2004 FORD F-150 Engine And Engine Coolingenginegasoline Problems
7 NHTSA complaints on file
Engine And Engine Coolingenginegasoline Issues in the 2004 FORD F-150
7 engine and engine coolingenginegasoline complaints have been filed with NHTSA for the 2004 FORD F-150. Of these, 0 involved a crash, 1 involved a fire, and 0 resulted in injury.
7
Complaints
0
Crashes
1
Fires
0
Injuries
0
Deaths
All Engine And Engine Coolingenginegasoline Complaints
FORD RECOMMENDS CHANGING THE SPARK PLUGS ON MY 2004 F150 5.4 3-VALVE AT 100,000 MILES. MILEAGE WAS GETTING CLOSE SO I TRIED TO CHANGE THEM. UNFORTUNATELY FORD DID NOT TELL OWNERS THAT THERE IS A HUGE PROBLEM WITH THE SPARK PLUGS BREAKING-OFF IN THE CYLINDER CAUSING A MASSIVE REPAIR BILL. ENGINE HAD MUST BE REMOVED TO TAKE OUT BROKEN PLUG. FORD DID PRODUCE A TSB, BUT DID NOT INFORM OWNERS THAT THIS ROUTINE SERVICE SHOULD BE DONE BY DEALER. UPON CHECKING INTERNET, THERE ARE SCORES OF REPORTS OF THE PLUGS BREAKING WHEN BOTH OWNERS AND DEALERS ATTEMPT THE ROUTINE MAINTENANCE. *TR
WITHOUT ANY WARNING THE V-8 5.4 ENGINE STARTED MISSING, DEALER IN WINSLOW AZ SAID THEY HAD A LOT OFTROUBLE WITH THAT ENGINE SHOOTING THE SPARK PLUGS OUT. TWO OF THE PLUGS WERE LOOSE , ONE APPARENTLY MORE THAN THE OTHER. REPLACING PLUGS DID NOT HELP. SOME REPORTS OF OTHERS TELL OF THIS GOING ON SINCE BEFORE 97. SOME WITH FIRES. I WONDER WHY THIS SITUATION HAS GONE ON SO LONG AND STILL NOT FIXED. *TR
REAR WINDOW SEAL IS LOOSE AND WINDOW RATTLES INSIDE OF MOUNTING AREA INDICATING AN INSUFFICIENT MOUNT TO RETAIN WINDOW IN MOUNTING AREA. *NM
I PURCHASED A NEW 2004 F-150 VIN [XXX] IN AUG 2004. THE SAFETY ISSUE I HAVE IS THAT WE BEGAN HAVING A PROBLEM WITH THE VEHICLE STALLING WHILE IT WAS BEING DRIVEN AND FOR SOME REASON WHEN THE VEHICLE WAS TURNING LEFT. IT WAS NOT A CONSTANT THING WHEN WE WERE DRIVING THE TRUCK. HOWEVER AFTER A FEW OCCASIONS OVER A COUPLE MONTHS WE TOOK IT TO THE DEALER.WE TOOK IN ON FEB.1 2005. THE VEHICLE HAD 2600 MILES ON IT AT THIS TIME.THE DEALER CONCURRED WITH THE PROBLEM AND THE DEALER CONTACTED FORD MOTOR COMPANY FOR ASSISTANCE ON HOW TO CORRECT THE PROBLEM.THE DEALER DID AS THEY WERE INSTRUCTED BY FORD AND DID CHECKS AND INSPECTIONS OF SEVERAL SYSTEMS. THEY THOUGHT THEY HAD IT RESOLVED.BUT A MONTH TO SIX WEEKS LATER IT BEGAN STALLING AGAIN.ONLY A COUPLE OF TIMES AT LOW SPEED.THEN SOME TIME PASTED IT DID IT AGAIN...
2004 FORD F-150 PICKUP TRUCK STALLS WHEN SLOWING TO A STOP. THE TRUCK HAS DONE THIS OVER 20 TIMES IN THE LAST 4 MONTHS.*AK
FIRE IN ENGINE COMPARTMENT OF FORD F-150. OWNER WAS ATTEMPTING TO DRIVE THE VEHICLE OUT OF THE SNOW WHERE HE GOT STUCK. WHILE DOING SO, THE ENGINE COMPARTMENT CAUGHT FIRE. FIRE FIRST SEE FROM THE DRIVER SIDE COWL. HEAVY FIRE DAMAGE TO THE ENGINE COMPT.
TRUCK CONTINUES TO STALL/ENGINE DIES WHEN DRIVING. USUALLY STOPS WHEN SLOWING DOWN OR STARTING FROM A STOP. COMMONLY DIES AT INTERSECTIONS/STOP SINGS ETC. HAS STOPED ON HIGHWAY WHEN SLOWING DOWN MAKING IT VERY DIFFICULT TO CONTROL.*AK
Other 2004 FORD F-150 Problem Areas
Visibilitypower Window Devices And Controls
615 complaints
Visibility
205 complaints
Engine And Engine Cooling
109 complaints
Engine
92 complaints
Power Train
88 complaints
Electrical System
87 complaints
Suspension
81 complaints
Unknown Or Other
81 complaints
Power Trainautomatic Transmission
66 complaints
Structurebody
58 complaints
Steering
57 complaints
Air Bags
48 complaints
Vehicle Speed Control
47 complaints
Engine And Engine Coolingengine
46 complaints
Tires
40 complaints
Air Bagsfrontal
31 complaints
Service Brakes Hydraulic
30 complaints
Fuel System Gasoline
28 complaints
Service Brakes Hydraulicfoundation Componentsdiscrotor
27 complaints
Equipment
25 complaints
Fuelpropulsion System
24 complaints
Service Brakes
24 complaints
Visibilitywiper
23 complaints
Power Traindriveline
22 complaints
Structure
22 complaints
Parking Brake
21 complaints
Suspensionfront
20 complaints
Power Traindrivelinedifferential Unit
19 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
17 complaints
Wheels
16 complaints
Power Traindrivelinedriveshaft
13 complaints
Latcheslockslinkagesdoorslatch
12 complaints
Power Trainaxle Assembly
12 complaints
Suspensionrear
12 complaints
Vehicle Speed Controlaccelerator Pedal
12 complaints
Visibilityglass Siderear
12 complaints
Latcheslockslinkages
11 complaints
Service Brakes Hydraulicfoundation Componentsdiscpads
11 complaints
Vehicle Speed Controlcruise Control
10 complaints
Tiressidewall
8 complaints
Exterior Lighting
7 complaints
Seat Belts
7 complaints
Service Brakes Hydraulicfoundation Componentsdisc
6 complaints
Structureframe And Members
6 complaints
Structureframe And Membersunderbody Shields
5 complaints
Tirestreadbelt
5 complaints
Electrical Systemwiring
4 complaints
Fuel System Gasolinedeliveryfuel Pump
4 complaints
Fuel System Other
4 complaints
Power Trainautomatic Transmissioncontrol Module Tcmpcmtecm
4 complaints
Steeringrack And Pinion
4 complaints
Structurebodyhood
4 complaints
Trailer Hitches
4 complaints
Air Bagsfrontaldriver Sideinflator Module
3 complaints
Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe
3 complaints
Equipment Adaptivemobility
3 complaints
Exterior Lightingbrake Lights
3 complaints
Fuel System Gasolinestoragetank Assembly
3 complaints
Parking Brakeconventionalmechanicallinkage And Cable
3 complaints
Power Trainautomatic Transmissionlever And Linkagecolumn Shift
3 complaints
Power Trainaxle Assemblyaxle Shaft
3 complaints
Power Traintransfer Case 4 Wheel Drive
3 complaints
Seat Beltsfront
3 complaints
Seats
3 complaints
Service Brakes Hydraulicfoundation Componentsdisccaliper
3 complaints
Service Brakes Hydraulicfoundation Componentsmaster Cylinder
3 complaints
Steering Steering Wheelhandle Bar
3 complaints
Tirestemporaryemergency Spare Tire
3 complaints
Tiresvalve
3 complaints
Visibilitysunmoon Roof Assembly
3 complaints
Visibilitywindshield
3 complaints
Visibilitywindshield Wiperwasher
3 complaints
Wheelsrim
3 complaints
Electrical Systemalternatorgeneratorregulator
2 complaints
Electrical Systemwiringfront Underhood
2 complaints
Engine And Engine Coolingexhaust System
2 complaints
Equipmentapplianceair Conditioner
2 complaints
Equipmentelectrical
2 complaints
Exterior Lightingfog Lights
2 complaints
Exterior Lightingtail Lights
2 complaints
Exterior Lightingturn Signal
2 complaints
Fuel System Gasolinedelivery
2 complaints
Fuel System Gasolinestoragetank Assemblymounting
2 complaints
Fuel System Otherfuel Injection System
2 complaints
Power Trainautomatic Transmissiongear Position Indication Prndl
2 complaints
Power Trainaxle Hubs
2 complaints
Power Trainmanual Transmission
2 complaints
Seat Beltsfrontbuckle Assembly
2 complaints
Service Brakes Airdiscrotor
2 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipcontrol Unitmodule
2 complaints
Service Brakes Hydraulicfoundation Componentsdrum
2 complaints
Service Brakes Hydraulicpedals And Linkages
2 complaints
Steeringcolumn
2 complaints
Steeringhydraulic Power Assist System
2 complaints
Steeringlinkages
2 complaints
Steeringlinkagestie Rod Assembly
2 complaints
Structurebodydoor
2 complaints
Structurebodydoorhinge And Attachments
2 complaints
Structurebodytailgatehinge And Attachments
2 complaints
Suspensionfrontcontrol Armupper Ball Joint
2 complaints
Suspensionfrontspringscoil Springs
2 complaints
Visibilitydefrosterdefoggerhvac System
2 complaints
Visibilityrear Window Wiperwasher
2 complaints
Air Bagsfrontalsensorcontrol Module
1 complaint
Electrical Systemignition
1 complaint
Electrical Systemignitioncoilspark Plugs
1 complaint
Electrical Systemsoftware
1 complaint
Electrical Systemwiringfuses And Circuit Breakers
1 complaint
Electrical Systemwiringinteriorunder Dash
1 complaint
Electronic Stability Control Esc
1 complaint
Engine And Engine Coolingcooling Systemhoseslinespipingfittings
1 complaint
Engine And Engine Coolingenginegasolinebelts And Associated Pulleys
1 complaint
Engine And Engine Coolingexhaust Systememission Control
1 complaint
Equipmentelectricalradiotape Deckcd Etc
1 complaint
Equipmentmechanicalcarrierrack
1 complaint
Equipmentrecreational Vehicletrailerlpg Systemslines And Fittings
1 complaint
Exterior Lightingturn Signalswitch
1 complaint
Firerelated
1 complaint
Forward Collision Avoidance Warnings
1 complaint
Fuel System Diesel
1 complaint
Fuel System Gasolinefuel Injection System
1 complaint
Fuel System Gasolinefuel Injection Systemfuel Rail
1 complaint
Fuel System Gasolinefuel Injection Systeminjectors
1 complaint
Fuel System Otherdeliveryfuel Pump
1 complaint
Fuel System Otherdeliveryhoses Linespiping And Fittings
1 complaint
Fuel System Otherstoragefuel Gauge System
1 complaint
Fuel System Otherstoragetank Assembly
1 complaint
Power Trainautomatic Transmissioncooling Unit And Lines
1 complaint
Power Trainautomatic Transmissionparkneutral Start Interlock Switch
1 complaint
Power Trainautomatic Transmissiontorque Converter
1 complaint
Power Traindrivelinecenter Support Bearing
1 complaint
Power Traindrivelineuniversal Joint
1 complaint
Power Trainshift Linkagecablerod
1 complaint
Seat Beltsfrontanchorage
1 complaint
Seat Beltsfrontretractor
1 complaint
Seat Beltsfrontwebbing
1 complaint
Seat Beltsintegrated Child Seat
1 complaint
Seatsmidrear Assembly
1 complaint
Service Brakes Airantilockcontrol Unitmodule
1 complaint
Service Brakes Hydraulicfoundation Components
1 complaint
Service Brakes Hydraulicpower Assistvacuum
1 complaint
Steeringgear Box Other Than Rack And Pinion
1 complaint
Steeringgear Boxshaft Pitman
1 complaint
Steeringhydraulic Power Assistpump
1 complaint
Structurebodybumpers
1 complaint
Structurebodyhoodhinge And Attachments
1 complaint
Structurebodytailgate
1 complaint
Suspensionfrontcontrol Armlower Ball Joint
1 complaint
Suspensionfrontstabilizer Bar
1 complaint
Suspensionmultiple Axle
1 complaint
Suspensionrearaxlespindle
1 complaint
Tiresbead
1 complaint
Vehicle Speed Controllinkages
1 complaint
Visibilitydefrosterdefoggerhvac Systemheater Core
1 complaint
Visibilityrear Window Wiperwasherlinkages
1 complaint
Visibilityrearview Mirrorsdevices
1 complaint
Visibilityrearview Mirrorsdevicesexterior
1 complaint
Wheelshub
1 complaint
Wheelslugsnutsboltsstuds
1 complaint