2018 FORD ESCAPE Engine Problems

I received a warning on my dashboard to pullover safely because my engine was overheating even though I just left work from a cold start. I had it towed to my mechanic who told me I had a serious issue and recommended I take it to Ford. Ford just confirmed a short engine block issue and even though I had the required repair done on 7/9/22 that was supposed to prevent this more expensive issue. My particular vehicle was not on the Program 21N12 Coolant Intrusion Recall for possible short engine block issue but that's the exact issues the dealership just told me has happened to my vehicle. Luckily I was able to maneuver it out of the line of traffic safely.

The contact owns a 2018 Ford Escape. The contact stated that while driving at an unknown speed, a warning message stated there was "High Engine Temperature Stop Safely". The contact stated that the check engine warning light illuminated, and the vehicle was towed to the residence. The vehicle was later towed to an independent mechanic where the vehicle was diagnosed with internal engine failure. Additionally, anti-freeze was leaking into the cylinder causing the engine to overheat. The independent mechanic contacted the dealer where it was recommended for the vehicle to be taken to the dealer. The contact had the vehicle towed to the dealer where the vehicle was diagnosed with a misfire in cylinder #3, a cylinder compression was low, and it was stated that the long block assembly needed to be replaced. The dealer submitted the findings to the manufacturer and the manufacturer stated that the vehicle would not...

Timing belt slipped at 72,000 miles causing total engine failure

I recently took my car for an oil change and was informed by the technician that a diagnostic was needed due to hearing coolant pooling into the engine. After the diagnostic was performed I was provided with a list of codes that stated it was a recall issue with coolant pooling into the engine. I then took it to a Ford dealership and they stated it was not a recall issue. I submitted a copy of the codes that the independent repair technician emailed me, and that they signified a recall issue. A week later after vehemently denying there was no coolant issue, Ford stated they removed a spark plug and found contaminants in the engine, yet stated it was not a recall issue. My safety was put at risk in that my engine could seize at any moment and cause bodily harm to me or others. The component has...

The contact owns a 2018 Ford Escape. The contact stated that while driving at approximately 50 MPH, the exhaust began to show signs of smoke, and the vehicle was pulled over to the shoulder of the road. The Check Engine Warning Light had illuminated. The vehicle was restarted but failed to maintain power and would not drive. The vehicle was towed to an independent mechanic where it was diagnosed that there was Anti-Freeze leaked into the engine and that the engine needed to be replaced. The local dealer was not contacted. The manufacturer was made aware of the failure. The vehicle was towed to a Ford Service center where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired as of yet. The failure mileage was approximately 93,000.

There is a known issue with the 1.5 liter engine for the 2018 Ford Escape related to coolant leaks in the engine causing cylinder misfires (which can lead to damaged spark plugs, lost coolant, overheating, among other things)--Ford has addressed the issue via a "customer service program" (program [XXX]) in what appears to be an attempt to avoid an active recall. Although the issue is widespread for the 1.5 liter engine, it still occurs in the 2.0 liter engine. I have the 2.0 liter engine and am having the same issue (coolant leak due to the design of the open block, has caused multiple issues). The Ford dealership service center (McLarty Daniel Ford in Bentonville, AR) confirmed the diagnosis and that I would need an entirely new engine. But because I'm 2,000 miles outside of my power train warranty and the customer service program only applies to 1.5 liter engines,...

The vehicle started overheating due to an internal coolant leak that sends coolant into the cylinder head. This is apparently a common issue with these vehicles and could easily lead to a fire. There is an active recall for the same exact engine in the Ford Fusion. There needs to be a recall for the Ford Escape engines as well before people sustain unnecessary injury/death.

Check engine light came on steady. Took vehicle in for service at 1st possible appt. Was told it was engine block failure due to faulty porous block installed by Ford. Vehicle has 54000 miles on it, 8 months out of the 60,000/5yr powertrain warranty. Have an extended warranty but they refused to pay stating Ford knew about the faulty engine blocks installed on thousands of vehicles. Ford had issued a TSB warning of potential engine failures in these vehicles, but no recall. TSB 22-2322 Huge safety issue due to possibility of catching fire or breaking down on busy interstate. Vehicle currently at Ford dealership with a repair price tag of 10,400.

Engine coolant leaking into engine cylinder number two.

I bought a used 2018 Ford escape eco-boost SUV from Elder Ford. I recently have been experiencing coolant problems where the coolant is dissipating from the engine. The car has run hot two or three times and now there appears to be coolant and oil mixed together that's over the engine and it appears that there is a cracked head gasket. I have researched on the computer to find this is a known problem from Ford back to 2010 and there are multiple customers that have experience the same thing. Now I believe the engine has to be replaced. Ford needs to be held accountable for this faulty mechanism. There's a coolant intrusion issue which causing gulping of the coolant into the cylinders. Apparently Ford changed the area around the pistons to an open deck which is causing this problem . I noticed that there's a class action lawsuit in...

The contact owns a 2018 Ford Escape. The contact stated while his wife was driving approximately 35-45 MPH, the check engine warning light illuminated, and the vehicle was overheating. A message advising to pull to the side of the road was displayed. The contact's wife was able to veer to the side of the road. The vehicle was taken to the nearest independent mechanic, where the water pump, the serpentine belt, the water pump gasket, the cylinder head temperature sensor and the coolant temperature sensor were replaced. The vehicle was repaired; however, the failure recurred. The contact stated that while his wife was driving at an undisclosed speed, the check engine warning light illuminated, the message "Service Now" was displayed, and the vehicle went into LIMP Mode. The vehicle was taken to the independent mechanic, where it was diagnosed that there was hydrocarbon intrusion into the coolant system. The mechanic...

See attached document for complaint

The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The contact became aware of a flowing liquid sound underneath the hood. The vehicle was taken to the independent mechanic where it was diagnosed with coolant leak into the engine and that the engine needed to be replaced. The vehicle was not repaired. The contact was informed of Customer Satisfaction Program: 21N12; however, the contact was informed that the repair could not be covered under the Customer Satisfaction Program. The manufacturer was made aware of the failure and advised the contact to report the failure to the NHTSA Hotline. The failure mileage was approximately 60,000.

Coolant intrusion to the cylinder bores.

Coolant leaked into causing engine failure. Now having to have engine replaced. Noticed 156 other complaints to NHTSA regarding same issues. Why is Ford not doing anything about this. My Ford has 58560 miles on it.

The contact owns a 2018 Ford Escape. The contact stated while driving 35 MPH, the vehicle started leaking fluid. The check engine warning light was illuminated. The vehicle was taken to the local dealer, where it was diagnosed that the fuel line was cracked. The vehicle was not repaired. The vehicle was taken to an independent mechanic, who informed the contact that the failure was due to a cracked fuel line. The contact stated that the failure was related to Customer Satisfaction Program: 21N12. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 75,000.

Went to start vehicle in morning after it had been sitting overnight. temperature gauge went all the way to red immediately and alert on dash said do not drive vehicle and turn engine off immediately. had it towed to dealer and they advised coolant was leaking which caused blown head gasket. only fix is to replace engine which will cost more than vehicle is worth

Our vehicle is a 2018 Ford Escape with 54,843 miles. This vehicle was purchased Used from Ted Britt Ford, Chantilly, Va. and assured there was no issues with the vehicle. On or around February 20, 2024 my daughter notified me the check engine light is on. Dropped it off a local repair shop which identified there was a misfiring and needed a bore scope to see inside. Borescope discovered coolant in the cylinders indicating the head gasket is leaking. Call Ford US Customer Service same day (February 26, 2024), said they need Ford mechanic to look at it. Took to Chantilly who confirmed. Called Ford USA back, said they would talk with Ford Dealer and call me back, never returned a call. I've been calling them every 2-3 days since. Finally today they said 'there is no program to provide financial assistance' which really pisses me off. Reading industry material...

Widely known issue that the engine has coolant leaking into the engine. Ford issued a statement on it. Now the same thing is happening to my car. Safety of myself and others put at risk by vehicle running incorrectly and engine is now misfiring resulting in difficulty maintaining power while driving. Problem has been confirmed by independent body shop and is being confirmed but dealer now. Check engine light was on at 97k and now at 106k with same codes.

The day after paying off my wife's 2018 Escape with 102,000 miles on it started telling us to pull over while driving on the highway because the engine was getting hot We pulled over and it went away. The next time we drove it our daughter was driving with our grandson in the car and it would not go more than a mile or two without overheating. We took it to be looked at by a local mechanic and was told that these regularly have head gasket problems, that was the problem with ours and we would have to replace the engine for about $10,000.00. A quick call to the Ford dealer and a perusal of the internet confirmed what the mechanic stated. I see information about the faulty head gaskets on the 1.0 liter engines, when I look on line I see at least as many customer complaints about...

Check engine light came on for misfire. Odaniel Ford in New Haven, Indiana confirms coolant intrusion. Short block needs replace for $6800.

The contact owns a 2018 Ford Escape. The contact stated that while driving at undisclosed speeds, the check engine warning light illuminated. The vehicle was taken to the local dealer, where it was diagnosed that coolant had intruded into the cylinders. The dealer recommended that the engine be replaced. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 77,000.

The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle shuddered, and a burning odor was detected. The check engine warning light was illuminated. The vehicle was taken to an independent mechanic, who replaced the water pump and timing belt; however, the failure recurred. The vehicle was then taken to the dealer, where the spark plugs were replaced, but the failure persisted, and the vehicle hesitated to restart. The vehicle was towed to the dealer, where it was diagnosed that the failure was related to Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion). The contact was referred to the manufacturer. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was informed that the VIN was included in Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion); however,...

My check engine light came on and I brought my 2018 Ford Escape to a mechanic. I then learned that coolant was leaking into the engine and causing the spark plugs to misfire. Ford had a bulletin on this issue but refused to perform any repairs on it (they recommended a full engine replacement). I contacted both Ford's customer service line and spoke to the service department at the dealership. Both said they could do nothing to help. I researched this issue and discovered that it is common in this make and model. I do not wish to pay the $10,000 it would cost to replace the engine on my own. I fear that this vehicle may overheat and fail for me on the highway with the loss of engine coolant or the misfire of the spark plugs.

The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle was experiencing hard shifts and the transmission was slipping. The vehicle was taken to an independent mechanic, who informed the contact that the failure was related to the transmission. The vehicle was taken to an unknown dealer, but the failure could not be duplicated. The vehicle was taken to another dealer, where it was diagnosed that an unknown transmission part had failed, but the vehicle was not repaired. The vehicle was taken to a transmission specialist, where the transmission fluid was flushed, and the failure ceased. The contact stated that the check engine warning light later illuminated. The vehicle was taken back to the transmission specialist, where it was diagnosed, and the contact was informed that the transmission fluid was abnormally dark. The transmission specialist replaced the valve control assembly, the...

Coolant leaking into engine

Car is experiencing coolant intrusion into cylinder of engine. Ford dealership in Orlando Florida is saying engine needs to be replaced. I'm reading that this issue is very common with this car. It was a safety hazzard for us because the car was running rough on a very busy highway. Had it towed to dealership.

The flex plate cracked in four places. I have images showing the cracks on the flex plate. The problem was confirmed by an independent service center. There were no warning lamps or messages, only a percussive tapping sound caused by the cracked flex plate. This issue could cause loss of control of the vehicle leading to an accident.

The contact owns a 2018 Ford Escape. The contact stated that the vehicle had experienced rough idling, with white smoke coming from the exhaust. The check engine warning light remained illuminated while driving. The vehicle was examined by the local mechanic who determined there was coolant inside the cylinder #3, which caused severe engine damage. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer and the local dealer were notified of the failure, but no assistance was provided. The approximate failure mileage was 100,000.

COOLANT LEAKING INTO ENGINE - I've owned this car for exactly 6 years tomorrow (2/20/24). It has 106k on the odometer. It's almost paid off and Ford tells me the coolant issue will be $10k to repair which is more than the car is worth, more than I owe on the car. They'll give me $500 to salvage it. Ford knows about this issue but won't cover it because my car is over 80k. Ridiculous. I will never buy another Ford product again.

I have ford escape 2018 S and I bought the car from koons ford silver spring MD. It is unfortunate whenever I drive the car for long hours ; suddenly the acceleration declines and the vehicle loose its power. And a strange click sound comes up and the check engine light on. Once I parked the car and the car cool down --the warning system disappear. I tried to contact the dealership and I was told my vehicle is not on recall list despite my vehicle have the same symptom--I bought this car very expensive and handle it with care and the car has only 5900 miles on it. Appreciate if you guys could investigate the case .

this car had an engine light go off and there was a cylinder 2 misfire. When I brought it into the dealership they said that there is a known issue that the coolant is intruding into the motor. Ford knows about this as a problem and has a faulty design and avoided telling people about it. I only realized the thousands of people who are being put at risk of the engine blowing while driving it down the road. My car was not the only one at the dealership with the same exact problem. These cars need to be recalled and corrected

Prior to this, my had no issues and I had been driving it all day. When coming home from some errands, the engine light suddenly came on and and then my car began shutting off on the highway. We were in the middle lane with cars going 70 miles a hour with no power in our own car, putting us in extreme danger. We were able to get it to the side of the highway and go through a series of starting it, having it run for a mile or so, and then having the engine shut down again. We were able to get it to a Ford dealership and it was inspected. Our garage immediately knew to look at the coolant cylinder to see if it was cracked and leaking as they have seen this issue multiple times. It was, in fact, cracked and coolant was leaking into our...

Coolant has leaked into my engine block causing damage to the engine. I have brought my car into the dealership on 3 different occasions with the same issue only to be told that something else was wrong with my vehicle. The first time I brought my vehicle in, it was covered (unknown to me) by a special service bulletin. I believe that I was intentionally misled so that the repair would not have to be covered. The first incident was on or around 2/1/23, the second incident was on or around 5/1/23, the third around 10/1/23 and most recently on 2/13/24

Coolant intrusion into motor. Coolant leak causing multiple misfires and my vehicle to lose power while driving and not to over 30mph. I have had the spark plugs, injectors, and coil packs all changed and problem persisted. Taking my car back to mechanic a test was done and there is coolant in the pistons.

I bought this car 8 months ago and one day it just wouldn’t start. the coolant leak has caused my engine to quit. I cannot afford to replace the engine, especially when ford knows this is an issue. My extended warranty also won’t cover it, the dealership said this is fords issue and they need to cover it. Ford has not issued a recall even though there is a service bulletin about it.

The contact owns a 2018 Ford Escape. The contact stated while driving 40 MPH, the check engine warning light started flickering and the vehicle vibrated and lost motive power upon depression of the accelerator pedal. The contact inspected the engine and discovered white rust on the spark plugs. The vehicle was taken to an independent mechanic where a diagnostic machine showed an engine misfire in engine cylinders #3 and #4. Upon further inspection, the mechanic discovered coolant intrusion into engine cylinders #3 and #4. The dealer was notified of the failure and the contact was informed that there were no recalls on the vehicle. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 100,000.

We purchased our 2018 Ford Escape used with 88,000 miles. At around 96,000 miles the check engine light came on and it threw the P0302 code for a misfire on cylinder 2. We took the car in to Greene Ford Co. in Gainesville, GA. They replaced the coil pack and sparkplug and the car ran well for ~10,000 miles before the check engine light came back on and the car started to sputter and run rough. Took it back to the Ford dealer and they informed us the cylinders were full of coolant and there was a leak allowing coolant to flood the engine block. They said the block was damaged and we would need to purchase a whole new engine. They also told us this was a very common complaint with certain Ford SUVs made in the late 2010s. Our car is completely unsafe to drive now and it...

While driving on the highway on [XXX] at normal highway speed, the instrumental panel suddenly displayed a warning to pull over and shut-off the engine. There were no prior indications of a malfunction. My daughter was alone on the highway shoulder with a car that instructed her to pull over and shut off the engine. After about 15 minutes, the car was restarted and driven to a near-by tire store. They noticed the coolant system was very low on coolant and topped it off. The next day, it was driven to Bob Maxey Ford in Howell, MI, where the codes P0217 (coolant over temp), P0303 (#3 misfire), P0316 (misfire on start), P1285 (cylinder over temp), P1299 (protection activated), P2601 (coolant pump A control circuit) were retrieved. The car has about 51K miles on it. That info was conveyed to Ford and authorization was quickly given by them to perform the...

Cylinder 3 cracked, needs a new long block. Car is at 100k miles. Needs a new engine.

High engine temp notification came on, car would not accelerate. I pulled over and had it towed to the dealer. The dealer said the engine had a coolant intrusion so a new short block is needed. My warranty company denied my claim for the short block claiming this was a recall with ford [XXX] ) . Ford confirmed this was a VIN specific customer satisfaction program, and confirmed my VIN was not issued [XXX] and it is not included on my VIN. The warranty company refuses to pay since all 2018 ford escapes should be under [XXX] . Now I have a 10,000 engine repair estimate and ford or the warranty company will not replace my engine. I want to know why my VIN was left off [XXX] since it’s the same year and same manufacturer. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

On Dec 27, I was told my water pump was leaking after an oil change. I brought my car to the dealership for extended warranty repairs on January 18. After an expection it was confirmed the water pump was leaking but also there were other possible leaks of the coolant into the cylindars. And the entire motor would need replacing. There were no service lights / check engine lights on before this happened.

My engine threw a check engine light for code P0302, Misfire on Cylinder 2. Took it to two mechanics and had work done (Coilpack, Plugs, Wires, then Camshaft and Crankshaft sensors) before it was noted that there was coolant intrusion. Was alerted to Technical Service Bulletin 22-2134/Customer Satisfaction Program 21N12 for "Certain 2017 - 2019 Model Year Fusion and Escape Vehicles Equipped with a 1.5L GTDI Engine-Short Block Replacement After Coolant Intrusion. I took it to the dealer and the technician diagnosed it the same: coolant intrusion in cylinder #2. This is a common issue in EcoBoost (GTDI) engines that Ford has not issued a recall on, but did send out Customer Satisfaction Program. Did not receive notice for this. I have contacted Ford about compensating me for a new engine on a 6-year old car at 75,000 miles. Both meet the above CSP/TSB as less than 7 years/84,000 miles....

The contact owns a 2018 Ford Escape. The contact stated while driving 62 MPH, the service engine light illuminated. While driving, the engine light started to flash, and the vehicle was running rough. The contact pulled off the roadway. The vehicle was taken to a tire center, but no assistance was provided. The vehicle was towed to the local dealer, where it was diagnosed that the head gasket had failed, and coolant had intruded into the engine. There was a misfire. The dealer recommended an engine replacement. The vehicle was not repaired. The contact called the manufacturer who opened a case and referred him to the NHTSA Hotline. The contact stated that the failure was related to Customer Satisfaction Program: 21N12. The failure mileage was approximately 129,000.

My engine gave a warning, check engine light went on. I took it to the dealer and the mechanic said the engine failed due to coolant intrusion. Upon searching the issue, this is apparently a common issue in these ecoBoost engine cars that Ford has not issued a recall on, but did send out some satisfaction notice. I never received this notice for some reason. The notice indicates the need to monitor coolant leak, but I never noticed any and wasn't looking for it since I never received the notice. I have contacted Ford about compensating me for a new engine on a 5 year old car, to which they said no because my car is over 84,000 miles (it is as 85,487). I need Ford to recall this issue and frankly it should be criminal not to actively pursue a fix for a known huge and expensive issue that...

Coolant leaked into one of the Cylinders which is requiring major engine block repairs. It only has 80K miles on the car and is in great condition. No warnings happened before it almost overheated and threw a error code.

While driving this vehicle (~87,000 miles), the engine began to overheat. The engine light had come on the day before (Saturday). The engine began to overheat the next day (Sunday) while driving on the highway. I quickly pulled off the highway and drove the vehicle back home while staying at a low speed. If I had not taken this action, the engine overheating could have posed a safety risk. Upon receiving repairs at a Ford dealer, I later learned that this engine overheating is a known issue by Ford. It is caused by coolant intrusion to the engine. Two customer satisfaction programs have been issued for this problem: 19B37, 21N12. However, given the safety issue (engine overheating), I was surprised this repair was not fully covered. This issue happened in my vehicle after the extended warranty period of 84,000 miles.

While driving this vehicle (~88,000 miles) on a route of ~100 miles, the car started shuddering / shaking at highway speed for 30 - 90 seconds every 10 - 15 minutes. I was 50 miles in to the drive when the shaking began. The shaking was startling and distracting. I drove the car to the dealer that night. While driving to the dealer, the car continued to shudder / shake for even longer durations at greater frequency. Additionally, the car had weak acceleration when the gas pedal was compressed. This created significant challenges when trying to navigate traffic (merging on to highway, accelerating car from stop, etc.). I have a video of the dash which shows the car exceeding 4000 RPM and not exceeding 25mph. I can share this video over e-mail, but could not attach to this form. - The dealer believes this is a malfunction of the powertrain...

The contact owns a 2018 Ford Escape. The contact stated that while driving at an undisclosed speed, the Engine Overheated message was displayed. The vehicle was taken to the dealer, where it was diagnosed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was informed that the VIN was included in Customer Satisfaction Program: 21N12 (Short Block Replacement After Coolant Intrusion); however, the mileage warranty had expired. The contact stated that he had not received notification of the Customer Satisfaction Program. The failure mileage was approximately 109,000.

I Purchased a 2018 Ford Escape SE (VIN# [XXX] ) with 1.5 EcoBoost Engine on 9/24/2023 with 89,726 miles. On 12/10/2023 my 16 year old son was operating vehicle when he experienced a catastrophic engine failure and the vehicle is unserviceable. The vehicle had 90,766 miles on it at the time of the failure. Vehicle was diagnosed on 12/18/2023 and it was determined that there was coolant intrusion into the #2 and #3 cylinder and that the engine will need to replaced. Diagnosis showed that Ford had issued (2) Customer Satisfaction Program alerts on the vehicle for this issue Ford CSP 21N12 and 19B37 on 06/9/2022. I contacted Ford Motor Company and my local dealer to report the issue. I was advised this is a known issue with this specific engine although the vehicle is beyond the extended warranty under the Ford CSP's above. This known issue on this vehicle...