2018 FORD ESCAPE Engine Problems

I wife was driving the the car it went into limp mode, lights on dashboard says pull over asp. The car would not restart now mechanic is saying it needs a new motor.

While driving to work on February 16, 2026 my car started making a knocking noise and had a hard time going. At one point I was in the middle of the road and the car wouldn’t move. I had it towed to a mechanic and they said it needs a new motor. My car is a 2018, just barely 7 years old.

While driving 1,100 miles from Topeka, Kansas to Maryland to spend time with our first grandchild, our trip was interrupted by coolant intrusion in the cylinders of our 2018 Ford Escape SE (ecoboost), which had 78,600 miles on it. Both an independent garage and the Ford dealership in Maryland said the car needed a new engine. The garage put the cost at $16,000; the Ford dealer, $12,200. I quickly discovered online that the problem of coolant intrusion in Ford Escapes from that year was widespread and caused by a design flaw. After purchasing the vehicle used in 2020, I was never informed of any recalls or service announcements about this problem and after the problem was diagnosed, I was told by Ford that recalls had all expired by now. Instead of spending $12,200 for a new engine from an out-of-state dealership I had no knowledge of or past service history...

Took car into local repair shop (HARLAN AUTO 650 W Main Street, Canfield, Ohio 44406. phone 330-506-1737.) for normal maintenance. 02/12/26 Odometer 65033. Previous maintenance 10/28/25 odometer 61335. Performed vehicle inspection, oil change and tire rotation. Harlan discovered no antifreeze, coolant in reservoir. I authorized them to perform a pressure test lasting several hours. Test revealed evidence of damage to spark plugs, cylinder walls and cracks in cylinder walls. Revealing major damage to ngine resulting in imminent failure. Harlan says short block replacement is necessary for repair. i authorized them to repair car based on value of the rest of the vehicle which they claimed it to be in very good condition. Totals for repair are as follows: labor $4790.07, parts $2501.78, tax $546.89, non-taxable nonjob supplies $29.49. GRAND TOTAL $ 7868.23. Engine failure could result in fire or being stranded on the road. There were no vehicle warning signs....

1. Vehicle Information • 2018 Ford Escape ECOSYSTEM 1.5 • 84,000 • VIN [XXX] . Problem Description : My 2018 Ford Escape has experienced coolant intrusion into the engine cylinders, a known issue affecting this model year. The vehicle began misfiring and consuming coolant without external leaks. This is an engine defect Ford has known about since 2010, yet they continued to put this engine into their cars. It is also the subject of at least one class action lawsuit. Common Issue: Many 2017–2019 1.5L engines suffer from coolant leaks into the cylinders, necessitating a replacement with a redesigned block.The dealership confirmed a Technical Service Bulletin applies to my VIN. This defect can cause engine failure while driving, creating a serious safety risk. Safety Risk: • Loss of power while driving • Risk of engine stall • Overheating risk • Highway safety concern INFORMATION REDACTED PURSUANT TO THE FREEDOM OF...

Engine Failure - available for inspection Safety was at risk when the vehicle died multiple times on the highway and I was told that there was no issue by ford. The dealership understand the problem now that the check engine light is staying on. No inspection other than by ford's mechanics. Possible insurance inspection. Alerts for engine failure whenever the car died. In November 2025 my car died on the highway. I was driving normally and the engine cut out (service code included Engine Failure). I was able to turn the vehicle back on and drive to auto zone. They believed the issue was my battery. I had the battery replaced at belle tire, 20 minutes after the battery replacement the car died again so I took it to a ford dealership and explained the issue. Ford drove the car approximately 40 miles and could not recreate the issue and...

I had three incidents in January of 2026 where the coolant was leaking and then the check engine light would come on. I took it to the Ford dealership to have it checked and they said I need a new engine for $12000! But there are no recalls, I have the 1.5L engine. The recalls are on the 2L engine so they say I have no recourse! I have only owned this vehicle for 8 months and there was one previous owner before me.

Check engine light came on, took it to the ford dealership in Denison Tx. I was notified that there was coolant in 3 & 4 cylinders. Possible blown head gasket or cracked block. Estimated repairs $11,000.00. Vehicle was purchased used from Ford dealership in Sherman, Tx. in November of 2025, check engine light came on in Nov/Dec 2025. While diagnosising problem they broke a spark plug off in cylingder head.

Engine coolant intrusion- I don't feel safe driving this vehicle due to engine problems known to FORD even at/before time of sale. Possible fire hazard. Transmission- I don't feel safe driving this vehicle due to transmission problems known to FORD even at/before time of sale. Vehicle lurched around while backing from my garage. Electronic emergency brake- Occasionally sticks in lock on position not allowing me to operate. Report date is today 02/08/2026 for issues as of manufacture date 12/17/17 I request FORD buy back this vehicle at full purchase price. I'm a single Widow and don't feel safe driving this vehicle alone. FORD selling vehicles with long known problems to unsuspecting customers is shameful.

Coolant intrusion into cylinder

The contact owns a 2018 Ford Escape. The contact stated that while driving approximately 25 MPH, the vehicle lost automotive power. Several unknown warning lights were illuminated. The message "Engine Malfunction - Service Immediately" was displayed. In addition, the contact stated that the vehicle was idling at a lower RPM. The vehicle was taken to a local dealer, where it was diagnosed with coolant intrusion into the engine, causing catastrophic engine failure. The vehicle was not repaired due to the cost. The contact related the failure to Technical Service Bulletin:19-2172; however, the vehicle was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 57,000.

Oct 2025 my engine died. Was told need new engine

MY 2018 Ford Escape Titanium has a engine malfunction that is known to Ford but has not been recalled. Their is a leak in the engine which causes coolant to leak. The long block engine needs to be replaced at a cost to me of $10,000. This cost was determined by the Ford dealership and I have included the invoice. This can cause complete engine failure without any warning.

Coolant leak into cyclender

I bought my 2018 for escape less than 2 years ago from carmax. I have 79,000 miles on it currently and have kept up with all the regular maintenance and upkeep. I had gotten an oil change and coolant flush in two days after this work had been completed. The check engine light came on and the code was read as an engine misfire. “VERIFIED THE CUSTOMER CONCERN OF THE CHECK ENGINE LIGHT ON. PULLED CODES AND FOUND CODE P0301 FOR A CYLINDER 1 MISFIRE. PULLED THE CYLINDER 1 COIL AND SPARK PLUG. FOUND NO CONCERNS WITH THE SPARK PLUG OR COIL. BOROSCOPED THE CYLINDER AND FOUND THAT CYLINDER 1 HAS COOLANT INTRUSION. FOUND TSB 22-2229 THAT STATES IF THIS CONDITION IS PRESENT THE LONG BLOCK NEEDS TO BE REPLACED.” $10,246.06 is the estimated cost of repair from the dealership. Ford refuses to be held accountable because the car is...

Engine began overheating. Noticed that the coolant was empty. Filled filled it with coolant to the max mark. In about two days and began to overheat again. This is when I found out that they had an engine designed flaw for the 2 L eco-boost. The block would crack, and Ford knew about it, but was still selling the engine with the design flaw. I never received any TSB on the problem. This is most definitely a safety hazard. Since the engine could’ve seized or caught fire as a result of this design flaw. At the very least Ford could’ve notified us that the problem was probable.

2018 Ford Escape SEL 1.5L 4Cyl Turbo. 43,883 miles. Engine light came on. Checked by mechanic on 1/15/26. (Philadelphia PA 19128). Diagnosis: Coolant leaking from head gasket into cylinder #3. Recommend remove & replace engine. Cost: $11,551.13 (total) (which is around what the vehicle is worth). I have since researched this problem and found out it is a longstanding issue with this Ford engine, across different models, but has not been addressed - no recall or maintenance notices that I am aware of. Many other consumers have encountered the SAME EXACT ISSUE, with engine replacement recommended for thousands of dollars - including in low milage vehicles like mine. Allegedly the faulty engines are still being manufactured and used...So, assuming this is true, if someone opts to replace the engine, couldn't they just be getting one with the very same problem?? It is INEXCUSABLE that this issue has not been addressed.

Blown head gasket, it is available for inspection. The engine overheating could’ve left me and my family stranded. The problem has not been confirmed by anyone. It also has not been inspected yet either. There were no other indicators lit on the dashboard other than the check engine light.

I have a 2018 Ford escape and I have a coolant intrusion leaking into the cylinders.i can smell coolant inside the vehicle.i did some researched the problem.i noticed other people having the same problem.some of the while driving the motor stopped running.ford does have the knowledge of this and have done nothing about it.this is a real dangerous safety hazard.someone is going to get hurt badly and maybe even death can happen.what is it going to take for a national recall for these vehicles affected to be repaired ? This is a very concerning dilemma.can someone please get back to me.thank you.

December/2025 I noticed a check engine light on my way home went to get the code read and was told I needed new plugs and coils had them replaced on 1/2026 about a week later check engine light again now I’m getting code po302 misfiring had them replaced again on 1/10/2026, only to get the same thing happen again to cylinder 2 as before with constant low coolant in overflow !! So as of 1/16/2026 same reading done same code my cylinder #2 has coolant in there and now I need internal engine work done on my vehicle with know manufacture recall because I brought my car in 7/2024 n now I’m stuck with a vehicle with major issues/problems and no funds to repair..

The contact owns a 2018 Ford Escape. The contact stated that the vehicle was parked in the garage after being driven in the morning; however, later in the day, the vehicle failed to restart. While the contact’s grandson was using the vehicle, there was an abnormal popping sound. There was white steam in the garage. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who noticed milky coolant inside the engine while using a camera to check the engine. The mechanic determined that there was coolant intrusion into the engine, causing a crack in the engine, which warped the cylinder heads. The mechanic informed the contact that the engine needed to be replaced. The vehicle was not repaired. The local dealer was not contacted. The manufacturer was not contacted. The approximate failure mileage was 54,000.

Coolant intrude. Coolant flow to engine make light on for engine high temperature at start. Can not drive after light on.

my Ford issue had the short block coolant intrusion which has resulted in a blown engine with only 55,000 miles on my car. It is my understanding in 2022, Ford issued a one time no cost repair as they knew they sold cars with a junk engine yet I was never sent the customer satisfaction program letter 21N12 informing me of the potential issue and the one time no cost engine replacement. When I called the Ford customer satisfaction program today, using my VIN they confirmed this as well and mentioned there hasn't been a recall on it to date but possibly sometime in the near future and to save all my maintenance receipts. My engine light had been coming on for quite some time, but my car ran fine so each time I took it to my mechanic no code came up so it was cleared and I drove...

Vehicle has overheated twice and left me in stranded in heavy traffic took to dealership to see what’s going on and was told coolant is leaking in cylinder number two and will need long block engine replacement no factory warranty or recall for this issue due to manufacture fault I have a infant granddaughter that has to ride in this car this problem is not anything of my fault at all

The engine failed after only 73,000 miles while I was driving the car. The car lost power suddenly and almost caused me to have an accident. I took the vehicle to the dealer and it requires the entire engine be replaced because of a known engineering defect noted in TSB 19 2346.

Vehicle with 84000 miles has coolant intrusion into cylinders, dealer is saying new engine is needed at $11,000. Vehicle was bought new by owner. This is a known issue from Ford who knew of this issue.

No warning but beginning of the issue with coolant intrusion on the engine: car is currently being looked at for blown head gasket or cracked engine block resulting in $3000+ of repairs. Car only has 75K miles on it. Car is shaking while in park/drive/reverse, making odd bumping noises while going up hill, and not throwing any codes. Upon my research, it states there could be a serious issue with the engine but it is expensive to diagnose and Ford refuses to look at it or diagnose it even though it is a known issue.

I purchased a 2018 Ford Escape from Metropolitan Ford dealership in Eden Prairie, MN on 5/15/2025. The very next day the engine light came on. I called them, made an appointment and brought it in thinking that it was a sensor. They checked it out and tried to charge me $1000 for the fix. I argued with them that I had just bought the car and the should be responsible for fixing it. In end I paid $300 and knew from that point that they would take no responsibility for anything wrong with th car. Fast forward to 12/12/2025 I was driving to work and as soon as I entered the interstate the engine light came on as well as the temperature gage going through the roof. I found that I couldn't accelerate and slowly drove the car off the next exit. I was able to get it to my...

I believe coolant got into the cylinders and caused an engine failure. I had to replace the engine on the vehicle at 58000 miles

When starting car, rough idle and engine light turns on. Diagnostic trouble codes show P0300, P0301, and P0304. This engine has a known manufacturing defect by Ford and they have some policies for replacement depending on age and mileage. There is no way to prevent this cracked block issue by consumers as it is a design flaw. Engine coolant seeps through the crack into the cylinders. I'm afraid to continue driving it as it may stall in traffic causing an accident or overheat if coolant gets low causing a fire.

While driving down the interstate the engine light started to flash and the engine started to stutter. It would rev up and down. This incident occurred while traveling at approximately 70mph with no prior warning. We exited the highway as soon as possible and towed the vehicle to a Ford dealership. They performed a diagnostic and found that a spark plug had broken and that there was coolant intrusion in 3 of the 4 cylinders. There were no prior engine warning lights. The only potential prior warning to this was the coolant was low during a oil change performed 2 weeks before. The dealership informed me that total engine failure was imminent and inevitable. The engine would need to be replaced for $13,000. The vehicle broke down approximately 100 miles from home. It is not available for inspection as bringing it home was cost prohibitive. I've already sold the car...

Engine coolant intrusion, confirmed by local mechanic and with Ford dealer technician over the phone.

Cracked Cylinder Block - Coolant Intrusion

In November 2024 lost acceleration light popped on the dashboard service now. Was found to have a bad turbo full turbo replacement done July 2025 driving on the highway slow down behind a semi went to pass them. Gas pedal went all the way to the floor would not accelerate Pulled over checked all fluids. Everything was fine. Got back on the road then check engine and oil light came on immediately pulled over checked oil. There was no oil in the car, even though it had been full when I checked fluids put oil in let the car run and cycle through for a while. Oil light went off Got back on the road in half a mile oil light came back on and then stopped driving the vehicle has been sitting at a dealership for five months dealership changed turbo did not do oil change as mandatory part...

My 1.5L engine in my 2018 ford escape has a coolant leak which is a known problem in these cars according to the internet. There was a CSP from ford (19B37) which I did January 3, 2020 which is supposed to stop this from happening My ca does not qualify for CSP 21N12 according to ford because it is for 84k miles or 7 years. My car has 95k miles but is still in the 7 years but they refuse to help. They have told me to pay for repairs and then submit receipts “IF” there is a recall issued I have just been getting the run around from everyone at ford from customer relations to service departments

coolant intrusion Issues leading to engine failure messages and head gaskets issues

TEMPERATURE GAUGE WARNING LIGHT CAME ON AND TEMPERATURE SHOT UP TO RED LINE. WAITED ON SIDE OF ROAD FOR 20 MINUTES TO COOL DOWN THEN RETSARTED AND DROVE 10 MINUTES BACK TO MY WORK AND TEMP GAUGE REMAINED IN NORMAL TEMP AREA. EXPLAINED TO MY MECHANIC AT WORK..HE CHECKED IT OUT AND SAID IT WAS COOLANT INTRUSION PROBLEM AND ENGINE WAS PROBABLY SHOT.

Engine small block cracked causing 2nd cylinder to fill with coolant causing error code related to misfire. Have been told this is a known issue with no recall notice. Ford dealership has confirmed this issue.

My car/engine is in need of a head gasket replacement at least if not a new engine based on significant coolant intrusion and malfunctioning. Over a short period of time, the coolant tank was almost nearly drained and the engine started misfiring which lead to shop visits and investigation. Coolant was found in the cylinders and currently it is needing multiple thousands of dollars in repairs due to what mechanics are telling me is a know issue though not a recall for my case (up to 84K miles its covered under an extended warranty but not at 100k like mine). My safety was not necessarily put at risk, though this seems to be a highly common issue I believe Ford needs to reimburse customers for based on the known issue and significant numbers of vehicles this has affected. There were no warnings prior to this event that I would be...

To whom this concerns: My name is [XXX] and I’m writing this on the behalf of my wife [XXX] , but her last name was [XXX] years ago. My wife purchases a 2018 Ford Escape. Car was working completely fine and there were no problems. As time went on, we had to take our vehicle to Jordan Ford where the car was purchased. The issue with the car was something called Engine intrusion. We took it to Jordan Ford, and they told is this needed to be fixed. The cost was around 5,000 which was a lot for this. Then we found out that this vehicle had a recall on it for the exact same issue that we were having. Looking at the recall, it said that we had to give them this by a certain date. We were too late on that date so the recall could not be...

Coolant loss with no visible leaks; idling roughly and misfiring Mechanic stated that coolant loss and appears to have intruded into the cylinders

My vehicle stooped running. I scheduled maintenance at Metro Ford. According to the diagnostic test completed at Metro Ford, there were powertrain issues. This diagnosis also appears on my Ford Motor Pass app. According to the service department at Metro Ford, coolant was leaking into the engine and that a new water pump and battery needs to be installed to get the car back running. We complied with the cost ($2,400 this included new water pump and battery) and 30 days later the car stopped running again. The car was towed back to Metro Ford and we were told that the engine is dead and that a new diagnostic check will need to be done with an additional $410 on top of the $2,400 which was paid to get the water pump and other items fixed previously. We were never informed that the engine will need to be replaced after...

Check engine light came on, took it promptly for service and was told coolant leaked into the cylinders and I need a new motor. Ford told me this is s a common issue and to report it to Ford for assistance in repair as it is a known issue.

The vehicle experienced a catastrophic engine failure due to a known defect in Ford’s 1.5-liter EcoBoost engine (coolant intrusion into the cylinders). The component that failed was the engine itself, specifically internal cylinder damage caused by coolant leaking into combustion chambers. The vehicle is in my possession and available for inspection upon request. The failure created a serious safety risk. Prior to the engine failure, the vehicle began stalling at low speeds, idling roughly, losing power, and the check-engine light came on. The stalling occurred while driving, which could have caused an accident in traffic. The engine ultimately became inoperable. The issue was evaluated and confirmed by an independent repair facility: Dobbs Tire & Auto in Eureka, MO, on September 18, 2025. They diagnosed complete engine failure and stated it was consistent with the widely reported coolant-intrusion defect affecting this engine type. Replacement cost was quoted at approximately $11,000. The...

This car has a known issue with the engine. Coolant leaking into cylinder 3 Caused by faulty design. This leak causes a cylinder misfire. And the coolant leak can cause the whole motor to seize. Reputable mechanics state the engine needs to be replaced after only 50,000 miles.

The contact's wife owns a 2018 Ford Escape. The contact stated that while his wife was driving 40-45 MPH, the vehicle shuddered and stalled. The check engine warning light was illuminated. The vehicle was towed to an independent mechanic who determined that the head gasket was blown. Upon further research, the contact related the failure to an undisclosed recall; however, the model year was not included. The local dealer was contacted and confirmed that the VIN was not under recall. The vehicle was not repaired. The manufacturer was contacted but no assistance was provided. The approximate failure mileage was 124,000.

Any ford car with the Eco boost 2.0 motor could have coolant intrusion causing the car to miss fire, burn coolant and overheat. this is not only bad for the environment but also dangerous for the roads. How many of these cars are on the roads and could cause traffic and or accidents? This problem is noticed by ford but not recalled TSB 22-2229

My 2018 Ford Escape SE is on its SECOND engine and has started with coolant intrusion AGAIN. The same issue has doomed the same car twice.

My 2018 Ford Escape equipped with a 1.5L ecoboost engine purchased new with 33,000 miles, experienced overheating, white smoke from the exhaust and extreme vibration which became undriveable. It was towed to a Ford dealer who determined it had coolant in the sparkplug holes and the engine would need to be replaced. There was no previous problem or check engine light until the event. There was a Customer Satisfaction Program 19B37 dated May, 2020 identifying the possibility of this problem which required the Ford dealer to perform a reprogramming to prevent the coolant from leaking into the engine. This was performed by a Ford dealer in October 6, 2020. Ford has determined that my vehicle is out of warranty.

Known coolant intrusion issue causes coolant to ruin the engine from the inside. Ford is unfairly denying their own program to remedy the situation for desperate customers.