2002 FORD F-150 Power Trainautomatic Transmission Problems

IN MY CASE THERE WERE THREE SEPARATE OCCURRENCES WHERE MY SPARK PLUGS SHOT OUT OF MY ENGINE. THE FIRST TIME IT HAPPENED ON THE HIGHWAY CRUISING ALONG ABOUT 70 MPH. I ACTUALLY THOUGHT I BLEW A TIRE.THIS WAS AT NIGHT SO IN THE MORNING I CHECKED IT OUT WITH A FRIEND'S HELP AND SAW THE PLUG SITTING RIGHT WHERE IT WASN'T SUPPOSED TO BE. SO WE WENT AND BOUGHT A NEW PLUG AND COIL PACK AND THREADED IT BACK IN AND BELIEVE IT OR NOT IT STAYED THERE AND STILL IS THERE TODAY. THIS FIRST TIME WAS ROUGHLY 3 1/2 YRS AGO. THE NEXT TIME IT HAPPENED WHILE MY SAME FRIEND WAS DRIVING MY TRUCK TO HIS HOUSE BUT THIS TIME IT WAS A DIFFERENT PLUG AND WE WEREN'T SO LUCKY THREADING IT BACK IN. THE THREADS WERE STRIPPED OUT SO WE HELICOILED IT BACK IN OURSELVES AND IT IS...

MY 2002 F-150 SUPERCREW 4X2 WITH 4.6LV8 EXPERIENCED A FAILURE OF THE AUTOMATIC TRANSMISSION ON SATURDAY AT ONLY 75K MILES. THE RESULT IS A REBUILD/REPLACEMENT FOR >$2000.00! I DON'T TOW ANYTHING WITH THE VEHICLE AND IT ISN'T ABUSED. THIS TYPE OF FAILURE IS VERY PREMATURE! THE TRUCK HAS BEEN VERY WELL MAINTAINED. MY MECHANIC SAYS THERE IS A HISTORY WITH THIS TRANSMISSION IN THE FORD TRUCKS/SUV'S HAVING LUBRICATION PROBLEMS. FORD SHOULD STEP UP AND TAKE RESPONSIBILITY FOR THE DESIGN DEFECT! *TR

MY 2002 FORD F150 NEEDED TO HAVE THE TRANSMISSION REBUILT. MY OVERDRIVE LIGHT WAS BLINKING ON AND OFF AND I LATER FOUND OUT THE ENTIRE TRANSMISSION NEEDED TO BE REBUILT. I'VE BEEN READING ONLINE FROM SEVERAL PEOPLE WHO HAVE HAD THIS SAME PROBLEM. IT SEEMS LIKE FORD HAS SOME TYPE OF PROBLEM WITH THIS YEAR. I DON'T UNDERSTAND WHY THERE CAN NOT BE A RECALL IN REGARDS TO THIS PROBLEM. *TR

SPIDER GEARS IN DIFFERENTIAL BLEW OUT FOR 2ND TIME ON THIS TRUCK WHICH IS A 2002 F-150 4X4 WITH A 3.55 DIFF. THE FIRST TIME WAS AT AROUND 45K MI.AND THIS TIME AT 83.5K MILES. THIS TRUCK WAS NEVER OVERLOADED AND NEVER PULLED A TRAILER. MUST BE SOMETHING WRONG WITH FORD REAR. AFTER THIS REPAIR,I AM DONE WITH FORD!! *TR

TRANSMISSION DROPS OUT OF GEAR AT 25 TO 30 MPH. TOOK TO DEALER, THEY SAY NO CODES SHOWN AND THEY NEED TO TAKE TRANSMISSION APART TO FIND PROBLEM. *JB

I OWN A 2002 FORD F-150 SUPERCREW 4X4 PICKUP WITH 5.4L V8 GAS ENGINE AND AOD AUTOMATIC TRANSMISSION. AT 48,500 MILES ON THE VEHICLE THE OD ON/OFF SWITCH WOULD NOT STAY ENGAGED AND WAS FLASHING INTERMITTENTLY I TOOK THE TRUCK TO A LOCAL TRANSMISSION SHOP WHO SHOWED ME METAL SHAVINGS IN THE TRANSMISSION PAN AND WAS TOLD THE TORQUE CONVERTER MUST BE REPLACED AND THE TRANSMISSION MUST BE REBUILT. I AGREED TO THE WORK BECAUSE I NEED A DEPENDABLE VEHICLE. I HAVE NEVER ABUSED THE TRUCK IN ANY WAY AND DO NOT HAUL ANY TYPE OF TRAILERS WITH THE VEHICLE. *NM

I BROUGHT THE TRUCK ON JUNE 1, 2004. A FEW MONTHS AFTER I BROUGHT THE TRUCK IT STARTED GIVING ME PROBLEMS. I TRIED TALKING TO THE DEALERSHIP BUT THEY WERE NO HELP AT ALL. I HAVE TRIED TALKING TO THEM PLENTY OF TIMES. I HAVE TOOK MY TRUCK TO AN MECHANIC AN THEY TOLD ME IT WAS A TRANSMISSION PROBLEM . I DON'T KNOW WHAT TO DO THE DEALERSHIP IS NO HELP AT ALL. THEIR WARRANTY POLICY IS A FRAUD THEY DO NOT KEEP UP WITH IT. I AM TIRED OF THIS SITUATION. THAT'S THE REASON I WANT TO CANCEL THE PURCHASE OF THIS CAR. *JB

2002 FORD F-150 TRAVELING WEST ON HIGHWAY 40 IN ARIZONA. RECALL NOTICE RECEIVED ON THE CRUISE CONTROL INITIAL FAILURE CRUISE CONTROL ON. ENGAGED MAINTAIN SPEED BUTTON VEHICLE STARTED ACCELERATING. PUNCHED ALL OF THE CRUISE CONTROL BUTTONS AND TAPPED THE BRAKES CRUISE CONTROL TURNED OFF. CONFIRMATION TURNED CRUISE CONTROL ON AND HIT MAINTAIN SPEED BUTTON. VEHICLE STARTED ACCELERATING AS BEFORE. HIT ALL OF THE CRUISE CONTROL BUTTONS AND TAPPED THE BRAKE. AT 85 MPH, I TURNED OFF THE IGNITION. IMMEDIATELY TURNED IGNITION ON. CRUISE CONTROL WAS ACTIVE, MOTOR RACED, BUT TRANSMISSION WAS IN NEUTRAL. SHIFTER WAS IN DRIVE. TURNED OFF IGNITION AGAIN AND CRUISED TO THE LEFT SIDE OF THE ROAD. STARTED VEHICLE AND PROCEEDED WITHOUT USING CRUISE CONTROL RECOMMENDATION TRANSMISSIONS SHOULD NOT SHIFT INTO NEUTRAL UNLESS THE OPERATOR PLACES THE SHIFT LEVER IN NEUTRAL. PREVIOUSLY OWNED FORDS FROM THE 60S, 70S, 80S, AND EARLY 90S DO NOT DISENGAGE THE TRANSMISSION...

DT: CONTACT STATES HIS CAR ROLLED BACKWARDS AND HIT A MAN PINNING HIM BETWEEN TWO TRUCKS. THE CAR WAS LOCKED AND PARKED AT THE TIME. HE IMMEDIATELY GOT IN HIS VEHICLE AND STARTED IT AND PULLED THE CAR OFF OF THE MAN. HE REPORTS HAVING NO PROBLEMS OF THIS KIND PRIOR TO THIS INCIDENT OR SINCE THIS INCIDENT. *JB UPDATED 12/07/05/ *JB

MY 2002 FORD F-150'S TRANNY COMPLETELY BROKE AT 35,000 MILES 27 DAYS AFTER THE 3 YEAR WARRANTY WAS UP. I DON'T HAUL OR PULL ANYTHING WITH THIS TRUCK. WE ARE HAVING TO PUT A FACTORY REBUILT TRANNY IN IT AS WE SPEAK. *NM

ELECTRICAL: AT 306 MILES THE SOLENOIDS HAD TO BE REPLACED. UPON SHUTTING THE VEHICLE OFF; THE DASH BOARD WOULD STILL ILLUMINATE. ALSO, UPON SHUTTING THE VEHICLE OFF IT WOULD CONTINUE TO RUN. THIS HAS HAPPENED A TOTAL OF FOUR TIMES. THE TRANSMISSION COMPLETELY FAILED WITH NO WARNING. THE CONSUMER TOOK THE VEHICLE TO THE DEALER, AND WAS TOLD THE WINDSHIELD HAD A LEAK WHICH CORRODED THE ELECTRICAL SYSTEM. THE ELECTRICAL PROBLEMS STARTED AT 44000 MILES. THE GASKET HAD TO BE REPLACED, AND THE HARNESS WIRING HAD TO BE REPLACED ALSO. UPON TRYING TO START THE VEHICLE AGAIN THE BATTERY WOULD BE COMPLETELY DEAD. PLEASE PROVIDE ANY FURTHER INFORMATION. *JB

I WAS DRIVING DOWN SR 33 IN POLK CITY WHEN IT SEEMED AS IF MY CAR WAS SLOWING DOWN. I HAD THE PEDAL DEPRESSED BUT THE TRUCK CONTINUED TO SLOW DOWN. I HAD TO PULL OFF TO THE SIDE OF THE ROAD. WHEN THE SPEEDOMETER FELL BACK DOWN TO ZERO I ATTEMPTED TO TAKE OFF AGAIN. ONCE AGAIN, THE TRUCK WOULD GET TO 50 AND THEN NOT SHIFT TO THE NEXT GEAR. THIS WAS THE FIRST AND ONLY SIGNS SOMETHING WAS WRONG. I ASSUMED IT WAS A PROBLEM WITH THE TRANSMISSION. I DROVE TO WORK (15 MILES) IN SECOND GEAR, CALLED A TOW TRUCK AND HAD IT TOWED TO LAKELAND FORD. I WAS TOLD THE OVERDRIVE CLUTCH BURNED UP AND THE DIRECT DRIVE PAK BURNED UP. THE FORD DEALERSHIP WANTED $2,326.09 TO FIX A 2002 VEHICLE THAT IS NOT EVEN TWO YEARS OLD AND HAS 44,176 MILES ON IT. MOST...

WHILE DRIVING CONSUMER HEARD NOISE COMING FROM THE FRONT OF THE VEHICLE WHEN ACCELERATING. *AK

WHILE DRIVING THE VEHICLE, THE TRANSMISSION BOLT CAME LOOSE AND THE FLUID WENT OUT, CAUSING PULL OUT ROAD. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION:: MR

TRANSMISSION DOES NOT SHIFT DOWN, JERKS WHEN YOU ACCELERATE. *AK

TRANSMISSION SLIPPING IN REVERSE, ESPECIALLY WHEN THE TRUCK HAS NOT BEEN DRIVEN WITHIN TWO DAYS. THE TRANSMISSION DOES NOT SLIP IN DRIVE ONLY IN REVERSE. *AK