NHTSA Complaint #10445878 — 2004 FORD F-150

I AM THE OWNER OF A 2004 F-150. THIS IS MY FIFTH FORD PRODUCT ON A ROW, TWO OF THEM PURCHASED NEW. RECENTLY THE PASSENGER SIDE REAR WINDOW REGULATOR FAILED, CAUSING THE WINDOW TO SLIDE DOWN INTO THE DOOR. IN DECEMBER. I PURCHASED A REPLACEMENT REGULATOR/MOTOR ASSEMBLY AND JUST FINISHED THE INSTALLATION. WHEN I EXAMINED THE OLD UNIT I FOUND THE OPERATING CABLE INCORRECTLY SPOOLED ONTO THE PRIMARY PULLEY. WHEN THE CABLE OVERLAPPED ITSELF THE END PULLED OUT OF THE LIFTING BLOCK. WHEN I WAS SEARCHING FOR INFORMATION ABOUT THE REPLACEMENT PROCEDURE, I CAME ACROSS NUMEROUS WEBSITES DETAILING COMPLAINTS ABOUT THE FAILURE OF F150 WINDOW REGULATORS. THIS LEADS ME TO BELIEVE THAT THE PROBLEM IS DUE TO A FAULTY DESIGN AND SHOULD BE ADDRESSED BY FORD WITH A REDESIGNED PART AND A RECALL TO REPLACE EXISTING UNITS. I WILL BE CONTACTING MY CONGRESSMAN, ABOUT THIS EXPENSIVE AND ANNOYING DEFECT.WEBSITES DETAILING THE ISSUE ARE LISTED BELOW: HTTP://WWW.JEREBEASLEYREPORT.COM/2011/08/PROBLEMS-WITH-FORD-F-150-WINDOW-REGULATORS/ HTTP://WWW.CARCOMPLAINTS.COM/FORD/F-150/2005/WINDOWS_WINDSHIELD/POWER_WINDOW_REGULATOR_FAILURE.SHTML INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT