 7 YEARS. IT STARTED WITH SMALL BLISTERING AND WHAT APPEARED TO BE JUST A FEW KNICKS ON THE HOOD. HOWEVER IT QUICKLY SPREAD AND THE ENTIRE HOOD AS WELL AS ROOF ARE IN NEED OF A PAINT JOB DUE TO RUST. I AM THE ORIGINAL OWNER AND HAVE APPS 129000 MILES ON IT.

THE FRAME UNDER MY F150 IS RUSTED THROUGH. I ONLY HAVE 81K MILES ON IT AND I DON'T UNDERSTAND WHY THE FRAME IS RUSTING SO BADLY. IT HAS ALREADY COST ME 2,400 TO HAVE A CERTIFIED WELDER REPLACE SOME OF THE SECTIONS THAT WERE RUSTED OUT. I KNOW JUST FOUND ANOTHER PART OF THE FRAME THAT IS RUSTED UNDER THE LEAF SPRING. THAT IS NOW GOING TO COST ME ANOTHER $500.00.

FRAME RUSTING OUT PREMATURELY CAUSING A SAFETY HAZARD.

BOTH REAR SUICIDE DOORS WILL NOT OPEN, THE LATCH MECHANISM IS BROKEN AND APPARENTLY COST OVER $700.00 TO FIX BOTH. IN ADDITION I HAVE REPLACED THE WHEEL BEARING ON ALL WHEELS TWICE AND NOW ANOTHER ONE IS GOING BAD. IT SEEMS LIKE I NEVER HAVE A PERIOD WHEN ALL THE BEARINGS ARE GOOD.

THE FRAME OF MY 2004 F150 IS ALMOST COMPLETELY ROTTEN FROM THE FRONT OF THE LEAF SPRING ALL THE WAY UP TO THE DRIVERS DOOR. THE BED SUPPORTS ARE ALSO ROTTED COMPLETELY OFF MAKING THE BED UNSAFE AND UNABLE TO USE.

DURING AN OIL CHANGE IT WAS NOTICED THAT THE LEFT HAND FRONT DIFFERENTIAL MOUNTING BRACKET APPEARED TO HAVE A CRACK PURSUANT WITH TSB 06-11-12. HOWEVER UPON CLOSER EXAMINATION IT WAS SHOWN THAT THE DAMAGE WAS MORE EXTENSIVE THEN THE "CONCERN OF THE LEFT HAND FRONT DIFFERENTIAL MOUNTING BRACKET SEPARATING FROM THE FRAME RAIL." MENTION IN THE TSB. INSTEAD OF THE AFOREMENTIONED MOUNT BREAKING, A SECTION OF THE FRAME APPROXIMATELY 1/4 OF AN INCH AROUND THE WELDS FOR THE DIFFERENTIAL MOUNT ON ALL SIDES HAD SEPARATED FROM THE REST OF THE FRAME LEAVING A HOLE IN THE FRAME APPROXIMATELY FOUR INCHES ACROSS.

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THERE WAS RUST FORMING ON THE REAR DRIVER AND PASSENGER SIDE TIRE WELLS. THE FAILURE RECURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENTIRE REAR PANEL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,800.

THE MIRROR(S) ARE FULL OF CORROSION AND THE DRIVERS SIDE MIRROR FELL RIGHT OFF THE CAR WHILE DRIVING. *TR

-REPAIR SHOP-2004 FORD F150 CREW CAB, FRAME COMPLETELY ROTTED THROUGH, FRAME REPLACEMENT REQUIRED. CUSTOMER WILL NOT HAVE REPAIRED. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE FRAME MEMBERS WERE EXTREMELY CORRODED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 109,000.

VEHICLE'S BACK WINDOW LEAK NOTED WITHIN 60 DAYS AFTER PURCHASE, RESEALED BY DEALER X2-STILL LEAKS. WITHIN A PERIOD OF ONE YEAR AFTER PURCHASE, THREE OF THE FOUR WINDOW GEAR BOXES WERE REPLACED DUE TO FAILURE. I'VE NOTED SEVERAL COMPLAINTS ABOUT THESE ISSUES, MET OTHER OWNERS WHO HAVE HAD THESE ISSUES FIXED UNDER WARRANTY, YET WE WERE REQUIRED TO PAY FOR REPAIR. AT HIGHWAY SPEEDS, 65MPH, THE VEHICLE BEGINS TO SHIMMY, VIBRATE AND BECOMES DIFFICULT TO MAINTAIN CONTROL OF STEERING. VIBRATION MAKES RIDE UNPLEASANT AND NOISY. *TR

WHEN DRIVING AT RELATIVELY LOW SPEED, THE HOOD LIFTED VIOLENTLY. THE DRIVER WAS ABLE TO STOP THE TRUCK SAFELY. THE PORTION OF THE HOOD WHICH SECURES THE HOOD STRIKER GAVE WAY, ALLOWING THE HOOD TO OPEN SO VIOLENTLY THAT THE GRILLE FLEW OFF. THE HOOD WAS PROPERLY CLOSED/LATCHED BEFORE THE INCIDENT, AND THE STRIKER WAS STILL IN THE LATCH (COMPLETE WITH PIECES OF ALUMINUM TORN OFF OF THE HOOD) AFTER THE INCIDENT. IT APPEARS THAT GALVANIC CORROSION (STEEL STRIKER ON ALUMINUM HOOD) LIKELY CAUSED THE ISSUE. SINCE THIS TRUCK IS IN A FLEET, THE REMAINDER OF THE F-150S OF THE SAME BODY STYLE (MY2008 AND OLDER) WERE CHECKED, 65 OF 580 TRUCKS HAD EITHER CRACKING OR CORROSION AROUND THE STRIKER BAR WHICH MAY LEAD TO THIS ISSUE. NOTE - THIS IS AN ONTARIO, CANADA FLEET BUT THESE ISSUES LIKELY AFFECT US-SOLD VEHICLES. *TR

REAR PASSENGER SIDE QUARTER PANEL RUST DUE TO RUBBER PANEL BEING IMPROPERLY INSTALLED AT FACTORY. FULL RUST THROUGH IN THE MIDDLE OF THE PANEL, FROM THE INSIDE OUT. *TR

RUST IN THE REAR PASSENGER QUARTER PANEL DUE TO A KNOW FACTORY DEFECT OF A RUBBER PAD BEING INSTALLED IMPROPERLY, CONTACTED FORD ABOUT THE PROBLEM, THEY REFUSE TO REPAIR OR ASSIST IN ANY WAY. *TR

WAS DRIVING DOWN THE ROAD AT APPROXIMATELY 55 MPH AND THE LEFT DRIVER'S SIDE WINDOW CAME CRASHING DOWN. I THOUGHT A ROCK WAS COMING THROUGH THE WINDOW AND ALMOST WENT OFF THE ROAD. *TR

IN LATE-JUNE 2012 A LOUD CLUNK/THUD/POP/SMALL EXPLOSION OCCURRED IN THE PASSENGER-SIDE DOOR OF MY 2004 FORD F-150 REGULAR CAB TRUCK, WHILE THE VEHICLE WAS STOPPED AND IDLING, AND THE WINDOW DROPPED INTO THE DOOR FRAME. WHEN I RETURNED HOME I REMOVED THE DOOR PANEL AND DISCOVERED THAT A SMALL PIECE OF MOLDED PLASTIC, 1 1/8" X 1 7/8" (PROBABLE COST TO FORD ABOUT 39 CENTS) ON THE WINDOW REGULATOR HAD DISINTEGRATED/FAILED, ALLOWING THE REGULATOR CABLE TO RELEASE THE WINDOW. I HAVE FOUND A REPLACEMENT WINDOW REGULATOR ON THE INTERNET FOR $70 (FORD CHARGES $175 FOR THE PART) AND WILL REPAIR THE DEFECTIVE ITEM MYSELF. I NOTIFIED FORD OF THE FAILURE OF A LESS-THAN-QUALITY PLASTIC PIECE ON THE REGULATOR AND ASKED FOR REIMBURSEMENT. FORD RESPONDED: "THERE ARE NO FACTORY WARRANTIES OR PROGRAMS IN EFFECT ON YOUR VEHICLE THAT WOULD PROVIDE FINANCIAL ASSISTANCE FOR YOUR CURRENT VEHICLE CONCERN." HOWEVER, THEY DID ADD:...

ON 25 MARCH 2011, I ENCOUNTERED A LOUD POP IN THE DOOR ON THE DRIVER-SIDE OF MY 2004 FORD F-150 REGULAR CAB TRUCK, AND THE WINDOW DISAPPEARED INTO THE DOOR FRAME. I REMOVED THE DOOR PANEL AND DISCOVERED THAT THE CABLE MECHANISM WITHIN THE WINDOW REGULATOR HAD FAILED. WITHOUT FURTHER DELAY I TURNED THE TRUCK INTO MY FORD DEALER TO HAVE THE WINDOW REGULATOR REPAIRED, AND RECEIVED A REPAIR BILL OF $301.86 (THE REGULATOR ALONE COST $159.36); THE FORD ADVISOR STATED THAT THEY HAD THE PART IN STOCK SINCE THE WINDOW REGULATOR FAILURE WAS A COMMON OCCURRENCE. I DID NOT INSPECT THE REGULATOR TO DETERMINE WHY THE CABLE MECHANISM HAD FAILED. AFTER THIS INCIDENT I VISITED WWW.NHTSA.GOV TO DETERMINE THE EXTENT OF THE PROBLEM, AND LEARNED THAT MORE THAN 240 OTHER 2004 FORD TRUCK OWNERS HAD EXPERIENCED THE EXACT SAME PROBLEM IN ONE DOOR OR THE OTHER IN THEIR TRUCKS....

IS ANYBODY DOING ANYTHING ABOUT THE FORD WINDOW REGULATOR PROBLEM. OVER THE YEARS ALL OF MY SONS WINDOWS HAVE ALL FALLEN DOWN. AT TIMES LEAVING THE KIDS WITH EXPOSURE TO WHOEVER PASSES BY...THIS IS NOT SAFE. TWO WINDOWS FAILED ON THE SAME DAY. TRIED TO CALL FORD AND GOT NO REASONABLE RESPONSE... *JS

I AM THE OWNER OF A 2004 F-150. THIS IS MY FIFTH FORD PRODUCT ON A ROW, TWO OF THEM PURCHASED NEW. RECENTLY THE PASSENGER SIDE REAR WINDOW REGULATOR FAILED, CAUSING THE WINDOW TO SLIDE DOWN INTO THE DOOR. IN DECEMBER. I PURCHASED A REPLACEMENT REGULATOR/MOTOR ASSEMBLY AND JUST FINISHED THE INSTALLATION. WHEN I EXAMINED THE OLD UNIT I FOUND THE OPERATING CABLE INCORRECTLY SPOOLED ONTO THE PRIMARY PULLEY. WHEN THE CABLE OVERLAPPED ITSELF THE END PULLED OUT OF THE LIFTING BLOCK. WHEN I WAS SEARCHING FOR INFORMATION ABOUT THE REPLACEMENT PROCEDURE, I CAME ACROSS NUMEROUS WEBSITES DETAILING COMPLAINTS ABOUT THE FAILURE OF F150 WINDOW REGULATORS. THIS LEADS ME TO BELIEVE THAT THE PROBLEM IS DUE TO A FAULTY DESIGN AND SHOULD BE ADDRESSED BY FORD WITH A REDESIGNED PART AND A RECALL TO REPLACE EXISTING UNITS. I WILL BE CONTACTING MY CONGRESSMAN, ABOUT THIS EXPENSIVE AND ANNOYING DEFECT.WEBSITES DETAILING...

I WAS TRAVELING ON A MAIN BOULEVARD WHEN ALL OF A SUDDEN THE DRIVERS SIDE WINDOW SLID DOWN WITH A LOUD SOUNDING BANG. THE WINDOW DID NOT BREAK. HOWEVER, WHAT SEEMS TO BE A SPRING LOADED MECHANISM, MUST HAVE BROKEN CAUSING THE WINDOW TO COLLAPSE DOWN INSIDE THE DOOR. THE SOUND WAS SO LOUD, IT CAUSED A NERVOUS REACTION IN ME WHICH RESULTED IN PULLING ON THE STEERING WHEEL TO ONE SIDE. THANKFULLY, THERE WERE NO VEHICLES TO THAT SIDE AND I WAS ABLE TO CORRECT MY STEERING TO GET BACK INTO MY LANE. AS IF ONE EXPERIENCE WAS NOT SUFFICIENT, IT HAPPENED AGAIN 9/1/11. THIS TIME ON THE PASSENGER SIDE DOOR. THE SAME EXACT EXPERIENCE REPEATED EXCEPT THAT THIS TIME I WAS DRIVING AT 75MPH ON I-25. I EXPECTED TO FIND A RECALL TO THIS DIS-FUNCTIONAL MECHANISM. WHAT ARE THE CHANCES OF THIS HAPPENING ALMOST BACK TO BACK WITHIN...

DOOR POWER WINDOW REGULATOR FAILS (BROKEN PLASTIC PIECE) AND DOOR WINDOW GLASS FALLS INTO THE DOOR. THIS USUALLY OCCURS WHILE DRIVING - SEE THOUSANDS OF INTERNET REPORTS. THIS IS A DANGEROUS DEFECT IN THE REGULATOR THAT FORD KNOWS ABOUT AND REFUSES TO RECALL. REPAIR PART AND LABOR COST APPROX $400 PER WINDOW. I HAVE HAD 2 WINDOW REGULATORS FAIL SO FAR! FORD SHOULD BE RESPONSIBLE FOR THIS. *TR

3RD POWER WINDOW REGULATOR FAILURE IN 1.5 YRS ON 2004 FORD F-150 SUPERCREW TRUCK. WHEN REGULATOR FAILS, IT SOUNDS AS THOUGH SOMEONE STRUCK OR SHOT THE WINDOW CAUSING ME TO JUMP AND TAKE MY EYES OFF THE ROAD TO SEE WHAT HAD HAPPENED AND IF ANY PASSENGERS WERE INJURED ALMOST CAUSING ME TO COLLIDE WITH AN ON-COMING VEHICLE. I HAVE HAD TWO OF THE REGULATORS REPLACED BY A LOCAL PAINT AND BODY SHOP WHERE I WAS TOLD THAT IT IS A KNOWN PROBLEM WITH THE REGULATORS. MY COST TO DATE HAS BEEN IN EXCESS OF $350 AND I NOW HAVE TWO SUCTION CUPS HOLDING ONE WINDOW UP UNTIL I CAN AFFORD TO HAVE IT REPAIRED. *TR

2004 FORD F150 WINDOW REGULATOR FAILURES...MULTIPLE TIMES..SEVERAL MONTHS APART. THE WINDOW COMES CRASHING DOWN AND IS TOTALLY OPEN. I HAVE DOGS THAT RIDE WITH ME. THIS HAS GOT TO BE FIXED BY FORD. *TR

WHILE DRIVING AT HIGHWAY SPEED THE REAR PASSENGER WINDOW DROPED, AT THAT TIME MY GRANDSON (3) TAUGHT IT WOULD BE OK TO THROW HIS SOCKER BALL OUT. THE BALL BOUNCED OF A CAR BEHIND ME BUT NO DAMAGE BUT SCARED THE DRIVER ALMOST CAUSING AN ACCIDENT. THIS IS A BIG PROBLEM, WINDOWS SHOULD NOT DROP LIKE THAT GOOD THING WEATHER WAS GOOD, I CAN ONLY IMAGINE IF IT HAD BEEN RAINING THE OTHER CAR WOULD HAVE NOT BEEN ABLE TO STOP CAUSING A MAJOR ACCIDENT AND I WOULD BE GETTING SEUD. THIS ISSUE NEEDS FIXING BY FORD BECAUSE IS NOT AN ISOLETED PROBLEM THOUSANDS ARE HAVING THE SAME PROBLEM. WINDOW NOT FIXED YET STILL RESEARCHING FOR PARTS. *TR

THERE ARE FACTORY MADE SQUARE HOLES UNDER THE SIDES OF THE TRUCK. WHEN IT RAINS, THE WHEELS SPLASH WATER INTO THESE HOLES. THE WATER COMES UP INTO THE FLOOR OF THE TRUCK. INSIDE THE TRUCK THERE IS A PLASTIC PANEL ALONG THE EDGES OF THE DOOR THAT POPS OUT. IT IS THE SQUARE HOLES THAT IT POPS OUT OF THAT THE WATER COMES IN THROUGH. I CAN STICK MY FINGER FROM THE UNDER OUTSIDE IF THE TRUCK AND SEE THEM THRU THE HOLES THAT HOLD THE PLASTIC PANELING ON THE INSIDE. THE WATER COLLECTS ALONG WHERE ALL THE ELECTRICAL WIRES ARE RUNNING AND SOAKS UP INTO THE CARPET. *TR