2002 FORD F-150 Engine And Engine Coolingengine Problems

TURNED OVER MY 2002 FORD F-150. A LOUD POP OCCURRED AS A SPARK PLUG/COIL PACK BLEW OUT. THIS IS THE 3RD COIL PACK THAT HAS BLOWN SINCE APRIL OF 2009. THEY FIX IT EVERY TIME BY HAVING TO REPLACE THE COIL PACK AND SPARK PLUG, ALONG WITH HAVING TO RE-TAP THE HEAD. LUCKILY, THIS TIME, I WAS IN A GROCERY STORE PARKING LOT. THE LAST TWO TIMES, MY WIFE AND I WERE DRIVING THE TRUCK WHEN IT HAPPENED, WHICH PLACED US IN DANGER BECAUSE IT COULD HAVE CAUSED AN EXPLOSION. I KNOW THERE ARE QUITE A FEW OTHER PEOPLE SAYING THE SAME THINGS ABOUT THAT HAPPENING TO THEM MULTIPLE TIMES. I THINK IT'S TIME THAT FORD PUSHES A RECALL THROUGH DEALING WITH THE COIL PACKS, AS MORE AND MORE PEOPLE ARE AFFECTED BY THE SAME ISSUE, BEFORE SOMEONE IS SERIOUSLY HURT AS A RESULT. *TR

WENT TO MAKE AN APPOINTMENT WITH FIRESTONE TO HAVE MY PLUGS CHANGED PER FORD MANUAL ON MY 2002 F150 5.4 LITER V8. IT WAS TOLD TO ME THAT THEY WOULD NOT TOUCH THE VEHICLE AS I SHOULD CONTACT FORD DIRECTLY. THEY CLAIM THE PLUGS EXPLODE. WE THEN CALLED THE FORD DEALER SERVICE DEPARTMENT IN SAYVILLE THE WOMAN STATED AT SAYVILLE FORD SERVICE DEPARTMENT THE PLUGS WOULD COST TO REPLACE $ 383.00 UNLESS THE PLUGS EXPLODE INSIDE THE ENGINE WHEN REMOVED THEN IT WOULD COST 1/2 HOUR MORE PER PLUG AS THEY ARE HAVING PROBLEMS WITH THE PLUGS EXPLODING IT COULD RUN UP TO A TOTAL COST OF$ 800.00 MAX TO REMOVE. SOMETHING ABOUT NEW SLEEVE HAS TO BE REPLACED WHEN IT EXPLODES. I WAS REALLY IRATE WE ARE ONLY TALKING ABOUT PLUGS. I THEN CONTACTED FORD AT 1 800 392-3673 AT CUSTOMER RELATIONSHIP CENTER CLAIMS THEY KNOW NOTHING ABOUT THIS...

I WAS DRIVING HOME FROM WORK DOING ABOUT 35MPH AND A LARGE AND LOUD POP FOLLOWED BY REPEATED QUIETER POPPING SOUND UNTIL I SHUT THE ENGINE OFF. I LOOKED UNDER THE HOOD AND CONFIRMED MY SUSPICION. A SPARK PLUG EJECTED FROM THE #3 CYLINDER. I HAD TO HELICOIL THE HEAD TO FIX IT, OTHERWISE THE DEALERSHIP WANTED $1800 TO REPLACE THE HEAD. 2 MONTHS LATER DRIVING TOO WORK THE #2 CYLINDER EJECTED ITS SPARKPLUG. SAME FIX. I'M TO WORRIED TO DRIVE THE TRUCK AT THIS POINT AND HAVEN'T DRIVEN IT SINCE. *TR

2002 FORD F-150 WITH A 5.4L TRITON V8. THE #7 SPARK PLUG BLEW OUT OF THE PORT AND BROKE THE COIL. THAT LEFT FUEL VAPORS FROM THE PISTON TO BE EXPOSED TO THE DAMAGED IGNITION COIL THAT WAS ARCING AND COULD OF CAUGHT FIRE WITH MY KIDS IN THE TRUCK. IF YOU LOOK ONLINE THERE ARE THOUSANDS OF COMPLAINTS FROM F150 OWNERS. THIS NEEDS TO BE ADDRESSED AND A RECALL FROM FORD NEEDS TO BE ISSUED. *TR

I HAVE A FORD F-150 THAT HAS A TRITON V-8 MOTOR. IT HAS 110,000 MILES. I HAVE HAD THE TRUCK FOR 3 YEARS AND PURCHASED IT WITH A 5 YEAR LOAN AGREEMENT. I WAS DRIVING AND THE SPARK PLUG BLEWOUT OF THE MOTOR. APPARENTLY THIS IS A COMMON PROBLEM,SO COMMON THAT THEY HAVE A KIT THATS A QWIK FIX. EVIDENTLY A PREVIOUS OWNER HAD THIS PROBLEM AND PUT THE KIT ON THERE GOT RID OF THE CAR AND IT WAS SOLD TO ME BY TOWN TOYOTA IN ROXBURY, NEW JERSEY. IT BLOWS MY MIND THAT I BOUGHT IT WITH 65,000 MILES AND IT ALREDY HAD A MAJOR PROBLEM NOT ONLY ONCE WITH A PREVIOUS OWNER BUT ALSO HAPPENED TO ME. NOW THE ONLY FIX IS TO REPLACE THE HEAD OF THE MOTOR OR EVEN REPLACING THE ENTIRE MOTOR.I HAVE COME INTO HARD TIMES WITH BEING LAID OFF FROM WORK AND...

MY 2002 FORD F150 WITH A 5.4 L TRITON V8 ENGINE SPIT OUT A SPARK PLUG FOR NO APPARENT REASON. MY F150 HAS 117,000 MILES ON IT AND HAS HAD NO MECHANICAL PROBLEMS OVER IT'S LIFE. IT IS SERVICED REGULARLY AND IS USED FOR ROUTINE DRIVING. I HAPPENED TO BE 30 MILES FROM HOME WHEN I HEARD A LOUD TAPPING COMING FROM THE ENGINE COMPARTMENT. KNOWING A LITTLE ABOUT ENGINES I CHECKED TO SEE WHAT HAD HAPPENED AND NOTICED THAT THE SPARK PLUG HAD BEEN PUSHED OUT OF THE CYLINDER HEAD, CAUSING THE COMPRESSION TO CAUSE IT AND THE COIL PACK TO CONTINUALLY STRIKE THE FUEL RAIL. FORTUNATELY I KNEW A MECHANIC IN THE AREA 1/4 MILE FROM MY LOCATION AND SLOWLY DROVE TO HIS SHOP. HE SAID THAT IT WAS A COMMON PROBLEM WITH FORD 4.6, 5.4 AND 6.8 TRITON ENGINES. HE ADDED THAT THE ALUMINUM USED FOR THE...

IN APRIL OF 2010 MY F-150 TRUCK "SPIT" A SPARK PLUG WHILE TRAVELING AT FREEWAY SPEED. THIS WAS A DANGEROUS SITUATION SINCE IT WAS DURING RUSH HOUR AND MANY 18 WHEEL TRUCKS WERE TRAVELING DOWN THE I-5 AT THE TIME AND WERE RELUCTANT TO ALLOW A CAR TO PULL OVER. I HAD THE TRUCK FIXED AT A AAA APPROVED REPAIR STATION WHICH REMOVED THE REMAINING SPARK PLUG, RETAPPED THE BLOCK, INSTALLED AN INSERT AND NEW PLUG. THEN, THE SAME THING HAPPENED AGAIN IN OCTOBER OF 2010 TO A DIFFERENT PLUG. AGAIN I HAD THE TRUCK REPAIRED IN THE SAME MANNER. THE RISK OF FIRE AND COLLISION WAS DIRECTLY CAUSED BY THE FAILURE OF THESE SPARK PLUGS. *TR

EVENTS LEADING UP TO THE FAILURE WOULD HAVE TO BE...EVERYDAY DRIVING.... THE FAILURE - FOR THE THIRD TIME NOW, A SPARK PLUG EJECTED FROM THE CYLINDER HEAD. CONSEQUENCES - $800 FORD DEALERSHIP PARTS/LABOR, PLUS 2 TOW TRUCK SERVICES. NEW PLUG, INSERT, AND COIL. *TR

ON SEPTEMBER 28TH 2010 I WAS DRIVING FROM INDIANAPOLIS, IN TO LOUISVILLE, KY ON A VERY BUSY I-65 INTERSTATE. AT APPROXIMATELY 4PM I HEARD A VERY LOUD POP AND LOST ALL POWER. I COULD HEAR A VERY LOUD BANGING NOISE AND AT FIRST I THOUGHT I BLEW A TIRE. I IMMEDIATELY TRIED TO GET FROM THE FAST LANE TO THE EMERGENCY LANE BUT WITH AS MANY CARS ON THE ROAD THIS WAS DIFFICULT. I FINALLY MADE IT TO THE EMERGENCY LANE AND TURNED MY FLASHERS ON. WHEN I GOT OUT OF MY VEHICLE I CHECKED FOR A FLAT TIRE BUT THAT WAS NOT THE ISSUE. I RESTARTED THE TRUCK AND LIFTED THE HOOD OF MY ENGINE. I NOTICED THAT ONE OF MY COIL POWER PACKS WAS AT A WEIRD ANGLE. WHEN I WENT TO CHECK IF IT WAS STILL ATTACHED THE COMPRESSION OF MY NUMBER 2 CYLINDER BLEW THE SPARK...

2002 F-150 FORD 4.6 V-8 SPARK PLUG EJECTION. FIRST TIME HAPPENED ON JUNE 20 2008 IN THE NUMBER 3 CYLINDER TRUCK SHOWING 160,000 KMS. I REMOVED THE HEAD SENT IT TO MACHINE SHOP TO BE REPAIRED. 11 MONTHS LATER(182000) THE HELI-COIL THAT WAS INSTALLED CAME OUT WITH THE SPARK PLUG. REMOVED THE HEAD AND INSTALLED REMAN HEAD (ON RIGHT SIDE) DURING THE SPRING OF 2010 I STARTED TO LOOSE COMPRESSION ON ALL CYLINDERS, RANGING FROM 0-90 LBS AND THE BEST CYLINDER AT 120 LBS) BROUGHT IT TO A FORD DEALER, AND RESULTS SHOWED LEAKING WAS AROUND SPARK PLUGS. FORD DECLARED I NEED A NEW ENGINE. I AM LUCKY ENOUGH TO BE ABLE TO DO MY OWN REPAIRS. I PURCHASED A USED ENGINE FROM A WRECKER AND INSTALLED @ 190000KMS IN JULY 2010. I HAVE SPENT OVER $4000.00 ON THIS PROBLEM, AND I AM NOT DUMB ENOUGH TO CHANGE SPARK PLUGS...

STARTING FROM A STOPLIGHT, I HEARD A SUDDEN POP AND SMELLED GAS. LOUD CLICKING OR POPPING NOISE CAUSED ME TO TURN AROUND AND HEAD STRAIGHT TO THE DEALER. THEY SAID A SPARK PLUG BLEW OUT, DAMAGING THE COIL. INITIAL ESTIMATE OF $500 GREW TO $3600 AS THEY SAID THEN THAT THE HEAD WOULD NEED TO BE REPLACED DUE TO DAMAGE THERE AS WELL. RESEARCHING THIS PROBLEM, IT APPEARS THAT THERE ARE QUITE A FEW (MANY MANY MANY) FORD OWNERS WITH THIS PROBLEM! WHY IS THERE NO RECALL? IMMEDIATE SAFETY OR NOT, THIS IS AN OBVIOUS DEFECT. *TR

TL* THE CONTACT OWNS A 2002 FORD F-150. WHILE TRAVELING AT 25 MPH, THERE WAS AN UNUSUAL POP FROM THE FRONT END OF THE VEHICLE. IMMEDIATELY, THERE WAS AN ABNORMAL AIR PRESSURE RELEASE SOUND. THE DEALER ADVISED THAT THE ENGINE HEAD WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THERE WERE NO PRIOR WARNINGS OF THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 106,000.

2002 F-150 HISTORY - HAVE HAD TO REPLACE 4 COILS. 2 WERE BURNED OUT AND 2 WERE DAMAGED FROM THE SPARK PLUG BLOWING OUT THE HOLE, THIS LAST TIME JUST RECENTLY (JUNE 2010). *TR

FORD TRITON V8-4.6L SPARK PLUG EJECTION ON #2 PLUG. THIS HAS NOW HAPPENED TO ME AS I WAS DRIVING AT 60MPH AND IT BLEW IT OUT AND THE COIL SPRING IS NOW DOWN ON TOP OF THE PISTON AND SMASHED WITHIN SECONDS. TOWED TO FORD DEALERSHIP AND MECHANIC ADMITTED THIS WAS COMMON BUT NO RECALLS. HE SCOPED THE CYLINDER WITH BORE SCOPE TO FIND THE COIL SPRING SMASHED SO BAD IT COULD NOT BE RETRIEVED. ESTIMATED COST IS $3500.00 PLUS REMOVE HEAD AND CLEAN OUT. CAN I CLAIM THIS BACK TO FORD? *TR

SPARK PLUG EJECTED FROM ENGINE. *TR

2002 FORD F150 SPARK PLUG FAILED. *NJ THE CONSUMER WAS CHARGED $2,600 TO FIX THE PROBLEM. *JB

WELL THE EVENTS LEADING UP TO THE FAILURE....THERE WERE NONE WE WERE DRIVING BACK HOME WHEN ALL OF A SUDDEN POP AND THERE GOES MY #3 SPARK PLUG. WELL I WAS STRANDED FOR TWO HOURS OR MORE UNTIL I GOT MY TRUCK TOWED TO MY HOUSE. THE ESTIMATED PRICE ON A REPAIR FOR THAT IS $1700 TO TAKE THE CYLINDER HEAD APART AND INSTALL AN INSERT AND THAT PRICE IS JUST FOR LABOR NO CHARGE ON PARTS YET. THIS IS A COMMON PROBLEM THAT IF YOU LOOK ONLINE YOU WILL SEE THAT MANY PEOPLE HAVE THE SAME PROBLEM. WE NEED TO MAKE FORD STAND UP FOR THEIR MISTAKE BEFORE SOMEONE LOOSES THEIR LIFE DO TO AN OPEN SPARK AND FUEL BEING PRESENT AND EXPOSED WHEN THE SPARK PLUG BLOWS OUT. *TR

I HAVE A 2002 FORD F150 SUPERCREW HARLEY DAVIDSON EDITION WITH A TRITON 5.4 L ENGINE. I PLACED THE TRUCK IN DRIVE AND HEARD A POP AND THEN A CONTINUED RHYTHMIC POPPING. I OPENED THE HOOD AND COULD TELL AIR WAS COMING FROM THE #4 CYLINDER. I TURNED OFF THE ENGINE AND INVESTIGATED FURTHER. THE SPARK PLUG HAD BLOWN COMPLETELY OUT OF THE HEAD AND BROKE THE IGNITION COIL ATTACHED TO THE SPARK PLUG WIRE. SO FAR THIS IS THE ONLY INCIDENT FOR ME BUT AFTER RESEARCHING ONLINE, FOR POSSIBLE REPAIRS SOLUTIONS, I FOUND THAT THIS IS WAY TOO COMMON OF A PROBLEM WITH THESE FORD ENGINES. I AM ONLY GLAD IT HAPPENED WHILE I WAS PULLING OUT OF MY GARAGE. IF THAT HAD HAPPENED AT SPEED ON THE HIGHWAY WITH THE ENGINE TEMPERATURE UP THERE COULD HAVE BEEN A SERIOUS SITUATION. AFTER READING ALL THE PROBLEMS SO MANY OTHERS...

TL*THE CONTACT OWNS A 2002 FORD F-150. WHILE THE CONTACT WAS DRIVING 75 MPH SHE SUDDENLY HEARD A LOUD POPPING SOUND IN THE ENGINE AND IMMEDIATELY THE VEHICLE SHUT OFF. A LOCAL MECHANIC STATED THAT THE ENGINE SEIZED AND NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS AND THE CURRENT AND FAILURE MILEAGES WERE 100000. UPDATED 11/13/09. *LJ UPDATED 11/16/09.*JB

THE SPARK PLUGS ARE BEING BLOWN OUT OF CYLINDER HEADS ON ALL SIZE TRITON ENGINES. THIS OCCURRED ON MY 2002 FORD F150, AND ON MY FATHER IN-LAWS EXPEDITION. THIS WAS ON A TRITON V-8 AND V-10S. WHEN I TOOK IT TO THE DEALERSHIP IN FT WAYNE INDIANA THEY INFORMED ME THAT THIS IS COMMON ON THESE ENGINES I ALSO SPOKE WITH FORD CUSTOMER CARE AND THEY CLAIM THAT THIS IS COMMON. THEY WONT RECALL IT BECAUSE THEY CLAIM THAT THIS IS NOT A SAFETY ISSUE. I FEEL THAT THIS IS A SAFETY ISSUE BECAUSE IT DOES NOT SHUT OFF THE FUEL SUPPLY TO THAT CYLINDER. NOT TO MENTION IT JUST HAPPENS WITH OUT ANY SORT OF WARNING LUCKILY I WAS ABLE TO LIMP MY TRUCK TO THE CLOSEST FORD DEALERSHIP IN MY AREA. WITH MY FATHER IN -LAWS EXPEDITION HE WAS JUST OUTSIDE OF TOWN ON HIS WAY TO ARKANSAS...

TL*THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT HE WAS ALERTED BY THE FIRE DEPARTMENT THAT HIS VEHICLE WAS ON FIRE. AS A RESULT THE VEHICLE WAS COMPLETELY DESTROYED. THE VEHICLE HAS NOT BEEN INSPECTED BY A TECHNICIAN. THE CURRENT AND FAILURE MILEAGES WERE 140000.

THERE WAS NO EVENTS LEADING UP TO OUR PROBLEM WITH OUR PICK UP TRUCK. I STARTED THE TRUCK AND HEARD A LOUD BANG AND THEN THE TRUCK SOUNDED LIKE IT WAS MISSING. WE FOUND OUT THAT THE 3RD SPARK PLUG ON THE PASSENGER SIDE OF THE MOTOR BLEW OUT. IT HASN'T BEEN FIXED YET IT HAPPENED YESTERDAY 8/17/09. *TR

MY 2002 FORD F150 TRUCK, WITH THE 5.4 LITER ENGINE, HAS HAD 2 FAILURES ON 2 DIFFERENT OCCASIONS IN THE SPACE OF 8 MONTHS. EACH TIME I WAS JUST DRIVING DOWN THE HIGHWAY AND A SPARK PLUG WAS BLOWN OUT OF THE HEAD, ALONG WITH THE COIL. (PLUG #3 THE FIRST TIME AND #7 THE LAST TIME.) THIS FAILURE CAUSED AN IMMEDIATE LOSS OF POWER. LUCKILY THE TRAFFIC WAS LIGHT EACH TIME, BEING LATE AT NIGHT, SO I WAS ABLE TO PULL SAFELY TO THE SIDE OF THE ROAD TO DETERMINE THE PROBLEM, WHEREAS IF THE TRAFFIC HAD BEEN HEAVY, IT COULD HAVE CAUSED A MAJOR ACCIDENT BECAUSE OF THE IMMEDIATE POWER LOSS TO THE ENGINE, AND/OR A FIRE DUE TO IT PROXIMITY TO THE INJECTORS. THE DEFECTS WERE REPAIRED AT THE LOCAL FORD DEALERSHIP WHERE THE TRUCK WAS PURCHASED USING A THREADED INSERT INTO THE OLD HEAD AND A...

FORDF150 2002 MODEL WAS DRIVING DOWN HWY 11W APPROXIMATELY 45 MILE AN HOUR AND HEARD LOUD BANG THE #5 SPARK PLUG HAD BLOWN OUT OF ENGINE SPITTING FUEL THE ENGINE IS 5.4 TRITION V8 IT BROKE THE COIL PACK AND BUSTED THE FUEL RAIL ON PICK UP TRUCK IS THE A RECALL ? OR NEEDS TO BE RECALLED ANY SUGGESTIONS AS TO HOW TO FIX THIS ISSUE? *TR

I OWN A2002 FORD F150. IT HAS ABOUT 80,000 MILES AND IT BLEW A SPARK PLUG OUT OF THE ENGINE. *TR

WHILE DRIVING AT 45 MPH ON LEVEL SURFACE THE #5 SPARK PLUG WAS EJECTED FROM IT'S HOLE DAMAGING THE COIL OVER PLUG CAUSING ARCING FROM THE COIL TO THE ENGINE. THE VEHICLE IMMEDIATELY SLOWED DRAMATICALLY AND THE SMELL OF GASOLINE WAS APPARENT. LUCKILY THERE WAS VERY LIGHT TRAFFIC AND I WAS ABLE TO PULL TO THE SIDE OF THE ROAD AND SHUTDOWN THE ENGINE. I IDENTIFIED THE PROBLEM AND HAVING SOME MECHANICAL TRAINING KNEW ENOUGH TO DISCONNECT THE FUEL INJECTOR WIRE FOR THE #5 CYLINDER. THIS WAS THE ONLY WAY I COULD SAFELY MOVE THE VEHICLE. HAD I NOT KNOWN WHAT TO DO, AN ENGINE COMPARTMENT EXPLOSION WOULD HAVE EASILY RESULTED. *TR

MY 2002 F150 RECENTLY SPIT OUT A SPARK PLUG, STRIPPING THE THREADS OF THE ALUMINUM CYLINDER HEAD. THE SERVICE SHOP WHERE I TOOK IT TOLD ME THAT IT'S BEEN A MAJOR PROBLEM WITH FORD TRUCKS FOR SOME TIME, AND REFUSED TO FIX IT. *TR

TL*THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING 35 MPH, THE SPARK PLUGS FAILED. THE CONTACT PULLED THE VEHICLE OVER AND EXAMINED UNDERNEATH THE HOOD. A WITNESS STATED THAT THERE WAS A NOISE WHEN THIS OCCURRED. THE VEHICLE WAS RESTARTED AND POPPING NOISES WERE HEARD. THE VEHICLE WAS TOWED TO A FORD DEALER AND THEY STATED THAT NOTHING COULD BE DONE AND THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIRS. THERE WERE NO COMPLAINTS FOUND FOR THIS VEHICLE. THE VEHICLE HAS BEEN REPAIRED. THE FAILURE MILEAGE WAS 43,332 AND CURRENT MILEAGE WAS 43,600.

DRIVING TO PICK UP MY SON AT SCHOOL FOR A TRIP. AS I TURNED LEFT ACROSS TRAFFIC I HEARD A LOUD POP IN MY 2002 FORD F150 AND THEN A LOUD SERIES OF LOUD POPS AS MY ENGINE CONTINUED TO RUN. I PULLED TO THE SIDE OF THE ROAD AND IMMEDIATELY NOTICED A STRONG SMELL OF GASOLINE. I MOVED THE VEHICLE TO A PARTS STORE JUST UP THE STREET AND WAS TOLD THAT MY TRITON V-8 ENGINE HAD JUST EJECTED A SPARK PLUG OUT OF THE HEAD. I HAD THE VEHICLE TOWED TO A MECHANIC WHO THEN CHARGED ME A GREAT DEAL TO REPAIR THE HEAD AND REPLACE THE SPARK PLUG. *TR

NORMAL DRIVING CONDITIONS ON THE FREEWAY - SPARK PLUG DISCHARGED OUT OF THE MOTOR. VEHICLE TOWED TO NEAREST AUTO REPAIR SHOP. TO REPAIR, THE HOLE FOR THE SPARK PLUG IN THE ALUMINUM HEAD WAS RETHREADED USING A STANDARD HELICOIL KIT. TWO SPARK PLUG HOLES HAVE BEEN REPLACED AT A COST OF $1100 PER HOLE FOR PARTS AND LABOR. *TR

2002 FORD F150 5.4 LITER ENGINE. TRAVELING AT APPROX 25 MPH I HEARD A LOUD POP FROM THE ENGINE COMPARTMENT AND SOMETHING HITTING THE HOOD. THE CAR STARTED TO RUN ROUGH AND GASOLINE FUMES STARTED TO FILL THE PASSENGER COMPARTMENT. I TOOK THE TRUCK TO A REPAIR GARAGE WHO INDICATED THAT A SPARK PLUG HAD BLOWN FROM THE HEAD. I WAS TOLD THIS IS A COMMON FORD PROBLEM BY THE GARAGE AND SUBSEQUENT RESEARCH ON THE INTERNET HAS VERIFIED THIS. THE HEAD WAS REMILLED AND THE PLUG AND COIL HAD TO BE REPLACED. FORD DOES ACKNOWLEDGE AN ISSUE AND HAS ISSUED A TSB HOWEVER WARRANTIES DO NOT COVER REPAIR. WITH THE PLUG BLOWN OUT OF THE HEAD GAS VAPORS WERE BEING INJECTED INTO THE ENGINE COMPARTMENT AND THE RISK OF FIRE IS PRESENT. *TR

WHILE BEING 250 MILES AWAY FROM HOME, THE SPARK PLUG BLEW OUT OF THE ENGINE OF MY 2002 F-150 TRUCK. I WAS ABLE TO BUY TOOLS AND PERFORM A TEMPORARY REPAIR IN ORDER TO GET MY TRUCK HOME. I THEN HIRED A MECHANIC TO REPAIR THE ENGINE USING A HELI-COIL. UNFORTUNATELY I DON'T TRUST THE TRUCK NOW AS I BOUGHT IT TO PULL MY CAMPER AND AM CONCERNED OVER BEING STRANDED. I WAS TOLD BY MY MECHANIC THAT IT IS A COMMON PROBLEM WITH THE 5.4 TRITON ENGINE. I AM NOT SURE WHY FORD HAS NOT PERFORMED A RECALL ON IT. *TR

TRUCK MAINTAINED ACCORDING TO MANUFACTURER SPECS. WHILE DRIVING DAUGHTER TO SCHOOL, HEARD LOUD POP. WAS ABLE TO MAKE IT TO LOCAL REPAIR SHOP. BLOWN SPARK PLUG OUT OF #2 CYLINDER. WITH THE USE OF HELICOIL REPAIRS CAME TO APPROX. $700. LESS THAN 6 WEEKS LATER #4 CYLINDER BLEW SPARK PLUG WHILE DRIVING 65 MILES PER HOUR ON THE FREEWAY. THIS TIME (AFTER MUCH RESEARCH OF SIMILAR COMPLAINTS) INSTALLED LONGER THREAD SPARK PLUGS SUGGESTED BY FORD PARTS DEPARTMENT. THIS TIME REPAIR COSTS WERE $800.00. IF FORD HAS MADE A SPECIAL KIT AND NEW LONGER SPARK PLUGS FOR THIS "PROBLEM" ISN'T THAT A SUBTLE ADMISSION OR GUILT/RESPONSIBILITY. WHAT EVER HAPPENED TO DOING THE RIGHT THING...ADMIT YOUR MISTAKES AND TAKE CARE OF THESE REPAIRS. "BUILT FORD TOUGH" MY EYE!! MY NEXT TRUCK WILL BE A TOYOTA... *TR

MY 2002 FORD F-150 WITH A 4.6 LITER V8 BLEW OUT A SPARK PLUG WHILE ACCELERATING ON A HIGHWAY ENTRANCE RAMP. THE SPARKPLUG THAT BLEW OUT WAS THE 3RD FROM THE FRONT ON THE PASSENGER SIDE. THE THREADS FOR THE SPARK PLUG IN THAT CYLINDER ARE NOW RUINED AS WELL AS THE COIL FOR THAT PLUG. TO REPAIR THIS PROBLEM I WILL PROBABLY END UP BUYING A $250 KIT TO RE-TAP THE HEAD. *TR

I HAVE A 5.4L ENGINE IN MY FORD TRUCK AND IT KEEPS STRIPPING OUT SPARK PLUGS. I AM NOT THE ONLY ONE WITH THIS PROBLEM. THERE ARE HUNDREDS IF NOT THOUSANDS OF PEOPLE THAT HAVE POSTED THE SAME PROBLEM ON CONSUMER AFFAIRS REPORT .COM. ONE GUYS TRUCK BURNT TO THE GROUND IN 12 MINUTES AND COULDN'T EVEN GET HIS NAVIGATION SYSTEM OUT OF HIS VEHICLE. FLAMES WERE SHOOTING OUT OF THE DASH TOWARDS HIM. I HAVE CONTACTED FORD WITH THE MATTER AND THEY STATE THAT IT IS NOT A SAFETY ISSUE AND YOU ARE THE ONES THAT HAVE TO RECALL IT. I WOULD SAY THAT IF YOUR VEHICLE CAN BURN TO THE GROUND IN A MATTER OF MINUTES, IT IS A SAFETY PROBLEM. THEY KNOW ABOUT THIS PROBLEM AND IT KEEPS HAPPENING TO PEOPLE ALL OVER AND THEY ARE NOT DOING ANYTHING ABOUT IT. A RECALL NEEDS TO BE CALLED...

TL*THE CONTACT OWNS A 2002 FORD F-150. WHILE DRIVING 65 MPH ON THE HIGHWAY, THE SPARK PLUGS STRIPPED OUT OF THE ENGINE BLOCK. THERE WERE NO PRIOR WARNINGS. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER FOR REPAIR. INSTEAD, HE SIMPLY NOTICED THE SPARK PLUG STICKING OUT FROM THE TOP OF THE HOOD. THE VEHICLE IS ABLE TO BE DRIVEN, BUT IT RIDES VERY ROUGHLY. THE FAILURE MILEAGE WAS 148,000.

I WAS DRIVING ALONG MN7 ON MY WAY HOME. I STOPPED AT A 4 WAY STOP. WHEN IT WAS MY TURN TO GO, I STARTED TO ACCELERATE AND THEN MY #5 SPARK PLUG BLEW OUT OF THE CYLINDER HEAD. THIS HAS HAPPENED BEFORE. ONE MAY 4TH 2008, #3 AND #4 BLEW OUT AND IT COST ME $2,000 TO FIX THIS. AFTER DOING SOME SEARCHING ON THE INTERNET, IT APPEARS THAT A LOTS OF FORD F150 OWNERS ARE HAVING THIS PROBLEM AND FORD WILL DO NOTHING TO FIX IT. *TR

THE # 3 SPARK PLUG SHOT OUT OF THE MY FORD F150 5.4 V8 TRITON ENGINE. THERE ARE NOT ENOUGH THREADS TO HOLD THIS IN CORRECTLY. THIS NEEDS TO BE RECALLED BY FORD. *TR

DRIVING 2002 FORD F-150 AND SUDDENLY ENGINE LOST POWER AND MADE POPPING SOUNDS. THIS HAPPENED ON VERY BUSY STREET NEARLY GOT REAR-ENDED AS POWER DRAMATICALLY FELL OFF. CHECKED ENGINE AND SPARK PLUG WAS BLOWN OUT AND COIL WAS DESTROYED ABOVE THE SPARK PLUG RIGHT UNDERNEATH FUEL RAIL. STRANDED ON SIDE OF BUSY ROAD FOR 2 HOURS UNTIL VEHICLE WAS TOWED TO DEALER. DEALER HAD TO USE HELIOCOIL AND REPLACED COIL COSTING APPROXIMATELY $600. *TR

VEHICLE POPPED OUT A SPARK PLUG FROM THE #7 CYLINDER UPON STARTING VEHICLE. SPARK PLUG WAS FOUND ON THE INTAKE MANIFOLD, COIL STILL PROVIDING SPARK. UNBRUNT FUEL MIXTURE WAS BEING VENTED FROM THE CYLINDER INTO THE ENGINE COMPARTMENT. I AM CONCERNED ABOUT FIRE HAZARD. *TR

VEHICLE STARTED MAKING LOUD NOISE UNDER THE HOOD, TURNED OUT TO BE A STRIPPED SPARK PLUG HOLE IN THE CYLINDER HEAD THAT LED TO COMPLETE REPLACEMENT OF HEAD. DEALERSHIP STATED THIS WAS THE 4TH ONE THIS YEAR, ALWAYS 2002 MODEL, 5.4 LITER ENGINE, ALWAYS RIGHT SIDE CYLINDER HEAD. IF A DEALERSHIP IN A TOWN OF LESS THAN 600 PEOPLE HAS A FAILURE RATE THIS HIGH, HOW BIG IS THIS PROBLEM NATION WIDE? *TR

I HAVE A 2002 FORD F-150 WITH 65,000 MILES ON IT. IT IS THE 4.2 LITER V-6 THAT HAS ALWAYS BEEN TAKEN CARE OF. THE MOTOR THREW A ROD AND NEEDED TO BE REPLACED AND STOPPED WITH A LOUD BANGING AND THE COST WAS 5,000 FOR A NEW LONG BLOCK BY LOCAL FORD DEALERSHIP. I HAVE LOOKED ON THE INTERNET AND SEEN HUNDREDS OF FOLKS HAVING TO HAVE THEIR SAME V-6 ENGINE GO OUT PREMATURELY. FROM 40,000 TO 100,000 MILES. THE PLASTIC INTAKE GASKETS ARE FAULTY AND IT GETS COOLANT ON THE SPARK PLUG IN CYLINDER AND MOTOR GOES OUT BY THROWING A ROD. FORD DOES NOT ACCEPT ANY RESPONSIBILITY FOR THIS LEMON ENGINE THAT SEEMS TO HAVE MANY DESIGN FLAWS STARTING FROM 1997 WHEN THEY STARTED PUTTING IT IN THEIR VEHICLES. *TR UPDATED 09/19/07 *TR

2002 FORD F-150 5.4L V-8 ENGINE HAS A BLOWN SPARK PLUG, FORD REFUSES TO ACCEPT RESPONSIBILITY FOR THE HEAD FAILURE. THEY MAKE A KIT FROM A 1987 OR SO ESCORT THAT HAD THE SAME PROBLEM AND THEY FIXED THOSE VEHICLES. *TR

IN THE MIDDLE OF JULY OF 07, MY WIFE, GRANDDAUGHTER AND I WERE COMING HOME FROM VACATION IN IDAHO, BY YORK, NE. THE TRUCK WAS ALL OF A SUDDEN RUNNING ROUGH. I WAS UNABLE TO FIND A MECHANIC TO LET ME KNOW WHAT WAS WRONG. I HAD TO DRIVE THE VEHICLE HOME. I CALLED MY SON IN IDAHO, WHO IS A MECHANIC AND HE LISTENED TO THE VEHICLE OVER THE PHONE. HE TOLD ME THAT IT SOUNDED LIKE A SPARK PLUG HAD BLOWN OUT. I LOOKED AND SAW THE PLUG ON TOP OF THE ENGINE. I CALLED AROUND AND FOUND OUT IT WAS GOING TO COST OVER 2000.00 FOR THE JOB. THEN I FOUND OUT THAT FORD HAD MADE A KIT FOR IT. IN OVER 40 YEARS OF DRIVING I HAVE NEVER HEARD OF SUCH A THING. IF FORD MADE A KIT FOR IT, THEN IT SEEMS TO ME THAT...

TL*THE CONTACT OWNS A 2002 FORD F150. THE CONTACT STATED THAT THE SPARK PLUG INJECTION ON THE NUMBER THREE CYLINDER IS DEFECTIVE. THE VEHICLE BEGAN SPILLING RAW FUEL INTO THE ENGINE COMPARTMENT. HE HAS TAKEN HIS VEHICLE TO THE DEALER AND THEY STATED THAT THIS IS SOMETHING THAT JUST HAPPENS AND THE VEHICLE IS NOT COVERED UNDER WARRANTY. CURRENTLY, THE VEHICLE IS AT THE DEALER, WHERE IT HAS BEEN FOR ELEVEN DAYS. THE CURRENT AND FAILURE MILEAGES WERE 104,000. THE CONSUMER PROVIDED FOR REPAIRS AND A LETTER FROM FORD MOTOR COMPANY REFERENCING THE DEFECT. UPDATED 08/07/07 *TR

TL*THE CONTACT OWNS A 2002 FORD F-150 HARLEY DAVIDSON EDITION. THE CONTACT STATED THAT THE SPARK PLUGS HAVE BEEN BACKING OUT. AS A RESULT, THE FAILURE HAS BLOWN THE COIL AND DAMAGED THE HEAD, WHICH NEEDS TO BE REPLACED. THE DEALER HAS WITNESSED THIS FAILURE BEFORE, BUT CANNOT OFFER AN EXPLANATION. ACCORDING TO A SITE THAT THE CONTACT VISITED, THIS HAS BEEN A FAILURE WITH THE SUPERCHARGED VEHICLES. HE HAS NOTIFIED FORD, BUT THEY HAVE NOT YET RESPONDED. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 50,000 AND FAILURE MILEAGE WAS 49,885. UPDATED 06/08/07. *JB

76000 MILES FORD F150 4.2L V6 WITH A P0174 CODE REPLACED INTAKE MANIFOLD GASKET ,MAF SENSOR. $750 DOLLARS LATER TRUCK RUNS FINE BUT WAS TOLD BY THE MECHANIC THIS WILL HAPPEN AGAIN ! FIRST AND LAST FORD I WILL HAVE . *AK

VEHICLE WAS ALWAYS MAINTAINED CORRECTLY, WHILE DRIVING AT APPROXIMATELY 25-30 MILES PER HOUR, THERE WAS A SUDDEN POPPING NOISE, VEHICLE LOST POWER WHICH STARTLED THE DRIVER AND CAUSED THE VEHICLE TO CRASH OFF THE ROAD. VEHICLE WAS RETURNED TO THE ROAD AND BROUGHT TO A PARKING LOT. NEXT DAY THE VEHICLE WAS TOWED TO MECHANIC AND IT WAS DISCOVERED THAT THE SPARK PLUG WAS BLOWN FROM THE ALUMINUM HEAD. MECHANIC TAPPED THE HEAD AND OWNER WAS FORCED TO SPEND $600 DOLLARS, OR REPLACE ENTIRE HEAD FOR $3500. MINOR VEHICLE DAMAGE DUE TO ACCIDENT, IF THIS OCCURRED AT HIGHER SPEED UNKNOWN WHAT COULD HAVE HAPPENED. PREGNANT WOMAN IN THE VEHICLE WHO WAS EXTREMELY SCARED DUE TO NOISES AND EXHAUST BLOWING INTO CABIN OF 02 F150 V8. *NM

I HAVE A F150 2002 FORD PICKUP WITH 55,000 MILES ON IT. MY PARENTS AND I HAD JUST FINISHED LUNCH AND GOT IN MY TRUCK. I TURNED THE KEY AND WE HEARD 2 LOUD POPPING NOISES AND THE MOTOR STARTED RUNNING ROUGH (PULSING). TURNED THE VEHICLE OFF, OPENED THE HOOD ONLY TO DISCOVER THE SPARK PLUG HAD BLOWN OUT OF THE #8 HOLE AND WAS LAYING DOWN IN A CREVICE ON THE ENGINE AND THEN ROLLED OUT OF SIGHT. WE HAD TO CALL A FLATBED TOW TRUCK AND WERE TOWED 82 MILES BACK TO NORTH COUNTRY FORD, COON RAPIDS, MN ON A SATURDAY NIGHT WHERE WE LEFT THE VEHICLE. ON MONDAY MORNING I FOUND OUT TO MY SURPRISE FROM THE SERVICE DEPARTMENT AT NORTH COUNTRY FORD THAT THE EXTENDED WARRANTY I HAVE ON THE TRUCK WOULD NOT COVER THE $2,300 COST. NORTH COUNTRY SENT OUT THE HEAD TO HAVE THE...

FORD F-150 BLEW OUT A SPARK PLUG FROM THE HEAD, THIS IS A KNOWN PROBLEM AND HAS HAPPENED TO THOUSANDS OF PEOPLE AND FORD REFUSES TO DO ANYTHING ABOUT IT. AVERAGE COST OF REPAIR TO THE CUSTOMER IS 3500. *JB