2002 FORD F-150 Steering Problems

SEED CONTRAL.

ENGINE QUITS RUNNING AND WONT RESTART, SO YOU HAVE NO POWER STEERING OR BRAKES. PROBLEM INDICATORS ARE 1. ENGINE WONT RESTART/ OR QUIT RUNNING 2. ODOMETER READS ALL DASHES, NO NUMBERS,3. ANTI THEFT ACTIVATED. THIS IS CAUSED BY THE POWER WIRE IN THE FUSE BOX UNDER THE HOOD CORRODING OFF FOR THE PCM RELAY AND LEAVING THE PCM DEAD. *TR

TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE STEERING WHEEL BECAME LOOSE. THE STEERING BOX THEN ABNORMALLY MOVED BACK AND FORTH. THE CONTACT NOTICED THAT THREE BOLTS THAT HELD THE STEERING GEAR TO THE FRAME WERE FRACTURED. THE HEAD OF THE BOLTS SNAPPED AND ONE SIDE OF THE BOLTS APPEARED TO BE CORRODED. THE VEHICLE WAS NOT TAKEN TO A REPAIR SHOP FOR INSPECTION OR REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 127,312. ..UPDATED 10/03/12 *BF

TL* THE CONTACT OWNS A 2002 FORD F-150. THE CONTACT STATED THAT THE STEERING BOX FAILED. THE STEERING WHEEL WOULD SPIN WITHOUT RESISTANCE AND WOULD NOT CATCH. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO ADVISED THAT THERE WERE NO RECALLS AND OFFERED NO FURTHER ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 214,000.

TL* THE CONTACT OWNS A 2002 FORD F150. THE CONTACT STATED THAT THE PASSENGER SIDE TIE ROD FRACTURED WHILE DRIVING 70 MPH, CAUSING HIM TO LOSE CONTROL OF HIS VEHICLE. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO REPAIRED THE INNER PASSENGER TIE ROD. THE CURRENT MILEAGE WAS 127,000. THE APPROXIMATE FAILURE MILEAGE WAS 124,000. THE VIN WAS UNAVAILABLE.

ONE GAS TANK STRAP WAS FOUND TO BE RUSTED AND THE TANK AT AN ANGLE. IT WAS INSPECTED BY A LOCAL FORD DEALER, WHO FOUND THAT THE GAS TANK WAS ALSO RUSTED AND LEAKING. THE GAS TANK AND STRAPS WERE REPLACED. BECAUSE THE MODEL YEAR WAS NOT IN THE DATE RANGE OF THE RECENT RECALL, WE HAD TO PAY $793. A POWER STEERING PUMP WAS ALSO LEAKING AND REPLACED. THE GAS TANK WAS THE MAJOR ITEM OF CONCERN.

WHILE DRIVING IN A STRAIGHT LINE AT 36 MPH ON A PAVED STREET THE LEFT OTTER TIE ROD END BROKE . CAR WAS CLOSE TO BEING OUT OF CONTROL BUT WAS SAFELY BROUGHT TO A STOP. REPLACED ALL TIE ROD ENDS, PITMAN ARM AND CENTER LINK. (SHOP THAT DID THE ALIGNMENT SAID I WAS THE SECOND CAR THAT HAD BROKEN A TIE ROD. THE OTHER VEHICLE WAS A 2001 F150). *TR

TOTAL FAILURE TIE ROD AND BALL JOINT ON FRONT DRIVER SIDE SUDDENLY CAME APART WITHOUT WARNING WHILE DRIVING CAUSING LOST OF CONTROL OF VEHICLE. I WAS ABLE TO "DIRECT" TRUCK OFF THE ROAD. *TR

WHILE PULLING OUT OF MY DRIVEWAY I WAS TURNING THE STEERING WHEEL WHEN I HEARD SOMETHING SNAP IN THE STEERING COLUMN AND THEN I HAD NO CONTROL OF THE STEERING. THE STEERING WHEEL WOULD TURN COMPLETELY AROUND AND THERE WAS NO CONTROL OF THE FRONT WHEELS. AFTER TAKING THE TRUCK TO THE DEALERSHIP WHERE I PURCHASED THE VEHICLE THEY REPLACED THE UPPER STEERING GEAR ASSEMBLY, THE STEERING SHAFT, AND REPLACED THE CLOCK SPRING UNDER THE STEERING WHEEL. THIS COST A TOTAL OF $810.16. I WAS ON MY WAY OUT OF TOWN THAT DAY AND WAS HEADING FOR THE INTERSTATE. I AM SO THANKFUL THAT I WAS NOT GOING 70 MPH ON THE INTERSTATE. THEY COULD NOT TELL ME WHY THIS HAPPENED. THE VEHICLE IS ONLY 3 YRS OLD AND HAS 63,878 MILES ON IT. *NM

2002 F-150 SUPER CAB, MAKES A POP RIGHT WHEN STEERING WHEEL IS TURNED IN EITHER DIRECTION, STANDING STILL (VEHICLE RUNNING OR NOT) AND MOVING, ALSO GETTING A VIBRATION AT HIGHWAY SPEEDS. PERSONAL INVESTIGATION WAS TO CHECK THE LUGNUTS FOR TIGHTNESS, ALL OK, THEN REMOVED BEARING COVER OFF FRONT WHEELS, FOUND NO LOCKING MECHANISM ON RIGHT FRONT WHEEL BEARING NUT. GOING TO DEALER TOMORROW (4/7/2004) VEHICLE HAS 26,500 MILES. OWNED SINCE NEW, FRONT WHEELS HAVE NEVER BEEN REMOVED. NOTICED SEVERAL "POPPING" COMPLAINTS ON THIS VEHICLE - WONDER IF THEY HAVE LOCKING MECHANISMS ON THEIR BEARING NUTS? *LA

PROBLEMS WITH VEHICLE STEERING GOING OUT.*MR STEERING WENT COMPLETELY OUT WHICH CAUSED THE DRIVER TO BRAKE FAST, AS A RESULT THE DRIVER AND PASSENGER WERE INJURED. *PH ALSO THE VEHICLE EXPERIENCED 2 FLAT TIRES TWO WEEKS AFTER THE INCIDENT. *JB

CONSUMER STATES THAT WHILE DRIVING AT 65MPH AND WITHOUT WARNING THE STEERING WHEEL WILL PULL TO THE RIGHT AND IT WILL BE HARD FOR THE CONSUMER TO CONTROL THE VEHICLE. DEALER NOTIFIED TS

WHILE DRIVING THE VEHICLE CONSUMER STATES CANT CONTROL THE STEERING WHEEL, WHEN MAKE LEFT OR RIGHT. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS